TECH TIPS - Genie Industries
Contents
1. C AN SECTION 5 FIRE FIGHTING MEASURES FLAMMABILITY NOT FLAMMABLI CONDITIONS OF F E LAMMABILITY AT T EM U ERATUR ES AT OR ABOVE FLASH POINT EXTINGUISHING MEDIA CARBON DIOXIDE DRY CHEMICAL FOAM WATER SPRAY SPECIAL PROCEDURES SELF CONTAINED BREATHING APPARATUS REQUIRED FIREFIGHTERS SHOULD WEAR THE USUAL PROTECTIVE GEAR DO NOT LET FIREFIGHTING WATER RUNOFF ENTER A SEWER AUTO IGNITION TEMPERATURE NOT AVAILABLE FLASH POINT DEG C METHOD CLOSED CUP ASTM D 93 gt 400 DEG F 204 DEG C OWER FLAMMABILITY LIMIT VOL NOT AVAILABLE UPPER FLAMMABILITY LIMIT VOL NOT AVAILABLE EXPLOSION DATA SENSITIVITY TO STATIC DISCHARGE NOT AVAILABLE SENSITIVITY TO MECHANICAL IMPACT NOT AVAILABLE HAZARDOUS COMBUSTION PRODUCTS CARBON MONOXIDE CO TRACES OF OTHER TOXIC FUMES RATE OF BURNING NOT AVAILABLE EXPLOSIVE POWER NOT AVAILABLE SECTION 6 ACCIDENTAL RELEASE MEASURES EAK SPI ONTAIN LL THI E S PILL ENT EN WILL LI P A TRY BE INTO SLIPP DRAINS SEWERS ERY2. Q ESSARY TO PREVENT EVE FACE PROTECTION SAFETV GOGGLES OR SAFETV GLASSES WITH SIDE SHIELDS SEE SECTION 2 FOR EXPOSURE LIMITS C ra 9 PHYSICAL AND CHEMICAL PROPERTIES PHYSICAL STATE LIOUID COLOR BLUE ODOR MILD VAPOR PRESSURE LESS THAN 5 MMHg AT 27 DEG C 80 DEG F pH NOT APPLICABL EL x1 BOILING POINT RANGE GREATER THAN 149 DEG C 300 DEG F MELTING POINT RANGE NOT AVAILABL CJ SPECIFIC GRAVITY 1 1 AT 23 9 DEG C 75 DEG F VAPOR DENSITY NOT AVAILABLE EVAPORATION RATE NOT AVAILABLE SOLUBILITY IN WATER SLIGHT PARTITION COEFFICIENT n OCTANOL WATER NOT AVAILABLE VOC CONTENT 4 48 49 3 GRAMS LITER EPA METHOD 24 C 00048 10 STABILITY AND REACTIVITY STABILITY STABLE HAZARDOUS POLYMERIZATION WILL NOT OCCUR HAZARDOUS DECOMPOSITION PRODUCTS OXIDES OF CARBON OXIDES OF SULFUR OXIDES OF NITROGEN IRRITATING ORGANIC VAPORS INCOMPATABILITY STRONG OXIDIZERS FREE RADICAL INITIATORS STRONG REDUCING AGENTS ALKALIS OXYGEN SCAVENGERS OTHER POLYMERIZATION INITIATORS COPPER IRON ZINC ALUMINUM RUST CONDITI
3. NATE ALL IGNITION SOURCES WEAR SUITABLE PROTECTIVE COLLE WASTE DISPOSAL DESTROY BY LIQUID INCINERATION USE ABSORBENT MATERIAL AND DEPOSIT IN TOXIC EN IN CASE MATERIAL IS RELEASED OR SPILLED E EQUIPMENT CT IN A FLAMMABLE WASTE CONTAINER FOR DISPOSAL METHOD T LANDFILL IN ACCORDANCE WITH LOCAL STATE AND FEDERAL REGS w r i SECTION VIII SPECIAL PROTECTION INFORMATION RESP I AIR S RATORY PROTECTION SPECIFY TYPE UPPLIED MASKS IN CONFINED AREAS IF LARGE QUANTITIES USED VENTI LATION LOCAL EXHAUST PREFERRED MECHANICAL GENERAL ACCEPTABLE PECIAL OTHER PROTECTIVE GLOVES YES IF LARGE QUANTITIES US T iD NITRILE RUBBER EYE PROTECTION GOGGLES IF LARGE QUANTITIES USED OTHER PROTECTIVE EQUIPMENT SAFETY SHOWER AND EYE BATH TE TT TT TS SECTION IX SPECIAL PRECAUTIONS PRECAUTIONS TO BE TAKEN IN HANDLING AND STORING WEAR RESISTANT GLOVES SUCH AS NITRILE RUBBER EYE PROTECTION CHEMICAL SPLASH GOGGLES PROTECTIVE EOUIPMENT TO PREVENT PROLONGED SKIN CONTACT
4. OTHER PRECAUTIONS T U S GOVERNMENT PRINTING OFFICE 1981 340 979 429 RGANIC PRODUCTS CO BELIEVES THAT THE INFORMATION CONTAINED IN THIS DS IS RECT AS OF THIS DATE ER DITIONS OVER WHICH ORGANIC PRODUCTS HAD NO CONTROL OR IN WAYS WE NOT ICIPATE WE GIVE NO WARRANTY EXPRESS URACY OF INFORMATION AND ASSUME NO RESPONSIBILITY FOR ANY DAMAGE TO PERSON PERTY OR BUSINESS ARISING FROM SUCH USE MOREOVER IT IS THE PONSIBILITY OF THE PURCHASER OR USER OF THIS MATERIAL TO ENSURE THAT ep T HOWEVER BECAUSE THE MATERIAL MAV BE USED ZO OW O Z D z T D OR IMPLIED AS TO THE Q Q Am O Bi ep Boo el OS s m H MH EA PROPERLY AND SAFELY USED FORM OSHA 20
5. tA ILABLE AVAILABLE NOT AVAILABLE CJ C ii mA SECTION 12 ECOLOGICAL INFORMATION ENVIRONMENTAL TOXICITY NO DATA AT THIS TIMI E ENVIRONMENTAL FATE NO DATA AT THIS TIME E ot VON SECTION 13 DISPOSAL CONSIDERATIONS WASTE DISPOSAL CONTACT A LICENSED WASTE DISPOSAL CONTRACTOR FOR DETAILED RECOMMENDATIONS MANY STATES CLASSIFY WASTE LUBRICANTS AS HAZARDOUS WHICH MEANS DISPOSAL CAN ONLY BE A LICENSED FIRM FOLLOW APPLICABLE LOCAL REGULATIONS T T Hj EDERAL STATE AND C AN SECTION 14 TRANSPORT INFORMATION DOT NOT REGULATED C la a aa AN SECTION 15 REGULATORY INFORMATION USA REGULATORY INFORMATION SARA HAZARD CATEGORIES SECTIONS 311 312 IMMEDIATE ACUTE HEALTH HAZARD NO DELAYED CHRONIC HEALTH HAZARD NO FIRE HAZARD NO SUDDEN RELEASE OF PRESSURE NO REACTIVE NO SARA SECTION 313 NOT REGULATED TSCA INVENTORY ALL COMPONENTS OF THIS PRODUCT AR T LISTED ON THE TSCA INVENTORV oo TC IDIC C e SECTION 16 OTHER INFORMATION SUPPLIER MSDS DATE 2003 02 10 DATA PREPARED BY GSM DISCLAIMER WHILE THE INFORMATION AND RE
6. ULATORY INFORMATION RY STATUS ED OR ARE EX RT NOTIFICATION RCLA SA EHS NONE CERCLA SA ERCLA SA 4 M A EPORTING DI T EALTH HAZAR TION 311 312 IMMEDIATE HIS PROD EPORTING c T R R EQUIREME ECTION 313 OF TH RIGHT TO KNOW ACI 15 9 CALIFORNIA PROPOSITION 65 THIS PRODUCT CONTAINS A CH CAUS CANC ti ti CANADA REG EMICA FOLLOWING TOXIC C L EMPT FROM LISTING ON THE TOXIC 150 76 5 MINIMUS ELAYED HEALTH UBJECT TO THE T 40 CFR 372 R AND BIRTH DE C ti PA DSL N ALL COMPON SUBSTANCES DSL STATUS WHMIS HAZA KNOWN TO R OTHER ATORY INFORMATION ED ON OR ARE AND COMMUNITY EROXIDE CASH 80 OF CALIFORNIA TO EMPT FROM LISTING ON THE DOMESTIC A 16 OTHER INFORMATION THIS MATERIAL SAFETY DATA SH VERSION IN SECTIONS 15 T ET CONTAINS CHANGES FROM THE PREVIOUS PREPARED BY KYRA KOZAK WOODS PRODUCT SAFETY AND REGULATORY AFFAIRS SPECIALIST ISCLAIMER HE DATA CONTAINED HEREIN ARE FURNISHED FOR INFORMATION ONLY AND ARE E LIEVED TO BE REL
7. 5 FIRE FIGHTING MEASURES SPECIAL NOTES Leaks ruptures in high pressure systems using materials of this type can create a fire hazard when in the vicinity of ignition sources eg open flame pilot lights sparks or electric arcs FIRE CLASSIFICATION Classification 29 CFR 1910 1200 Not classified by OSHA as flammable or combustible FLAMMABLE PROPERTIES FLASH POINT COC 338 424F 170 218C min AUTOIGNITION NDA FLAMMABILITY LIMITS by volume in air Lower NA Upper NA EXTINGUISHING MEDIA C02 Dry Chemical Foam Water Fog NFPA RATINGS Health 1 Flammability 1 Reactivity 0 FIRE FIGHTING INSTRUCTIONS This material will burn although it is not easily ignited COMBUSTION PRODUCTS Normal combustion forms carbon dioxide water vapor and may produce oxides of sulfur and nitrogen Incomplete combustion can produce carbon monoxide 6 ACCIDENTAL RELEASE MEASURES CHEMTREC EMERGENCY NUMBER 24 hr 800 424 9300 or 703 527 3887 International Collect Calls Accepted ACCIDENTAL RELEASE MEASURES Stop the source of the leak or release Clean up releases as soon as possible observing precautions in Exposure Controls Personal Protection Contain liquid to prevent further contamination of soil surface water or groundwater Clean up small spills using appropriate techniques such as sorbent materials or pumping Where feasible and appropriate remove contaminated soil Follow prescribed procedures for r
8. 800 424 9300 508 996 6721 PRODUCT NAME ad T CHI EMICAL FAMILY 8 00 AM 5 00 PM NYOGEL 760G LUBRICATING GR HMIS H F R PPE DORE T ET EKDAYS FASE IO SECTION 2 INGREDIENT INFORMATION C A S CONC INGREDIENT ACGIH TLV WGT WGT NAME OIL MIST AVAILABLE INGREDIENT NAME NIOSH RE OIL MIST 5 MG M3 OSHA PEL OSHA PEL ACGIH TLV TWA STEL TWA STEL 5 MG M3 NOT 5 MG M3 NOT AVAILABLE L TWA NIOSH REL STEL NIOSH IDLH 10 MG M3 2500 MG M3 iiiI A SEC NOTE PRODUCT FO 7 im RMULATION IS PROPRI NO INGREDI ENTS ARI a ry H F H KNOWN TO BI TARY HAZARDOUS UND TION 2A ADDITIONAL INGREDIENT INFORMATION CJ ER NORMAL USAGE IIN AAA SECTION 3 HAZARD IDENTIFICATION EMERGENCY OVERVIEW MAY IRRITATE EYES PROLONG IRRITATION INHALATION OF OIL MIST OR VAPORS FROM MATERIAL AT HIGH TEMPERATURES MAY IRRITATE RESPIRATORY PASSAGES T tA D OR REPEATED SKIN CONTACT MAY CAUSE ROUTE OF ENTRY SKIN CONTACT EYE CONTACT INHALATION AND INGESTION EFFECTS OF ACUT T EXPOSURE CJ EYE CONTACT MAY CAUS EJ H RRITATION SKIN CONTACT
