Home

Manual

1. S MANUAL GO ACROSS SLOPE NOT UP AND DOWN DO NOT MOW WHEN CHILDREN OR OTHER ARE AROUND LOOK DOWN AND BEHIND BEFORE AND WHILE MOVING BACKWARDS REMOVE OBJECTS THAT COULD BE THROWN BY THE BLADE KEEP SAFETY DEVICES GUARDS SHIELDS SWITCHES ETC IN PLACE AND WORKING MJ401E 2137 LL i Know Your Lawn Mower Switch lever Safety lock off button Cable relief Cable clip Upper handle Tighten knob Lower handle Flap Power cable Reset button of over load switch Grassbox Mower deck Wheel Wheel cover Top cover Z2rxer re Maoo0 8 p gt M Figure 2 Technical Data 1 Power 12A 4 Voltage 120V 60Hz 2 Performance Cut up to 14 36cm wide in one pass 5 Rotating Speed 3500rmp 3 Control Adjust cutting height up to 2 4 6 1cm deep 6 Weight 13kg Assembly 2 Slide the wire management Clip C onto the upper handle D VAN CAUTION VAN 3 Join the upper handle D to the lower handle E by means of the knob F plastic washer G and bolts H provided Inspect wiring which if damaged during shipping may cause serious bodily injury during equipment use If any damage is seen or suspected do not assemble Instead contact Sun Joe customer service 1 866 766 9563 for assistance Handle with care during assembly so that electrical wiring does not become damaged Before using the mower follow these instructions to
2. Model No MJ401E A Division of Snow Joe LLC IMPORTANT Safety Instructions All Operators Must Read These Instructions Before Use Always follow these safety guidelines Failure to do so may result in serious bodily injury or death General Safety WARNINGS When using electric lawn mowers basic safety precautions should always be followed to reduce the risk of fire electric shock and personal injury including the following Warning Risk of injury could occur if the lawn mower is operated without the catcher assembly attached Warning The use of any other accessory or attachment might increase the risk of injury Warning To reduce the risk of injury inspect catcher assembly frequently and replace with recommended replacement if these are signs of wear or deterioration Before using the mower take the time to familiarize yourself with the controls especially how to stop the mower in an emergency Only allow responsible individuals who have a thorough understanding of these instructions to operate the mower Never allow children to operate the mower Retain this manual future reference and reread it at the start of each mowing session FOR DOUBLE INSULATED LAWN MOWERS 1 Replacement Parts When servicing use only identical replacement parts 2 Polarized Appliance Connections To reduce the risk of electric shock this appliance has a polarized plug one blade is wider than the other and will requi
3. Mower requires service or maintenance please call 1 866 766 9563 for assistance Model and Serial Numbers When contacting the company or reordering parts you will need to provide the model and serial numbers of your product These are found on the decal affixed to the housing or handle of your mower Copy these numbers into the space provided below Record the following numbers from the housing or handle of your new product Model IMJ 4 0 1 E Serial Ee a ee ee A Two Year Full Warranty for residential use in the United States and Canada General Conditions Snow Joe LLC warrants this product to the original purchaser for two years against defects in material or workmanship when used for normal residential purposes Snow Joe LLC will repair any defect in material or workmanship and repair or replace any defective part subject to the conditions limitations and exclusions set forth herein Such repair or parts replacement will be free from charge to the original purchaser except noted below The duration of the warranty applies only if the product is put to personal use around the household or residence If the product is put to any business use commercial or industrial then the duration of this warranty is 90 days from the date of original purchase If any product is rented or leased the duration of the warranty is 90 days from the date of original purchase It is the owner s responsibility to perf
