MODEL YEAR 2010 & O - RV Parts Express RV Parts Express
Contents
1. A CAUTION Use care when adjusting the pitch as the awning may move abruptly Pitch Adjustment Pin Tip 1 Extend the awning completely It is easier to adjust the pitch when the refer ni in step 3 awning is fully extended 9 ae i l Lift u Pull down 2 Hold on to the awning arm to keep it hen pin iS when al steady while adjusting the pitch at front of hole back of hole 3 Press in the pitch adjustment pins located on the long scissor arms Tip Applying LIGHT pressure on the arm will decrease the force required to press the pitch adjustment pins 4 Slide the outer scissor arm to the desired set of holes towards the Pitch Adjustment Pins coach for a lower pitch and away from J one on each side the coach for a higher pitch Support and Lift in this area RAIN RELEASE SETTING The effects of wind and rain on an awning are Minimum unpredictable and can cause severe damage to the awning and or the vehicle IF WIND OR EXTENDED PERIODS OF RAIN ARE EXPECTED ROLL UP THE AWNING AND SECURE If the awning is extended during rain position one arm at minimum pitch and the other arm at maximum pitch This Maximum f gt provides slope to allow the water to run off Pitch Note The awning can be retracted with the arms set in the rain release setting The pitch does not have to be equalized before closing See Warning below Las AWARNING FOR AWNINGS UNDER 12 FEET LONG DO NOT SET THE ARMS2. This will help prevent the fabric from stretching or distorting LEAKING On vinyl canopies side hems and poly cords are stitched in with a sewing machine On occasion this stitching may allow water to seep or leak through the stitches This is normal and not a defect covered by warranty Treat the seams with a seam sealer ARM CARE The best method of keeping the arms operating smoothly is to clean them Dirt and debris can cause the channels not to slide easily Avoid introducing water into the motorized and non motorized housings Periodically wash out the channels with running water i e a hose to keep them clean If the arms still do not slide easily lightly spray the pivot and contact points with a dry silicone lubricant after the arms have been cleaned and dried thoroughly 10 ECLIPSE CAREFREE MAJOR PRODUCT LIMITED WARRANTY Carefree of Colorado hereafter referred to as Carefree warrants to the first retail Purchaser that the Carefree Product is free of defects in material and workmanship within the terms and conditions as set forth in the warranty statement available online at www carefreeofcolorado com Carefree s obligation under this warranty is limited to the repair or replacement at Carefree s option of any defective component with new or factory refurbished components OWNER MUST RETAIN THE ORIGINAL PROOF OF PURCHASE AND OR HAVE THE PRODUCT WARRANTY REGISTRATION ON FILE AT CAREFREE FOR WARRANTY CLAIMS THI
3. on Carte pereact ON Tie Retract Lom Power Press to OFF Extend E0063 i Press to Press to Extend Retract E0045a Carefree of Colorado SYSTEMS WITH OPTIONAL AUTO RETRACT The Auto Retract System is an exciting enhancement to basic awning operation When activated the system will retract the awning automatically in windy conditions Sensitivity is set at the control panel The system uses a sensor in the motor head to detect awning motion caused by windy conditions The system operates by gauging the vertical motion of the awning s leading edge When persistent motion exceeds the factory preset threshold value for 2 seconds or longer the system will automatically retract the awning The pushbutton controls allow the user to choose between 3 factory preset sensitivity values threshold values Gust detection is incorporated into the Direct Response software When the motion value is suddenly and sharply increased above a safe maximum value then the 2 second persistence measure is overridden and the awning closes immediately CAUTION THE CAREFREE DIRECT RESPONSE AUTO RETRACT SYSTEM IS A PREMIERE ELECTRONIC AUTO RETRACT SYSTEM THAT PROVIDES PROTECTION AGAINST ADVERSE ELEMENTS BUT NO AUTO RETRACT SYSTEM IS A GUARANTEE AGAINST SEVERE OR DESTRUCTIVE WEATHER THE EFFECTS OF WIND AND RAIN ON AN AWNING ARE UNPREDICTABLE AND MAY CAUSE SEVERE DAMAGE TO THE AWNING AND OR VEHICLE IF WIND OR EXTENDED PERIODS O
