Stannah Stairiser SR Feb 2014 - Stannah Technical Information
Contents
1. Battery Charge System The motor of the stairlift is powered by batteries which are reloaded by a recharger The recharging occurs in the upper and lower stop positions by recharge contacts therefore if the lift is not in use it is important that it is parked in the stop positions An acoustic warning signal sounds if the stairlift is parked outside of the stop position The Beeper eon If the platform is not in the stop position within 5 minutes after use the beeper will sound every second If so please bring the platform to the stop position If the lift is parked in the stop position and the beeper still gives signals this suggests on a problem with the recharger Please turn off the lift mains power switch and check if there are building power outs or if a fuse is not working If any such errors are corrected and the beeper is still giving signals please contact your Service Branch If the battery voltage is too weak for normal operation then the beeper will sound en every 2 5 seconds Please bring the carriage in the stop position to recharge the batteries If the beeper does not stop after recharging then the batteries may need to be changed Even with weak batteries the control system is programmed to ensure the carriage always reaches the lower position with the remaining battery voltage GENERAL LAYOUT Landing Controls The Stairiser SR is equipped with landing controls that communicate via radi2. Case 2 The occupied platform is not close to a stop position For the rescue of the passenger two persons are needed If Main there is only one person available it is necessary to wind the f f i power carriage into the next station see case 1 switch Notice The main power switch is on the side of the platform wall 1 Switch of main power switch Insert hand wheel 3 Tighten the hand lever for break release and turn the hand Ope wheel until the position has been reached where the dis a tance between the rail and the steps are minimal bar 4 Emergency unclamping of the barrier In order to open the a barrier when not in a station please carry out the following r 19 instructions It is only permitted to open the barrier up to the ka stairs see page 18 Otherwise one could face the danger Or of falling or rolling down 5 Detailed instruction for the emergency unclamping is given on page 23 6 The wheelchair driver can now be lifted down from the plat form 7 If using a manual platform close the platform as usual That means First close the barriers and then fold up the platform 8 If using an automatic platform first fold down the barrier to the closed position Now the platform can be closed without any problem The platform must be locked with the padlock on the carriage 9 Call your service team Insert Break release Hand wheel amp break lever Always res cue with two people assisti
3. hs The carriage start travelling after pressing the directional control on the X platform and stops after about 10 cm Please close amp No gee Are all barriers the barriers closed _ Yes we TT Check if the ramps and the safety pad if Does the stairlift gt No existing on the underside of the platform are i operate free of contact with obstacles Yes When all barriers and ramps are free of contact with obstacles please close the barriers also when the automatic platform is used once more by pressing it down manually Try to start travelling once again lt a Yes S Does the stairlift operate lt No y Carry out the instructions given in the paragraph Rescue of passengers Fi N Contact our service team and OK ask for advice 26 27 28 29 Stannah Lifts Ltd Anton Mill Andover Hampshire SP10 2NX Tel 01264 339090 Stannah STANNAH SERVICE BRANCHES CONTACT STANNAH LIFT SERVICES LIMITED AT SCOTLAND 45 Carlyle Avenue Hillington Industrial Estate Glasgow G52 4XX Tel 0141 882 9946 Fax 0141 882 7503 NORTH amp NORTH EAST ENGLAND Wellington Road Dunston Gateshead Tyne amp Wear NE11 9JL Tel 01914 600010 Fax 01914 601143 NORTH WEST ENGLAND amp NORTH WALES 6850 Daresbury Park Daresbury Warrington WA4 4GE Tel 01928 7031
4. 1 1 Key switch 2 Emergency Stop 3 Barriers 4 Carriage cover 5 Drive controls Up down 6 Green lamp 12 OPERATING INSTRUCTIONS When the passenger has moved onto the platform in accordance with the Driving Moving onto the platform instructions the platform control must be switched on e Put in the key and turn it into ON position The green lamp will start to glow Turn key ON e Now the carriage can be set in motion by pressing the up or down directional controls The carriage stops at all stop Watch the positions upper lower intermediate stop path of the automatically When the directional control lift on the remains pressed during an intermediate stop the carriage will stop for about two seconds then the carriage will continue travelling towards the planned stop posi tion stairs Always watch the path of the lift on the stairs If there is danger that the platform will hit an obstacle stop the lift by releasing the control button The lift will automatically stop when it reaches your destination If there is an intermediate stop the lift will continue to travel after a pause of 2 seconds if the directional control button remains pressed The carriage will stop if obstacles are encountered carriage In the unlikely event that the stairlift does not stop when the directional control button is released press the emergency stop button a self locking butt