4. NORMA UL 1447 CONFORME A LA NORME UL 1447 EVITE LESIONES GRAVES O LA MUERTE DANGER DE BLESSURES GRAVES OU A AVERTISSEMENT MORTELLES Lire le manuel d utilisation Tondre pentes et talus en diagonale et non la verticale Ne pas utiliser la tondeuse proximit d enfants ou autres personnes Scruter attentivement le sol si vous devez reculer avec la machine D barrasser la zone de travail de tout objet risquant d tre projet S assurer que les dispositifs de s curit carters crans interrupteurs etc sont bien en place et fonctionnels Risque de choc lectrique Ne pas exposer l eau remplacer imm diatement tout cordon endommag e DOUBLE ISOLATION N utiliser que des pi ces de remplacement identiques e Afin de r duire le risque de blessures ne pas utiliser la machine si les dispositifs de protection ne sont pas en place Afin de r duire le risque de blessures inspecter r guli rement l ensemble tr mie de collecte bac herbe et remplacer les pi ces us es ou d t rior es par des pi ces recommand es e Risque de mutilation des doigts ou des orteils e Garder enfants et autres personnes distance Replacement manual available by sending model and serial numbers to Snow Joe LLC 86 Executive Avenue Edison NJ 08817 or visit www snowjoe com El manual de reemplazo est disponible al enviar los n meros de modelo y serie a Snow Joe LLC 86 Executive Avenue Edison NJ 08817 o v
5. To reduce the risk of injury inspect catcher assembly frequently and replace with recommended replacement if there are signs of wear or deterioration Severing of toes or fingers rotary mower blade Keep bystanders children away SUN JOE MOW JOE MJ401E 120 VAC 60 HZ 12A NO 3500 MIN 360 MM Made in China SUN JOE MOW JOE MJ401E 120 VAC 60 HZ 12 A NO 3500 MIN 360 MM Hecho en China SUN JOE MOW JOE MJ401E 120 VCA 60 HZ 12A NO 3500 MIN 360 MM Fabriqu en Chine ADVERTENCIA Lea el manual del operador Vaya a trav s de los desniveles nunca de arriba abajo No corte cuando haya ni os u otras personas alrededor Mire hacia abajo y hacia atras antes y mientras se mueve hacia atras Quite objetos que pudieran ser arrojados por la cuchilla Mantenga los dispositivos de seguridad protectores cubiertas interruptores etc en su lugar y funcionando Riesgo de choque el ctrico No exponga al agua reemplace el cable da ado inmediatamente DOBLE AISLAMIENTO al prestar servicio use s lo piezas de repuesto iguales Para reducir el riesgo de lesi n no opere sin protectores en su lugar us Para reducir el riesgo de lesi n inspeccione frecuentemente el ensamble del dep sito para el c sped y reemplace como se recomienda si hay se ales de desgaste o deterioro e Peligro para dedos o pies cuchilla rotativa de cortadora 3174208 e Mantenga alejados a espectadores ni os CONFORMS TO UL STD 1447 DE CONFORMIDAD CON LA
6. ackward unless absolutely necessary Always look down and behind before and while moving backward Never direct discharged material toward anyone Avoid discharging material against a wall or obstruction Do not operate machine without the entire grass catcher discharge guard rear guard or other safety protective devices in place and working Never leave a running machine unattended Stop the engine motor and wait until the blade comes to a complete stop before cleaning the machine removing grass catcher or unclogging the discharge guard Operate machine only in daylight or good artificial light Do not operate machine while under the influence of alcohol or drugs Never operate mower in wet grass Always be sure of your footing walk never run 15 Disengage the drive system if so equipped before starting the engine motor 16 If the machine should start to vibrate abnormally stop the engine motor and check for the cause immediately Vibration is generally a warning of troble 17 Always wear eye protection when operating machine 18 Only allow responsible adults who are familiar with the instructions to operate this machine SLOPE OPERATION Slopes are a major factor related to slip and fall accidents which can result in severe injury Operation on all slopes requires extra caution If you feel uneasy on a slope do not mow it 1 Mow across the face of slopes never up and down Exercise extreme c
