Oxygen Concentrator Invacare Platinum
Contents
1. 5 09 8 AH3A3 Cosues SLINm 098 H2949 6101291 SYNOH 0 X1SD2HI SYNOH OTEP AH3A3 UILU H294 5 3 4 3eulqeD uea UO sano pesdej3 BDIAJeS JO IA 2 no NOILOAdSNI HOV3 HOJVH IN3ONOO N39AXO WANILW 1d 3HVOVANI QHOO3H 3ONVN3 LNIVIA 3ALLN3A3Hd FIGURE 6 2 Preventive Maintenance Record 25 Platinum Series Part No 1118353 SECTION 7 TROUBLESHOOTING GUIDE SECTION 7 TROUBLESHOOTING GUIDE SYMPTOM Alarm SHORT BEEPS LONG PAUSE Concentrator NOT operating power switch ON PROBABLE CAUSE Main Power Loss Power cord NOT plugged in SOLUTION Insert plug into outlet 2 No power at outlet 2 Inspect house circuit break ers or fuses If problem recurs use a different outlet 3 Tripped circuit breaker 3 Call Service Provider CONTINUOUS Concentrator NOT operating Power Switch ON System Failure Unit overheating due to blocked air intake la Remove and clean cabinet filters Ib Move oxygen concentrator at least three inches away from walls draperies or furniture 2 Insufficient power at outlet 2 DO NOT use extension cords Move to another elec Beeeeeeeep trical outl2. GREEN FIGURE 5 7 Front Panel Indicators Units with SensO2 Initial Startup of the Concentrator NOTE Concentrator may be used during the initial start warm up time approximately 30 min while waiting for the O purity to reach maximum LABEL O PURITY INDICATOR LIGHTS SYMBOL LED O SYSTEM OKAY GREEN Indicator Light over 85 2 Between 73 3 YELLOW Indicator light A YELLOW Solid to 85 1276 B YELLOW Flashing Sensor Failure Call a qualified technician Have a back up supply of oxygen ready SYSTEM FAILURE RED Indicator Light Below 73 3 Continuous Audible Alarm Sieve GARD Compressor Shut down Call a qualified technician Switch to a back up supply of oxy gen immediately Part No 1118353 21 Platinum Series SECTION 5 OPERATING INSTRUCTIONS Front Panel Indicators Units without SensO NOTE For this procedure refer to FIGURE 5 8 Auto Shut Down Use Backup a Normal 4 GREEN FIGURE 5 8 Front Panel Indicators Units without SensO2 Initial Startup of the Concentrator NOTE Concentrator may be used during the initial start warm up time approximately 30 min O purity will build to a maximum during this period LABEL STATUS INDICATOR LIGHTS SYMBOL LED SYSTEM OKAY GREEN Indicator Light SYSTEM FAILURE RED Indicator light O Continuous Audible Alarm Sieve GARD Compresso
3. C 35 C at 20 6076 relative Temperature humidity Exhaust Platinum 5 and XL Less than Ambient 35 F 1990 Platinum 0 Less than Ambient 45 F 25 C Oxygen Output Temperature Platinum 5 and XL Less than Ambient 4 F 2 C Platinum 10 Less than Ambient 8 F 4 4 C Cabinet Impact Resistant flame retardant plastic cab inet that conforms to UL 4 0 Regulatory Listing Double Insulated Product ETL certified complying with UL 1097 ETL certified to CSA 22 2 No 68 Electrical No extension cords Placement No closer than three inches from any wall furniture draperies or similar surfaces Tubing 7 ft cannula with a maximum 50 ft of Crush Proof Tubing DO NOT pinch Platinum 10 Recommended use up to 50 ft high flow tubing with high flow cannula at all flow rates Relative Humidity 20 to 60 Time of Operation Up to 24 hours per day Recommended Storage and 20 F to 150 F 29 C to 65 C at 15 95 Shipping Temperature relative humidity Part No 1118353 15 Platinum Series SECTION 5 OPERATING INSTRUCTIONS SECTION 5 OPERATING INSTRUCTIONS Introduction Your oxygen concentrator is intended for individual use indoors It is an electronically operated device that separates oxygen from room air It provides high concentration of oxygen directly to you through a nasal cannula Clinical studies have documented that oxygen concentrators are therapeutically equivalent to o
