Home

Sentinel CBRN PAPR Instruction Manual

1. 5 Fit the Waist belt length to your waist size when dressed in your protective garments 12 S 2018 REV D Invaild if not in process 5 days from MC Print Date A WARNING ALWAYS DON THE RESPIRATOR IN A NON CONTAMINATED AREA FAILURE TO PROPERLY DON THIS RESPIRATOR BEFORE ENTERING A HAZARDOUS ATMOSPHERE MAY RESULT IN INJURY OR DEATH IF YOU HAVE ANY DOUBTS ABOUT THE APPLICABILITY OF THE EQUIPMENT TO YOUR JOB SITUATION CONSULT AN INDUSTRIAL HYGIENIST OR CALL THE TECHNICAL SERVICE DEPARTMENT OF ILC DOVER at 1 800 631 9567 DO NOT REACH YOUR HAND INTO THE HOOD IN AREAS WHERE THE AIR IS CONTAMINATED LEAVE THE CONTAMINATED AREA AND CLEAN CONTAMINANTS FROM YOUR HANDS BEFORE REACHING INSIDE THE HOOD DECONTAMINATION PROCEDURES If the Sentinel XL PAPR CBRN becomes contaminated with any CBRN agent decontamination must be completed using specific protocol and directives of the agency using this product followed by disposal of the product REMOVING THE PAPR SYSTEM Only remove the Sentinel XL PAPR CBRN system while the blower is operating The Sentinel XL PAPR CBRN should not be removed if you are not sure you are in a safe uncontaminated area If you have been in achemical biological environment the outside of the Sentinel XL PAPR CBRN will be contaminated Only persons wearing appropriate protective gloves and clothing should conduct respirator decontamination and removal You and the Sentinel XL PAPR CBRN must
2. Chemical Test Agents Filter Gas Life Challenge Concentration ppm 170 Ipm both 25 and 80 RH Ammonia NH3 Cyanogen Chloride CK Cyclohexane CsH12 Formaldehyde HCHO Hydrogen Cyanide HCN Hydrogen Sulfide H2S 0 3 Test Agent Allowable Breakthrough PPM Service Time Min Nitrogen Dioxide NO2 Phosgene COCh Phosphine PHs PSO Sulfur Dioxide SO2 Sum of HCN and C2N gt Nitrogen Dioxide breakthrough is monitored for both NOzand NO The Breakthrough is determined by which quantity NO2 or NO reaches breakthrough first CUSTOMER SERVICE INFORMATION If you need additional information on the Sentinel XL PAPR CBRN or any ILC Dover product consult your distributor or contact Customer Service ILC Dover One Moonwalker Road Frederica DE 19946 2080 Phone 800 631 9567 OR 302 335 3911 ext 506 Fax 302 335 1320 www ilcdover com 36 S 2018 REV D Invaild if not in process 5 days from MC Print Date This respirator provides respiratory protection against inhalation of certain gas and vapor chemical agents biological particulates and radiological and nuclear dust particles This respirator provides limited dermal skin protection to the head area and eyes This respirator does not protect against radioactive x rays gamma rays or neutrons Eye irritation may be experienced based upon the Chemical Biological Radiological and Nuclear CBRN agent and exposure concentrati
3. Invaild if not in process 5 days from MC Print Date NIOSH APPROVAL For a listing of the components in the ILC Dover respirator systems ILC Dover SENTINEL XL PAPR CBRN that are NIOSH approved refer to the NIOSH approved label insert NIOSH CAUTIONS AND LIMITATIONS A B C F T 7 O Z Zr 5 A GG QQ Not for use in atmospheres containing less than 19 5 percent oxygen Not for use in atmospheres immediately dangerous to life or health Do not exceed maximum use concentrations established by regulatory standards Do not use this respirator 1f airflow is less than four cfm 115 Ipm for tight fitting facepieces or six cfm 170 Ipm for hoods and or helmets Follow established cartridge and canister change schedules or observe ESLI to ensure that cartridges and canisters are replaced before breakthrough occurs Contains electrical parts that may cause an ignition in flammable or explosive atmospheres Failure to properly use and maintain this product could result in death or serious injury Follow the manufacturer s instructions for changing cartridges and or filters Allapproved respirators shall be selected fitted used and maintained in accordance with MSHA OSHA and other applicable regulations Never substitute modify add or omit parts Use only exact replacement parts in the configuration as specified by the manufacturer Refer to users instructions And or maintenance manuals for information on use and ma