7. assemble the Handle and Grassbox Handle Assembly 1 Fit the lower handle into the two holes in the machine body A and fasten them with the screws B provided Figure 4 Cable relief Upper handle Lower handle Tighten knob Plastic washer Bolts Figure 3 A Machine body B Screw ro m moo ices 3 Raise the spring loaded rear door C and move the basket Grassbox Assembly amp Fitting up to the mower body Fasten it onto the coupling hooks D 1 Fit the support rod A into the holes in the plastic cover The bend of the support rod should face the rear of the machine Figure 5 C Rear door D Coupling hooks A Support rod 2 Place the protective plastic profiles B onto the U rod 4 Release the rear door to secure the basket in position Figure 6 B Protective plastic profile Figure 8 Features Safety Lock off Button A Used to engage the switch Up ry LL ET yy N y a J a Q A Figure 9 A Safety lock off button Switch Lever B Used to start and stop the mower e l TT Se AGS A Figure 10 B Switch lever Grassbox C Used to collect mowed clippings Figure 11 C Grassbox Operation After conducting all safety checks and necessary preparations follow these steps to operate the mower 1 Push the loop of the electric extension cord through the slot fr
8. aution when changing direction on slope 2 Watch for holes ruts bumps rocks or other hidden objects Uneven terrain could cause a slip and fall accidents Tall grass can hide obstacles 3 Do not mow on wet grass or excessively steep slopes Poor footing could cause a slip and fall accident 4 Do not mow near drop offs ditches or embankments You could lose your footing or balance CHILDREN Tragic accidents can occur if the operator is not alert to the presence of children Children are often attracted to the machine and the mowing activity Never assume that children will remain where you last saw them 1 Keep children out of the mowing area and under the watchful care of a responsible adult other than the operator 2 Be alert and turn mower off if a child enters the area 3 Never allow children to operate the machine 4 Use extra care when approaching blind corners shrubs trees or other objects that may block your view of a child SERVICE GENERAL SERVICE 1 Keep all nuts and bolts tight to be sure the equipment is in safe working condition 2 Never tamper with safety devices Check their proper operation regularly 3 Keep machine free of grass leaves or other debris build up 4 lf you strike a foreign object stop and inspect the machine Repair if necessary before starting 5 Never make any adjustments or repairs with the engine motor running 6 Always unplug electric mower
9. ducts Nothing contained in this warranty shall be construed as obligating Snow Joe LLC to incorporate such design changes into previously manufactured products nor shall such changes be construed as an admission that previous designs were defective This warranty is intended to cover product defects only Snow Joe LLC is not liable for indirect incidental or consequential damages in connection with the use of the Snow Joe Products covered by this warranty This warranty does not cover any cost or expense incurred by the purchaser in providing substitute equipment or service during reasonable periods of malfunction or non use of this product while waiting for completion of repairs under this warranty Some states do not allow exclusions of incidental or consequential damages so the above exclusions may not apply in all states This warranty may give you specific legal rights in your state If you wish to contact Snow Joe please direct inquiries to the Customer Service Department Snow Joe Center 86 Executive Avenue Edison NJ 08817 Customers who have purchased Snow Joe products exported from the United States and Canada should contact their Snow Joe Distributor Dealer to obtain information applicable for your country province or state If for any reason you are not satisfied with the distributor s service or if you have difficulty obtaining warranty information contact your Snow Joe seller If in the event your efforts are unsatisfacto
10. erside of the blade housing Clean plastic parts with a damp cloth Do not use solvents or cleaning fluids on plastic components Check all nuts bolts and screws before each use Store the mower in a dry area Blade Maintenance The steel blade is designed to provide a fine cut in long or tough grass Deterioration in the quality of cut indicates blade wear or damage Follow these steps to determine if the blade needs to be repaired or replaced 1 Disconnect the electrical supply to the mower 2 Turn the mower on its side so the underside of the blade housing is exposed 3 Check the blade a If the blade is blunt or has minor wear then re sharpen b If the blade has major wear or damage i e gouged bent replace Please call Sun Joe customer service 1 866 766 9563 for assistance Blade Replacement Important Only use original replacement parts specified for this mower Figure 17 A Blade B Spanner 1 Disconnect the electrical supply to the mower 2 Turn the mower on its side so the underside of the bladehousing is exposed 3 Use a cloth to grip the blade or wear heavy duty gloves 4 Using the spanner provided turn the nut counter clockwise to loosen and remove the nut from the motor spindle 5 Fit the blade and the special Belleville washer back on in the correct direction A Nut Figure 18 B Blade 11 Service and Support If your Mow Joe Electric Lawn