4. RISK OF ELECTRIC SHOCK Do not remove cover Refer servicing to qualified service personnel AN Flow rates below 0 5 L min will trigger Low Flow Alarm rapid audible alarm Set flowmeter at 3 L min or less when filling HomeFill II cylinders CAUTION Federal USA law restricts this device to sale by or on the order of a physician pm 1108755 Serial Number Label is located on the resonator intake assembly Specification Label is located on the back near the bottom Platinum Series SECTION GENERAL GUIDELINES SECTION GENERAL GUIDELINES In order to ensure the safe installation assembly and operation of the Platinum concentrator these instructions MUST be followed A WARNING This section contains important information for the safe operation and use of this product To Reduce the Risk of Burns Electrocution Fire or Injury to Persons A DANGER Risk of electric shock DO NOT disassemble Refer servicing to qualified service personnel No user serviceable parts Avoid using while bathing If continuous usage is required by the physician s prescription the concentrator MUST be located in another room at least 7 ft from the bath DO NOT come in contact with the concentrator while wet DO NOT place or store product where it can drop into water or other liquid DO NOT reach for product that has fallen into water Unplug IMMEDIATELY If the concentrator has a damaged
5. SECTION 6 MAINTENANCE 2 Clean the cabinet filters with a vacuum cleaner or wash in warm soapy water and rinse thoroughly 3 Dry the filters thoroughly before reinstallation Cabinet Filter S located on both sides of concentrator FIGURE 6 1 Cleaning the Cabinet Filter Cleaning the Cabinet A WARNING UNPLUG the concentrator when cleaning To avoid electrical shock DO NOT remove cabinet Clean the cabinet with a mild household cleaner and non abrasive cloth or sponge Cleaning the Humidifier NOTE To clean the oxygen humidifier follow the instructions provided by the manufacturer If none are provided follow these STEPS 1 Clean the humidifier every day 2 Wash it in soapy water and rinse it with a solution of ten parts water and one part vinegar d Rinse thoroughly with hot water and refill with distilled water to the level shown on the humidifier Platinum Series 24 Part No 1118353 SECTION 6 MAINTENANCE SERIAL NO IRC MODEL NO ENUE Jo uonoes e ueuexurej J9J9 JosseJduoD jo pug doy pinqay JN asneux3 e ejdey 8 3eeH ueelD aauin au sv UlJe v 5507 H2949 5 osues uone nue uo 5 le3llJ 3elul JosseJduuoD H294 9U Vd3H PPRNO peu 5 3eulqeD o e dey ueo 5
6. drap eries and furniture 5 Insufficient power at 5 DO NOT use extension outlet cords Move to another elec trical outlet or circuit 6 Internal repairs 6 Call Service Provider required GREEN LIGHT Internal repairs Call Service Provider with YELLOW required Part No 1118353 27 Platinum Series NOTES NOTES Platinum Series 28 Part No 1118353 NOTES NOTES Part No 1118353 29 Platinum Series LIMITED WARRANTY LIMITED WARRANTY NOTE THE WARRANTY BELOW HAS BEEN DRAFTED TO COMPLY WITH FEDERAL LAW APPLICABLE TO PRODUCTS MANUFACTURED AFTER JULY 4 1975 This warranty is extended only to the original purchaser who purchases this product when new and unused from Invacare Corporation or a dealer This warranty is not extended to any other person or entity and it is not transferable or assignable to any subsequent purchaser or owner Coverage under this warranty will end upon any such subsequent sale or other transfer of title to any other person This warranty gives you specific legal rights and you may also have other legal rights which may vary from state to state Invacare Corporation warrants its Platinum XL Oxygen Concentrators when purchased new and unused to be free from defects in materials and workmanship for a period of five years from date of purchase from Invacare or a dealer with a copy of the seller s invoice required for coverage under this warranty Invacare Corporation warrants its Pl
7. sss 21 Front Panel Indicators Units without SensO 22 Initial Startup of the Concentrator sss 22 Part No 1118353 3 Platinum Series REGISTER YOUR PRODUCT TABLE OF CONTENTS SECTION 6 MAINTENANCE 00000000000000000000000000 23 Routine 23 Cleaning the Cabinet Filter sees 23 Cleaning the Cabinet pe 24 Cleaning the Humidifier 0 24 SECTION 7 TROUBLESHOOTING GUIDE 26 LIMITED WARRANTY 000000000000000000000000000000000000 30 REGISTER YOUR PRODUCT The benefits of registering include Safeguarding your investment 2 Ensuring long term maintenance and servicing of your product 3 Receiving updates with product information maintenance tips