9. T RIALS D CONTAINE T 9 ep c SECTION 8 EXPOSURE CONTROLS PERSONAL PROTECTION PRECAUTIONARY MEASURES GLOVES TYPE CHEMICAL RESISTANT GLOVES AVOID SKIN CONTACT E RESPIRATORY TYPE NONE REOUIRED UNDER NORMAL US IF EXPOSURE LIMIT IS EXCEEDED WEAR A NIOSH APPROVED RESPIRATOR AVOID BREATHING OIL MIST EYE TYPE AVOID EYE CONTACT SAFETY GLASSE IN ACCORDANCE S GOGGLES OR FACE SHIELD WITH OSHA 29 CFR 1910 133 T FOOTWEAR TYPE SAFETY SHOES P R LOCAL DU EGULATIONS CLOTHING TYPE WEAR ADEQUATE PROTECTIVE CLOTHES APRON OTHER TYPE EYE WASH FACILITY SHOU E IN CLOSE PROXIMITY EMERGENCY SHOWER SHOULD BE IN CLOSE PROXIMITY T ta T VENTILATION REQUIREMENTS LOCAL VENTILATION IS GENERA USE WITH ADEQUATE GENERAL VENTILATION VENTILATION AND OTHER FORMS OF ENGINEERING CONTROLS ARE THE PREFERRED MEANS FOR CONTROLLING CHEMICAL EXPOSURES LY NOT NECESSARY UNDER NORMAL CONDITIONS OF T C n j SECTION 9 PHYSICAL AND CHEMICAL PROPERTIES
10. Polypropylene lt 320 F Percent Volatile by Volume Not Vapor Hydrogen Air 1 0 069 Evaporation Not Applicable Density Electrolyte Air 1 3 4 Rate Applicable Solubility in Water Reactivity in Water Electrolyte water reactive 1 Electrolyte 100 Soluble Appearance Battery Polypropylene or hard rubber case solid and Odor Lead Gray metallic solid Electrolyte Liquid colorless oily fluid nuisance odor when hot or charging battery SECTION 10 STABILITY AND REACTIVITY Stability Unstable Conditions High temperatures cases decompose at lt 320 F Stable E to Avoid Avoid overcharging and smoking or sparks near battery surface and rapid overcharge Incompatibility Materials to Avoid Sparks Open flames Keep battery case away from strong oxidizers An explosive hydrogen oxygen mixture within the battery may occur during charging Combustion can produce carbon dioxide CO and Hazardous carbon monoxide CO Molten metals produce fumes and or vapor that may be toxic or respiratory irritants Decomposition Products Hazardous May Occur Polymerization Will Not Occur K Do not overcharge SECTION 11 TOXICOLOGICAL INFORMATION GENERAL The primary routes of exposure to lead are ingestion or inhalation of dust and fumes ACUTE INGESTION INHALATION Exposure to lead and its compo
11. SKIN PPM WA WA a Md ii NX 3 HAZARDS IDENTIFICATION EM ERG ENCY OVE RVI EW PHYSICAL zal STATE LIQUID COLOR BLUE ODOR MILD MIS EALT HYSICAL HAZARD 2 H H FLAMMABILITY E P ERSONAL PROTEC WARNING TION SEE ECT K CAUSES E MAY CAUSI MAY CAUS E IRRI SKIN ALL td J ERGIC SKIN R TATION IRRITATION ION 8 EBACTION MAY CAUSE RES PIRA TO RE EVANT ROUTES OF EXPOSURE F E POTENTIAL HEA iTH EFFECTS INHALATION MAY SKIN CONTACT MAY CA IRRITATION SKIN INHALATION RY TRACT IRRITATION EYE CAUSE ESPI USE ALL T RGIC SKIN REACTION MAY CAUSE EYE CONTACT CONTACT WITH EX ES WILL CAUSE RATORY TRACT IRRITATION SKIN IRRITATION INGI ESTION NOT EXISTING CONDIT EVE SKIN AND W EXP ECT ED TO B IONS AGGRAVAT RI ED BY EX ESPIRATORY DISORD CJ E HARMFUL BY INGES TION POSURE RS ECTION 11 FOR ADDITIONAL TOXICO LOGICAL INFORMATION A y N 4 FIRST AID MEASURES INHALATION REMOVE TO FRESH AIR IF SYMPTOMS DEVELOP AND PERSIST GET MEDICAL A
12. T DUST T H O ALI ERGE ENTRAL N IRRI TANT IRRI TANT UTAGEN NO NO NO ECTS RGANS ERVOUS SYSTEM www j 12 ECOLOGICAL INFORMATION ECOLOGICAL INFORMATION NOT AVAILABL CJ dc 13 DISPOSAL CONSIDERATIONS INFORMATION P ROVIDED IS FOR J ECOMMENDED M ETHOD OF DIS DISPOSE EGULATIONS s ti PA HAZARDOUS OF ACCORDING TO E ED im RAL POSAL STATE im UNUSED PRODUCT ONLY AND LOCAL GOVE RNM ENTAL WASTE NUMBER CJ NOT A RCRA HAZARDOUS WASTE ETTE Y 14 TRANSPORT INFORMATION Uzm D EPARTM ENT OF TRANSPORTATION GROUND 49 CFR UO CJ A H U ti WATE PROP HAZA ER SHIP PROPE ESTRICTI HAZARD CLASS OR I p NONE ENTIFICAT PACKING GRO NATIONAL AI RTATION ti ESTRICTI NONE R PER SHIP RD CLASS DENTIFICAT PACKING GRO m TRANSE IMO IMDG ESTRICTI NONE R ER SHIP RD CLASS IDENTIFICAT PACKING GRO MARINE POLL OR DIVISION ti CJ ICAO IATA ED c A 15 REGULATORV INFORMATION UNITED STAT TSCA 8 B ALL COMPON SUBSTANC CONTROL ACT INV TSCA 12 B L c HAZARD
13. ADDITIVES INCLUDING THE FOLLOWING lt 15 00 ZINC ALKYL DITHIOPHOSPHATE Chemical Name PHOSPHORODITHIOIC ACID 0 0 DI C1 14 ALKYL ESTERS ZINC SALT CAS68649423 lt 1 00 NONE NA COMPOSTTION COMMENT All the components of this material are on the Toxic Substances Control Act Chemical Substances Inventory This product fits the ACGIH definition for mineral oil mist The ACGIH TLV is 5 mg m3 the OSHA PEL is 5 mg m3 3 HAZARDS IDENTIFICATION POTENTIAL HEALTH EFFECTS EYE Not expected to cause prolonged or sigmificant eye irritation SKIN Contact with the skin is not expected to cause prolonged or significant irritation Not expected to be harmful to internal organs if absorbed through the skin High Pressure Equipment Information Accidental high velocity injection under the skin of materials of this type may result in serious injury Seek medical attention at once should an accident like this occur The initial wound at the injection site may not appear to be serious at first but if left untreated could result in disfigurement or amputation of the affected part INGESTION Not expected to be harmful if swallowed INHALATION Contains a petroleum based mineral oil May cause respiratory irritation or other pulmonary effects following prolonged or repeated inhalation of oil mist at airborne levels above the recommended mineral oil mist exposure limit 4 FIRST AID MEASURES EYE No specific first aid meas
14. PHYSICAL STATE SEMI SOLID APPEARANCE amp ODOR SLIGHT ODOR CLEAR TO LIGHT YELLOW SMOOTH GREASE ODOR THRESHOLD PPM NOT AVAILABLE VAPOR PRESSURE MMHg NEGLIGIBLE VAPOR DENSITY AIR 1 NOT AVAILABLE VOLATILES NONE EVAPORATION RATE BUTYL ACETATE 1 NOT AVAILABLE BOILING POINT DEG C NOT VOLATILE FREEZING POINT DEG C NON MELTING pH NOT AVAILABLE SPECIFIC GRAVITY 20 DEG C WATER 1 4 DEG C 0 91 8 25 SOLUBILITY IN WATER INSOLUBLE COEFFICIENT OF WATER OIL DIST NOT AVAILABLE VOC NONE DEG C oe BD SECTION 10 STABILITY AND REACTIVITY CHI CONDITIONS OF INSTABILITY EMICAL STABILITY STABLE UN D PY HAZARDOUS POLYMERIZATION WIL INCOMPATIBLE HAZARDOUS D SUBSTANCES ECOMPOSITION PRODUCTS STRONG OXI ROLYSIS L NOT OCCUR DIZING AG S T ER NORMAL CONDITIONS ENTS E HAZARDOUS COMBUSTION PRODUCTS iiiI IA SECTION 11 TOXICOLOGICAL INFORMATION S REPRODUCTIVE ENSITIZATION TO PRODUCT NOT EFF ECTS NOT AVA T ERATOG ENICITY NOT EJ MUTAGI ENICITY NOT AVAILABLE SYNI ERGISTIC MAT ERIALS AVAILABLE
15. Service Call Customer reguires MSDS sheets for Terex Genie Eguipment Tools Needed None Model AWP IWP DPL of servic Tech Tips Safety Rules A Danger Failure to obeythe instructionsand safety rulesin the appropriate Operators Manual and Service Manual for your machine will result in death or serious injury Many of the hazards identified in the operator s manual are also safety hazards when maintenance and repair proceduresare performed Do Not Perform Maintenance Unless gt You are trained and qualified to pefom maintenance on this machine gt You read understand and obey o manufacturer s instructions and safety rules o employer ssafety rulesand worksite regulations o applicable govemmental regulations gt You have the appropnate tools lifting equipment and a suitable workshop The information contained in thistech tip isa Supplement to the service manual Consult the appropnate service manual of your machine for safety rules and hazards TECH TIPS Step 1 Attached is a list of MSDS sheets for the required models Step 2 HAZARD RATING F TROJAN BATTERY COMPANY ts IFOJ LEAD ACID BATTERY H R MATERIAL SAFETY DATA SHEET SECTION 1 CHEMICAL PRODUCT AND COMPANY IDENTIFICATION MANUFACTURER S EMERGENCY NAME TROJAN BATTERY COMPANY TELEPHONE NO CHEMTREC 800 424 9300 ADDRESS OTHER 12380 CLARK ST SANTA FE SPRINGS CA 90670 INFORMATION CALLS 562 946 8381 800 423
