Home

warning - Fleetwood RV.

1. Test the GFCI at least once a month To test the GFCI 1 Connect the main power cord to 120 volt AC 2 Push the TEST button The RESET button should pop out indicating that the pro tected circuit has been disconnected 3 If the RESET button does not pop out when the test button is pushed a loss of ground fault protection is indicated Do not use any electrical outlets Have the motor home electrical system checked at an authorized Fleetwood Service Center or by a qualified electrician Do not use the system until the problem has been corrected 4 To restore power push the RESET button A WARNING Do not install 12 volt fuses or 120 volt breakers with amperage ratings greater than that specified on the device or label Doing so constitutes a fire hazard Generator If Equipped Your motor home is equipped with a diesel powered generator which will provide complete electrical self containment when regular public utility AC power is unavailable Controls are on the instrument panel rear bedroom nightstand and on the generator With the generator operating power is available at all of the 120 volt power outlets in the motor home just as if the power cord were connected to an external source The generator is also con nected to the power converter thus supplying 12 volt power as well The generator circuit breakers are located on the generator A WARNING Do not under any circumstances op
2. all 12 volt interior lighting fixtures amp out lets e fresh water pump e satellite e 12 volt accessories House batteries provide 12 volt DC power These batteries are not the chassis 12 volt batteries Power is also provided by a DC con verter that operates when the motor home elec trical cord is plugged into 120 volt AC power source or by the generator if equipped The house batteries are charged by the motor home engine alternator or by the converter when it is operating J NOTE Power for living area radios and tape decks is avail able from either the chassis or house batteries A switch on the instrument panel allows you to select the power source If you use the radio tape decks or other 12 volt DC equipment for long periods of time when the motor home engine is not running either battery may be discharged 08 1 Electrical Systems Battery Disconnect If Equipped Some accessories or equipment such as clocks radios or the refrigerator may draw small amounts of current even when turned OFF A manual operated rotary switch disconnect sys tem allows you to disconnect either the chassis batteries or the coach batteries or both Disconnecting the batteries will help reduce the likelihood of battery discharge over long storage periods For your convenience relay operated disconnect circuits may be equipped with your motor home These circuits isolate selected elec trical systems fr
3. A WARNING Turn off Propane main valve before filling Propane tank or entering a Propane bulk plant or motor fuel service station Turn off all pilot lights and appliances individually before refueling of motor fuel tanks and or Propane containers When not individually turned off automatic ignition appliances may continue to spark when Propane is turned off at the container PROPANE SYSTEM CHECK Do a visual check of all exposed piping and fit tings after you have arrived at a destination and before you use the Propane system Keep the tank valve closed and turn off all appliances if the unit is not being used Always have the system checked by a profes sional any time you detect a garlic rotten egg like odor or hear a sustained hiss when you turn the Propane on A WARNING Never check for leaks with an open flame Do not check copper and brass plumbing lines and fittings for leaks using ammoniated or chlorinated house hold type detergents These can cause cracks to form on the line and brass fittings If the leak cannot be located take the unit to a Propane service representative PROPANE LEAK DETECTOR ALARM A permanently installed Propane leak detector alarm is located near the floor The unit contains an alarm that will sound alerting you to the presence of low levels of potentially dangerous Propane that may have accumulated The detector alarm unit is powered by the 12 volt DC system
4. If the sensor probes mounted in the tanks get coated with grease the monitor panel may indicate falsely or not at all Avoid pouring grease oils or similar sub stances down drains or the toilet If this is unavoid able the holding tank s should be washed out with a soapy water solution See your dealer for additional information To check tank levels Press PROPANE FRESH WATER GRAY or BLACK TANK switches 06 7 Living With Your Motor Home The E or empty indicator light will always be lit when the rocker or touch switches are depressed If the tank is full all lights will be on Lights are sequential and indicate levels in approximately 1 3 or 1 4 tank increments depending on monitor or panel design It the tank selected is approximately 1 2 full for example lights E 1 4 and 1 2 will be on Erroneous tank level indications can be caused by a Water with low mineral content The level is measured by a very low level electrical signal traveling through the liquid Some water may not conduct the signal properly This condition may be infrequent but can exist Check the panel reading when the fresh water tank is filled b Material trapped on the holding tank probes may give a full reading when the tank is actually empty To check the battery charge 1 Shut off all charging sources engine gen erator and disconnect the 120 volt power cord to turn off the converter 2 Press BATTERY roc
5. LIGHTING PROPANE APPLIANCES Detailed operating information for the Propane appliances can be found in your Owner s Information Package Please read and follow these instructions Air trapped in the Propane lines may delay the initial lighting of any appliance It could take several seconds or minutes for the Propane to reach the appliance To purge some of the air from the Propane system first light a burner on the range The other appliances will then light more quickly The first time the furnace or oven is operated paints and oils used in its manufacture may gen erate some smoke and fumes If this occurs open doors and windows to air out the motor home These materials should burn off after the first 15 to 20 minutes of appliance operation Always follow the appliance manufacturer s lighting operating and maintenance instructions A WARNING The Propane detector alarm is powered by a 12 volt source Any interruption in power will render this alarm inoperative Always ensure power is applied especially when appliances are in use 09 4 The appliances installed in your motor home are tested and listed and comply with standards established by these organizations All appliances are covered by Fleetwood s Ownercare Warranty program Each appliance is also warranted by its manufacturer Y NOTE The individual appliance manuals included in your Owner s Information Package contain detailed oper
6. These ratings are shown on the label which includes the Federal Certification Tag 05 1 On The Road A WARNING The heaviest loaded motor home with all passengers goods water driver and towed vehicle must not exceed any of the following 1 The gross vehicle weight rating GVWR 2 The gross combination weight rating GCWR 3 The front rear gross axle weight ratings GAWRs 4 The individual tire and wheel ratings Towing a Vehicle or Trailer Towed Load or Towed Unit J NOTE Some states and provinces require brakes and safety chains when towing vehicles Consult the proper authorities in the states or provinces through which you will be traveling When you use your motor home to tow remem ber that you must stop the towed load with your motor home s brakes This is critical on hills and in the mountains where you may encounter sharp curves and possibly irregular road surfaces Check your motor home Chassis Operator s Owner s Guide Manual for the maximum weight your motor home can pull and stop on both level and steep roads NOTE In most cases the GCWR of the chassis and the fin ished motor home are the same In some cases due to the equipped hitch receiver the GCWR may be reduced Please refer to the Federal Certification Tag posted in your motor home for the rated GCWR If the Chassis Operator s Owner s Guide Manual equipped wi
7. A WARNING Never expose the battery to open flame or electric spark Chemical action in the battery generates hydrogen gas which is flammable and explosive Do not allow battery electrolyte acid to contact skin eyes fabrics or painted surfaces Solar Panel If Equipped Your new motor home may be equipped with an optional solar charger The solar charging panel installed on the roof of your motor home is designed to trickle charge your battery system It is not intended to be a fast charger It also can not supply large amounts of current to operate 12 volt DC electrical equipment When the sky is clear and under bright sun the solar panel will help keep your batteries topped up Do not try to operate 12 volt DC appliances with the output of the solar panel Selecting a Replacement Battery When the battery requires replacement always choose a battery with the same physical and elec trical characteristics as the original equipment Your dealer or an authorized Fleetwood Service Center can advise you on proper battery selection Auxiliary Start System If Equipped You can use the Auxiliary Start System to start the chassis engine or the generator with the house batteries if the chassis batteries are dis charged To use the Auxiliary Start System to start the chassis engine 1 Be sure the motor home is stopped Shift the transmission to N and apply the parking brake 2 Press and hold the Aux
8. Inspect the sealants around doors and win dows every three months See Sealant Renewal section Lubricate locksets in doors and exterior storage compartments at least annually with powdered graphite If the motor home is located at a beach or is exposed to salt air more frequent lubrica tion may be required FIBERGLASS ROOF SYSTEM Cleaning Your motor home is equipped with a fiberglass roof For normal cleaning standard household detergents or cleansers may be used Use a nonabrasive common household detergent and plenty of water Be sure to keep the sidewalls wet to reduce streaking Care The fiberglass roof itself does not require annual coatings or additional sealants Periodic washing with soap and water is all that is required Use caution when loading sharp articles on the roof If you add accessories or new equipment on the roof be sure the installer is qualified to work on the fiberglass roof material This is required under the terms of the warranty Repair kits are available through your dealer The roof requires special adhesives and material A WARNING The fiberglass roof material is slippery when it is wet Sealant Renewal This section outlines the procedures you must follow to maintain the weatherproof integrity of your motor home Leak damage caused by fail ure to inspect and maintain the roof vents TV satellite antenna and molding seals may affect your warranty coverage The a
9. Mallard e Nitrous Orbit e Pace Arrow Pegasus Pioneer Providence Prowler Pulse e Quantum Redline Regal Revolution LE Southwind e Terra Terry Tioga e Wilderness This page intentionally blank TABLE OF CONTENTS INTRODUCTION 6 is ccinsd sade evesanws 01 1 Inspect and Maintain 2 2c0 20000 04 01 2 Planning and Preparation oo 36 caes ak ec deed 01 2 Owner s Information Package 01 2 Chassis and Vehicle Identification 01 3 Suspension Alignment and Tire Balance 01 3 After Market Steering Aid Devices 01 4 Warnings Terms and Concepts for Safe Operation of Your Motor Home 01 4 Event Data Recording Device CT BQUIpped 2ceceteseeocesevexeee ved 01 6 Drivers License Requirements 01 6 WARRANTY siieiceiiaisccwakedcuwenes wae 02 1 Coverage Provided 220 29415402e80ceeud 02 1 What is Not Covered by This Warranty 02 1 LimitatioNS ecese gesi eerdigercens teesis 02 2 Your Rights Under State Law 02 2 Dealer s Obligations nnnnannn na 02 2 Owner s Obligations 4 22 s44 lt ceeesee4 02 2 Manufacturer s Obligations 02 2 Warranty Service sa da eau gawnws ake ea dadd 02 3 Reporting Safety Defects 4 64 6s00 444 02 4 IMPORTANT NOTICES 03 1 AMERICAN COACH INFORMATION 04 1 Eagle Tradition and Heritage Information 04 1 Electrical Circuit Breaker Panels Circuit Fuse Panels and Battery Di
10. e Load and secure heavier items lower in the storage areas than lighter items If you fail to properly load your belongings and supplies you will defeat the load distribution design of the motor home possibly leading to handling problems and a vehicle crash Vehicle Response When you the driver accelerate brake or steer the motor home it responds to these inputs If you are faced with an emergency while driving the way you respond to the emergency and the way the motor home responds becomes more critical If you load alter or maintain your motor home improperly it will not respond as it did when you first received it in an unloaded condition Improper loading alteration maintenance and improper driver responses to emergency conditions can lead to handling problems and vehicle crashes 01 4 Introduction Vehicle Towing V NOTE Your motor home can be equipped with a hitch designed to allow you to tow vehicles or other loads behind your motor home The maximum amount of weight your motor home can pull or stop is determined by the manufacturer of the chassis on which your motor home is built Check the Chassis Operator s Owner s Guide Manual provided by the motor home chas sis manufacturer for the limits on the weight you can tow In most cases the GCWR of the chassis and the fin ished motor home are the same In some cases due to the equipped hitch receiver the GCWR may be reduced Ple
11. pyramiding of waste material 07 5 Plumbing Systems and Holding Tanks 4 To drain the gray water tank repeat the steps above using the small knife valve This tank is drained last to aid in flushing the outlets and hose The gray water knife valve may be left open in a semi permanent hookup 5 See the tank flush system instructions in the next section if your recreational vehicle is so equipped 6 Remove the sewer hose and cap the outlet 7 Rinse out the sewer hose with fresh water and remove the sewer hose from the dump station 8 Replace sewer or dump station covers A CAUTION The sewer drain valve must be open when using the black tank flush inlet Black Tank Flush System If Equipped A black water holding tank system that is equipped with a flush system has rinsing spray heads inside the tank that will aid in the removal of sewage residue from the interior of the hold ing tank To operate the tank flushing system follow the procedures for Draining The Holding Tanks in this chapter After dumping the gray water tank proceed as follows 1 With the dump valves open attach a garden hose to the black tank flush inlet connection 2 Turn on water supply to garden hose and allow the water to run for approximately three minutes to flush tank 3 Turn off water supply to garden hose 4 Remove hose from black tank flush inlet connection and store hose 5 After rinse water has tho
12. Have you ever been a member of ACC Yes NO If yes what was your member Full Name for database Co Pilot s full name for the data base First Name First Name For you name badge For your name badge Mailing Address City State Zip Home Phone Cell Phone 2 Cell Phone E Mail Coach Year Length of Coach Slides Heritage Eagle Dream Tradition Limited ACC Member FMCA Member F To be assigned FMCA Membership is required before membership can be processed 1 Year Dues 12 00 Make Check payable to Cost of 2 Name Badges 15 00 American Coach Chapter of FMCA 27 00 Mail to the above address Total Due This page intentionally blank Over one million families also calla Fleetwood home SMALL MEDIUM AND LARGE HOMES FROM THE DESERT TO THE SEA FLEETWOOD IS AMERICA S HOME OF CHOICE In addition to building America s most popular recreational vehicles Fleetwood designs and builds factory crafted homes with floorplans and design options to suit your unique tastes and lifestyle From 550 2 500 square feet choosing to buy a Fleetwood home is easy Choosing which one is a little more challenging A Fleetwood home is rivaled by no other factory crafted home But what about homes built on site Frankly few are built as well as a Fleetwood home Today Fleetwood is one of the nation s largest builders of homes and recreational vehicles having built a
13. If Equipped The roof mounted satellite dish antenna is designed for reception of digital satellite televi sion signals Before traveling remember to lower the antenna and secure it to prevent damage to the antenna motor home roof or objects in the path of the antenna such as overhead wires Do not travel with the antenna raised SATELLITE RADIO If Equipped The satellite radio is located in the dash The radio will require membership enrollment Your Owner s Information Package contains detailed operating instructions concerning this system TELEPHONE JACK if Equipped A telephone jack is conveniently located in the front under the dash on the passenger s side and in various locations in the motor home The park connection point is located near the rear on the roadside sidewall MICROWAVE OVEN If Equipped The microwave oven is powered by 120 volt AC power and will only operate when connected A wall receptacle for the microwave is located in the overhead cabinet adjacent to the microwave cabinet WASHER DRYER READY OPTION If your RV is equipped with an electric dryer ready option and if an electric dryer is installed in the future by either you your dealer or another appliance installer the installation must comply with the following instructions 1 The clothes dryer moisture lint exhaust vent duct must not be connected to any other duct vent or chimney 2 The exhaust duct must be of sufficien
14. We FLEETWOOD Driven to Explore THE OFFIC F R IAL LUXURY COACH OF THE AMERICAN ROAD yoeog ue2n uy 600Z 2009 Owner s Manual 10 2008 American Coach Manual Printed in USA We FLEETWOOD Driven to Explore HE RITA G E 2008 by Fleetwood Enterprises Inc All rights reserved No part of this publication may be reproduced or trans mitted in any form or by any means electronic or mechanical including photocopying recording or by any infor mation storage or retrieval system without written permission from Fleetwood Enterprises Inc IMPORTANT PLEASE READ Product information photography and illustrations included in this manual were as accurate as possible at the time of publication Materials design and specifications are subject to change without notice Fleetwood has designed its recreational vehicles for a variety of customer uses Each vehicle features optimal seating sleeping storage and fluid capacities The user is responsible for selecting the proper combination of loads i e occupants equipment fluids cargo etc to ensure that the vehicle s weight capacities are not exceeded Manufacturing subsidiaries of Fleetwood Enterprises Inc build the following motor homes and travel trailers American Allegiance American Eagle e American Heritage e American Tradition e Backpack Bounder Bounder Diesel e Compass Discovery Excursion Expedition Fiesta e Formula Gearbox Icon Jamboree
15. Alterations to Your Motor Home Many motor home owners like to add a personal touch to their motor home But there is a difference between changing how your motor home looks versus how it handles or responds to driver inputs If you expect to make any type of alteration to your motor home consult a professional who understands the correct way to do the alteration and how the alteration will change or affect the stability handling vehicle response and overall performance and safety of your motor home An improper alteration that affects vehicle handling or response can cause a vehicle crash and any improper alteration to the electrical or Propane systems can cause a fire and can endanger your motor home and its occupants Fleetwood your chassis and other manufacturers stand behind the motor home as delivered NOT as altered by someone else Due to a recent change implemented by the National Highway Traffic and Safety Administration NHTSA additional requirements for added features must be followed If an added feature to the motor home changes the basic weight of the unit by 100 pounds or more the units must be reweighed and a new Federal Certification Tag printed and installed Contact your dealer Fleetwood or NHTSA for additional information 01 5 Introduction Warning Devices Your motor home is equipped with warning devices Check them before a trip for proper operation A disabled warning device cannot warn you
16. Right Turn Signal Tachometer Front amp Rear Air Pressure Gauge Heating Air Conditioning Fan Speed Control Heating Air Conditioning Temperature Control Vent Control Defrost Fan Speed Control Defrost Temperature Control Driver Power Sun Visor Switch Blank Docking Lights Switch Hood Light Switch Chassis and Generator Engine Areas 21 22 23 24 25 26 27 28 29 30 31 32 33 34 Dome Light Switch Radio Switch Blank Generator Start Switch Passenger Power Sun Visor Switch Driver Shade Switch Passenger Shade Switch Door Shade Switch Driver Front Shade Switch Blank Generator Hour Meter ATI Temperature Compass Gauge Back up Monitor Radio Satellite Radio Optional Tire Pressure Navigation System Chassis Engine Ignition Switch Parking Brake Control Knob 04 5 Heritage Information Shifter Selector Side Pod 35 Spot Light Control 51 36 Driver Exit Switch VENT 37 Driver Set Switch 38 Driver 2 Switch 39 Driver 1 Switch 40 Leveling jacks Control Panel w Air Dump 41 Air Horn Switch 42 Automatic Traction Control Switch 43 Tag Axle Dump Switch 44 Engine Brake Selector Switch H LOW 45 Engine Brake Switch ON OFF 46 Transmission Shifter 47 Blank 48 Blank 49 Power Window Mirror Controls 50 Coin Holder 51 Cup Holder Shifter Selector Side Pod 04 6 Eagle Tradition and Heritage Information LIVING WITH YOUR MOTOR H
17. See Note NOTE Refer to the tire load charts published by the tire manufacturer to determine the proper inflation pressures recommended for single and dual axles equipped Always inflate each axle set to the tire with the higher of the side to side loads ri o Dangers of Overloading Do not overload your RV In addition to possible problems with tires wheels and springs there can be problems of brake failure drivetrain fail ure wheel bearing failure etc Moreover an overloaded RV uses more fuel is harder to han dle and can lead to driver fatigue If any com ponent should fail it could result in vehicle damage and or loss of vehicle control In addi tion to the above dangers there are some states that require certain motor homes and RVs to uti lize the Highway Patrol s weight scales to check for overloaded axle weights Citations can be issued to violators Since you may load your motor home differ ently for different trips loading and weight pat terns will change Periodically reweigh your motor home and log the weights in this chapter Refer to your log as you prepare to load for future trips 05 9 On The Road Loading Tips Do not load heavy items on the bumpers e Make a loading diagram of your properly loaded motor home and then weigh the properly loaded motor home The loading diagram your loading log and the loaded motor home weight will help you locate where specific items
18. and if it finds that a safety defect exists in a group of vehicles it may order a recall and remedy campaign To contact NHTSA you may either call the toll free Vehicle Safety Hotline at 1 888 327 4236 TTY 1 800 424 9153 or go to http www safercar gov or write to Administrator National Highway Traffic Safety Administration 1200 New Jersey Avenue SE Washington DC 20590 You can also obtain other information about motor vehicle safety from the Hotline 02 4 Please pay close attention to these statements while you read this Owner s Manual In this manual statements preceded by the fol lowing words are of special significance A DANGER indicates an imminently hazardous situation that if not avoided will result in death or seri ous injury A WARNING indicates a potentially hazardous situation which if not avoided could result in death or serious injury A CAUTION indicates a potentially hazardous situation which if not avoided may result in minor or moderate injury CAUTION indicates a potentially hazardous situation which if not avoided may result in damage to the component or vehicle NOTE indicates points of particular interest for more efficient and convenient operation IMPORTANT NOTICES 03 1 This page intentionally blank AMERICAN COACH INFORMATION Eagle Tradition and Heritage Information ELECTRICAL C
19. ating and maintenance instructions Always refer to the respective manual for the appliance in question A WARNING The water heater and furnace combustion air exhaust ports may be hot when the water heater and furnace are operating Do not touch these outlets or allow any material to come near the exhaust ports while operat ing the water heater and or furnace WATER HEATER The water heater operates on Propane or if so equipped with 120 volt AC power and is much like the one in your home It contains an auto matic shut off valve which stops the Propane supply if the water temperature rises too high The water heater is reached through an access panel on the outside of the motor home Turn on the hot water faucet at the galley sink If water flows continuously the heater is full A CAUTION Do not light water heater until it is filled with water Water Heater Bypass Valve This valve is provided to cut off the flow of water to the water heater The water heater bypass valve greatly reduces the quantity of antifreeze required to winterize the water system The valve is usu ally located near the water heater Consult with your dealer for the location for your particular unit APPLIANCES To bypass the water heater turn the lever valve vertical To supply water heater with water turn lever horizontal N fo R M A L F L o w BYPASS Water Heater Bypass
20. home may be any of several finishes and tex tures Never use harsh detergents or abrasive cleaners on walls or ceilings Most surfaces will clean with a soft cloth moistened with mild liq uid detergent in warm water or a clear window cleaner solution Do not scrub the surface or use large amounts of water which could saturate the material Simply spray or apply the solution to the spot and blot with a clean dry rag or paper towel Aggressive scrubbing may damage the texture or pattern Attaching Accessories to Your Motor Home The sidewalls of your motor home are built with a dense fiber and polymer panel or rigid wood panel used as a substrate to the exterior fiber glass or interior finish surface 11 4 Maintenance Structural members are located specifically to mount and attach factory installed components and accessories and may not be located to accommodate after market accessories not specifically designed for use on or in your motor home Exterior Please consult with your dealer before attempting to install or mount accessories on the sidewalls or roof of your motor home Holes drilled in the sidewall may cause damage and may affect portions of your warranty Interior If you want to attach items to the inte rior walls YOU MUST USE RIVETS The rivets can be installed with a hand operated tool such as the Arrow E Z Pull Model RH200 This and similar tools are available in most hardware stores and home improv
21. is closed 06 1 Living With Your Motor Home MANUAL STEPWELL COVER If Equipped Your motor home may be equipped with a man ual stepwell cover The stepwell cover closes off the stepwell area when you are traveling When the cover is extended it provides a floor surface HYDRAULIC OR ELECTRIC STEPWELL COVER If Equipped Your motor home may be equipped with a hydraulic or electric operated hydraulic stepwell cover The stepwell cover closes off the stepwell area when you are traveling When the cover is extended it provides a floor surface Stepwell Cover Operation 1 The stepwell cover control is located on the passenger side of the overhead 2 To extend the cover move the control switch forward 3 To retract the cover move the control switch rearward 4 The stepwell cover can be pushed in manu ally to retract To retract the cover manu ally a The hydraulic entry step cover can be manually retracted A force exceeding 50 Ibs will be required b The entry step cover will drop down a couple of inches during its initial retrac tion c Continue to push on the entry step cover until it is fully retracted d In the event the entry step cover fails to operate seek professional assistance from an authorized Fleetwood Dealer A WARNING Do not operate the hydraulic or electric stepwell cover while anyone is positioned in the stepwell or standing on the stepwell cover A perso
22. remote from the generator exhaust Operate the gen erator only when safe dispersion of exhaust gases can be assured and monitor outside conditions to be sure that exhaust gases continue to be dispersed safely Generator Cooling System The generator is liquid cooled The cooling sys tem includes a radiator cooling fan water pump a coolant reservoir recovery container and is similar to the automotive engine cooling system Check and maintain the coolant level at the coolant recovery container located on the front of the generator A CAUTION Do not check the coolant system at the radiator cap when the generator is hot Check the system at the coolant recovery container only Generator Slide Out If Equipped The generator may be mounted on a slide out cradle A WARNING Keep all obstacles and body parts clear of the gener ator and slide out mechanism when extending or retracting the generator Generator Maintenance Refer to the generator manufacturer s informa tion in the Owner s Information Package for details on generator operation and maintenance Automatic Generator Start Control System If Equipped The Automatic Generator Start Control System AGS performs two distinct functions 1 Start the auxiliary generator automati cally in response to low battery voltage The AGS continuously monitors the coach battery system and will start the generator automatically
23. tue ce ote eee weds Generator Filters cncanxew ene pansret Acrylic Assist Handles If Equipped Windshield Wipers and Washers Maintenance Guideline g 05344k2 inna k dues STORAGE Storage Checklists 25202203 8oedeeeue eax Short Term Storage Less than 30 days 12 1 Long Term Storage Over 30 days Winterizati OM se aaa Si panD ie eA Bi aana Te teres Water System Winterizing Reactivating the Motor Home After Storage ido csc cn gheusivagid dud GLOSSARY 00 4 Welcome to the recreational vehicle life style and the growing family of motor home owners We sincerely thank you for choosing a Fleetwood motor home NOTE This manual describes many features of your RV and includes some instructions for its safe use This man ual including photographs and illustrations is of a gen eral nature only Some equipment and features described or shown in this manual may be optional or because of the continuous program of product change conducted by Fleetwood it is possible that recent prod uct changes may not be included NOTE Throughout this manual the term RV represents a Recreational Vehicle as defined by the NFPA 1192 This includes motor homes fifth wheel trailers travel trailers camping trailers recreational park trailers and truck campers A WARNING Failure to follow proper procedures or install proper equipment can resul
24. 07 4 Plumbing Systems and Holding Tanks Draining the Holding Tanks The holding tanks terminate in a valve arrange ment that permits draining each tank separately The valves are called knife valves A blade closes the opening in the sewer drain pipes The blade is connected to a T handle and cable assembly mounted in the utility compartment Do not pull the holding tank knife valve open when the protective cap is installed on the pipe Pull the T handle to release the contents of the tank s During extended or semi permanent hookups to sewage systems waste materials will build up in the tank and cause serious plugging if the tank valves are continuously open In these cases keep the valves closed until the tanks are full and then drain into the sewage system The holding tank drain valve outlet is to be used with a removable termination fitting that locks onto the outlet with a clockwise twist Clamp the sewer drain hose to this fitting A protective cap should remain in place when you are not drain ing the tanks A WARNING Holding tanks are enclosed sewer systems and as such must be drained into an approved dump station Both black and gray water holding tanks must be drained and thoroughly rinsed regularly to prevent accumulation of harmful or toxic materials Black Water Tank Dumping During self containment use the sewer line is securely capped to prevent leakage of wa
