3.5mm Auxiliary Input Kit Instruction Sheet - Harley
Contents
1. cMOTOR HARLEY DAVIDSON NWU J06025 INSTRUCTIONS REV 2014 11 19 AUXILIARY INPUT KIT GENERAL Kit Number 69200907 Models For model fitment information see the P amp A retail catalog or the Parts and Accessories section of www harley davidson com English only Installation Requirements Even if a Harley Davidson dealer does not install this kit an update to the Audio Inputs function is available without charge from any dealer through Digital Technician Il Dealer labor rates could apply for the update procedure WARNING The rider s safety depends upon the correct installation of this kit Use the appropriate service manual procedures If the procedure is not within your capabilities or you do not have the correct tools have a Harley Davidson dealer perform the installation Improper installation of this kit could result in death or serious injury 00333a J06025 Many Harley Davidson Parts amp Accessories are made of plastics and metals which can be recycled NOTE This instruction sheet refers to service manual information A service manual for this year model motorcycle is required for this installation One is available from a Harley Davidson dealer Kit Contents This kit consists of e a 20 in 0 5 m long audio jack jumper cable Part No 69200610A e two cable straps Part No 10006 PREPARATION WARNING To prevent accidental vehicle start up which could cause2. death or serious injury remove main fuse before pro ceeding 00251b NOTE e WITH security siren With security fob present turn ignition switch ON See the service manual After system is disarmed turn ignition switch OFF IMMEDIATELY remove main fuse e WITHOUT security siren See the service manual Remove main fuse 1of2 Please dispose of materials responsibly INSTALLATION 1 See the service manual Remove outer fairing 2 Connect the audio jack jumper cable to the black twelve way Molex CB connector 184 above the radio 3 If the vehicle has CB a Unplug the CB connector b Release the secondary lock on the AUX cable side De pin the wire in cavity 6 from black connector using a Molex de pin tool NOTE Colors could vary with AUX cable assemblies De pin and repin one wire at a time c Release the secondary lock on the CB module socket side Remove the corresponding cavity pin in cavity 6 d Insert the terminal from step 3 b AUX cable above back cavity 6 of the CB connector socket side e Repeat for cavity 7 and 8 f Engage the secondary lock on the CB module con nector g Plug in the CB connector NOTE DO NOT drill hole in media tray if audio source is not located there 4 If locating an audio source IN THE MEDIA TRAY see Figure 1 or Figure 2 a See the service manual Remove the media tray 1 b Drilla 1 2 in 13 mm diameter hole 2 in the location shown c Ligh
3. tly sand the opening to remove burrs and sharp edges Clean all drilling and sanding debris from the media tray d Insert the open end of the audio jack jumper cable through the newly drilled hole Secure the grommet into the newly drilled hole e See the service manual Install media tray If using with a Zumo GPS unit as an AUDIO source for voice prompts or audio Connect the open end of the audio jack jumper cable to the mating Zumo harness connector marked AUDIO IN 5 Secure the audio jack jumper cable with cable straps from the kit 6 Have a Harley Davidson dealer use the Digital Technician Il service tool to update the Audio Inputs to the desired setting Audio Only Tone Detection Only Both Audio AND Tone Detection This update is available without charge from any dealer Dealer labor rates could apply for the update procedure 7 Check the audio system for proper function a new AUX appears under the Media tab J06025 8 See the service manual Install outer fairing is07995 1 Media tray 2 Drill 1 2 in 13 mm diameter hole 3 View in direction of arrow A Figure 1 Drill Hole in Media Compartment FLH Models is08314 Media tray Drill 1 2 in 13 mm diameter hole View in direction of arrow A 1 2 3 4 Measure 1 320 in 33 53 mm Figure 2 Drill Hole in Media Compartment FLT Models 2 of 2
Download Pdf Manuals
Related Search