and industry news Register ONLINE at warranty invacare com Please have your model number and purchase date available to complete your registration Any registration information you submit will only be used by Invacare Corporation and protected as required by applicable laws and regulations Platinum Series 4 Part No 1118353 SPECIAL NOTES SPECIAL NOTES Signal words are used in this manual and apply to hazards or unsafe practices which could result in personal injury or property damage Refer to the following table for definitions of the signal words SIGNAL WORD MEANING Danger indicates an imminently hazardous situation which if not avoided will result in
8. kPa 3 45 kPa Platinum 10 9 psi 0 5 psi 62 0 kPa 3 45 kPa NOTE Stated concentration levels achieved after initial warm up period approximately 30 minutes Part No 1118353 13 Platinum Series SECTION 4 TYPICAL PRODUCT PARAMETERS Flow Range Platinum 5 and XL 0 5 to 5 L min For flowrates less than L min we recommend the use of the Invacare Pediatric Flowmeter IRCPFI6 Accessory Platinum 10 2 to 10 L min Low Flow Alarm Platinum 5 0 L min to 0 5 L min Platinum 10 0 L min to L min Rapid Audible Alarm Beeping No Accessories Connected Average Power Platinum 5 and XL 400W Consumption Platinum 10 585W Pressure Relief Mechanism 35 psi 3 5 psi 241 kPa 24 1 kPa Operational at Change in maximum recom 0 7 L min mended flow when back pres sure of 7kPa is applied Cabinet 2 Outlet HEPA and Compressor Inlet Safety System Current overload or line surge shutdown High temperature compressor shutdown High Pressure Alarm w compressor shut down Low Pressure Alarm w compressor shutdown Battery Free Power Loss Alarm SensO Oxygen System SensO Model Low Flow Alarm Weight Platinum 5 and XL 52 Ibs 2 Ibs 23 6 kg kg EE 2 Shipping Weight Platinum 5 and XL 58 Ibs 2 Ibs 26 3 kg kg Platinum 10 60 Ibs 2 Ibs 27 2 kg kg Platinum Series 14 Part No 1118353 SECTION 4 TYPICAL PRODUCT PARAMETERS Operating Ambient 50 F 95 F 10
9. EPAIR OR REPLACEMENT OF THE DEFECTIVE PRODUCT PURSUANT TO THE TERMS CONTAINED HEREIN THE APPLICATION OF ANY IMPLIED WARRANTY WHATSOEVER SHALL NOT EXTEND BEYOND THE DURATION OF THE EXPRESS WARRANTY PROVIDED HEREIN INVACARE SHALL NOT BE LIABLE FOR ANY CONSEQUENTIAL OR INCIDENTAL DAMAGES WHATSOEVER SOME STATES DO NOT ALLOW THE EXCLUSION OR LIMITATION OF INCIDENTAL OR CONSEQUENTIAL DAMAGE OR LIMITATION OF HOW LONG AN IMPLIED WARRANTY LASTS SO THE ABOVE EXCLUSION AND LIMITATION MAY NOT APPLY TO YOU THIS WARRANTY SHALL BE EXTENDED TO COMPLY WITH STATE PROVINCIAL LAWS AND REQUIREMENTS Part No 1118353 3l Platinum Series This product may be manufactured under one or more of the following patents US 5 906 672 and US 5 917 135 Other patents pending Invacare Corporation www invacare com USA Trademarks are identified by and All CC One Invacare Way trademarks are owned by or licensed to Elyria Ohio USA Invacare Corporation unless otherwise 44036 2125 noted Yes you can 800 333 6900 2008 Invacare Corporation Technical Services 800 832 4707 Part No 1118353 Rev 2 08
10. Operator s Manual Platinum Series XL 5 10 Oxygen Concentrators Standard with SensO HomeFill Invacare 5 with SensO Invacare 5 Model IRC5LXO2 Model IRC5LX Invacare 10 with SensO Invacare 10 Model IRCIOLXO2 Model IRCIOLX Dealer This manual MUST be given to the end user User Before using this product read this manual and save for future reference For more information regarding Invacare products parts and services please visit www invacare com Yes you can WARNING A WARNING DO NOT use this product or any available optional equipment without first completely reading and understanding these instructions and any additional instructional material such as owner s manuals service manuals or instruction sheets supplied with this product or optional equipment If you are unable to understand the warnings cautions or instructions contact a healthcare professional dealer or technical personnel before attempting to use this equipment otherwise injury or damage may occur A ACCESSORIES WARNING Invacare products are specifically designed and manufactured for use in conjunction with Invacare accessories Accessories designed by other manufacturers have not been tested by Invacare and are not recommended for use with Invacare products ACCESSORIES There are many different types of humidifiers oxygen tubing cannulas and masks that can be used with this device You should contact you