25. Chair Phone 970 532 3476 23188 CR 1 Membership e mail accmembers aol com Berthoud CO 80513 Congratulations on your choice of an American Coach product We are confident that you will enjoy it as much as we have ours To enhance your utilization and pleasure we invite you to join our organization We are the only American Coach Chapter of the Family Motor Coach Association FMCA is the foremost motor home organization in the world and offers a large number of free or for cost benefits Our Chapter meets to rally twice a year immediately preceding each of the two International Motor home Conventions held by FMCA The American Coach Factory Service Team joins us at our Rally to perform repairs and service on our coaches One or more Dealers also join us to display the latest coaches perhaps sell some and to participate in fellowship To be eligible for membership in the American Coach Chapter a person must first be a member in good standing of the FMCA and also own at least a one third interest in an American Coach Heritage American Coach Eagle American Coach Dream American Coach Tradition or a Limited Motor Coach Please fill out the form below and mail it and your check or money order to the address shown above All funds are to be in US dollars We will provide you with a Name Badge Periodically you will receive a Chapter Newsletter The America Way We look forward to having you join us and hope to see you at our next Rally
26. Check the laws in the area where you anticipate traveling MOTOR HOME LOADING Responsibility for Proper Loading As the operator of this motor home you are respon sible for its proper and safe loading This section is intended to provide you with helpful information concerning the loading of your motor home Your motor home chassis is designed to carry a specifically rated maximum weight This weight includes everything the weight of the empty motor home itself all occupants and their belongings fuel fresh water waste water and anything else that may be in or attached to the motor home The specified weights must never be exceeded If you do exceed them you will change how your motor home handles and responds possibly leading to a vehicle crash Some Definitions First Before discussing loading and weighing we need to explain some common weight terms We will use abbreviations and you should refer back to these terms if you do not understand what the abbreviation means Designated Seating Capacity Canadian units only the number of sleeping positions desig nated equals the seating capacity Factory Weight is the UVW at the time of shipment from the factory to the dealer GAWR Gross Axle Weight Rating is the maximum permissible loaded weight a specific axle is designed to carry GCWR Gross Combined Weight Rating is the value specified by the motor home ON THE ROAD manufacturer as the maximum allowable
27. J NOTE If your Owner s Information Package does not con tain these items even if you purchased your motor home used please call or write Fleetwood and request the desired or missing information American Coach Owner Relations 1420 West Patterson Street Decatur Indiana 46733 1 800 435 7345 01 2 Introduction CHASSIS AND VEHICLE IDENTIFICATION Several numbers are used to identify the vehicle and components used on the vehicle The V I N or Vehicle Identification Number is assigned by the chassis manufacturer and is the number used for vehicle registration The V I N is found on the Federal Certification Tag attached in the driver s compartment Refer to this infor mation when ordering parts from the chassis manufacturer or chassis dealer service center The F I N or Fleetwood Identification Number is located on the tag just outside the main entry door or on the outside left front side of the motor home Use this number when ordering parts through your Fleetwood dealer Example FEDERAL CERTIFICATION TAG MFD BY DATE MFD INC VEH MFD BY DATE OF VEH MFD GVWR KG LB FRONT GAWR KG LB WITH RIMS TIRES AT KPA COLD SINGLE PSI INTERMEDIATE KG LB GAWR WITH RIMS TIRES AT KPA COLD PSI REAR GAWR KG LB WITH RIMS TIRES AT KPA COLD DUAL PSI GAWR COMBINED INTERMEDIATE AND REAR KG LB THIS VEHICLE HAS BEEN COMPLETED IN ACCORD
28. Manual This is the operating and maintenance manual supplied by the chassis manufacturer It is part of your Owner s Information Package It contains information on operating and maintaining the engine transmission drive train and other components of the motor home chassis Clearance Lights This switch will flash the clearance lights and is useful when signalling other large vehicles when passing or being passed DC Converter An electronic device that changes 120 volt AC energy from the main power connection or the generator to 12 volt DC energy to operate the 12 volt interior lights or other 12 volt DC appliances or accessories Designated Seating Capacity Canadian units only The number of sleeping positions des ignated equals the seating capacity Dinghy A motorized vehicle such as an auto mobile or truck towed behind a motor home with all four tires on the ground GLOSSARY Doorside The right side of the motor home from the driver s point of view So named because the main entry exit door is on this side FIN Fleetwood Identification Number The number that identifies your motor home as a Fleetwood product Use this number when ordering parts or requesting warranty service for your motor home Factory Weight The UVW at the time of ship ment from the factory to the dealer GAWR Gross Axle Weight Rating The maxi mum permissible loaded weight a specific axle is designed to carry GCW
29. Operate all faucets and fixtures in the fresh water system Check for leaks at all joints and fittings Repair if necessary making sure the water heater bypass is open Check operation of 12 volt circuit breakers and inspect fuses Replace as necessary Operate all 12 volt lights and accessories Install new batteries in battery operated devices Check operator s manual for each device for any additional requirements Test carbon monoxide Propane and smoke detectors alarms Check monitor panel operation Operate vents and vent fans including the range hood fan Inspect the 120 volt electrical system inverter power cord converter all outlets and any exposed wiring If defects are found refer service to an authorized Fleetwood Dealer Prepare the generator for operation follow ing instructions in the generator operating manual in your Owner s Information Package Start and run generator Operate 120 volt appliances and air condi tioner s Be sure to uncover air conditioner shroud s Inspect the Propane system and check for leaks as described in the Propane System chapter If the Propane tank shows signs of rust or corrosion have it inspected by a qualified Propane technician 25 Operate each Propane appliance Have the Propane regulator adjusted for proper pres sure by a qualified technician 26 Inspect and clean the interior 27 Check the sealant around all roof floor and body seams and
30. With Your Motor Home process to allow water snow or debris to fall off the awning and not become entrapped within the awning fabric or mechanism WINDOWS Windows in your motor home are either slider or torque pane type Open slider windows by rotating the locking lever and sliding the win dow Open and adjust torque windows by turn ing the knob or crank located at the bottom of the window frame On your ventilating windows water is trapped by the frame During a heavy downpour or washing water may be seen in the lower portion of the frame The sloping sill and weep slots allow the water to drain to the outside These weep slots must be kept open Damage or failure resulting from the application of after market window tinting is the owner s responsibility If water collects in the bottom channel and overflows check the weep slots for debris and obstructions and clean as necessary NOTE Screens are not removable for cleaning They may be pushed out of their frames if the window must be used for emergency exit In this case the screens will be destroyed and will probably have to be replaced Emergency Exit Window s A WARNING Using the emergency exit window during some form of a life threatening emergency it should be noted that the window exit is very high off the ground Care must be used to avoid injury when exiting through the exit window Emergency exit windows are identifi
31. a monthly basis e Use the air conditioner or a dehumidifier during humid months particularly during the summer in hot humid climates e Use exhaust fans in kitchen and bathrooms to remove excess moisture e Clean the bathroom with mold killing products For more information about mold and what you can do to reduce moisture and remediate mold growth in your RV please refer to the following websites and literature 1 U S Environmental Protection Agency Mold Remediation in Schools and Commercial Buildings 2001 http www epa gov iaq molds moldremediation html 2 U S Environmental Protection Agency A Brief Guide to Mold Moisture and Your Home 2002 http www epa gov iaq molds moldquide html The particle board hardwood plywood or pan eling used in your motor home are made with urea formaldehyde resin The companies that supply us with these materials have asked that 06 11 Living With Your Motor Home we tell you about urea formaldehyde with the statements on this page Ventilation is important for making the interior of your motor home comfortable Please read the section about ventilation and prolonged occupancy in the Living With Your Motor Home chapter in this Owner s Manual We provide you consumer information as detailed by the National Fire Protection Association NFPA and the American National Standards Institute ANSI The information and warnings found on these pages may also be f
32. are driving can distract your attention from the road and possibly cause an accident Enter the information into the system yourself only when the vehicle is stopped The directions provided by the system are sugges tions only The driver is ultimately responsible for the safe operation of the vehicle and therefore evaluate whether it is safe to follow these directions Always use good judgment and common sense 05 17 On The Road TRIP ENGINE COMPUTER Your motor home is equipped with a computer The computer will operate the Trip Engine Computer The motor home will have two color display screens One is located in the dash and the other monitor is located in the control panel display center Your Network Computer Information Package contains detailed operating and maintenance instructions concerning the system BODY UNDERCOATING Certain chassis and underbody components of your motor home have been coated with an under coating material This material is intended to assist in protecting these components from corro sion or other effects of weather and road condi tions Please be aware that certain areas of the motor home do not have undercoating applied in keeping with good engineering practice and to meet the requirements of chassis manufacturers FUEL AND FUEL SYSTEMS See the Chassis Operator s Owner s Guide Manual in the Owner s Information Package for chassis engine fuel recommenda tions The st
33. at a temperature above the vapor point of the Propane Ask your Propane supplier or your motor home dealer for information on product blends available in your area and the areas in which you will be traveling The following chart shows the reduction in available BTU s hour under various fill levels as the temperature drops 09 2 Propane System 20 LB TANK FULL 20 0 5 10 15 60 36 000 18000 12 750 8 500 4 250 50 32400 16 200 12 150 8 100 4 050 40 28 800 14400 11 400 7 600 3 800 30 25 200 12 600 10450 7 300 3 150 20 21 600 10 800 8 100 5 400 2 700 10 16 200 8 100 6 075 4 050 2 025 30 lb Tank multiply x 1 40 The chart clearly shows how the availability of the Propane is reduced at lower temperatures With this in mind keep your Propane tank as full as possible during cold weather Check the BTU hr rating plates on your Propane appliances This information will help you manage your Propane usage FILLING PROPANE TANKS To fill the chassis mounted storage tank drive the vehicle to an Propane supplier or a service station which sells Propane Do not attempt to fill the Propane tank yourself A WARNING Do not fill Propane containers to more than 80 capacity Overfilling can result in uncontrolled Propane flow which can cause fire and explosion A properly filled container holds about 80 of its volume as liquid FAILURE TO COMPLY COULD RESULT IN DEATH OR SERIOUS INJURY
34. be alert to exhaust odors or symp toms of carbon monoxide poisoning A WARNING Exhaust gases are deadly Do not block the tailpipes or exhaust ports or situate the vehicle in a place where the exhaust gases have any possibility of accu mulating either outside underneath or inside your vehicle or any nearby vehicles Outside air move ments can carry exhaust gases inside the vehicle through windows or other openings remote from the exhaust outlet Operate the engine s carbon mon oxide producing systems or components only when safe dispersion of exhaust gases can be assured Monitor outside conditions to be sure that exhaust continues to be dispersed safely If you or others experience any of these symp toms get out into fresh air immediately If symptoms persist seek medical attention Shut down the unit and do not operate it until it has been inspected and repaired Carbon Monoxide Detector Alarm Your motor home is equipped with a carbon monoxide CO detector alarm If the detector alarm sounds it is an indication that unacceptable levels of carbon monoxide gas are present This may occur in traffic concentra tions or in campgrounds where other vehicles as well as your motor home are contributing to the carbon monoxide level in the surrounding air Sounding of the detector alarm does not indicate a faulty detector alarm The detector alarm is doing its job of warning you of potentially high conce
35. be brushed not scraped off e Have any paint nicks or scratches repaired as soon as they occur to protect against corrosion e Should your RV s finish become damaged have it repaired as soon as possible Contact a reputable repair shop near you and specify the DuPont ChromaSystem used for the original finish the color for mula will be located on the vehicle This will assure you the best possible color match and the same durability and appear ance as when your vehicle was new e For the name of the nearest DuPont Repair Facility call 1 800 GET DUPONT or visit us on the web at www performancecoatings dupont com Exterior Graphics Care The pressure sensitive graphics installed on the exterior surfaces of your motor home require little maintenance and should be treated similarly to a painted surface Here are some guidelines to help you keep your exterior graphics looking like new 1 Wash your graphics with any mild car wash soap solution Be sure to rinse thoroughly 2 Keep high pressure wash nozzles at least 1 feet from the edge of the graphics High pressure spray may cause the edge of the graphic to lift and peel away from the wall surface 3 Test any cleaning solution on a small sec tion of the graphic before using the clean ing solution on a larger surface 4 Do not use any aromatic solvents such as acetone MEK toluene paint thinner lac quer thinner on your graphics Any solvent of this type m
36. consult your dealer for the best winterizing procedure for your climate Your dealer can winterize your motor home for you or can supply you with one of the spe cial antifreezes which are safe and approved for use in RV water systems Follow the instructions fur nished with the antifreeze A WARNING Do not use automotive or windshield washer anti freeze in the motor home water system These solu tions may be harmful if swallowed 1 Remove water filter cartridge if equipped and install the winterizing adapter 2 Drain the fresh water tank by opening the water tank drain valve Close valve when drained 3 Turn water pump on 12 volt power must be on 4 Open a cold water faucet When the flow of water stops turn the pump off 5 Open water faucets then open the drain valves on HOT and COLD water pipes Leave these valves open 6 Drain the water heater by opening the drain plug at the bottom of the heater and the safety valve at the top 7 Flush the toilet Operate toilet sprayer if equipped 8 Drain the shower head by opening the valve Let all water drain out the tub spout Leave the valve open 9 When each faucet has been drained close all faucets water line drain valves and the fresh water tank drain valve install the water heater plug and close the safety valve 10 Drain the waste water system by following the normal procedure for draining the hold ing tanks See Plu
37. e Keep matches and igniter devices safely stored and away from small children e Do not store combustibles inside your RV gasoline charcoal lighter etc A WARNING Do not bring or store Propane containers gasoline or other flammable liquids inside the vehicle because a fire or explosion may result A WARNING Explosive fuel clouds may be present at fuel filling stations Before refueling either gasoline diesel fuel or Propane be sure to turn off all pilot flames and appliances in your motor home Turning off the Propane at the tank is insufficient Pilotless appliances may still spark or pilot flames may not extinguish immediately A WARNING Portable fuel burning equipment including wood and charcoal grills and stoves shall not be used inside this recreational vehicle The use of this equipment inside the recreational vehicle may cause fires or asphyxiation Smoke Detector Alarm A battery powered smoke detector alarm is mounted on the ceiling in the living cooking area of your motor home Please read the smoke detec tor alarm operating instructions for details on test ing and caring for this important safety device Test the smoke detector alarm after the motor home has been in storage before each trip and at least once a week during use The smoke detector alarm should never be dis abled due to nuisance or false alarm from cook ing smoke a dusty furnace etc Vent
38. either forward or backward The vehicle has to be in motion for the front wheels to be turned with ease Driving on winding or mountain roads is not difficult if done with reasonable care Observe proper vehicle speeds when ascending or descending hills and always operate in the proper transmission range Downshift on hills to avoid overheating or undue engine loads Downshift when descending grades Engine compression and friction will help con trol vehicle speed and relieve some of the strain on the brakes Shift the transmission to a lower gear before starting down the grade Mountain driving or desert temperatures can put extreme demands on drive train components Under extreme heat conditions you may need to turn off the vehicle air conditioner to improve engine and transmission cooling Be aware of the extra height of your motor home Check for low hanging tree branches or other obstructions whenever you drive or park Avoid low overhangs when pulling in for serv ice Always check overhead clearances of over passes and bridges This may be particularly important if you drive with the overhead vents open or if the motor home is equipped with a roof air conditioner roof rack CB or TV radio satellite antenna Before leaving on a trip check your route Some tunnels prohibit motor homes with Propane systems 05 16 On The Road When parking parallel to a curb be sure to allow for poles or obstructions a
39. etc Open all doors and compartments Check for animal or insect intrusion water dam age or other deterioration Check all chassis fluid levels engine oil engine coolant power steering fluid brake fluid transmission fluid rear axle oil Check charge level in batteries Refill and recharge as necessary Reinstall batteries if necessary Be sure cable ends and terminals are clean and free of corrosion Check Chassis Operator s Owner s Guide Manual for any instructions on resetting chassis computer after battery is reinstalled Check tire pressures Inflate to specified cold pressure 7 Remove covering from inside windows 10 it 12 Open vents and windows for ventilation Be sure engine instruments indicate proper readings Run engine up to operating tem perature Shut engine down Check all flu ids Top up if necessary During engine run check the operation of headlights tail lights turn signals backup lights clearance lights license plate light emergency flashers Operate the vehicle air conditioner If air conditioner does not work or unusual sounds occur have the system checked by a qualified air condi tioner technician Drain flush and sanitize the fresh water system as outlined in the Plumbing chapter Install a new water filter cartridge if equipped 12 4 Storage 13 14 15 16 17 18 19 20 eae 22 23 24
40. in the battery 3 Dry the cables and terminals 4 Do not use grease on the bare metal inside the cable terminals to prevent corrosion Most greases are an insulator A plastic bat tery terminal spray will protect the termi nals after they have been cleaned and rein stalled 5 Keep the carrier and hold down hardware clean and free of corrosion and chemical accumulation A WARNING Before working on either electrical system shut OFF the Automatic Generator Start System AGS gener ator inverter chassis engine and disconnect the shore cord and negative terminals from the batteries If you work on the electrical systems with these sys tems ON or connected you may be shocked electro cuted or severely burned Battery Charging Both sets of batteries will be kept charged by the chassis engine alternator and charging system while you are driving The DC power converter will charge the chassis and house batteries when plugged into 120 volt AC service or by the gener ator if equipped If the battery needs to be charged from a different charging source please follow these safety guidelines e Leaving a charger connected to a battery for an extended period of time can shorten bat tery life e Do not smoke near batteries being charged or which have been recently charged Please 08 2 Electrical Systems note that batteries are being charged while you drive and while you are connected to 120 volt AC
41. is turned off at the container 7 Do not fill Propane containers to more than 80 capacity Overfilling can result in uncontrolled Propane flow which can cause fire and explosion A properly filled container holds about 80 of its vol ume as liquid FAILURE TO COMPLY COULD RESULT IN DEATH OR SERIOUS INJURY 8 Propane regulators must always be installed with the regulator vent facing downward Regulators that are not in compartments have been equipped with a protective cover Make sure that the regulator vent faces downward and that the cover is kept in place to minimize vent blockage that could result in excessive Propane pressure causing fire or explosion 9 Do not use a wrench or pliers to close the tank shut off valve This valve is designed to be closed by hand If a tool is required the valve probably needs repair or replacement 10 If you do not have the special tools and training necessary do not attempt to repair Propane system components 11 Motor homes stored in enclosed garages must be well ventilated 12 Do not modify or alter the Propane plumbing sys tem 13 If any appliance or piping has been serviced ensure that a system leak check has been performed by a trained technician This should be verified before taking delivery of the unit by a trained technician This should be verified before taking delivery of the unit A WARNING Propane cylinders shall not be placed or stored inside the vehicle
42. load of the vehicle is dangerous and may cause premature wear tire damage and or loss of control of the vehicle A tire that is underinflated will build up exces sive heat that may go beyond the prescribed limits of endurance of the rubber and the radial cords This could result in sudden tire failure A tire that is underinflated could also cause poor vehicle handling rapid and or irregular tire wear or an increase in rolling resistance which results in a decrease in its fuel economy Overinflation will reduce the tire s footprint or contact patch with the road thus reducing the traction braking capacity and handling of the vehicle A tire that is overinflated for the load that it is carrying will also contribute to a harsh ride uneven tire wear and will be more suscep tible to impact damage Maintaining correct tire inflation pressure for each loaded wheel position on your vehicle is of the utmost importance and must be a part of regular vehicle maintenance Federal law requires that the tire s maximum load rating be molded into the sidewall of the tire If you look on your tire s sidewall you ll see the maximum load allowed for the size tire and load rating and the minimum cold air infla tion pressure needed to carry that stated maxi mum load Utilizing less air pressure means a lesser load can be carried by the tire Another method of determining the maximum tire pres sure is to review the Federal Certificat
43. monitor when left turn signal is active The displaying of the back up camera image when reverse gear is selected will override all other screens including the door and road side camera images When the reverse gear or the right or left turn signals are no longer selected the monitor screen will return to the previous screen VIDEO VALET SWITCH Heritage only There will be a VIDEO VALET rocker switch for each monitor For the front in dash monitor the VIDEO VALET rocker switch will be on the gear select panel that is located on the left hand side of the driver If the coach has the optional bedroom monitor the VIDEO VALET rocker switch for the bedroom monitor will be located just below the monitor on the side of the cabinet or on the wall adjacent to the monitor These rocker switches are used to select a source to be displayed on the monitor s The rocker switch are two way momentary ON switches which means that when you push either side of the switch and release it the switch will move back to the neutral position Pressing the top side of the switch will move you up through the images one at a time and pressing the bottom side of the switch will move you down through the images one at a time 04 9 This page intentionally blank State laws in the United States and provincial laws in Canada vary concerning operator licensing requirements and vehicle dimen sional restrictions
44. plastic surfaces Maintenance How to Maintain Care for and Repair the Finish on your Fleetwood RV DuPont ChromaSystem provides superior pro tection against the elements your recreational vehicle will face throughout its life To make sure you maximize the benefits of the DuPont ChromaSystem use the following guide to take care of your finish e Wash your vehicle often especially when exposed to salty dusty acidic or alkaline environments e When washing your vehicle use commer cially available car wash soaps specifically designed for washing cars These soaps are non abrasive and have a neutral pH non acidic or alkaline detergent Do not use solvent based solutions for washing large areas e During the first 30 days when the finish is still fresh clean the vehicle with water rinse only Pressure washers used when paint is still fresh could affect the finish Avoid high pressure too close to areas that have stone chips visible on fresh paint e Do not wash vehicle using extremely hot water or while the surface is hot Do not wash vehicle in the hot sun e Avoid washing with stiff bristles Soft cloth and felt brushes are recommended Avoid machine type automated washing systems e Do not allow spilled gasoline anti freeze hydraulic fluid or windshield washer fluid to stand on the paint remove immedi ately by rinsing with water e Do not wax for the first 60 days e Ice and snow should
45. power through the converter charger circuit e Do not break live circuits at the terminals of the battery Use care when connecting or disconnecting booster leads or cables Attaching booster cables and poor connec tions are a common cause of electrical arcs which can cause explosion e As required and depending on the type check and adjust the electrolyte level before charging Fill each cell to the indica tor with distilled water e Always remove all vent caps before charg ing the battery e Do not charge the battery at a rate that causes the electrolyte to spew out e In cold temperature storage conditions bat teries may freeze if not properly charged e Some motor homes are equipped with maintenance free batteries Examine the batteries and identify which type they are so that they can be properly maintained per the appropriate manufacturer s instructions A WARNING Remove rings metal watchbands and other metal jewelry before working around a battery Use caution when using metal tools If a tool contacts a battery ter minal or metal connected to it a short circuit could occur which could cause personal injury explosion or fire A WARNING Do not allow battery electrolyte to contact skin eyes fabrics or painted surfaces The electrolyte is a sul phuric acid solution which could cause serious per sonal injury or property damage Wear eye protection when working with batteries
46. the fresh water gray and black water tanks You can also check the charge in the battery batteries MGTW Maximum Gross Towing Weight The maximum loaded weight of a trailer or towed vehicle this motor home with equipped hitch has been designated to tow MGTW cannot be increased by changing the trailer hitch MTW Maximum Tongue Weight The maxi mum permissible downward force exerted on the hitch ball by the towed vehicle coupler NOTE A statement or instruction in this Owner s Manual with information to help you use the vehicle or equipment more efficiently such as a tip OCCC Occupant andCargo Carrying Capacity The available weight capacity for occupants and cargo however dealer options may reduce this by the LCCR Owner s Information Package This is a pack age of papers manuals warranty and instruc tion cards and other material put together for you by Fleetwood These materials contain operating and maintenance instructions for most of the components and appliances in your motor home Ownercare Card The card that has your name and vehicle ID FIN embossed on it Use this card when you request or need warranty serv ice Please note that this is NOT a credit card You cannot purchase anything with it It is used only to identify you and your motor home Park Cable The F style video connector that allows you to connect to an outside television signal source such as the cable TV feed at an RV p
47. the lines Troubleshooting the Fresh Water System Water system problems usually fall into two categories Inherent system problems and prob lems caused by neglect System problems are 07 2 Plumbing Systems and Holding Tanks usually the result of road vibration and campsite water pressure variations Problems of neglect usually stem from failure to clean filters improper winterization and poor battery main tenance Most water system problems can be avoided by conscientious maintenance Leaks Vibration flexing and twisting while traveling can work pipe fittings loose Check all plumbing for leaks at least once a year If the water pump runs when a faucet is not open suspect a leak Be sure the tank drain valves are tightly closed Leaks occur most often around threaded fittings If necessary tighten or clean and tighten the fit tings Do not overtighten fittings Connections at galley and lavy fixtures should not be tightened with a wrench They will normally seal with hand tightening If a leak persists at one of the fittings disconnect it completely and check for mineral deposits or other foreign matter at the seating surfaces Clean the surfaces thoroughly and reinstall the fitting Connections at the water tank pump and valves are made with special clamps They can be replaced with standard automotive type hose clamps Leaks caused by freezing damage can be pre vented by proper winterization of the syst
48. to the tire with the higher of the side to side loads WEIGHING YOUR TANDEM AXLE MOTOR HOME To Obtain Individual Axle and Gross Vehicle Weights STEP la STEP 1b STEP 1c Scale Weight0 lbs Scale WeightO lbs Scale Weight0O lbs 0 oO Step 1a GAW O 00 Step 1b GVW O oO Step 1c O From O From O o a g Owner s Manual Ibs Owner s Manual lbs O o0 GAWR oO GVWR STEP 1d STEP le Calculated Scale Weight0 lbs 0 Scale Weight0 lbs 0 oO Step 1d GAW O oO Drive Axle GAW 1c 1d 0 From O From O Owner s Manual lbs O Owner s Manual lbs O o0 GAWRO 00 GAWRO If pulling a towed vehicle see Weighing Your Motor Home Step 4 05 8 On The Road WEIGHING YOUR TANDEM AXLE MOTOR HOME To Obtain Individual Wheel Positions Weights STEP 2a STEP 2b One SideO One SideO Scale Weight0 lbs 0 Scale Weight0 lbs 0 00 Step 2a 0 00 Step 2b 0 Calculate Other lbs 0 Calculate Other lbs 0 Side Weight0 Step 1a 2a 0 Side Weight0 Step 1c 2b 0 oO Oo Tire Load Ibs 0 lbs O oO oO See Note O InflationOO psi O 00 See Note Oo STEP 2c STEP 2d Calculated One SideO One SideO Scale WeightO Ibs O Scale WeightO lbs O oO Step 2c O 00 Step 2d Right Duals 2b 2c 0 Calculate Other lbs 0 Calculate OtherO lbs 0 Side Weight0O Step 1d 2c O Side WeightO Left Duals 1e 2d 0 Oo Oo Tire Load lbs O lbs 0 Tire Load lbs O lbs 0 00 See Note O 00 See Note O Inflation00 psi O InflationOO psi O 00 See Note oO
