FGA-700 User Manual
Contents
1. Remarks amp Action Taken Service Type o Periodic Inspection o Monthly Inspection Completed By Printed Name Company Remarks amp Action Taken Service Type o Periodic Inspection o Monthly Inspection Completed By Printed Name Company Remarks amp Action Taken 280400 280401 FGA 700 Owner s Manual Complete this section after each service repair inspection and or maintenance Photocopy additional pages as required o 6 Month Inspection o Repair o Yearly Inspection o Other Signature o 6 Month Inspection o Repair o Yearly Inspection o Other Signature o 6 Month Inspection o Repair o Yearly Inspection o Other Signature o 6 Month Inspection o Repair o Yearly Inspection o Other Signature o 6 Month Inspection o Repair o Yearly Inspection o Other Signature o 6 Month Inspection o Repair o Yearly Inspection o Other Signature Rev 10 18 12 Page 29 Warranty This Warranty does not affect or in any way limit your Statutory Rights 1 Prism Medical guarantees all equipment supplied as new against failure within the period of 1 year from date of purchase by virtue of defects in material or workmanship 2 This warranty does not apply to failure attributable to normal wear and tear damage by natural forces user neglect or misuse or to deliberate destruction or to batteries more than 90 days after original purchase 3 This equipment warranty shall be void if the equipment is not se2. cycle is defined as Moving with load the actuator draws more than 1 5 Amps Moving direction up for a minimum of 5 seconds several activations are allowed followed by moving down for a minimum of 2 seconds Total work made by lifting actuator Work indicator for the lifting actuator measures via ampere usage x seconds in use The work indicator gives very good indication of how worn is the actuator Typical minimum lifetime per formance without abuse of the actuator is 10000 cycles in life test equals to 5 600 000 A x S Total number of over loads Counts the number of times the lifting actuator has been overloaded Resetting of Service interval after service has been carried out Resetting of service is done by pressing 2 buttons Lifting arm UP and lifting arm DOWN on the hand control at the same time for 5 seconds After pressing the buttons for 5 seconds you will receive an audio signal indicating that the timer has been reset The timer will clear the display for service symbol and start counting a new service period 280400 280401 FGA 700 Owner s Manual Rev 10 18 12 Page 20 Technical Specifications FGA 700 Specifications for FGA 00 Bariatric Aluminum 00 Ibs ise load ae weight in Ibs and Dimensions in inch common S e Le rorrearae w kaas ei e2 es Radius oo eels eel oe 700 EE SLL 30 1 46 9 25 2 MEA 27 2 17 8 20 9 28 7 72 5 21 3 80 9 57 5 CAEI Max lo
3. tector caps on the bolts and nuts as shown in Figure 12 and 13 Figure 6 Figure 7 Figure 11 Figure 12 Figure 13 7 Remove the screws from the mounting position of push handle on Mast assembly Insert the screws through the push handle bracket and mount on the Mast assembly as shown in Figure 14 and 15 lt m Figure 14 Figure 15 280400 280401 FGA 700 Owner s Manual Rev 10 18 12 Page 9 Assembly Instructions Attaching 4 Point QRS Locking Carry Bar to Lift 8 To attach 4 point locking carry bar supplied along with the lift to the lift tilt the carry bar to almost 90 and push the latch to the swivel mount holder bolt as shown in Figure 16 and 17 Make sure that swivel mount of carry bar is perfectly sit onto the swivel mount holder bolt as shown in Figure 18 Figure 17 Attaching 2 Point QRS Carry Bar to Lift 9 Attach 2 Point Quick Release Carry Bar to the Quick Release Hook as shown in Figure 19 and 20 Figure 19 Figure 20 280400 280401 FGA 700 Owner s Manual Rev 10 18 12 Page 10 Assembly Instructions 9 Remove the middle screw from the mounting bracket using 3 mm Allan Key as shown in Figure 21 10 Press the FGA 700 CBJ Care Control Box 280445 against the mounting bracket and slide it down The control box should be seated securely on top of the edge of bracket as shown in Figure 22 11 Mount the Control Box to the mounting bracket using same screw that you
4. 0 C Temperature 10 to 70 C Relative Humidity 10 to 100 RH Relative Humidity 30 to 75 RH Atmospheric Pressure 500 to 1060 hPa Atmospheric Pressure 700 to 1060 hPa 280400 280401 FGA 700 Owner s Manual Rev 10 18 12 Page 5 Cautions Under no circumstance should the FGA 700 and sling s be put in control of a person who has not been properly trained in the use and care of this equipment Failure to adhere to this warning may re sult in serious injury to the operator and or the individual being lifted transferred e The FGA 700 Bariatric floor lift and sling s are not toys Do not use it for unsafe practices Do not allow children to play with the floor lift or any of its components e The manufacturer s warranty is voided if persons unauthorized by Prism Medical Ltd will perform work on the FGA 700 Bariatric floor lift e There are no user serviceable parts inside the actuator Do not remove cover screws or open the unit as this will VOID THE WARRANTY In facilities where more than one operator will be responsible for using the FGA 700 and sling s it is imperative that all such members are to be trained in its proper use A training program should be established by the facility to acquaint new operators with this equipment e Never expose the FGA 700 Bariatric floor lift directly to water Warranty does not cover any misuse or abuse of the floor lift system e To maintain optimum function the FG
