TriCoPolymer FS5 Use and Care Manual
Contents
1. 1 N A Voc lt 0 Method 24 used 4of7 Evaporation Rate Normal Butyl Acetate 1 lt O 1 NO VOC Water and soap cleanup SECTION X STABILITY AND REACTIVITY Stability Stable under ordinary conditions of use and storage Agglomeration may occur following freezing or boiling of liquid product Hazardous Polymerization Will not occur Incompatibility Strong acids Hazardous Decomposition Products Carbon monoxide and unidentified organic compounds may be formed during combustion Thermal decomposition may produce various hydrocarbons and irri tating acrid vapors SECTION XI TOXICOLOGICAL INFORMATION Acute Oral LDso gt 25 mL kg Rat Acute Dermal LDso gt 5 mL kg Rabbit Acute Inhalation LDso No mortality at 592 PPM 4H Rat Chronic Carcinogenicity This product does not contain any chemical currently listed by the Interna tional Agency for Research on Cancer IARC the National Toxicology Program NTP or regulated by the Occupational Safety and Health Administration OSHA as a carcinogen SECTION XII ECOLOGICAL INFORMATION Ecotoxicity Common Name Genus species Test LCs0 Survival Comment Type 3 Rainbow Oncorhynchus mykiss 96 Hour gt 1 000 mg L Trout Acute Water Flea Daphnia magna 96 Hour gt 1 000 mg L DOL T Acute Sheepshead Cyprinodon varie 96 Hour gt 10 000 mg L Minnow gatus Acute Mysid Shrimp Americamysis bahia 96 Hour gt 1 000 mg L Acute Fathead Pimephales2. REQUIREMENTS Department Of Transportation DOT Classification Class 1V nonflammable nontoxic liquid III Class 60 Controlle Europe DOT Proper Shipping Name Tricopolymer Liquid solution HS Tariff 2852 90 000 HST 3209 USA DOT Hazard Class Non Toxic class 60 DOT Non Bulk Shipping Name Refer to Bill of Lading Not DOT Regulated Keep from Freezing Not dangerous goods 6of7 SECTION XV REGULATORY INFORMATION TSCA Section 8 b Inventory Status All components are included in the EPA Toxic Substances Control Act TSCA Chemical Substance Inventory None are listed as hazardous TSCA Section 12 b Export Notification HST 2852 90 00 This material does not contain any components that are subject to the U S Toxic Substances Control Act TSCA Section 12 b Export Notification re quirements or Canada applicable WHMIS symbols No GHS hazard rating or symbol required due to nontoxicity rating Independent Testing ASTM OSHA Hazard Communication Standard 29 CFR 1910 1200 hazard class es None This material is not classified as hazardous under the criteria of the U S Occupational Safety and Health Administration OSHA Hazard Communication Standard 29 CFR 1910 1200 EPA SARA Title III Section 304 CERCLA NA Reportable quantities have not been established for any of this material s components EPA SARA Title III Section 311 312 HAZARD COMMUNICATION STANDARD HCS This material is not a hazardous c
3. Rating 10 0 Resistance to wash off when dry 99 9 Full water immersion test 100 retention over 119 months No delamination or dissolving of film noted Prevents nail and hardware rusting and oxidation Use to seal interior brick concrete cinder block and underlayment ASTM D3273 D5590 Enviro chamber 60 day for mold mildew fungal resistance 30 day is normal test 365 days tropical 10 0 Prevents mineral fiber dusting in HVAC Ducting Freeze resistant when dry minus 20 degrees Great for plywood OSB all subflooring trusses and engineered wood Prevents chemi cal leach out in Pressure Treated wood Not Hazardous under State of California regulations Landfill and wash out method ap proved for disposal Calif Rules 65 compliant Boiling point 212 degrees Flash Point 170 degrees PH 8 0 to 3 0 depending on prod uct type Hot radiator surface 220 degrees 80f7 Permeation Rate 001 to 12 depending on product type Adhesion rate 98 90 normal paint primer is 75 91 No VOC s 0 VOC Optical quality Milky white when in liquid wet state Clear to slightly transparent when dry Flexural strength 3 times stretch 100 when applied Film is UV resistive without additives LEED qualified product 4 5 when applied to schools 1 LEED point in general use Non reactive to ferrous or non ferrous metals Test on surfaces for appearance properties before using Cautions Observe OSHA Safety Rules and Regulations H
4. based lt 1 nonionic and cationic Ingredients verified by ORMI NOP WERCS services retained to protect Trade Secret and processes of components SECTION IV FIRST AID MEASURES Eye Contact Immediately flush eyes with water for at least fifteen minutes lifting lower and upper eyelids occasionally If irritation persists for more than 30 minutes seek medical attention 2of7 Skin Contact Remove saturated clothing shoes Wash skin with soap or mild detergent and water for at least 15 minutes If irritation develops or persists seek medical attention Inhalation No vapor is expected but if airborne particles are inhaled remove to fresh air If not breathing give artificial respiration If breathing is diffi cult give oxygen Call a physician Ingestion If conscious give person 1 to 2 glasses of water and then induce vomiting immediately as directed by medical personnel Get immediate medical atten tion Never give anything by mouth to an unconscious person Children should seek immediate physician s advice Note To Physician If more than 2 0 ml per kg has been ingested and vomiting has not occurred emesis should be induced with supervision Keep victim s head below hips to prevent aspiration If symptoms such as loss of gag reflex convulsions or unconsciousness occur before emesis gastric lavage using a cuffed endotra cheal tube should be considered SECTION V FIRE FIGHTING MEASURES Fla