49. windows Reseal if neces sary See Sealant Renewal section 28 Lubricate all exterior locks hinges and latches 29 Reinstall windshield wiper blades or remove protective covers Check wiper washer oper ation 30 Wash and wax the exterior Inspect the body for scratches or other damage Touch up or repair as necessary Flush the under side thoroughly 31 Run thorough operational checks of steer ing brakes engine and transmission Operate vehicle slowly during these checks to allow sufficient circulation of fluids and reseating of components Your motor home should now be ready for a new traveling season If you choose your dealer can double check your preparation and repair any problems or make any necessary adjustments 12 5 This page intentionally blank AC Inverter An electronic device that changes 12 volt DC energy from the batteries to 120 volt 60 cycle AC energy to operate microwave ovens TVs VCRs or other appli ances that require 120 volt 60 cycle power Belted Seating Positions These are seats with seat belts Anyone riding in the motor home must use one of these seats any time the motor home is in motion Black Water Tank The water tank in your plumbing system that is designed to contain waste water from the toilet ONLY CAUTION Any statement in this Owner s Manual that if not followed could result in damage to the vehicle or components Chassis Operator s Owner s Guide
50. windows and doors until the residues are completely burned off Always follow the appliance manufacturer s lighting and operating instructions If the furnace does not keep you comfortably warm NEVER use the range oven or a catalytic heater for supplementary heat even with a vent or window open Combustion air for the furnace comes from out side the RV The products of combustion from the furnace carbon dioxide carbon monoxide and other gases are returned to the outside air A WARNING Portable fuel burning appliances are not safe for heat ing inside the motor home Asphyxiation or carbon monoxide poisoning can occur HYDRO HOT HYDRONIC HEATING SYSTEM If Equipped Your motor home may be equipped with a Hydro Hot Hydronic heating system The Hydro Hot Hydronic heating system is an on board heating system that provides an on demand continuous supply of domestic hot water as well as interior heat where and when it is needed Both heating features are accomplished by a 50 000 BTU diesel fired burner and a 1650 watt electric heating element 120 volt AC These two heating sources maintain the temperature of the Hydro Hot s 50 50 solution of water and antifreeze In addition the Hydro Hot has been designed to preheat the vehicle s engine prior to starting This feature provides easy engine start up when cold weather conditions exist A CAUTION The Hydro Hot s Exhaust is HOT DO NOT park
51. 1 Lift table reach underneath fold up the legs under the table top Secure the legs 2 Lower table top to the dinette frame to complete the bed base 3 Slide the seat and back cushion into place over the bed base The under seat storage may be reached by raising the cushion platform Sofa Conversion If Equipped To convert a sofa bed into a bed 1 Remove sofa bolsters if applicable 2 Lift front of sofa seat above front kick panel up and out The back of the sofa will drop back and down as the seat is pulled outward To restore the sofa lounge 1 Lift the front edge of the sofa seat up and push it back towards rear The sofa back will come up 2 Push the sofa fully into position Sleeper Sofa Conversion If Equipped To convert a sleeper sofa into a bed 1 Remove sofa cushions 2 Lift front of sofa seat above front kick panel up and out While lifting the seat out the middle legs will automatically unfold into a vertical position 3 Pull upward on the center of the metal bar and rotate it down slowly until the wood bars rest on the floor To restore the sleeper sofa 1 Lift the front edge of the bedframe up and rotate it back 2 Lift the middle section of the bed up and push it back towards the rear until the bed is fully into position 3 Replace the cushions Folding Doors Privacy Curtain Dividers The dividers allow you to separate areas in the motor home They glide on n
52. ANCE WITH THE PRIOR MANUFACTURERS IVD WHERE APPLICABLE THIS VEHICLE CONFORMS TO ALL APPICABLE FEDERAL MOTOR VEHICLE SAFETY STANDARDS IN EFFECT IN VLN TYPE VEHICLE MULTI PURPOSE PASSENGER VEHICLE The tires and wheels with sizes and ratings designated above have been equipped with this vehicle by Fleetwood Any replacement tires installed must meet the same specifications and minimum load requirements FLEETWOOD ENTERPRISES INC PRODUCT YEAR MODEL FIN pounds GROSS VEHICLE WEIGHT RATING GVWR FACTORY WEIGHT ON OCCUPANT AND CARGO CARRYING CAPACITY FULL FRESH WATER TANK gal Ib gal GROSS COMBINED WEIGHT RATING GCWR MAX GROSS TOWED WEIGHT MAX TONGUE WEIGHT kilograms MOTORHOME OCCUPANT AND CARGO CARRYING CAPACITY VIN THE COMBINED WEIGHT OF OCCUPANTS AND CARGO SHOULD NEVER EXCEED kg or Ibs Safety belt equipped seating capacity A full load of water equals kgor Ibs of cargo 1kg L Ibigal and the tongue weight of a towed trailer counts as cargo CAUTION LOAD CARRYING CAPACITY REDUCED Modifications to this vehicle have reduced the original load carrying capacity by kg or Ibs Located in the driver s compartment SUSPENSION ALIGNMENT AND TIRE BALANCE The front suspension and steering system of this vehicle was accurately aligned at the factory before delivery to the dealership However after you have fully loaded the vehicle according to your personal needs have the ali
53. CAUTIONS Propane is a safe and reliable fuel As with any other volatile and flammable material common sense dictates that Propane be handled and used with respect and caution Because Propane sys tems are so reliable they are often taken for granted Neglect can be a very dangerous habit If the system is maintained regularly you can expect almost trouble free operation The first time you have your Propane tank filled have the serviceman bleed a little Propane out of PROPANE SYSTEM the small outage valve this also lets you check that the bottle is not overfilled and note the odor described as garlic rotten egg like for future reference A small number of people can not smell this odor if you are one of these you must take extra care whenever you use your motor home Keep the tank valve closed and turn off all appliances if the unit is not being used A WARNING Propane is flammable and potentially explosive Use proper handling lighting and ventilating procedures WARNING IF YOU SMELL PROPANE 1 Extinguish any open flames pilot lights and all smoking materials 2 Do not touch electrical switches 3 Shut off the Propane supply at the container valve s or Propane supply connection 4 Open doors and other ventilation openings 5 Leave the area until the odor clears 6 Have the Propane system checked and leak age source corrected before using again FAILURE TO COMPLY COULD RESULT IN EXPLOSION RES
54. Dinette Conversion with Free Standing Table If Equipped 20 020 0c00 8 06 6 Sofa Conversion If Equipped 06 6 Sleeper Sofa Conversion If Equipped 06 6 Free Standing Furniture If Equipped 06 6 Folding Doors Privacy Curtain DIAG songs Gam ee bids Waa aka ewer 06 6 Interior Lighting sccccendeeanetexexed 06 6 Overhead Vents 2 vise ck ca eaee datdeed 06 7 Folding Chairs If Equipped 06 7 Free Standing Furniture If Equipped 06 7 Monitor Panel lt ssescresrecrr escent saad 06 7 Effects of Permanent Occupancy 06 8 Condensation and How to Control It 06 8 Dripping Ceiling Vents 06 10 Important Information i ccdcdsn caw ed 06 10 What the RV Owner Can Do 06 11 BUC Say cen cebeeeeek 2 deed bee et 06 12 Fire Safety Precautions 5 06 13 Smoke Detector Alarm 0 046 06 13 PLUMBING SYSTEMS AND HOLDING TANKS 07 1 Fresh Water System osccse065b504500s04 07 1 External Fresh Water Hookup 07 1 Filling the On Board Water Tank 07 1 Draining the Fresh Water Tank 07 2 Wat r Pump os v0 tine os he eR es ee 07 2 Water Pump Filter a an na wa acd 07 2 Low Point Drains 0 00 000 res 07 2 Troubleshooting the Fresh Water System 07 2 Leaks aa Stas bw ues Gets eee Goi ita Goa 07 3 Sanitizing the Fresh Water System 07 3 Exterior Shower If Equipped 07 3 Power Water Hose Reel If Equip
55. EATH OR SERIOUS INJURY 10 2 Appliances When you use the range oven for cooking or baking always open a vent or window to provide ventilation Never operate the range or oven when you are sleeping or if your alertness is impaired in any way FAILURE TO COMPLY COULD RESULT IN DEATH OR SERIOUS INJURY A WARNING Do not use open flames to warm the living area Gas combustion consumes the oxygen inside the motor home RANGE EXHAUST HOOD The exhaust hood allows vapors and cooking odors to escape and may provide a vent for the galley area Switches for the fan and light are located either on the range hood or the front of the microwave The hood has grease filter screen s which require periodic cleaning To clean remove the screens and wash in soapy water Rinse with water and let the screens drain dry If needed replace the light bulb with an equiva lent type found on the bulb or listed in the appli ance owner s manual AIR CONDITIONER WITH HEAT STRIP If Equipped The roof mounted air conditioner s can operate only when the motor home is connected to 120 volt AC power from either a public utility or the generator Be sure the air conditioner circuit breaker is ON Each return air duct is equipped with a filter Check these filters at regular intervals for accu mulations of dust that could restrict air flow For best performance park the motor home in the shade and close curtains Close
56. IRCUIT BREAKER PANELS CIRCUIT FUSE PANELS AND BATTERY DISCONNECT SWITCH LOCATIONS American Eagle Tradition and Heritage e Chassis 12 Volt Fuse Front Panel seenen In the entry step well e Chassis Fuse 12 Volt Fuse Rear Panel eee Next to 12 Volt Battery Disconnect Switch e Chassis 12 Volt Battery Disconnect Switch Rear engine access compartment e House 12 Volt Battery Disconnect Switch In the battery compartment e House 12 Volt Fuse Panel sississcosssvisccnssvadennysndseonssnesonsyns In the basement in front of the batteries e House 120 Volt Breaker Panel 5 cccisc apcoceeaveseapeesnte resis Various Locations by model H Behind TV Cabinet D Under Desk F Corner Cabinet in hallway All Other models Hallway A WARNING Do not install 12 volt fuses or 120 volt breakers with amperage ratings greater than that specified on the device or label Doing so constitutes a fire hazard A CAUTION Before relamping disconnect power source by remov ing fuse or placing circuit breaker and control switch in OFF position Halogen bulbs operate at extremely high temperatures and pressures and will shatter if not handled correctly Always use a soft dry cloth or cotton gloves when han dling halogen bulbs Do not touch glass area with bare hands If bulb is touched with bare hands wipe the bulb clean with rub bing alcohol Do not use near flammable or combustible materials and or objects which may be
57. If the seal gets damaged it is easily replaced Do not use harsh household drain cleaners POWER CORD J BOX POTABLE WATER HOSE STORAGE TV CABLE TELEPHONE CONNECTIONS ELECTRIC CORD STORAGE CITY WATER FILL BYPASS VALVE DRAIN HOT amp COLD COLD WATER HOT WATER VALVES FOR DRAIN SEWER HOSE BLACK WATER GRAY WATER OUTDOOR KNIFE VALVE KNIFE VALVE SHOWER American Eagle and Tradition Utility Compartment detail varies depending on product SENSATANK TANK MONITOR MULTIPLEX SWITCH SPRAY NOZZLE HOT amp COLD VALVES ri FORSPRAYER fo ry ZF 7 5 SZZ GFI OUTLET 2 HHS QO B Pa g GREY TANK WATER_ PUMP SWITCH i olbja a 12 VOLT OUTLET OS dk S J CARGO LIGHT BLACK TANK WATER sal gt T CITY WATER CONECTION PUMP SWITCH aa PAPER TOWEL 7 SANI FLUSH VALVE 4 SANI FLUSH CONECTION SEWER HOSE CONECTION _ SOAP DISPENSER i WATER TANK BYPASS Heritage Utility Compartment detail varies depending on product 07 8 ELECTRICAL SYSTEMS Your motor home is equipped with three electri cal systems the chassis 12 volt system the Fleetwood 12 volt house system the 120 volt AC system They operate together to give you electrical power for many different situations Batteries Your motor home has tw
58. LIGATIONS The owner is responsible for normal mainte nance as described in the Owner s Information Package however minor adjustments such as adjustments to the interior or exterior doors cabinet latches TV antenna control etc will be performed by the dealer during the first 90 days after delivery Thereafter such adjustments are the responsibility of the owner as normal main tenance unless required as a direct result of repair or replacement of a defective part under this warranty If a problem occurs which the owner believes is covered by this warranty the owner shall con tact the selling dealer or other authorized dealer giving sufficient information to resolve the matter Written notice of defects must be given to the selling dealer or manufacturer within thirty 30 days of discovery by owner but no later than ten 10 days after the expiration of the warranty period The owner shall deliver the motor home to the dealer or an authorized Fleetwood dealer location for warranty service See Warranty Service page 2 3 for additional details To the extent allowed or not prohibited by appli cable law the manufacturer requires that the owner first provide it with direct written notifi cation of any alleged unrepaired defect or any other dissatisfaction experienced with the motor home so the manufacturer has the opportunity to cure the problem or dissatisfaction itself Giving the manufacturer this direct no
59. OME When preparing to travel in your motor home you have 20 minutes to retract your slide outs and raise your leveling jacks before the air leveling system times out In the event you exceed this period you will be required to turn the motor off with the ignition key wait five seconds with the key in the off position and restart your engine Press the Travel Mode on the leveling system key pad to ensure activation of the leveling system to travel height This event should take less than five minutes You can verify the leveling system is at ride height by observing the clearance between the tires and the wheel well skirts There should be approximately two to three inches of vertical clearance between these two components with the wheels pointing straight ahead Failure to wait until the leveling system is fully inflated may result to damage to the fiberglass wheel well skirt or damage PLUMBING SYSTEMS AND HOLDING TANKS DRAINING THE HOLDING TANKS The holding tanks terminate in a valve arrange ment that permits draining of each tank sepa rately The valves are called knife valves A blade closes the opening in the sewer drain pipes The blade is connected to a 12 Volt elec tric motor A button will activate the knife valve for discharging the wastewater from the RV During self containment use the sewer line is securely capped to prevent leakage of waste material onto the ground or pavement Do not activate the knife va
60. OSS OF USE LOSS OF VALUE LOSS OF INCOME LOSS OF TIME INCONVEN IENCE COMMERCIAL LOSS BUS FARES VEHICLE RENTAL INCIDEN TAL CHARGES SUCH AS TELEPHONE CALLS OR HOTEL BILLS 2 ANY OTHER PROPERTY DAMAGE CAUSED OR ALLEGED TO BE CAUSED BY MOLD MILDEW FUNGUS DRY ROT OR ANY MICROBIAL MATTER OR 3 LEGAL FEES OR EXPENSES Some states do not allow the exclusion or lim itation of incidental or consequential dam ages so the above limitation or exclusion may not apply to you 02 1 Warranty LIMITATIONS ANY IMPLIED WARRANTIES INCLUDING BUT NOT LIMITED TO THE IMPLIED WARRANTIES OF MERCHANTABILITY AND FITNESS FOR A PARTICULAR PURPOSE ARE LIMITED IN DURATION TO THE DURATION OF THIS WRITTEN WARRANTY Some states do not allow restrictions on how long an implied warranty lasts so this limita tion may not apply to you The manufacturer is not responsible for any undertaking representation or warranty made by any dealer or other person beyond those expressly set forth in this warranty YOUR RIGHTS UNDER STATE LAW This warranty gives you specific legal rights and you may also have other rights which vary from state to state DEALER S OBLIGATIONS By agreement with the manufacturer the dealer is obligated to maintain the motor home prior to retail sale to perform a detailed predelivery inspection and to repair or replace any parts necessary to correct defects in material or work manship OWNER S OB
61. Propane cylinders are equipped with safety devices that relieve excessive pressure by dis charging Propane to the atmosphere FAILURE TO COMPLY COULD RESULT IN DEATH OR SERIOUS INJURY SYSTEM COMPONENTS Hoses The hoses used in your Propane system meet stringent requirements and are rated to with stand many times the pressures encountered in the system Check the hoses for weather check ing or other signs of deterioration every time you have the Propane tank filled or serviced When you replace hoses be sure that replacements are properly rated and approved for RV use Propane Regulator The two stage regulator produces approximately 11 inches of water column less than 0 5 psi to serve your appliances Be sure the regulator vent stays clean and free from obstructions The regulator is mounted so that the vent is fac ing downward and is protected by a cover Be sure the cover is on at all times If the vent becomes clogged it can be cleaned with a tooth brush If corrosion is evident contact a qualified Propane service technician for assistance A WARNING Do not attempt to adjust the regulator It has been preset by the regulator manufacturer If any adjust ment is required it must be made by a qualified Propane service technician using special equipment USING PROPANE SYSTEM AT LOW TEMPERATURES Your Propane system will function at low tem peratures provided the system components are kept
62. R Gross Combined Weight Rating The value specified by the motor home manufac turer as the maximum allowable loaded weight of this motor home with its towed trailer or towed vehicle Towing and braking capacities may be different Refer to Fleetwood and the chassis manufacturer s manuals for complete information Gear Preselection The selection of a lower gear to match the driving conditions you encounter or expect to encounter Preselection will give you better control on slick or icy roads and on downgrades Downshifting to lower gears increases engine braking The selection of a lower gear often prevents cycling between a gear and the next higher gear on a series of short up and down grades GFCI Ground Fault Circuit Interrupter An electrical device attached to the bathroom AC circuits that disconnect the outlet if a problem occurs in the ground circuit Gray Water Tank The water tank in your plumbing system that is designed to contain waste water from the sinks and shower drains ONLY No toilet wastes go into this tank GVWR Gross Vehicle Weight Rating Is the maximum permissible weight of this fully loaded motor home 13 1 Glossary LCCR Load Carrying Capacity Reduction The amount the OCCC is reduced due to vehicle weight added by the dealer between vehicle certification and first retail sale Monitor Panel An electronic device that allows you to conveniently measure the approximate levels in
63. R LIGHTS S POWER D048 LEFT TURN STOP D047 RIGHT TURN ELECTRIC BRAKE NOTCH TRAILER HITCH PLUG AS SHOWN FROM PLUG SIDE DEEP SNOW AND MUD SWITCH IF EQUIPPED A deep snow and mud option switch is included with ATC This function increases available traction on extra soft surfaces like snow mud or gravel by slightly increasing the permissible wheel spin Drivers use a deep snow and mud switch to select this feature When this function is in use the ATC indicator lamp blinks continuously Switch and lamp locations will vary depending on the vehicle make and model Listed below is how the Deep Snow and Mud feature works Function Function Driver System Active Not Action Response Active Press deep ATC lamp snow and blinks X mud switch continuously Press ATC lamp switch stops blinking X again NOTE Turning off the ignition will also deac tivate the deep snow and mud feature 04 4 Heritage Information DRIVER S CONTROLS 11 13 12 30 MY if e7 Pay SA Fo NG ae Wa Jol ATP a a 5 gt a LILI gdl e 27 c gt 14 34 31 Instrument Panels 1 11 12 13 14 15 16 17 18 19 ONoar YN Auxiliary Switch Blank Dimmer Switch Driver Lamp Switch Head Light Switch Fuel Water Oil Gauge Left Turn Signal Speedometer
64. SOCIATION is an independent member operated organization limited to owners of American Coach motor homes Members can choose to join one or more of eleven local chapters located strategically throughout the United States Members of local chapters of the American Coach Association meet frequently for social and recreational rallies in different and interesting locations Useful and interesting American Coach information is distributed bimonthly in the associations magazine Subject material varies from important technical matters to fascinating travel destinations Local chapter news items are included as well as travel tips and favorite recipes recommended for on the go travelers The magazine also includes information on the upcoming national and chapter rallies ASSOCIATION CHAPTERS e GREAT LAKES CHAPTER NORTHEAST CHAPTER e MAC PACK CHAPTER SOUTH CENTRAL CHAPTER e SOUTHEAST CHAPTER SOUTHERN CALIFORNIA CHAPTER e NORTHERN CALIFORNIA CHAPTER SOUTHWEST CHAPTER e MISSOURI VALLEY CHAPTER NORTHWEST CHAPTER e HAPPY WANDERERS CHAPTER FOR CONTACT INFORMATION PLEASE REFER TO THE AMERICAN COACH ASSOCIATION WEBSITE AT WWW AMERICANCOACHASSOC COM COME AND SEE WHAT S NEW FROM AMERICAN COACH AT THE NEXT NATIONAL RALLY National rallies for all American Coach Association members are conducted twice yearly with special product seminars and Fleetwood Corporate representative participation On site vendors display new maintenance a
65. There may be times when your motor home will need repairs or parts while you are on the road If your motor home is repaired by a non authorized repair facility non Fleetwood dealer be sure to save receipts and especially any parts that are replaced These parts will usually have to be returned to your dealer before you can be reimbursed for their cost Always make a written list of the motor home problems or the specific work you want done If you ve had work done that is not on your maintenance log let the service advisor know If you have a long list of service items that need attention and you need your motor home very soon discuss the situation with the service advisor listing the items in order of priority This will help the service department manage its time and will help get you going as quickly as possible If required work is not covered under the warranty your dealer s service department can help you with getting the correct service The materials in your Owner s Information Package Package contain warranty information and operating instructions on the various appliances and components in your motor home If you do not have operating instructions for a particular appliance or component contact your dealer Warranty registration cards for these items should be filled out and mailed as soon as possible after you take delivery of your motor home When contacting any of the equipment manufacturers always have the m
66. ULTING IN DEATH OR SERIOUS INJURY 1 Never check for leaks with an open flame Use an approved leak detection solution or a non ammoni ated non chlorinated soap solution only 2 Always be careful when drilling holes or fastening objects to the motor home The Propane supply lines could be punctured by a nail or screw 3 Do not restrict access to Propane containers In an emergency the container service valve must be eas ily identified and accessible The container compart ment door must always be unlocked and the Propane label should be visible 4 Do not carry or store filled or empty Propane con tainers including accessories such as Propane bar becues in your motor home Propane containers are equipped with a safety device that relieves excessive pressure by discharging Propane into the atmos phere Always store Propane containers outside with the valves closed and plugged 5 Do not use any Propane container other than the one furnished with your motor home without being sure that all connecting components are compatible 09 1 Propane System A WARNING 6 Turn off Propane main valve before filling Propane container or entering an Propane bulk plant or motor fuel service station Turn off all pilot lights and appli ances individually before refueling of motor fuel tanks and or Propane containers When not individually turned off automatic ignition appliances may continue to spark when Propane
67. Valve REFRIGERATOR Read the operating instructions furnished in your Owner s Information Package Before operating the refrigerator when the motor home is parked make sure it is level If it is not level the refrig erant will not circulate cooling action will stop and the refrigeration system may be damaged The refrigerator uses the absorption principle of operation If you plan to cool food or drinks in high outside temperatures precool the food and if possible park the motor home with the refrigerator vent door in the shade Once the interior of the refrigerator is cool the refrigera tion system will usually maintain this tempera ture If the inside of the refrigerator is hot the food is not precooled and the outside tempera ture is high it will take longer for your food to be cooled 2 STAGE FORCED AIR FURNACE The furnace is a forced air unit fueled by Propane All furnaces are equipped with a wall thermostat for temperature setting The furnace will not operate properly if your stored personal items block the free flow of air at 10 1 Appliances the registers or the return air to the furnace Storage under cabinets should be done carefully so as to not crush or damage any furnace ducting Smoke and fumes created as a result of burning off manufacturing compounds are sometimes present the first time the furnace is used This is normal however when you light the furnace the first time open all
68. ad Distribution 2 6625 sedan teeads 05 6 How to Weigh Your Loaded Motor Home 05 6 Dangers of Overloading ou 556 25k 0 wai 05 9 Loading TIOS 64050 e a Ctwades eevee ed 05 10 TITES 2cudcsevedegeredaseeecesaeeaesd 05 10 Tire Inflation 6035 ian thetececcueted 05 10 Air Pressure ec itn wee eee eee 05 11 UNACTIANGHON 26 si ace eed Seereaes eed 05 11 Air Pressure Check 2 3 55 6h 24 Oh ee eg ead 05 12 Tire Replacement 6 5650 dona nee cd 05 12 If You Get a Flat Tire 2 cc0sscecasncecd 05 12 Changing a Flat Tire 05 12 Seats and Seat Belts dsaacs4 n44 hese od 05 13 Combination Lap and Shoulder Belts 05 13 Safety Belt Maintenance 05 14 Safety Restraints for Children 05 14 Safety Belts for Children 05 14 Child Seat Tethers If Equipped 05 14 Air Bags If Equipped lt 022s005 28 lt 05 15 00 1 Table of Contents Driving and Vehicle Control 05 15 Using the Engine to Slow the Motor Home sccesuavde meee anwewes 05 16 Maneuvering in Traffic 003 seseensss ot 05 16 Rear View Video Monitor If Equipped 05 17 Exterior Side Camera System If Eq ipped sacs bicii3 exiwdivaes ed 05 17 Global Positioning System Navigation GPS accckeudweaeercaced 05 17 Trip Engine Computer 2422iss2iedeess 05 18 Body Undercoating 5 24 ce sve exudes 05 18 Fuel and Fuel Systems 2 2ys4 a0 enue ad 05 18 Fuel Types and Driveability Issues 05 18 API Refueli
69. ad for that wheel position Consequently it too may have suffered some casing damage due to over loading Air Pressure Check You should check the air pressure every two weeks or at least once each month and before any major trip Your RV tires air pressure should be checked every drive morning on long trips On short trips of a day or less driving each way your tires should be checked before you leave on your trip and again before you start your trip home Check your tires when they are cold and have not been driven for more than one mile The stated load capacity for a given cold inflation pressure is based on ambient outside tempera ture If you must check your tires when they are warm or hot do allow for a slight increase in air pressure and make sure they are within a couple of pounds of each other on the same axle Frequently check tires If a tire picks up a nail or screw that creates a slow leak and causes some air pressure loss you might eventually spot it visually if it is a front tire If it is an outside rear dual you might also spot it with a visual inspec tion However if it is an inside rear dual the chances of spotting it without an air pressure check are very slim If you begin driving without finding it very quickly in most cases a few miles your outside rear tire next to the low air pressure tire is going to heat up from carrying double its load which if left un remedied will eventually wil
70. all covering material before using appliances or vents Cap or close holding tank drain city water inlet and fresh water fill spout Turn off all radios TVs interior and exte rior lights Close curtains and or mini blinds and pull shades Disconnect and store the 120 volt power cord Cover tires with cloth plywood or after market tire covers Prepare generator Refer to generator oper ating manual included in your Owner s Information Package Run the engine for about 15 minutes every 30 days Turn the vehicle air conditioner ON during this run Check engine oil transmission fluid and coolant levels 12 1 Storage Long Term Storage Over 30 Days 1 Perform all steps as required for short term storage 2 Run chassis engine to normal operating temperature Operate automotive air condi tioner s to lubricate compressor seals Drain engine oil replace filter refill engine with fresh oil 3 Remove windshield wiper blades and store inside the motor home 4 Charge and remove both the chassis and house battery ies Store in a cool dry place and check the charge and water level every 30 days If the specific gravity is being checked recharge the battery when it drops to 1 220 With the advent of com puter controlled engine and transmission management systems certain procedures must be followed whenever the chassis bat tery is disconnected or replaced Please refer to your Chassis Oper
71. almost 2 2 pounds of water can be released into the air Clothes drying After 10 pounds of clothes have been washed and spin dried in a washer they still contain about 10 pounds of water If these clothes are dried inside that water is released into the air in the RV Propane appliances When Propane is burned carbon dioxide nitrogen and water are given off into the air For every 1000 cubic feet of Propane burned nearly 88 pounds of water is released into the air Humidifiers Humidifiers are designed to put moisture into dry air up to two pounds per hour So in a 24 hour period an uncontrolled humidifier can put almost 50 pounds of water into the air House plants and aquariums Plants give off almost as much water as you put on them Open aquariums permit higher rates of evaporation than closed types People and animals A large source of water in the RV is the inhabitants them selves A family of four can put up to 12 pounds of water into the air per day through breathing and perspiration As you can see just the normal course of living adds a great deal of water to the air What will all this water do to my RV The least it will do is fog your windows If it is really cold outside frost or even clear ice could form on the inside of the glass Excessive moisture in the air could show up as water running down or dripping off walls ceilings or fixtures It may look like your roof or windows
72. andard generator is designed to run on the same fuel as the chassis engine or on Propane Consult the generator operating instructions for special cautions about mainte nance with different types of fuels A WARNING When removing the fuel fill cap rotate it slowly only far enough to allow the pressure to release After any hissing sound stops remove the cap completely Modern fuel systems may build up vapor pres sure within the tank as the fuel warms during use or hot weather Under certain conditions sudden release of this pressure when removing the fuel cap can cause fuel to spray from the fill opening creating a fire hazard To protect the fuel system from excessive pres sure or vacuum or from sudden release of pres sure replace lost or damaged fuel fill caps with caps of the same design which are available from your Fleetwood motor home dealer Clean up fuel spills immediately Fuel spilled on the motor home could damage the exterior fin ish and is a serious fire hazard J NOTE Fuel for the generator is taken from the main fuel tank through a special feeder tube which is higher in the tank than the feeder tube to the motor home engine This arrangement prevents the generator from run ning the motor home fuel tank dry Fuel Types and Driveability Issues Your motor home s automotive fuel and emis sions systems are sophisticated and engineered to meet Federal and State em
73. are ammonia based Most tar removers are petroleum based Wash Assembly with MILD SOAP AND WATER ONLY WINDSHIELD WIPERS amp WASHER Your motor home is equipped with windshield wipers that are located on the upper front cap Having the proper windshield washer solution will be an important step in maintaining your system in good operating order CAUTION Use only a windshield washer solution that is rated at a minimum of 20 degrees F 8 deg C to prevent damage to the system from freezing up MAINTENANCE GUIDELINE While many RV owner s use their RV for week end and vacation travel others may use their RV full time Full time use of an RV can consider ably affect its condition as well as maintenance requirements As long as you are not full timing or traveling under several climate conditions the normal maintenance guidelines that are outlined in your Fleetwood Owner s Manual will ensure your RV will provide you many years of enjoy able use Severe climates either hot or cold can affect your seals sealants plumbing Propane system and cause internal condensation issues Full timing can cause extra wear and tear to your RV simply from continuous usage and or exten sive miles driven If you are a full timer or using your RV in severe climate conditions follow the full timer severe climate scheduled mainte nance program as outlines in your Fleetwood Owners Manual By following this maintenance sche
