User Manual for SEA-DOO® Sea scooter Dolphin SD5542
Contents
1. DO NOT STORE BATTERY IN SEASCOOTER Z S VO E 6 Follow steps 14 to 15 on page 13 to close the SEASCOOTER Buying batteries Additional batteries can be purchased separately Contact your local customer service centre distributor to purchase them Care And Maintenance Battery and Catalyzer Care Please read and understand important Battery Use safety information on page 8 9 10 and 11 The battery supplied with your SEA DOO SEASCOOTER should last about 200 cycles or two years before it should be replaced Please contact your local customer service centre distributor Using a battery in excess of these recommendations can result in excessive off gassing of explosive gas A safety catalyzer to protect against explosive gas in normal use is held in a spring in the bottom of the battery housing and should be replaced at the same time as any battery replacement Fig 8 The catalyzer should be replaced sooner if it appears to be damaged Please contact your local customer service centre distributor If the catalyzer is wet it will not function and must be allowed to dry out before use Catalyzer Care after using the SEASCOOTER ALWAYS remove the battery from the SEA DOO9 SEASCOOTER immediately after use DO NOT STORE BATTERY IN SEASCOOTER Always rinse the SEASCOOTER in fresh water and allow it to dry before storage Whenever possible rinse the SEASCOOTER in fresh water2. children under the age of eight 8 and must ONLY be used by children under adult supervision An adult must be responsible for battery safety at all times during use storage and charging Read the user manual carefully Never stick body parts clothing or other objects in the vicinity of the propeller Do not wear loose or flowing clothing or equipment that could be drawn into the propeller e Particular care should be exercised when using the Seascooter near anybody with long hair Users with long hair should tie it up or wear a swimming cap when using the Seascooter Always inspect the swimming area to ensure it is free of hazards or obstacles such as boats and swimmers before using the Seascooter e Always charge battery to its fullest before using the SEASCOOTER M After charging is complete the battery will continue to off gas Wait at least 30 minutes after charging before removing the battery from the charger or placing the battery into the battery housing Failure to do so could result in an explosion 3 ALWAYS ensure sufficient charges remains in the battery to return to the poolside before using the AQUANAUT The Seascooter is not a personal floatation device always wear a Approved Personal Flotation Device Approved Life Preserver when using the Seascooter e Do not use the Seascooter under the influence of alcohol or drugs ALWAYS remove the battery from the unit when
3. no ZS06 SD5542 CAUTION ELECTRICALLY OPERATED PRODUCT Not recommended for children under 8 years of age As with all electrical products precautions should be observed during handling and used to reduce the risk of electric shock Introduction Parts diagram WARNINGS FIT RUBBER SEAL BEFORE FRIST USE Getting started Battery use Care amp Maintenance Trouble Shooting Technical Specifications 15 17 21 Instruction Thank you for having chosen the SEA DOO SEASCOOTER DOLPHIN The DOLPHIN adds a new dimension of fun and excitement to swimming and snorkeling Years of design and engineering have resulted in a water scooter that gives you power up to 2 mph 3 2 km h for up to 60 minutes of use but at the same time is compact and light The DOLPHIN weight just 12 Ibs 5 4 kg The DOLPHIN features various safety features making it safe for kids ages 8 and up These are positive buoyancy protective grilles auto shut off when triggers are released and safety lock Please take a little time to study this manual to get the most out of your DOLPHIN QGQOOOQ OO Parts Diagram Nose Cone Battery leads and Connector Battery Seal Latch Handle 8 Trigger Safety Switch Front Grille Nozzle Propeller Rear Grille Silicone Grease O ring Seals Charger Charger Jack WARNINGS N WARNING CHOKING HAZARD Small parts Not for children under 3 years Not to be used by
