IKON Waste Disposer Manual 3212 3213 Sept2015
Contents
1. The disposer installation is complete Read all operation and safety instructions in section 11 before operating the disposer Lastly place stopper in sink to close position Fill sink with water remove the stopper turn the disposer on and check for leaks Please allow 24 hours before using product to let the plumbers putty seal 06 Food Waste Disposer Users Manual 10 Important Safety Instructions Warning When using electrical appliances basic precautions are always to be followed including 07 1 If the air switch or wall switch fails to shut off or turn on disposer unplug the power cord and contact your qualified trade person 2 This product is designed to dispose of normal household food waste inserting materials other than food waste into the disposer could cause personal injury and or property damage To reduce the risk of injury do not use the sink containing the disposer for purposes other than food preparation such as baby bathing or wash hair This appliance is not intended for use by persons including children with reduced physical sensory or mental capabilities or lack of experience and knowledge unless they have been given supervision or instruction concerning use of appliance by a person responsible for their safety Children should be supervised to ensure that they do not play with disposer To reduce the risk of injury close supervision is required when an appliance is used nea2. too short you can purchase an Picture9 1 extension from hardware store 4 Place nut then ferrule on discharge tube and tighten on drain trap If you have a double sink use separate drain traps for both sides of sink Ensure lower mounting ring is still securely locked over ridges on mounting flange 04 9 Warning Electrical shock Food Waste Disposer Users Manual Connect Disposer to Electrical Supply 10 1 To avoid electrical shock disconnect power before installation or servicing disposer If you are not thoroughly familiar with electrical power contact a qualified electrician to connect disposer to electrical circuit Y Picture10 1 If three prong earth plug is used plug must be inserted into three hole earth receptacle All wiring must comply with local electrical codes Do not attach earth wire to gas supply pipe If the supply cord is damaged it must be replaced by the manufacturer its service agent or similar qualified persons in order to avoid hazard Note You must have access to an earth wall socket Any additional socket should befitted by a qualified electrician and properly earthed The disposer is fitted with a molded plug and cable On off Control 05 Connect to a 10 amp earth wall socket using a 10 amp cable OAir Switch Air switch is included with each disposer An air switch activates turns off the unit by sending a pulse of air to the control box OA
3. IKO OR BETTER LIVING IKON COMMERCIAL LTD 18 Charlies Way Frankton Hamilton New Zealand 3204 Phone 0800 83 83 84 Fax 0800 83 83 85 Website www ikoncommercial co nz Waste Disposer User Manual 3212 3213 Food Waste Disposer Users Manual 1 Parts installation drawings B Series installation parts Picture 1 1 Code 3212 3213 TS Sy ix 0 Y f 1 A 12 Tig amp Ly 4 13 Picture 1 1 Installation parts Disposer Discharging parts 1 plug 9 Dishwasher water inlet 10 Rubber seal 2 Sink flange 11 Pipe flange 3 rubber gasket 12 hexagon socket screw 4 sink gasket 5 Fiber lining 13 Discharging bending pipe 6 Flange nut tightening screw 7 Clamp ring 8 Splash guard 01 Food Waste Disposer Users Manual 2 Check the installation size 1 Disposer s height 1 2 The bottom of sink to the middle of discharge outlet 3 Disposer s width 4 4 Disposer s vertical center line to the vertical center line of U pipe 5 3 Disconnect Sink Drain 1 Loosen nut at the top of trap with pipe wrench 2 Loosen nut at the top of extension pipe Remove extension pipe 3 Loosen nut at base of sink flange 4 Push sink flange up through sink hole and remove it 5 Clean sink flange area of any putty or other debris 4 Disassemble New Disposer Mounting Assembly 2 1 Unlock the lock catch of the snap ring take off the snap ring 2 2 Ta
4. er hole on Don t the bottom of the disposer See picture 11 1 Work the wrenchette Don t turn off water or disposer until grinding is complete and only back and forth until it turns one full revolution Remove the sound of motor and water running is heard wrenchette Don t grind large amount of egg shells fibrous materials like corn 3 Reach into the disposer with tongs and remove objects Allow the husks artichokes etc to avoid possible pipe blockage disposer motor to cool for 3 5 minutes and lightly push red reset Don t grind non food waste of any kind button on the disposer bottom See picture 11 2 Don t use this appliance to dispose of hard materials such as glass and metal Don t ever pour fats oils or grease down the sink it will block your drains and sewage system Don t fill disposer with lots of vegetable peels all at once Instead turn the water and disposer on first and then feed the peels in gradually Over time grease food particles may accumulate in the grind chamber A 114 and baffle causing an unpleasant odor To clean the disposer Cleaning Disposer Service 1 Turn off disposer and disconnect power supply If service is required contact authorized service center or your dealer 2 Reach through sink opening and clean underside of the splash baffle Guarantees are void if you attempt to repair or if the disposer is used for and inside upper lip of grind chamber with scourin
5. ers and chemicals automotive fluids plastic wrap 13 All IKON series of disposers are designed to national standard for intermittent usage and shall not be used continuously per time Operation Instructions 1 Remove strainer basket and plug from sink opening and run cold water 2 Turn on wall switch or press air switch See picture to start disposer 3 Slowly insert food waste into disposer and position strainer basket in right place to minimize noise and possible ejection of material while grinding See picture 4 After grinding is complete turn disposer off and run water for at least 15 seconds to flush drain line Grind food waste with minimum cold water flow of 6 liters per minute 1 5G P M Grind hard material such as small bones and fruit pits to clean inside of grind chamber Grind citrus melon rinds vegetables and coffee grounds After grinding run water for at least 15 seconds to flush drain line 08 Food Waste Disposer Users Manual Food Waste Disposer Users Manual Switch off or unplug the appliance before attempting to free a jammed Releasing Disposer Jam rotor with implement If the motor stops while the disposer is operating the disposer may be Maintain the area underneath the disposer of any objects to be sure jammed To release jam you have access to the disposer reset button 1 Turn disposer power and water off 2 Insert one end of the self service wrenchette into the cent