11. isite www snowjoe com Pour obtenir un autre exemplaire du Manuel d utilisation faire parvenir les num ros de mod le et de s rie de votre machine l adresse suivante Snow Joe LLC 86 Executive Avenue Edison NJ 08817 ou consulter notre site Internet l adresse www snowjoe com a CT MJ401E 2135 CAUTION ATTENTION AAWARNING jCUIDADO When starting the MOW JOE lawn mower in grass move the mower to a previously cut region or apply downward pressure to the handle to lift the front wheels slightly off the ground In the event of circuit failure reset the circuit after one minute by depressing the circuit breaker reset button Al arrancar la cortadora de c sped MOW JOE en hierba mueva la cortadora a un rea previamente cortada o aplique presi n hacia abajo a la agarradera para levantar ligeramente las ruedas delanteras En caso de presentarse una falla en el circuito vuelva a arrancar el circuito despu s de un minuto oprimiendo el bot n de reposici n del cortacircuitos MJ401E 2136 Pour proc der la mise en marche de la tondeuse MOW JOE placer la machine sur une portion de pelouse pr alablement coup e ou exercer une faible pression sur le guidon afin de soulever l g rement les roues avant de la tondeuse En cas de d clenchement du circuit lectrique attendre une minute et r enclencher le circuit en actionnant le disjoncteur AVOID SERIOUS INJURY OR DEATH READ THE OPERATOR
12. mower Important The mower blade will continue to rotate as you are pulling the Switch lever Do not reach inside the blade housing or attempt to lift the mower until the blade has completely stopped and the electrical supply to the mower has been disconnected Adjusting the Cutting Height Follow these instructions to adjust the cutting height of the lawnmower A WARNING DO NOT make these adjustments when the mower is running or plugged in Doing so can cause serious injury or death Also we recommend wearing gloves due to the close proximity of the cutting blade ALWAYS FOLLOW ALL SAFETY PRECATIONS AND RECOMMENDATIONS LISTED PREVIOUSLY IN THIS MANUAL 1 Power down and unplug the lawnmower 2 Remove and empty the grass box 3 Place the lawnmower on one of its sides See Fig 16 High Setting Low Setting Rod Axel Figure 16 4 The wheel axels can be places into 3 different cutting heights Low will cut grass the shortest medium and high 5 Move all four wheels to the desired cutting height Simply pull back on the rod axel and set your desired wheel height Make sure all four wheels are the same height 6 Place the lawnmower back on to its wheels and re attach the grass box 7 Plug back in your mower and resume normal use Maintenance and Care General Always keep the mower clean and free of grass clippings After each cutting session scrap or blast with water the built up grass from the und
13. nection of lawn mower cord set during operating i Make a knot as shown in Figure 1 or ii Use one of the plug receptacle retaining straps or connectors described in this manual Save These Instructions Method of securing cord set a Appliance cord Cord set B Connect plug and receptacle Figure 1 10 Don t abuse cord Never pull lawn mower by cord or yank it to disconnect from receptacle Keep cord from heat oil and sharp edges EXCEPTION This statement does not apply to a cordless battery operated lawn mower 11 Don t force lawn mower It will do the job better and safer at the rate for which it was designed 12 Don t overreach Keep proper footing and balance at all times 13 Stay alert Watch what you are doing Use common sense Do not operate lawn mower when you are tired 14 Disconnect lawn mower Disconnect the lawn mower from he power supply when not in use before servicing when changing accessories such as blades and the like 15 Store Idle lawn mower indoors When not in use lawn mower should be stored in an indoor dry locked up place out of reach of children 16 Maintain lawn mower with care Keep cutting edges sharp and clean for best and safest performance Following instructions for lubricating and changing accessories Inspect lawn mower cord periodically and if damaged have it repaired by an authorized service facility Inspect extension c