74. are designed to be mainte nance free with proper use Please refer to the Owner s Manual for further information regarding the Battery Charging System Automatic Generator Start AGS The Automatic Generator Start AGS is part of the Magnum Inverter control panel Heritage The AGS panel is in the front overhead for the Eagle and Tradition Your Owner s Information Package contains detailed operating and maintenance instructions concerning the system TRIP NAVIGATION AND HOUSE MONITORING SYSTEM REFERENCE MATERIAL XNAV9525 Installation Manual amp Quick Start Guide Dual Navion TM R5000 Operating Instructions 0 0 00 ee eee Lectronix Video Valet Video Source Management System Installation amp Coretronics Inc GVN 52 Garmin Owner s Manual Garmin Video Valet Video Source Management System Installation amp Coretronics Inc User s Manual Model 200 Mobile Monitor Operating Instructions Sony TripTek Motor Coach Trip Computer Operator s Manual Coretronics Inc NAVIGATION SYSTEM The coach is optionally equipped Standard on Heritage with a Garman GVN 52 GPS Navigation System that is integrated into the standard Navion R5000 This system functions as your navigational aid providing turn by turn visual and voice guidance to direct you to your selected destination The navigation system uses the Global Positioning System GPS sa
75. are leaking This water may stain woodwork carpeting ceiling panels or even furniture But the most damage is caused by water you can t even see Water will penetrate almost any material except glass and metals Water vapor in the air always wants to move toward dry air Scientists call this vapor pressure action It will go through walls floor covering plywood paint just about anything The water that gets trapped in these materials can cause warping mildew paint failure and rotting The damage caused by excessive humidity can be invisible and worse expensive to fix Please remember that this damage is not covered under the warranty What can I do to reduce or eliminate condensation problems in my RV The two most important things are Reduce moisture released into the air and increase ventilation To reduce moisture released inside the RV 1 Run the vent fan when cooking and the bath vent fan or open the bath vent when bathing 2 Avoid making steam from excessive boiling or use of hot water 3 Remove water or snow from shoes before entering to avoid soaking the carpet 4 Avoid drying clothes inside except in the dryer if equipped The water drying out of the clothes goes into the air 5 Vent appliances to the outside Your clothes dryer should always be vented according to the dryer manufacturer s installation instructions Some dryers are designed to be ventless and do not requ
76. are stored and will help speed the loading process e Secure and brace items so they won t move during travel Generally load heav ier items lower e Fresh water and waste water weigh over eight pounds per gallon Carry only as much water as needed for travel use or to balance the load and whenever practical empty the holding tanks before traveling e Store emergency items in a readily accessi ble location As a minimum include a fire extinguisher tools first aid kit rain gear flashlight highway warning devices an electric cord with light and sturdy gloves A WARNING originally equipped by the manufacturer to carry addi tional equipment vehicles or cargo will reduce your warranty coverage and may cause personal injury or property damage Modification of your vehicle by addition of racks not A WARNING Do not store or carry Propane containers gasoline or other flammable liquids inside your motor home TIRES Your motor home is equipped with wheels and tires selected to match the capacity specifications of the chassis as designed by the chassis manufac turer Under normal circumstances and with proper tire and chassis maintenance you should receive thousands of miles of trouble free service Some motor homes accumulate relatively few miles and therefore the tire age from the date of manufacture not mileage may become the main tire life determining factor Motor home tires normally
77. ark or any other 75 ohm video source This connector usually carries an RF modu lated signal Park City Water Connection The garden hose style connector that allows you to con nect to an outside pressurized water source Power Shore Cord This is the main power cord coming into your motor home electrical system You connect it to 120 volt AC power at a park or campsite Roadside The left side of the motor home from the driver s point of view So named because at least in North America the road outside the vehicle is usually on this side UVW Unloaded Vehicle Weight The weight of a vehicle with maximum capacity of all fluids necessary for operation of the vehicle but without cargo or accessories that are ordinarily removed from the vehicle when they are not in use UVW does not include occupants and cargo such as water in the vari ous holding tanks VIN Vehicle Identification Number The legal 17 digit vehicle identification number as shown on the vehicle registration certifi cate WARNING A statement or instruction in this Owner s Manual that if not followed could lead to personal injury or death lead to per sonal injury or death 13 2 Privat cach AS STOCTATT KON CELEBRATING OVER 15 YEARS OF MOTOR HOME ADVENTURES Expand your use and enjoyment of your American Coach Motor Home Join the Organization built by hundreds of other owners like yourselves The AMERICAN COACH AS
78. ase refer to the Federal Certification Tag posted in your motor home for the rated GCWR If the Chassis Operator s Owner s Guide Manual equipped with your motor home does not provide specific information on towing weight limits it is strongly recom mended that the towed vehicle or trailer be equipped with a properly installed and oper ating supplemental brake control system that operates in combination with the brakes on your motor home You may be able to increase the weight of any towed load by properly installing on the towed load a supplemental brake control system that operates with your motor home s braking system Even with addi tional brakes you cannot tow more than the GTW or GCWR for the chassis under your motor home Again check the Chassis Operator s Owner s Guide Manual You CANNOT increase the towed weight limit by changing the size of your hitch Properly load what you tow to avoid a vehicle crash Do not attempt to tow something that is too heavy for your chassis When driving in mountainous areas look for and obey highway signs con cerning grades and curves Your driving experience when pulling and stopping a towed unit on mountain roads will be very different from what you experience on level ground State laws in the United States and provin cial laws in Canada vary concerning towing equipment requirements and limits Check the laws in the areas where you anticipate traveling
79. ater 3 Turn water pump switch ON Be sure you have 12 volt DC power Open all faucets individually until water flows steadily then turn them off This will purge any air from the lines 4 Top off water tank with fresh water and allow the system to stand for at least 4 hours 5 Drain the entire system by opening all potable water tank valves plumbing line drain valves and operating faucets 6 Flush the system with potable water Let the fresh water flow through the system for sev eral minutes to flush out the chlorine solu tion 7 After you stop the flushing close the tank valve drain valves and faucets You can now fill the tank with potable water and the system is ready to use Exterior Shower If Equipped A shower fixture is mounted in the exterior util ity compartment The water pump must be ON or city water pressure must be available for the shower to operate 07 3 Plumbing Systems and Holding Tanks Power Water Hose Reel If Equipped The water hose reel uses 12 volt DC power to operate the control panel switch which is located next to the water hose reel Your Owner s Information Package contains detailed operating and maintenance instructions concern ing this system Whole Coach Water Filter System If Equipped The water filter helps provide consistent drink ing water quality to the entire water system The filter cartridge is located in the service panel compartment Your Own
80. ator s Owner s Guide Manual for any instructions sup plied by the chassis manufacturer with respect to this subject J NOTE If your motor home is equipped with a solar battery charger it will trickle charge both house and chassis batteries The battery disconnect switch must be ON for the solar charger to charge the batteries 5 Remove clean and replace roof air condi tioner filter s Cover the air conditioner shroud s 6 To help preserve the tires park each tire on a piece of plywood about 12 inches square 7 Cover the windows on the inside with foil cardboard paper etc to reduce curtain drape and carpet fading 8 Remove batteries in battery powered devices 9 During extended periods of storage gasoline may deteriorate due to oxidation This can damage rubber and other materials in the fuel system It may also clog small orifices Commercially available gasoline fuel stabiliz ers should be added whenever actual or expected storage periods exceed 60 days Follow the additive manufacturer s instruc tions Operate the vehicle regularly during the storage period to mix and circulate the anti oxidant agent throughout the fuel system 10 Check tire inflation pressures every 30 days Maintain maximum rated cold infla tion pressure 11 Check the sealant around all roof floor and body seams and windows Reseal if neces sary See Sealant Renewal section 12 Lubricate all locks and h
81. ay be cleaned from the top of the motor home Use soapy water on the vent cover The screens may be vacuumed or lightly brushed to remove accumulation of leaves or other debris Lubricate the gears and mechanism yearly with a light water resistant grease Folding Chairs If Equipped In some models folding chairs are provided for your convenience Store these chairs in an appropriate compartment when traveling to avoid personal injury or damage Free Standing Furniture If Equipped Your motor home may be equipped with free standing furniture Fleetwood has designed retention hardware which will secure any loose furniture during travel Always secure any furni ture or loose articles before moving the motor home Failure to do so could result in damage to your furniture and motor home as well as result in personal injury or death in the event of an accident or emergency maneuver A WARNING Loose furniture must be secured before travel Failure to do so may result in injury or death in the event of an accident or emergency maneuver A WARNING Do not sit on folding chairs while the vehicle is in motion Personal injury may result MONITOR PANEL The monitor panel allows you to conveniently check the approximate levels in the holding tanks Propane tank and to check battery condi tion s Electrical probes installed in the tanks measure the levels at various points in the tanks NOTE
82. ay soften or smear colors 5 Do not paint over the graphics with clear or any other type of paint 6 Do not let gasoline or other fuels drip or stay on graphics for any length of time If a spill occurs wipe off and rinse with water immediately 7 Do not apply wax over graphics especially if the wax contains any petroleum distil lates Wax that has dried between stripes can be removed by softening it with rub 11 2 Maintenance bing isopropyl alcohol and cotton swabs Be sure to rinse the area after cleaning 8 Be careful when storing your motor home The graphic materials should be protected from prolonged direct sunlight and heat Vinyl Front End Mask If Equipped The front end vinyl mask must be removed peri odically Paint damage may occur if the mask is left on while wet for long periods of time Never store your coach with the front end mask attached The mask is designed for use while traveling Always keep your front end mask clean To better protect your RV s finish wax the area to be covered by your front end mask Windows Doors Vents and Locks Keep moving parts hinges and latches adjusted and maintained Lubricate with a light oil at least once a year Check and tighten the screws holding the windows in place as required Clean screens by gently wiping with a damp cloth or soft flat brush Not all screens are easily remov able and can be destroyed and will probably have to be replaced
83. ded to provide the owner and operator with a general overview of service and maintenance information for the motor home Detailed service and maintenance information may be found in the owner s operator s manuals contained in the Owner s Information Package While the information in this section is intended to establish proper maintenance and inspection procedures there may be times when detailed diagnostic and repair procedures may be required Consult your dealer or an authorized Fleetwood Dealer in these situations EXTERIOR Some exterior parts of your motor home are made of fiberglass The finish on these parts is durable but not indestructible Any material and finish will deteriorate in time Exposure to sun light moisture and airborne pollutants can cause dulling and fading of the finish Generally changes in the finish due to weathering are cos metic they are on the surface of the part and do not affect its strength Weathering can take the form of chalking fading and yellowing The best insurance against these effects is routine maintenance If the finish is not washed and MAINTENANCE waxed thoroughly the surface can deteriorate rap idly The following maintenance guidelines can help you reduce these weathering effects 1 When the motor home is not in use keep the fiberglass surfaces out of the sun or covered with a canvas tarpaulin Avoid using plastic or other nonporous materials which can trap moist
84. dhesives and sealants used in the construc tion of your motor home were developed to remain waterproof under sustained effects of weather and vibration However even the finest materials will eventually dry out and lose their effectiveness Y NOTE Failure to seal could cause serious damage and will affect your warranty coverage Your dealer can perform the resealing inspection and work for you Your dealer also has current information on sealants used in your motor home and can recommend the appropriate sealants for you if you prefer to do this work yourself Always use the recommended sealants Maintenance EXTERIOR SEALANTS Consult your Fleetwood Motor Home dealer for the most current sealant use Windshield Window sealant Roof sealant DOOR WINDOW ROOF COMPONENT AND MOLDING RESEALING Inspect the sealants around windows floors joints and doors at least every three months Also inspect roof vents other roof components moldings at front and rear caps and perimeter molding If any of the following defects are evi dent during inspection the affected areas must be resealed e Sealant cracked or peeling e Void or missing sealant If you find any of the above defects 1 Clean all areas to be resealed with an appropriate cleaner and clean rags 2 Make sure that all areas to be resealed are absolutely dry before new sealant is applied NOTE Do not seal the bottom flange
85. distribution hitch to produce enough force to bend the trailer A frame hitch head assembly hitch receiver or motor home frame when operated over severe bumps and badly undulating road surfaces Contact your weight distributing hitch manufac turer for further information Frame damage resulting from this type of operation may void portions of your warranty If you expect to tow with your motor home there are additional guidelines that you must follow e Do not use a load equalizing hitch if your hitch head receiver rating is below 10 000 lbs capacity It could cause structural damage to the motor home frame compo nents 05 2 On The Road Do not exceed Maximum Tongue Weight as listed on the Federal Certification Tag Heavier tongue weights can change your vehicle s handling and response can cause a vehicle to crash and will restrict your cov erage under the Ownercare Warranty e Do not tow anything weighing more than the GTW listed on the Federal Certification Tag Heavier towed loads can exceed your chassis ability to pull and stop the load and cause a vehicle crash damage the motor home structure or drive train and restrict your coverage under the Fleetwood or chas sis manufacturer s warranty Changing the trailer hitch will not increase the tow capac ity of the motor home Consult the Chassis Operator s Owner s Guide Manual and U S state and Canadian provincial laws for towing weight
86. doors and windows and set the thermostat for desired cool ness Refer to the air conditioner manufacturer s instructions for detailed operating and preven tive maintenance requirements Remember that air conditioners use a large portion of your available electric power Experience has shown that some RV parks may experience reduced power low voltage on days with high heat or humidity commonly referred to as a brown out This condition may result in the air conditioner circuit breaker tripping in your power distribution center This protects your air conditioner motor from damage and is necessary during low voltage conditions This breaker tripping is sometimes perceived as a fault in your motor home but it is a necessary safety valve The heat pump feature will provide 5 600 BTU s of warm air from the ceiling plenum Y NOTE Your motor home is equipped with a ceiling ducted air conditioning system For most efficient operation adjust each vent so that is completely open If you change the vent opening to regulate air flow try not to restrict the vent opening to below 70 open Restricting air flow below this opening will affect the efficiency of the air conditioner TELEVISIONS AND DVD PLAYERS If Equipped All televisions and DVD players are set up to operate on a 120 volt AC power source This source can be from the generator shore cord or inverter When cleaning the television or o
87. dule you should be able to prolong the life and enjoy your RV for many years to come For your convenience a maintenance guideline is presented Options and accessories usually have their own owner user manuals that often contain maintenance instructions Consult these manuals as required Modify any suggested maintenance schedule as use conditions or per formance requires 11 6 Maintenance Wash exterior Wax exterior Lubricate and adjust exterior locks hinges roof vents window mechanisms etc Lubricate power step mechanism Lubricate TV antenna Check all exterior sealants around windows doors sidewall seams windshield lamps all exterior Openings and roof components Re seal if necessary Inspect and clean fuel fired appliance vents Water heater refrigerator furnace Inspect and clean water pump water dispenser and whole coach filters Inspect all hot cold drain plumbing Inspect test and service safety equipment fire extinguisher Propane CO and smoke detectors alarms and GFI receptacles Complete Propane pressure check and system check e Service appliances and equipment refrigerator roof air conditioner furnace generator etc Inspect generator exhaust system Inspect Propane system components Sanitize fresh water tank Clean drapes and interior fabrics Check exterior lamp operation Check slide out room function and s
88. e but are not limited to the following e Before bringing items into the RV check for signs of mold Potted plants root and soil furnishings or stored clothing and bedding materials may also contain mold spores e Regular vacuuming and cleaning will help reduce levels of settled mold spores Additionally detergent solutions and most tile cleaners are effective in controlling mold growth on surfaces e Keep the humidity in the RV below 40 Ventilate kitchens and bathrooms by open ing windows using exhaust fans or run ning the air conditioning to remove excess moisture in the air and to facilitate evapora tion of water from wet surfaces In general windows or doors throughout the RV should be opened periodically to ventilate the RV e Promptly clean up spills condensation and other sources of moisture Thoroughly dry any wet surfaces or material Do not let water pool or stand in or under your RV e Inspect for leaks on a regular basis Look for discolorations or wet spots Repair any leaks promptly Inspect condensation pans refrigeration and air conditioners for mold growth Take notice of musty odors and any visible signs of mold growth Other actions the RV owner can take to prevent moisture issues include the following e Do NOT use unvented Propane kerosene or other unvented combustion heaters e Do NOT cover or close off the floor regis ters if equipped e Check your cooling equipment filter on
89. e dump switch up towards the word open and watch for discharge down the sewer hose The valve will open in 1 2 sec onds and an LED light will come on Do not hold the switch for more than 2 sec onds 3 Allow enough time for the tank to drain completely When the tanks is empty push the rocker switch to the close position Again the valve will open in 1 2 seconds The LED light will go out when the valve is completely closed Run enough water up to five gallons or so into the tank to cover the bottom This will aid the break 04 7 Eagle Tradition and Heritage Information up of solid wastes and reduce pyramid ing of waste material 4 To drain the gray water tank repeat the steps above using the other knife valve This tank is drained last to aid in flushing the outlets and hose The gray water knife valve may be left open in a semi perma nent hookup 5 See the tank flush system instructions in the next section if your recreational vehicle is SO equipped 6 Remove out the sewer hose and cap the outlet 7 Rinse out the sewer hose with fresh water and remove the sewer hose from the dump station 8 Replace sewer or dump station covers A CAUTION The sewer drain valve must be open when using the black tank flush inlet ELECTRICAL SYSTEMS Battery Charging Your motor home is equipped with AGM sealed batteries These batteries do not contain elec trolyte fluid They
90. e motor home by open ing vents windows and doors as well as by oper ating air conditioning if available High indoor temperatures and humidity raise formaldehyde levels when a motor home is to be located in areas subject to extreme summer tem peratures an air conditioning system can be used to control indoor temperature levels If you have any questions regarding the health effects of formaldehyde consult your doctor or local health department 05 19 On The Road CARBON MONOXIDE SAFETY PRECAUTIONS Carbon monoxide is a colorless tasteless odorless gas It is a by product of the burning of fossil fuels gasoline Propane diesel fuel etc The chassis and generator engines furnaces water heater Propane refrigerator and range in your motor home produce it constantly while they are operat ing CARBON MONOXIDE IS DEADLY Please read and understand the following precautions to protect yourself and others from the effects of car bon monoxide poisoning Beware of the symptoms of exhaust gas carbon monoxide poisoning Dizziness Vomiting Nausea Muscular twitching Intense headache Throbbing in temples Weakness and sleepiness Inability to think clearly A WARNING Do not under any circumstances operate any engine or the cooking stove or range while sleeping You would not be able to monitor outsider conditions to assure that engine exhaust does not enter the interior and you would not
91. e to drive or both Axle load is important and it is recom mended that you should load your motor home so that the front axle is loaded to at least 80 of the front GAWR How to Weigh Your Loaded Motor Home Refer to your local telephone directory to find a public weigh station The following procedures will help you determine whether your loaded motor home complete with cargo fluids passengers and driver is within GAWR GVWR and GCWR limits When you arrive at a weigh station the attendant will guide you through the correct positioning of the motor home on the scales Your RV must be weighed fully loaded that is with passengers food clothing fuel water Pro pane supplies etc Any towed vehicle car pickup boat or trailer or item loaded on brackets on the back of the RV such as bikes or motor cycles should also be included in the weighing The following steps are suggested and are illus trated on the following pages 1 Pull onto the scale so that only the front axle is on the platform with the end of the scale midway between the front and rear axles and record the scaled weight 2 Pull forward until the full unit is on the scale and record the scaled weight 3 Pull forward so that only the rear axle is on the scale again with the edge of the scale midway between the front and rear axles and record the scaled weight If the RV has a rear tag axle pull forward so that only the tag axle remains on
92. ealing if equipped Chassis refer to chassis operator s manual Inspect hydronic exhaust system Annual battery replacement for safety detectors alarms is recommended regardless of battery condition Items marked with Require special equipment and or qualified personnel A Each Trip or Monthly E Each Year B Weekly F At Specified Mileage or Interval G At Specified Mileage for Heavy Duty Service A Severe Climate and Full Time Usage C Every 3 Months D Every 6 Months 11 7 This page intentionally blank STORAGE CHECKLISTS The following checklists will help you perform the steps necessary to prepare your motor home for storage Use the checklist that applies to the storage conditions you anticipate These checklists do not include every detail required and you may want to expand them to suit your needs Contact your dealer for addi tional suggestions suitable to your climate and storage conditions particularly extremes of hot and cold Short Term Storage Less Than 30 Days 1 Wash the motor home exterior and under side Hose off accumulations of mud and road salts 2 Thoroughly clean the interior of the motor home including carpets counter tops lavy tub and shower and galley 3 Inflate tires to maximum rated cold pres sure 4 Park the motor home as level as possible front to rear and side to side Block wheels front and rear Put transmissio
93. eas as to exterior Consult the Motor Home Loading section in the On The Road chapter SLIDE OUT ROOMS If Equipped Your new motor home may be equipped with an optional slide out room The slide out room s are designed to provide additional living space A detailed operating and maintenance guide is included in your Owner s Information Package Read all instructions for these systems carefully before operating the slide outs In some installations it may be necessary to slide the driver s seat to the full forward position and place the seat back in the full upright posi tion prior to moving the slide out room in or out to prevent the room from striking or rubbing against the seat back Always exercise caution when operating the slide out room e Always be certain that there is plenty of clearance for your room to safely extend to the full outward position e Remove any other potential obstructions to room movement For operation of the slide out room the follow ing is required e Park the RV and level it for stationary use e Ignition on engine running is mandatory or the system will not operate e Transmission in PARK or in NEU TRAL for diesel products e Parking brake engaged and for diesel prod ucts the air brakes engaged or set Slide out key or switch activated J NOTE Under wet snow weather conditions after retracting the slide out rooms s it may be necessary to towel off moisture from the
94. ecog nizing the danger and practicing common sense safety and maintenance habits Know where your fire extinguisher is located and how and when to use it Read the instructions on the fire extinguisher Remember that portable fire extinguishers are intended for use by the occu pants of a building or area that is threatened by fire They are most valuable when used immedi ately on small fires They have a limited amount of fire extinguishing material and therefore must be used properly so this material is not wasted Fire extinguishers are pressurized mechanical devices They must be handled with care and treated with respect They must be maintained as outlined in any maintenance instructions provided with the device so they are ready to operate prop erly and safely Parts or internal chemicals may deteriorate in time and need replacement Always follow maintenance and recharging instructions provided by the fire extinguisher manufacturer Maintain proper charge in the fire extinguisher Walk around your motor home and identify where all or the emergency window exits are located These window are identified with red handles A WARNING Urethane foam is flammable Do not expose urethane foams to open flames or any other direct or indirect high temperature sources of ignition such as burning operations welding burning cigarettes space heaters or unprotected electric light bulbs Once ignited urethane foams will burn rap
95. ed by the red handles and EXIT label Take time to look and identify where each emergency exit window is located Storm windows should never be installed over emergency exit windows Read and understand these instructions before you need to use them The emergency exit win dow provides an escape route in case the motor home must be evacuated under emergency con ditions To operate the emergency exit window either e Pull the red handle and remove the screen or e Lift the red latch to release the window Slide it completely through the slot so the window swings free When parked be sure the exit window is not blocked by trees or other obstacles REMOTE MIRROR CONTROL Your new motor home may be equipped with power mirrors The driver s control panel also contains controls for the exterior rear view mir ror adjustment and heater if equipped To adjust the mirrors select either LEFT or RIGHT mirror and press the appropriate arrow Activate the mirror heaters by pressing the HEATER control In the event the power mirror option was not selected and added manual adjustment of the mirrors is required to provide a view of the sides and rear of the motor home Mirrors should be adjusted prior to operation of your vehicle in traffic In the event the power mirror can not be adjusted using the power controls the arm may require repositioning in the base Consult the Owner s Manual for the mirrors in the Owner s Informat
96. em See the Storage chapter of this manual Freezing damage is usually extensive and may include a burst water tank split piping and a damaged water pump toilet and water heater If you experience this type of damage repairs can best be made by an authorized Fleetwood Dealer For your safety the shower faucet is equipped with a vacuum breaker device This device is designed to prevent backflow of water into the fresh water system reducing the possibility of contamination of the water supply When the faucet is in the OFF position with the shower hose held above the faucet water will drain out of the vacuum breaker This drainage is not a defect but indicates that the faucet is working correctly Sanitizing the Fresh Water System As approved by the U S Public Health Service sanitize the fresh water tank and piping system whenever the system may have become contam inated has not been used for a period of time or before long periods of storage This will dis courage the growth of bacteria and other organ isms that can contaminate the water supply Use a chlorine fresh water rinse as follows 1 Prepare a solution of 14 cup household liq uid chlorine bleach 5 sodium hypochlo rite to one gallon of water Use one gallon solution for each 15 gallons of tank capac ity 2 Close drain valves and faucets pour the chlorine solution into the exterior fresh water tank filler spout and complete filling at tank with potable w
97. em heat Be sure to inspect your motor homes exhaust system at a minimum of once per year During the inspection the exhaust system should be checked for leaks loose clamps missing or damaged components or other irregularities that have the potential to create an exhaust leak Have your dealer inspect the exhaust system and make the recommended repairs before using your motor home ENGINE TEMPERATURE GAUGES Engine temperature gauges typically have been calibrated to indicate a midrange reading as the normal operating temperature As a motor home owner be aware that the gauge is intended to provide a warning of any rapid change in engine coolant temperature from the normal reading of the gauge rather than an absolute tem perature reading A WARNING IMPORTANT HEALTH NOTICE Some of the building materials used in this recre ation vehicle emit formaldehyde Eye nose and throat irritation headache nausea and a variety of asthma like symptoms including shortness of breath have been reported as a result of formaldehyde exposure elderly persons and young children as well as anyone with a history of asthma allergies or lung problems may be at greater risk research is continuing on the possi ble long term effects of exposure to formalde hyde Reduced ventilation may allow formaldehyde and other contaminants to accumulate in the indoor air Dilution of indoor contaminants may be obtained by ventilating th