5. on with the key the directional control is pressed but the carriage does not move TS the platform closed T Yes Is the green lamp at the wall control glowing when calling the lift Yes No No gt lt y existi Check if the ramps and the safety pad if ng on the underside of the platform are free of contact with obstacles y c c heck if all emergency stops on the arriage and on the landing controls are unlocked va v iS Tiy to control the stairlift from the landing control s aS nearest to the carriage Yes Yes Does the stairlift operate lt No AA Open the platform and close the barriers y ry to control the stairlift from the directional control on the carriage lt lt Does the stairlift Yes operate T No check the fuses in the controlbox as described in this handbook A S8 A Does the stairlift Operate2 Ne Y No y N Contact our service team and ask for advice e the form v Check if the platform is closed completely and if N there is no object jamed pi between the platform and the carriage y o lt Does the stairlift gt gt operate Yes v 2 r X Probably the platform has not been closed completely Nu 25 TROUBLE SHOOTING GUIDE
6. the STOP switch it will be necessary to press it once more or to turn it clockwise We recommend preventive checks are carried out on the lift Regular servicing of your stairlift will ensure safe operation for a long time Any abnormal operation of the lift should be reported to the service office In the case of irregularities such as vibrations or abnormal noise emissions do not use the lift call your Service Branch NEON AN Oon Pe IS TA ENE Key switch Emergency STOP Ramps Barriers liftable Carriage cover Directional control Folding seat option Main control button at the carriage side Green lamp Drive behind the carriage sidewall Gear box Motor Hand wheel Hand lever for break release Lower guide rail toothed rack Aa US ww GENERAL LAYOUT Technical Details X Standard Performance O Optional Performance Feature 00 Detail ih cr ictatoerism a standard 750 x 850 mm standard 800 x 900 mm standard 800 x 1000 mm Optional size OOOO oo i O GENERAL LAYOUT i 2 3 F 4 5 6 x 8 9 Wall control Recharger Carriage Upper stop position Lower stop position Intermediate stop position Upper railway tube Lower railway tube Overspeed governor J s e000 oo
7. 70 Fax 01928 714824 MIDLANDS EAST 48 Bleakhill Way Mansfield Nottinghamshire NG18 5EZ Tel 01623 631010 Fax 01623 636182 WEST MIDLANDS amp MID WALES Unit A6 Coombswood Way Halesowen B62 8BH Tel 0121 559 2260 Fax 0121 559 8171 SOUTH MIDLANDS amp HOME COUNTIES Unit 4 Boundary Road Buckingham Road Industrial Estate Brackley Northants NN13 7ES Tel 01280 704600 Fax 01280 701187 EAST ANGLIA Unit 27 28 Morgan Way Bowthorpe Industrial Estate Norwich Norfolk NR5 9JJ Tel 01603 748021 Fax 01603 743097 SOUTH WEST ENGLAND amp SOUTH WALES Unit 2 Brook Office Park Emersons Green Bristol BS16 7FL Tel 0117 906 1380 Fax 0117 955 5993 LONDON amp THE SOUTH EAST Unit 8 Swan Business Park Sandpit Road Dartford DA1 5ED Tel 01322 287828 Fax 01322 222720 SOUTHERN ENGLAND 6 Ambassador Park Estate Airfield Road Christchurch Dorset BH23 3TQ Tel 01202 476781 Fax 01202 485424 NATIONAL CONTRACTS No 1 Ravensquay Business Centre Cray Avenue Orpington Kent BR5 4BQ Tel 01689 883240 Fax 01689 883241 NOTE Whilst every effort has been used to ensure the clarity and accuracy of this Handbook we cannot be held responsible for damage or injury resulting from negligence or misuse of this lift equipment We are continually developing and improving the Stairiser range and we therefore reserve the right to alter or amend the specification without prior notice The Stanna