4. AT MORE THAN THREE 3 POSITIONS DIFFERENT BETWEEN THE SHALLOW AND STEEP PITCH DAMAGE TO THE ARMS AND CANOPY CAN OCCUR IF THE AWNING IS RETRACTED WHEN THE ARMS ARE SET AT MORE THAN 3 POSITIONS DIFFERENCE Pitch Rain Release Minimum Setting Pitch 3 Positions Maximum Difference E0017b ECLIPSE THE AUTO DUMP FEATURE When set at the MINIMUM flat pitch the Eclipse awning will automatically dump accumulated water The feature works by having one arm automatically folding partially closed to create a valley in the canopy The valley allows the water to run off one side to prevent pooling When the rain has stopped and the water has drained the arm will extend back to normal This feature is disabled when accessories such as rafters or rooms are installed EMERGENCY OPERATION If the original power source fails or is unavailable the Eclipse has emergency override terminals 12V The terminals can be used with a 9V 18V power source such as a cordless drill battery or car battery AWA RNING DO NOT CONNECT THE TRAVEL R TERMINALS TO A 110V POWER SOURCE DOING SO WILL PERMANENTLY DAMAGE THE AWNING A CAUTION Do not use the emergency terminals without following the directions below The electronic circuit creates a dynamic brake for the motor by shorting and grounding the motor leads Steps 1 amp 2 remove the brake to allow the emergency override to work 1 If there is an external plug
5. disconnect the plug then go to step 3 2 Awnings without an external plug 2 1 Remove the front cover from the motor head There are six 6 small screws do not remove the larger screw toward the center 2 2 Disconnect the input cable wires from the terminals DO NOT disconnect the wires to the motor 2 3 Leave the wires disconnected and reattach the front cover 3 Attach the provided jumper leads to the terminals located on the rear of the motorized head 4 Connect the other ends of the jumper leads to a 12V source If the awning does not begin to move reverse the leads 5 Maintain contact throughout the retraction process A CAUTION Use care when retracting the awning as the it may move abruptly Disconnect Wires from Arm Channel E0047 Front Cover Carefree of Colorado AWNING CARE Maintaining a Carefree Awning is easy Just follow these basic steps e Always operate the awning according to the instructions e Periodically check that the fasteners are tight Tighten if necessary e Keep the awning fabric and arms clean FABRIC CARE CAUTION Do NOT USE OIL BASED CLEANERS OR ANY CAUSTIC GRANULATED OR ABRASIVE TYPE CLEANERS ON YOUR CAREFREE PRODUCT 1 One of the best ways to keep the fabric looking good and to delay the need for deep or vigorous cleanings is to hose fabrics off on a monthly basis with clear water This practice will helo prevent di
6. AWNING ARE UNPREDICTABLE AND CAN CAUSE SEVERE DAMAGE TO THE AWNING AND OR THE VEHICLE IF WIND OR EXTENDED PERIODS OF RAIN ARE EXPECTED ROLL UP THE AWNING AND SECURE A KEEP ALL SOURCES OF HEAT AND FLAME AWAY FROM THE AWNING CANOPY FABRIC IS NOT FIRE PROOF AND CAN BURN IF LEFT IN CONTACT WITH ANY FLAME OR HEAT SOURCE N CAUTION Itis recommended that if leaving the RV unattended for a length of time retract the awning to avoid unexpected climate conditions 2 ECLIPSE SINGLE SWITCH OPERATION Press to For basic installations a single interior Retract control switch is provided for Extend and Retract motor control To Operate the Awning Press and hold the Patio Switch until the awning is in the desired position then release the switch Press to Extend TravelR041 MULTIPLE SWITCH OPERATION The multiple switch configuration provides 3 switches for Extend and Retract Motor control Two interior switches a Power ON OFF and a Patio switch A second outside Patio switch is mounted into the bottom cover of the right arm To Operate the Awning e Press the Power Switch to the ON position e Press and hold a Patio Switch until the awning is in the desired position then release the switch IT IS STRONGLY RECOMMENDED THAT THE POWER SWITCH BE SET TO OFF WHENEVER THE AWNING IS NOT BEING OPERATED AND DURING TRANSPORT THIS ACTS AS A SAFETY TO PREVENT THE AWNING FROM BEING ACCIDENTLY OPENED Power Press to uly e