98. ement centers When you install a component carefully mark the hole location and drill a 3 16 hole where the rivet is to be located If you need rivets contact your Fleetwood dealer CAUTION Do not use any type of screw to attach items to the interior or exterior walls of your motor home If you want to attach items to the walls you must use expanding head type rivets Rivet quality length and grip range will vary depending on item to be attached Plastic Fiberglass Shower Stall Some cleaners attack the plastic causing it to discolor and become brittle The following cleaners have been tested and approved when mixed with water e Distilled vinegar e Mild dishwasher detergent e Liquid deodorizing cleaner Avoid cleaners that contain any amount of abra sives acetone or MEK methyl ethyl ketone Floors and Carpeting Vinyl flooring requires only washing and periodic waxing Vacuum carpeting regularly and clean it with a quality carpet cleaner Do not use water or waxes mixed with water on the wood floor Wood Floor If Equipped Floors are natural resting places for dust dirt grit and food spills Dirt underfoot causes abra sions Therefore keep the floor clean and use exterior walk off mats at the entry door and e Immediately blot up spills or spots with a damp cloth e Periodically clean the floor with Anderson Quick Kleen Follow the instructions on the container Your wood floor ca
99. end walls CAUTION Never attempt to move your motor home with the slide out room s extended Damage can occur to the slide out or motor home CAUTION In case of a power failure the slide out room can be retracted manually Be sure to understand the opera tion section as explained in the slide out systems Operations Manual in the Owner s Information Package 06 5 Living With Your Motor Home INTERIOR AND FURNISHINGS The materials used inside your motor home have been selected for durability and comfort With reasonable care these materials will stand up under years of recreational living The Maintenance chapter in this manual outlines care requirements for the various upholstery fabrics floor cabinet and wall finishes Dinette Conversion with Built in Table If Equipped To convert the dinette into a bed 1 Remove cushions 2 Lift table reach underneath unlatch and fold the leg s up under the table top or remove the table leg s and if necessary store them between the seats 3 Raise front portion of table several inches to disengage inserts from the wall supports 4 Lower table top to the dinette frame to complete the bed base 5 Slide seat and back cushion into place over the bed base The under seat storage may be reached by raising the cushion platform Dinette Conversion with Free Standing Table If Equipped To convert the dinette into a bed
100. er s Information Package contains detailed operating and mainte nance instructions concerning this system J NOTE This system is not designed for or effective in remov ing or neutralizing bacterial contaminants Insta Hot Drinking Water System If Equipped The Insta Hot drinking water system is tied into the coach drinking water system It will provide instant filtered hot water from the galley water dispenser Your Owner s Information Package contains detailed operating and maintenance instructions concerning this system V NOTE This system is not designed for or effective in remov ing or neutralizing bacterial contaminants WASTE WATER SYSTEM The waste water system in your RV is made up of sinks tub shower toilet plumbing drain and vent lines a gray water holding tank and a black water holding tank The gray tank holds shower tub and sinks where the black tank holds toilet effluent The holding tanks make the sys tem completely self contained and allow you to dispose of waste water at your convenience A flexible sewer hose is required to connect the holding tank outlet to the inlet of an approved waste water dump station or sewer system The drain plumbing is very similar to that used in your home The system is trapped and vented to prevent waste gases from backing up into the RV The drain plumbing is made of plastic and is durable and resistant to most c
101. er hose with fresh water and remove the sewer hose from the dump station Replace sewer or dump station covers 07 6 Plumbing Systems and Holding Tanks Please Practice good housekeeping when e Keep the black water tank knife valve draining wastes at a campsite or disposal sta closed Fill tank to at least full before tion Leave the site in good order Above all do draining Be sure to cover the tank bottom not pollute with water after draining e Use only toilet tissue formulated for use in A CAUTION septic tank or RV sanitation systems e S e Keep both knife valves closed and locked The sewer drain valve must be open when using the i Blaak Ane auch ick and the drain cap tightly in place when using the system on the road e Use only cleaners that are approved for use A C AUTION in septic tank or RV sanitation systems e Use a special holding tank deodorant chem Do not use the same hose you use for filling the ical approved for septic tank systems in the potable water tank or for connection to the city water inlet This is especially true if you the connect the black water holding tank These chemicals quick connect hose to the typical rinsing hoses at aid the breakdown of solid wastes and make most dumping stations Use of a different hose will the system much more pleasant to use Do insure that you will not contaminate your fresh water Sea ak supply not put facial tissue paper ethylene glyco
102. erate the genera tor while sleeping You would not be able to monitor outside conditions to assure that generator exhaust does not enter the interior and you would not be alert to exhaust odors or symptoms of carbon monoxide poisoning Generator Fuel Supply Fuel for the generator is taken from the main fuel tank through a special feeder tube which is higher in the tank than the feeder tube to the motor home engine This arrangement prevents the generator from running the motor home fuel tank dry Propane Generator If Equipped Fuel is provided from a dedicated Propane tank Y NOTE Refer to the generator operating instructions provided in your Owner s Information Package for informa tion before starting the generator Do not start the generator unit with a heavy power load Always wait at least three minutes after starting generator before turning on or plugging in heavy electrical loads such as the roof air conditioner 08 5 Electrical Systems Generator Operations To start the generator 1 Push the control switch to its START posi tion and hold it there while the status indi cator light blinks rapidly indicating preheat Let go when the light comes on continuously indicating that the generator is running and that the starter has been dis connected Depending on how cold it is preheat can take up to 15 seconds extend ing the time that the light blinks A CAUTION Exc
103. eries The battery system must be connected battery dis connect in the ON position for the entry step to operate The entry step will typically extend and retract with the opening and closing of the entry door as controlled by the entry door position switch function is automatic Activating the override switch will move the entry step to the extended position and it will stay there regardless of whether the door is open or closed Regardless of the override switch position activation of the ignition key with the entry door closed will retract the entry step This helps to prevent inad vertently driving off with the entry step extended The switches operate the entry step according to the following table A WARNING Always look and be sure the step is extended before entering or exiting the motor home A WARNING If door is quickly opened and closed without allowing the step to fully extend and lock in the OUT position the step will immediately retract and lock in the UP position Refer to the power step Owner s Manual in your Owner s Information Package for details on maintenance and lubrication Ignition Overdrive Step Switch Switch Position Position Position Action OFF OFF Step extends and retracts with the opening and closing of the door OFF ON Step stays in the extended position regardless of door open or closed position ON ON OFF Step retracts when the door
104. erter compartment The disconnect switch needs to be turned on for normal use of the inverter The switch is intended for motor home storage and will be turned off when the motor home is delivered Failure to turn off the inverter disconnect during motor home storage could result in discharged batteries TO ENSURE FULLY CHARGED BATTERIES START AND RUN YOUR MOTOR HOME AT LEAST ONCE EVERY 30 DAYS THEN RETURN TO STORAGE 08 4 Electrical Systems Power Converter The converter will automatically supply 12 volt DC power when your motor home is operating on 120 volt from the generator or a public utility It also charges the coach and chassis batteries Ground Fault Circuit Interrupter GFCI Bathroom galley and patio 120 volt electrical outlets are protected by a Ground Fault Circuit Interrupter GFCI This device is intended to protect you against the hazards of electrical shocks possible when using electrical appliances in the bathroom or galley or in damp areas Should a circuit or appliance electric shaver hair dryer etc develop a potential shock hazard the GFCI device is designed to disconnect the outlet and other outlets on the same circuit limiting your exposure time Y NOTE If an outlet doesn t work check the GFCI Reset it if necessary If the GFCI continues to trip have the motor home electrical system checked at an authorized Fleetwood Service Center or by a qualified electrician
105. essive cranking can overheat and damage the starter motor Do not crank for more than 30 seconds at a time Wait at least 2 minutes before trying again 2 See the Troubleshooting Guide in RV Genset Operator s Manual located in the Owner s Information Package if the gen erator does not start after several tries To stop the generator 1 Run the generator at no load for a few min utes to allow the engine to cool down and then push the control switch briefly to its STOP position Generator Operating Safety Precautions Read and understand the generator operating maintenance and safety instruction furnished in your Owner s Information Package e Do not smoke or use an open flame near the generator unit or fuel tank e Do not use generator ventilation air for heating any space e Check engine fuel lines Fuel leakage in or around the compartment is an extreme fire hazard Do not use the generator until fuel leaks are repaired e Be aware of exhaust gas carbon monox ide poisoning symptoms Refer to the sec tion on Carbon Monoxide Safety Precautions in the On The Road chapter e Check the generator exhaust system after every usage and whenever the system may have been damaged and repair any leaks or obstructions before further operation Disconnect the battery ies before perform ing any maintenance on the generator Allow the generator to cool before performing any maintenance e Do not use
106. g and maintenance instructions concerning the system A CAUTION The rear view video monitor system provides a gen eral view of the road and objects to the rear of the motor home Your perception of this view and the rela tionships of objects to the motor home and each other will be different from that seen in a rear view mirror Light conditions and the adjustment of the screen controls will also affect your perception Always use the side mounted rear view mirrors with the video monitor system J _NOTE Be careful not to scratch the monitor or camera lenses when cleaning Use only household glass cleaner and a soft cloth Wipe gently and dry thoroughly Also do not spray glass cleaner directly on the monitor lens located inside your vehicle because the cleaner could leak inside the unit and cause damage EXTERIOR SIDE CAMERA SYSTEM If Equipped Refer to Owner s Information Package for operating instructions GLOBAL POSITIONING SYSTEM NAVIGATION GPS Your motor home is equipped with a computer The computer will operate the Global Positioning Navigation System The motor home will have two color display screens One is located in the dash and the other monitor is located in the control panel display center Your Owner s Information Package contains detailed operating and maintenance instructions concerning the system A WARNING Programming the GPS navigation system while you
107. g injured in a collision greatly increases For your safety your vehicle has combination lap and shoulder belts for the driver and front seat passenger and lap belts without retractors in all other designated seating positions Always drive and ride with your seatback upright and the lap belt snug and low across the hips to reduce the risk of serious injury to the abdomen or neck that could be caused by slid ing under the safety belts in a collision Never let a passenger hold a child on his or her lap while the vehicle is moving The passenger cannot protect the child from injury in a colli sion Refer to sections on Safety Restraints for Children and Safety Belts for Children Never use a single belt for more than one person or across more than one seating position This greatly increases the risk that one or both of the people will be injured in a collision Each desig nated seating position in your vehicle has a spe cific seat belt assembly which is made up of one buckle and one tongue that are designed to be used as a pair Combination Lap and Shoulder Belts While your vehicle is in motion the combination lap and shoulder belt adjusts to your movement However if you brake hard corner hard or if your vehicle receives an impact the lap and shoulder belt locks and prevents you from moving A WARNING Use the shoulder belt on the outside shoulder only Never wear the shoulder belt under the arm Never sw
108. gnment checked and adjusted if necessary To help pre vent uneven tire wear check the front end align ment periodically Please note that front end alignment after retail delivery is the owner s responsibility and is not covered under the warranty Example FLEETWOOD MOTOR HOMES OF PLAN APPROVAL NO F LN MFD ID NO DATE OF MFR MO Located on the left of the main entry door or on exterior left front side of the motor home F I N Fleetwood Identification No 01 3 Introduction Excessive or abnormal tire wear may indicate worn or misaligned suspension or steering com ponents unbalanced or improperly inflated tire s or some other tire suspension problem Alignment can be affected by worn steer ing suspension parts or road hazards such as hit ting a curb pothole railroad track etc Improper alignment can cause tires to roll at an angle and wear unevenly It may also cause the vehicle to pull to the right or left Out of balance tires will not roll smoothly and will cause annoying vibrations and uneven tread wear such as cupping or flat spots If you see uneven tire tread wear or if the vehicle ride comfort decreases the tires may need to be bal anced Do not confuse road imperfections transmitted from the tires through the suspen sion and structure into the motor home Often times this is perceived as a tire balance issue See the Chassis Operator s Owner s Gu
109. have a life of 5 7 years depending on mileage However Fleetwood recommends peri odic tire inspection by a reputable tire dealer regardless of tread depth J NOTE When parking your motor home for an extended time in storage or camping you can extend tire life by parking each tire on a piece of plywood approxi mately 12 inches square Tire Inflation For safety and maximum tire life vehicle speeds must be proper proper inflation pressure must be maintained and tread depth and wear must be monitored Properly inflated and maintained tires also contribute to overall motor home sta bility and safety Refer to the tire section in your Chassis Operator s Owner s Guide Manual or any tire manufacturer s information that may be provided in your Owners Information Package for information on maintenance and tire care If no information is provided please contact your local tire manufacturer s location for advice The maximum cold inflation pressures are stated on the tire sidewall The recommended maxi mum tire inflation pressure for this coach is shown on the Federal Certification Tag located on the sidewall near the driver s seat To maxi mize tire performance consult with the tire manufacturer s guidelines or Chassis Operator s Owner s Guide Manual for recom mended tire inflation pressure J NOTE The tire pressures on your motor home were adjusted at the factory to the tire pres
110. hemicals All drain plumbing except the toilet connection ter minates in the gray water holding tank and drains directly into it Toilet Your RV is equipped with a marine type toilet The flushing mechanism whether a foot oper ated pedal or a hand operated lever allows a valve in the bottom of the bowl to open permit ting the contents to be flushed into the black holding tank A stream of water under pressure from the RV s water system swirls around the bowl cleaning it and flushing the contents into the holding tank Most models have two levers each working independently of the other so the bowl can be filled with water prior to use In order to help prevent hard deposits from building up within the black tank and help reduce unwanted odor it is recommended to always keep water in the tank When empty after a tank discharge flush the toilet several times in order to introduce about five gallons of water It is highly recommended that a deodorizing product should be used for the black tank after each discharge at a dumping station This will help control unwanted odors Ensure that the black tank sewer drain system is always closed and only opened when draining at a dump station Never allow your black tank system to dry out unless it has been thoroughly cleaned sanitized and rinsed first For additional information please refer to the toilet operating manual in your Owner s Information Package
111. hild seat we recommend using a tether whenever one is required or available Your motor home may be equipped with a child seat top anchorage tether strap anchorage point in the forward passenger seat location You can visually identify the anchorage hard ware by inspecting the lower rear of the passen ger or secondary seat A small metal anchorage loop will be present which will allow the tether strap hook to engage see Illustration 1 To use with the seat in position drape the tether strap over the seat back and down see Illustration 2 Attach the tether strap hook to the tether anchorage point and tighten the strap according to the child seat manufacturers instructions Make sure the strap is not twisted and that the forward facing seat is always posi A WARN l NG tioned upright and locked in the forward facing position when the motor home is in motion An incorrectly anchored tether strap could lead to seat failure and injury to the child In a collision the seat could come loose and allow the child to crash into the inside of the vehicle or other passengers or even be thrown from the vehicle Use only the speci fied anchor positions to secure a child restraint requir ing top tether strap s Illustration 2 AIR BAGS lf Equipped Air Bag Supplemental Restraint System SRS If your RV is equipped with Air Bag Supple mental Restraint System SRS please refer to your Chassis Operator s Ow
112. ide Manual for more information AFTER MARKET STEERING AID DEVICES Fleetwood does not sanction or condone the installation of any steering aid device that is not approved by our chassis manufacturer s Any add on device of this type may void the chassis manufacturer s warranty on the item or items affected WARNINGS TERMS AND CONCEPTS FOR SAFE OPERATION OF YOUR MOTOR HOME Vehicle Crash Like any other vehicle you may drive your motor home can be involved in a vehicle crash including a rollover The motor home will be damaged and you and others can be injured or killed Drive defensively at all times DO NOT drive if you are tired have been drinking alcoholic beverages are under the influence of any controlled substance or are taking any medication or drugs that may impair your sight hearing judgment or coor dination Pull off the road and park in a safe area until you can drive safely Vehicle Handling Your motor home is longer wider and higher than a typical car or truck you may be accustomed to driving Keep this in mind as you become familiar with driving your motor home New motor home own ers should take special care to learn the driving and handling characteristics of your vehicle in safe and familiar surroundings The distribution of the weight of your motor home is designed so it will handle safely while being driven e When loading the motor home balance the load front to rear and side to side
113. idly releas ing great heat and consuming oxygen very quickly In an enclosed space the resulting deficiency of oxy gen will present a danger of suffocation to the occu pants Hazardous gases released by the burning foam can be incapacitating or fatal to human beings if inhaled in sufficient quantities 06 12 Living With Your Motor Home Fire Safety Precautions In addition to instructing occupants on what to do in case of fire and holding fire drills periodi cally consider these fire safety suggestions e If you experience a fire while traveling maintain control of the vehicle until you can safely stop Evacuate the vehicle as quickly and safely as possible e If you experience a fire while camped evacuate the vehicle as quickly and safely as possible e Consider the cause and severity of the fire and risk involved before trying to put it out If the fire is major or is fuel fed stand clear of the vehicle and wait for the fire department or other emergency assistance e If your RV is damaged by fire do not move or live in it until you have had it thoroughly examined and repaired Just as in your home included below are some common sense tips to help prevent a fire inci dent from occurring e Never leave unattended food cooking on the stove or in the oven e Never smoke in bed or leave cigars cigarettes unattended e Keep candles or any open flames away from curtains fabrics walls and ceiling
114. ience a flat tire Summon professional help through your auto club travel service or a local truck service facility Your motor home is not equipped with a jack or other lifting device Do not attempt to lift the motor home with a jack Consult the Chassis Operator s Owner s Guide Manual for addi tional information on tire inflation and proper torque 05 12 On The Road A WARNING Wheels and tires equipped with your motor home are extremely heavy and may weigh 100 pounds or more Do not attempt to remove the spare tire if equipped unless you are capable of handling the weight A WARNING To avoid personal injury and or property damage if a blowout or other tire damage occurs obtain expert tire service help Do not attempt to change the tire yourself SEATS AND SEAT BELTS Seat belts help to restrain you and your pas sengers in case of a collision In most states the law requires their use Seat belts provide the best restraint when the seat back is upright e the occupant is sitting upright not slouching e the lap belt is snug and low on the hips e the shoulder belt is snug against the chest e the knees are straight forward A WARNING Make sure that you and your passengers including pregnant women wear safety belts Be sure that lap belts fit snugly and as low as possible around the hips If safety belts are not used properly the risk of you or your passengers bein
115. if the voltage falls below 11 5 volts 2 Start the auxiliary generator automati cally in response to air conditioning requests The AGS continuously monitors the ther mostat of the air conditioning system and starts the auxiliary generator if the temper ature rises to the preset level requiring con ditioning Main Features Easy to use push button operation controls all functions of the AGS Time is indicated to the hour by an internal real time clock Quiet time periods can be entered in hours to prevent automatic operation of the aux iliary generator during inappropriate times Hours may be set either for AM or PM A Time Zone indicator is provided for easy changing of local time when traveling J NOTE For detailed information on how to use the Automatic Generator Start Control System see the Owner s Information Package Power Cord Reel If Equipped The power cord reel allows you to conveniently extend and retract the power cord shore cord where 120 volt AC service is available Your 08 7 Electrical Systems Owner s Information Package contains detailed operating and maintenance instructions concern ing this system Y NOTE Do not cut or alter the cable in any way Do not remove the ground pin in the cable connector or defeat the ground circuit in the motor home ELECTRICAL WIRING DIAGRAMS Because of the many model floor plans and option variatio
116. ilate your motor home with fresh air and the detector alarm will shut off Do not discon nect the battery Replace the battery once a year or immediately when the low battery BEEP signal as described in the operating instructions sounds Check the operation of your Smoke Detector Alarm by depressing the test but tom a minimum of once per month For fur ther instructions regarding the Smoke Detector Alamr consult you instruction manual located in the Owner s Information Packet 06 13 Living With Your Motor Home If the smoke detector alarm fails to operate with new batteries replace it with a new unit available through an authorized Fleetwood Dealer 06 14 PLUMBING SYSTEMS AND The plumbing systems in your motor home are constructed of durable thermoplastic materials Holding tanks and piping components are strong lightweight and corrosion resistant Holding tanks are of three types e Fresh Fresh potable water e Grey Lavy shower effluent e Black Toilet effluent It is recommended to discharge as many fluid tanks as practical before driving FRESH WATER SYSTEM Fresh potable water is available from either an external city water hookup or on board storage External Fresh Water Hookup The external system is pressurized by the water system at an RV park or city water supply The connection is located in the utility compartment on the rear left side of the motor home To connec
117. ile dolly or other towed load The weight label on your hitch receiver provides the maximum trailer weight rating and the maxi mum tongue weight rating It is important that these ratings not be exceeded Consult with your dealer or towing equip ment trailer supplier to determine the correct type of hitch head assembly hitch ball and other tow equipment you should use for towing and leveling the load you intend to pull If you intend to tow take advantage of reading and studying literature that is available from vehicle manufacturers the National Highway traffic Safety Administration equipment manu facturers trade associations and publica Safety Chain Weight Carrying Hitch Head Assembly Weight Distributing Hitch Head Assembly tions books about how to tow A WARNING Failure to understand and follow these guidelines as presented in this section could result in damage to the motor home frame or body could cause unstable driv ing and handling characteristics and will restrict your warranty coverage Dinghy Towing When a motorized vehicle is towed behind a motor home with all four tires on the ground the towed vehicle is often referred to as a dinghy Vehicle manufacturers produce tow able cars and trucks that are designed to be capable of being towed behind a larger vehicle such as a motor home with all wheels down Caution should be exercised when selecting a vehicle for dingh
118. iliary Start switch on the instrument panel 3 Start the chassis engine with the ignition switch 4 Hold the auxiliary start switch for at least 30 seconds after motor starts before releas ing 08 3 Electrical Systems To use the Auxiliary Start System to start the generator 1 Press and hold the Auxiliary Start switch on the instrument panel 2 Press the Generator Start switch until the generator is running 3 Release the Auxiliary Start switch 120 VOLT SYSTEM This system provides grounded 120 volt AC electrical service for appliances such as air con ditioners TV microwave ovens etc This system includes e the generator e the main electrical power cord shore chord e charger and inverter e residential refrigerator Your motor home is equipped with a heavy duty power cord It is commonly called the shore cord This cord is used to connect to external 120 volt AC service The cord and connector is molded together to form a weatherproof cable assembly Do not cut or alter the cable in any way Do not remove the ground pin in the cable connec tor or defeat the ground circuit in the motor home To connect the power cord to external service turn off both the circuit breakers at the external service and the motor home power distribution panel push the plug straight into the receptacle A WARNING Do not operate the 120 volt electrical system without a proper ground Electrocution or
119. in areas i e dry grassy fields where dry conditions exist underneath the vehicle as a fire may result DO NOT operate the Hydro Hot inside an enclosed building Operating the Hydro Hot diesel burner or electric heat ing element without the 50 50 solution of water and antifreeze will cause serious damage to the heater The heater must be shut OFF when refueling J NOTE For more information on the Hydro Hot System see Owner s Information Package RANGE The Propane oven and burners are operated with Propane The basic operation is the same as the range in your home This warning label has been located in the cook ing area to remind you to provide an adequate supply of fresh air for combustion Unlike homes the amount of oxygen supply is limited due to the size of the recreational vehicle and proper ventilation when using the cooking appli ances s avoids dangers of asphyxiation It is especially important that cooking appliances not be used for comfort heating as the danger of asphyxiation is greater when the appliances is used for long periods of time Refer to Lighting Propane Appliances section in the Propane System chapter of this manual A WARNING It is not safe to use cooking appliances for comfort heating Cooking appliances need fresh air for safe operation Before operation 1 Open overhead vent or turn on exhaust fan and 2 Open window FAILURE TO COMPLY COULD RESULT IN D
120. in your motor home A green light on the detector alarm front panel indicates that the detector alarm has power Test the leak detector alarm each time the motor home is relocated and set up for use Detailed information for the leak detector alarm can be found in the Owner s Information Package Testing Procedure 1 Hold a butane fueled pocket lighter near the sensor 2 Open the lighter valve without striking a flame for 3 seconds 3 The leak detector alarm should respond within a few seconds 4 Press the mute button to reset the alarm 5 Lightly fan the area around the detector alarm to insure complete dispersion of the Propane from the lighter and to prevent another sounding of the alarm 09 3 Propane System 6 A mute button allows you to temporarily quiet the alarm for 60 seconds after it has been set off or after testing 7 If the alarm does not sound during a test or if the green indicator light is not visible see your dealer or an authorized Fleetwood Dealer There are no batteries or user serv iceable parts inside the unit A WARNING If your motor home is equipped with battery discon nect devices the Propane leak detector alarm will not function if battery disconnect s are OFF NOTE The detector alarm draws enough current to dis charge your battery Remember to turn off the chas sis and house battery disconnects if you are not using your motor home
121. ing it around the neck over the inside shoulder Failure to follow these precautions could increase the risk and or severity of injury in an accident To fasten the belt pull the lap shoulder belt from the retractor so that the shoulder portion of the belt crosses your shoulder and chest Insert the belt tongue into the proper buckle until you hear a snap and feel it latch For more details on seat belt usage see Manufacturers Usage Manual To tighten the lap portion of the belt pull up on the shoulder belt until it fits you snugly The lap portion belt should rest as low on your hips as possible A longer lap and shoulder belt assembly is available and is a direct replacement for the driver and front passenger positions The longer lap and shoulder belt is made and tested to the same standards as the original belt This belt assembly can be purchased and installed at any authorized Fleetwood motor home dealer 05 13 On The Road Safety Belt Maintenance Check your safety belt system periodically to make sure that it works properly and isn t dam aged If the webbing shows any wear nicks or cuts have it examined by a qualified technician to determine if replacement is necessary Always have your safety belt system checked after a collision SAFETY RESTRAINTS FOR CHILDREN In most states you are required by law to use safety restraints for children If small children ride in your vehicle you must pu