4. be decontaminated Be aware that touching or removing a contaminated Sentinel XL PAPR CBRN after it has been decontaminated could lead to skin contamination or exposure to toxic materials Once you have removed the Sentinel XL PAPR CBRN be sure to place it where others cannot accidentally handle it It must be disposed of carefully and in accordance with local state and federal guidelines A WARNING DO NOT ATTEMPT TO CLEAN AND RE USE ANY SENTINEL XL PAPR CBRN COMPONENT THAT HAS BEEN EXPOSED TO A CBRN AGENT CBRN AGENTS MAY ADHERE OR BE ABSORBED INTO SPECIFIC SENTINEL XL PAPR COMPONENTS AND MAY NOT BE EFFECTIVELY REMOVED WITH THE USE OF CLEANING MATERIALS REUSE OF ANY COMPONENT OF THE ILC SENTINEL XL PAPR CBRN FOLLOWING CONTAMINATION OF CBRN AGENTS MAY RESULT IN SERIOUS INJURY OR DEATH DISPOSAL OF CARTRIDGES Remove used Cartridges and dispose of properly Handle Cartridges with care Cartridges may contain the contaminant that was in the atmosphere while the Cartridges were being used and they must be handled as a contaminated or potentially contaminated object Disposal of Cartridges must be in accordance with state and local environmental regulations 26 S 2018 REV D Invaild if not in process 5 days from MC Print Date 7 Cartridge Installation Verify that the Cartridges are the appropriate type for the application by examining the label attached to the cartridge e Before removing the Cartridges verify th
5. in the area above the face shield You should feel the air entering into the hood e Don the hood Place your thumbs on both ends of the padded part of the head strap with the visor facing your body Place the hood on your head the padded part of the head strap should be centered on your forehead The pictures below illustrate the positioning of the head harness on the forehead Incorrect Incorrect Too high Too low Correct 24 S 2018 REV D Invaild if not in process 5 days from MC Print Date PAPR BACKPACK COMPONENT INTEGRATION The Sentinel XL PAPR CBRN system is shipped with components pre installed in the backpack Use the following instructions for general storage or addition of replacement components in the backpack L 4 Position the blower on the backpack pad the charging socket is Open the package boxes and take out the components e Blower S 2002 installed in backpack e Battery S 2003 Rechargeable NiMH Battery Pack Assembly or S 2004 Non Rechargeable LiMnO2 Battery pack Assembly installed in blower e Alkaline Battery Adaptor S 4013 Optional Batteries NOT included e Battery charger with Instructions S 2009 e Cartridge x 3 with Instructions S 2016 e Flow Meter S 2010 e Backpack S 2007 e PAPR Hood S 2001 Insert the hood wrapped in its plastic bag into the backpack hood compartment and close the hood compartment using the zippers Open the blower compartment cover roll it upw
6. reason or purpose until ILC has been notified of the proposed return and Buyer has signed and returned an ILC Return Goods Authorization RGA form Under no circumstance will ILC accept return of a product which has been exposed to known carcinogens toxic or biological materials 6 This document contains the complete statement of product Warranty by ILC and no Warranty or representation not set forth herein has been made to or is relied upon by Buyer No course of prior dealings between ILC and Buyer and no usage of trade shall be relevant or admissible to supplement explain or vary any of the terms of this document The failure of either ILC or Buyer to insist upon strict adherence to any term of this document on any occasion shall not be considered a waiver or deprive ILC or Buyer as the case may be of the right thereafter to insist upon strict adherence to that term or any other terms of this document This document can be changed or terminated or its provisions waived only in a document signed by ILC and Buyer or their duly authorized agents Disclaimer of Certain Warranties Limitation of Liability Except as provided herein or in written materials furnished by ILC Dover ILC Dover does not make any representation or warranty of any kind express or implied with respect to the Sentinel XL PAPR CBRN including any warranty as to its merchantability or any warranty as to its fitness for any particular purpose or use In no event shall