5. 14 mm Wrench Carry bar mount 280400 280401 FGA 700 Owner s Manual Rev 10 18 12 Page 25 Service Record History Initial Information Complete the following section on Purchase and Service Information as soon as this equipment is purchased Use the service record history to record to any completed service and repairs Ensure that the service record is signed and dated each time it 1s used Be sure to have this piece of equipment serviced on a regular basis as described in the General Inspection and Maintenance Section PURCHASE INFORMATION Product Name FGA 700 Bariatric floor lift Model Serial Date of Purchase Purchased From local authorized Prism Medical Representative Address City Postal Code Telephone No Comments SERVICE INFORMATION Contact the following company for service Company local authorized Prism Medical Representative Address City Postal Code Telephone No Comments 280400 280401 FGA 700 Owner s Manual Rev 10 18 12 Page 26 Service Record History Service Type o Periodic Inspection oc Monthly Inspection Completed By Printed Name Company Remarks amp Action Taken Service Type o Periodic Inspection o Monthly Inspection Completed By Printed Name Company Remarks amp Action Taken Service Type o Periodic Inspection o Monthly Inspection Completed By Printed Name Company Remarks amp Action Taken Service Type o Per
6. A 700 should be inspected and maintained on a regular basis See the section titled General Inspection and Maintenance e Any accessories used with the FGA 700 including sling s should be checked to ensure that they are in good working order Check for signs of wear or fraying prior to use Report any unusual wear or damage immediately to your local authorized Prism Medical Service Provider e The FGA 700 Bariatric floor lift and associated sling s are intended only for lifting and trans ferring of a person Prism Medical will not be responsible for any damage caused by the misuse ne glect or purposeful destruction of the lift and or its associated components e In any circumstances do not exceed the maximum allowable load of this lift Refer to the Specifications section of this manual and or the labels on the side of the lift There is a risk of explosion if the lift is used in the precsense of flammable anaesthetics e Ensure that a clear space is maintained around the lift Move any obstacles out of the way before opereating the floor lift 280400 280401 FGA 700 Owner s Manual Rev 10 18 12 Page 6 Assembly Instructions 1 Place the Carton Packaging box in a clear working area open carefully and remove following items and place on the floor taking care to protect the finish from damage Mast with Boom assembly Base Assembly with Legs attached Battery Pack and Charging Power Cord Hand Control T
7. Completed By Printed Name Company Remarks amp Action Taken Service Type o Periodic Inspection o Monthly Inspection Completed By Printed Name Company Remarks amp Action Taken Service Type o Periodic Inspection o Monthly Inspection Completed By Printed Name Company Remarks amp Action Taken 280400 280401 FGA 700 Owner s Manual Complete this section after each service repair inspection and or maintenance Photocopy additional pages as required o 6 Month Inspection o Repair o Yearly Inspection o Other Signature o 6 Month Inspection o Repair o Yearly Inspection o Other Signature o 6 Month Inspection o Repair o Yearly Inspection o Other Signature o 6 Month Inspection o Repair o Yearly Inspection o Other Signature o 6 Month Inspection o Repair o Yearly Inspection o Other Signature o 6 Month Inspection o Repair o Yearly Inspection o Other Signature Rev 10 18 12 Page 28 Service Record History Service Type o Periodic Inspection oc Monthly Inspection Completed By Printed Name Company Remarks amp Action Taken Service Type o Periodic Inspection o Monthly Inspection Completed By Printed Name Company Remarks amp Action Taken Service Type o Periodic Inspection o Monthly Inspection Completed By Printed Name Company Remarks amp Action Taken Service Type o Periodic Inspection o Monthly Inspection Completed By Printed Name Company