5. MATERIAL SAFETY DATA SHEET Tricopolymer MSDS 10 Pages 1995 2014 TM Updated June 08 2014 Visit www tricopolymer com Proud Member saa ae C ae Since 1995 Copyright TM 1995 2014 MVB AII Rights Reserved paintcars Xas Section 1 Product and Company Identification Product Name Lumber Seal www tricopolymer com Product class Water reducible Tricopolymer Liquid Product Use Surface Coatings and Sealants MANUFACTURER 24 HOUR EMERGENCY ASSISTANCE TriSealUSA LLC TriSealUSA LLC 1600 Stethem Ferry 1 800 650 0553 or 678 699 3704 Johns Creek Georgia 30022 USA or call your local poison control center 1 800 650 0553 GENERAL MSDS ASSISTANCE 1 800 650 0553 TriSealUSA LLC Attn Michael Berry Managing Partner 678 699 3704 Email trisealusa gmail com EPA Registered Company 90313 GA 001 HSTARIFF 2852 90 000 NMFC ITEM 50395 SECTION Il HAZARD S IDENTIFICATION Appearance And Odor Liquid is white emulsion with mild odor Cured product is clear when dry without odor Liquid Product HEALTH HAZARD 0 FIRE HAZARD 0 REACTIVITY 0 CONTACT 0 Cured Product Non Flammable Non Carcinogenic Non Irritating Non Toxic THE HEALTH EFFECTS NOTED BELOW ARE CONSISTENT WITH REQUIREMENTS UNDER THE OSHA HAZARD COMMUNICATION STANDARD 29 CFR 1910 1200 Meets Canada CERA requirements Controlle Europe Registered FDA Compliant Page 1 of 10 Safety Infor
6. hemical EPA SARA Title III Section 313 TOXIC CHEMICAL LIST TCL This product does not contain Section 313 Reportable Ingredients EPA RCRA This product is not regulated under RCRA EPA Clean Air Act 1990 This product does not contain nor was it directly manufactured with any Class I or Class II ozone depleting substances per 40 CFR Part 82 State Regulations California This product is not regulated as a hazardous waste under CCR Title 22 Division 4 5 and passes prop 65 Canada HMIS Personal protection and equipment letter C SECTION XVI OTHER INFORMATION The information contained herein is based on the data available to us and is believed to be correct However TriSealUSA LLC makes no war ranty expressed or implied regarding the accuracy of these data or the results to be obtained from the use thereof TriSealUSA LLC assumes no responsibility for injury or misuse of the product described herein If you wish to receive updates to this information please contact TriSealUSA LLC general MSDS assistance line at 1 800 650 0553 or by facsimile at 770 818 5414 or email trisealusa gmail com 70f7 User Responsibility Each user should read and understand this information and incorporate it in individual site safety programs in accordance with applicable hazard communication standards and regulations BE SAFE READ OUR PRODUCT TriSealUSA LLC SAFETY INFORMATION AND At
7. ingredients listed EPA Registered Company 90313 GA 001 No harmful or controlled ingredients listed IARC No harmful or controlled ingredients listed or used NTP National Toxicology Program No harmful or controlled ingredients used NIOSH No harmful or controlled ingredients listed for mask blockage OSHA Use and labeling requirements met 9of7 Canadian DSL No harmful or controlled ingredients listed not a drug source No Required WHMIS label Protection Class C Canadian NDSL No harmful or controlled ingredients listed European EINECS All ingredients are listed Controlee Europe Registered meets all packaging and import export regulations UN Con tainers NAFTA Mexico Canada registered DOT class 60 UPS USPS FEDEX registered with several carriers Hellman Export HS TARRIF 3209 Philippines Chemical Inventory Control PICCS AII ingredients are registered Australian Inventory of Chemical Substances AICS All ingredients are registered ASTM Member since 2000 testing of product meets or exceeds requirements Independent Testing Rengo Block Environmental K Prime Test America University of Oregon American Beekeeping Federation 20 test hives spanning 5 years History of product Since 1995 Questions Callus 1 800 650 0553 or visit www tricopolymer com Fax 770 818 5414 Email at tricopolymer gmail com or trisealusa gmail com Copyright Trademark Tricopolymer 1995 2014 TriSealUSA L L C All rights reserved Compiled to
