User Manual - electricvehicles4you
Contents
1. and negative posts for circuit shortcut 4 it is forbidden to use other company s charger or other parts and the company shall not be responsible to any loss caused by using other company s charger and parts 6 it is forbidden to allow battery close to fire or other flammable and explosive corrosive gases 7 please do not attempt to dismantle battery battery box in case of the damage of internal parts Do not damage the sticker on the battery and the battery cover otherwise you would lose warranty service 8 it is forbidden to connect the positive and negative posts of battery by wire line or other conductors in case of damaging the battery or other dangers 9 the battery shall be taken up and put down slightly in case of falling collisions IV normal problems and troubleshooting While driving if alarming sound is arisen from control panel and battery capacity display is flashing at same time you shall stop driving and check the vehicle immediately After checking and turning on the power switch you can Page 16 Surpassing Ever Technology Co td continue to drive only if the display is normal but you are only allowed to drive under the speed of 3 5KM H If you find the battery voltage is lower again please get off and walk the vehicle If some problems happened during usage please refer to the followings 1 one side wheel can not rotate that means that side motor control unit may be broken or the motor may be bro2. Surpassing Ever Techno malt Ecogreentrade surpassing Technology for 2013 HTilly aol com Supporting Crohns Research Operational Manual of Auto balancing two wheels vehicle Model RM7016D Dear customers for the safety of you and others for the high performance and reliability of this product please read this operational manual carefully before attempting to drive this vehicle This manual provides daily operation and maintenance knowledge which is helpful for your operations of this product any improper operation would damage your vehicle Due to update of product if any technical description in this manual is inconsistent from the real product the real product will prevail Any content marked with should be read carefully and abided by strictly Page 1 Surpassing SEC e b Page 2 Content 1 important statement to uSers 3 2 structure diagram of electrical vehicle 4 3 installation instructions of electrical vehicle4 4 main technical specification of electrical vehicle 6 5 operation instruction of electrical vehicle 6 6 battery and charging 10 7 maintenance 12 8 notices and warning s sss 13 9 troubleshooting 14 10 RM7016D service instructionS 15 11 warranty Card cce e 12 Sales service policy Surpassing Ever A 6 Important s
3. The battery voltage may still not be enough even the displayed total voltage is higher than 30V especially when the battery was used for long time and the capacity was reduced VI battery and battery charging Battery Characters 1 This vehicle uses lithium battery as power This lithium battery without Page 12 Surpassing Ever Technology Co td memory effect can be charged and discharged at any time without pollution to environment This battery is real green power free from cadmium lead mercury and other harmful substances 2 This lithium battery is safe and reliable It will not burn or explode while meeting Impact crush acupuncture short circuit high voltage charging high temperature and other destructive conditions 3 Fast charging with the dedicated charger the battery will be charged to full condition in 4 5 hours at 25 C ambient temperature it can be charged two times one day 4 Intelligent charging system this system can detect each cell voltage at any time and can realize overcharge protection automatic equalizing charging on each single cell battery 5 The control panel can display the battery voltage the battery shall be charged while the voltage is lower than 30V Charging Instruction 1 Connect the charger and the red indicating light is on 2 Standard charging time with attached standard charger the charging time is 4 5 hours at 25 C ambient temperature Page 13 Surpassing Ever Techn
4. assing Ever Technology Co td Description lithium ion battery without maintenance 6h V driving instruction of electrical vehicle 1 Withdraw vehicle support turn on electrical switch the power switch shall be off during storage transportation or while not in use 2 Uphold the vehicle put single foot on chassis base turn on electrical switch observe the indicating light flashing on display panel without any shaking on the vehicle after indicating light stopping flashing pull back the grab bar slightly if you feel the resistance preventing vehicle collapse that means the vehicle is Started properly and you can drive tt Page 7 Surpassing Ever Technology Co td 3 Driving the vehicle will be driven forward while you slightly tilt your body forward the vehicle will be stopped or driven backward while you slightly tilt your body backward Be gentle and avoid fierce shaking steer the steering wheel right the vehicle will turn right steer the steering wheel left the vehicle will turn left 4 Braking If you need brake the vehicle while driving forward you shall move Page 8 Surpassing Ever Technology Co td your weight center of your body backward immediately and yank the grab bar 5 Steer turning steer the steering wheel for turning after reducing the speed Cautions The speed shall be lower than 8KM H during wide angle turning 6 High speed turning while steer the vehicle right o