16. MATERIALS AS IMPURITIES WHICH ARE REGULATED BY PROPOSITION 65 SEE SECTION X SECTION III PHYSICAL DATA BOILING RANGE ABOVE 900 DEG F VAPOR DENSITY HEAVIER THAN AIR SPECIFIC GRAVITY 970 APPEARANCE amp ODOR RED LUBRICANT LIKE SOLUBILITY IN WATER NO EVAPORATION RATE SLOWER THAN ETHER VOLATILE NEGLIGIBLE SECTION IV FIRE amp EXPLOSION HAZARDS FLASH POINT 475 COCF LEL SEE SECTION II UEL SEE SECTION II EXTINGUISHING MEDIA EXTINGUISH WITH DRY CHEMICAL CO2 WATER SPRAY FOAM SAND OR EARTH AND FOAM MAY CAUSE FROTHING NOTE THAT WHILE WATER FOG EXTINGUISHERS ARE ALSO ACCEPTABLE DO NOT APPLY A DIRECT STREAM OF WATER ON BURNING PRODUCT BECAUSE IT MAY CAUSE SPREADING amp INCREASE FIRE INTENSITY SPECIAL FIRE FIGHTING PROCEDURES WEAR SELF CONTAINED BREATHING APPARATUS AND PROTECTIVE CLOTHING http genie complyplus com MSDS print_bare asp S 520 amp ShowTOC 1 amp ShowHazardR 4 20 2010 C704 NCP 2 BATTERY TERMINAL PROTECTOR by NOCO Page 3 of 5 UNUSUAL HAZARDS NONE KNOWN SECTION V HEALTH HAZARD DATA THRESHOLD LIMIT VALUE SEE SECTION II HAZARDOUS INGREDIENTS ROUTES OF ENTRY INHALATION NO SKIN YES INGESTION YES Bi FFECTS OF OVEREXPOSURE SKIN HORT TERM SKIN CONTACT IS NOT EXPECTED TO CAUSE SKIN IRRITATION ROLONGED OR REPEATED CONTACT MAY CAUSE REDNESS BURNING AND DERMATITIS tg WwW EYE THIS MATERIAL MAY CAUSE EYE IRRITATION DIRECT CONTACT MAY CAUSE BURNI
17. N A RMULA N A AND SYNONYMS 255 3924 248 0585 SENTRY SI AL E F 1000 SENTRY SEAL AND ZIP COD 438 7321 tA lt NS css j SECTION IIHAZARDOUS INGREDIENTS PAINTS PR ES ERVATIVES PIGMENTS CATALYST VE HICLE SOLVENTS TOLUENE CAS ADDITIVE S OT HERS 108 88 3 amp SOLVENTS TLV UNITS 100 PPM ALLOYS AND METALLIC COATINGS oe TLV UNITS BASE METAL ALLOYS METALLIC COATINGS T FILLER METAL PLUS COATING OR CORE FLUX OTH RS HAZARDOUS MIXTURES OF OTHER LIQUIDS SOLIDS OR GASES UNITS oe TLV C i i i I IDIDIDLPICVC AN SECTION IIIPHYSICAL DATA BOILING POINT DEG F 230 DEG F SPECIFIC GRAVITY H20 1 87 VAPOR PRESSURE MMHg 65 DEG F 20 PERCENT VOLATILE BY VOLUM tA oe lt VAPOR DENSITY AIR 1 3 2 EVAPORATION RATE 1 2 4 SOLUBILITY IN WATER NIL APPEARANCE AND ODOR AROMATIC ODOR HEAVY THICK PASTE J cc AN SECTION IV FIRE AND EXPLOSION HAZARD DATA FLASH POINT METHOD USED 45 DEG F CLOSED FLAMMABLE LIMITS 43 bi ti UEI EXTINGUISHING ME
18. 6569 PERSON RESPONSIBLE FOR PREPARATION Ismael Pedroza Jr Revision Date February 19 2006 SECTION 2 COMPOSITION INFORMATION ON INGREDIENTS PRINCIPAL HAZARDOUS C A S COMPONENT S Hazard Category ACGIH OSHA chemical amp common name s TLV PEL TWA 7439 92 1 Lead Lead Oxide Lead Sulfate Acute Chronic 60 97 0 05 mg m 0 05 mg m 7440 36 0 Antimony 1 5 4 0 5 mg m 0 5 mg m 7440 38 2 Arsenic Acute Chronic 0 01 mg m 0 01mg m 7664 93 9 Sulfuric Acid Reactive Oxidizer 10 38 1 0 mg m 1 0 mg m Battery Electrolyte Acute Chronic 7440 70 2 Calcium lt 0 15 Not established Not established j l gt ij 2 NOTE PEL s for individual states may differ from OSHA PEL s Check with local authorities for the applicable state PEL s OSHA Occupational Safety and Health Administration ACGIH American Conference of Governmental Industrial Hygienists NIOSH National Institute for Occupational Safety and Health COMMON NAME Used on label Trade Name 8 Synonyms Lead Acid Storage Battery Chemical Family Toxic and Corrosive Material Mixture Chemical Name Lead Acid Storage Battery Formula Lead and Acid electrolyte Signs and 1 Acute Do not open battery Avoid contact with internal components Internal components include lead and liquid electrolyte Symptoms of Hazards Electrolyte Electrolyte is corrosive and contact may cause skin irritation and chemical burns Electrolyte causes Exposure se
19. in soil resulting in little mobility Lead may be immobilized by ion exchange with hydrous oxides or clays or by chelation with humic or fulvic acids in the soil Lead when in the dissolved phase is bio accumulated by plants and animals both aquatic and terrestrial SECTION 13 DISPOSAL CONSIDERATIONS Waste Disposal Lead acid batteries are completely recyclable Return whole scrap batteries to distributor manufacturer or lead smelter for recycling Methods For information on returning batteries to Trojan Battery Company for recycling call 800 423 6569 For neutralized spills place residue in acid resistant containers with sorbent material sand or earth and dispose of in accordance with local state and federal regulations for acid and lead compounds Contact local and or state environmental officials regarding disposal information SECTION 14 TRANSPORT INFORMATION U S DOT PROPER SHIPPING NAME Batteries wet filled with acid U S DOT HAZARD CLASS 8 U S DOT ID NUMBER UN 2794 U S DOT PACKING GROUP III U S DOT LABEL Corrosive IMO PROPER SHIPPING NAME Batteries wet filled with acid IMO REGULATION PAGE NUMBER 8120 IMO U N CLASS 8 IMO U N NUMBER UN 2794 IMO PACKING GROUP III IMO LABEL Corrosive IMO VESSEL STOWAGE A IATA PROPER SHIPPING NAME Batteries wet filled with acid IATA U N CLASS 8 IATA U N NUMBER UN 2794 IATA PACKING GROUP III IATA LABEL Corrosive SECTION 15 REGUL
20. 2952 CPS255678 CPS255679 SYNONYM CHEVRON Hydraulic Oil AW MV ISO 100 CHEVRON Hydraulic 011 AW MV ISO 32 CHEVRON Hydraulic Oil AW MV ISO 46 CHEVRON Hydraulic Oil AW MV ISO 68 CHEVRON Rykon Premium Oil ISO 100 CHEVRON Rykon Premium Oil ISO 32 CHEVRON Rykon Premium Oil ISO 46 CHEVRON Rykon Premium Oil ISO 68 CHEVRON Rykon Premium Oil MV COMPANY IDENTIFICATION EMERGENCY TELEPHONE NUMBERS Chevron Products Company HEALTH 24 hr 800 231 0623 or Global Lubricants 510 231 0623 International 555 Market St TRANSPORTATION 24 hr CHEMTREC Room 803 800 424 9300 or 703 527 3887 San Francisco CA 94105 2870 Emergency Information Centers are located in U S A Int l collect calls accepted PRODUCT INFORMATION MSDS Requests 800 414 MSDS or 800 414 6737 Environmental Safety amp Health Info 415 894 0703 Product Information 800 582 3835 2 COMPOSITION INFORMATION ON INGREDIENTS 100 0 CHEVRON Rykon Premium Oil CONTAINING COMPONENTS AMOUNT LIMIT OTY AGENCY TYPE LUBRICATING BASE OIL CONTAINING ONE OR MORE OF THE FOLLOWING gt 85 00 HYDROTREATED DIST HVY PARA Chemical Name DISTILLATES HYDROTREATED HEAVY PARAFFINIC CAS64742547 gt 85 00 5 mg m3 mist ACGIH TWA 10 mg m3 mist ACGIH STEL 5 mg m3 mist OSHA PEL DISTILLATES HYDROTREATED Chemical Name DISTILLATES PETROLEUM HYDROTREATED LIGHT PARAFFINIC CAS64742558 5 mg m3 mist ACGIH TWA 10 mg m3 mist ACGIH STEL 5 mg m3 mist OSHA PEL
21. ATORY INFORMATION U S Hazardous Under Hazard Communication Standard Lead YES Sulfuric Acid YES Antimony YES Arsenic YES Ingredients Listed on TSCA Inventory YES CERCLA Section 304 Hazardous Substances Lead YES RQ NA Sulfuric Acid YES RA 1000 pounds Antimony YES RQ 5000 pounds Arsenic YES RQ 1 pound Reporting not required when diameter of the pieces of solid metal released is equal to or exceeds 100 micrometers EPCRA Section 302 Extremely Hazardous Substance Sulfuric acid YES EPCRA Section 313 Toxic Release Inventory Lead CAS NO 7439 92 1 Sulfuric Acid CAS NO 7664 93 9 Antimony CAS NO 7440 36 0 Arsenic CAS NO 7440 38 2 SECTION 16 OTHER INFORMATION THE INFORMATION ABOVE IS BELIEVED TO BE ACCURATE AND REPRESENTS THE BEST INFORMATION CURRENTLY AVAILABLE TO US HOWEVER TROJAN BATTERY COMPANY MAKES NO WARRANTY OF MERCHANTABILITY OR ANY OTHER WARRANTY EXPRESS OR IMPLIED WITH RESPECT TO SUCH INFORMATION AND WE ASSUME NO LIABILITY RESULTING FROM ITS USE USERS SHOULD MAKE THEIR OWN INVESTIGATIONS TO DETERMINE THE SUITABILITY OF THE INFORMATION FOR THEIR PARTICULAR PURPOSES ALTHOUGH REASONABLE PRECAUTIONS HAVE BEEN TAKEN IN THE PREPARATION OF THE DATA CONTAINED HEREIN IT IS OFFERED SOLELY FOR YOUR INFORMATION CONSIDERATION AND INVESTIGATION THIS MATERIAL SAFETY DATA SHEET PROVIDES GUIDELINES FOR THE SAFE HANDLING AND USE OF THIS PRODUCT IT DOES NOT AND CANNOT ADVISE ON ALL POSSIBLE SI
