Nokia N900 RX-51 Service Manual L1L2
Contents
1. B COVERZ ZZ 10215 WATER INGRESS LABEL m 19998 A LABEL fi 10212 CELLMO GPS ANTENNA ASSEMBLY ANTENNA ASSEMBLY 10216 10217 SCREW RF1 4x4 10220 STYLUS 10218 T SCREW M1 4x5 0 10219 BATTERY COVER ASSY 10221 Only available as These parts can not be assembly il reused after removal 9 Confidential e Copyright 2009 NOKIA e All rights reserved Version 1 0 ISSUE 1 NOKIA Care Nokia N900 RX 51 Academy Service Manual Level 1 amp 2 8 SERVICE DEVICES CA 101 100cm ws FLS 5 Flash Device CA 101 Service Cable AC 10 Travel Charger SS 206 SS 210 Camera removal tool RJ 230 Domesheet alignment tool NOKIA Stands Toolkit V2 NMP standard toolkit v2 For more information refer to the Service Bulletin SB 011 on NOKIA Online Supplier or manufacturer contacts for tool re order can be found in Recommended service BL 5 Battery SS 100 Camera removal tool equipment document on NOKIA Online 10 Confidential e Copyright 2009 NOKIA e All rights reserved Version 1 0 ISSUE 1 NOKI A Care Nokia N900 RX 51 Academy Service Manual Level 1 amp 2 9 SW UPDATE Flash concept Point of Sales To use the FLS 5 Flash Dongle follow the user guide inside the sales package Please check always for the latest version of flash software wich is available on Nokia Online SERVICE ia SOFTWARE PRODUCT SPECIFIC S BATTERY 11 Confidential e Cop2. Level 1 amp 2 gt EROGATE Nd ui IK d PE my A a s A dk I Sek A Lo Mi 4 13 Then remove the QWERTY KEYMAT 14 Use the SS 93 to carefully lift up the engine 15 While removing the engine board be careful 16 Remove the STYLUS by pulling it as shown not to damage the USB connector A t TAN i age ry TA a E er em 4 i 7 _ 17 Use the SS 93 to carefully detach the CELLMO 18 Release the GPS ANTENNA ASSEMBLY carefully ANTENNA ASSEMBLY Then remove the antenna with the SS 93 14 Confidential e Copyright 2009 NOKIA e All rights reserved Version 1 0 ISSUE 1 Nokia N900 RX 51 Academy Service Manual Level 1 amp 2 Pe 19 Remove the antenna 21 Push the camera removal tool SS 100 down until the camera retaining clips are released Sla 23 Release the DOMESHEET with the dental tool and 24 Do not use the DOMESHEET again peel it off Be aware of the sharp point of the dental tool be careful not to injure yourself 15 Confidential e Copyright 2009 NOKIA e All rights reserved Version 1 0 ISSUE 1 Nokia N900 RX 51 Service Manual Level 1 amp 2 26 Until all six screws become visible Unscrew the six Phillips size 00 screws in the order shown Do not use them again 27 Use the SS 93 to slightly lift up the SLIDE ASSY so 28 Next disconnect the LCD connector from the that LCD connector is revealed SLIDE ASSY with
3. amp 2 4 ESD PROTECTION Nokia requires that service points have sufficient ESD protection against static electricity when servicing the phone Any product of which the covers are removed must be handled with ESD protection The SIM card can be replaced without ESD protection if the product is otherwise ready for use To replace the covers ESD protection must be applied All electronic parts of the product are susceptible to ESD Resistors too can be damaged by static electricity discharge All ESD sensitive parts must be packed in metallized protective bags during shipping and handling outside any ESD Protected Area EPA Every repair action involving opening the product or handling the product components must be done under ESD protection ESD protected spare part packages MUST NOT be opened closed out of an ESD Protected Area For more information and local requirements about ESD protection and ESD Protected Area contact your local Nokia After Market Services representative 6 Confidential e Copyright 2009 NOKIA e All rights reserved Version 1 0 ISSUE 1 NOKIA Ca re Nokia N900 RX 51 Academy Service Manual Level 1 amp 2 5 CARE AND MAINTENANCE This product is of superior design and craftsmanship and should be treated with care The suggestions below will help you to fulfil any warranty obligations and to enjoy this product for many years e Keep the phone and all its parts and accessories out of the reach of sma