4. not in use DO NOT store the battery in the unit e The DOLPHIN is for pool use only DO NOT use in the Open sea FIT RUBBER SEAL BEFORE FIRST USE 1 Unlock two latches and remove Nose Cone STEP 2 Fig 2b 2 Rubber seal must be fitted as shown and lightly lubricated with the supplied grease 6 Getting Started When you buy the SEA DOO SEASCOOTER DOLPHIN the battery is disconnected and needs to be charged Follow the safety cautions on pages 8 9 10 and 11 and charging instructions on pages 12 13 and 14 Using the SEASCOOTER for swimming and snorkeling To use the SEASCOOTER for swimming or snorkeling follow these instructions 1 Charge the battery and install just before use 2 Place the SEA DOO SEASCOOTER DOLPHIN into the water 3 When ready to set off switch the Safety Lock to the On position shown in fig 3a 4 Pull and hold both Triggers to start the Propeller There is a short delay before the Propeller begins to rotate 5 To stop the Propeller simply release one or both trigger s 6 Always set the Safety Lock to the Off position when out of the water see fig 3b 7 ALWAYS remove the battery when not in use On Position Off Position Battery Use WARNING BATTERY SAFETY RE CHARGE THE BATTERY Must remove and store AT LEAST the battery separately from E V R y the unit when not in use Must re charge the battery MONTHS after use WITHIN 24 HO
5. pin or washers 7 Remove the blockage from the Propeller 8 Replace the drive pin if removed see fig 11 and Propeller Turn the Propeller slowly until you locate the pin and push the Propeller fully on Drive Pin In Position 9 Replace the washer and nut and tighten with the socket whilst holding the Propeller making sure it is securely fastened See fig 12 10 Replace the Rear Grille 11 Replace the battery and connect and replace the Nose Cone Propeller NN Nut Drive pin Washer Sand or Grit on Seal Sand or grit is the enemy of seals Correct maintenance and care is essential To remove sand or grit from the seal rinse the seal in fresh water and apply fresh lubricant If there is sand inside the Battery Housing gently brush the sand from the unit taking care not to scratch the sealing surfaces Accidental Flooding Be sure to keep the seal sand and grit free to ensure it keeps water out and to close the latches fully after accessing the battery chamber However should the seal not be clean or the latches not fully closed and water enter the battery chamber your SEASCOOTER will not be damaged as it is designed for protection against accidental flooding If water enters the battery chamber 1 Remove the unit from the water open the nose cone and tip any excess water out 2 Wait two minutes for any gases to dissipate then remove the battery 3 If salt water has entered rinse batte
6. 000183900 0001 000183900 0002 000330279 0001 000330295 0001 03020902 7 302949 302564 302563 302950 302948 2005100230 200503474 29 268 724 11 595 675 000816376 0001 Toll Free 1 877 2650996 service stallionsport com www stallionsport com Produit Autoris Licensed Product SEA DOO and the BRP logo are trademarks of Bombardier Recreational Products Inc or its affiliates used under licence to Stallion asia Ltd For more information on SEA DOO products visit www sea doo com P r o d u c t Patented Print in China uo 6 1u UNOA u 83uo2 BOIAIOS Jeulojsn y Je seAnejueseJdaJ BOIAI9S JBWOJSND INO Jo euo 9e uoo5 d3L1S SJIeMSUe juejsu pui o uonoes Dy JNO ees pue ulooJejoooseesoopees WMWM 01 OF Z dJLS UIOD 18 009SL SOOPL S MMM USIA sp d sjenuey sN eui jo doo e 104 enuen sN 1n0oA pea esee d L d31S uomnnjosaiJ se pue seo 10 sdeis wojaq eui Mojoj eseeid H31009SV3S sOOQ V3S 4no BuipieB 1 oAeu Aew noA seuenb 40 suonsenb Aue 104 enue eoiuegs eui Aq peideooe eq 10u IM xoq eui Jo episino eui oi pree peuoene J1equinw uonezuouiny Jredey unyay pue 1die264 eseuoung JO joo4g eui eneu JOU OP Fey seueAjeg ILON 3SV3Td eJue BOIAIBS y o1 eDexoed y dius S JOQUINN uonezuouiny eday unay eui ui 49u19601 qISIA A preojo xoq 8u JO episino du 0 1die29J eseuoung JO joojg 1no Jo doo eui YOeUY p Sued eAnoojep e pue yun eui epn