22. COMMENDATIONS SET FORTH HEREIN ARE BELIEVED TO E HEREOF NYE BE ACCURATE AS OF THE DAT WARRANTY WITH RESPECT THERETO AND LUB DISCLAIMS ALL RICANTS INC MA LIAI BILITY WITH R KES NO ESP ECT THEREON Hosted as Genie Industries Inc Comply Plus Copyright IHS Inc 1999 2009 All Rights Reserved U S DE PARTM ENT OF LABO OCC FORM AP ERIA UPATIONA SAFETY AND PROVI D OMB NO R HEALTH ADMINISTRATION 44 R1387 1 SAE ETY DATA SH UIR ED UND ER USDL SAF EET 7 T TY AND H EALTH R 01 07 05 PBUILDING AND SHIPB REAKING 29 CFR 1915 1916 EGULATIONS FOR SHIP REPAIRING 1917 A SECTION MANUFACTUR A 1 I DDRESS N 963 E RVING T ER S NAME UMB RVING BLV EXAS 75060 BJ O RGANIC PRODUCTS COMPANY ERS STR D T E T CITY STATE HONE N UMB ER FOR INFORMATION 972 EMERGENCY T ELE PHONE NUMB ER EM TSI T DI F my G Hd MICA L 800 USA NAME 813 PAINT UN1263 TRADE NAME CHI ta FO AND SYNONYMS MICAL FAMILV
23. DIA CARBON DIOXIDE OR DRY CHEMICAL REGULAR FOAM SPECIAL FIRE FIGHTING PROCEDURES WEAR SELF CONTAINED BREATHING APPARATUS WITH A FULL FACE PIECE WITH PRESSURE ON DEMAND UNUSUAL FIRE AND EXPLOSION HAZARDS KEEP AWAY FROM PILOT LIGHT LIGHTS FLAMES SPARKS HEATERS SMOKERS wr csr i SECTION V HEALTH HAZARD DATA THRESHOLD LIMIT VALUE 100 PPM EFFECTS OF OVEREXPOSURE FATIGUE HEADAC SEVERE IRRITATION EMERGENCY AND FIRST AID PROCEDURES REMOVE TO FRESH AIR WASH AND FLUSH AFFECTED A FLUSH EYES DO ty O AE lt zj UNCONSCIOUSNESS NAUSEA IF SWALLOW HE MENTAL CONFUSION STRONG DEGREASER OF SKIN EYE E1 D VOMITING PU EAS WITH WATER AND SOAP NOT INDUCE VOMITING IF SWALLOWED KEEP WARM AND QUIET T EDICAL HELP II DD SECTION VI REACTIVITY DATA STABILITY UNSTABLE STABLE X CONDITIONS TO AVOID AVOID HEAT SPARKS AND FIRES INCOMPATABILITY HAZARDOUS DECOM HAZAR MAY OCCUR WILL NOT OCCUR DOUS POLYM MATERIALS TO AVOID STRONG OXIDIZING AGENTS POSITION PRODUCTS RIZATION X I CONDITIONS TO AVOID FC LL ee emata SECTION VII SPILL OR LEAK PROCEDURES STEPS ELIMI TO BE TAK
24. E PRESENCE OF AIR MAY YIELD MAJOR AMOUNTS OF OXIDES OF CARBON AND MINOR AMOUNTS OF OXIDES OF SULFUR AND NITROGEN HAZARDOUS POLYMERIZATION WILL NOT OCCUR SECTION VII SPILL OR LEAKAGE PROCEDURES STEPS TO BE TAKEN IN CASE MATERIAL IS RELEASED OR SPILLED WASH DOWN ANY EXCESS LIQUID WITH WATER WASTE DISPOSAL METHOD DISPOSE OF PRODUCT IN ACCORDANCE WITH LOCAL COUNTY STATE AND FEDERAL REGULATIONS SECTION VIII SPECIAL PROTECTION INFORMATION RESPIRATORY PROTECTION NONE PROTECTIVE GLOVES RECOMMENDED FOR PROLONGED OR REPEATED CONTACT EYE PROTECTION SAFETY GLASSES VENTILATION NONE OTHER PROTECTIVE EQUIPMENT NONE SECTION IX SPECIAL PRECAUTIONS PRECAUTIONS TO BE TAKEN IN HANDLING AND STORAGE DO NOT STORE NEAR INCOMPATIBLE SUBSTANCES SEE SECTION VI OTHER PRECAUTIONS NONE PURSUANT TO PROPOSITION 65 PROPOSITION 65 APPLIES TO LIST OF CHEMICALS NAMED BY THE GOVERNOR OF CALIFORNIA AS CARCINOGENS OR REPRODUCTIVE TOXINS WARNING REQUIREMENTS FOR SPECIFIC CHEMICALS TAKE EFFECT ONE YEAR AFTER THEY ARE ADDED TO THE GOVERNOR S LIST OTHER CHEMICALS ALREADY ADDED TO THE GOVERNOR S LIST WILL BE REGULATED LATER UNDER PROPOSITION 65 http genie complyplus com MSDS print_bare asp S 520 amp ShowTOC 1 amp ShowHazardR Page 4 of 5 4 20 2010 C704 NCP 2 BATTERY TERMINAL PROTECTOR by NOCO Page 5 of 5 SECTION X HAZARDOUS MATERIAL IDENTIFICATION COMMUNICATION OF PHYSICAL PROPERLY HEALT
25. FLASH POINT gt 330 F 165 C COC AUTOIGNITION TEMPERATURE Not Available UNUSUAL FIRE AND EXPLOSION HAZARDS None expected EXTINGUISHING MEDIA Foam dry chemical carbon dioxide water spray SPECIAL FIRE FIGHTING PROCEDURES Use air supplied breathing equipment for enclosed areas Water or foam may cause frothing which can be violent especially if sprayed into containers of hot burning liquid 10 SPILL LEAK PROCEDURES Recover free product Contain any spill to prevent entry to sewers or streams Add sand earth or suitable absorbent to spill area Transfer to closed container 11 WASTE DISPOSAL METHODS Dispose of in accordance with local state and federal laws BOELUBE 70200 MSDS 12 PRECAUTIONS TO BE TAKEN IN HANDLING AND STORING Store in closed containers away from heat or open flames Do not store with oxidizing agents Not for internal use Empty containers may contain product residue Do not cut heat or weld on or around empty containers Avoid freezing temperatures 13 TOXICOLOGICAL INFORMATION ACUTE TOXICITY Oral LDso greater than 20 g kg rats SKIN IRRITATION Non irritant rabbits EYE IRRITATION Non irritant rabbits SKIN SENSITIZATION Not a sensitizer MUTAGENICITY Ames test Negative Non mutagenic 14 ECOLOGICAL INFORMATION BIODEGRADATION Biodegradable expected to exhibit greater than 70 degradation within 28 days in the Modified Sturm test ECOTOXICITY Not determined However this pro
26. H AND SAFETY INFORMATION IS A KEY FACTOR IN OUR PRODUCT SAFETY PROGRAM WITH THIS INFORMATION YOU CAN BETTER FULFILL YOUR OBLIGATION TO EDUCATE EXPOSED PERSONNEL IN THE PROPER HANDLING TECHNIQUES REQUIRED TO MAINTAIN SAFETY IN THE WORKPLACE LISTED IN THIS SECTION IS NPCA HMIS CLASSIFICATION FOR THIS PRODUCT HMIS CLASSIFICATION CODE HEALTH 1 SLIGHT HAZARD FLAMMABILITY 1 SLIGHT HAZARD REACTIVITY 0 LEAST HAZARD PERSONAL PROTECTION B GLASSES AND GLOVES THE ABOVE INFORMATION PERTAINS TO THIS PRODUCT AS CURRENTLY FORMULATED AND IS BASED ON THE INFORMATION AVAILABLE AT THIS TIME ADDITION OF REDUCERS OR OTHER ADDITIVES TO THIS PRODUCT MAY SUBSTANTIALLY AFTER THE COMPOSITION AND HAZARDS OF THE PRODUCT SINCE CONDITIONS OF USE ARE OUTSIDE OUR CONTROL WE MAKE NO WARRANTIES EXPRESS OR IMPLIED AND ASSUME NO LIABILITY IN CONNECTION WITH ANY USE OF THIS INFORMATION Hosted as Genie Industries Inc Comply Plus Copyright IHS Inc 1999 2009 All Rights Reserved http genie complyplus com MSDS print_bare asp S 520 amp ShowTOC 1 amp ShowHazardR 4 20 2010 NYOGEL 760G PRODUCT 760G REVISION DATI T Pie 2003 02 10 AN SECTION 1 PRODUCT AND COMPANY IDENTIFICATION MANUFACTURER NYE LUBRICANTS INC 12 HOWLAND ROAD FAIRHAVEN MA 02719 U S A MANUFACTURER EMERGENCY PHONE NUMBER CHEMTREC
27. IABLE HOWEVER HENKEL CORPORATION DOES NOT ASSUME PONSIBILITY FOR ANY RESULTS OBTAINED BY PERSONS OVER WHOSE METHODS NKEL ORPORATION HAS NO CONTROL IT IS THE USER S RESPONSIBILITY TO TERMINE THE TABILITY OF HENKEL S PRODUCTS OR ANY PRODUCTION METHODS MENTIONED PHMmUANAUADAWHD ABLE HE PROTECTION OF PROP I A PARTICULAR PURPOSE AND TO ADOPT SUCH PRECAUTIONS AS MAY BE S L RTY AND PERSONS AGAINST ANY HAZARDS THAT MAY E NVOLVED IN THE HANDLING AND USE OF ANY OF HENKEL CORPORATION S RODUCTS IN IGHT OF THE FOREGOING HENKEL CORPORATION SPECIFICALLY DISCLAIMS ALL ARRANTIES EXPRESS OR IMPLIED INCLUDING WARRANTIES OF MERCHANTABILITY AND FITNESS FOR A PARTICULAR PURPOSE ARISING FROM SALE OR USE OF HENKEL CORPORATION S PRODUCTS HENKEL CORPORATION FURTHER DISCLAIMS ANY LIABILITY FOR CONSEQ PROFITS T Ser UH WH T G ENTIAL OR INCID ligi NTAL DAMAGES OF ANY KIND INCLUDING LOST C704 NCP 2 BATTERY TERMINAL PROTECTOR by NOCO Page 1 of 5 Genie Industries Inc Redmond C704 NCP 2 BATTERY TERMINAL PROTECTOR NOCO FileName Language Internal ID Revision Date 000009 English 6 7 2005 Table Of Contents SECTION I PRODUCT 8 COMPANY IDENTIFICATION SECTION II HA
