Glass mounted GSM combined aerial_8685982_en
Contents
1. Page 5 of 13 Installation instructions accessories Glass mounted GSM combined Volvo Car Corporation G teborg Sweden R3903908 A8800136 R8504113 VolvoCar Corporation 2002 Printed in Sweden Preparations e Remove the right hand side panel from the centre console Pull off the panel starting at the front edge Then pull backwards until all the clips release Preparations Applies to cars with power front seats e Position the right hand front seat so that the panels over the front and right rear seat mountings and the small panel at the lower edge of the right hand B post are not obstructed They will be removed later after disconnecting the battery negative lead Applies to all models e Turn the ignition key to position 0 e Disconnect the battery negative lead Note Wait at least five minutes before disassembling the connectors or removing other electrical equipment Preparations Applies to cars with automatic gearboxes e Turn the ignition key to position Il Applies to all models e Move the gear selector lever to its rearmost position e Carefully pry off the gear selector lever panel at the lower edge using a weatherstrip tool Pull the panel backwards to access the screws for the dashboard environment panel 8685982 Page 6 of 13 Installation instructions accessories Glass mounted GSM combined Volvo Car Corporation G teborg Sweden Preparations e Remove the screws holdi2. This is to prevent damage SRS warning lamp If the SRS warning lamp lights after repairs have been carried out take the car to an authorised Volvo workshop SRS collision sensor control module S60 V70 00 S80 XC90 The collision sensor control module is located on the tunnel under the 8685982 Page 4 of 13 Installation instructions accessories Glass mounted GSM combined Volvo Car Corporation G teborg Sweden VolvoCar Corporation 2002 Printed in Sweden centre console in front of the parking brake CAUTION The air bag inflation areas must not be obstructed Never place any objects such as upholstery or accessories within these areas The panels must be able to open in the correct manner at the right time otherwise there is an increased risk of personal injury in the event of a collision CAUTION The ignition must be in position 0 and the key removed from the ignition switch if any connector in the SRS system is to be unplugged Then wait at least one minute and disconnect the battery negative lead before unplugging any of the connectors When work is completed the ignition key must be turned to position Il before reconnecting the battery negative lead Glass mounted GSM combined aerial Caution The aerial must be removed from the external base module if using a carwash Note When installing the aerial the window must remain at a temperature of at least 10 C 8685982
3. along the rear door sill Continue inside the floor carpet to the front door opening e Clamp the cable harness in the hole in the front member for the seat mounting and in the rear hole in the horizontal panel at the right hand side of the seat Use the tie straps 2 from the kit Cable routing and connecting the combined aerial e Pull up the left and right sides of the carpet at the right hand front seat slightly Insert a cable 1 underneath the carpet at the front edge of the air ducts on the right hand side of the centre console Pull out the cable at the right hand door sill as illustrated e Tape the aerial cable 2 at the pre routed cable Route the cable to the right hand side of the centre console e Route the aerial cable up at the air ducts and pull along in the centre console R3903912 e Connect the aerial cable to the cable from the carphone holder Cable routing and connecting the combined aerial Reinstall e the floor carpets e the bracket with dashboard environment panel and control module in the centre console e the gear selector lever panel e the sill trim panels in the doors e the panel above the joints for the sill trim panels e the cover and panels for the seats VolvoCar Corporation 2002 Printed in Sweden 8685982 Page 12 of 13 Installation instructions accessories Glass mounted GSM combined Volvo Car Corporation G teborg Sweden e the right hand side floor hatch e Reinstall
4. the D post panel and the headlining and any relevant connectors e Reinstall the folding panel Cable routing and connecting the combined aerial e Turn the ignition key to position II e Reconnect the battery negative lead A8800137 e Reinstall the storage boxes and floor hatches e Reinstall the right hand side panel on the centre console VolvoCar Corporation 2002 Printed in Sweden 8685982 Page 13 of 13