7. D may flash green when charging is complete The charger will then be in a trickle charge mode Occasionally the charger may indicate a solid green light following a full charge cycle which is also considered normal e Charging is also possible when the blower is attached to the backpack as demonstrated 18 S 2018 REV D Invaild if not in process 5 days from MC Print Date A WARNING DO NOT OVER TIGHTEN CARTRIDGE OVER TIGHTENING MAY RESULT IN DISTORTION OR DISPLACEMENT OF THE SEAL AND MAY ALLOW CONTAMINATED AIR TO ENTER THE RESPIRATOR HEADPIECE THIS MAY RESULT IN INJURY OR DEATH 6 Adjust the backpack s waist belt length to your waist size when dressed in your protective garments 7 Check the airflow with the Flow Meter e Verify that the Cartridges are installed on the A D blower The blower can be mounted on the indienii line backpack ESIR e Switch the blower on A short beep will sound 5 e Place the flow meter in the blower s hood connector applying light pressure to allow a seal between the flow meter and the blower Keep the flow meter vertical e The position of the upper flat surface black cone in the flow meter should be above the indication line If any part of the upper flat surface of the black cone is below the line on the flow meter check for o Blower malfunction o Improperly installed clogged or damaged Cartridge s o Low battery charge or b
8. ESS SIZING INSTRUCTIONS adjustment snap S a j The Sentinel XL CBRN head harness is packaged pre sized to the XXL head adjustment To adjust the head harness to different size unsnap the female end and move the female adjustment snap to the proper male location and fasten into place If the user is sizing for small or XS this will cause the hood slot material to bunch Fasten the male loose snap located next to the D ring of the head harness into the female end located on the visor 22 S 2018 REV D Invaild if not in process 5 days from MC Print Date PREPARATION FOR USE USING BACKPACK ASSEMBLY 1 Open the blower compartment using the zipper see picture to th 2 If using a rechargeable battery pack remove the battery charger from the backpack To charge the PAPR e Make sure thatthe battery pack is assembled to the blower unit at all times The battery pack should be separated from the blower only for battery pack replacement Plug the battery charger to the socket at the back of the PAPR e Connect the battery charger to an electrical outlet A solid green LED light indicates that the charger is operating properly When plugged into the battery the charger LED will turn solid red after a short time indicating that charging is underway e Charge the battery for approximately 5 hours e While the battery is charging the red LED on the battery charger will be continuous e The charger LE
9. Invaild if not in process 5 days from MC Print Date Sentinel XL POWERED AIR PURIFYING Z RESPIRATOR ILC DOVER creating what s next SENTINEL XL PAPR CBRN SYSTEM USER INSTRUCTION MANUAL FOR MODEL NO S 5000 A WARNING IMPROPER USE OF THIS RESPIRATOR MAY RESULT IN PERSONAL INJURY OR DEATH IMPROPER USE INCLUDES BUT IS NOT LIMITED TO USE IN ATMOSPHERES CONTAINING UNKNOWN CONTAMINATES AND OR UNKNOWN CONCENTRATIONS OF CONTAMINANTS USE WITHOUT ADEQUATE TRAINING DISREGARD TO THE WARNINGS AND INSTRUCTIONS CONTAINED HEREIN AND FAILURE TO INSPECT AND MAINTAIN THIS RESPIRATOR THE RESPIRATOR IS NOT INTENDED FOR USE IN ATMOSPHERES WHERE THE IDENTITY AND OR CONCENTRATION OF THE CONTAMINANT IS UNKNOWN THIS MAY RESULT IN IMMEDIATE DANGER TO PERSONNEL THIS RESPIRATOR DOES NOT SUPPLY OXYGEN AND MUST NOT BE USED IN OXYGEN DEFICIENT ENVIRONMENTS CONTAINING LESS THAN 19 5 OXYGEN S 2018 REV D Invaild if not in process 5 days from MC Print Date 4 Any products returned for repair that are not covered by the Warranty set forth in Section 1 above shall be returned by Buyer to ILC at Buyer s expense As to such products ILC shall be entitled to charge Buyer for handling inspection testing and repairing the products at its prevailing rates Such products whether or not repaired by ILC shall be returned to Buyer at Buyer s expense shipping charges collect 5 No products shall be returned to ILC for any