28. MAV CAUSE IRRITATION ON PROLONGED OR REPEATED CONTACT INHALATION OIL MIST AND VAPORS AT HIGH PASSAGES U PERATURES MAY IRRITATE RESPIRATORY INGESTION MAY CAUSE GASTRO INTESTINAL IRRITATION EFFECTS OF CHRONIC EXPOSURE SEE EFFECTS OF ACUTE EXPOSURE EJ CARCINOGENIC EFFECTS IARC NTP AND OSHA DO NOT LIST THIS PRODUCT OR ITS INGREDIENTS AS CARCINOGENS T lt ti EDICAL CONDITIONS AGGRAVATED BY EXPOSURE NONE KNOWN TARGET ORGANS RESPIRATORY PASSAGES AT HIGH TEMPERATURES EYES SKIN 2 LL m SECTION 4 FIRST AID MEASURES KIN CONTACT EMOVE CONTAMINATED CLOTHING ASH THOROUGHLY WITH SOAP AND WATER EEK MEDICAL ATTENTION IF IRRITATION PERSISTS EYE CONTACT FLUSH WITH WATER FOR AT LEAST 15 MINUTES OBTAIN IMMEDIATE MEDICAL ATTENTION T INHALATION REMOVE VICTIM TO FRESH AIR IF NOT BREATHING OUALIFIED PERSONNEL SHOULD ADMINISTER ARTIFICIAL RESPIRATION GET MEDICAL ATTENTION T IF BREATHING IS DIFFICULT ADMINISTER OXYGEN INGESTION OBTAIN IMMEDIATE MEDICAL ATTENTION DO NOT INDUCE VOMITING UNLESS DIRECTED TO DO 50 BY A PHYSICIAN
29. NG TEARING AND REDNESS INHALATION THIS PRODUCT HAS LOW VOLATILITV AND SO IS NOT EXPECTED TO CAUSE RESPIRATORX TRACT IRRITATION INGESTION INGESTION OF THIS MATERIAL MAY CAUSE IRRITATION OF THE DIGESTIVE TRACT Q HRONIC CANCER NO INFORMATION FOUND IN STANDARD REFERENCES EMERGENCY AND FIRST AID PROCEDURES INGESTION IF SWALLOWED DO NO INDUCE VOMITING GIVE 2 OR 3 CUPS OF MILK OR WATER TO DRINK SEEK MEDICAL ATTENTION INHALATION IF IRRITATION OF NOSE OR THROAT DEVELOPS MOVE AWAY FROM SOURCE OF EXPOSURE AND INTO FRESH AIR EYE CONTACT FOR DIRECT CONTACT FLUSH THE AFFECTED EYE S WITH GENTLE STREAM OF CLEAN WATER FOR AT LEAST 15 MINUTES IF IRRITATION PERSISTS SEEK MEDICAL ATTENTION SKIN CONTACT DO NOT USE GASOLINES THINNERS OR SOLVENTS TO REMOVE PRODUCTS FROM SKIN WIPE MATERIAL FROM SKIN AND REMOVE CONTAMINATED CLOTHING CLEANSE AFFECTED AREA S THOROUGHLY BY WASHING WITH MILD SOAP AND WATER AND IF NECESSARY A WATERLESS SKIN CLEANER IF IRRITATION OR REDNESS DEVELOPS AND PERSISTS SEEK MEDICAL ATTENTIO SECTION VI REACTIVITY DATA http genie complyplus com MSDS print_bare asp S 520 amp ShowTOC 1 amp ShowHazardR 4 20 2010 C704 NCP 2 BATTERY TERMINAL PROTECTOR by NOCO STABILITY STABLE INCOMPATIBILITY AVOID CONTACT WITH STRONG OXIDIZING AGENTS EXTENDED EXPOSURE TO HIGH TEMPERATURES MAY CAUSE DECOMPOSITION HAZARDOUS DECOMPOSITION PRODUCTS THERMAL DECOMPOSITION IN TH
30. ONS TO AVOID SEE HANDLING AND STORAGE SECTION 7 AND INCOMPATABILTY SECTION 10 C IN 11 TOXICOLOGICAL INFORMATION EN E PRODUCT TOXICITY DATA ACUTE ORAL LD50 GREATER THAN 10 000 MG KG ACUTE DERMAL LD50 GREATER THAN 5000 MG KG CARCINOGEN STATUS HAZARDOUS COMPONENTS NTP CARCINOG CARCINOGEN POLYGLYCOL DIMETHACRYLATE NO 25852 47 5 POLYGLYCOL OLEATE NO 9004 96 0 SACCHARIN NO 81 07 2 RAT RABBIT IARC CARCINOGEN OSHA SILICA AMORP HO US FUMI CRYSTALLINE E 112945 52 5 UM 80 ENE 15 9 YDROP p ROPYLENE T ROXIDE GLYCOL 57 55 6 LITERATURE R EF ER ENC HAZARDOUS COM POLYGLYCOL DIME PONENTS THACRYLATE 25852 47 5 POLYGLYCOL OLE 9004 96 0 SACCHARIN 81 07 2 SILICA AMORP HO FUM US CRYSTALLINE E 112945 52 5 CUM COR 80 ENE HYD ROSIVE 15 9 ROP PROPYLENE T ROXIDE GLYCOL 57 55 6 NO NO ED TARGET ORGAN amp OTH NO NO NO ER HEALTH EFF EALTH EFF ECTS TARG T LERG NO TARGI NUISANCI N RRITANT IRRITANT ET ORGANS i
31. OPEN WATERS T T AN UP METHODS QAK UP WITH INERT ABSORBENT STORE IN A PARTLY FILLED CLOSED T I AINER L DISPOSAL 7 HANDLING AND STORAGE HANDLING AVOID CONTACT WITH EYES SKIN AND CLOTHING AVOID BREATHING VAPOR AND MIST WASH THOROUGHLY AFTER HANDLING STORAGE FOR SAFE STORAGE STORE AT OR BELOW 38 DEG C 100 DEG F KEEP IN A COOL WELL VENTILATED AREA AWAY FROM HEAT SPARKS AND OPEN FLAME KEEP CONTAINER TIGHTLY CLOSED UNTIL READY FOR USE T INCOMPATIBL PRODUCTS REFER TO SECTION 10 FOR INFORMATION ON PRODUCT SHELF LIFE CONTACT HENKEL CUSTOMER SERVICE AT 800 243 4874 8 EXPOSURE CONTROLS PERSONAL PROTECTION ENGINEERING CONTROLS NO SPECIFIC VENTILATION REQUIREM STILL BE REQUIRED IF CONCENTRATIONS EXCE T INTS NOTED BUT FORCED s NTILATION MAY T T D OCCUPATIONAL EXPOSURE LIMITS RESPIRATORY PROTECTION USE NIOSH APPROVED RESPIRATOR IF THERE IS POTENTIAL TO EXCEED EXPOSURE LIMIT S AJ SKIN PROTECTION USE IMPERMEABLE GLOVES AND PROTECTIVE CLOTHING AS NE SKIN CONTACT NEOPRENE GLOVES BUTYL RUBBER GLOVES NATURAL RUBBER GLOVES
32. R TKR EER KR RRR KE EEE ER RII Rok THIS IS THE LAST PAGE OF THIS MSDS LOCTITE R MAT A RIAL SAFETY DATA SHEET HENKEL H ECHNOLOGIES REVISION DATE 04 12 2006 ISSUE DATE 04 12 2006 A 1 CHEMICAL PRODUCT AND COMPANY IDENTIFICATION PRODUCT NAME LOCTITE R 242 R THREADLOCKER MEDIUM STRENGTH ITEM NO 24221 FU RODUCT TXPE ANAEROBIC SEALANT A EGION UNITED STATES COMPANY ADDRESS HENKEL CORPORATION 1001 TROUT BROOK CROSSING ROCKY HILL CONNECTICUT 06067 CONTACT INFORMATION TELEPHONE 860 571 5100 EMERGENCY TELEPHONE 860 571 5100 INTERNET WWW LOCTITE COM 483 2 COMPOSITION INFORMATION ON INGREDIENTS HAZARDOUS COMPONENTS ACGIH TLV OSHA PEL OTHER POLYGLYCOL DIMETHACRYLATE 60 100 NONE NONE NONE 25852 47 5 POLYGLYCOL OLEATE 10 30 NONE NONE NONE 9004 96 0 SACCHARIN 15 NONE NONE NONE 81 07 2 SILICA AMORPHOUS FUMED 1 5 6 MG M3 TWA 10 MG M3 TWA 3 MG M3 TWA CRYSTALLINE FREE RESPIRABLE 112945 52 5 DUST CUMENE HYDROPEROXIDE l 5 NONE NONE 1 PPM PROPYL ENE MG M3 57 55 6 WEEL T GLYCOL NON NONE
33. Sect 8 a 05 CA Prop 65 Repro Tox 15 ACGIH STEL 26 TSCA Sect 8 d 06 IARC Group 1 16 ACGIH Calc TLV 27 TSCA Sect 4 a 07 IARC Group 2A 17 OSHA PEL 28 Canadian WHMIS 08 IARC Group 2B 18 DOT Marine Pollutant 29 OSHA CEILING 09 SARA 302 304 19 Chevron TWA 30 Chevron STEL 10 PA RTK 20 EPA Carcinogen The following components of this material are found on the regulatory lists indicated DISTILLATES HYDROTREATED HEAVY PARAFFINIC is found on lists 14 15 17 DISTILLATES PETROLEUM HYDROTREATED LIGHT PARAFFINIC is found on lists 02 14 15 17 PHOSPHORODITHIOIC ACID 0 0 DI C1 14 ALKYL ESTERS ZINC SALTS is found on lists 01 11 EU RISK AND SAFETY LABEL PHRASES May cause long term adverse effects in the aquatic environment NEW JERSEY RTK CLASSIFICATION Under the New Jersey Right to Know Act L 1983 Chapter 315 N J S A 34 5A 1 et seq the product is to be identified as follows PETROLEUM OIL WHMIS CLASSIFICATION This product is not considered a controlled product according to the criteria of the Canadian Controlled Products Regulations 16 OTHER INFORMATION NFPA RATINGS Health 1 Flammability 1 Reactivity 0 HMIS RATINGS Health 1 Flammability 1 Reactivity 0 0 Least 1 Slight 2 Moderate 3 High 4 Extreme PPE Personal Protection Equipment Index recommendation Chronic Effect Indicator These values are obtained using the guidelines or published evaluations prepared by the National Fire Protection Assoc
34. TTENTION SKIN CONTACT WASH WITH SOAP AND WATER REMOVE CONTAMINATED CLOTHING AND SHOES WASH CLOTHING BEFORE REUSE GET MEDICAL ATTENTION IF SYMPTOMS OCCUR T EYE CONTACT FLUSH WITH COPIOUS AMOUNTS OF WATER PREFERABLY LUKEWARM WATER FOR AT LEAST 15 MINUTES HOLDING EYELIDS OPEN ALL THE TIME GET MEDICAL ATTENTION INGESTION DO NOT INDUCE VOMITING KEEP INDIVIDUAL CALM OBTAIN MEDICAL ATTENTION I A 5 FIREFIGHTING MEASURES FLASH POINT GREATER THAN 93 DEG C 200 DEG F TAGLIABUE CLOSED CUP T AUTOIGNITION TEMP T RATURE NOT AVAILABL tA FLAMMAB FLAMMAB oe 2 6 PROPYLENE GLYCOL 12 5 PROPYLENE GLYCOL E EXPLOSIVE LIMITS LOWER E EXPLOSIVE LIMITS UPPER de EXTINGUISHING M LI LI DIA FOAM DRY CHEMICAL OR CARBON DIOXIDE SPECIAL FIRE FIGHTING PROCEDURES NON EJ UNUSUAL FIRE OR EXPLOSION HAZARDS NON tA HAZARDOUS COMBUSTION PRODUCTS OXIDES OF CARBON OXIDES OF SULFUR OXIDES OF NITROGEN IRRITATING ORGANIC VAPORS OIRA 6 ACCIDENTAL RELEASE MEASURES ENVIRONMENTAL PRECAUTIONS PREVENT PRODUCT FROM ENTERING DRAINS OR