6. g pad commercial usage 3 Place stopper in sink opening and fill sink halfway with warm water 4 Mix 60ml baking soda with water Turn disposer on and remove stopper from sink at the same time to wash away loose particles 09 10 11
7. ir Switch Installation 1 Drill a 33mm wide hole into the kitchen work top or the corner of the sink unit at the most convenient point for use Some sink units may already have a suitable hole in them which can be exposed by removing the cap 2 Remove the nut from the push button below while keeping the rubber gasket in place Push one end of the PVC tubing onto the spout of the push button bellows feed the other end of the tube through the hole in the work top and through the nut underneath the work top Picture 10 3 Food Waste Disposer Users Manual 3 Fit the Push button bellows in the hole and then screw up the nut underneath the work top until it is hand tight Do not use a wrench to tighten the nut Picture10 3 4 Take the other end of the air tube and firmly push it over the spout of the air switch which is located on the underside of the waste disposer 10 3 10 4 ODisable Air Switch The air switch can be disabled if wall switch is preferred The disposer is shipped with the switch in the off position 1 Push one end of the PVC tubing provided onto the spout of the push button bellows 2 Take the other end of the air tube and push it over the spout of air switch which is located at the bottom of the disposer unit 3 Depress the air switch one time until you hear the switch click Remove and discard the push button and PVC tubing The disposer may now be activated by a wall switch
8. ke off the sink flange i gt S 5 Attach Upper Mounting Assembly to Sink Picture 5 1 1 1 Use plumbers putty under sink flange Ensure sink hold area is clear of debris and place sink flange into sink hole 1 2 Working from under the sink slip rubber gasket fiber lining over the sink flange and then mount the feeding mouth locking screw and lock up 1 3 Tighten three mounting screws up to sink until mounting assembly is seated tightly and evenly against sink 02 Food Waste Disposer Users Manual 6 Dishwasher Attachment And Overflow Connection Wastewater from a dishwasher can be plumbed into the disposer through the inlet access on the upper part of the disposer There is a plug on the inside of the inlet tube Note If the dishwasher connection is made without removing the plug the dishwasher may overflow Remove Knockout Plug Picture 7 1 1 Lay disposer on its side and insert screwdriver 1 into the dishwasher inlet so tip rests on outer edge of knockout plug 2 Tap end of screwdriver handle with hammer until molded plug breaks loose 3 Remove loose knockout plug from inside disposer Picture 7 1 If you have a sink overflow it should be connected to the overflow inlet on the tailpipe To connect the overflow remove the plug in the tailpipe by unscrewing the overflow connector cap 7 Connect Disposer to Mounting Assembly Note To avoid personal injury do not position your head or body under dis
9. poser the unit could fall during installation Clear any objects from inside the disposer grind chamber before mounting the disposer to the sink 1 This product must be installed so that the motor reset button located on the bottom of the disposer is readily accessible Keep this space clear of all objects 03 Food Waste Disposer Users Manual 2 Lift the disposer inset the top end into the mounting assembly and turn So the mounting assembly bottom end end can slide into the splash guard slot 3 Mount the Locking ring and lock it up 4 Run water into sink then check for leaks Insert sound baffle into sink flange 8 Attach Discharge Tube to Waste Drain Pipe Do not use plumbers putty on any other disposer connection other than on sink flange Do not use thread sealants These may harm disposer and cause property damage Regularly inspect disposer and plumbing fittings for water leaks as water leaks can cause property damage Manufacturer can not be held responsible for property damage as a result of water leaks Discharge pipe installation Picture 9 1 1 Place metal flange over discharge tube Insert rubber gasket with gasket lip facing the metal flange into discharge tube 2 Secure metal flange and discharge tube to disposer with bolts 3 Rotate disposer so that discharge tube is aligned with drain trap To prevent leaks do not pull or bend discharge tube to drain trap If discharge tube is
10. r children When attempting to loosen a jam in the food waste disposer switch off or unplug the appliance before attempting to free a jammed rotor USE A SELF SERVICE WRENCHETTE AS DESCRIBED IN THE RELEASING DISPOSER JAM SECTION Use long handle tongs or pliers to remove objects from disposer TO reduce the risk of injury by materials that are expellable by a waste disposer do not operate disposer without the sound baffle in place See picture Place stopper in sink opening Do not put the following into a disposer clam or oyster shells large bones metal such as bottle caps steel shot tin cans or utensils hot grease or other hot liquids Replace sound baffle mounting gasket splash guard when worn to help prevent entry or ejection of material and water Food Waste Disposer Users Manual 8 When not using disposer leave stopper in place to reduce risk of objects falling into disposer Make sure disposer power switch is turned off 9 Before pressing reset button attempting to clear jam or removing objects falling into disposer Make sure disposer power switch is turned off 10 Do not insert hands or fingers into disposer 11 Fire Hazard Do not store flammable items such as rags paper or aerosol cans near disposer Do not store or use gasoline or other flammable vapors and liquids in vicinity of disposer 12 Do not dispose of the following in the disposer paints solvents household clean
Download Pdf Manuals
Related Search