10. L PAPR CBRN until you have read and completely understand this instruction manual You are required to inspect the packaging of this system immediately after purchasing it Refer to the inspection procedures in this manual which explain how to do so Failure to comply with this WARNING could lead to serious personal injury serious illness or death The Sentinel XL PAPR CBRN system has been tested against live chemical warfare agents agent stimulants and industrial chemicals under controlled laboratory conditions Protection time time before breakthrough and loss of adequate protection may decrease depending upon agent type agent concentration breakthrough criteria temperature and humidity The protection time provided by the Sentinel XL PAPR CBRN in an actual emergency will depend on the aforementioned variables The wearer should immediately evacuate the contaminated area if the low voltage alarm sounds if the blower fails or if other anomalies occur The Sentinel XL PAPR CBRN is designed to operate per NIOSH Statement of Standard for a Chemical Biological Radiological and Nuclear CBRN Powered Air Purifying Respirator 2 S 2018 REV D Invaild if not in process 5 days from MC Print Date NIOSH Performance Criteria for the Sentinel XL PAPR CBRN System Level Agent Challenge Smart Man Agent Challenge Concentration Duration of Challenge minutes Mustard HD Vapor 50mg m Sarin GB Vapor 210 mg m
11. TTERIES ARE CHANGED CHANGE ALL FIVE D CELL BATTERIES AT THE SAME TIME IMPROPER BRAND SELECTION USING A COMBINATION OF BATTERY BRANDS OR NOT USING FIVE BRAND NEW D CELL BATTERIES AFTER THE LOW VOLTAGE ALARM IS INDICATED MAY RESULT IN INJURY OR DEATH DISPOSING OF DEPLETED BATTERIES 1 Remove Battery and dispose of properly e Dispose of depleted or damaged batteries in accordance with state and local environmental regulations e Do not throw away depleted or damaged batteries as ordinary waste A WARNING DISPOSE OF DEPLETED OR DAMAGED BATTERIES IN ACCORDANCE WITH FEDERAL STATE AND LOCAL ENVIRONMENTAL REGULATIONS DO NOT THROW AWAY DEPLETED OR DAMAGED BATTERIES AS ORDINARY WASTE IMPROPER HANDLING OF DEPLETED OR DAMAGED BATTERIES MAY RESULT IN INJURY OR DEATH 34 S 2018 REV D Invaild if not in process 5 days from MC Print Date ILC DOVER SENTINEL XL PAPR CBRN SYSTEM WITH ADJUSTABLE WAIST BELT OR DECON AND QUICK RELEASE BELT AND CLIP Forehead strap Visor a F pr i Exhalation valve Hood vith integrated hose not shown i Blower with battery LED ONOFF switch Adaptor Filter Thread iV ois Belt Charger Flaw m tte i Filters Decon and Quick Release Belt and Clip Not to Scale S 2018 REV D Invaild if not in process 5 days from MC Print Date 9 After batteries are placed into the Alkaline Battery Adaptor install the part into the back of the b
12. ards and fasten the straps with the buckles exposing the backpack pad and the three net Cartridge receptacles accessible through the pad Attach the blower to the backpack by passing the 4 straps through the blower s loops and snapping them to the back of the backpack pad 16 S 2018 Invaild if not in process 5 days from MC Print Date 10 Head Harness Adjustment and Donning the Butyl Hood Note If possible the buddy system should be utilized to aide in effective and fast donning of the system A second person can help the wearer by insuring that the head harness is adjusted and donned properly and to check proper positioning of the hose and hood skirt Don the blower and hood in a safe hazard free area and accomplish the following e Confirm that the three cartridges are properly mounted on the blower unit e Adjust the hood s head strap according to your head size making adjustments to ensure a comfortable stable fit e Initial sizing is based upon head circumference although other factors including the subject s head shape forehead size and shape and hair will affect the sizing of the product Protective wrap ah E A S 4 f SAN a Remove the protective wrap from the head harness and discard Visor snap E Hood Slot t Visor snap A After making the proper size adjustment make sure to center the head harness in the hood slot between the two visor snaps HEAD HARN