7. PHIN releases a potentially explosive gas during charging Charging should only take place in a well ventilated area away from children and naked flames or other ignition sources cigarettes sparks Never charge the battery whilst still in the SEA DOO SEASCOOTER DOLPHIN Always remove the battery from the battery housing before charging Always connect charger jack to the battery first and then plug charger into the mains After charging disconnect from the mains first and then disconnect the battery from the charger After charging is complete the battery will continue to off gas Wait at least 30 minutes after charging before removing the battery from the charger or placing the battery into the battery housing Failure to do so could result in an explosion use Remove battery from charge once fully charged Never charge the battery in sealed container Always ensure the unit is dried thoroughly before opening the Nose Cone Never charge the battery near water Only use the charger supplied with the SEA DOO SEASCOOTER DOLPHIN Charge the battery as soon as possible after use within 24 hours Never short circuit the battery or battery connectors Always ensure the charger is dry before use Battery Use CAUTION The charger gets quite warm in use this is normal If in doubt of the state of the battery recharge it until the indicator on the battery charger indicates a full charge If the
8. URS Must re charge the battery at least EVERY THREE MONTHS when not in use User Manual must be read and understood before use No warranty for the battery Please read and follow the Battery Safety Instruction Incorrect battery maintenance may reduce the battery life and influence its function Battery Use CAUTION Your SEA DOO SEASCOOTER DOLPHIN is supplied with a battery that needs to be treated carefully as it will release potentially explosive gasses during its normal cycle of use off gassing Please read the entire manual thoroughly and follow all instructions Failure to do so can result in an explosion occurring Always remove the battery from your SEA DOO9 SEASCOOTER DOLPHIN when it is not in use and store separately in a well ventilated area where it is out of the reach of children and away form heat and ignition sources Do not install the battery in your SEA DOO SEASCOOTER DOLPHIN until immediately prior to using it Before disconnecting connecting any cables open the nose cone and allow two minutes for any explosive gases to dissipate Do not use store charge the battery in temperatures above 40 C 104 F as excessive off gassing may occur Keep the battery and SEA DOO SEASCOOTER DOLPHIN in the shade when not in Battery Use CAUTION Always charge the battery to the fullest before using the SEA DOO SEASCOOTER DOLPHIN The battery supplied with your SEA DOO SEASCOOTER DOL
9. battery is not to be used for an extended period store it in a well ventilated area away from children heat and ignition sources and recharge it every three months to maintain charge and avoid excess of gassing DO NOT store the battery inside the SEA DOO SEASCOOTER DOLPHIN If the battery appears damaged or will not charge fully the battery must be replaced If battery life is noticeably reduced the battery should be replaced Do not recharge non rechargeable battery This charger only charge to Sealed rechargeable lead acid 12V 7 5Ah battery one battery per each charge This appliance is not intended for use by persons including children with reduced physical sensory or mental capabilities or lack of experience and knowledge unless they have been given supervision or instruction concerning use of the appliance by a person responsible for their safety Children should be supervised to ensure that they do not play with the appliance During charging batteries must be placed in the well ventilated area only for battery chargers for lead acid batteries Charging the battery For battery charging follow these instructions 1 Always ensure that the Safety Lock in the Off position is Off see fig 3b 2 Always ensure that the SEA DOO9 SEASCOOTER DOLPHIN is out of the water dry and placed in a dry area 3 Pull the latches down and remove the Nose Cone as shown in fig 4 so fw J 4 Allow two minutes for a