11. atinum 10 Oxygen Concentrators when purchased new and unused to be free from defects in materials and workmanship for a period of three years from date of purchase from Invacare or a dealer with a copy of the seller s invoice required for coverage under this warranty DO NOT OPEN OR ATTEMPT TO SERVICE THE 4 WAY VALVE BODY This will void any and all warranty applicable to the valve body If within such warranty periods any such product shall be proven to Invacare Corporation s satisfaction to be defective such product shall be repaired or replaced at Invacare Corporation s option This warranty only applies to the labor for repairs performed by the Invacare Service Department or Invacare Authorized Service Centers It does not apply to the labor performed by the purchaser or user This warranty does not include normal wear and tear or shipping charges Invacare Corporation s sole obligation and your exclusive remedy under this warranty shall be limited to such repair or replacement Routine maintenance items such as filters are excluded from this warranty Platinum Series 30 Part No 1118353 LIMITED WARRANTY For warranty service please contact Invacare Corporation s Service Department at the toll free number on the back cover Upon receiving notice of an alleged defect in a product Invacare Corporation will issue a serialized return authorization It shall then be the responsibility of the purchaser to return the entire unit or remove at
12. cord or plug if it is not working properly if it has been dropped or damaged or dropped into water call qualified technician for examination and repair A spontaneous and violent ignition may occur if oil grease or greasy substances come in contact with oxygen under pressure These substances MUST be kept away from the oxygen concentrator tubing and connections and all other oxygen equipment DO NOT use any lubricants unless recommended by Invacare Avoid creation of any spark near medical oxygen equipment This includes sparks from static electricity created by any type of friction Platinum Series 8 Part No 1118353 SECTION GENERAL GUIDELINES Operating Information For optimum performance Invacare recommends that each concentrator be on and running for a minimum of 30 minutes ata time Shorter periods of operation may reduce maximum product life Keep the oxygen tubing cord and unit out from under such items as blankets bed coverings chair cushions clothing and away from heated or hot surfaces including space heaters stoves and similar electrical appliances DO NOT move or relocate concentrator by pulling on the power cord NEVER drop or insert any object or liquid into any opening Invacare recommends that Crush Proof oxygen tubing be used with this product and not exceed 15 2 m 50 ft in length There are no user serviceable parts This does not include normal maintenance items See maintenance section for
13. death or serious DANGER injury Warning indicates a potentially hazardous situation which if not avoided could result in death or WARNING serious injury Caution indicates a potentially hazardous situation which if not avoided may result in property CAUTION damage or minor injury or both NOTICE The information contained in this document is subject to change without notice A DANGER DO NOT SMOKE while using this device Keep all matches lighted cigarettes or other sources of ignition out of the room in which this product is located and away from where oxygen is being delivered NO SMOKING signs should be prominently displayed Textiles and other materials that normally would not burn are easily ignited and burn with great intensity in oxygen enriched air Failure to observe this warning can result in severe fire property damage and cause physical injury or death Part No 1118353 5 Platinum Series SPECIAL NOTES CAUTION Caution Federal law restricts this device to sale or rental by or on order of a physician or any other practitioner licensed by the law of the State in which he she practices to use or order the use of this device Invacare recommends an alternate source of supplemental oxygen in the event of a power outage alarm condition or mechanical failure Consult your physician or equipment provider for the type of reserve system required This equipment is to be used as an oxygen