7. F RAIN ARE EXPECTED RETRACT THE AWNING Don t have Direct Response Contact your Carefree dealer about having an upgrade kit installed ECLIPSE DESCRIPTION OF CONTROLS The Eclipse Awning with Direct Response uses 3 switches at the control panel Power Switch Patio Switch and Motion Sensitivity Switch Press to Retract Motion Sensitivity Awning Control Power RETRACT MOTION l i ie Low EXTEND whe Power Carele OFF Press to Extend DR039 POWER SWITCH POWER ON The bottom position activates the Patio switch and the Auto Retract system and provides power to the awning POWER OFF The top position shuts the system down The awning cannot be extended or retracted in this mode The auto retract system is also disabled IMPORTANT NoTE The auto retract system is ON when the power is ON The system is OFF when the power switch is set to OFF If the power is shut off while the awning is extended the awning is not protected by the auto retract system PATIO SWITCH This is a two position momentary contact switch This description also applies to any additional patio switches that may be installed EXTEND 05 Press and release the switch The awning automatically opens To stop the awning before it is fully open press and release the extend switch a second time RETRACT 005 Press and release the switch The awning automatically retracts until it is fully closed T
8. S WARRANTY IS NOT TRANSFERABLE For Warranty Duration Warranty Coverage and Exclusions Warranty Terms of Coverage and Warranty Claim Procedures Refer to publication 052580 111 Carefree Major Product Limited Warranty available online at www carefreeofcolorado com Register your Carefree products online at www carefreeofcolorado com Publications available on line www carefreeofcolorado com 052547 001 Eclipse Arms and Canopy After Market Installation Manual 052547 021 Eclipse Arms and Canopy OEM Installation Manual 052568 201 Eclipse Owner s Manual 052547 301 Eclipse Service Manual 052526 001 Direct Response Installation Manual IMPORTANT NOTICE It is strongly recommended that adjustments and repairs not described in this book be performed by trained technicians at your Authorized Carefree Dealer Work performed by non authorized persons or businesses may void warranty Carefree of Colorado Colorado www carefreeofcolorado com Carefree of Colorado 2145 W 6 Avenue Broomfield CO 80020 a Scott Fetzer company 052568 201 Printed in USA June 2010
9. ce may vary depending on the specific installation and Function location of the receiver in the vehicle Buttons To use turn system power ON at the control panel Stop NOTE Power ON OFF and the Auto Retract system and can only be operated at the control panel Extend Press and release The awning will extend out to the full extension and stop automatically Retract_ Press and release The awning will retract and stop automatically when the awning is fully retracted Press and release During extend and retract functions the awning may be stopped by pressing this button KEY FOB BATTERIES The Key FOB w antenna uses a battery Radio Shack p n 23 279 or equivalent that should provide a long period of service To access Remove the small screw from the back of the case and carefully snap off the back Lift the old battery out and insert the new battery Batteries are available through your local battery outlets Battery life is dependent on frequency of use environmental conditions and condition of remote ECLIPSE PROGRAMMING THE REMOTE RECEIVER When adding or replacing a remote control it is necessary to program the transmitter and receiver Press to Learn Transmitter Indicator Program Light Button DRO20 Power to the control box must be on Press and release the Press to Learn Transmitter button on the bottom of the receiver box The receiver is in program mode when the red light comes o