5. ehind ba nnn Page 21 Surpassing Ever Technology Co td Picture 13 Picture 14 Placed Picture 15 Page 22 Surpassing Ever Technology Co td 4 Check the whole wire line carefully for any default 5 Plug the electrical outlet 6 Turn on the electrical switch 7 Put one foot on pedal two hands control steering wheel firmly start the vehicle and observe the control panel 8 Put one finger on power switch pull back grab bar slightly watch the wheels rotation direction feel the resistance coming from grab bar If the rotation direction is wrong turn off the power immediately turn the steering wheel right and left and check the steering direction 9 Close the electrical control cab and tighten all bolts 10 Close and lock the battery box Page 23
6. ken or the connection may be dropped off 2 lift one side wheel and rotate the wheel by hand If the wheel can not rotate smoothly that means the side control unit is broken and it shall be replaced 3 there is no response while turning on power switch a battery or battery protection plate is broken please replace battery or battery protection plate b vehicle control governor is broken please replace it c connection terminals are dropped please check and re connect them d PCB is broken replace and test new PCB 4 power switch Is broken replace power switch 5 plug the charger if the charging light is not on please check the battery and battery plate and replace it if necessary 6 battery capacity is lower or the display indicates the battery voltage is lower after charging replace the battery 7 pull the grab bar backward slightly if you cannot feel any resistance and the vehicle is moving forward that means the gyroscope is broken please replace Page 17 Surpassing Ever Technology Co td Troubleshooting troubleshooting The e Charge battery light on panel The battery life is The power switch Change switch is broken e casa I Short driving Battery life is off Change battery ileage afte Battery voltage do Maintain or change one time not match battery charging SS a Battery No output for the cannot be charger charged or Charger cannot be fully charged connected well Change cha
7. ology Co td 3 The charging has over current protection function and permit long time charging charging time less than 18 hours will not affect the lives of battery and charger Charging Precautions 1 Please keep the charging process on safe place where the children cannot reach 2 It is not recommended to drive vehicle while the battery is not full 3 Do not use other brand charger and do not use other brand battery 4 There is high voltage inside of charger and do not attempt to dismantle it 5 Prevent the liquid and metal from coming inside of charger during usage and Storage avoid falling or impact for any damage 6 Do not cover the charger during charging process 7 This charger is indoor model please use it in dry and ventilated environment 8 If you find bad smell or high temperature during charging process please stop charging and send the charger for repair Battery Maintenance 1 Please charge the battery in time after daily driving otherwise the battery life will decrease 2 If the vehicle will not be used for long time please charge the battery before driving The lithium battery shall be fully charged and discharged every half year Page 14 Surpassing Ever Technology Co td Little Knowledge for battery it is normal that the battery capacity will decrease slowly during usage the battery cannot be recovered after it wore out VII vehicle maintenance 1 check the bolts of left and right wheels fo
8. r any loosing 2 check the tire tread for worn out or broken and check the tire pressure 3 check each connection parts and control panel displays 4 if you do not drive this vehicle for long time please charge the battery periodically for better performance normally once every one or two months 5 for the safety of your driving also keep your vehicle in best condition please periodically maintain and clean your vehicle 6 it is forbidden to wash or spay the vehicle by water in case of wetting the electrical parts and wire lines inside or causing potential accident 7 Please use a mild detergent to clean the surface of vehicle VIII Important tips and advice 1 Develop a good habit of charging vehicle in time every day For every driving you shall fully charge the battery in time before it reaches the minimum permit of voltage 2 Almost all batteries will be affected by environment Normally the battery has better performance at high temperature environment and the battery capacity will reduce more than one third when the temperature is lower than 0 So in Page 15 Surpassing Ever Technology Co td winter or clod area It is normal that the driving mileage will decrease after each charging and it will get recovery when the temperature returns 3 when you lift or pull battery box please be cautious of avoiding dropping metal materials such as wire line or key into the charging hole of battery or connecting to Battery positive
9. r left in high speed please lean your body right or left accordingly Page 9 Surpassing Ever Technology Co td es ee Se a m em 5 dm i ai gt a a x r S a d E b a m oaa p gt ms i E k manr eee B o hi j ia i _ SA j E Tm y ee ba i 4 i d _ tam ae sz S BATE ae s Eoi ee N 2 eH mg eg d a a be e T ai Ty it a CAN A E E ee ae k a a LT x a WAS A L UZ E m m 7 Stop reduce the speed until stopping the vehicle keep hands on the grab bar leave one foot off vehicle and after touching the ground firmly then take another foot off the vehicle then turn off electrical switch Do not power off the vehicle while the person is on the vehicle 8 Downhill deceleration Please keep in mind that leaning your body backward while on downhill lane and put your hands on the steering wheel to control the speed 9 While meeting obstacles please lower down the speed to 5 8KM H first and then pass in a constant speed Page 10 Surpassing Ever Technology Co td a p as l C as ee za B x Orta on Z a ast uae ed Te r C bilni aa 7 SZZZZEZBBEBT 10 While meeting impassable obstacles please get off and walk the vehicle there is no necessary to turn off the power in this condition kd 4 Sy 11 While the vehicle get stuck by difficult road conditions do no