8. FGA 700 by Prism Medical roduc osisanom rai rine 2 VT IG earann A 2 Components of the Floor Lift ccceceeeseeeeeeeeeeeeees 3 Component LIS E ccesarncccetecienecaneaieinccesaannandethiawenanndions 4 SPESCMICAUIOINS oseetecccn cen tececetadsonute ence eetedeachenteacscbakeseeees 5 O52 10 16 9 een ae oe ee eee ee eet ne en renee eer cere 6 Assembly Instruction ccccseecceeeeseesenseeeeseeseesenseees 7 Operation CHEN GING AE AEE E T ede linscosceasace ales seas 13 OU A EPEE IATE E T T T TTE EAE 13 Forward MoOvemen cccccceeeeeeeeeeeeeeeeeneeees 14 TEDI ooer E 14 Leg Adjustment ccccccccesesseeeeseeseneeeeeeanens 15 Raising and Lowering BOOM scceeeeeeeeees 15 Casters and Braking cccceseeeeeeeeeaeeneeaseeees 15 Basics in transferring an individual 0sceeee 16 Emergency Stop amp LOWETING cccceeeeeeee eee ees 18 Control Box Usage Information ccceeeeeeeeees 19 Control Box Service Information cccceceeeeeeees 20 Technical Specifications cccc eee ce cence eee eeeaes 21 DO S and DONIS wecsccaiecesdsossucesczacieues etacbaganeetecscedas 22 Fault Nad 222208 tase besa teecseetinsysceddveneeneedeenseaabenss 23 General inspection and maintenance 605 24 Points of Attachment Checklist cceeeeeee ees 25 Service record NiStOry ccceeceece eee eeeeeaees
9. ad and an Siem ieee ean in kg Dimensions in em Max a Turning load CACICADA CAA Radius KARL 1e8 AL E18 188 150 92 5 76 5 119 64 106 5 125 105 8 5 48 69 1 73 73 risa 54 206 146 120 100 280400 280401 FGA 700 Owner s Manual Rev 10 18 12 Page 21 DO S amp DON TS DO v Do charge the battery whenever possible This will extend the battery life A large number of cycles can be obtained from operating on the batteries but battery lifetime is reduced with frequent discharging v Do inspect all cables particularly the mains power cable on the charger for any damage replace where necessary v Do stow the handset and if fitted with charger the mains power cable when transporting the hoist v Do clean the actuators control box charger battery and handset at regular intervals to remove dust and dirt The exterior of the lift should only be cleaned disinfected and sterilized using isopropyl alcohol Damp a cloth with isopropyl alcohol and wipe down entire exterior of lift No other chemicals and or liquids should be used to clean disinfect and sterilize this lift Caution Take great care to ensure that no liquids get inside the lift This lift is not drip proof or water tight Failure to protect the lift from liquids may result in damage to the lift and or may cause personal injury DON T x Don t allow the batteries to fully discharge before connecting to the charger The batter
10. age 8 25 2 inches 64 cm Height to top of legs 6 1 inches 15 5 cm Clearance from bottom of legs to floor 3 3 inches 8 5 cm Overall length 59 inches 150 cm Distance inside the legs min 25 2 inches 64 cm Distance inside the legs max 41 9 inches 106 5 cm Distance outside the legs min 30 1 inches 76 5 cm Distance outside the legs max 46 8 inches 119 cm Reach at maximum height 18 9 inches 48 cm Reach at minimum height 17 8 inches 45 3 cm Maximum Reach Distance between center of carry bar to front of the mast 27 2 inches 69 1 cm 62 8 inches 159 5 em Front 4 101 mm Rear 5 127 mm w brake Weight of lift 161 Ibs 73 kgs Total Shipping Weight WGS Box On B Electrical Specifications FGA 700 lift Wheels dual wheel castors Lift Motor 24 VDC 9 7 Amps Max Charger Input 100 240 VAC 50 60 Hz 0 4 Amps Max Charger Output 24 VDC 0 65 Amps Batteries 24 VDC 2 x 12 VDC 2 9 Ah Sealed Lead Acid Hand Control Electric Lifting Range 21 3 to 72 5 for Lowest Mast Setting eo yClenE Dee Maximum load of the installed floor lift is determined by Maximum Load Standard maximum load 700 Ibs i referring to the product label located on side of floor lift Duty Cycle 10 use 90 rest Rated Performance 30 lifts at 700 Ibs 10 duty cycle 60 lifts at 350 lbs 10 duty cycle Shipping Storage Conditions Normal Operating Conditions Temperature 40 to 7
11. e carry bar Be sure to double check to ensure that the straps are properly attached to the carry bar and that the individual being lifted 1s properly positioned in the sling prior to lifting A Caution Prior to lifting an individual make sure that the straps of the sling are securely placed on the hooks of the carry bar 280400 280401 FGA 700 Owner s Manual Rev 10 18 12 Page 16 Basics in transferring an individual continued Step 5 The individual may now be raised using the UP button on the hand control While lifting is in pro gress the height required in order for the transfer to be completed safely should be closely observed Ensure that the individual being lifted will not be injured by any obstructions during the initial lifting Caution Always use caution when lowering raising an individual who is in the sling of the lift Watch out for and avoid any obstructions that may cause injury to the individual or dam age to the lift Step 6 Once at the correct height the individual can be moved to the desired location Refer to the sections already described in this manual on how to do so Step 7 Once at the desired location the individual in the sling can be lowered raised to the correct height in order to complete the transfer On completion of lowering raising ensure that the individual is properly posi tioned and safely supported prior to removing the straps of the lift from the carry bar A Caution Pr