122. inges as described in the Maintenance chapter 13 Remove high grass or weed growth if coach is parked on dirt WINTERIZATION Thoughtful planning and preparation for the winter season can help eliminate equipment fail ures and breakdowns and can extend the life of your motor home and its systems Your dealer can advise you concerning specific winterization procedures and products for your climate area or the areas through which you will be traveling Your dealer may also provide winterization service for all appliances and systems in the motor home The following is a check list if you prefer to perform these procedures yourself 1 Check engine coolant level and antifreeze protection Drain and flush engine cooling system and add antifreeze per the chassis operator s manual 2 Service and winterize the generator as out lined in the generator operating manual included in your Owner s Information Package 12 2 Storage 3 Winterize the Propane system Your Propane dealer or service station will per form this for you 4 Winterize all appliances as outlined in the individual operator s manuals 5 Remove snow accumulations as often as pos sible Water System Winterizing Read this section completely before performing winterization A CAUTION Draining the water system alone will not provide ade quate cold weather protection If the motor home is to be unheated during below freezing temperatures
123. ion Tag This tag is located on the interior side wall by the driver s seat Other information regarding tires and vehicle weights is also included on this tag The amount of air pressure you need to use depends on the weight of your fully loaded vehicle So you cannot determine your correct air pressure unless you know your vehicle s actual weights Underinflation When an underinflated tire is run at normal high way speeds it flexes too much and builds up heat This heat damages the inner liner casing and outer sidewall of the tire If not remedied quickly the tire will be irreparably damaged In extreme cases the sidewall of the tire is destroyed both from the excessive heat it endured due to the weight of the vehicle pressing on the tire casing without the cushioning load carrying effect of the correct air pressure and the crush ing cutting action of the wheel as it rolls on the underinflated sidewall According to guidelines put out by the Rubber Manufacturers Association RMA any tire that has been run at less than 80 of recommended air pressure for the load it is carrying should be inspected for possible damage When one tire in a dual configuration comes out of service due to underinflation damage the other tire in the dual configuration should be inspected immediately If the unserviceable tire 05 11 On The Road was underinflated that means the serviceable tire was carrying more and more of the lo
124. ion packet for adjustment information SUN VISORS If Equipped Sun visors at the driver and passenger positions swing down and are adjustable to provide relief from glare and bright sun Your motor home may also be equipped with side shades mounted on the side windows that can be adjusted to suit driving 06 3 Living With Your Motor Home conditions Swivel tension may be adjusted with a screwdriver at the tension adjusting screw POWER SUN VISORS If Equipped Your motor home may be equipped with optional power sun visors The driver s control panel contains controls for the up down opera tion for both left and right driver and passen ger sun visors PULL SHADES If Equipped To Lower shades Gently pull the shade down to the desired height To Raise shades Gently pull the bottom of shade until the spring tension from the roller is felt allow ing shade to raise to desired height Day Night Shades If Equipped The day night shades are dual purpose window covering that provide privacy at night and light control during the day To Lower shades Using both hands gently pull down on the lower bar to expose the sheer fabric for daytime light control For use at night pull on the upper bar to unfold the privacy curtain To Raise shades Using both hands gently raise the upper bar allowing the sheer fabric to fold then raise the lower bar allowing the privacy curtain to fold MINI BLINDS If Eq
125. ire a vent to the outdoors Check 06 9 Living With Your Motor Home the vents periodically to be sure they are not blocked 6 If you operate or use vaporizing inhalers or similar devices always pro vide adequate ventilation CAUTION Do not heat the RV interior with the range or oven Open flames add moisture to the interior air Do not use an air humidifier inside the RV Water put into the air by the humidifier will increase condensation A WARNING Never use open flame Propane or kerosene burning heaters indoors These devices release water into the air and the exhaust gases contain poisonous sub stances A WARNING Do not cover emergency exit window s This window must be left accessible at all times for emergency exit To increase ventilation 1 Use the kitchen and bath exhaust fans if equipped when cooking or bathing Let them run for a while after a bath or meal 2 Ventilate with outside air Partially open one or more roof vents and or windows to provide circulation of outside air into the interior While this ventilation will increase furnace heating load it will greatly reduce or eliminate condensation Even when it is raining or snowing out side air will be far drier than interior air and will effectively reduce condensation 3 Do not tape windows or doors closed This will prevent any air movement and will make the condensation problem worse 4 Ve
126. issions standards They are sometimes sensitive to fuel types and blends particularly fuels blended for certain altitudes and climates Fuel suppliers provide customers with the correct fuel for their location and seasonal conditions Sometimes though fuel blended for winter is supplied during summer months To determine which fuel your vehicles uses check the fuel fill door or adjacent surrounding area for a federally mandated sticker This sticker will specify the required fuel for you vehicle API Refueling Advisory The American Petroleum Institute API offers the following consumer advisory and safety guidelines on vehicle refueling to help con sumers avoid potential problems with refueling and static electricity One of many possible causes of static electricity build up is reentering your vehicle during refu eling particularly in cool or cold and dry cli mate conditions This can cause a build up of static electricity similar to shuffling your feet on the carpet when the air in your home is dry If you return from your vehicle interior to remove the filling nozzle without discharging the static build up in rare circumstances a brief flash fire 05 18 On The Road could occur at the filling point if the static dis charges and the resulting spark ignites fuel vapors around the fill spout A simple precaution to help avoid this potential problem is to stay near the vehicle s fueling point Do not get back int
127. ker switch on the panel 3 Turn on a light or any 12 volt appliance The battery must be checked with a load 4 Read battery condition on the indicator A WARNING The systems in this coach are not designed to be used for any life support applications In the unlikely event a system in this coach should malfunction or fail to operate it is possible any connected appli ances including life support equipment may also fail resulting in potential medical complications EFFECTS OF PERMANENT OCCUPANCY Condensation and How to Control It You need to understand how to properly manage and control the humid conditions and condensa tion that you may experience RVs are much smaller than a house and are tightly built This means that the interior air will become saturated with moisture more quickly than in a typical house The routine activities of a few people can put a lot of water into the air In cold weather this moisture may become visi ble as condensation Condensation happens naturally Just as mois ture collects on the outside of a glass of cold water during humid weather moisture can con dense on the inside surfaces of your RV during cold weather when the humidity of the interior air is high Water vapor will condense on the inside of the windows and walls In really cold weather frost or ice may appear It may also condense out of sight within the walls or the ceiling If enough water collects in
128. l based or other automotive antifreeze femi nine hygiene products or household toilet cleaners in the holding tanks Holding Tank Care Since holding tanks don t rely on any sophisti e Do not put anything solid in either tank cated mechanical devices for their operation that could scratch or puncture the tank they are virtually trouble free The most com mon problem is also an unpleasant one clog ging You can minimize the chances of clogging by keeping the following considerations in mind If the drain system does get clogged e Use a hand operated probe to loosen stub born accumulations WATER FILL WATER HEATER LAVATORY SINK WATER SYSTEM DRAINS EXTERIOR SHOWER i BYPASS WATER PUMP FILTER S BE sa nres gt w Typical Hot and Cold Diagram 07 7 Plumbing Systems and Holding Tanks e Seriously clogged P traps may require disas Cold Weather Usage sembly Be careful not to overtighten when reassembling The holding tank s area is heated through ducts from the furnace To prevent holding tank freeze up the furnace thermostat should be set to main Do not use motorized drain augers tain a minimum of 35 degrees Fahrenheit in the e Sometimes the holding tank valve will get holding tank s area Be aware that exposed drains clogged In this case a hand operated auger may freeze quickly may be necessary Be ready to close the valve quickly once the clog is cleared
129. l cause both tires to fail Tire Replacement Replacement tires must be the same size type and tread depth per axle and have at least the same weight carrying capacity as the original equipment Tires supplied by various manufac turers of the same size and rating may not have the same weight carrying capacity and maxi mum cold inflation pressures Consult your tire dealer The original equipment wheels and tires supplied on your motor home have weight car rying capacities to support Gross Axle Weight Ratings GAWR as stated on the Federal Certification Tag attached in the driver s com partment If You Get a Flat Tire In case of sudden tire failure NOTE The motor home will tend to pull toward the side with the flat tire e Apply the accelerator to maintain direc tional stability then gradually release the accelerator e Use moderate brake pedal pressure Do not pump the brake The vehicle is equipped with Anti lock Brakes ABS which will help control braking e Firmly hold the steering wheel while avoiding abrupt steering inputs and move slowly to a safe place e Park ona firm level surface e Turn off the ignition e Set the parking brake e Turn on the hazard flasher system e Ensure your passengers are safely located and children monitored e Get professional roadside assistance Changing a Flat Tire Even with good tire maintenance and normal driving you may exper
130. l not be responsible for front end alignment after this predelivery inspection has been performed For warranty service you should return your motor home to the selling dealer If this is not possible you may contact any other authorized Fleetwood motor home dealer The service department at any of the locations listed at the back of this manual can help you find a dealer in your area If for some reason a problem is not handled to your satisfaction 1 Discuss any warranty related problems directly with the manager and or owner of the dealership giving them an opportunity to help the service department resolve the matter for you 2 If a problem arises that has not been resolved to your satisfaction by your local dealer contact Fleetwood Owner Relations The locations are listed in the back of this manual Please contact the one nearest you 3 We sincerely believe that your dealer and the factory representative will be able to solve any problem which might arise If their combined efforts are not satisfactory please send a letter describing the circumstances to American Coach Owner Relations 1420 West Patterson Street Decatur Indiana 46733 Please include the brand name and serial number of your motor home The serial number is located on the identification tag on your warranty card 4 If you wish to call for assistance please use this toll free telephone number American Coach Owner Relations 1 800 435 7345
131. leveling system are located in the driver s compartment A detailed operating and maintenance guide is included in your Owner s Information Package Read all instructions for this system carefully before operating the system A WARNING The leveling system is designed as a leveling system only Do not use the system as a jack or with a jack Do not attempt to raise the tires off the ground The system should be used to raise the recreational vehi cle to the lowest level position possible AIR DUMP SYSTEM The suspension system air bags must be deflated before the motor home is leveled with the level ing system An air dump system is installed on the suspension system to drain the air from the suspension air bags A dual position switch on the instrument panel controls the air dump system When the air bags are deflated the motor home will settle slightly from normal ride height and you may hear a sound of rushing air This is normal After the air bags are completely deflated the leveling system can be operated Be sure to set the air dump switch back to nor mal position after retracting the leveling system and before attempting to drive away POWER ENTRY STEP If Equipped The power entry step is controlled by a magnetic entry door position switch the engine ignition switch and by an override switch located near the entry door Power for the entry step is sup plied by the chassis battery or batt
132. limits and for guidelines for installing supplemental braking systems that operate with your motor home s brakes Towing equipment to consider includes a weight distribution system a sway control system a brake controller and a supple mental brake control system The weight of your towed load in comparison to the tow ing capacity of your motor home should be evaluated during this consultation Installation of tow equipment must be per formed by a competent installer Make sure the installation follow the tow equipment manufacturer s instructions A WARNING Do not exceed the rated load of the motor home or the rated load of any axle Exceeding the GVWR GAWR GTW or GCWR of your motor home can cause handling problems a vehicle crash damage your motor home and void your warranties The way your motor home handles and responds will be affected by the way the towed unit is loaded If the tongue weight is too light in rela tions to the GTW handling and response will change and your motor home will operate less safely Careful load planning and safe experi mentation with different loading patterns in what you are towing can avoid this risk and make your driving and towing experience safer and more enjoyable Your motor home is equipped with some of the equipment required to tow a trailer automobile dolly or other towed load The equipment supplied with your motor home is called the hitch receiver This com
133. loaded weight of this motor home with its towed trailer or towed vehicle Towing and braking capacities may be different Refer to Fleetwood and the chassis manufacturer s manuals for complete information GVWR Gross Vehicle Weight Rating is the maximum permissible weight of this fully loaded motor home The GVWR is equal to or greater than the sum of the Unloaded Vehicle Weight plus the Occupant and Cargo Carrying Capacity LCCR Load Carrying Capacity Reduction is the amount the OCCC is reduced due to vehicle weight added by the dealer between vehicle certification and first retail sale MGTW Maximum Gross Towed Weight is the maximum loaded weight of a trailer or towed vehicle this motor home with equipped hitch has been designated to tow Maximum Gross Towed Weight cannot be increased by changing the trailer hitch MTW Maximum Tongue Weight is the maximum permissible downward force exerted on the hitch ball by the towed vehicle coupler OCCC Occupant and Cargo Carrying Capacity is the available weight capacity for occu pants and cargo however dealer options may reduce this by the LCCR UVW Unloaded Vehicle Weight is the weight of a vehicle with maximum capacity of all fluids necessary for opera tion of the vehicle but without cargo or accessories that are ordinarily removed from the vehicle when they are not in use UVW does not include occupants and cargo such as water in the various holding tanks
134. lve when the protective cap is installed on the pipe Always drain the tank into an acceptable sewer inlet or dump station Drain the holding tanks only when they are at least 3 4 full If necessary fill the tanks with water to 3 4 full This provides sufficient water to allow complete flushing of waste material into the sewer line Whenever possible drain the holding tanks before traveling Wastewater and sewage in the holding tanks reduces the carry capacity of the motor home See the Motor Home Loading chapter During extended or semi permanent hook ups to sewage systems waste materials will build up in the tank and cause serious plugging If the tank valves are continuously open In these cases keep the valve closed until the tanks are 3 4 full and then drain into the sewage system The holding tank drain valve outlet is to be used with a removable termination fitting that locks onto the outlet with a clockwise twist Clamp the sewer hose drain to this fitting A protective cap should remain in place when you are not draining the tanks To drain the holding tanks 1 Attach the sewer hose to the holding tank outlet Insert the end of the hose into the sewer or dump station inlet pushing it firmly far enough into the opening to be secure In some cases adapters may be necessary or required between the line and the inlet Arrange the sewer hose so it slopes evenly 2 Drain the black water holding tank first Push th
135. mbing chapter 11 Apply silicone lubrication to the knife valve actuator rod s 12 Be sure ALL water from ALL plumbing fixtures has been drained 13 Close holding tank drain valves 14 Pour approximately five gallons of approved non toxic antifreeze into the fresh water tank 15 Turn the water pump master switch ON 16 Open each water faucet run the water pump and let about a cup of antifreeze solution flow continuously through each faucet Close each water faucet 17 Flush the toilet until the antifreeze solution flows continuously Release flush mecha nism 18 Your vehicle is equipped with a water heater bypass Winterize the hot water lines by opening each hot water faucet allowing antifreeze solution to flow continuously and then close each faucet This will require considerably more antifreeze solu tion and you may choose to do this step before winterizing the cold water lines so you can recycle the solution Y NOTE When filling the plumbing systems with antifreeze be sure to open and operate all fixtures and valves allow ing the antifreeze solution to flow freely 12 3 Storage 19 Pour one cup of antifreeze solution down each drain 20 Install all protective caps Water tank fill City water inlet cap Waste tank drain outlet cap 21 If your refrigerator is equipped with an ice maker winterize it as follows 1 Shut off the water supply valve to the ice make
136. n be damaged by a number of things including e Water Do not wet mop the wood floor e Oil soap or other waxes and polishes e Ammonia cleaners e High heel shoes Tile Floor if Equipped To clean tile areas use a clean sponge mop with a mild detergent in hot water Avoid abrasive cleansers Engine Access The top of the engine may be accessed from inside the motor home for service by lifting or removing the engine cover A WARNING The interior engine cover is heavy Use care when opening or closing the cover Maintenance A WARNING When installing the engine cover be sure the cover is fully seated on the gasket seal and secured by the clamps Do not allow insulation carpeting or other material to interrupt the seal between the cover and the engine compartment If the engine cover is not installed correctly engine exhaust gases could leak into the passenger compartment creating a safety hazard If the engine must be run with the engine cover off for maintenance purposes be sure the vehi cle interior is adequately ventilated GENERATOR FILTERS Consult your Fleetwood Motor Home dealer or see the GenSet Service and Parts Directory in your Owner s Information Package Oil Filter Fuel Pump Filter Element Fuel Filter ACRYLIC ASSIST HANDLES If Equipped Do not use any cleaners that contain ammonia petroleum ammonia based or petroleum based products Most glass cleaners
137. n be supported Mold has existed for millions of years and human beings have coexisted despite their exposure to mold and mold spores If the proper conditions are present mold can and will grow in your recreational vehicle Most RV owners are familiar with mold growth in the form of bread and cheese and on bathroom tile In order 06 10 Living With Your Motor Home to grow mold requires a food source These food sources might be supplied by items found in the RV such as fabric carpet wallpaper or building materials i e wood and insulation Also most mold growth requires a temperate climate The best growth occurs at temperatures between 40 F and 100 F Most importantly mold growth requires moisture and moisture is the only growth factor that can be controlled By minimizing inte rior sources of moisture an RV owner can reduce or prevent mold growth However if optimal growth conditions persist mold can develop within 24 to 48 hours Moisture in the RV can stem from a variety of sources such as spills leaks overflows condensa tion damp or standing water and human activity such as showering or cooking Good maintenance practices are essential in the effort to prevent or reduce mold growth What the RV Owner Can Do The RV owner can take positive steps to reduce the occurrence of mold growth in the RV and thereby minimize any possible adverse effects that may be caused by mold These steps may includ
138. n in park and set the parking brake 5 Check the charge in the battery Recharge as necessary 6 Disconnect battery cables Refer to Chassis Operator s Manual for proper removal and installation sequence Clean terminals top and sides of batteries and battery boxes Reinstall cables dress with a battery termi nal spray 7 Use battery disconnect switch es if equipped 8 Drain black gray and potable water tanks 9 Winterize if appropriate See Winterization section in this manual 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 293 STORAGE Turn off water pump and water heater switches Turn off Propane at tank valve Turn off refrigerator and furnace Turn off range and oven burner valves and pilot valves if equipped Remove all perishables from refrigerator and galley cabinets Block refrigerator door s open to reduce odor buildup An open box or tray of baking soda in the refrigerator will help absorb odors Open closet doors drawers and cabinets so air can circulate In warm or hot climates slightly open suggested roof vents for ventilation In cold climates close and cover all vents to prevent entry of snow etc Close and lock all windows Be sure vent fan and range hood fan switches are off Cover exterior appliance vents water heater furnace range hood refrigerator to prevent insects from getting in Be sure to remove
139. n standing on the step well cover or in the stepwell could lose their balance and fall if the stepwell cover is operated A WARNING In the event of a fire or other life threatening emer gency do not attempt to retract the entry step cover if itis in the out position Use what ever method nec essary to safely exit the motor home that will not result to injury to yourself or others A WARNING Feet legs hands and other body parts could be pinched or injured during stepwell cover operation Keep clear of the stepwell cover during operation ENTRY AND SCREEN DOORS The main entry door uses a latching system sim ilar to that used in automobiles It has a second ary latch as well as a primary latch When clos ing the door be sure to close it firmly to engage the primary latch This will ensure that the door is fully closed When traveling always lock the deadbolt The screen door may be separated from the main entry door by depressing the catch or releasing the magnet PATIO AWNING If Equipped An operating and maintenance guide for your awning is included in your Owner s Information Package It contains complete instructions for opening and closing the awning as well as maintenance and care instructions Any awning can collect debris and puddle water After it has rained or snowed cautiously retract your awning and or slide out box If necessary occasionally stop the retraction 06 2 Living
140. nd accessory products Included are programs for the interest for all members The National rallies provide an opportunity for members to receive current and beneficial motor home maintenance and operating information from American Coach specialists ASSOCIATION FOR OWNERS OF AMERICAN HERITAGE AMERICAN EAGLE AMERICAN DREAM AMERICAN TRADITION AND LIMITED MOTOR COACHES S Pramean oah Membership Application Please Print Please use the first name that you want on your name badge Owner s Last Name First Name Co owner s Last Name First Name Mailing Address City State Zip Phone Cell Email optional I we own American Heritage Year American Eagle Year American Dream Year Fax optional American Tradition Limited Dues First Time Member 45 00 35 00 dues 10 00 Initiation Fee Your membership will begin at the time we receive your check and will be effective for one year Annual renewal 35 00 Your expiration date will be shown on your newsletter address label Please complete the form and mail with your check payable to American Coach Association Membership Services Have the P O Box 3370 Long Beach CA 90803 Chapter Contact Me Referred by New Members Application American Coach Chapter of FMCA Carol Mayo Membership Chair Chapter Web Site www americancoach fmca com American Coach Chapter of FMCA Membership
141. nd sold over one million homes An accomplishment earned one home at a time One family at a time We hope your next home will be a Fleetwood home CALL 1 877 4FLEETWOOD FOR A PARTICIPATING RETAILER NEAR YOu OR CLICK ON www fleetwoodhomes com We FLEETWOOD 3200 Myers Street P O Box 7638 Riverside California 92513 7638 MANUFACTURING PLANTS FLEETWOOD MOTOR HOMES OF CALIFORNIA INC P O Box 1549 Riverside California 92502 951 788 2920 FLEETWOOD MOTOR HOMES OF PENNSYLVANIA INC Route 487 R F D 1 P O Drawer 5 Paxinos Pennsylvania 17860 570 644 0817 FLEETWOOD MOTOR HOMES OF INDIANA INC 1031 U S 224 East P O Box 31 Decatur Indiana 46733 260 728 2121 SERVICE CONTACT AMERICAN COACH OWNER RELATIONS P O Box 1008 Decatur IN 46733 1 800 435 7345 Notes Notes
142. ner s Guide Manual for any instructions supplied by the chassis manufacturer with respect to this system Illustration 1 DRIVING AND VEHICLE CONTROL Driving your motor home will be different from driving your family car or truck Your motor home is large and heavy You may have to adjust or learn new driving techniques to safely oper ate your motor home Downhill driving puts extra strain on many dri vetrain components of your motor home The brakes are easily overloaded and overheated 05 15 On The Road when used for downhill slowing Brake fade will occur if the brakes overheat When driving down long grades shift the trans mission to a lower gear at the top of the grade Rule of thumb Use the same lowest gear going down as it took to go up the hill Crest the hill in the lower gear Monitor your speed Using the Engine to Slow the Motor Home To use the engine as a braking force select the next lower gear Engine braking provides good speed control for going down grades When the motor home is heavily loaded towing or the grade is steep preselection of a lower gear prior to the grade may be desirable Gear preselection means the selection of a lower gear to match the driving conditions you encounter or expect to encounter Preselection will give you better control on slick or icy roads and on down grades Downshifting to lower gears increases engine braking The selection of a lower gear often pre
143. ng Advisory 05 18 mete Fan oh cee cde ites ees de 05 19 Exhaust System Heat si 22diaeieee e ts 05 19 Engine Temperature Gauges 05 19 Carbon Monoxide Safety Precautions 05 20 Carbon Monoxide Detector Alarm 05 20 Emergency Towing 022ee seeeseeened 05 20 Windshield Wipers and Washers 05 21 LIVING WITH YOUR MOTOR HOME 06 1 Leveling System If Equipped 06 1 Air Dump System 2 62e050ee0e4 06 1 Power Entry Step If Equipped 06 1 Manual Stepwell Cover If Equipped 06 2 Hydraulic or Electric Stepwell Cover IF BQUIS DEO ar segant aaaeei eh a 06 2 Stepwell Cover Operation 06 2 Entry and Screen Doors 22 22s lt 45 4 06 2 Patio Awning If Equipped 06 2 WINdOWS pesar redirodaires ridai sea kua 06 3 Emergency Exit Window s 5 06 3 Remote Mirror Control dsc cdaeewk saad 06 3 Sun Visors If Equipped o 4 0caceenee 06 3 Power Sun Visors If Equpped 06 4 Pull Shades If Equipped x inentcxasccsd 06 4 Day Night Shades If Equipped 06 4 Mini Blinds If Equipped 06 4 Storage 6 25 doe en ae oe a eae ee 06 4 Exterior Compartments coos ick 8 wee 06 4 Interior Storage cae s acacia awndaas 06 5 Slide Out Rooms If Equipped 06 5 Interior and Furnishings 06 6 Dinette Conversion with Built in Table If Equipped a can ceca spas cob waxed 06 6
144. ns available it is beyond the scope of this manual to include wiring dia grams In certain situations specific wiring dia grams may be available to help troubleshoot a problem If you need specific wiring informa tion please contact your dealer Complete wiring diagrams are not available MOTOR HOME FUSES AND CIRCUIT BREAKERS The 120 volt circuit breakers and 12 volt fuses are located on separate panels The purpose of these panels is to provide electrical circuit breakers and fuses to interrupt current flow if a circuit is overloaded See the American Coach Information section in this manual for the loca tions of breaker and fuse panels used in your RV 08 8 Propane is available from an approved storage container to operate your range oven furnace and water heater and as an alternate energy source for some refrigerators With proper han dling precautions Propane is safe and provides modern conveniences wherever you travel Propane is stored as a liquid under pressure and vaporizes under the control of a pressure regula tor A typical Propane tank installation is illustrated below Although specific details of the system may differ in your motor home the major com ponents and their relationships will be similar to those shown Propane tank Sight gauge Stop fill valve Main shut off valve Regulator assembly 6 Propane hose 7 Outage valve 8 Remote Fill Hose 9 Outage Hose PROPANE SAFETY PRE
145. ntilate closets and cabinets During use in cold weather leave cabinet and closet doors partially open to warm and ventilate the interiors of storage com partments built against exterior walls The air flow will warm the exterior wall surface and reduce condensation and prevent possible ice formation Avoid crowding closets or wardrobe space Overstuffed closets restrict air flow 5 Stock kitchen and bath cabinets to allow free air circulation 6 Open window coverings and windows as often as possible and convenient 7 Control the interior heat Here are some tips on controlling humidity with heat e Keep registers and the furnace blower clean and unobstructed This helps air circulation e Do not operate a humidity device on your furnace Dripping Ceiling Vents During cold weather condensation frequently forms on ceiling vents and may even accumulate to the point of dripping onto the surfaces below This is frequently misinterpreted as a leaking roof vent but is most often condensation drip page Follow the preceding steps to control moisture condensation and protect surfaces with plastic sheeting until the moisture has dissipated IMPORTANT INFORMATION Mold is a fungus that occurs naturally in the envi ronment and serves necessary functions including aiding in the decomposition of plant and other organic material Mold spreads by means of microscopic spores borne on the wind and is found everywhere life ca