14. om the opposite side of the restraint hook Position the loop over the hook and pull the cable back through the slot Figure 12 A Cable relief B Extension cord Note Use a waterproof electrical extension cord rated 14AWG HO5VV F and HO5RN F in US Figure 13 Place the bulk of the extension cord on the lawn close to the starting point Note The directional method of operation is recommended to obtain the maximum cutting performance and reduce the risk of the electrical extension cord entering the cutting path 3 Hold the handle assembly with both hands 4 Tilt the handle downwards to slightly raise the front of the mower This will reduce the risk of lawn damage during start up Depress the Safety lock off button A and pull the Switch lever B towards you MU l i ao A S2 Figure 14 A Safety lock off button CET ET TTJ yy EL ye Figure 15 A Safety lock off button B Switch lever Lower the mower down into the cutting position 7 Follow these instructions to mow the cutting area A Proceed to cut as shown in Fig 13 working from position 1 towards position 2 B At position 2 turn right and proceed to position 3 C Continue to the end of the cutting area turn left and proceed to position 4 D Proceed as shown in Figure 13 always working away from the electric extension cable Release the Switch lever to stop the
15. ords periodically and replace if damaged Keep handles dry clean and free from oil and grease 17 Keep guards in place and in working order 18 Keep blades sharp 19 Keep hands and feet away from cutting area 20 21 22 Objects struck by the lawn mower blade can cause severe injuries to persons The lawn should always be carefully examined and cleared of all objects prior to each mowing If lawn mower strikes a foreign object follow these steps i Stop lawn mower Release the switch li Unplug power cord iii Inspect for damage iv Repair any damage before restarting and operating the lawn mower Use identical replacement blades only IMPORTANT Safety Instructions for Walk Behind Mowers GENERAL OPERATION 1 10 11 12 13 14 Read understand and follow all instructions on the machine and in the manual s before starting Do not put hands or feet near or under the machine Keep clear of the discharge opening at all times Only allow responsible adults who are familiar with the instructions to operate this machine Clear the area of objects such as rocks wire toys etc which could be thrown by the blade Stay behind the handle when the engine motor is running Be sure the area is clear of bystanders before operating Stop machine if anyone enters the area Do not operate machine barefooted or while wearing sandals Always wear substantial footwear Do not pull machine b
16. orm correctly all maintenance and minor adjustments explained in the owner s manual Electric Products To obtain a replacement electric powered unit or repair the existing electric powered unit you must return the complete unit and postage prepaid to Snow Joe Return Center 86 Executive Avenue Edison NJ 08817 Gasoline Battery Products Limitations e Batteries are warranted only for the period of 12 months after the date of purchase on a prorated basis Rechargeable batteries will be replaced free from charge during the first 90 days After the initial 90 days batteries will be replaced at prorated cost to the customer e Idlers cables and electrical components are warranted to the original purchaser for use at household or residence for a period of two years Exclusions e Snow Joe brand engines are covered under this warranty All other engines and engine accessories are covered only by the engine manufacturer s warranty and are not covered by this warranty e Parts used that are not genuine Snow Joe parts are not covered by this warranty e Damages resulting from misuse alteration improper assembly improper adjustment neglect or accident which requires repair is not covered under this warranty e Belts augers and tines are not covered under warranty belts augers and tines wear out and can be purchased at www snowjoe com or by calling 1 866 766 9563 Snow Joe LLC may from time to time change the design of its pro