10. rging outlet with outlet water enters inside the control The control unit and cause unit was burnt shortcut circuit and components damage Change charger Change control unit TL RM7016 Maintenance Instruction 1 First power off electrical switch 2 Open battery box and take off battery connection plug ensure to disconnect Page 18 Surpassing Ever Technology Co td battery and control unit picture 7 8 ME L X he eR Picture 7 Picture 8 Page 19 Surpassing Ever Technology Co td 3 Open electrical control cab electrical components as picture 10 change damaged parts Gyro got az terminally Battery terminal roscope Lr per Joint motor terminal Mme lt R ESC terminal S L ESC terminal RL ESC ue ee tee aie ak A ca ol BZ 2 6 zi _ a vo d g A g T T L ak K 1 T R Panel wire gt f Dat tory singi l tal kem iS Picture 10 a change governor and control board picture11 1 aw P 9 K 7 h e a a N 4 F E ns i d F a ad 7 N 2 e pue x C F E E a E d aw p k N F a er z E ar _ ni r pe i E a aa a aod N P N j P a E X E a wee E P 29 9 _ a ee a N d a v NA per 9 f n Remove the 6 fixed bolt open the box Page 20 Surpassing Ever Technology Co td Picture 11 b change Gyroscope picture 12 13 14 15 me m Attention head downward face to behind picture 12 ownward face to b
11. t try to get through again and again at same place You shall drive back and then try again or get off the vehicle and walk through if you hear abnormal noise in the wheel that means the electrical motor is in heavy duty load outputting condition the motor and control unit will get heated soon and may be burnt if this condition lasts longer if the vehicle wheels got stuck for a certain time a continuous alarming sound such as DiDi will arise from the control panel You may remove the alarming by driving back or getting off and walking the vehicle otherwise the protection system will be activated in seconds the vehicle will get collapsed for Page 11 Surpassing Ever Technology Co td losing of power J K La E 12 Speed limit Do not drive this vehicle over 15KIM H while the driving speed is over maximum speed limit the continuous alarming sound will arise from control panel and speed display light will flash to alarm that it is over speed simultaneously the vehicle will automatically lean backward to reduce speed the driver shall do deceleration action and do not force to accelerate the vehicle under this condition 13 Lower voltage of battery while the battery voltage is lower there is DIDI sound arising from control panel voltage display is flashing and the system will control the speed lower than 2KM H the vehicle will automatically lean backward to reduce speed you must get off and walk with the vehicle Cautious
12. tatement to users 1 During driving this product you shall strictly abide by the relevant traffic regulations control the driving speed and pay attention to yield to pedestrians 2 Similar as other manned vehicle this product has safety risk during operation you shall take proper safety measures to prevent dangers from happening 3 While the battery voltage is low you shall get off and walk the vehicle 4 This vehicle cannot be driven in rain and snow conditions or wades into water If the water lever is higher than battery box it would cause a short circuit to the vehicle electrical system 5 For the safety of others please do not lend your vehicle to the persons without license in case of unnecessary damage 6 The vehicle battery is a safe power but the battery interface cannot be touched in wet hands or connected by metal otherwise a big short circuit current may be arisen to cause accident Be sure to pay attentions 7 Do not dismantle the vehicle by yourself please buy standard parts from our authorized agency for any replacement 8 Unauthorized modifications are not recommended otherwise your vehicle will lose warranty policy and the factory will not provide after sale services or bear any vehicle damage or other loss Please abide by above statement for any accident happened while driving Page 3 Surpassing Ever Technology Co td vehicle the company only ensure the after sales service of the product itself an
13. y other loss or damage shall be the responsibility of the user ll structure diagram of electrical vehicle picture 1 picture 2 III installation instructions of electrical vehicle 1 Connect the lower grab bar to lower bar base by bolts and lock the bolts Page 4 Surpassing Ever Technology Co td picture 3 picture 3 2 Put the rubber sleeve on the upper grab bar and plug the plastic insert picture 4 Picture 4 3 Put the upper grab bar inside the lower grab bar ensure the hole on the lower bar aligning with the groove of upper grab bar picture 5 Picture 5 4 Install the position and lock device as per picture 6 tighten the nut to adjust the lever of grab bar the nut tightness can adjust the hand feeling of lock Page 5 Surpassing Ever Technology Co td device Picture 6 5 Installation and dismantle of battery box picture 2 Put the key in the switch on the middle of battery box turn to ON position open open the right and left lock of battery box and then take off the box by pulling two sides of box IV main technical specifications of electrical vehicle 1 main specification parameters Load 120KG weight 38KG Max Speed 20KM H Mileage after single charging 30KM Gradeability lt 30 Length 46cm Width 63cm Height 93cm in withdraw condition Tire 1673 5 inch SOOKPA vacuum tire Battery 33V 10AH 2 Main technical parameters of the lithium ion battery Page 6 Surp
Download Pdf Manuals
Related Search