8. S Driving Moving onto the Platform You can move onto the platform after you have opened the platform and the barrier in ac cordance with the former chapter Always face the direction of travel and use the wheelchair brake for safety Press the button for open on the wall control as long as the platform is horizontally positioned and the barrier is opened When opening the other controls are automatically disabled so that no other person can move the lift at the same time Always keep a clear view of the path y of the lift on the stairs image 6 If there is any danger immediately stop the movement of the lift by re leasing the pressed button Switch off the platform control by turning the key into OFF position Take out the key When the unlocked barrier is opened the ramp will automatically fold down image 7 The barrier down to the staircase is always locked excepting at the lower stop position special customer request Always face the direction of travel and use the wheelchair brake for safety Close the barrier when on the platform image 8 When the barrier is closed the ramps will automatically lift up This is an additional safety feature that secures the wheelchair Open platform amp barrier Open barrier amp enter platform chair 1 brakes Travelling The carriage control on the sidewall consists of a directional control on spiral cable a key switch and a
9. STAIRISER SR USER HANDBOOK IMPORTANT Before using your Stannah Stairiser platform stairlift please ensure that you read and familiarise yourself with these instructions Introduction Intended Use General Layout Operating Instructions Emergency Operations General Stairlift Care Procedures Trouble Shooting Guide Notes Guarantee Service branch contact details NOTE Whilst every lift has been made to ensure the clarity and accuracy of this hand book we cannot be held responsible for any damage or injury resulting in negligence or misuse of this stairlift 10 20 23 24 27 30 31 INTRODUCTION This users handbook is to help provide an understanding of correct and safe use of the Stannah Stairiser SR It is important that you arrange for the lift to receive regular inspection and servicing by a competent person at intervals not exceeding six months after the 12 months guarantee period Failure to ensure servicing is carried out could lead to unreliable or unsafe operation For all enquiries regarding servicing please contact your local Stannah Service Branch details in the back of this User Handbook A Service Log Card will be completed after each service visit For your records KEY SYMBOLS The following signs are used as a guide throughout the handbook Pay attention to all paragraphs marked with this sign These paragraphs contain important hints that will insure flawless operation of th
10. e lift duces the possibility of hazardous situations Pay attention Do not execute the actions marked with this sign Y WARNING Important safety advice Observing these instructions greatly re Load Capacity The maximum capacity of the lift is indicated on the front face of the carriage Safe working load 225 kg wheelchair and occupant e This stairlift SR must only be used for the transport of persons in wheelchairs or sitting on the optional fold down seat e Never use the stairlift in the standing position e The stairlift is not designed for carrying goods or animals of any kind The exceptional use by trained guide dogs is permitted e Remove key switch from both the lift and the platform after use e Do not let children play on the lift e Do not exceed the maximum platform load or maximum wheelchair size e Keep hands and fingers away from the back of the carriage e Passengers must remain in the wheelchair or seat while the lift is operating Persons walking up or down the stairs while the lift is being operated must avoid contact with the platform Platform users should take into consideration that the platform needs more space in a bend than on a straight railway Therefore before moving look to see if anyone is using the stairs or if there are any obstacles Emergency Stop An emergency stop is fitted on the carriage In case of emergency press the red STOP switch and the lift will stop immediately To release
11. ge 14 To avoid unauthorised use of the stairlift always switch it off with the key when not in use Close platform EMERGENCY OPERATION If it necessary to evacuate a user from the lift due to either lift or power failure the proce dures described here should be followed A different process is needed dependant on where the platform has stopped Case 1 The occupied platform is near a stop position bet oa Mai Notice The main power switch is on the side of the platform awed wall 5 switch 1 Switch of main power switch Insert hand wheel 3 Tighten the hand lever for break release and turn the hand wheel until the next station has been reached 4 At every landing the barrier can be opened manually at the side where leaving the plat form is desired 5 Now the wheelchair driver can leave the platform 6 If using a manual platform close the platform as usual That means First close the bar riers and then fold up the platform 7 If using an automatic platform first fold down the barrier to the closed position Then the platform can be closed without any problem The platform must be locked with the padlock on the carriage 8 Call your service team Attention Rescue of passengers can only be done by authorised people Hand wheel and break lever Insert hand wheel Break release Ws Ih Cs Attention Rescue of passengers can only be done by authorised people 20 EMERGENCY OPERATION