12. eeaeeaeees 26 WV GPE a A E AEE E E E E EET 30 Owner s Manual PRISM MEDICAL 45 Progress Parkway Use and Care m oc SR e T 1 866 891 6502 314 692 9135 Fault Finding F 314 692 7858 Warranty Information CAUTION DO NOT ATTEMPT TO USE THIS EQUIPMENT WITHOUT FIRST UNDERSTANDING THE CONTENTS OF THIS MANUAL Introduction Before using this equipment and to ensure the safe operation of your FGA 700 Bariatric floor lift care fully read this entire manual especially the section on Cautions The FGA 700 is designed to be used in conjunction with Prism Medical accessories and slings Please refer to any user guides supplied with these components and refer to them while reviewing this manual Should any questions arise from reviewing this manual contact your local authorized Prism Medical Repre sentative Failure to comply with warnings in this manual may result in injury to either the operator or the in dividual being lifted transferred Damage to the floor lift and or related components may also occur Be sure that the contents of this manual are completely understood prior to using this floor lift Store this manual with the documents included with the floor lift and sling s Contents of this manual are subject to change without prior written notice Overview of FGA 700 Bariatric floor lift The FGA 700 is a lifting aid used by health care professionals to transfer clients The floor lift makes it possi ble to
13. es works properly Leg spreading actuator works properly Batteries are fully charged 280400 280401 FGA 700 Owner s Manual Rev 10 18 12 Page 12 Operation A Caution Visually inspect the floor lift before using for any unusual wear and tear Should any thing look unusual then contact your local representative prior to use Failure to comply with this caution could result in serious injury to the operator the individual being lifted and or damage to the lift Because of the safety function in the actuator the lifting arm and hanger bar can fall down to the height of the spindle Therefore both before and after each lifting operation press the lifting arm down to ensure that it is supported by the actuator This must be done to remove the possibility of the lifting arm falling down and the risk of subsequent injury occurring Charging The On light illuminates when you plug the control box to the power outlet and should turn off when it is unplugged The Charge light illuminates and when you connect the battery to the control box and it is charging also the LCD displays shows the symbol of mains cable plug in as shown in the Figure 30 The Charge light will turn off when the battery is finished charging The lift should be plugged in for charging whenever the lift is not in use to get the max number of cy cles out of the battery An audible battery alarm will sound when approximate 25
14. ies are a lead acid gel cell type that can be trickled charged continuously batteries used for standby and have a high current discharge capacity Life is greatly reduced by deep or complete discharging of the bat teries Longer lifetime is obtained by maintaining fully charged batteries x Don t continue to operate the handset by repeatedly pressing the buttons if the lift function will not move or the actuator will not function If this occurs then the actuator has either reached its end posi tion the load is too great or there is a malfunction x Don t exert excessive force on the handset cable as this may break off the wires inside the cable and prevent some or all of the operations x Don t continually operate the hoist functions The system is not designed for continuous operation Continuous Operation will cause batteries to be deeply discharged or to damage the actuator or con trol box by overheating 280400 280401 FGA 700 Owner s Manual Rev 10 18 12 Page 22 Fault Finding Should problems arise with the use of the lift review the following chart Find the fault and complete the rec ommended solution If the fault is not found and or the solution does not correct the problem contact your local Prism Medicalauthorized Service Provider for service immediately PROBLEM Lift cannot raise lower control box is not clicking Lift cannot raise lower control box is clicking Emergency Lower button on control box does not l