14. et or circuit 3 Internal repairs 3 Call Service Provider required Alarm Low Flow Alarm Inspect for kinks or RAPID Kinked or blocked tub blockages Correct clean or ing cannula or humidifier replace item Once Beep Beep corrected turn power OFF Beep Beep for 60 seconds and then turn power back ON 2 Flowmeter set too low 0 5 L min or less for Platinum 5 1 0 L min or less for Platinum 10 2 Reset flowmeter to pre scribed flowrate If prescribed flowrate is below 0 5 L min use the Pediatric Flowmeter IRCPFI6 Only with Platinum 5 and XL 26 Part No 1118353 Platinum Series SECTION 7 TROUBLESHOOTING GUIDE SYMPTOM YELLOW or RED LIGHT Illuminated Alarm CONTINUOUS On red light only Only applies to PROBABLE CAUSE Low oxygen purity SOLUTION Clean or Replace filters 2 Kinked or blocked tub ing cannula or humidifier 2 Inspect for kinks or block ages Correct clean or replace item Once corrected turn power OFF for 60 seconds and then turn power back ON 3 Flowmeter set too low 0 5 L min or less for 3 Check flowmeter is set to 1 0 L min or more Light Flashing SLXO and Platinum 5 1 0 L min 10LXO SensO less for Platinum 10 models 4 Unit overheating due to 4 a Remove and clean cabinet blocked air intake filters 4b Move concentrator at least three inches from walls
15. n the IRC10 A WARNING DO NOT change the L min setting on the flowmeter unless a change has been prescribed by your physician or therapist NOTE To properly read the flowmeter locate the prescribed flowrate line on the flowmeter Next turn the flow knob until the ball rises to the line Now center the ball on the L min line prescribed 2 Ifthe flowrate on the flowmeter ever falls below 0 5 L min for Platinum 5 1 L min for Platinum 10 for more than about one minute the LOW FLOW alarm will be triggered This is a rapid beeping of the audible alarm Check your tubing or accessories for blocked or kinked tubing or a defective humidifier bottle After rated flow is restored more than 0 5 L min for Platinum 5 1 L min for Platinum 10 the LOW FLOW audible alarm will go off NOTE The use of some accessories such as the pediatric flowstand and the HomeFill compressor will deactivate the Low Flow Alarm Ball FIGURE 5 6 Flowrate Platinum Series 20 Part No 1118353 SECTION 5 OPERATING INSTRUCTIONS Front Panel Indicators Units with SensO NOTE For this procedure refer to FIGURE 5 7 The SensO feature monitors the purity of oxygen generated by the oxygen concentrator If purity falls below factory preset standards indicator lights on the control panel will illuminate OXYGEN PURITY Auto Shut Down Use Backup a e Cal Supplier IER ee RED Below Normal o YELLOW Normal 28
16. otify the carrier or your local dealer 2 Remove allloose packing from the carton 3 Carefully remove all the components from the Se Lut carton FIGURE 3 1 Unpacking NOTE Unless the oxygen concentrator is to be used immediately retain containers and packing materials for storage until use of the concentrator is required Inspection Inspect examine exterior of the oxygen concentrator for nicks dents scratches or other damages Inspect all components Storage 1 Store the repackaged oxygen concentrator in a dry area 2 DO NOT place objects on top of repackaged concentrator Platinum Series 12 Part No 1118353 SECTION 4 TYPICAL PRODUCT PARAMETERS SECTION 4 TYPICAL PRODUCT PARAMETERS 120 10 132 108 60 Hz Rated Current Input INN e Altitude Platinum 5 and XL Up to 6 000 ft 1828 meters above sea level without degradation of concentration levels From 6 000 ft 1828 meters to 3 129 ft 4000 meters below 9076 efficiency Platinum 10 Up to 4 000 ft 1230 meters above sea level without degradation of con centration levels From 4 000 ft 1230 meters to 3 129 ft 4000 meters below 90 efficiency Oxygen Output All 5LXO2 5LX models 87 to 95 6 for Concentration Levels flows ranging 0 5 to 5 L min and all 10LXO2 10LX models 87 to 95 6 for flows ranging 2 L to 10 L min Maximum Outlet Pressure Platinum 5 and XL 5 psi 0 5 psi 34 5