35. TUATIONS THEREFORE YOUR SPECIFIC USE OF THIS PRODUCT SHOULD BE EVALUATED TO DETERMINE IF ADDITIONAL PRECAUTIONS ARE REQUIRED Form MSDS Rev 2 19 07 MATERIAL SAFETY DATA SHEET Emergency Phone 631 205 9700 Date Prepared 03 30 05 Chemtrec 800 424 9300 Supplier The Orelube Corporation 20 Sawgrass Drive Bellport NY 11713 1 PRODUCT IDENTIFICATION NFPA PRODUCT NAME BOELUBE 70200 Health 1 SYNONYMS 70206 16B4F Flammability 1 CHEMICAL FAMILY Proprietary Reactivity 0 PRODUCT USE Metalworking Lubricant 2 PRECAUTIONARY INFORMATION This product is not known or expected to be hazardous 3 HAZARDOUS INGREDIENTS IDENTITY INFORMATION COMPONENTS OSHA ACGIH ACGIH CAS PEL TLV STEL This Material Safety Data Sheet has been prepared under guidelines in OSHA Hazard Communication Standard 29 CFR 1910 1200 No known hazardous ingredients present in product Exposure limits not established None of the components of this product at concentrations greater than or equal to 0 1 are listed as a carcinogen or potential carcinogen by NTP IARC and OSHA 4 HEALTH HAZARD DATA EYE Excessive exposure may result in transient irritation SKIN Excessive exposure may result in transient irritation in some individuals INGESTION Not an expected route of exposure Non toxic by oral dosing in rats INHALATION Not an expected route of exposure SYMPTOMS OF EXPOSURE No persistent adverse health effects are known to be associated wi
36. UN APPRO OR SC A SPILL He wD zj ep P RAP AR RIATE IL EANED P ROTEC TIVE UIPMENT p E U E UE SPILLED MATERIAL EA AE TER MA TERIAL PIC WI W W T RANSFER TO AN A PP ROVED CONTAINI m Bi OBSERVE PR ECA FOL LOW APPLICABLE UTION S E OSHA 2 ROM OTHE S R 9 CF AND OTH K UP IS COMPLE R FOR DISPOSAL OR R ECTIONS R 1910 120 ER WAT ERWAYS TE ECOV ERY STATE AND LOCAL REGULATIONS T A SECTION 7 HANDLING AND STORAGE HANDLING PROCEDURES AND EOUIPMENT WASH THOROUGHLY AFTER USING PARTICULARLY BEFORE EATING OR SMOKING DO NOT EAT DRINK OR SMOKE IN HANDLING AREA AVOID CONTAMINATION OF CIGARETTES OR OTHER TOBACCO PRODUCTS LAUNDER CONTAMINATED CLOTHING PRIOR TO REUSE USERS SHOULD BE ALERT TO THE POSSIBILITY THAT VERY SMALL PERCENTAGES OF THE POPULATION MAY DISPLAY UNEXPECTED ALLERGIC REACTIONS TO OTHERWISE INNOCUOUS INDUSTRIAL LUBRICANTS AND RAW MATERIALS STORAGE REQUIREMENTS STORE AWAY FROM INCOMPATIBLE MAT DO NOT STORE IN OPEN OR UNLABELL
37. ZARDOUS INGREDIENTS SECTION III PHYSICAL DATA SECTION IV FIRE 8 EXPLOSION HAZARDS SECTION V HEALTH HAZARD DATA SECTION VI REACTIVITY DATA SECTION VII SPILL OR LEAKAGE PROCEDURES SECTION VIII SPECIAL PROTECTION INFORMATION SECTION IX SPECIAL PRECAUTIONS SECTION X HAZARDOUS MATERIAL IDENTIFICATION MSDS State Health Flammability Reactivity Other MSDS MATERIAL SAFETY DATA SHEET 900701 SECTION I PRODUCT amp COMPANY IDENTIFICATION PRODUCT NUMBER 900701 PRODUCT NAME C704 NOCO R NCP 2 BATTERY TERMINAL PROTECTOR HMIS CODES HEALTH 1 FLAMMABILITY 1 REACTIVITY 0 IANUFACTURER S NAME THE NOCO R COMPANY CLEVELAND OH 44122 EMERGENCY TELEPHONE NO 800 424 9300 INFORMATION TELEPHONE NO 800 456 6626 DATE OF PREPARATION 07 JUNE 05 http genie complyplus com MSDS print_bare asp S 520 amp ShowTOC 1 amp ShowHazardR 4 20 2010 C704 NCP 2 BATTERY TERMINAL PROTECTOR by NOCO Page 2 of 5 SECTION II HAZARDOUS INGREDIENTS BY WT CAS NO INGREDIENT PEL PPM TLV PPM TLV MG M3 UEL 90 PROPRIETARY MINERAL OIL NONE NONE 5 0 N A SARA HAZARD NONE NOT LISTED TITLE III SECTION 313 CARCINOGENICITY THIS PRODUCT IS NOT CONSIDERED A SUSPECTED ANIMAL CARCINOGEN BY THE NATIONAL TOXICITY PROGRAM THE INTERNATIONAL AGENCY FOR RESEARCH ON CANCER OR THE OCCUPATIONAL SAFETY AND HEALTH ADMINISTRATION PURSUANT TO PROPOSITION 65 CERTAIN RAW MATERIALS USED IN MAKING THIS PRODUCT MAY CONTAIN SMALL AMOUNTS OF
38. duct is not expected to cause harm to aquatic organisms 15 REGULATORY INFORMATION This product does not contain a SARA Title 3 Section 313 40 CFR 372 reportable chemical This product is not considered a controlled product according to the criteria of the Canadian Controlled Products Regulations CALIFORNIA PROPOSITION 65 No reportable components INVENTORY STATUS This product contains only chemicals that are currently listed on USA TSCA Australia AICS EU EINECS Canada DSL Korea ECL Japan ENCS Philippines PICCS and China SEPA 16 TRANSPORTATION INFORMATION Not regulated by US DOT IMO or ICAO 17 OTHER INFORMATION This information is furnished without warranty expressed or implied except that it is accurate to the best knowledge of The Orelube Corporation The Orelube Corporation assumes no legal responsibility for the use or reliance upon this data Please note that the chemical identity of some or all of the ingredients that may or may not be listed herein is confidential business information and is being withheld as permitted by 29 CFR 1910 1200 and various State Right to Know Laws BOELUBE 70200 MSDS jit 2 SS Chevron Lubricants MATERIAL SAFETY DATA SHEET Chevron Rykon MV and Rykon Premium Hydraulic Oils AIl Grades MSDS 7341 Revision 0 Revision Date 01 06 99 1 CHEMICAL PRODUCT AND COMPANY IDENTIFICATION CHEVRON Rykon Premium Oil PRODUCT NUMBER S CPS231015 CPS232950 CPS23
39. eporting and responding to larger releases 7 HANDLING AND STORAGE DO NOT USE IN HIGH PRESSURE SYSTEMS in the vicinity of flames sparks and hot surfaces Use only in well ventilated areas Keep container closed Drum is not designed to contain pressure Do not use pressure to empty drum or drum may rupture with explosive force Empty containers retain product residue solid liquid and or vapor and can be dangerous Do not pressurize cut weld braze solder drill grind or expose such containers to heat flame sparks static electricity or other sources of ignition They may explode and cause injury or death Empty drums should be completely drained properly bunged and promptly returned to a drum reconditioner or properly disposed of Avoid contaminating soil or releasing this material into sewage and drainage systems and bodies of water 8 EXPOSURE CONTROLS PERSONAL PROTECTION GENERAL CONSIDERATIONS Consider the potential hazards of this material see Section 3 applicable exposure limits job activities and other substances in the work place when designing engineering controls and selecting personal protective equipment If engineering controls or work practices are not adequate to prevent exposure to harmful levels of this material the personal protective equipment listed below is recommended The user should read and understand all instructions and limitations supplied with the equipment since protection is
40. for disposal Dispose of contaminated material in accordance with applicable local state and federal regulations Sodium bicarbonate soda ash sand lime or other neutralizing agent should be kept on site for spill remediation Personal Precautions Acid resistant aprons boots and protective clothing ANSI approved safety glasses with side shields face shield recommended Ventilate enclosed areas Environmental Precautions Lead and its compounds and sulfuric acid can pose a severe threat to the environment Contamination of water soil and air should be prevented SECTION 7 HANDLING AND STORAGE Precautions to be Taken in Handling and Storage Keep away from flames during and immediately after charging Combustion or overcharging may create or liberate toxic and hazardous gases and liquids including hydrogen sulfuric acid mist sulfur dioxide sulfur trioxide stibine arsine and sulfuric acid Store batteries in cool dry well ventilated area Do not short circuit battery terminals or remove vent caps during storage or recharging Protect battery from physical damage GOOD PERSONAL HYGIENE AND WORK PRACTICES ARE MANDATORY Refrain from eating drinking or smoking in work areas Thoroughly wash hands face neck and arms before eating drinking or smoking Launder soiled clothing before reuse Emptied batteries contain hazardous sulfuric acid residue SECTION 8 EXPOSURE CONTROLS AND PERSONAL PROTECTION Re
