Instruction Cum User Manual For EURO-DEL
Contents
1. each use jars lids overflow cut off valve catheters etc should be cleaned thoroughly When cleaning is necessary after infective fluid has been evacuated the jars lids cut off valve and tubing can be sterilized by autoclaving upto 120 C for 20 minutes Alkaline cleaning agents and disinfectants based on phenyel may not be used Adherence to hospital directives on hygiene is of prime importance The instructions provided by the suppliers of cleaning agents as well as by the manufactures of sterilization and or disinfection units must also be followed where application temperature process duration and airing etc are concerned PUMP The unit is fitted with Piston type oil free pump provides reduced maintenance cost a Open the unit with the aid of an allen key provided and disconnect the tube from the inlet point on the pump housing b Take out the motorized pump fitted on and together with the platform c The fly valves sheet is placed in the top the four screws of which can be opened one for vacuum and the other for outlet The piston is fitted below the top and over the eccentrically rotated came Just wipe clean these parts and set the unit again d There are two openings small and U type large in both the top portions While fitting see that large U of the one face towards the small round of the other and small of the first face the large of the screws can be put back and tightened in their positions e Please run the2. in full accordance with the instruction manual which is solely a guide and no substitute for professional training The safe and effective use of this product largely depends on the skill of the operator We are not liable for any damages due to mishandling or improper and unauthorised use e The company reserve the right to change technical specifications designations and catalogue numbers without prior notice Note Ensure that your electrical wirings are well earthed with 1 line and 1 neutral phase and your voltage is between 220V 240V 50 Hz Ensure that the suction unit should not be lifted above human body level Dispose of used product packaging in safe manner so as not to harm stray cattle children and environment WARRANTY CARD Model No ____LL eee Lee LLL LLL INN eee eee Date of Purchase Dealer Name taal ANAND MEDICAIDS PRIVATE LIMITED Regd Office 33 16 Punjabi Bagh Extn New Delhi 110026 India Tel 91 11 25225225 25229206 42464264 Fax 91 11 25225062 E mail sales anandind com Works 1460 M I E Bahadurgarh Haryana 124507 India EC REP KALEIDOS SH VIA PONTIOA 4 2012 MILANO ITALY www anandind com Page 5 DOC ID NO 6305 REV 01 DATE 09 10 2010 www suction india com
3. refers to sea level According to local conditions and barometric pressure slight deviations in vacuum reading may be noted As a reference the table below shows several factors by which the indicated maximum vacuum value must be multiplied according to the altitude of location where the measurement is carried out Location Maximum Vacuum Location Sea level 1000m 2000m 4000m Factor 1 00 0 88 0 78 0 60 GUIDELINES FOR USE Negative Pressure Before the unit is put to use required vacuum must be _ set by occluding the safety jar nozzle and controlling the releasing valve y na 4 Fully tightened clockwise vacuum control knob means full vacuum E Jars Tubings The material of the jars polycarbonate pc is superior to glass l It is less fragile when subjected to impact and less sensitive to temperature shock PC is resistant upto 12 C provided it is not subjected to any physical loading As the flow rate is high 3 4 filling of the jar is recommended The lid has a built in antifrothing device The jar is easier to clean if a little water or disinfectant is put into it prior to suction operation The safety jar must 2 however remain dry Tubing after repeated use can be brittle and must be changed www anandind e com Page 2 DOC ID NO 6305 REV 01 DATE 09 10 2010 www suction india com Anand MEDICAIDS Instruction Cum User Manual PRIVATE LIMITED For EURO DEL Cleaning and Disinfecting After
4. An ISO 9001 2008 13485 2012 Certified Company Anand MEDICAIDS Instruction Cum User Manual PRIVATE LIMITED For EURO DEL CE 2195 Bacterial Filter Vacuum Gauge Vacuum Control Knob Connector for Patient use On Off Switch i 44 Vacuum cut off valve 1 Itr Jar i th Yi 44 n r m m eT osa pia ae og ii fi d oi Venteuse Cup Dear Customer Congratulations on your purchase of this versatile and need oriented suction unit It will serve you well for years if properly looked after The medical professions have long felt the need for a lightweight easy to move safe dependable and easy to regulate suction unit for labour room EURODEL fills this healthcare need to a degree unmatched by any other unit It is designed for use in hospitals nursing homes and labour rooms Non corrosive and shockproof enclosure is pressure moulded in engineering plastic ABS giving smooth and easy to clean surface ASSEMBLY The pump is housed in the enclosure Small tube with push in nozzle also filter is inserted in the slot on the jar lid the other end being connected to the nozzle on the panel The second nozzle on the lid is for the tubing to the patient The release valve for adjusting the negative pressure and the vacuum gauge are on the panel An on off switch cum pilot lamp fuse and the removable main lead connector are on the side Before the unit is put on please see that 1 O rings on push in