146. ntrations of carbon monoxide Test the CO detector alarm after the motor home has been in storage before each trip and at least once a week during use Please refer to the materials included in your Owner s Information Package EMERGENCY TOWING The preferred emergency towing methods are either an under reach wheel lift device or a flat bed trailer Most tow truck operators willing to tow motor homes will be familiar with these devices Be prepared to give the tow truck operator at least the following information when you call Length and height of motor home Chassis manufacturer Gross vehicle weight rating A CAUTION Do not tow the motor home from the rear Towing from the rear will cause serious overloading of the front tires and suspension possibly resulting in tire or front suspension failure The rear frame extensions are not designed to withstand the load imposed by lifting from the rear 05 20 On The Road A WARNING DO NOT crawl under or place any part of your body under a vehicle that is being lifted Stand clear of all towing equipment and the vehicle being lifted The vehicle must be towed from the front either on the rear wheels if operational or on a heavy duty dolly Consult your Chassis Operator s Owner s Guide Manual for any available instructions Contact the chassis assistance cen ter prior to calling a tow company to receive tow instructions and possible assi
147. o battery systems One system supplies 12 volt DC power to start the vehicle engine The other system supplies 12 volt DC power to the house living area and starts the generator A CAUTION The systems in this coach are not designed to be used for any life support applications In the unlikely event a system in this coach should malfunction or fail to operate it is possible any connected appli ances including life support equipment may also fail resulting in potential medical complications CHASSIS 12 VOLT ELECTRICAL SYSTEM The chassis 12 volt or vehicle electrical system generally includes chassis battery chassis house battery charging system ignition system instrument panel and controls inverter charger headlights taillights turn signals power entry step Propane detector alarm leveling jacks if equipped slide out if equipped fog lights if equipped air horns if equipped power Seats if equipped radio luggage compartment lights other vehicle lights and accessories Chassis Bulbs and Fuses Fuses will interrupt the flow of electricity if a circuit is overloaded See the American Coach Information section 04 in this manual for the locations of breaker and fuse panels used in your RV A CAUTION Always replace bulbs and fuses with equivalent types The type is marked on the bulb or fuse FLEETWOOD 12 VOLT HOUSE AND AUTOMOTIVE SYSTEM This system generally includes
148. o your vehicle during refueling even when using the nozzle s auto matic hold open latch If you must reenter your vehicle discharge the static electricity build up when you get out by touching the outside metal portion of your vehicle away from the filling point before attempting to remove the nozzle ENGINE FAN When the engine is under load or requires maxi mum cooling the engine fan turns faster The fan may become noisy at high speed and when maximum cooling is required High speed fan noise can sometimes be misinterpreted as trans mission slippage This is not the case This fan noise indicates that the fan is doing what it is supposed to do This noise is not a defect in the fan or the transmission Vibration from the fan is Sometimes is interrupted as tire and wheel vibration This is not the case When the fan shuts off the vibration should disappear EXHAUST SYSTEM HEAT Your motor home engine has been designed to conform to Federal and State emission require ments To meet these requirements engine operat ing temperatures are high As a result the engine transmission and exhaust systems radiate heat Heat shields are built into your motor home to protect wiring and other components from pos sible heat damage caused by the exhaust system Do not remove these shields modify the exhaust system or add additional equipment such as wiring plumbing or other components which may be effected by exhaust syst
149. odel and serial numbers available Appliance identification numbers will be found on tags or plates attached to the appliance 02 3 Warranty If you have a warranty or service concern about the chassis portion of your motor home you may go directly to an authorized chassis dealer for service This may save you time and effort as the chassis warranty is administered by the chassis manufacturer Consult your area directory for an authorized claims dealer If you are unsure if the issue is chassis related please contact your Fleetwood dealer The motor home has been thoroughly inspected before shipment Your dealer is responsible for performing a complete predelivery inspection of the motor home as specified in the Ownercare delivery checkout Please refer to the warranty in the front of this manual It explains your rights and obligations as well as the rights and obligations of the dealer and manufacturer Please read this section carefully You will be better informed in case you have a warranty related problem and your dealer will be better able to get you on the road again REPORTING SAFETY DEFECTS If you believe that your vehicle has a defect which could cause a crash injury or death you should immediately inform the National Highway Traffic Safety Administration NHTSA in addition to notifying American Coach Owner Relations at 1 800 435 7345 If NHTSA receives similar complaints it may open an investigation
150. ollision Use a safety seat that is recommended for the size and weight of the child Seat backs should be upright for use with child safety seats Any objects in close proximity which may come into contact with the child in the event of an accident or sudden stop should be removed A WARNING Place child safety seats only in forward facing locked seating positions equipped with a restraint system A WARNING Carefully follow all of the manufacturer s instructions that come with the safety seat that you put in your vehi cle Make sure that the shoulder belt if provided at the seating position where the safety seat is being used does not cross or rest in front of the child s face or neck If you do not install and use the safety seat properly the child may be injured in a sudden stop or collision A WARNING When using any infant or child restraint system it is important that you follow the instructions and warnings provided by the manufacturer concerning its installa tion and use Failure to follow the restraint manufac turer s instructions could increase the risk or severity of an injury in the event of a collision or sudden stop Child Seat Tethers If Equipped Some child seat manufacturers recommend the use of a top anchorage tether strap in addition to the lap belt Since a top anchorage tether 05 14 On The Road strap can provide additional security to a c
151. om either the chassis or the house batteries Deactivating the relay s will prevent battery discharge which may occur over extended storage periods During normal use of your motor home the relays must always be in the on position If you plan to store the motor home for an extended period press the disconnect switch es and turn off the inverter switch es to OFF Remember to press the switch es to ON when you take the motor home out of storage J NOTE When charging the batteries the battery disconnect switches must be ON Battery Inspection and Care A WARNING Do not use the motor home when the chassis batter ies are disconnected The power step will not operate as designed if the chassis battery is disconnected If the step is not in the correct extended position you may be injured if you step out of the motor home Check the external condition of the batteries periodically Look for cracks in the cover and case Check the vent plugs and replace any that are cracked or broken Keep the batteries clean Acid film and dirt on the battery top may permit current to flow between the terminals and dis charge the battery To clean the batteries 1 Wash the battery with a diluted solution of baking soda and water to neutralize any acid present 2 Flush with clean water Foaming around terminals or on top of the battery is normal acid neutralization Avoid getting the soda solution
152. on If Equipped 10 3 Whole Coach Surge Protection UPB PPC 5 403 Ga ek et thee ace wd es 10 4 Power TV Antenna If Equipped 10 4 Satellite Dish Antenna If Equipped 10 4 Satellite Radio If Equipped 10 4 Telephone Jack If Equipped 10 4 Microwave Oven If Equipped 10 4 Washer Dryer Ready Option 10 4 Miscellaneous Appliances 10 4 MAINTENANCE ce ccvocndadues chvaceees 11 1 PRIGTION oo voetess on ENEE TE EIERNE 11 1 SIAS paata aw alate Aa wie egal TE RE 11 1 How to Maintain Care for and Repair the Finish on your Fleetwood RV 11 2 Vinyl Front End Mask If Equipped 11 2 00 3 Table of Contents Windows Doors Vents and Locks Fiberglass Roof System CROONINEG serraria t e 54 eRe RSN CAE E enaA E EEA A EEA AE Sealant Renewal 0 0c cece Exterior Sealants 0 0002 Door Window Roof Component and Molding Resealing TOUICE 6 34 sa ee rk Oe ses ete ed FADTICS sae orn tai Ga nEn ENEO oa dates Solid Surface Top Care If Equipped Laminate Top Care If Equipped Walls and Ceiling Panels Attaching Accessories to Your Motor Home 0 000 ce eee Plastic Fiberglass Shower Stall Floors and Carpeting 6 oss lt aH ep Rae Wood Floor If Equipped Tile Floor If Equipped Engine Access 6 0 00
153. on it This man ual includes a section outlining maintenance intervals If you follow the maintenance guide lines you will minimize the possibility of fail ure of any important system or part of your motor home PLANNING AND PREPARATION Each year millions of Americans embark on trips using some type of recreational vehicle Proper planning of your trip will ensure a pleas urable experience A thorough knowledge of your RV is important if you are going to get the most out of the convenience and safety items built into your motor home Be as familiar with it as you are with your personal car or truck If you have trouble or have questions please con sult your dealer OWNER S INFORMATION PACKAGE This package contains valuable documents about your motor home and its equipment and systems This Owner s Manual and the Chassis Operator s Manual are in the package Since this manual does not cover every possible detail of equipment and options installed on or in your motor home there are booklets and instructional material in the package that will help you safely operate maintain and troubleshoot those items Be sure you read all this information and understand the safety and operating instructions included in the package Additionally you must follow all maintenance instructions to insure full warranty coverage If you decide to sell or trade your motor home be sure the new owner receives all the material in this package
154. or vehicle occu pants of a life threatening danger Keep them working and respond to them quickly Examples of These Devices Include e Carbon Monoxide Detector Alarm e Propane Detector Alarm e Smoke Detector Alarm e Seat Belt Warnings e Hazard Flashers e Brake Warning e Engine Warning EVENT DATA RECORDING DEVICE If Equipped SPECIAL NOTICE Vehicle Event Data Recording Capabilities Motor homes equipped with driver passenger airbags Navigational or Vehicle Avoidance Systems and or equipped with certain other electronic devices may be equipped with event data recording capabilities Your motor home is built on a vehicle chassis supplied by an automotive manufacturer For diagnostic and safety related reasons this chas sis comes equipped with electronic modules devices Certain electronic modules have the capability to record information about the vehicle driver and passenger such as engine performance braking performance vehicle location vehicle speed and occupant seat belt use or other data The data stored in the electronic modules may be retrieved by authorized parties using special ized equipment for vehicle diagnostic or acci dent investigation purposes Please refer to the chassis manufacturer owner s guide and or if equipped electronic device manufacturers owner s guide s for further details on event data recording capabilities DRIVERS LICENSE REQUIREMENTS Some states require eithe
155. ound in other chapters of this Owner s Manual Please see the Propane System and Appliances chapters for other safety and operating information A WARNING This product is manufactured with urea formalde hyde resin Formaldehyde vapor may in some people cause headaches eye nose and throat irritation and aggravation of allergies and respi ratory problems such as asthma Proper ventila tion should reduce the risk of such problems A WARNING This product is manufactured with a urea formaldehyde resin and will release small quantities of formaldehyde Formaldehyde lev els in the indoor air can cause temporary eye and respiratory irritation and may aggravate respiratory conditions or allergies Ventilation will reduce indoor formaldehyde levels A WARNING Irritant This product contains a urea formalde hyde resin and may release formaldehyde vapors in low concentrations Formaldehyde can be irritating to the eyes and upper respira tory system of especially susceptible persons such as those with allergies or respiratory ail ments Use with adequate ventilation If symp toms develop consult your physician FIRE SAFETY The hazard and possibility of fire exists in all areas of life and the recreational life style is no exception Your RV is a complex machine made up of many materials some of them flammable But like most hazards the possibility of fire can be minimized if not totally eliminated by r
156. ped 07 4 Whole Coach Filter System If E ipped srsirircrerisisti sssi 07 4 00 2 Table of Contents Insta Hot Drinking Water System If Equipped 2552 2eecepenee tees wed 07 4 Waste Water System os ca0sie ee adeweaw ed 07 4 Toilet si bila aorta ha cite Gon ed a have go a ae 07 4 Draining the Holding Tanks 07 5 Black Tank Flush System If Equipped 07 6 San T Flush Operation Using Sanitizing Bottle from Kit If Equipped 07 6 Holding Tank Care ase sscessaxcaxeed 07 7 Cold Weather Usage ccce nccewcaent 07 8 ELECTRICAL SYSTEMS 4 08 1 Batteries 6 04 ene e eee eee yd soos ah 08 1 Chassis 12 Volt Electrical System 08 1 Chassis Bulbs and Fuses 5 08 1 Fleetwood 12 Volt House and Automotive SYSTEMI veaa a Sie ayn Se EOR aaa 08 1 Battery Disconnect If Equipped 08 2 Battery Inspection and Care 08 2 Battery Charging aaack oa a Cen d Kaw wea 08 2 Solar Panel If Equipped 08 3 Selecting a Replacement Battery 08 3 Auxiliary Start System If Equipped 08 3 120 Volt System ci ses cays nh eG ed ee asd 08 4 Power Inverter uci eee desta ouneed 08 4 Power Converter lt 0ls s iim enn Cea wind 08 5 Ground Fault Circuit Interrupter GFCI 08 5 Generator If Equipped 08 5 Generator Fuel Supply 45 08 5 Propane Generator If Equipped 08 5 Generator Operations 44 08 6 Gene
157. ponent is attached to the motor home frame The square tube opening receives any of a wide variety of hitch head assemblies The hitch head is the component that includes the hitch ball Hitch head assemblies are available in both Weight Distributing load equalizing and Weight Carrying types A weight distributing hitch uses spring bars attached to the trailer tongue A frame assembly to transfer some of the trailer tongue weight to both motor home axles A weight carrying hitch head assembly does not use spring bars All of the tongue weight of the trailer bears down on the hitch assembly which loads the motor home rear axle For this reason the maximum load you can tow with a weight carrying hitch head assembly is limited In addition to weight carrying and weight dis tributing your hitch may also have a dinghy towing rating This rating will apply should you tow a motor vehicle with all four wheels down 05 3 On The Road Typical hitch system components are shown in the following illustration Hitch Ball Receiver Chain Loop 2 Chain Bracket Typical Hitch System Components The ratings associated with the particular hitch receiver supplied with your motor home are noted on the weight tag and on a label affixed to the hitch receiver It is important that the devices which attach to the hitch receiver equipped with your motor home are rated to equal or exceed the loads of your towed trailer automob
158. r 2 Place a shallow pan under the water solenoid valve 3 Remove the inlet fitting to the ice maker water solenoid valve Drain the water from the supply line 4 Remove the plastic nut and water line from the outlet side of the water solenoid valve Drain water from the line 5 Cycle the ice maker several times while blowing compressed air through the water solenoid valve Be sure all water is out of the solenoid NOTE Your motor home dealer can do this for you 6 Reconnect and tighten the lines on the solenoid valve Leave the water supply turned off until temperatures are above 32 F 0 C 7 Dry out the ice maker mold assembly with a soft cloth Place the bail arm to the UP OFF position REACTIVATING THE MOTOR HOME AFTER STORAGE If the motor home was properly and carefully prepared for storage taking it out of storage will not be difficult The following procedure check list assumes that you stored the motor home with care If you didn t and extensive freeze damage or other serious deterioration has occurred please consult an authorized Fleetwood Dealer for advice Thoroughly inspect the outside of the vehi cle Look for animal nests in wheel wells under the hood in air cleaner or in other out of the way places Remove all appliance vents ceiling vent and air conditioner coverings Be sure all furnace water heater and refrigerator openings are clear and free of debris or insect nests webs
159. r an endorsement or a different class of drivers license to operate or tow a recreational vehicle License classes are often based on the size of the vehicle you wish to drive or the weight of the trailer you wish to tow Please refer to your home states vehicle drivers license authority to determine if there is such a requirement 01 6 LIMITED ONE YEAR WARRANTY For Motor Homes Manufactured by Subsidiaries of Fleetwood Enterprises Inc Sold in the United States and Canada COVERAGE PROVIDED Your new motor home including the structure plumbing heating and electrical systems all appliances and equipment installed by the man ufacturer is warranted under normal use to be free from manufacturing defects in material or workmanship The warranty covers the first retail purchaser and all transferees during the warranty period The warranty begins on the date of original retail delivery or the date the motor home is first placed into service as a rental commercial or demonstrator unit whichever occurs first Start Date and extends for the following periods 1 For non structural defects one 1 year from the Start Date or until the motor home reaches 15 000 total miles as determined by the mileage shown on the odometer whichever occurs first 2 For structural defects three 3 years from the Start Date or until the motor home reaches 50 000 total miles as determined by the mileage shown on the odometer whichever occu
160. raction Control Tag Dump Switch Engine Brake Selector Switch H MED LOW Engine Brake Switch ON OFF Transmission Shifter Blank Adjustable Pedals Brake amp Accelerator 12 Volt Outlet Power Window Mirror Controls Coin Holder Cup Holder 04 3 Eagle Tradition and Heritage Information TOWED VEHICLE WIRING Your motor home is equipped with an electrical connector from here on referred to as a hitch plug which provides an electrical connection for your towed vehicle The hitch plug is located at the rear of the motor home near the hitch receiver It is a 7 position connector wired as follows Please note this connector provides separate positions for the two turn signals and brake lights This is necessary for the towed vehicles that have separate amber turn signals in addition to the red brake lights Some towed vehicles will not have amber turn signals separate from the brake lights They will instead use the same lamp to indicate braking as well as turn signal Towed vehicles with this type of lighting will not be able to utilize the standard hitch plug on your motor home For towed vehicles with this type of lighting you will need to replace your hitch plug A replacement hitch plug wiring harness is avail able through Fleetwood s American Coach Service This harness replaces your current hitch plug and is easily installed in minutes TO POWER DISTRIBUTION BOX BATTERY COMP T a RUNNING MARKE
161. rator Operating Safety Precautions 08 6 Generator Cooling System 5 08 7 Generator Slide Out If Equipped 08 7 Generator Maintenance 5 08 7 Automatic Generator Start Control System If Equipped 08 7 Main Features ccs cccivadebavedxeskas 08 7 Power Cord Reel If Equipped 08 7 Electrical Wiring Diagrams 08 8 Motor Home Fuses and Circuit Breakers 08 8 PROPANE SYSTEM cceeeeee 09 1 Propane Safety Precautions 09 1 System Components 46Ksees4sesaun 4 09 2 HOSES Taaa ais ewan eee eek Glee aed 09 2 Propane Regulator 0 056026 040440804 09 2 Using Propane System at Low Temperatures ats cone a ce ew nanne 09 2 Filling Propane Tanks 09 3 Propane System Check 0 0ssense lt xsie ved 09 3 Propane Leak Detector Alarm 09 3 Lighting Propane Appliances 09 4 APPLIANCES osx dissevsesei seen ctsueed 10 1 Water Heder ac ccstu inte dann kustansi x 10 1 Water Heater Bypass Valve 10 1 Refrigerator 2263420202000 caus doa 10 1 2 Stage Forced Air Furnace 10 1 Hydro Hot Hydronic Heating System If EQUIPDEO wsceuaytnncas sea unenes 10 2 PS og a din a ms ate a RS GR e 10 2 Range Exhaust Hood 10 3 Air Conditioner with Heat Strip If Equipped onc 2 ode one bake onsen ds 10 3 Televisions and DVD Players If Eqg ipp d seset estemu doe nce eines 10 3 LCD Televisi
162. roughly drained from the black tank close the knife valve and replace the termination cap Rinse out the sewer hose with fresh water and remove the sewer hose from the dump station If you are parked at a site with a semiperma nent sewer hookup keep the black water knife valve closed to allow the waste level to build up The outlet will probably clog if you leave the knife valve open continually Run enough water into the tank to cover the bot tom This will aid the break up of solid wastes 6 Replace sewer or dump station covers San T Flush Operation Black and Grey Tank Flush System Using sanitizing bottle from kit If Equipped 1 Dump holding tanks in the usual manner at an approved station 2 Leave dump valves open 3 Attach garden hose to San T Flush attach ment 4 Remove clear plastic bottle 5 Place one 1 waste liquefier tablet into screen 6 Replace the bottle Hand tighten 7 Hook water hose to inlet side of the sani tizing bottle cover 8 Connect the male disconnect to the San T Flush valve yellow handle Turn the valve to BLACK TANK 9 Flush black tank until tablet is 2 3 dissolved 10 While water is running turn the San T Flush valve to GREY WATER TANK and flush until the tablet is dissolved 11 Turn San T Flush valve to BLACK TANK 12 Remove San T Flush attachment and gar den hose 13 Remove the sewer hose and cap the outlet 14 Rinse out the sew
163. rs first Structural defects are defined only as the motor home s roof structure sub floor structure and Vacubond walls WHAT IS NOT COVERED BY THIS WARRANTY This warranty does not cover 1 The automotive chassis system including the chassis and drive train tires and batter ies all of which are covered by the sepa rate warranties of the respective manufac turers of these components 2 Defects caused by or related to a Abuse misuse negligence or accident b Failure to comply with instructions con tained in the Owner s Information Package c Alteration or modification of the motor home d Environmental conditions salt hail chemicals in the atmosphere etc 3 Normal deterioration due to wear or expo sure such as sealants fading of exterior surfaces fabrics drapes and carpet wear etc 4 Motor homes on which the odometer read ing has been altered 5 Normal maintenance and service items such as light bulbs fuses sealants lubri cants etc 6 Appearance imperfections or damage to paint graphics exterior materials or upholstery that may have occurred prior to delivery and are normally corrected during the delivery inspection process at the man ufacturing plant or at the dealership 7 Transportation to and from dealer location 8 FLEETWOOD SHALL NOT BE LIABLE FOR ANY 1 INCIDENTAL OR CONSE QUENTIAL DAMAGES INCLUDING BUT NOT LIMITED TO ANY CLAIMS FOR PROPERTY DAMAGE L
164. rvice or Sales Department will han dle any normal problems which might occur Some equipment and features described or shown in this manual may be optional or not available on some models Because of the continuous program of product improvement conducted by Fleetwood it is pos sible that recent product changes may not be included in this manual Specifications may change without notice Product information illustrations and photography included in this Owner s Manual were as accurate as possible at the time of publication and are representative of function and may or may not be specific in their depiction of actual equipment fabrics interior or exterior decor or design options as installed on or in your recreational vehicle The instructions included in this manual are intended as a guide and in no respect extend the responsibilities of the manufacturing subsidiary parent company or affiliates beyond the stan dard written warranty as presented in this man ual Fleetwood has designed its recreational vehicles to provide a variety of uses for its customers Each vehicle features optimal seating sleeping storage and fluid capacities The user is respon sible for selecting the proper combination of loads to ensure that the recreational vehicle s capacities are not exceeded INSPECT AND MAINTAIN Follow a consistent schedule of inspection and maintenance for your motor home Your contin uing safety and comfort depend
165. s of windows and doors Special gaps in the sealant have been intentionally left in the bottom flange to provide drainage INTERIOR Fabrics Interior appointments such as draperies bed spreads mattress covers upholstery and wall pads are manufactured from high quality materi als and should be dry cleaned only Frequent vacuuming will keep them free of dust and dirt Minor spills should be cleaned up quickly to avoid staining The affected area should be blot ted not rubbed to prevent the stain from work ing deeper into the fabric A WARNING Do not use lacquer thinner nail polish remover carbon tetrachloride spot remover gasoline or naphtha for any cleaning purpose These products may cause damage to the material being cleaned and may be highly flammable or poisonous Solid Surface Top Care If Equipped The counter top is constructed of a solid surface material that requires little care Routine care involves wiping the surface with a damp cloth to remove water marks For stains wipe with soapy water or ammonia based cleaners Do not use abrasive cleansers or steel wool Laminate Top Care If Equipped For cleaning laminate surfaces uses mild dish washing liquid with warm water Use a soft cloth for both washing and drying Do not use abrasive cleaners steel wool or gritty cleaners or damage will occur to the surface Walls and Ceiling Panels The paneling and the ceiling of your motor
166. s the front and rear portions of the motor home swing wider than an automobile When parking on an incline turn the front wheels into the curb in the direction of the roll to aid the parking brake When parking always shift the transmission to P and set the parking brake If you can t avoid operating parking or idling your vehicle off road e Be aware that combustible materials could catch fire from the vehicle s hot exhaust system e Avoid driving your vehicle through or over combustible materials such as leaves grass vegetation or stubble high enough to touch catch or collect on its hot exhaust system e Parking or idling should be done only in an area where there are no combustible materials under the vehicle A WARNING Do not park or idle the motor home over combustible materials such as tall grass or dried leaves Combustible materials may catch fire from the hot exhaust gases soot or sparks that could escape through corrosion holes or cracks This is particularly important if the exhaust system has not been properly maintained REAR VIEW VIDEO MONITOR If Equipped Your motor home is equipped with a computer The computer will operate the Rear View Video Monitor back up system The motor home will have two color display screens One is located in the dash and the other monitor is located in the control panel display center Your Owner s Information Package contains detailed operatin
167. sconnect Switch Locations S556 Aled A xe ok ee we acd 04 1 Eagle and Tradition Driver s Controls 04 2 Instrument Panels ose cesta ta eeweadaad 04 3 Shifter Selector Side Pod 04 3 Towed Vehicle Wiring o4 42244 0censeeced 04 4 Deep Snow and Mud Switch If Equipped 04 4 Heritage Drivers Controls 2c226c8iud 04 5 Instrument Panels ce 253285 cerdee deve 04 5 Shifter Selector Side Pod 04 6 Living with Your Motor Home 04 7 Plumbing System and Holding Tanks 04 7 Draining the Holding Tanks 04 7 Electrical Systems 4 osedecsseideedua veed 04 8 Battery Charging 25 56 bob O eee eg HRS bE 04 8 Automatic Generator Start AGS 04 8 Trip Navigation and House Monitoring SYSE 26sec renceeo cen re sees 04 8 Reference Material sccnsexw en wae oxana Kd 04 8 Navigation System 04 8 Navin I S000 2c2ste pea tetesana ce 04 8 Cameras soari ene ire ga Ep aos ean 04 9 Video Valet Switch Heritage only 04 9 ON THE ROAD ooosssssnsossssssoss 05 1 Motor Home Loading lt 1s2se0 ews das 05 1 Responsibility for Proper Loading 05 1 Some Definitions First 05 1 Towing a Vehicle or Trailer 05 2 Suggested Owners Manual addendum for weight distribution hitches 05 2 Dinghy Towing 66 0 4axes anes agsiacd 05 4 Towed Vehicle Wiring 444 05 5 Occupant and Cargo Carrying Capacity and Lo
168. sensitive to fading or drying Use bulbs designed or specific by manufacturer as to style wattage and voltage 04 1 Eagle and Tradition Information DRIVER S CONTROLS 28 29 04 2 and Tradition Information 30 Shifter Selector Side Pod Instrument Panels 1 Auxiliary Start Chassis amp Generator Engine Blank Dimmer Switch Driving Lamp Switch Head Lights Switch Fuel Water Oil Gauge Left Turn Signal Indicator Speedometer 9 Right Turn Signal Indicator Tachometer Front amp Rear Air Gauges 11 Heating Air Conditioner Fan Speed Control 12 Heating Air Conditioner Temperature Control 13 Vent Control 14 Defrost Fan Speed Control 15 Defrost Temperature Control ONDA WN 16 17 18 19 20 21 22 23 24 25 26 27 28 29 Driver Power Sun Visor Switches Blank Docking Lights Hood Light Switch Dome Light Switch Radio Switch Blank Generator Start Switch Passenger Power Sun Visor Switch Generator Hour Meter Gauge ATI Temperature Compass Gauge Back up Monitor Radio Satellite Radio Optional Tire Pressure Navigation system Chassis Engine Ignition Switch Parking Brake Control Knob Shifter Selector Side Pod 30 31 32 33 34 35 36 37 38 39 40 41 42 Leveling Jacks Control Pad w Air Dump Air Horn Switch Automatic T
169. severe electrical shock could result A CAUTION Switch off the 50 amp main breakers located in the 120 volt AC load center breaker panel before you insert or remove the 50 amp power plug Be sure to insert or remove the plug straight into or out of the receptacle The neutral and both 120 volt volt pins should make contact at the same time to avoid exces sive voltage on one leg of the circuit that could dam age 120 volt appliances Power Inverter The inverter uses 12 volt DC power from the coach batteries and transforms it into 60 cycle 120 volt AC power to run some of the appli ances in the motor home Because the inverter uses 12 volt power extended use of any available appliance TV microwave etc can run the batteries down A low power indicator and automatic shut down system built into the inverter can help prevent deep battery discharge When the inverter shuts down the bat teries will require recharging through the con verter when the motor home is plugged into external AC service or when operating the gener ator The batteries will also be recharged by the chassis charging system while on the road The roof air conditioners cannot be operated on power supplied by the inverter The motor home must be plugged into an external AC service or the gener ator must be operating to run the air conditioners Y NOTE There is an inverter disconnect switch located inside the inv
170. springs etc on the heavier side could be overloaded even though the total axle load is within the GAWR It is important to redistribute the load to avoid component failure as well as to improve the handling characteristics of the vehicle With these actual weights it is now possible to compare them against the GAWR GVWR and tire capacities These actual weights are also what should be used to help determine the proper air pressure for the tires WEIGHING YOUR MOTOR HOME To Obtain Individual Axle and Gross Weights Scale Weight Ibs Step 1 GAW From CCC Label Ibs GAWR STEP 3 Scale Weight Ibs Step 3 GAW From CCC Label Ibs GAWR STEP 2 Scale Weight Ibs Step 2 GVW From CCC Label Ibs GVWR Scale Weight Ibs Step 4 From CCC Label Ibs Vehicle Weight GCWR GVW 05 7 On The Road WEIGHING YOUR MOTOR HOME To Obtain Individual Wheel Positions Weights STEP 1S STEP 3S One Side One Side Scale Weight Ibs Scale Weight Ibs Step 1S Step 3S Calculate Other Ibs Calculate Other Ibs Side Weight Step 1 1S Side Weight Step 3 3S Tire Load Ibs Ibs Tire Load Ibs Ibs See Note See Note Inflation psi Inflation psi See Note See Note NOTE Refer to the tire load charts published by the tire manufacturer to determine the proper inflation pressures recommended for single and dual axles equipped Always inflate each axle set