10. iJ yom ed 10 eDeuiep Aue 104 9Ju92 9IAJ9S jeujojsno Jno Durmoejuoo 910Jeq enuey sN Jno o J9JoJ eseejd Dunejedo jou s yun noA J SAIYINONA YANWOLSNOD Asayyeg eui apnjoul OU s op uenem SIU AH3 LIVS SNOISN19X4 3ON3IN3ANOONI HO AWIL dO SSO GNV LONGOdd AO ASN dO SSO HOLNEINLSIG JHL OL LONGOYd AHL SNINH LESH dO 3SN3dX3 OL GSLINIT LON LNG DNIGNIONI S39VINVO H3HLO HO IWILNSNOASNOO IVLN3GIONI HOS ALITISISNOdS3H ON SAWNSSV HOLNGIYLSIG JHL NOIJVOI18O HdHlO ANY WAHL HOd AWNSSV OL 3NOANV AZIHYOHLNV HO AWNSSV LON S300 YOLNEIYLSIG AHL H3NWOLSO AHL OL LONGOYd JHL dO NYNLSAY GNV SldVd JAILOASSG dO LNAWSOV1dsY HO HlVddH AHL OL AGALINIT ATSAISNIOXS ANY ATLOIHLS SI ALNVHHVM AHL YSQNN NOIIVOlIHO S YOLNEIYLSIG AHL GOlYdd ALNVHHVM JALVIYdOUddV AHL AO NOIJVHIdX3 FHL H31d4V AL3HILN3 YISHL NI GSWIVIOSIG 3HV SSIMYSHLO HO 3SsOdH d YVINOILYVd V HOS SSANILIA ALITISVLNVHOH3N SONIGNIONI S31ILNVHHVM Qal 1dINI HONS ANY GOldsd ALNVHHVM JHL OL NOILWYNG AHL NI GSLINIT 3HV SSILNVYYVM Gd 1dINI TIV 189 pue 129M jewou 59u li dx Jeu SWd9 149AOO jou S Op AjueIIeM si uonippe ul ullqeinp 40 eoueulojed uone4edo si s 2 ye A osJoApe JO onpoid aui YUM qi eduuooui Jaya uoiluwM seuossoooe JO sued jo esn ul Aq 10 seam ewou Aq Kjesseoeu epeui syiedds o puajxe JOU seop AlU amp JJeA SIU sn pepuelul Sy eBueyo oj se os peuipoul Jo paJeye u q seu ey jonpoud Aue oj JO eoueueojureui Jedouduur Jo nsa y s jeu 1o
11. immediately after use To clean the SEASCOOTER do not use detergents only use a damp cloth to wipe the unit clean The Battery Housing interior should be kept dry at all times If the Battery Housing interior ever gets wet see page 20 Accidental Flooding for steps to take When storing the SEASCOOTER for extended periods of time open and remove the Nose Cone ALWAYS store your SEASCOOTER vertically when not in use to prevent deformation of the Propeller Nozzle Trouble Shooting Unit does not function If the motor does not start when both triggers are pressed make sure 1 The battery is properly connected 2 The battery is fully charged see page 12 charging the battery 3 The Safety Lock is in the On position see fig 3a page 7 4 There is no water in the battery compartment see page 20 accidental flooding Blocked Propeller If the Propeller becomes blocked the Rear Grille and Propeller can be removed to remove the obstacle Removing rear grille and Propeller to remove obstruction 1 Remove the SEASCOOTER from the water 2 Make sure the Safety Lock is in the Off position 3 Disconnect and remove the battery see page 12 step1 6 4 Unscrew the eight Rear Grille screws as shown in fig 9 Q 5 Whilst holding the Propeller use an M6 socket to remove the nut from the Propeller shaft See fig 10 6 Slide the Propeller off the shaft taking care not to loose the drive
12. jour pue weoy auasAjsAjod eui Buipnjoui BuiDexoed euiDuo sii ul yun eAnosjep y YLd E 4di9298J eseuoung JO JOOJY JNOA jo doo e yeNn Z JOQUINN uonezuouiny meday uinjeH INOA 10 B JUBD 29IAJ9S Jeulo sn aul 2 I SYNGs00 d Nl Ei Ndf1Lddi 101nquisip 290 INOA 19e uoo pue WO3 13 009SL SOOPL S MMM 1ISIA eseajd s lI0111191 194 0 104 WOOD RISBUOI EISMPIMES IEW 9gec 918 2z89 ON euoug FYLNFI FDIAYFS YINOLSNI TET TE c0Od vIS NNOY ONOH uloouodsuJexXq eoruJes jPU3 OZ 0S 919S 98Et ON 8uoud EIFE JOIAYGAS YANOLSNI wibFLOOISVAS eOOd VaS ddOuna IWYHLNID ANY NYSHLNOS NH31S V3 Biopeydje ouyol ew SISIS 602L 0 prt ON uoud FYLNFD FIIAYAS YANOLSNI mYILOOISVIS e0OG VIS JdOUNA NYALSIAM Ul02491009seesoopeesq ueo AjueJjeM IEW 99 99 999 L ON euoug FYLNFID FOIAYIS YANOLSNI m4ILOOISVIAS e0OG vVIS VOVNVD Ul02491009seesoopeesQyesn AjueJeM jeuld 19 2 19 009 L ON euoug EE FDIAYTS YIWOLSNI m4ILOOISVIS e0OOG vVIS SJIVLS GILINN eseo Ino Buljpuey Ul BOUe SISSE J0J 9J1u92 BOIAIOS J uuolsno JNO j9e uoo eseo g sued aAnoasjep je pue enau Hulyoed auasAjsAjod aui Buipniou BuiBeyoed eui amp uo uw peddius eq snu sjonpoud peuinjey eue 99IAJ9S y oi 1onpoud eui Buipues 8J0Jeq jequinN uomnezuouiny ed r uINJOY E JO xse pue yu g m JBWOISND ino jeo 1snu sjeujojsno PSSIBIer diVdad EI IEE peseuound SEM 9JOUM 9JO S y 01 1onpoud ano uunjeJ jou op se jd pauinbo
13. npoud y oj eDeurep Aue o Ajdde ou seop uenem siy enuen JOS eui ui peiuoeds se suononuisuri Bunejedo y 0 qeJjuoo Aem Aue ul poejeJedo ueeq sey ey 10 juepiooe 10 eouefi Dou asnsiw 0 1oe qns ueeq seu ey 1onpoud Aue 18409 JOU Seop AU amp JIeA SIU