5. connector are not worn out 2 Jars are checked for possible crack or flawed spots Any defect can result in implosion under vacuum www anandind e com Page 1 DOC ID NO 6305 REV 01 DATE 09 10 2010 www suction india com A Anand MEDICAIDS Instruction Cum User Manual PRIVATE LIMITED For EURO DEL 3 Check the bacterial filter and change the filter element if necessary The housing must be flip tightened 4 The lid and tube are tightly placed on the jar To avoid leakage the push in and angular connectors must be inserted as far as the stop While unplugging twist and pull 5 The main power supply is well earthed In case of fluctuation use voltage stabilizer corrector 6 The vacuum control knob is not loose It must be fully tightened clockwise TECHNICAL Housing Engineering moulded ABS plastic cabinet with built in handle Capacity 0 575 mm Hg 10 at 15 Itr min Fine regulation vlave for neccessary adjustment with break mechanism under thumb in venteuse cup Hi Low switch provides full or half vacuum with one flick Pump type Oil free piston pump Jar 1 Itr PC Vacuum Gauge Bourden type 5 cms 0 700mm Hg calibration Filter Bacterial filter Power 220V 50 Hz Single phase 110V on request Venteuse cup Silicone 50mm 60mm and 70mm minimizes risk of trauma and cephalohematome of fetal cramium Dimension amp Weight 33 x 14 x 29 cms 6 kg VACUUM AT ALTITUDES The specified maximum vacuum
6. the cause is external External cause Bacteria filter safety jar overflow valve in the Investigate the whole external suction circuit lid float valve push in connectors tubing etc for blockage s float valve sticking kinked tubing and rectify Pump does not suck however If the vacuum gauge still indicates a vacuum the cause is internal Vacuum gauge indicates a vacuum www anandind com Page 4 DOC ID NO 6305 REV 01 DATE 09 10 2010 www suction india com Anand MEDICAIDS Instruction Cum User Manual PRIVATE LIMITED For EURO DEL TERMS OF WARRANTY Anand Medicaids Private Limited warranty the high quality and workmanship of each Anand s HI VAC for a period of one year subsequent to the date of delivery by the company During this period faulty material will be replaced free of charge This warranty does not extend to components that are subject to wear and tear in the course of normal operation or due to improper treatment maintenance as per instructions Further conditions in accordance with international standard IEC 601 1 item 6 8 2b The manufacturer is only responsible for effects on the safety the reliability and the performance of the appliance if e Installation additions adjustments modifications or repairs are carried out by personnel authorized by the manufacturer e The electrical installations within the room concerned satisfy the requirements laid down by IEC e The appliance is used
7. unit and see its satisfactory functioning before housing is screwed up Unlike the rotary design NO LUBRICATION IS REQUIRED IN THIS PUMP The unit has not to be tampered with by any mechanic other than our factory engineer or the person authorized Patient Filter A i Gauge i Q L ___i PPA a r Release ar Valve ESTEN E ee S ar N Inlet E Outlet MOTORIZED PUMP www anandind com Page 3 DOC ID NO 6305 REV 01 DATE 09 10 2010 www suction india com Anand MEDICAIDS Instruction Cum User Manual PRIVATE LIMITED For EURO DEL TROUBLE SHOOTING Possible source of trouble Check Action to be taken Power Supply Voltage power socket Main switch Set at ON Electrical cord Plug type plug connections damaged cord The blood has entered the pump The remedy is given above under pump cleaning Leak within the pump or in the external Isolate the source of trouble by carrying out Suction circuit the checks outlined External cause Push in connector O rings Lid gasket Condition Push in and angular connectors Tubing Lid Jar Filter paper Condition position of housing Blockage or kink in tubing within the Isolate source of trouble as follows Motor does Not Run Inadequate Suction Performance pump or in the external suction circuit Remove the safety jar from the pump leave the suction connection open If the vacuum gauge now indicates zero vacuum
Download Pdf Manuals
Related Search