10. n Press and release the SToP button on the remote The red light will go out after the receiver learns the remote signal NOTE Pressing the stop button will cause the blue up arrow button to default as the close retract function If a function button is pressed to train the receiver it will be programmed as the retract button Example Pressing the top button will program the top button for retract and the bottom button as extend OPERATIONAL NOTES Transmitter and receiver operate on frequency 433 MHz The receiver exits the program mode after ten seconds If the light does not come on the memory is full and must be cleared To clear the memory PRESS AND HOLD the transmitter learn button While holding the button the indicator light should be OFF for the full 5 seconds then come on If the light does not go out during programming the receiver already knows the transmitter s signal or the battery in the remote needs to be replaced The system may be programmed for up to 5 remotes Additional remotes may be ordered separately Carefree of Colorado ADJUSTING THE PITCH The Eclipse arms have 6 pitch adjustment settings from minimum pitch to maximum pitch The awning can be extended and retracted in any of these positions without having to reset the pitch between uses See the Warning about rain release settings at the bottom of the page Maximum 4 Minimum g Pitch Sd Pitch l l TravelR033
11. nd Acrylic fabrics and fabric covers Consult your Carefree Dealer for available options and upgrades This manual describes the operation and care for your Eclipse Patio Awning Descriptions include Single Switch Operation Multiple Switch Operation that includes a convenient outdoor patio switch and the optional auto retract system that closes the awning automatically in windy conditions Operational Notes Awning Motor The awning motor is equipped with a thermal protection circuit to protect the motor from overheating Operating the awning repeatedly over a short time period may cause the circuit to sense a overheat condition and shut off the motor If this occurs wait approximately 15 minutes to allow the motor to cool then operate the awning in normal fashion Ignition Lockout Sensors Available with Direct Response Only If the optional Carefree EL ignition lockout is installed the system will disable the extend function while the vehicle ignition key is in the ON position Special order RTL ignition lockouts will fully retract the awning and disable the extend function when the vehicle ignition key is in the ON position Functions will return to normal operation when the ignition key is turned OFF RV manufacturers may install their own lockout design Refer to the RV literature for 12V power used for accessories AWARNINGS A AWNINGS ARE DESIGNED TO PROVIDE SHADE AND PROTECTION FROM THE SUN THE EFFECTS OF WIND AND RAIN ON AN
12. nla OWNER S MANUAL Carefree ECLIPSE MODEL YEAR 2010 amp ON TABLE OF CON Introduction _ Ee x2 Single Switch Operation ae O 3 Multiple Switch Operation cccccccccseccenecneccnsecescceseseeseceneceneseeeseeneseneeeeeeeenensaes 3 Systems with Optional Auto Retract cccecccessseeeeeseeeeeeseeeeeeeeeeeaeneeseaenenseaes 4 Description of Controls lt sxccssansccans cncaasuseasecnssanasesioesuecedesctonseedoedeenmsanedecmsaueceteinesd 5 Operating the Controls cccccccceeeccececeeeeeeeseseeeeeeeeeeeeeeeeeeeaaaaasssseeeeeeeeeees 6 Testing the Direct Response System nneannnnnnnennnnnnennsnnnnnnnnnensennnrreeenenne 6 Using the Key FOB Remote Control ccccccccceccsesseeeeeceeeeeeeeeeseeeeessaeaeeeees 6 Programming the Remote Receiver ccccseececceeeeeeceeeeeceeeeeseeeeeeseeeesaaees 7 Adjusting the 2 ICING ccs sonemiarteann atecseneuesiecesasautiaiwuecwanesdancesnsussmssnpatestodusanamneapiusces 8 Rain Release Setting cccccccccccsssssseecceceesseeeeeeeeeeesseeeeeeeeeeeeseaeaeeeeeeessaaeees 8 The Auto DUMP Feature cccsesseccccsssseecccsesserscssonseesessenseesessonsersessonsensens 9 Emergency ODCI ANON rsisi an E e 9 AWNING O ATE a EEE Ea 10 Fabie CG ee 10 PIV Ae EEE E ANE E E A A E AEE 10 Carefree Major Product Limited Warranty ccccsssseesesseeeeeeeeeneeeeeensaeneeses 11 Special Note This manual provides a basic descri