14. ny gasses to dissipate 5 Disconnect the battery cable from the housing cable if not already disconnected the cable will be disconnected when you buy your SEASCOOTER by pressing the locking feature as shown in fig 5 6 Remove battery and place on a level surface 7 Connect the battery cable to the charger cable 8 Plug charger into mains and turn on the supply Q Press here to release and pull to disconnect 9 Charging will take 14 16 hours for a fully discharged battery When the battery is charging the red LED is lit when the battery is charged the green LED is lit 10 Unplug the adapter from the mains 11 Unplug the battery cable from the charger cable 12 Allow battery to stand for 30 minutes before using it 13 When ready for use place the battery into the housing and connect the housing cable 14 Make sure the seal and sealing surfaces are clean and lubricated before replacing the Inner Nose Cone See fig 6 Ensure sealing surface is clean and seal is lubricated 15 Replace the Nose Cone and close the latches 43 To replace a flat battery with a fully charged battery 1 Follow the steps 1 to 3 on page 12 to open the SEASCOOTER 2 Allow two minutes for gases to dissipate 3 Unplug the battery at the socket by pressing the locking feature shown in fig 5 4 Remove the flat battery 5 When ready for use install and connect battery in the correct position see fig 7
15. ry housing and battery with fresh water 4 Dry housing and battery thoroughly 5 A safety catalyzer to protect against explosive gas in normal use is held in a spring in the bottom of the battery housing If the catalyzer is wet it will not function and must be allowed to dry out before use Technical Specifications Unit Dimensions 11 25 inches x 11 25 inches x 19 inches 285 x 283 x 483 mm Unit Weight Battery Type 12 lbs 5 4 kg with rechargeable battery 5 3 lbs 2 4 kg without rechargeable battery 1 x 12v 7 5Ah rechargeable battery Battery Life Depth rating Speed Approximately 1 5 hours 15ft 5m Up to 2 0 mph 3 2km h For more information on Sea Doo Seascooter Products Warranty Customer Care Maintenance Parts amp Battery Purchase PLEASE VISIT www seadooseascooter com Distributed by Stallion asia u Block F 6 F Wah Hing Industrial Mansions 36 Tai Yau Street San Po Kong Kowloon Hong Kong Products covered by the following patents USA Canada EU Australia Japan Hong Kong China amp Turkey US D471 506S US D518 768S D527 702S US D506 176S US D507 776S D512 678S D519 911S 6848385 B2 US 7000559 B2 US 7093554 B1 11 102 302 0500577 8 0500578 0 0500579 2 HK1072691 ZL200530005661 5 ZL200430079550 4 ZL200430057359 X ZL200530005662 X ZL200530005663 4 ZL200320103738 8 ZL200520008894 5 1194933 1254107 1225250 000330311 0001
16. uu 9 Vd 1X3N JJS 1 ulo sno eui 0 19npoid y Buluin i Jo esuedxe y 10 ed Iw JOINGUISIG SUL 4oinquisiq eui o jonpoJd y Buli AI p Jo esuedxe y 104 Aed IM JeuJojsno eu poled AjueJew y uiui JOINGUISIG 9uj oj jues eq snu ed eAnosjep Aue Buipniou jonpoud y 40qe Jo sued 104 eBjeuo nou lA Joinquisiq eu Aq peoejdaiJ JO paJredaiJ 9q IM diysuewyJom JO Jenae UI 9An99Jep 9q o Jojnquisiq ay Jo jueuj6pn ejqeuoseoi y Ul puno pue Jojnquisiq 24 q perjddns jonpoud au jo wed uy J9j u92 BdIAIaS Ji u Buijeo Aq uoibes noA ul poued AjueueM y 10 JOINGUISIG 290 INOA xsv Jajeap peziuoujne ue wol peseuound sjonpoud uoles Jue ueA AINO S4J0j1nqijsiq S Jiejop 91 JUBD DIIAIIS 1O NGIIJSIP 10 U102 19 002SP8SOODpPeoS MMM JISIA SL d A10 119 JNOA ui sjueuieDuejge AJUeLIEM JO 103nqijsip e20 Jno 32ejuoo se jd epeue Jo sojejs pajuf y ui pejeoo Jou aJ no JI sy npoid m u 104 eseuound jo a ep y wol sujuoui 9 JO Aju amp JleM pow pJepuejs e piAoid epeue pue soajejs payun y ui sjojnqujsiq TUTO TERRE VIT M ES Te Yo eT 3 23e T0 e 3 RM 1 NO A T3LVIGSIANWI ALNVYY YM ANOA ALVAILIV SAVA TV uonensibay Ajueue AI 32P ue YJIM SJONPOJd uenem A TINO S40 nqujsiq NOILVNAOANI 3J3 IA3 q3S dANOLSNID 9 ALNVeH HVM ul0o2 19 002S E9SOODEOS MMM QUOUe3t wp User Manual English Version SDP95002 a 3E 9 200 SEA DOO SEASCOOTER DOLPHIN Model
Download Pdf Manuals
Related Search