15. increases the risk of the lift tilt over Application If the lift is used incorrectly any warranty or product liability might cease to be valid The mobile lift must only be used for person lifting and only for persons who including the sling do not weigh more than the stated max weight load If the load exceeds the stated weight limit and if the lift is used for lifting anything but persons then any product liability that Prism Medical might have in connection with insurance warranty maintenance etc will cease to be valid To avoid possible accidents and injury to persons being lifted the floor lifts must only be operated as de scribed in the preceding pages 280400 280401 FGA 700 Owner s Manual Rev 10 18 12 Page 15 Basics in transferring an individual A Caution The following steps are intended to generally illustrate the procedure involved in the lifting and transferring of an individual from one location to another using the floor lift The manual for the sling that was purchased with the lift should be reviewed in detail prior to attempt ing these steps as the sling illustrated here may not be the same as the one that was purchased Contact your local authorized Prism MedicalRepresentatives if you have any questions or concerns Step 1 Unplug the lift from its charging station or current location and move close to the individual that is to be transferred Use the procedures for up and down and transferr
16. ing as described in the sections titled Start Forward Movement and Turning Caution Always use extreme care when moving the lift from one location to another Watch out for and avoid any obstructions that may cause injury to the individual in the sling or damage to the lift Step 2 Prepare the individual being transferred with the appropriate sling Refer to the instructions supplied with the sling that was purchased on how to properly outfit an individual with a sling Caution Always make sure that the sling is correctly fitted and adjusted on each side of the individual so that maximum comfort and safety are achieved prior to lifting Step 3 Once the individual has been outfitted with the sling move the lift so that it 1s positioned directly over the individual and utilize leg opening function if required Lower the carry bar to a height so that the straps of the sling can be easily attached to the carry bar AS Caution Always check to ensure that the lift is correctly positioned directly above the per son to be lifted Caution Check to ensure that the carry bar has no cuts dents or sharp edges that may come in contact with the straps of the sling and cause damage to them Report any concerns to your local authorized representative Step 4 Attach the straps of the sling to the hooks of the carry bar The straps on each side of the sling are gen erally attached to the corresponding side of th
17. iodic Inspection o Monthly Inspection Completed By Printed Name Company Remarks amp Action Taken Service Type o Periodic Inspection o Monthly Inspection Completed By Printed Name Company Remarks amp Action Taken Service Type o Periodic Inspection o Monthly Inspection Completed By Printed Name Company Remarks amp Action Taken 280400 280401 FGA 700 Owner s Manual Complete this section after each service repair inspection and or maintenance Photocopy additional pages as required o 6 Month Inspection o Repair o Yearly Inspection o Other Signature o 6 Month Inspection o Repair o Yearly Inspection o Other Signature o 6 Month Inspection o Repair o Yearly Inspection o Other Signature o 6 Month Inspection o Repair o Yearly Inspection o Other Signature o 6 Month Inspection o Repair o Yearly Inspection o Other Signature o 6 Month Inspection o Repair o Yearly Inspection o Other Signature Rev 10 18 12 Page 27 Service Record History Service Type o Periodic Inspection oc Monthly Inspection Completed By Printed Name Company Remarks amp Action Taken Service Type o Periodic Inspection o Monthly Inspection Completed By Printed Name Company Remarks amp Action Taken Service Type o Periodic Inspection o Monthly Inspection Completed By Printed Name Company Remarks amp Action Taken Service Type o Periodic Inspection o Monthly Inspection
18. ior to removing the straps of the sling from the carry bar be sure to check that the individual being lifted is securely supported in the final desired position Step 8 Lower the carry bar sufficiently to allow the straps of the sling to be easily removed from the carry bar Take care not to let the carry bar come in contact with the individual in the sling The straps from the sling can now be removed from the carry bar The lift should then be moved away from the immediate area so that it will not interfere with the removal of the sling from the client Step 9 The sling can now be gently removed from the individual It should then be stored in a safe place for future use Step 10 The lift can now be moved to a safe location until further use or relocated to its original location The lift should be turned off when not in use It is recommended that the lift be left on charge when not in opera tion Refer to the section titled Charging the lift for instructions on charging 280400 280401 FGA 700 Owner s Manual Rev 10 18 12 Page 17 Emergency Stop amp Lowering A Caution The manual emergency lowering system should be used only if the lowering procedures de scribed in the previous section of the manual do not work Should you have any concerns or questions contact your local authorized Prism Medical Representative A Caution DO NOT use the lift after the manual lowering mechanism has been used The lift must be rese
