Single Seater Golf Buggy Owners Manual - KB-Golf
Contents
1. Do not get off the buggy until it has come to a complete stand still The direction switch should not be changed when the buggy is moving The Speed switch should not be changed when the buggy is moving Parts List 20 19 18 17 16 A A N A PA A x A Z AF E rs ag a R k s gt ya a N gt i 12 13 14 7 Quick Release Lever for Handlebar Assembly Picture 1 Picture 2 Fully locked lever assembly Unlock lever assembly Picture 3 Picture 4 Fold down lever handle Lever handle bar release Picture 1 2 Flick lever on handle over to release tension on fixing bolt Picture 3 amp 4 Pull down lever handle from top fixing bracket Slide lever to the left releasing the holding bolt from the top bracket therefore releasing the handlebars to fold down 5 Inspection and maintenance Parts Golf buggy Steering system Accelerator throttle handle Battery power indicator Seat Brake pedal Tyres Wheels Batteries Battery charger Inspection After use clean any mud or debris from under the body either with a hand brush or a light air hose Only use a mild detergent with warm water for the exterior DO NOT use a high pressure jet wash Ensure all parts are functioning properly Ensure the buggy moves when the throttle is turned anti clockwise and it stops when the throttle is released Ensure the power has enough charge remaining before use Ensure the seat is fixed2. properly Ensure the brake pedal works freely Ensure the tyres are in good condition and that they are at the recommended air pressure at all times Check all nuts and bolts and ensure the wheel nuts are tight and secure Recharge batteries after every use and check the battery indicator is full before use DO NOT allow the battery charger to get wet 6 Trouble shooting The buggy won t start Battery indicator will not reset after 8 hour charge Other Check the key is in the on position Check the battery power indicator Check the batteries are connected properly Ensure the buggy is NOT in free wheel mode Ensure the footbrake is NOT engaged Press the Reset indicator button This is situated under the body on the white controller cover Contact your supplier Check charger is working 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 2 1 Parts list Control panel Golf bag holder Handlebar release pin Body Front suspension Front bumper Foot brake pedal Horn button Battery power indicator Direction switch Accelerator throttle Ignition Seat suspension Rear carry bracket Electromagnetic brake handle Free wheel lever Rear tyre Padded seat Seat body assembly Footplate Front tyre Bonnet release catch Micro switch High low speed switch Slide cap battery charger point 3 Operation 3 1 Operation Please rem
3. I motioncaddy gt lt Dedication to Excellence I motioncaddys gt Dedication to Excellence im Single Seater Golf Buggy Owners Manual WwWw i motioncaddys com sales i motioncaddys com Www i motioncaddys com sales i motioncaddys com Introducing the i m Single seater golf and utility vehicle The i m4 golf buggy is like any other electrical or mechanical device Cleaning care and inspection is a must which will result in longer life and extended reliability General care and inspection After every use clean any mud or debris from under the body either with a hand brush or a light air hose Use a mild detergent and warm water for the exterior DO NOT use a high pressure wash Check all bolt and nut connections are tight before use especially the wheel nuts Check tyre pressure and maintain the recommended pressure at all times Recharge batteries after every use and check the battery indicator is full before use DO NOT allow the battery charger to get wet Let the i m4 add to your golfing experience Score Card Holder Assembly Picture 1 Picture 2 Mount score card holder bracket into bakelite sleeve on back of knob golf bag holder Fix using Picture 3 Fix using bakelite knob Press on score card holder to supprting bracket We MARTNI tiiti Ti AIL TU ail i anal a wae Picture 1 To access the batteries release bakelite knob at th
4. akelite bolt push up the rear bracket and re tighten the bakelite bolt 4 Specifications Item Motor Battery Controller Accelerate Charger Dimension Weight without batteries Carrying capacity Maximum speed Low speed Slope climbing capacity Brake range Turning radius Brake method Micro switch Wheel base Minimal ground clearance Tyre Tyre pressure Parameter 36V 1200 Watt permanent magnetism 12V 48AH x 3 12V 45AH x 3 12V 75AH x 3 Curtis controller 1227 3402 dc36v 160A Hall accelerator continuous variable speed system Full automatic efficiency pulse charger 5 Amp or 8 Amp 1 27 x 0 82 x 1 05m 105kg 200kg 13 15km h 4 6km h 17 degrees lt 4m 3 secs lt 3m Electromagnetic amp mechanical brake Motor protectiory Power cut off switch 90cm 11cm 32 5cm x 15cm 4 Wheels Front 20 psi and Rear 20 psi i m Available accessories e Mud guards Front and rear e Rear basket e Fold up golf bag holder e Umbrella holder e Back seat rest e Strobe lights e Front and rear indicator e Quick release seat system e Rear golf bag holding bracket e Front basket assembly e Waterproof cover e Scorecard holder e Sun shade canopy e Front head lights e Ramps
5. e rear of the buggy lift the body and attach the fixed hold up arm Golf Bag Holder Assembly 1 Safety Operation Picture 1 Picture 2 1 1 Safety Please read the following instructions carefully before using the i m4 golf buggy DO NOT use the throttle handle as a support when mounting the buggy Turn off ignition when not in use Leave buggy in neutral mode when not in use Picture 1 Picture 2 Locate pivot arm into slot provided locate bottom pivot arm into fixing The i m4 golf buggy is designed to carry one person on fixing angle Attach to i m4 hole provided and semi tighten and semi fasten bakelite knob bakelite knob provided The buggy is NOT road legal provided Please use the throttle to decrease the speed when turning the buggy Picture 3 Please use the throttle to increase the speed when climbing a hill Picture 3 When driving the buggy take care in crowded areas wet or Tighten both top and bottom slippery surfaces and tight gaps bakelite knobs for firm fix Do not allow others to use the i m4 buggy without your Reverse process to remove permission Please do not stand up on the i m4 buggy when in motion as you may lose your balance Please do not lean side from side to side on the im4 Do not drive the i m4 down hills backwards Try to avoid pot holes or uneven paths Keep the i m4 buggy in a dry area or under cover when not in use Do not use a mobile phone when driving the buggy
6. ove the charger from the buggy before turning the ignition key on Turn ignition key on Ensure charge indicator is sufficient Press FWD to move forward Press REV to move in reverse Turn throttle anti clockwise to increase speed Release throttle to slow down or stop Brake pedal is for emergency stop only When the throttle is released the back wheel is locked automatically for parking on inclines or declines oe brake handle The electro magnetic brake lever free wheel lever can be found under the body attached to the motor Make sure the electro magnetic brake lever is in the vertical position to engage the motor Dis engage the electro magnetic brake lever to free wheel the vehicle Battery discharging Point The battery charger socket is located under the seat Ensure the cover is replaced after charging Power display Running time will change according to ground conditions and terrain FULL CHARGE LED light bar is at the top MINIMAL CHARGE LED light bar is at the bottom Seat The seat height can be adjusted to 3 positions using the bolts at the top end of the suspension spring Seat can have a quick release system fitted to allow easier seat removal Golf bag holder The golf bag holder is attached and detached using the lower and upper bakelite knobs at the front of the buggy Rear fold down carrier To open Release the bakelite bolt fold down the rear bracket and tighten the bakelite bolt To close Release the b
Download Pdf Manuals
Related Search