13. at the foil package is vacuum sealed and inspect the foil bag for any damage Do not use the Cartridges if the foil bag has been damaged If the foil bag has no damage and the vacuum was maintained remove the Cartridges from their packaging Confirm that the Cartridges do not exceed the use by date and that the connecting thread is not damaged e Confirm that the threads in the three Cartridge threaded inlets are in good condition and clear of foreign matter e Verify that each Cartridge threaded inlet has a black rubber gasket present that is properly seated without twists raised areas or surface defects that may prevent proper sealing of the Cartridge e Remove all plugs from the Cartridge openings before using the system Retain the plugs for future use e Screw the Cartridge into the threads until they are hand tight A WARNING DO NOT OVER TIGHTEN CARTRIDGE OVER TIGHTENING MAY RESULT IN DISTORTION OR DISPLACEMENT OF THE SEAL AND ALLOW CONTAMINATED AIR TO ENTER THE RESPIRATOR HEADPIECE RESULTING IN INJURY OR DEATH 8 Check the airflow with the Flow Meter e Ensure that the Cartridges are installed on the blower The blower can be installed on the waist belt e Switch the blower ON A short beep should sound e Place the flow meter in the blower s hood connector applying light pressure to allow for a seal between the flow meter and the blower Keep the flow meter vertical Assure that nothing is restricting a
14. attery malfunction o Improperly seated filter gasket s e Ifthe upper portion of the black cone is above the indication line on the flow meter the system is ready for use A WARNING BEFORE ENTERING A HAZARDOUS ATMOSPHERE WEARING THIS RESPIRATOR SYSTEM THE RESPIRATOR SYSTEM MUST BE INSPECTED COMPLETE AN AIRFLOW CHECK AND DON THE SYSTEM ACCORDING TO THE INSTRUCTIONS IN THIS MANUAL FAILURE TO DO SO MAY NOT ADVERSELY AFFECT RESPIRATOR PERFORMANCE AND MAY RESULT IN INJURY OR DEATH DO NOT WEAR THIS RESPIRATOR SYSTEM TO ENTER AREAS WHERE ATMOSPHERIC CONCENTRATIONS OF CONTAMINANTS ARE UNKNOWN THE AREA MAY NOT EXCEED THE MAXIMUM USE CONCENTRATION MUC FOR THE RESPIRATOR HEAD PIECE OR ATMOSPHERE MAY NOT CONTAIN LESS THAN 19 5 OXYGEN THIS MAY RESULT IN IMMEDIATE DANGER TO PERSONNEL 20 S 2018 REV D
15. intenance of these respirators Some CBRN agents may not present immediate effects from exposure but can result in delayed impairment illness or death Special or critical User s Instructions and or specific use limitations apply Refer to User s Instructions before donning The respirator provides respiratory protection against inhalation of radiological and nuclear dust particles Procedures for monitoring radiation exposure and full radiation protection must be followed Direct contact with CBRN agents requires proper handling of the respirator after use Correct disposal procedures must be followed Use in conjunction with personal protective ensembles that provide appropriate levels of protection against dermal hazard Failure to do so may result in personal injury even when the respirator is properly fitted used and maintained UU The respirator should not be used beyond eight 8 hours after initial exposure to chemical warfare agents VV to avoid possibility of agent permeation If liquid exposure is encountered the respirator should not be used for more than two 2 hours PAPRS with TC 23C approvals may NOT be used for escape from IDLH atmospheres 10 S 2018 REV D Invaild if not in process 5 days from MC Print Date PAPR Blower Unit Verify that each Cartridge threaded inlet has a black rubber gasket present that 1s properly seated without twists raised areas or surface defects that may prevent proper sealing of