41. iation NFPA or the National Paint and Coating Association for HMIS ratings REVISION STATEMENT This is a new Material Safety Data Sheet ABBREVIATIONS THAT MAY HAVE BEEN USED IN THIS DOCUMENT TLV Threshold Limit Value TWA Time Weighted Average STEL Short term Exposure Limit TPQ Threshold Planning Quantity RQ Reportable Quantity PEL Permissible Exposure Limit C Ceiling Limit CAS Chemical Abstract Service Number Al 5 Appendix A Categories Change Has Been Proposed NDA No Data Available NA Not Applicable Prepared according to the OSHA Hazard Communication Standard 29 CFR 1910 1200 and the ANSI MSDS Standard 2400 1 by the Toxicology and Health Risk Assessment Unit CRTC P O Box 1627 Richmond CA 94804 KR KKK KKK KKH KKK RK KKK RK KEKE KKK KIKI KK KEK IKK IKK IKK K ERE EKER KKK KEKE ETER Kok AP eee The above information is based on the data of which we are aware and is believed to be correct as of the date hereof Since this information may be applied under conditions beyond our control and with which we may be unfamiliar and since data made available subsequent to the date hereof may suggest modification of the information we do not assume any responsibil ity for the results of its use This information is furnished upon condition that the person receiving it shall make his own determination of the suitability of the material for his particulaxr purpose RRR KIRK RRR RR RRR RE KR KKK KK IRR R
42. ly carcinogenic to humans Group 2A or possibly carcinogenic to humans Group 2B 12 ECOLOGICAL INFORMATION ECOTOXICITY No data available ENVIRONMENTAL FATE No data available 13 DISPOSAL CONSIDERATIONS Oil collection services are available for used oil recycling or disposal Place contaminated materials in containers and dispose of in a manner consistent with applicable regulations Contact your sales representative or local environmental or health authorities for approved disposal or recycling methods 14 TRANSPORT INFORMATION The description shown may not apply to all shipping situations Consult 49CFR or appropriate Dangerous Goods Regulations for additional description requirements e g technical name and mode specific or quantity specific shipping requirements DOT SHIPPING NAME NONE DOT HAZARD CLASS NONE DOT IDENTIFICATION NUMBER NONE DOT PACKING GROUP N A ADDITIONAL INFO Petroleum Lubricating Oil Not Hazardous by U S DOT ADR RID Hazard class Not applicable 15 REGULATORY INFORMATION SARA 311 CATEGORIES 1 Immediate Acute Health Effects NO Delayed Chronic Health Effects NO Fire Hazard NO Sudden Release of Pressure Hazard NO Reactivity Hazard NO URUN REGULATORY LISTS SEARCHED Ol SARA 313 11 NJ RTK 22 TSCA Sect 5 a 2 02 MASS RTK 12 CERCLA 302 4 23 TSCA Sect 6 03 NTP Carcinogen 13 MN RTK 24 TSCA Sect 12 b 04 CA Prop 65 Carcin 14 ACGIH TWA 25 TSCA
43. ns with the following medical conditions must take precautions pulmonarv edema bronchitis Generally emphysema dental erosion and tracheobronchitis Aggravated by Exposure Routes of Inhalation YES Eye Contact YES Entry Ingestion YES Skin Contact YES Chemical s Proposition National Toxicology LA R C OSHA NO EPA Listed as 65 YES Program YES Monographs YES CAG YES NIOSH YES Carcinogen or potential Carcinogen SECTION 4 FIRST AID MEASURES Emergency and TE A i First Aid Contact with internal components if battery is opened broken or spilled Procedures 1 Inhalation Remove to fresh air and provide medical oxygen CPR if needed Obtain medical attention 2 Eyes Immediately flush with water for at least 15 minutes hold eyelids open Obtain medical attention 8 Skin Flush contacted area with large amounts of water for at least 15 minutes Remove contaminated clothing and obtain medical attention if necessary 4 Ingestion Do not induce vomiting If conscious drink large amounts of water milk Obtain medical attention Never give anything by mouth to an unconscious person SECTION 5 FIREFIGHTING MEASURES Class ABC CO Halon Auto Ignition Polypropylene Temperature 675 F Flash Not Flammable Limits Hydrogen Lower Upper Extinguisher Point Applicable in Air by Volume Hz 41 74 2 Media When charging Special Fire Lead acid batteries do not burn
44. or burn with difficulty Do not use water on fires where molten metal is present Extinguish fire with agent Fighting suitable for surrounding combustible materials Cool exterior of battery if exposed to fire to prevent rupture The acid mist and vapors Procedures generated by heat or fire are corrosive Use NIOSH approved self contained breathing apparatus SCBA and full protective equipment operated in positive pressure mode Unusual Fire and Hydrogen gas and sulfuric acid vapors are generated upon overcharge and polypropylene case failure Ventilate charging areas as per Explosion Hazards ACGIH Industrial Ventilation A Manual of Recommended Practice and National Fire Code 1980 Vol 1 P 12 B 9 10 Hydrogen gas may be flammable or explosive when mixed with air oxygen chlorine Avoid open flames sparks other sources of ignition near battery To avoid risk of fire or explosion keep sparks or other sources of ignition away from batteries and do not allow metallic materials to simultaneously contact negative and positive terminals of cells and batteries SULFURIC ACID REACTS VIOLENTLY WITH WATER ORGANICS SECTION 6 ACCIDENTAL RELEASE MEASURES Procedures for Cleanup Stop release if possible Avoid contact with any spilled material Contain spill isolate hazard area and deny entry Limit site access to emergency responders Neutralize with sodium bicarbonate soda ash lime or other neutralizing agent Place battery in suitable container
45. spiratory Other Precautions Protection Acid gas NIOSH approved respirator is required when the PEL is exceeded or employee experiences respiratory irritation When exposure levels Specify Type are unknown or when firefighting wear a self contained breathing apparatus with a full facepiece operated in a positive pressure mode Ventilation Must be provided when Local Exhaust When PEL is exceeded Mechanical General Normal mechanical ventilation charging in an enclosed recommended for stationary area Change air every 15 applications min Protective Gloves Wear rubber or plastic acid resistant Eye Protection ANSI approved safety glasses with side shields face shield recommended gloves with elbow length gauntlet Safety goggles when filling batteries Other Protective Clothing or Equipment Ventilation as described in the Industrial Ventilation Manual produced by the American Conference of Governmental Industrial Hygienists shall be provided in areas where exposures are above the PEL or TLV specified by OSHA or other local state and federal regulations Acid resistant rubber or plastic apron boots and protective clothing Safety shower and eyewash SECTION 9 PHYSICAL AND CHEMICAL PROPERTIES Boiling Point Electrolyte Vapor Electrolyte 1 mm Specific Electrolyte H20 1 Approx 235 F Pressure Hg 145 8 F Gravity 1 250 1 320 pH lt 2 Melting Point
46. th exposure to this product PRIMARY ROUTES OF ENTRY Occupational exposure most likely to occur through skin contact 5 FIRST AID MEASURES SKIN Wash off with plenty of soap and water EYE Flush with large amounts of water If any irritation persists get medical attention INGESTION Remove material from mouth Drink plenty of water If large amount swallowed or symptoms develop get medical attention INHALATION Remove to fresh air 6 EXPOSURE CONTROLS PERSONAL PROTECTION ENGINEERING MEASURES Ensure ventilation or local exhaust especially for enclosed space HYGIENE MEASURES Good industrial hygiene should be followed OCCUPATIONAL EXPOSURE LIMITS No occupational exposure limits have been established PERSONAL PROTECTIVE EQUIPMENT Normal precautions should be observed If repeated or prolonged skin contact is likely impervious gloves are recommended 7 PHYSICAL CHEMICAL PROPERTIES PHYSICAL STATE Solid COLOR White ODOR None BOILING POINT Not determined MELTING POINT 110 F 43 C VAPOR PRESSURE lt 0 1 mm Hg 20 C VAPOR DENSITY Heavier than air SPECIFIC GRAVITY 0 84 g ml 25 C SOLUBILITY IN WATER Insoluble VOC CONTENT Not volatile 8 STABILITY REACTIVITY STABILITY Stable under normal conditions HAZARDOUS POLYMERIZATION Will not occur HAZARDOUS DECOMPOSITION PRODUCTS Thermal decomposition will evolve oxides of carbon MATERIALS TO AVOID Oxidizing agents 9 FIRE EXPLOSION DATA