4. the torque of 15 Ncm in the order shown torque of 15 Ncm in the order shown N jl i ii Il fiiit 3 Tighten the two TORX size 6 screws to the torque of 6 Ncm in the order shown 19 Confidential e Copyright 2009 NOKIA e All rights reserved Version 1 0 ISSUE 1 NOKI A Care Nokia N900 RX 51 Academy Service Manual Level 1 amp 2 12 SOLDER COMPONENTS TOP BOTTOM Et ie ao a X7504 20 Confidential e Copyright 2009 NOKIA e All rights reserved Version 1 0 ISSUE 1
5. the SS 93 While opening the connector be careful not to damage the flexes 29 The SLIDE ASSY can now be separated 30 Use the SS 93 to unlock the locking mechanism of the LCD connector 16 Confidential e Copyright 2009 NOKIA e All rights reserved Version 1 0 ISSUE 1 Nokia N900 RX 51 Service Manual Level 1 amp 2 40 Disconnect the LCD connector by pulling outthe 41 Use the SS 93 to lift up the LCD display and then touch window flex carefully remove it 42 Remember to protect the LCD display with a 43 Use the dental tool to release the earpiece protective film 44 Remove the earpiece with the tweezers The 45 Release the A COVER FRAMING with the SRT 6 earpiece adhesive cannot be reused Insert the SRT 6 between the frame and the A COVER ASSY and slide the SRT 6 around the edges 17 Confidential e Copyright 2009 NOKIA e All rights reserved Version 1 0 ISSUE 1 NOKI A Care Nokia N900 RX 51 Academy Service Manual Level 1 amp 2 46 Remove the framing 47 Release the A COVER ASSY with the SRT 6 48 Remove the A COVER ASSY 49 Nokia N900 disassembly is now complete END OF DISASSEMBLY 18 Confidential e Copyright 2009 NOKIA e All rights reserved Version 1 0 ISSUE 1 NOKI A Care Nokia N900 RX 51 Academy Service Manual Level 1 amp 2 11 ASSEMBLY HINTS 1 Tighten the six Phillips size 00 screws to the 2 Tighten the four Phillips size 00 screws to
6. NOKI A Care Nokia N900 RX 51 Academy Service Manual Level 1 amp 2 SERVICE MANUAL Level 1 amp 2 NOKIA N900 Transceiver characteristics RX 51 Band Display 3 5 wide screen display with 800x480 resolution and Window Touch 16M colours Camera fe SMPix Carl Zeiss autofocus camera with dual LED flash Operating System Maemo Linux Connections 3 5 mm AV connector Bluetooth 2 0 with A2DP support Micro USB 2 0 A GPS WLAN 802 119 b TV out Transceiver with BL 5 battery pack Talk time Standby GSM GSM Talk times are Up to 9 hours Up to 10 days dependant on CDMA WCDMA network Up to 5 hours Up to 10 days parameters and phone settings 1 Confidential e Copyright 2009 NOKIA e All rights reserved Version 1 0 ISSUE 1 NOKIA Ca re Nokia N900 RX 51 Academy Service Manual Level 1 amp 2 Table of contents Li TURTLE TNS CONN ccc csc cccsscecscc sa E E E A ni 3 2 ON 4 3 Warnings and 1 AUS alan 5 Sl Wanda iii 5 5 los 5 4 ESD protecion eaae a E E E a E A aA a Ai 6 5 RA E EEE E E E N E T E A E E E E gece erie T 6 BatteVviniormati0Ni ase aaa 8 i 18 0 10 21611 iano 9 SORT RO 10 o Wide 11 10 DISASSEMBLY INSCFUCTIONS uss secsccccccesesescssesessssssssssssecssesesesssssssssssesesesesesesessssssssesecessssssssesesesesesesssesssssscsssesesececes 12 bb As emb eE EEN E EA E E das cseesienisee tenets sce 19 12 Solder 0 0 81 2 Sn 20 2 Confidential e Copyright 2009 NOKIA e All righ
7. e the capacity and lifetime of the battery Always try to keep the battery between 15 C and 25 C 59 F and 77 F A phone with a hot or cold battery may temporarily not work even when the battery is fully charged Batteries performance is particularly limited in temperatures well below freezing Do not dispose batteries in a fire Dispose of batteries according to local regulations e g recycling Do not dispose as household waste 8 Confidential e Copyright 2009 NOKIA e All rights reserved Version 1 0 ISSUE 1 NOKIA Care Nokia N900 RX 51 Academy Service Manual Level 1 amp 2 T EXPLODED VIEW A COVER FRAMING 10002 A1 TOUCH WINDOW ASSY 10003 10005 EARPIECE ADHESIVE 10005 EARP 29R 7 N 10004 TOUCH WINDOW ASSY 10003 A COVER ASSY 10001 LCD AM 800x480 LIGHT PROTECTION FOIL m 10204 SLIDE ASSY 10102 i SCREW M1 4x2 8 i MAIN FLEX ASSY Mi 10007 i 10101 Na QWERTY COVER ASSY 10201 QWERTY KEYMAT 10202 A2 LIGHT SWAP PACKAGE 10203 10212 19998 Im BB SHIELD LID LIGHT SWAP PWB 10207 B gt faqs le p lt lt WLAN BT SHIELD LID S ae QWERTY e 10208 a e a DOME SHEET ASSY T GPS SHIELD LID 10203 10209 AUDIO SHIELD LID T MEMORY CARD PCB 10206 e TA ELMO LID ff CAMERA MOD 5MP CHGR SHIELD LID T 10210 10213 IOXXX EMMC SHIELD LID m A3 B COVER ASSY ona ann sales 10214 10215 10214