16. ir flow into the cartridges e The position of the upper flat surface black cone in the flow meter should be above the indication line If any part of the upper flat surface of the black cone is below the line on the flow meter check for o Blower malfunction o Improperly installed clogged or damaged Cartridge s o Low battery charge or battery malfunction o Improperly seated filter gasket s e Ifthe upper portion of the black cone is above the indication line on the flow meter the system 1s ready for use 14 S 2018 REV D Invaild if not in process 5 days from MC Print Date Center the head harness in the hood slot after making the sizing adjustment Fasten the male located next to the D ring of the head loose snap opposite side of the D ring of the harness into the female end located on the head harness into the female end located on the visor visor e Ifthe adjustable waist belt or decon belt is used adjust the blower and belt on your waist over your protective clothing Adjust the waist belt for a comfortable fit keeping the breathing tube and hood behind the head and shoulders e Ifthe backpack is used adjust the blower and backpack on your back over your protective clothing using the shoulder straps Adjust the waist belt strap for a comfortable fit keeping the breathing tube and hood behind the head and shoulders e Switch the blower ON av i lt a e Place your hand inside the hood
17. lower The pull strap should remain outside as shown below and is used to remove the alkaline battery pack for exchange of battery cells or replacement with alternative battery options DURACELE aI 10 Connect the new battery pack to the blower 11 Tuck the connector and wires into the open cavity at the top side of the blower as shown in the photo below DURACELE ALKALINE BATTERY a5 Ta 3 i DURACELL DU ALKALINE BATTERY i ALKALINE T lt n HE cere e i is Terns DN EWS i FY Toronto ON MSWICS ee at e sei n i _ f Connector in stowed position eo S 2018 REV D Invaild if not in process 5 days from MC Print Date GENERAL SAFETY INFORMATION Intended Use The ILC Dover SENTINEL XL PAPR CBRN blower can be mounted to the Adjustable waist belt Decon and Quick Release Belt and Clip or optional backpack and 1s connected to the hood assembly via an integrated flexible breathing tube The ILC Dover SENTINEL XL PAPR CBRN must be used with the S 2016 CBRN Cartridge The ILC Dover SENTINEL XL PAPR CBRN systems are intended to provide respiratory protection against inhalation of certain gas and vapor chemical agents biological particulates and radiological and nuclear dust particles This respirator provides limited dermal skin protection to the head area and eyes This respirator does not protect against radioactive x rays gamma rays or neutrons Note Inspect emergency use respirators o
18. mbly is packed and stored in a flat configuration to save storage space Adjusting the head harness to the wearer s head circumference creates the three dimensional Structure Blower P N S 2002 The blower is comprised of an electrical motor that drives an air blower An on off switch is located on top of the blower A red LED near the on off switch at the top indicates when the blower is on There is one male thread at the blower top to connect the breathing hose There are three female threaded inlets with rubber gaskets at the blower sides and bottom to connect three Cartridges The blower is equipped with a self test mechanism Upon starting the blower the red LED will blink once or twice a buzzer will sound one or two short beeps followed by continuous LED light and no sound This indicates that the blower is functioning correctly The blower is equipped with an audio visual low voltage alarm indicating that battery voltage is decreasing The alarm is given by the blinking LED and successive buzzer beeps The sound from the alarm is easily heard within the hood Once the low voltage alarm has sounded the user must exit the contaminated area 4 S 2018 REV D Invaild if not in process 5 days from MC Print Date A WARNING FOR ALKALINE BATTERY ADAPTOR OPTION P N S 4013 USE ONLY DURACELL BATTERIES DO NOT USE A COMBINATION OF DURACELL OR OTHER BRANDS IT IS IMPORTANT THAT ALL FIVE BATTERIES ARE DURACELL D CELL BATTERIES WHENEVER BA