171. stance with coordinating the tow A CAUTION Remove the axle shafts or disconnect the drive line before towing the motor home To prepare your motor home for towing 1 The rear axle shafts or the drive line MUST be removed before towing See the Chassis Operator s Owner s Guide Manual 2 Secure any loose or protruding parts of the disabled vehicle if any 3 Secure all heavy or loose items in the inte rior 4 Turn off Propane appliances and the Propane tank valve 5 Do not allow any person to ride in the towed vehicle Spartan Motors Chassis Customer Assistance 800 543 4277 A CAUTION The air brake system and air suspension system may require recharging with air before towing to release the brakes and provide proper ride height An air inlet fitting is located in the front road side compartment or under the front hood Tow truck operators should be equipped to re charge these air systems Windshield Wipers amp Washers Your motor home is equipped with windshield wipers It is important to have the proper wind shield washer solution to maintain your system in good operating order CAUTION Use only a windshield washer solution that is rated for a minimum of 20 degrees F 8 degrees C to prevent damage to the system from freezing up 05 21 This page intentionally blank LIVING WITH YOUR MOTOR HOME LEVELING SYSTEM If Equipped Controls for the
172. ste material onto the ground or pavement Always drain the tank into an acceptable sewer inlet or dump station Drain the holding tanks only when they are at least Ys full If necessary fill the tanks with water to 3 4 full This provides sufficient water to allow com plete flushing of waste material into the sewer line Whenever possible drain the holding tanks before traveling Waste water and sewage in the holding tanks reduce the carrying capacity of the motor home See the Motor Home Loading chapter NOTE Local or state regulations may prohibit highway travel unless the holding tank outlet is securely capped To drain the holding tanks 1 Attach the sewer hose to the holding tank outlet Insert the end of the hose into the sewer or dump station inlet pushing it firmly far enough into the opening to be secure In some cases adapters may be necessary or required between the line and the inlet Arrange the sewer hose so it slopes evenly 2 Drain the black water holding tank first Grasp the handle of the black water knife valve the large one firmly and slide the valve open with a quick steady pull 3 Allow enough time for the tank to drain completely Rinse and flush the tank through the toilet When the tank is empty push the handle in to close the valve Run enough water up to five gallons or so into the tank to cover the bottom This will aid the break up of solid wastes and reduce
173. sures specified on the Federal certification tag These pressures are specified at full gross vehicle weight and should be reset to match the weight of your motor home For maximum performance tire manufacturers pro vide tire inflation pressure charts so you can match the tire pressures to the loads on your motor home For additional tire pressure information consult the Chassis Operator s Owner s Guide Manual 05 10 On The Road A WARNING For safety and maximum tire life check and adjust tire pressure including the spare if equipped at the beginning of each trip and daily during the trip Pay special attention to inside rear duals Always check pressure when tires are cold and do not bleed air out of warm tires Follow the tire pressure instructions in the Chassis Operator s Owner s Guide Manual or the tire manufacturer s tire pressure chart NOTE Fleetwood recommends using a high quality tire pres sure gauge for accurate repeatable pressure readings NOTE Check the wheel lug nut tightness periodically They could work loose during driving Check the Chassis Operator s Owner s Guide Manual for correct lug nut torque and torquing procedure and schedule Air Pressure The most important factor in maximizing the life of your tires is maintaining proper inflation Driving on a tire that does not have the correct inflation pressure for the
174. t length so as not to terminate beneath the recreation vehicle 3 The exhaust duct must not be connected with sheet metal screws or other fasteners that extend into the interior of the duct 4 The exhaust duct and termination fittings must be installed in accordance with the appliance manufacturer s printed instruc tions MISCELLANEOUS APPLIANCES You may have additional appliances in your unit which operate only when connected to 120 volt power from either a public utility or the generator In some cases appliance selector switches are provided in the galley to allow you to select com binations of appliances yet still remain within the power capacity of the electrical system 10 4 Your motor home has been designed to provide you with many years of use with a minimum amount of maintenance This section will famil iarize you with the areas of your motor home that require scheduled care Time spent taking care of your motor home on a regular basis will pay for itself in extended service and will help protect your investment If you are mechanically inclined and regularly perform routine maintenance and repairs on your car or truck you may want to do the mechanical work on your motor home yourself If you pre fer your dealer can perform these services for you His trained personnel will assure that your motor home is maintained and repaired in keep ing with original performance expectations This section is inten
175. t in property damage injury and or death INTRODUCTION Your motor home has been designed to provide you with years of carefree pleasant traveling and vacationing It conforms with or exceeds applicable National Fire Protection Association NFPA Canadian Standards Association CSA units built for Canada only Federal Motor Vehicle Safety Standards FMVSS Environ mental Protection Agency EPA and California Air Resources Board CARB regulations The seal attached just outside the entry door indi cates compliance with NFPA or CSA standards Like all equipment your motor home will require care and regular maintenance in order to deliver maximum value and performance The dealer will give you basic operating and maintenance instruc tions However supplement this by reading all instructional material s furnished with the motor home in the Owner s Information Package and the motor home Chassis Operator s Owner s Guide Manual This information out lines important areas of operation and mainte nance for you to follow for safe trouble free serv ice from your motor home Study these materials carefully A good working knowledge of your motor home and how to care for it will help you enjoy many miles and years of recreational living 01 1 Introduction If you have any questions regarding operation maintenance or service please contact your dealer immediately so he can assist you Your dealer s Se
176. t them in safety seats that are made specially for children Safety belts alone do not provide maximum protection for these children Check your local and state laws for specific requirements Safety belts and seats can become hot in a vehi cle that has been closed up in sunny weather and could burn a child Check seat covers and buck les before you place a child anywhere near them Children who are too large for child safety seats should always wear safety belts A WARNING Never leave a child unattended in your vehicle Always remove the key from the ignition and take it with you Safety Belts for Children If the shoulder belt cannot be properly positioned so that it does not cross or rest in front of the child s face or neck move the child to one of the seats with a lap belt only and use the lap belt Lap belts and the lap portion of lap and shoulder belts should always be worn snugly and below the hips touching the child s thighs Children should use forward or rearward facing seat positions not seated facing sideways A WARNING If safety belts are not properly worn and adjusted as described the risk of serious injury to the child in a collision will be much greater Children should always ride with the seatback in the fully upright position When the seatback is not fully upright there is a greater risk that the child will slide under the safety belt and be seri ously injured in a c
177. t to pressurized city water 1 Connect one end of a potable water hose to the RV park or city water supply This will usually be a faucet or valve similar to your garden hose valve at home Potable water hoses are available at RV supply stores 2 Run the city water supply for a few sec onds to clear the line Turn off the water 3 Attach the other end of the potable water hose to city water connection located on the motor home Make sure all connections are tight 4 Turn on the RV park city water supply Open all faucets inside the motor home to clear the lines Then turn off faucets HOLDING TANKS External Fresh Water Connection A CAUTION Since water pressures at campgrounds vary we rec ommend you install an in line pressure regulator if not equipped at the water supply faucet This will pro tect the motor home water system and your supply hose from excessively high water pressure To disconnect the city water 1 Turn OFF the city water supply 2 Remove the hose from the city water supply valve 3 Drain and store the hose Filling the On Board Water Tank The on board fresh water tank can be filled in two ways 1 city water pressure or 2 gravity 1 City water pressure When connected to the city water supply as described above turn the bypass valve located in the utility compartment to Water Tank Fill from the Normal setting This will fill the on board fresh
178. tel lites and a digital roadmap database to calculate and display travel directions on the R5000 Display screen NAVION R5000 The Navion TM R5000 combines radio CD MP3 Player rear view camera system and advanced engine coach and trip monitors into a single integrated system designed specifically for use in RVs It also allows navigation satel lite radio and tire pressure monitoring as options Standard on Heritage accessible from one common interface 04 8 Eagle Tradition and Heritage Information Reference the R5000 Operating Instructions 14950 A 0 for R5000 control radio Navigation and tire pressure operating instruc tions CAMERAS There are four cameras provided with the sys tem They are back up rear door side road side and interior The camera images are dis played on the coach dash monitor and on the optional bedroom monitor The cameras can be manually selected by the Video Valet Switch and camera images can be displayed one at a time The cameras are also automatically selected when the ignition is in the ON position There are three camera functions that automatically occur based on external activity The automatic camera functions are as follows Automatically display back up camera on the monitor when reverse gear is selected Automatically display door side camera on the monitor when right turn signal is active Automatically display road side camera on the
179. th your motor home does not provide specific information on towing weight limits it is strongly recommended that the towed vehicle or trailer be equipped with a prop erly installed and operating supplemental brake control system that operates in combination with the brakes on your motor home The supplemen tal brakes will NOT allow you to tow more than the listed GCWR for your motor home f you cannot stop you will crash You must not exceed the tire capacities or the weight factors listed below if you expect to tow something behind your motor home either with or without a dolly The factors are e GCWR Gross Combined Weight Rating e MGTW Maximum Gross Towed Weight e MTW Maximum Tongue Weight e GAWR Gross Axle Weight Rating The ratings for the above factors are all listed on the Federal Certification Tag posted inside the motor home Tire Capacity The tire capacity is dependent upon the inflation pressure set at the load applied Suggested Owners Manual addendum for weight distribution hitches A major weight distributing hitch manufacturer provides the following information in their installation and operation instructions Severe bumps and badly undulating road can damage your towing vehicle hitch and trailer and should be negotiated at a slow steady speed A weight distributing hitch that has been prop erly adjusted for operation on relatively level road surfaces may cause the weight
180. the scale and record the scaled weight To determine individual wheel position weights it is necessary to repeat the first three steps but this time use only one side of the scale as shown on the following pages shown on the fol lowing pages 05 6 On The Road To calculate the opposite side of the vehicle wheel position weight subtract this side s weights from the weights recorded in steps 1 2 and 3 If there is a towed vehicle proceed to step 4 to obtain the towed vehicle only weight 4 If a boat trailer or other vehicle is being towed it should be weighed and combined with the towing vehicle s GVW Gross Vehicle Weight to ensure the total weight does not exceed the GCWR Gross Combined Weight Rating Even though the weight of the total axle may be within the axle s rating it may be overloaded on one side This causes one wheel position to be overloaded therefore side to side weighing is required Your RV must remain as level as possible on the scale even though an axle or side is not physically on the scale Obviously to obtain the side to side weights there must be enough space on either side of the scale to accommodate the RV being par tially off the scale You may desire to use wheel ramps to get the required side to side leveling If there is a difference in the weights on one side of the vehicle as compared to weights on the other side components tires wheels brakes
181. the generator as an emergency power source to a general residential or industrial utility line This is illegal and may cause shock or electrocution to power line utility personnel attempting to repair power lines A WARNING Do not place flammable material or store any other materials in the generator compartment A WARNING Do not operate the generator when parked in or near high grass or brush Exhaust component heat may cause a fire A WARNING Do not modify the generator installation or exhaust system in any way Do not use the generator as an emergency power source to a general residential or industrial utility line This is illegal and may cause shock or electrocution to power line utility personnel attempting to repair power lines A WARNING Do not block the generator ventilating air inlets or out lets The engine requires a constant supply of cooling air Restricted ventilating air inlets or outlets can cause engine failure 08 6 Electrical Systems A WARNING Exhaust gases are deadly Inspect the generator exhaust system thoroughly before starting the gener ator engine Do not block the tail pipe or situate the motor home in a place where the exhaust gases have any possibility of accumulating either outside under neath or inside your vehicle or any nearby vehicles Outside air movements can carry exhaust gases inside the vehicle through windows or other openings
182. the pump shuts off It can run dry for extended periods without damage See Electrical Systems chapter Turn the pump master switch ON to pressurize the system When a faucet is opened after the initial filling of the tank the water may sputter for a few seconds This is normal and is not cause for concern The water flow will become steady when all air is bled from the water lines J NOTE Turn water pump off before traveling Road vibration could cause a faucet to open If the water pump is on your fresh water supply could be pumped into the holding tank Water Pump Filter Dirt mineral scale and organic matter are filtered out of the fresh water system by an in line water filter on the inlet side of the water pump If you suspect a clogged filter it is easily removed and cleaned Inspect the filter after running the first full tank of water Clean and inspect monthly thereafter The filter is located in the utility compartment behind the service panel 1 Loosen the clamp at the inlet end of the filter 2 Pull the water line off the filter 3 Unscrew the filter from the water pump 4 Turn each end of the filter and pull apart 5 Flush out and clean screen 6 Reverse procedure to install 7 Operate the water pump and check for leaks Low Point Drains To drain hot and cold lines 1 Open hot and cold low point drains 2 Open the shower handle and faucet until all water has drained from
183. the wall or ceiling materials it may cause water stains on the wall or ceiling surface You might think that your walls or ceil ing are leaking You have a problem with con densation if you see these signs You need to do something to reduce the moisture inside your RV Here are some frequently asked questions about condensation and some answers that will help you understand more about your RV and how to keep it comfortable Q In cold weather my windows and walls look like they re sweating Is that con densation A Yes Your windows are a good way to know if the humidity in your RV is too high All air contains water vapor When air is warm it can hold much more water vapor than when it is cold When the air cools the water vapor condenses back to a liquid Since your windows are usually cooler than the air the water collects on the surface of the glass Q Where does all the water come from A Moisture in the air comes from many 06 8 Living With Your Motor Home A sources Some of the most common are Cooking Meals prepared for a family of four can add up to a gallon of water per day into the air from cooking Bathing An average shower can put between 4 2 pounds of water into the air Dishwashing Doing the dishes for a typ ical day s meals can add up to one pound of water to the air Floor mopping When an 8 x 10 kitchen floor is mopped and rinsed
184. ther electrical entertainment device consult the appropriate operational and service manual for recom mended practices The information is located in the Owner s Information Packet This will help avoid scratching discoloring or otherwise dam aging the appearance of the component LCD TELEVISIONS if Equipped The LCD television is set up to operate on a 120 volt AC power source This source can be from the generator shore cord or inverter The front LCD television will not operate while the motor home is in motion because of a power lock out feature 10 3 Appliances J NOTE Do not operate the rear television while the vehicle is in motion Your Owner s Information Package con tains detailed operating and maintenance instructions concerning this system WHOLE COACH SURGE PROTECTION If Equipped The whole coach surge protection unit is located under the bed base or power cord compartment The system is set up to protect the 120 volt AC power source This will include protection of the generator shore power and the inverter Your Owner s Information Package contains detailed operating and maintenance instructions concern ing this system POWER TV ANTENNA If Equipped The roof mounted antenna is designed for reception of VHF and UHF television signals A WARNING Do not raise antenna near overhead electric wires as contact may cause serious injury SATELLITE DISH ANTENNA
185. tice and opportu nity to cure enables the manufacturer to supple ment prior efforts by its authorized dealers so any ongoing problem or dissatisfaction can be resolved or addressed by the manufacturer The manufacturer s written notice should be mailed to American Coach Owner Relations P O Box 1008 Decatur Indiana 46733 MANUFACTURER S OBLIGATIONS Upon receipt of notice of a claim where the dealer was unable or unwilling to resolve the problem a Fleetwood Service Center will repair or replace any parts necessary to correct defects in material or workmanship For motor homes manufactured by the following subsidiaries of Fleetwood Enterprises Inc Fleetwood Motor Homes of California Inc Fleetwood Motor Homes of Indiana Inc Fleetwood Motor Homes of Pennsylvania Inc For Chassis Customer Assistance contact Spartan Motor Chassis Customer Assistance 1 800 543 4277 02 2 Warranty WARRANTY SERVICE If you need warranty service or warranty information please see the booklets and other documents included in your Owner s Information Package If you have any questions about the warranty or what it does or does not cover please contact Fleetwood Owner Relations As a part of the predelivery inspection procedure the dealer is responsible for road testing the motor home noting and correcting any steering problems and setting correct tire pressures before delivery Fleetwood and its subsidiaries wil
186. ting If neces sary use straps to prevent movement 06 4 Living With Your Motor Home e Be sure liquid containers are capped and cannot tip or spill e Secure all glass containers and dishes before traveling e Exterior storage compartments may not be watertight in all conditions Carry any arti cles which could be damaged by water inside the motor home e Care must be exercised when loading cargo into the storage compartments Care must be used not to damage tear or displace the luggage door seals A WARNING Do not store flammable volatile liquids or hazardous chemicals inside the motor home or in outside stor age compartments Toxic fumes from these liquids or chemicals may enter the interior of the motor home Interior Storage The closets and cabinets have catches along one edge of the door Pull on the cabinet door handle to open Overhead doors have supports to hold them open The drawers have a catch along the edge of the drawer Pull the drawer handle to open It is recommended that cabinet drawers should not be loaded to exceed more than 15 Ibs Closets may be equipped with 12 volt lights that turn ON when the closet door is opened Be sure the light goes OFF when the closet door is closed your battery will be discharged if it stays ON If the light stays on when the door is closed the door switch requires adjustment The same loading considerations apply to inte rior storage ar
187. ug is located at the rear of the motor home near the hitch receiver It is a 7 position connector wired as follows TO POWER DISTRIBUTION BOX BATTERY COMP T MARKER LIGHTS TOW D048 POWER LEFT TURN D047 RIGHT TURN NOTCH TRAILER HITCH PLUG AS SHOWN FROM PLUG SIDE Your motor home trailer towing plug is wired to have the turn signals and the brake light acti vated by separate circuits and independent bulbs If your towed vehicle does not have this type of wiring an adapter and alternate wiring will be required The adapter converts the three tail lamp system to a two lamp system where the brake lamp and turn signal share the same filiment You local authorized Fleetwood dealer can assist with this conversion 05 5 On The Road Occupant and Cargo Carrying Capacity and Load Distribution NOTE The Occupant and Cargo Carrying Capacity OCCC printed on the two tags inside the motor home is per the Factory Weight of the motor home and includes all factory options Dealer added weight LCCR is listed on the same tags in writing and must be subtracted from the printed OCCC to attain the OCCC at the time of first sale If any other equipment is added after first sale such as leveling jacks awnings roof pods etc then these items must also reduce the OCCC The occupants and cargo weight you can place in your motor home is the motor home s GVWR minus its current UVW or in other
188. uipped To Lower mini blinds Pull straight down on the cord slightly and move it about 45 degrees to either the left or right and lower the blind Stop the blind in mid travel by moving it back to the straight down position Re attach the retainers when traveling To Raise mini blinds Release bottom of blind from retainer Pull straight down on cord and release at desired height It is not necessary to pull the cord to one side or the other to secure blind To Adjust the angle Turn the adjusting rod either direction To lock cord simply release grip STORAGE Exterior Compartments Exterior storage compartments should accommo date most of your storage needs All of the stor age compartments except the Propane tank com partment can be locked Fire prevention regula tions require that the Propane tank compartment be unlocked at all times Please note Your motor home could be over loaded or out of balance if not properly loaded Refer to the Motor Home Loading section of the On The Road chapter of this manual and follow the loading and weighing instructions in that sec tion When storing equipment and supplies e Always keep tools and equipment stored in areas where they will not shift while traveling e Whenever possible place heavy articles in storage compartments which are low and in the best location for weight distribution Pack articles carefully in the storage com partments to minimize shif
189. ure between the cover and the fiberglass surface 2 Wash the exterior with a mild soap Avoid strong alkaline cleaners and abrasives For the best results use a cleaner formulated for fiberglass and follow the directions for using the cleaner DO NOT use automatic dish washer detergent abrasives bleaches strong chemicals with acids bases or ammonia 3 Wax the exterior at least once a year twice if possible with a wax formulated for fiber glass When waxing always read and follow the instructions and precautions on the con tainer Some cleaners and waxes are recom mended for use on only certain types of sur faces As with automobiles covered storage yields best results for longevity of exterior appearance and ease of maintenance 4 In some cases a light rubbing compound finishing material or other product adver tised to restore fiberglass may be required Always follow the manufacturer s instruc tion Always use a high quality wax after treatment Stains Stains are generally caused by two types of sub stances water soluble and non water soluble Water soluble stains can usually be washed away with water and mild detergent Follow the washing with wax Non water soluble stains are usually oil based Removal of this type of stain may require the use of highly flammable or poisonous solvents Refer this type of service an authorized Fleetwood Dealer Never use strong solvents or abrasives to clean
190. vents cycling between a gear and the next higher gear on a series of short up and down hills MANEUVERING IN TRAFFIC Be cautious when maneuvering to allow for the length and width of the vehicle Always allow room to comer and to change lanes Your vehicle s side view mirrors and rear view camera monitor if equipped will help you keep aware of your vehicle s position and the position of other vehi cles and or obstructions near your motor home You must monitor them constantly while you are driving Become familiar with the operation of the side mirrors and learn to use them to view objects and the road beside and behind the motor home The rear view mirrors are controlled from a panel located on the driver s left side instrument panel Mirrors should be adjusted prior to opera tion of your vehicle in traffic To adjust the mir rors select either LEFT or RIGHT mirror and press the appropriate arrow Activate the mirror heaters if equipped by pressing the HEATER position Remember that your motor home is heavier than a car making it less maneuverable and harder to stop Also because of its greater side surface area it is more easily affected by cross winds Allow extra distances for passing and stopping J NOTE Although your motor home s equipped with power steering the front wheels may be difficult to turn when at a dead stop When maneuvering in some close situations give yourself some room to move
191. water tank Make sure the external gravity fill connec tion is open remove the cap to allow air to escape from the on board tank When water flows out of this external fill the on board tank is full After filling turn the bypass valve to Normal 07 1 Plumbing Systems and Holding Tanks A CAUTION Overfilling the fresh water tank from a pressurized source may cause damage to the water system Monitor water tank filling continually 2 Gravity fill The external gravity water fill is located on the exterior of the motor home The on board water tank can be filled here To fill the fresh water tank remove the cap remove the vent plug and fill the tank using a potable water hose Typical Gravity Fresh Water Tank Fill Draining the Fresh Water Tank Avoid leaving the water in the tank when the motor home is not in use Turn the water pump OFF before draining the water tank Whenever possible drain the fresh water tank before trav eling Water in the tank will reduce the carrying capacity of the motor home See Motor Home Loading section of the On The Road chapter The main water tank quick drain valve may be located on the end of the water tank or in the utility compartment Water Pump The on board fresh water system is pressurized by a self priming 12 volt DC pump The pump operates automatically when the pump power switch is ON and a faucet is opened When the faucets are closed
192. words its maximum capacity minus the current weight of your motor home including fluids such as fuel and propane When the motor home is being designed the number and size of storage com partments the liquid tank capacities and number of belted seating positions are determined for value and convenience If you fill all liquid tanks to capacity fill all storage compartments and cupboards to maximum volume and fill all avail able seating positions with passengers the motor home could be overloaded See Loading Tips Be aware of the weight of the items you store where you store the items in your motor home and weigh your motor home after it is fully loaded In addition to knowing the overall weight that can be safely loaded in or attached to the motor home you must know how to distribute the weight so that correct amounts of weight are dis tributed between the axles or front to rear and also between the wheels or side to side It is also important to place heavier items in under the floor storage or low in the motor home If you make the motor home top heavy or much too heavy on one side the motor home can be over turned and crash in a curve turn or in an emer gency steering maneuver When the load is prop erly distributed your motor home will handle and respond safely and you as the driver can be more confident and will be more comfortable If your motor home is improperly loaded it may be unsafe to drive uncomfortabl
193. y towing If not battery drain on the electrical system could occur the trans mission of the vehicle could be damaged the vehicle may be too heavy to pull among other concerns 05 4 On The Road Before selecting the vehicle that will be towed consult the vehicle manufacturers instructions to ensure the vehicle is approved by the manufac turer for dinghy four wheels down towing Any aftermarket products that modify the dinghy for towing should also be approved by the vehicle manufacturer Make sure that the dinghy weight and attaching hardware do not exceed the motor home hitch receiver rating Make sure that the weight of the motor home and dinghy together do not exceed the gross combination weight rating GC WR of the motor home Make sure that tow bars and hitch equipment is rated to handle the weight of the vehicle you intend to tow In addition the dinghy must be equipped with its own independent auxiliary brake system that is activated any time the motor home brakes are applied Because of State Province regulations care must be exercised when wiring the dinghy for all lighting requirements Check with the DMV of your State and or States and Provinces you will be traveling through for their requirements TOWED VEHICLE WIRING Your motor home is equipped with an electrical connector from here on referred to as a hitch plug which provides an electrical connection for your towed vehicle The hitch pl
194. ylon rollers They are held closed by a catch When the dividers are open for traveling be sure to attach the hold back latch to keep them from sliding back and forth Interior Lighting Both decorative and utility style 12 volt light ing fixtures may be used in your motor home Utility style fixtures may be either single or 06 6 Living With Your Motor Home dual A slide switch selects either single or dual brightness For your convenience some lights are operated from wall switches Clean the lenses with soapy water A CAUTION Some of the lighting fixtures may be equipped with halogen bulbs The bulbs and fixtures may get very hot when they are on Do not touch these lighting fix tures when they are on Allow them to cool before attempting to replace a bulb or to clean Replace all light bulbs with the same type and wattage as origi nally installed or as indicated on the fixture Overhead Vents Overhead vents may be located in the galley and bathroom areas for fresh air circulation and exhausting heat odors and water vapor Turn the crank in the center of the overhead vent to open and adjust Some vents may also be equipped with a 12 volt fan A switch controls fan operation Be sure to turn the fan OFF before closing the vent Some vents may be con nected to a wall switch Close the overhead vents or lower them before traveling to avoid damage from wind and low overhead clearances The vent m

warning - Fleetwood RV.

Contents

Download Pdf Manuals

Related Search

Related Contents