12. h Promise Always true to our word Anton Mill Andover Hampshire SP10 2NX Telephone 01264 339090 www stannahlifts co uk
13. lid only for carriages equipped with automatic platforms and barriers Wall Controls All automatic platform lifts are equipped with wall controls which allow control from either end of the staircase and allow to fold down or up the platform Landing controls are fitted in the area of landing positions Emergency switch if existing UP Button DOWN Button Close Button Open Button Key switch Green light ark WP Oo eo O ea If the platform is not on the level on you require call the platform by using the wall controls Switch on the wall control by inserting and turning the key Press the Up or Down Button and the platform moves into the direction as long as you hold the button The green light starts to flash The carriage travels as long as you keep the directional button on the wall control depressed on Wall controls only control the lift when the platform is folded up The carriage stops automatically at the stop position To use the lift fold down the platform by using the Open Button Press the button as long as it takes that the platform is in horizontal position and the barrier has opened completely Simultaneously the ramps turn down to the correct position enabling safe driving moving onto the platform When the platform is folded down all controls other than the platform control lose their functionality This allows safe movement onto the platform 16 OPERATING INSTRUCTION
14. ls If the main power switch and the key switch are switched on the green lamp on top of the carriage is illuminated The main power switch connects the stairlift to the power supply system For use of the lift first turn on the main power switch By switching off the main power switch the stairlift can be isolated from the circuit Main switch It is necessary to switch off the main power switch while repairs are done to the stairlift especially in the drive box Before operating the lift ensure that the platform area is clear OPERATING INSTRUCTIONS MANUAL PLATFORM OPERATING INSTRUCTIONS The following comments are valid only for carriages equipped with a manual platform Calling of the platform Most lifts are equipped with wall controls that allow control from either ends of the staircase Landing controls are fitted in the area of landing positions Battery behind cover Up Button Down Button Key switch Green light pe a ra aR WN If the platform is not on the level on which you want to move onto the platform you can call the platform by using the wall controls Switch on the wall control by inserting and turning the key Press the Up or Down button and the platform moves in the direction requested as long as you press and hold the button The green light will start to flash on Wall controls only control the lift when the platform is folded up y Always make sure that y
15. n emergency stop image 9 The platform contains a directional control con nected to a spiral cable a key switch an emergency stop and a green control lamp at the side of the platform On some models there may also be a key switch at the side of the platform Key switch Emergency Stop Barriers Carriage cover Drive controls Up down Green lamp aaRwWN When the passenger has moved onto the platform in accordance with the Driving Moving onto the platform instructions the platform control must be switched on Put in the key and turn it into ON position The green lamp will start to glow image 10 Switch on the key switch OPERATING INSTRUCTIONS lift on the stairs If there is danger stop the lift by releasing the control button The carriage stops when the ramps or any other safety pad travels against obstacles image 11 V Always maintain a clear view of the Switch The lift will stop automatically when it on the reaches it s destination If there is an key intermediate stop the lift will continues switch after a pause of 2 seconds if the direc tional control button remains pressed Watch After the lift stopped the drive button the path must be kept pressed until the barrier of the opens If you don t want to stop at an lift on intermediate stop position briefly the stairs release the drive button and activate it again in the same direction The lift will briefly sto