19. n a monthly basis A WARNING THESE RESPIRATORS HELP PROTECT AGAINST CERTAIN AIRBORNE CONTAMINANTS MISUSE MAY RESULT IN INJURY OR DEATH FOR PROPER USE SEE SUPERVISOR USER INSTRUCTIONS OR CALL ILC DOVER TECHNICAL SERVICE AT 1 800 631 9567 USE ONLY ILC DOVER PARTS AND ACCESSORIES FOR THE ILC SENTINEL XL PAPR CBRN SYSTEM AS DESCRIBED IN THESE USER INSTRUCTIONS ALWAYS DON THE RESPIRATOR SYSTEM PROPERLY AND IN AN UNCONTAMINATED AREA DO NOT REACH YOUR HAND INTO THE FACE PIECE IN AREAS WHERE THE AIR IS CONTAMINATED LEAVE THE CONTAMINATED AREA AND CLEAN CONTAMINANTS FROM YOUR HANDS BEFORE REACHING INSIDE THE HOOD IF YOU DISCOVER ANY OF THE WEAR AND DAMAGE DESCRIBED IN THE TROUBLESHOOTING SECTION OF THIS USER INSTRUCTION DISCARD COMPONENT AND REPLACE IT WITH A NEW ONE FAILURE TO DO SO MAY ADVERSELY AFFECT RESPIRATOR PERFORMANCE AND RESULT IN SICKNESS OR DEATH BEFORE USE THE WEARER MUST READ AND FULLY UNDERSTAND THESE USER INSTRUCTIONS KEEP THIS INSERT FOR FUTURE REFERENCE IF YOU HAVE ANY DOUBTS ABOUT THE APPLICABILITY OF THESE RESPIRATOR SYSTEMS TO YOUR JOB SITUATION CONSULT AN INDUSTRIAL HYGIENIST OR CALL THE ILC DOVER TECHNICAL SERVICE LINE Use the ILC Dover SENTINEL XL PAPR CBRN for The ILC Dover SENTINEL XL PAPR CBRN systems are intended to provide respiratory protection against inhalation of certain gas and vapor chemical agents biological particulates and radiological and nuclear dust particles This respi
20. on and duration Some CBRN agents may not present immediate effects from exposure but can result in delayed impairment serious illness serious injury or death CBRN agents depending on how they are used may provide disabling effects as a result of skin exposure Direct contact with CBRN agents requires proper handling of the respirator after use Correct decontamination and or disposal procedures must be followed DO NOT USE for applications other than CBRN incidents DO NOT USE for gamma rays x rays and neutrons DO NOT USE for hazardous projectiles DO NOT USE for protection against or contact with liquid droplets of chemical warfare agents A written respiratory protection program must be implemented meeting all the requirements of OSHA 29 CFR 1910 134 In Canada the Z94 4 requirements must be met Annual training on how to store care for and use this product and your emergency escape plan is required DESCRIPTION The ILC Dover SENTINEL XL PAPR CBRN is a blower assisted air purifying respirator known as a Powered Air Purifying Respirator or PAPR The SENTINEL XL PAPR CBRN is comprised of the following components 1 Butyl Hood one size fit all P N S 2001 The hood is equipped with a large area visor allowing for an undisturbed field of vision an adjustable head harness that fits all head sizes a double skirt and an integrated breathing hose that connects the hood to the blower unit The Butyl Hood Asse
21. onal Batteries NOT included Battery Charger with Instructions S 2009 Cartridge x 3 with Instructions S 2016 Flow Meter S 2010 Adjustable Waist Belt S 2007 or Decon and Quick Release Belt and Clip S 4011 Optional PAPR Hood S 2001 Make sure that the battery pack is assembled to the blower unit at all times The battery pack should be separated from the blower only for battery pack replacement Plug the battery charger to the socket at the back of the PAPR Connect the battery charger to an electrical outlet If charger is connected to an electrical outlet before connecting to a battery a solid green LED light indicates that the charger is operating properly When plugged into the battery the charger LED will turn solid red after a short time indicating that charging is underway Charge the battery for approximately 5 hours The charger s LED will change from solid red to flashing green when charging is complete The charger will then be in a trickle charge mode If the light goes to continuous green the battery will cool down automatically and then will go to red and continue charging Charging is also possible when the blower is attached to the waist belt or decon belt as demonstrated 4 If you are using the Non Rechargeable Battery or Alkaline Battery Adaptor continue onto Step 5 If there is no battery installed into the blower refer to pages 29 and 30 respectively for battery installation instructions