17. purchaser s cost the defective component part s identified pack the component part s in a manner to avoid shipping damage and to ship the component part s to either Invacare Corporation s plant or service center as specified by Invacare Corporation in advance Defective component part s MUST be returned for warranty inspection using the serial number as identification within thirty 30 days of return authorization date DO NOT return products to our factory without prior consent C O D shipments will be refused please prepay shipping charges LIMITATIONS AND EXCLUSIONS THE FOREGOING WARRANTY SHALL NOT APPLY TO PRODUCTS SUBJECTED TO NEGLIGENCE ACCIDENT IMPROPER OPERATION MAINTENANCE OR STORAGE SOOT OR SMOKE FILLED ENVIRONMENTS OR OTHER THAN NORMAL APPLICATION USE OR SERVICE OR TO PRODUCTS MODIFIED WITHOUT INVACARE CORPORATION S EXPRESS WRITTEN CONSENT INCLUDING BUT NOT LIMITED TO MODIFICATION THROUGH THE USE OF UNAUTHORIZED PARTS OR ATTACHMENTS OR TO PRODUCTS DAMAGED BY REASON OF REPAIRS MADE TO ANY COMPONENT WITHOUT THE SPECIFIC CONSENT OF INVACARE CORPORATION OR TO PRODUCTS DAMAGED BY CIRCUMSTANCES BEYOND INVACARE CORPORATION S CONTROL THE FOREGOING EXPRESS WARRANTY IS EXCLUSIVE AND IN LIEU OF ANY OTHER WARRANTIES WHATSOEVER WHETHER EXPRESS OR IMPLIED INCLUDING THE IMPLIED WARRANTIES OF MERCHANTABILITY AND FITNESS FOR A PARTICULAR PURPOSE AND THE SOLE REMEDY FOR VIOLATIONS OF ANY WARRANTY WHATSOEVER SHALL BE LIMITED TO R
18. r Shutdown Call a qualified technician Switch to a back up supply of oxygen immediately Platinum Series 22 Part No 1118353 SECTION 6 MAINTENANCE SECTION 6 MAINTENANCE A WARNING The Invacare concentrators are specifically designed to minimize routine preventive maintenance Only qualified personnel should perform preventive maintenance on the concentrator Power should be disconnected before beginning preventive maintenance on the Invacare concentrator NOTE At a minimum preventive maintenance MUST be performed according to the maintenance record guidelines In places with high dust or soot levels maintenance may need to be performed more often Refer to Preventive Maintenance Record on page 25 Routine Maintenance NOTE The following routine maintenance should be performed more frequently See recommended intervals in each section and preventive maintenance record Cleaning the Cabinet Filter CAUTION DO NOT operate the concentrator without the filter installed NOTE For this procedure refer to FIGURE 6 1 on page 24 NOTE There are two cabinet filters one located on each side of the cabinet 1 Remove each filter and clean at least once a week depending on environmental conditions NOTE Environmental conditions that may require more frequent cleaning of the filters include but are not limited to high dust smoking air pollutants etc Part No 1118353 23 Platinum Series
19. r local home care provider for recommendations on which of these devices will be best for you They should also give you advice on the proper usage maintenance and cleaning Platinum Series 2 Part No 1118353 TABLE OF CONTENTS ACCESSORIES e eee eee eeececcccccccccccssccccccecccecs 2 REGISTER YOUR PRODUCT 4 SPECIAL NOTES ccccccccccccccccccccccccccccccccccccccccccs D LABEL LOCATION c 7 SECTION GENERAL GUIDELINES 8 To Reduce the Risk of Burns Electrocution Fire or Injury to 8 Operating 9 Radio Frequency Interference eene 9 SECTION 2 FEATURES 0000000000000000000000000000000000 SECTION 3 HANDLING 000000000000000000000000000000000 12 M 12 reete pU n 12 Mire E E A 12 SECTION 4 TYPICAL PRODUCT PARAMETERS 00000000000000000000000000000000000000000000000 13 SECTION 5 OPERATING INSTRUCTIONS 16 Introductio l6 l6 5 17 Plug in Power Cord 17 Connect Humidifier If So Prescribed 17 Power Switch ee 19 a SN 20 Front Panel Indicators Units with SensO D Re retia 21 Initial Startup of the Concentrator