47. unds may cause headache nausea vomiting abdominal spasms fatigue sleep disturbances weight loss anemia and pain in the legs arms and joints Kidney damage as well as anemia can occur from acute exposure CHRONIC INHALATION INGESTION Prolonged exposure to lead and its compounds may produce many of the symptoms of short term exposure and may also cause central nervous system damage gastrointestinal disturbances anemia and wrist drop Symptoms of central nervous system damage include fatigue headaches tremors hypertension hallucinations convulsions and delirium Kidney dysfunction and possible injury has also been associated with chronic lead poisoning Chronic over exposure to lead has been implicated as a causative agent for the impairment of male and female reproductive capacity but there is at present no substantiation of the implication Pregnant women should be protected from excessive exposure Lead can cross the placental barrier and unborn children may suffer neurological damage or developmental problems due to excessive lead exposure in pregnant women SECTION 12 ECOLOGICAL INFORMATION In most surface water and groundwater lead forms compounds with anions such as hydroxides carbonates sulfates and phosphates and precipitates out of the water column Lead may occur as sorbed ions or surface coatings on sediment mineral particles or may be carried in colloidal particles in surface water Most lead is strongly retained
48. ures are reguired because this material is not expected to cause eye irritation As a precaution remove contact lenses if worn and flush eyes with water SKIN No specific first aid measures are required because this material is not expected to be harmful if it contacts the skin As a precaution remove clothing and shoes if contaminated Use a waterless hand cleaner mineral oil or petroleum jelly to remove the material Then wash skin with soap and water Wash or clean contaminated clothing and shoes before reuse INGESTION No specific first aid measures are required because this material is not expected to be harmful if swallowed Do not induce vomiting As a precaution give the person a glass of water or milk to drink and get medical advice Never give anything by mouth to an unconscious person INHALATION If exposed to excessive levels of material in the air move the exposed person to fresh air Get medical attention if coughing or respiratory discomfort occurs NOTE TO PHYSICIANS In an accident involving high pressure equipment this product may be injected under the skin Such an accident may result in a small sometimes bloodless puncture wound However because of its driving force material injected into a fingertip can be deposited into the palm of the hand Within 24 hours there is usually a great deal of swelling discoloration and intense throbbing pain Immediate treatment at a surgical emergency center is recommended
49. usually provided for a limited time or under certain circumstances ENGINEERING CONTROLS Use in a well ventilated area If user operations generate an oil mist use process enclosures local exhaust ventilation or other engineering controls to control airborne levels below the recommended mineral oil mist exposure limits PERSONAL PROTECTIVE EQUIPMENT EYE FACE PROTECTION No special eye protection is normally required Where splashing is possible wear safety glasses with side shields as a good safety practice SKIN PROTECTION No special protective clothing is normally required Where splashing is possible select protective clothing depending on operations conducted physical requirements and other substances Suggested materials for protective gloves include lt Viton gt lt Nitrile gt lt Silver Shield gt RESPIRATORY PROTECTION No respiratory protection is normally required If user operations generate an oil mist determine if airborne concentrations are below the recommended mineral oil mist exposure limits If not wear a NIOSH approved respirator that provides adequate protection from measured concentrations of this material Use the following elements for air purifying respirators particulate 9 PHYSICAL AND CHEMICAL PROPERTIES PHYSICAL DESCRIPTION Pale yellow liguid pH NDA VAPOR PRESSURE NA VAPOR DENSITY AIR 1 NA BOILING POINT NA FREEZING POINT NDA MELTING POINT NA SOLUBILITY Soluble in h
50. vere irritation and burns of eyes nose and throat Ingestion can cause severe burns and vomiting Lead Direct skin or eye contact may cause local irritation Inhalation or ingestion of lead dust or fumes may result in headache nausea vomiting abdominal spasms fatigue sleep disturbances weight loss anemia and leg arm and joint pain 2 Subchronic l E s and Electrolyte Repeated contact with sulfuric acid battery electrolyte fluid may cause drying of the skin which may result in irritation dermatitis and Chronic Health skin burns Repeated exposure to sulfuric acid mist may cause erosion of teeth chronic eye irritation and or chronic inflammation of the nose Effects throat and lungs Lead Prolonged exposure may cause central nervous system damage gastrointestinal disturbances anemia wrist drop and kidney dysfunction Pregnant women should be protected from excessive exposure to prevent lead from crossing the placental barrier and causing infant neurological disorders California Proposition 65 Warning Battery posts terminals and related accessories contain lead and lead compounds chemicals known to the State of California to cause cancer and reproductive harm and during charging strong inorganic acid mists containing sulfuric acid are evolved a chemical Known to the State of California to cause cancer Wash hands after handling Medical i MD s A ii nl Conditions If batterv is broken or material is spilled then perso
51. ydrocarbon solvents insoluble in water SPECIFIC GRAVITY 0 86 0 87 a 15 6 15 6C EVAPORATION RATE NA VISCOSITY 28 8 90 0 cSt 40C Min PERCENT VOLATILE VOL NA 10 STABILITY AND REACTIVITY HAZARDOUS DECOMPOSITION PRODUCTS H2S may be released at high temperatures CHEMICAL STABILITY Stable CONDITIONS TO AVOID No data available INCOMPATIBILITY WITH OTHER MATERIALS May react with strong oxidizing agents such as chlorates nitrates peroxides etc HAZARDOUS POLYMERIZATION Polymerization will not occur 11 TOXICOLOGICAL INFORMATION EYE EFFECTS The eye irritation hazard is based on data for a similar material SKIN EFFECTS The skin irritation hazard is based on data for a similar material ACUTE ORAL EFFECTS The acute oral toxicity is based on data for a similar material ACUTE INHALATION EFFECTS The acute respiratory toxicity is based on data for a similar material ADDITIONAL TOXICOLOGY INFORMATION This product contains petroleum base oils which may be refined by various processes including severe solvent extraction severe hydrocracking or severe hydrotreating None of the oils requires a cancer warning under the OSHA Hazard Communication Standard 29 CFR 1910 1200 These oils have not been listed in the National Toxicology Program NTP Annual Report nor have they been classified by the International Agency for Research on Cancer IARC as carcinogenic to humans Group 1 probab
Download Pdf Manuals
Related Search