16. ng 22 EMERGENCY OPERATION Emergency Unclamping of Barrier For unclamping a barrier somewhere out of a station press the lever located at the back of the carriage The position of this lever is shown in detail on the drawing beside Attention The red marked lever must be pressed for unlocking the bar rier up to the stairs Do not press the unmarked lever in this case the downside barrier would be opened and there is dan ger of falling down the stairs Press and hold this lever and open the barrier with an abrupt pull Levers for unclamping are at the backside of the platform The lever for the emer gency unclamping of the barrier up to the stairs is marked RED VE GENERAL STAIRLIFT CARE It is absolutely necessary that the lift is serviced regularly to ensure safe operation Stannah Lift Services Ltd offers a special maintenance programme adapted to the frequency of use Check Up amp Care Check the following points at regular intervals say once a week 1 The carriage must not start travelling until the barrier is completely folded down and the ramp is turned down to the appropriate position 2 It should be impossible to fold up the barriers while travelling This should be tested be tween two stop positions 3 Check if the barriers are closed and if the ramps are folded up while travelling If the ramps run against an
17. o with the carriage With these controls the lift can be called and sent when the platform is closed In the case of automatic platform the platform also can be opened and closed with the con trols The controls are supplied by one 9volt battery A connection cable to a constant power sup ply is possible The life time of the battery is approximately one year In general the battery is usually changed during the service The functionality of the battery can be checked as follows e In each wall control a green lamp is installed e This lamp will begin to flash if the key switch of the control is switched on and control buttons are depressed e If the lamp does not flash a change of the batteries will be necessary 10 OPERATING INSTRUCTIONS The Stairiser SR is easy to use The technical control of the lift is entirely adapted to the abilities of physically handicapped persons Please refer to the general layout on the previ ous pages for a better understanding of the stairlift There are two types of platform operation manual or automatic Manual platforms must be opened by hand the barriers have to be lifted as well Automatic platforms perform these functions automatically Main Power Switch The main power switch is located at the left side wall of the carriage For use of the lift first turn on the main power switch By switching off the main power switch the lift cannot be used also disables the wall contro
18. obstacle or if the user presses down the ramp the carriage will have to stop immediately The linkage between barriers and ramps must be in fault less condition safely screwed on no damage of the rope 4 The carriage has to stop automatically at every stop position The carriage must stop when the directional control is released The brake has to be activated immediately The emergency stop button must put the whole stairlift out of operation If an emergency call system is in place ensure that it works Remove dust and dirt from the tubes of the railway at regular intervals Keep the access free to the drive and to the main power switch Nn SO Oh a For cleaning the stairlift use a soft cloth and soapy water D All further maintenance work is only allowed to be done by Stannah Lift Services ltd or any of our authorised partners DISMANTLING REMOVAL OF STAIRLIFT You should not attempt to dismantle any parts of the stairlift Such work should be entrusted only to competent personnel with relevant expert knowledge and training Advise any malfunctions of the lift operation to the Stannah Service Office or to our service personnel when they are next in attendance 23 TROUBLE SHOOTING GUIDE For safety reasons the Stairiser SR is equipped with several electrical and mechanical lock ing devices The stairlift will not work if any of these devices are tripped or if the order of events is incorrect By following the ins
19. on and the lift will stop immediately To unlock the emergency stop button press it once more or turn it clockwise y As a safety measure the lift is equipped with an emergency stop red button on the OPERATING INSTRUCTIONS Leaving the Platform The stairlift has been designed to stop in the correct position at each landing Release the directional control when the carriage has reached the desired stop position Switch off the platform control by turning the key into OFF position Take out the key image 3 Turn off are k itch Lift the unlocked barrier image 3 and the ad it g ramps will automatically descend to the turn the Sea down position Now you can leave the platform To avoid unauthorised use of the stairlift y always switch it off with the key when not in use image 3 After leaving the stairlift lift down the barriers and fold up the platform By folding up the platform the wall controls landing controls will be re activated The carriage can be sent to the desired parking position image 4 L th eave the platform releasing the directional control button then the lift is probably not in the exact re charging position Please reactivate the drive button to send the lift in the final posi tion image 5 V If there is an acoustic signal 5 seconds after Platform closed 14 OPERATING INSTRUCTIONS AUTOMATIC PLATFORM OPERATING INSTRUCTIONS The following comments are va