19. move mobility impaired individuals with minimal strain or risk to the caregiver while providing com plete safety dignity and comfort for the client The FGA 700 Bariatric floor lift is one of two components that make up this technology The other compo nent the sling is a specially designed fabric accessory that attaches to the floor lift by means of a carry bar and straps and holds an individual while the lift or transfer takes place The sling is generally supplied with the floor lift at the initial time of purchase Please refer to any user guides supplied with the sling and reference them while reviewing this manual The FGA 700 has the ability to lift an individual up from one location such as bed then move the individual to another location and finally lower the individual into a chair or bath The functions of lifting up or down or opening and closing the legs on the lift are accomplished by pressing buttons on the hand control The hand control is attached to the floor lift Due to the design of the floor lift system it takes very little effort to press a button to perform the desired motion Please familiarize yourself with the components of the FGA 700 Bariatric floor lift by referring to the dia gram on the next page 280400 280401 FGA 700 Owner s Manual Rev 10 18 12 Page 2 Components of the FGA 700 Floor Lift Boom I z Hand Control on Push Handle J n A A oe QRS Carry Bar ae Sie Cont
20. o users about the need for service If the lift stops because of overload the symbol will appear on the display and give user the information about why the lift is stopped If someone tries to use the lift while mains plugged in the symbol will appear on the display The user receives the information about why the lift is not working Usage of lift while charging is not possible The display showing a full battery symbol indicates that the battery is fully charged The display showing a half empty battery symbol indicates that it is time to charge the battery The display showing a empty battery symbol indicates that no battery is completely discharged The display showing a lifting actuator is moving up The display showing a lifting actuator is moving down The display showing a legs are opening The display showing a legs are closing 280400 280401 FGA 700 Owner s Manual Rev 10 18 12 Page 19 Control Box Service information The control box of FGA 700 lift having LCD display to have some basic service data on the display To get this information press the lifting arm up button on hand control for half a second The information that appears on the display is as shown below Total cycles made by lifting actuator Total work made by lifting actuator A x S Total number of overloads Number of days since last service Number of days between services Total cycles made by lifting actuator One
21. of battery capacity remaining To obtain max life charge the battery at no more than 30 discharge Please Note The battery can be charged whether the Emergency Stop is activated or not Charging Indicator Light ON when Lift is charging ee Ble Display shows Mains Cable Plug in Start The Hand Control has four functions up down and in out Press down on the symbols to operate the desired function It is not possible to use two functions at the same time An audible alarm will sound once the load becomes too great on the lift This will cause the lifting op eration to stop Do not continue to operate the handset by repeatedly pressing the buttons At this point the lift has reached it s maximum lift This is a purposefully built in safety feature Please Note The emergency stop must be released at all times during normal operation 280400 280401 FGA 700 Owner s Manual Rev 10 18 12 Page 13 Operation Forward Movement To move the lift forward hold onto the handle bar and push forward HANDLE BAR Turning When turning the lift stand on along one side With one hand pull gently on the handle bar and with the other hand push gently away on the lifting arm In this way the lift will rotate around its own axis This movement is performed with a smooth slow action to avoid swinging the patient unnecessarily A Warning Do not hold on to the actuator or swing link when turning the lift as there i
22. onal e Weigh scale functional if applicable e Casters are clean and free of debris e All bolts and attachment points are secure see next page for Points of Attachment e Visual inspection of all weld points and cast components e Check operation of the emergency stop button C Annually To be completed at least every 12 months e Complete the inspection as noted in the Semi Annually section above Also check the following e Perform a working load test of one 1 lifting cycle with the maximum load This is in accord ance to the periodic inspection requirements of ISO10535 e Check functional operation of the emergency lowering mechanism e All bolts in connection with the carry bar must be inspected greased and tightened All defec tive or worn components must be replaced e Connection bolts bearings between arm and mast to be inspected All defective or worn com ponents must be replaced e Leg spreading function to be tested and all bolts to be inspected All defective or worn com ponents must be replaced e Check that main actuator is functional 280400 280401 FGA 700 Owner s Manual Rev 10 18 12 Page 24 Floor Lift Points of Attachment Use the described tools to tighten the bolts on a monthly basis in the areas shown 17mm Wrench Actuator mounting Smm Allen Key Push Handle 4mm Allen Key Mounting Bracket 17mm Wrench Actuator mounting 13mm and