13. o stop the awning before it is closed press and release the retract switch a second time MOTION SWITCH HIGH lt gt MED lt LOW Low requires less amount of motion before the awning closes automatically High requires more motion before the system closes automatically You may have to experiment to find the best setting for your preferences NOTE If the motion switch is not installed the system defaults to the medium setting Carefree of Colorado OPERATING THE CONTROLS e Turn the Power switch ON e Use the Patio switch to extend or retract the awning as desired e Set the Sensitivity switch to the level desired TESTING THE DIRECT RESPONSE SYSTEM It is important to test the Direct Response system periodically to ensure that the system is working properly Follow the simple test below 1 Extend the awning completely Set the motion sensitivity to the lowest setting Gently move the roller tube up and down in a vertical motion If the awning retracts the system is working properly If the awning does not retract contact an authorized Carefree dealer for repairs Operate the awning with the Patio switch until the system is repaired ae 2 f USING THE KEY FOB REMOTE CONTROL A remote control Key FOB is available only with the auto retract system The remote provides the advantage of allowing you to operate the awning from any convenient location The remote has a maximum operating range of 50 feet Actual distan
14. ption of the product and the standard operating controls provided by Carefree of Colorado Some Original Equipment Manufacturers OEM s may alter or change the placement style and or functional configuration of the switches If your controls do not match the style or description included contact the coach manufacturer for an accurate description OEM furnished components are not covered by the Carefree warranty Carefree of Colorado INTRODUCTION From it s beginning in the early 70 s Carefree of Colorado has emerged as the premier manufacturer of quality awnings and accessories for Recreational Vehicles RVs Our full line of products can provide the accessories that match your life style no matter what type of RV you own The Eclipse Patio Awning uses unique scissor style arms that do not require vertical ground support The arms provide easy to use pitch adjustment simply push together the pins on the arms snap into the hole set desired and the pitch is set The pitch can be left in any position and the Eclipse will roll up completely When the awning Is rolled back out it rolls out to the pitch setting previously set Features include e The awning rollbar and arms are made from light weight no rust aluminum e 100 billow proof worm gear drive motor eliminates the need for travel locks e Highest head clearance of any vertical arm awning e Automatic Self Leveling Retraction from any pitch e Large selection of vinyl a
15. rt from becoming deeply imbedded in the fabric In most environments a thorough cleaning will be needed every two to three years 2 When it s time for a thorough cleaning the fabric can be cleaned while still on the awning frame e For Vinyl Fabric Use a soft brush and warm water with soap e For Acrylic Fabric Use a stiff brush and warm water with soap 3 When cleaning the fabric it is important to observe the following Always use a natural soap never detergent Water should be cold to lukewarm never more than 100 F Air dry only Never apply heat to the fabric Always allow the fabric to dry thoroughly before rolling up the awning MILDEW Mildew is a fungus growth that looks like dirt Vinyl coated polyester fabrics are mildew resistant because of a chemical biocide in the vinyl coating Under ordinary conditions mildew will not appear However in areas where high temperature and humidity are common mildew can be a problem and require the material to be washed more frequently Thoroughly rinse the fabric with clean water and allow to air dry completely before rolling up the awning POOLING When water collects on the top of the fabric this is known as pooling This can occur during inclement weather or if a running air conditioner discharges over the awning The water is dumped when the awning is retracted It is recommended that if water accumulates on the top retract the awning in steps 8 12 to dump the water
Download Pdf Manuals
Related Search