20. ou have a clear view of the path of the lift when moving the carriage on the stairs Stop the lift immediately if there is an obstacle in the way y Should the carriage not stop after releasing the drive button use the key switch to stop the lift Unfolding the Platform In order to enter the lift the platform or the seat has to be opened When opening the other controls are automatically switched off so that no other person can move the lift at the same time and a safe passage onto the lift is possible OPERATING INSTRUCTIONS Driving Moving onto the Platform When the unlocked barrier is opened the ramp will automatically fold down Image 1 The barrier down to the staircase is always locked except at the lower stop position special customer request Open barrier and enter platform Always face the direction of travel and use the wheelchair V brake for safety Close the bar rier when on the platform image 2 When the barrier is closed the ramps will automati cally lift up This is an additional safety feature that secures the wheelchair Travelling The carriage controls consist of a di Use rectional control on a spiral cable a wheelchair key switch and an emergency stop brakes The platform contains a directional control connected to a spiral cable a key switch an emergency stop and a green control lamp at the side of the platform On some models there may be a key switch at the side of the plat
21. p and then continue to drive in the desired direction control Press the emergency stop button and the lift will stop immediately To unlock y As a safety measure the lift is equipped with an emergency stop red button on the the emergency stop button press it once more or turn it clockwise 18 OPERATING INSTRUCTIONS Leaving the Platform The stairlift has been designed to stop in the correct position at each station Lift up barrier Keep the directional control button pressed until arm the barrier has folded up and the ramp has and folded down to the correct position image 12 switch When the barrier is fully opened and the ramps off the are fully folded down release the directional key control switch Switch off the platform control by turning the key into OFF position Take out the key Now you can leave the platform image 13 After leaving the platform you have to switch on the wall control by putting in and turning the key Press the Up Button and the platform folds up as long as you hold the button Press the Up Button until the platform is folded up com pletely Now switch off the wall control by turn ing back the key to position OFF Take out the key before travelling away from the stairlift Leave platform By folding up the platform the wall controls landing controls will be re activated The carriage can now be sent to the desired parking position for recharging ima
22. tructions provided in the ensuing paragraphs the user will be able to determine the reason for breakdown You must not manipulate modify or remove any safety feature of the stairlift Work through the following instructions paragraph by paragraph Do not skip any part Be sure that the landing controls are deactivated whenever the platform is folded down Before trouble shooting pay attention to the following When a landing control is activated it automatically deactivates all other wall con trols i e the complete lift can only be controlled by one control at a time If a wall control activates the parked lift no other control can signal the lift as long as this wall control is active Please check that the main power switch located at the left side of the drive box is activated The green lamp on the platform should now glow Please check if the fuses in the distribution box of your house business are working and turned on If the lift is giving acoustic signals please check the batteries as described in the sec tion battery charge system If you call the service please note your lift number This you find at the front of the carriage under the serial number It is the easiest way to identify your lift to give fast and efficient advice 44qq 4 24 TROUBLE SHOOTING GUIDE Close the platform operate Yes lt Does the stairlift eo The landing control has been turned
Download Pdf Manuals
Related Search