23. ool Kit User Manual and Test Certificate 280400 280401 FGA 700 Owner s Manual Rev 10 18 12 Page 7 Assembly Instructions 4 The lifting height can be set at three different levels as shown in Figure 3 In most cases lifting height at middle hole is recommended For extra lifting height the lower most setting lower hole on the mast is recommended For lower lifting height the upper most setting upper hole on the mast is recommended The distance between two holes is 2 inch 50mm For lower lifting height upper hole on the mast is recommended Lifting height at middle hole on mast is recom mended in most cases For extra lifting height lower hole on the mast is recommended Figure 3 5 Using locking handles secure the lift mast in the desired position on the base as shown in Figure 4 Tighten the mast locking knob as shown in Figure 5 Adjust the position of the locking handles pointing in downward direction towards the base as shown in Figure 5 Locking 1 Handles Figure 4 Figure 5 280400 280401 FGA 700 Owner s Manual Rev 10 18 12 Page 8 Assembly Instructions 6 Insert the bolts and plastic white washers into the Arm rest and then pass through the two holes on Mast assembly as shown in Figure 6 to 8 Insert other Arm rest into the bolts and place plastic white washers as shown in Figure 9 and 10 Tight the nuts using 17 mm wrench as shown in Figure 11 Place the bolt pro
24. ower Lift cannot spread or close legs control box is not clicking Lift cannot spread or close legs control box is clicking Cannot move lift Cannot tighten Mast into Base tube 280400 280401 FGA 700 Owner s Manual SOLUTION Hand control is not properly plugged in Hand control is defective Control box is defective Lifting actuator cord 1 is not fully plugged into slot 1 on the control box Lifting actuator is defective Lifting actuator cord 1 is not fully plugged into slot 1 on the control box Lifting actuator is defective Control box is defective Hand control is not properly plugged in Hand control is defective Control box is defective Leg spreading actuator cord 2 is not fully plugged into slot 2 on the control box Leg spreading actuator is defective Rear caster brake is engaged Casters are defective Mast locking assembly are defective replace with new Mast locking assembly Rev 10 18 12 Page 23 General Inspection and Maintenance A Each Use To be completed by User e All functions on hand control are operational B Semi Annually To be completed at least every 6 months Should any of these items fail the inspection do not use the lift Contact Prism Medical Systems or your local qualified service technician for service e Complete the inspection as noted in the Each Use section above Also check the following e Battery charger functi
25. removed from the middle of the bracket as shown in Figure 23 Figure 21 Figure 22 Figure 23 12 To install the battery 280449 you will need to press the battery against the bracket and slide it down until it sits straight on top of the control box as shown in Figure 24 Make sure to secure the battery box by latching the battery lock into the bracket as shown in Figure 25 Figure 24 Figure 25 280400 280401 FGA 700 Owner s Manual Rev 10 18 12 Page 11 Assembly Instructions 13 Connect all the cables to the control box as shown in the picture below A Connect the Hand Control connector to the large circle on the left side of the control box as shown in the Figure 26 B Connect the LA44 Actuator Cable connector to the second circle Marked No 1 from the left side of the control box as shown in the Figure 27 C Connect the LA28 Leg Spreading Actuator Cable connector to the third circle Marked No 2 from the left side of the control box as shown in the Figure 28 D Connect the Mains Cable Power Cord to the rectangular outlet on the control box as shown in the Figure Figure 28 Figure 29 14 Please make sure to charge battery before initial use and before each operation of floor lift After assembly check to ensure that Lifting actuator moving up and down with the buttons on the hand control and control box Emergency lowering mechanical and electrical functions works properly Rear wheel brak