5. the panel forward Preparations e Fold the backrest on the right hand seat in the second row forward as far as possible Slide the front seat forward as far as possible On cars with two rows of seats the second row is secured e Remove the cover 1 for the right rear seat mounting by prying off the rear edge Preparations Illustration A e Remove the sill trim panel for the right hand rear door Pull the rear edge until the clips release Continue forwards until the remaining clips have released Applies to cars with two rows of seats e Oncars with two rows of seats the seat cannot be slid forwards To remove the sill trim panel Start by folding the backrest forward when pulling the rear edge of sill trim panel loose Then reposition the backrest to raise the seat cushion and provide more room for removing the sill trim panel It is securely positioned Do not damage the panel and surrounding components R8504173 VolvoCar Corporation 2002 Printed in Sweden 8685982 Page 8 of 13 Installation instructions accessories Glass mounted GSM combined Volvo Car Corporation G teborg Sweden Illustration B e Unhook from the B post panel and place in the second third row of seats Preparations Applies to cars with three rows of seats and integrated carrier bag holder on the under side of the centre floor hatch e Fold the rear centre floor hatch up e Detach the two straps from the panel underneath Lift up th
6. Installation instructions accessories Glass mounted GSM combined Volvo Car Corporation G teborg Sweden XC90 2003 XC90 2004 XC90 2005 XC90 2006 XC90 2007 XC90 2008 XC90 2009 XC90 2010 Replaces issue 2001 12 ar Corporation 2002 Printed in Sweden Page 1 of 13 Installation instructions accessories Glass mounted GSM combined as Volvo Car Corporation G teborg Sweden Required tools VolvoCar Corporation 2002 Printed in Sweden 8685982 Page 2 of 13 Installation instructions accessories Glass mounted GSM combined Volvo Car Corporation G teborg Sweden Any comments on this publication Please contact your nearest dealer Thank you Publication no MA 8685982 Issue 2002 06 VolvoCar Corporation 2002 Printed in Sweden 8685982 Page 3 of 13 Installation instructions accessories Glass mounted GSM combined Volvo Car Corporation G teborg Sweden INTRODUCTION e NOTE Read through the whole installation instruction before starting the work e The front page gives the date of this edition and the edition it replaces e The second page shows the tools needed for the installation and the contents of the installation kit e The illustrations display the procedure in order of operation The order of operation is repeated in the text section e Cut out the text page in order to follow the illustrations and text at the same time VolvoCar Corporation 2002 Printed in Swede
7. e panel at the rear edge Fold the floor hatch back towards the panel and lift out the floor hatch and the panel Applies to cars with three rows of seats without integrated carrier bag holders e Lift up the centre rear floor hatch at the rear edge and lift it out Applies to cars with two rows of seats e Remove the two centre floor hatches First lift up slightly and then pull them loose from the mountings at the front edge If the rear centre floor hatch has a carrier bag holder on the lower side the floor hatch is secured by a strap on each of the shorter sides of the storage box These must be removed e Remove the two storage boxes from underneath Preparations Applies to all models e Remove the right hand side floor hatch 1 8504158 VolvoCar Corporation 2002 Printed in Sweden 8685982 Page 9 of 13 Installation instructions accessories Glass mounted GSM combined Volvo Car Corporation G teborg Sweden Preparations e Remove the folding side panel from the right hand side in the cargo compartment Preparations e Remove the cover and the screws for the rear headlining e Carefully pry off the panel at the rear edge using a weatherstrip tool e Pull the rear edge of the panel downwards until all clips in the inside have released e Applies to cars with three rows of seats Disconnect the connector for the rear roof lighting Pull the panel backward Preparations e Carefully detach the D post panel
8. n Cars equipped with SRS SIPS Airbag Warning Extra care must be taken when working on cars equipped with SRS SIPS air bags This is important to prevent 1 Personal injury 2 Damage to or malfunction of the SRS SIPS system Work on the SRS SIPS systems or related components must always be carried out by an authorised Volvo workshop Is the car equipped with SRS supplemental restraint system Cars equipped with a driver s airbag have the letters SRS imprinted on the centre panel of the steering wheel Cars equipped with driver s and passenger airbags are marked with SRS on both the steering wheel centre panel and also on the dashboard close to the airbag If the car is equipped with SIPS side impact protection system a SIPS decal is marked on both the front seats Cars equipped with inflatable curtains have the marking SRS on one of the panels along the posts on the inside of the car Cars equipped with SRS supplemental restraint system also have an SRS decal on the front windscreen Do not damage the SRS wiring Do not trap chafe pierce or damage the SRS wiring SRS wiring has orange casing and or is plaited Steering and front suspension The contact reel in the SRS system can easily be damaged when working on the steering wheel steering shaft or steering gear Refer to the SRS supplemental restraint system Service Manual or service instructions in VIDA for information on carrying out such work