8. f Nokia is prohibited Nokia Nokia Connecting People and Nokia X and Y are trademarks or registered trademarks of Nokia Corporation Other product and company names mentioned herein may be trademarks or tradenames of their respective owners Nokia operates a policy of continuous development Nokia reserves the right to make changes and improvements to any of the products described in this document without prior notice Under no circumstances shall Nokia be responsible for any loss of data or income or any special incidental consequential or indirect damages howsoever caused The contents of this document are provided as is Except as required by applicable law no warranties of any kind either express or implied including but not limited to the implied warranties of merchantability and fitness for a particular purpose are made in relation to the accuracy reliability or contents of this document Nokia reserves the right to revise this document or withdraw it at any time without prior notice The availability of particular products may vary by region IMPORTANT This document is intended for use by qualified service personnel only 4 Confidential e Copyright 2009 NOKIA e All rights reserved Version 1 0 ISSUE 1 NOKIA Ca re Nokia N900 RX 51 Academy Service Manual Level 1 amp 2 3 WARNINGS AND CAUTIONS Please refer to the phone s user guide for instructions relating to operation care and maintenance including importa
9. ll children Keep the phone dry Precipitation humidity and all types of liquids or moisture can contain minerals that will corrode electronic circuits Do not use or store the phone in dusty dirty areas Its moving parts can be damaged Do not store the phone in hot areas High temperatures can shorten the life of electronic devices damage batteries and warp or melt certain plastics Do not store the phone in cold areas When it warms up to its normal temperature moisture can form inside which may damage electronic circuit boards Do not drop knock or shake the phone Rough handling can break internal circuit boards Do not use harsh chemicals cleaning solvents or strong detergents to clean the phone Do not paint the phone Paint can clog the moving parts and prevent proper operation e Use only the supplied or an approved replacement antenna Unauthorised antennas modifications or attachments could damage the phone and may violate regulations governing radio devices All of the above suggestions apply equally to the product battery charger or any accessory T Confidential e Copyright 2009 NOKIA e All rights reserved Version 1 0 ISSUE 1 NOKIA Ca re Nokia N900 RX 51 Academy Service Manual Level 1 amp 2 6 BATTERY INFORMATION Note A new battery s full performance is achieved only after two or three complete charge and discharge cycles The battery can be charged and discharged hundred
10. nt safety information Note also the following 3 1 Warnings 1 CARE MUST BE TAKEN ON INSTALLATION IN VEHICLES FITTED WITH ELECTRONIC ENGINE MANAGEMENT SYSTEMS AND ANTI SKID BRAKING SYSTEMS UNDER CERTAIN FAULT CONDITIONS EMITTED RF ENERGY CAN AFFECT THEIR OPERATION IF NECESSARY CONSULT THE VEHICLE DEALER MANUFACTURER TO DETERMINE THE IMMUNITY OF VEHICLE ELECTRONIC SYSTEMS TO RF ENERGY 2 THE HANDPORTABLE TELEPHONE MUST NOT BE OPERATED IN AREAS LIKELY TO CONTAIN POTENTIALLY EXPLOSIVE ATMOSPHERES EG PETROL STATIONS SERVICE STATIONS BLASTING AREAS ETC 3 OPERATION OF ANY RADIO TRANSMITTING EQUIPMENT INCLUDING CELLULAR TELEPHONES MAY INTERFERE WITH THE FUNCTIONALITY OF INADEQUATELY PROTECTED MEDICAL DEVICES CONSULT A PHYSICIAN OR THE MANUFACTURER OF THE MEDICAL DEVICE IF YOU HAVE ANY QUESTIONS OTHER ELECTRONIC EQUIPMENT MAY ALSO BE SUBJECT TO INTERFERENCE 3 2 Cautions 1 Servicing and alignment must be undertaken by qualified personnel only 2 Ensure all work is carried out at an anti static workstation and that an anti static wrist Strap is worn 3 Use only approved components as specified in the parts list 4 Ensure all components modules screws and insulators are correctly re fitted after servicing and alignment 5 Ensure all cables and wires are repositioned correctly 5 Confidential e Copyright 2009 NOKIA e All rights reserved Version 1 0 ISSUE 1 NOKIA Ca re Nokia N900 RX 51 Academy Service Manual Level 1