26. rol Box Up amp Down Actuator Leg Spreading Actuator Rear Caster w Brake 280400 280401 FGA 700 Owner s Manual Rev 10 18 12 Page 3 Component List The following components are included with your new FGA 700 Bariatric floor lift system e FGA 700 Bariatric floor lift e Hand Control e Floor Lift Integrated Charger e Charger Cord e Owner s Manual e Warranty Card e Multi Function Wrench e 5mm Hex Allen Key Short Arm e 4mm Hex Allen Key Short Arm SLINGS If a sling has been supplied with floor lift then pl refer to the instructions included with the sling ACCESSORIES If additional accessories such as a weigh scale have been supplied with the floor lift then pl refer to the instructions included with those items IMPORTANT Before initial use the floor lift unit must be charged for 4 to 5 hours Refer to section titled Charging Instructions The Hand control must also be connected to the floor lift If it is not connected then pl refer to the section titled Assembly Instructions 280400 280401 FGA 700 Owner s Manual Rev 10 18 12 Page 4 Technical Specifications FGA 700 A Dimensions and Weight FGA 700 lift Specification FGA 700 Maximum weight capacity 700 Ibs 318 kg Maximum lifting height See lifting height setting see Assembly page 8 76 4 inches 194 cm Minimum lifting height See lifting height setting see Assembly p
27. rviced by Prism Medical or its authorized service agents in accordance with the manufacturer s recommendations or if any unauthorized person carries out works on the equipment 4 The liability of Prism Medical under the terms of this guarantee shall be limited to the replacement of defective part s to the sales distributor dealer agent person or entity which purchased the equipment from Prism Medical In no event shall Prism Medical incur liability for any consequential or unforeseeable losses If you have any questions about the manufacture or operation of this equipment please contact Waverley Glen or your local authorized dealer PRISM MEDICAL SS 45 Progress Parkway Maryland Heights MO 63043 USA Phone 314 692 9135 Fax 314 692 7858 Toll Free 1 866 891 6502 www prismmedicalltd com This document conforms to EN ISO 10535 requirements T Trade mark of Corven Health Care Inc Used under licence E amp O E 280400 280401 FGA 700 Owner s Manual Rev 10 18 12 Page 30
28. s a risk of getting your fingers caught 280400 280401 FGA 700 Owner s Manual Rev 10 18 12 Page 14 Operation Leg Adjustment The legs of FGA 700 lift are electrically adjustable for opening and closing base width The legs can be opened to enable access around arm chairs or wheel chairs For transferring through narrow doorways and passages the lift legs should be in closed position Leg adjustment is achieved by pressing appropriate buttons on the hand control The legs motion will be stopped whenever the hand control button 1s released Raising and Lowering the Boom The up and down movement of boom on FGA 700 lift is achieved by a powerful electric actuator which 1s controlled by hand control The hand control has two button with directional arrows UP and DOWN The actuator stops automatically at the limit of travel in both directions Casters and Braking The FGA 700 lift has two rear casters with brake The rear casters can be braked for rotation lateral move ment and parking To apply the brake press the brake pedal down with your foot To release the brake press the raised pedal towards the wheel During the lifting the rear wheels should remain unlocked so that the lift will move to the patient s centre of gravity The wheels should however be locked if there is a risk of lift moving to the patient For example when lifting the patient from the floor A Warning Locked wheels during lifting will
29. t by a qualified lift technician after use Contact your local authorized Prism Medical Service Provider Emergency Stop Push the Emergency Stop button to cut all power on the Floor Lift To resume power release the emergen cy stop button by turning in the direction as indicated by arrows on the Emergency Stop button Electrical emergency lowering raising The lift boom is lowered or raised by pressing the UP and DOWN arrow button on the control box Electrical emergency leg adjustment The lift legs are opened or closed by pressing the leg opening and leg closing arrow button on the control box Z BATTERY S JUMBO CARE Emergency Stop Button Emergency Lowering Button Emergency Leg Closing Button Emergency Raising Button Emergency Leg Opening Button sacl Mechanical emergency lowering In case of power failure it is possible to mechanically lower a patient placed in FGA 700 lift Turn the manual lowering handle in clockwise direction to lower the boom until the boom reaches to safe position 280400 280401 FGA 700 Owner s Manual Rev 10 18 12 Page 18 Control Box Usage information The control box of FGA 700 lift having LCD display to have some basic usage information on the display Following information will be visible on the LCD display of control box SERVICE MAX i kg Ibs When it is time for service the service symbol will appear on the display will light up and give notice t
Download Pdf Manuals
Related Search