20. ries 10 Part No 1118353 SECTION 2 FEATURES SECTION 2 FEATURES Oxygen Purity Indicator Lights SensO model only Fault Oxygen Outlet and Power Indicator Lights LX model only Flowmeter Power Switch Circuit Breaker Elapsed Time Meter Cabinet Filter one of two shown ACCESSORIES NOT SHOWN Remote Humidifier Flowmeter Accessory IRCRF5 Platinum 5 and XL Only REAR VIEW PreciseRX Pediatric Humidifier Flowmeter Accessory IRCPF16 Platinum 5 and XL Only HomeFill home oxygen compressor 0 NOTE This outlet fitting is to be used only for filling oxygen cylinders with the HomeFill home oxygen compressor The outlet fitting does not affect concentrator performance Refer to the HomeFill owner s manual part number 1100873 for connection and operating instructions When not in use the plug provided with the concentrator should be inserted into the outlet fitting For more information about the HomeFill contact your Invacare dealer Part No 1118353 Platinum Series SECTION 3 HANDLING SECTION 3 HANDLING The concentrator should ALWAYS be Kept in the upright position to prevent cabinet damage while being transported If the concentrator is to be reshipped by common carrier additional cartons are available from Invacare Unpacking NOTE For this procedure refer to FIGURE 3 1 1 Check for any obvious damage to the carton or its contents If damage is evident n
21. scribed A WARNING DO NOT overfill humidifier DO NOT reverse the oxygen input and output connections Water from the humidifier bottle will travel through the cannula back to the patient NOTE For this procedure refer to FIGURE 5 1 FIGURE 5 2 and FIGURE 5 3 on page 18 and FIGURE 5 4 on page 19 NOTE For Platinum 5 XL recommended humidifiers are Invacare 3260 003 40 or 006 40 For Platinum 10 recommended humidifiers are high flow 7900 10 7900 25 1 Remove cap and fill humidifier bottle with distilled water to the level indicated by the manufacturer 2 Replace the humidifier cap and securely tighten Humidifier Bottle FIGURE 5 1 Filling the Humidifier Part No 1118353 17 Platinum Series SECTION 5 OPERATING INSTRUCTIONS Humidifier Bottle FIGURE 5 2 Humidifier Compartment 3 Remove the filter access door located on the side of the concentrator Insert a flathead screwdriver in the plate groove on the top edge of the filter access door and gently pry the filter access door open Refer to Detail A in FIGURE 5 3 4 The humidifier adapter is next to the inlet filter Pull up and remove the humidifier bottle adapter Refer to Detail B in FIGURE 5 3 5 Attach it to the humidifier by turning the wing nut on the humidifier bottle counterclockwise until it is securely fastened Refer to Detail C in FIGURE 5 3 6 Place the humidifier bottle in the humidifier compartment Pla
22. supplement and is not considered life supporting or life sustaining Platinum Series 6 Part No 1118353 LABEL LOCATION LABEL LOCATION IRCS5LX and IRCIOLX HomeFill Il Compatible BOQ Operating Instructions See Operator s Manual Alarms 1 0 O See Operator s Manual ZA warnine RISK OF FIRE NO SMOKING Keep ALL sources of ignition out of the room in which this product is located and away from areas where oxygen is being delivered Textiles oils and other combustibles are easily ignited and burn with great intensity in oxygen enriched air Z caution RISK OF ELECTRIC SHOCK Do not remove cover Refer servicing to qualified service personnel Flow rates below 0 5 L min will trigger Low Flow Alarm rapid audible alarm Set flowmeter at 3 L min or less when filling HomeFill II cylinders CAUTION Federal USA law restricts this device to sale by or on the order of a physician Part No 1118353 x pm 1108820 IRC5LXO2 and IRCIOLXO2 S HomeFill II Compatible 2a witl SensO Au 2m AN 0 Operating Instructions See Operator s Manual 020 Alarms See Operator s Manual NwaRNING RISK OF FIRE NO SMOKING Keep ALL sources of ignition out of the room in which this product is located and away from areas where oxygen is being delivered Textiles oils and other combustibles are easily ignited and burn with great intensity in oxygen enriched air NcaurioN