22. rator provides limited dermal skin protection to the head area and eyes This respirator does not protect against radioactive x rays gamma rays or neutrons Never use the ILC Dover SENTINEL XL PAPR CBRN for Atmospheres where oxygen concentration is below 19 5 where concentrations of contaminants are unknown immediately dangerous to life or health IDLH exceed applicable local standards or OSHA standards for maximum use concentrations for the respirator whichever is lower Refer to additional limitations and cautions under NIOSH Cautions and Limitations 8 S 2018 REV D Invaild if not in process 5 days from MC Print Date INSTALLING THE ALKALINE BATTERY ADAPTOR P N S 4013 1 Make sure the blower is turned off 2 Open the battery pack compartment by pressing on the latch connecting it to the blower 3 Disconnect the battery wire connector from the blower and separate the battery from the blower Set battery aside for future use 4 Remove Alkaline Battery Adaptor from its original kit packaging Set aside the battery backing plate until Step 12 5 Remove the adhesive backing paper on the Alkaline Battery Adaptor hook and place the adaptor plate into the open cavity on the back of the blower with metal connectors facing out Note Do not separate Velcro hook from Velcro loop on the back of the Alkaline Battery Adaptor These parts need to remain together during assembly 30 S 2018 REV D
23. the Cartridge A WARNING IF RUBBER GASKETS APPEAR TO BE POSITIONED IMPROPERLY WITH TWISTS RAISED AREAS OR SURFACE DEFECTS DO NOT USE BLOWER CONTACT THE ILC DOVER CUSTOMER SERVICE DEPARTMENT IMMEDIATELY GASKET FAILURE WILL AFFECT THE RESPIRATOR PERFORMANCE AND MAY RESULT IN INJURY OR DEATH Examine the blower housing for cracks Replace if cracked or damaged Examine the outside of the battery pack for cracks Replace if damaged Cartridge Examine Cartridges for mechanical damage and deformities If found determine potential for contamination of user A WARNING IF EXCESSIVE WEAR AND OR DAMAGE TO THE RESPIRATOR SYSTEM OR ITS COMPONENTS IS OBSERVED AT ANY TIME DO NOT USE THE RESPIRATOR SYSTEM UNTIL ALL NECESSARY REPAIRS HAVE BEEN PERFORMED AND THE WEARER HAS SUCCESSFULLY COMPLETED THE USER PERFORMANCE CHECK DESCRIBED IN THIS USER INSTRUCTION MISUSE MAY ADVERSELY AFFECT RESPIRATOR PERFORMANCE AND MAY RESULT IN INJURY OR DEATH 28 S 2018 REV D Invaild if not in process 5 days from MC Print Date PREPARATION FOR USE USING ADJUSTABLE WAIST BELT OR DECON BELT 1 Open the package box and take out the components 2 Remove the Blower from its box 3 If using a rechargeable battery remove the Battery Charger from its box To charge the PAPR Blower S 2002 Battery S 2003 Rechargeable NiMH Battery Pack Assembly or S 2004 Non Rechargeable LiMnO2 Battery pack Assembly Alkaline Battery Adaptor S 4013 Opti
24. the liability of ILC Dover exceed the purchase price of the product and in no event including the case of latent defects negligence or strict liability shall ILC Dover be liable for incidental or consequential damages A WARNING The failure to use and maintain the Sentinel XL PAPR CBRN in strict conformance with the instruction manual may result in serious personal injury serious illness or death The use of the Sentinel XL PAPR CBRN in any manner that is not expressly authorized pursuant to the applicable instruction manual may result in severe adverse impacts to human health Copyright ILC Dover 2003 all rights reserved 38 S 2018 REV D Invaild if not in process 5 days from MC Print Date SAFETY PRECAUTIONS The Danger Warnings Cautions and Notes contained in this instruction manual have the following significance A DANGER Danger indicates an imminently hazardous situation which if not avoided will result in serious personal injury serious illness or death A WARNING Warning indicates a potentially hazardous situation which if not avoided could result in serious personal injury serious illness or death CAUTIONS Caution indicates a potentially hazardous situation which if not avoided may result in damage to equipment and or minor to moderate personal injury Operating procedures and techniques or information considered important to emphasize A WARNING DO NOT USE the Sentinel X

Sentinel CBRN PAPR Instruction Manual

Contents

Download Pdf Manuals

Related Search

Related Contents