9. ng the bracket for the dashboard environment panel and the control module e Pull out the bracket at the lower edge Pull downwards from the top edge of the centre console e Disconnect the connectors from the dashboard environment panel control module If applicable disconnect the CD player and or Mini disc player connectors Preparations e Remove the cover 1 on the left front mounting on the right hand front seat by prying off the front edge e Pry off the front edge of the right panel 2 Remove the panel Preparations e Remove the panel on the right rear mounting on the right hand front seat Pry it up slightly at the rear edge and then pull it back upwards R8504241 Preparations e Carefully pry off and remove the panel above the joint between the right hand door sills at the lower edge using a weatherstrip tool R8504169 VolvoCar Corporation 2002 Printed in Sweden 8685982 Page 7 of 13 Installation instructions accessories Glass mounted GSM combined Volvo Car Corporation G teborg Sweden Preparations e Detach the sill trim panel for the right hand front door Pull off the panel starting at the front edge until the clip releases Continue backwards until the remaining clips have released e Unhook the sill trim panel from the B post panel Preparations e Remove the panel in the right hand front seat mounting on the right hand seat in the second row Push up the catch 1 on the top Pull
10. s on the right and left hand sides starting at the top edge Continue downwards until all three clips have released e Remove the panel by pulling upwards slightly and unhooking from the side panel If applicable disconnect the connector for the D post loudspeaker A R8504086 Installing the combined aerial e Clean the surface where the inner base module is to be positioned using the cleaning cloth from the kit e Wipe dry e Remove the backing from the inner base module e Position the inner base module horizontally on the side window in line with the rear end of the headlining The upper rear corner of the inner base module must R3903913 be positioned edge to edge with the tinted area of the side widow as illustrated VolvoCar Corporation 2002 Printed in Sweden 8685982 Page 10 of 13 Installation instructions accessories Glass mounted GSM combined Volvo Car Corporation G teborg Sweden Installing the combined aerial e Install the aerial on the external base module Installing the combined aerial e Clean the surface where the external base module is to be positioned using the cleaning cloth from the kit e Wipe dry e Remove the backing from the external base module Press the external base module into place on the side window opposite the inner base module 7 i e Press hard on points 1 2 3 4 and 5 in order for 3 4 seconds R3903914 e Ensure that the tape is sealed around the external base mod
11. ule For optimum adhesion heat the glass Use a hairdryer or similar Cable routing and connecting the combined aerial e Route the aerial cable down along the existing wiring at the rear edge of the side window down to the rear edge of the wheel arch e Clamp the aerial cable at the existing wiring using the tie straps from the kit R3903916 Cable routing and connecting the combined aerial Applies to cars with two rows of seats e Route the aerial cable on the right hand side of the cargo floor support inside the front edge of the floor carpet in the right hand rear door opening Continue along the right hand side of the car VolvoCar Corporation 2002 Printed in Sweden 8685982 Page 11 of 13 Installation instructions accessories Glass mounted GSM combined Volvo Car Corporation G teborg Sweden Cable routing and connecting the combined aerial Applies to cars with three rows of seats e Inserta cable 1 at the rear edge of the right hand side panel and along the inside of the panel above the mountings for the load securing eyelets and to the front edge of the side panel e Tape the end to the aerial cable 2 at the cable Pull the cable with the aerial cable from the front edge of the side panel Cable routing and connecting the combined aerial e Route the pre routed aerial cable 1 on the reverse of the air duct at the front edge of the wheel arch to the left hand side of the seat belt lower mounting and
Download Pdf Manuals
Related Search