23. te Groove Insert Flat Head Screwdriver Here Filter Access DETAIL Humidifier Bottle Adapter DETAIL A Filter Access Humidifier Bottle Adapter FIGURE 5 3 Attaching the Humidifier Bottle Adapter Platinum Series 18 Part No 1118353 SECTION 5 OPERATING INSTRUCTIONS 7 Attach oxygen tubing from the humidifier bottle to oxygen outlet connector on the oxygen concentrator FIGURE 5 4 8 Attach the cannula patient supply tubing to the humidifier bottle outlet FIGURE 5 4 9 After assembly ensure that oxygen is flowing through the cannula Oxygen Outlet Oxygen Connector Tubing Humidifier Outlet FIGURE 5 4 Attaching the Oxygen Tubing Power Switch NOTE For this procedure refer to FIGURE 5 5 on page 19 1 Press power switch to on position All the panel lights and the audible alarm will come on for one second indicating that the unit is functioning properly After one second only the GREEN system ok power light will stay on On Off Power Switch FIGURE 5 5 Power Switch Part No 1118353 19 Platinum Series SECTION 5 OPERATING INSTRUCTIONS Flowrate NOTE For this procedure refer to FIGURE 5 6 on page 20 1 Turn the flowrate knob to the setting prescribed by your physician or therapist CAUTION Never set the flow greater than 5 L min on the IRC5 Never set the flow greater than 10L min o
24. ther types of oxygen delivery systems Your provider will show you how to use your oxygen concentrator He She should be contacted with any questions or problems regarding your oxygen concentrator This owner s manual will tell you about your concentrator and will serve as a reference as you use your concentrator Select a Location A WARNING NEVER block the air openings of the product or place it on a soft surface such as a bed or couch where the air opening may be blocked Keep the openings free from lint hair and the like Keep unit at least 3 inches away from walls draperies furniture and the like You may select a room where using your oxygen concentrator would be most convenient Your concentrator can be easily rolled from room to room on its casters The air intake of the unit should be located in a well ventilated area to avoid airborne pollutants and or fumes DO NOT place in a closet Platinum Series 16 Part No 1118353 SECTION 5 OPERATING INSTRUCTIONS Set Up Plug in Power Cord Plug in power cord to an electrical outlet A POLARIZED PLUG WARNING As a safety feature this appliance may have a polarized plug one blade is wider than the other This plug will fit in a polarized outlet only one way If the plug does not fit fully in the outlet reverse the plug If it still does not fit contact a qualified electrician DO NOT attempt to defeat this safety feature Connect Humidifier If So Pre
25. user maintenance items A product should NEVER be left unattended when plugged in Make sure the Platinum is Off when not in use Close supervision is necessary when this product is used near children or physically challenged individuals Additional monitoring or attention may be required for patients using this device who are unable to hear or see alarms or communicate discomfort DO NOT connect the concentrator in parallel or series with other oxygen concentrators or oxygen therapy devices Radio Frequency Interference This equipment has been tested and found to comply with EMC limits specified by IEC EN 60601 1 2 These limits are designed to provide a reasonable protection against electromagnetic interference in a typical medical installation Part No 1118353 9 Platinum Series SECTION GENERAL GUIDELINES Other devices may experience interference from even the low levels of electromagnetic emissions permitted by the above standards To determine if the emissions from the Platinum is causing the interference turn the Platinum Off If the interference with the other device s stops then the Platinum is causing the interference In such rare cases interference may be reduced or corrected by one of the following measures Reposition relocate or increase the separation between the equipment Connect the equipment into an outlet on a circuit different from that to which the other device s is connected Platinum Se
Download Pdf Manuals
Related Search