11. s of times but it will eventually wear out When the operating time talk time and standby time is noticeably shorter than normal it is time to buy a new battery Use only batteries approved by the phone manufacturer and recharge the battery only with the chargers approved by the manufacturer Unplug the charger when not in use Do not leave the battery connected to a charger for longer than a week since overcharging may shorten its lifetime If left unused a fully charged battery will discharge itself over time Temperature extremes can affect the ability of your battery to charge For good operation times with Ni Cd NiMh batteries discharge the battery from time to time by leaving the product switched on until it turns itself off or by using the battery discharge facility of any approved accessory available for the product Do not attempt to discharge the battery by any other means Use the battery only for its intended purpose Never use any charger or battery which is damaged Do not short circuit the battery Accidental short circuiting can occur when a metallic object coin clip or pen causes direct connection of the and terminals of the battery metal strips on the battery for example when you carry a spare battery in your pocket or purse Shortcircuiting the terminals may damage the battery or the connecting object Leaving the battery in hot or cold places such as in a closed car in summer or winter conditions will reduc
12. ts reserved Version 1 0 ISSUE 1 NOKIA Ca re Nokia N900 RX 51 Academy Service Manual Level 1 amp 2 1 CHANGE HISTORY Status NersionNo Date Comments Approved 10 25 08 2009 First approved version The purpose of this document is to help NOKIA service levels 1 and 2 workshop technicians to carry out service to NOKIA products This Service Manual is to be used only by authorized NOKIA service suppliers and the content of it is confidential Please note that NOKIA provides also other guidance documents e g Service Bulletins for service suppliers follow these regularly and comply with the given instructions While every endeavor has been made to ensure the accuracy of this document some errors may exist If you find any errors or if you have further suggestions please notify NOKIA using the address below CMO Operation amp Logistics Training and Vendor Development Multimedia Creation amp Support mailto Service Manuals nokia com Please keep in mind also that this documentation is continuously being updated and modified so watch always out for the newest version 3 Confidential e Copyright 2009 NOKIA e All rights reserved Version 1 0 ISSUE 1 NOKIA Ca re Nokia N900 RX 51 Academy Service Manual Level 1 amp 2 2 COPYRIGHT Copyright 2009 Nokia All rights reserved Reproduction transfer distribution or storage of part or all of the contents in this document in any form without the prior written permission o
13. yright 2009 NOKIA e All rights reserved Version 1 0 ISSUE 1 NOKI A Ca re Nokia N900 RX 51 Academy Service Manual Level 1 amp 2 10 DISASSEMBLY INSTRUCTIONS 1 Nokia N900 disassembly 2 You must use the Nokia Standard Toolkit version 2 the AV plug and the SS 100 or SS 210 camera removal tool F L La Oral i LA hey oe Wye yer Y x a pa NO ay ALTE rato nad D Pra 4 Use the finger groove to release the BATTERY COVER ASSY 5 Remove the battery cover If there is a battery 6 Unscrew the four Phillips size 00 screws in the inserted remove it also order shown Do not use them again 12 Confidential e Copyright 2009 NOKIA e All rights reserved Version 1 0 ISSUE 1 NOKIA Care Nokia N900 RX 51 Academy Service Manual Level 1 amp 2 7 Carefully lift up the upper block to gain access to 8 The upper block can now be separated the MAIN FLEX CONNECTOR Disconnect the flex from the engine board with the SS 93 Be careful not to damage the connector i E FACCI Soy Se A 2s 9 ap eee we ree J ir 9 Unscrew the two TORX size 6 screws in the order 10 Use the SS 93 to release the clips holding shown Do not use them again QWERTY COVER ASSY Ma the Le bi 11 Make sure that all the clips are released 12 Remove the QWERTY COVER ASSY 13 Confidential e Copyright 2009 NOKIA e All rights reserved Version 1 0 ISSUE 1 NOKIA Car e Nokia N900 RX 51 Academy Service Manual
Download Pdf Manuals
Related Search