17. re the use of a polarized extension cord The appliance plug will fit into a polarized extension cord only one way If the plug does not fit fully into the extension cord reverse the plug If the plug still does not fit obtain a correct polarized extension cord Apolarized extension cord will require the use of a polarized wall outlet This plug will fit into the polarized wall outlet only one way If the plug does not fit fully into the wall outlet reverse the plug If the plug still does not fit contact a qualified electrician to install the proper wall outlet Do not change the equipment plug extension cord receptacle or extension cord plug in anyway Contact with moving parts may cause entanglement dismemberment or other serious bodily injury Always keep body parts i e hands feet away from moving 2011 by Snow Joe LLC All rights reserved Original instructions octo Fev oar Form No SJ MJ401E 880E OPERATOR S MANUAL parts Ensure all covers and guards are securely in place before use Hot surfaces i e motor may ignite flammables or combustibles and cause a fire or explosion resulting in serious injury Keep the mower away from flammables or combustibles until hot surfaces have completely cooled Do not store mower near flammables or combustibles A damaged blade or worn blade nut may break off from the mower assembly and cause serious injury Replace the damaged blade or blade nut before using the mo
18. ry please write to the Snow Joe Center at the above address If you have any questions about your product warranty please call 1 866 SNOW JOE or visit us online at www snowjoe com 12
19. s before adjusting cleaning or repairing 7 Check grass catcher components and the discharge guard frequently and replace with manufacturer s recommended parts when necessary 8 Mower blades are sharp Wrap the blade or wear gloves and use extra caution when servicing them 9 Maintain or replace safety and instruction labels as necessary SYMBOLS CPSC Danger label Severing of toes or fingers rotary mower blade Thrown object from mower deck Keep bystanders children away Safety alert Slip on slope Read the operator s manual El Double insulation Safety and Instruction Decals DANGER MANTERLA LAS MANOS Y LOS PIES DISTANGIA GARDER MAINS ET PIEDS A DISTANCE DA Safety decals and instructions are easily visible to the operator and are located near areas of potential danger Lost or damaged decals should be replaced MJ401E 2134 A WARNING Read the operator s manual Go across slopes not up and down Do not mow when children or others are around Look down and behind before and while moving Remove objects that could be thrown by the blade Keep safetydevices guards shields switches etc in place and working Risk of electric shock Do not expose to water replace damaged cord immediately DOUBLE INSULATION when serving use only identical replacement parts AVOID SERIOUS INJURY OR DEATH To reduce the risk of injury do not operate without guards in place
20. wer FOR ALL LAWN MOWERS 1 Avoid dangerous environment Don t use lawn mowers in damp or wet locations 2 Don t use in rain 3 Keep children away All visitors should be kept at a safe distance from work area 4 Dress properly Do not wear loose clothing or jewelry They can be caught in moving parts Use of rubber gloves and footwear is recommended when working outdoor 5 Use safety glasses Always use face or dust mask if operation is dusty 6 Use right appliance Do not use lawn mower for any job except that for which it is intended 7 Ground fault circuit interrupter GFCI protection should be provided on the circuit s or outlet s to be used for the lawn mower Receptacles are available having built in GFCI protection and may be used for this measure of safety 8 Warning To prevent electric shock use only with an extension cord suitable for outdoor use such as SW SOW STW STOW SJTW or SUTOW EXCEPTION This warning does not apply to a battery operated lawn mower 9 Extension cord Make sure your extension cord set is in good condition When using an extension cord be sure to use one heavy enough to carry the current your product will draw For lengths less than 100 feet No 14 AWG extension cord should be used An undersized cord will cause a drop will cause a drop in line voltage resulting in loss of power and overheating Length and name To reduce the likelihood of discon

Manual

Contents

Download Pdf Manuals

Related Search

Related Contents