TEREX AL5HT Light Tower with Hydraulic Mast
Contents
1. 1800 rpm o Prime 13 5 hp 1800 rpm o 3cylinder o 1 123 L displacement Fuel consumption prime 0 5 gph 60 Hz engine generator Industrial engine exhaust system Rubber vibration dampers isolate engine generator from frame Cooling system capable of operating at 120 F ambient Full flow oil filter spin on type Fuel filter with replaceable element Dry type cartridge air filter Polyethylene fuel tank with large diameter opening o 30 gal capacity o 60 hr run capacity o 3 fill port ENGINE CONTROLS e Galvanized control panel located inside cabinet e Four position keyed switch glow plugs preheat off run start e Hour meter e Automatic low oil high temperature shutdown system GENERATOR Marathon Electric o Brushless 8 kW standby output 120 240 VAC 20 30A 6 capacitor voltage regulation ELECTRICAL SYSTEM AND CONTROLS Individual floodlight circuits with 15A breakers Hydraulic tower controls located inside cabinet 30A start limit breaker assures no load condition exists before starting Standard individually breakered convenience outlets o 1 120 VAC 20 Amp GFCI duplex outlets Nema 5 20R type o 1 240 VAC 30 Amp twistlock outlets Nema L6 30R type 700 CCA wet cell battery FLOODLIGHTS Four light fixtures 1000 watts each metal halide Quick adjust cast aluminum square housing with horizontally mounted bulbs Tempered glass lens Silicone gaskets for moisture and dust protection Individual floodlig2. 52m 8 9 0 TEREX SUSTAINABLE LIGHTING LLC Distributed by Light Towers USA A Turnkey Electric LLC Company 1 800 975 5977 www lighttowers net www ledlighttower net America s Largest Mobile Light Center Effective Date January 2009 Product specifications and prices are subject to change without notice or obligation The photographs and or drawings in this document are for illustrative purposes only Refer to the appropriate Operator s Manual for instructions on the proper use of this equipment Failure to follow the appropriate Operator s Manual when using our equipment or to otherwise act irresponsibly may result in serious injury or death The only warranty applicable to our equipment is the standard written warranty applicable to the particular product and sale and we make no other warranty express or implied Products and services listed may be trademarks service marks or trade names of Terex Corporation Genie Industries Inc and or their subsidiaries in the U S A and many other countries and all rights are reserved Terex is a Registered Trademark of Terex Corporation in the U S A and many other countries Genie is a Registered Trademark of Genie Industries Inc in the U S A and many other countries Genie is a Terex Company 2009 Terex Corporation AL8000 HT 5K 0109D Part 127107 TEREX AL SHT ENGINE Kubotae D1105 liquid cooled diesel engine o Standby 15 4 hp
3. 2s TEREX reg Bg Articulated hydraulic mast provides maximum flexibility and control for quick effortless light positioning 28 foot vertical height 20 foot horizontal outreach and 359 degree powered rotation 8 foot 2 inch stowed length provides for ease of transport for towing or transportation on a trailer or container Optional environmental spill containment to meet local regulations or for use in sensitive areas Light fixtures plug into weatherproof receptacle box at top of tower with UL and CSA approved connectors AL8000 HT The unique articulated hydraulic mast is ideal for the mining industry as well as use on railroad municipal and large construction sites Models shown with optional 8 light configuration Standard configuration features 4 lights Individual plug in ballasts installed in galvanized steel boxes Can be replaced without disconnecting wiring terminals Control panel is inside away from the elements Houses main and branch circuit breakers and hourmeter Galvanized outriggers with pre set position stops ensure quick and proper spacing Single point lifting eye and forklift pockets provide for easy loading and unloading Optional Australian mining configuration designed specifically to meet Australian regulations and mining application requirements Light Tower AL8000 HT Specifications Standard Unit Optional Equipment Lamps Generator Mast Rotation Light Bar Tilt In
4. dividual Light Pivot Engine Fuel Capacity Wheel Size Axle Rating Tongue weight travel position Total weight no fuel Metal Halide 4 x 1 000 W Brushless 60 Hz 8 0 kW 359 powered rotation 180 180 front to back 360 side to side Kubota Diesel 13 6 hp 30 gal 114 L 15 in 38 cm 4 200 Ibs 1 905 kg 375 Ibs 170 kg 2 605 Ibs 1 185 kg Metal Halide 8 x 1 000 W lamps Brushless 60 Hz 20 kW generator Brushless 60 Hz 12 kW generator Isuzu Diesel 34 5 hp engine 60 gal 228 L fuel capacity Environmental spill containment a a a a la rs i f Tough coat paint Combination ring ball hitch Tail light package Block heater Fuel line heater Roda Deaco air shutdown system lt Al 3 a 25 20 15 10 5 5 10 15 20 7 62 m 6 10 m 4 57 m 3 05 m 1 52m 0 1 52 m 3 05 m 4 57 m 6 10 m 762m 30 0 14 m 25 7 62 m 28 9 8 76 m 20 6 10 m F 15 4 57 m i aH 10 3 05 m My z i 1 52 m 0 25 20 15 10 5 5 10 15 20 25 7 62 m 6 10 m 4 57 m 3 05 m 1 52 m 0 1 52m 3 05 m 4 57 m 6 10 m 7 62 m 30 014m 25 7 62 m 20 6 10 m 8 2 2 49 m 15 F Da un Cay 10 er oe em gt F 6 11 1 2 ALBOOO n seat 5 D o 1
5. ht On Off switches WIRING MAST All wiring is sized to the amperage draw required AC amp DC wiring diagrams are provided in service manual 28 articulated hydraulic mast with 20 of outreach 359 of powered rotation Mast cable track to manage electrical cables Equipped with single lifting eye and fork pockets ENCLOSURE Steel enclosure 14 gauge o UV amp fade resistant high temperature cured white polyester powder paint Dome light with switch 12V English English French or symbol operating safety decals License plate holder with light Manual holder with operating manual TRAILER Mast support 3 x 2 x 3 16 tubular steel A frame Removable flip up tongue 46 75 long Tubular steel chassis 2 5 x 3 16 Four 3000 Ib adjustable leveling jacks 4 point stance All jacks transport and lock in horizontal position for storage Side outriggers 8 2 5 span Safety chains with s hooks 2 ball hitch Steel fenders 16 gauge DOT approved tail side brake and directional lights o Recessed rear and side lights 4200 lb leaf spring axle P205 75L15 tires 73 axle span WEIGHTS amp DIMENSIONS Dry weight 2 650 Ibs 1 182 kg Mast stowed 98 x 83 5 x 81 in 2 49 x 2 12 x 2 07 m WARRANTY l year parts and service Engine and generator covered under OEM warranty consult factory for details CERTIFICATIONS CSA certified Options CHASSIS OPTIONS 30 gal fuel tank with
6. spill containment 60 gal fuel tank 60 gal fuel tank with spill containment Highway safety chains w snap hook Hitch 2 1 2 in Ring Hitch 2 5 16 in Ball Hitch Combination Ring and Ball Spare tire and wheel Tough coat paint surface cabinet and trailer front Trailer brakes electric Trailer brakes Hydraulic surge must specify either ring or ball hitch ENGINE OPTIONS 12 kW 60 Hz generator with 16 3 hp Kubota diesel 20 kW 60 Hz generator include external receptacle package and 2 ea 20A 12V GFI amp 3 ea 30A 240V T L Auto Start Mechanical automatic air shutdown Fuel water separator filter Fuel water separator with fuel line heater TOWER OPTIONS 6 metal halide lights 8 metal halide lights only available with 12kW or 20 kW engine option Tower Lock kit COLD WEATHER OPTIONS 1000 CCA battery Battery heater blanket Engine block heater Low temperature coolant mixture 40 F
Download Pdf Manuals
Related Search