8. istory of Tricopolymer Product Since May 1995 Does not mix with gasoline kerosene oil or oil based paints Do not inject Stain wood surfaces first before applying product Store above 35 degrees but not over 120 degrees Strain before spraying as usual with coat ings Observe OSHA Rules and Regulations Cover personal belongings wear eye protection hair and skin protection Niosha mask 60 is required Do not run HVAC while applying Will handle most desert application conditions Keep Buckets away from children and pets Do not inject or injest Clean copper before soldering do not spray into electrical boxes heating elements oily surfaces and valuable objects Tarp over important non application areas with rubber backed drop cloths only User assumes end use risk Site reports must be submitted for warranty for each project Manufacturer is not responsible for prior issues labor spray equip ment or repair application spills completion or timely delivery No warranty or guarantee is inferred in this document Some rights vary from State to State Tricopolymer Regulatory Information VOCs No Zero EPA Method 24 ASTM D3792 Petroleum derivatives No Chemicals known to cause cancer No Chemicals known to cause reproductive harm No Chemicals known to cause developmental toxicity No Meets or exceeds Proposition 65 Yes No harmful or controlled ingredients listed for any state Meets SARA 313 304 302 No harmful or controlled
9. mation Eye Contact Liquid may be slightly irritating to eyes if used improperly Skin Contact Liquid contact to intact skin is expected to be only slightly irritating to the skin but no serious dermatitis hazard is anticipated Proper wash up after application and before film dries are recommended Inhalation Paint grade mask required No vapor is to be expected however particulate matter may become airborne when applying this product Observe OSHA rules and regulations Ingestion Swallowing Liquid is not expected to be toxic If this product is ingested Do Not induce vomiting this may lead to chemical aspiration in the lungs potential ly causing chemical pneumonitis which may be fatal Signs And Symptoms Mild to moderate irritation to eyes and skin as noted Aggravated Medical Conditions Persons with preexisting eye or skin disorders or impaired liver or kidney may be more susceptible to the affects of liquid exposure to this product Other Health Effects None Carcinogenicity This material does not contain any chemical listed by the International Agency for Research on Cancer IARC the National Toxicology Program NTP or regulated by the Occupational Safety and Health Administration OSHA and Canada CERE WHMIS as a carcinogen SECTION Ill COMPOSITION INFORMATION ON INGREDIENTS NO COMPOSITION CAS NO PERCENT Ls Tricopolymer Proprietary 99 2 Wetting agents Water
10. pick up and recycle or dispose at Landfill SECTION VII HANDLING AND STORAGE Storage Do not allow product to freeze or stand in direct sunlight Keep containers closed when not in use to minimize contact with air Keep in temperature range of 40 to 100 degrees Handling Use only in well ventilated areas Avoid contact with eyes Avoid breathing vapors Avoid prolonged or repeated contact with skin Maintain general hygiene practices when using this product Wear disposable clothing SECTION VIII EXPOSURE CONTROLS PERSONAL PROTECTION Engineering Controls General industrial hygiene practices should b mployed when using this product Personal Protective Equipment Eye Protection Safety glasses with top and side shields Skin Protection Disposable gloves Coveralls Inhalation Protection NIOSH Mask Adequate ventilation Precautionary Measures Avoid contact with skin and eyes Wash thoroughly after handling Exposure Limits PEL OSHA Not established TLV ACGIH Not established SECTION IX PHYSICAL AND CHEMICAL PROPERTIES Physical Form Liquid Color Milky White transparent when cured Odor Mild Slight odorless when cured pH N A Boiling Point gt 100 00 C gt 212 00 F Freezing Point lt 0 C lt 32 F Freeze resistant when dry Specific Gravity H20 1 9 432 Vapor Pressure Mm Hg Not Determined Melting Point F N A Solubility In Water Infinitely Dispersed Vapor Density Air
11. promelas 96 Hour 100 Leachate from Minnow Acute cured product HoneyBee All species No reported deaths 8 year usage Environmental Fate MFG Considered eco green cradle to grave SECTION XIII DISPOSAL CONSIDERATIONS Hazard Class The product in its purchased form is not a hazardous waste as characterized by the Federal Resource Conservation and Recovery Act RCRA under 40 CFR 261 or the California hazardous waste control law under CCR Title 22 Division 4 5 Disposal of the product is not regulated under RCRA or the California Department of Toxic Substances Control DTSC Individual state or local hazardous waste regulations may apply if they differ from those required by RCRA or DTSC Consult federal state and local regulations to ensure that this product and its containers if discarded are disposed of in compliance with all regulatory requirements Disposal The wastes resulting from the direct use of this product may be disposed of onsite or at an approved waste disposal facility Do not contaminate water food or feed by storage or disposal Product imparts a milky white color to contaminated waters Foaming may result Sewage treatment plants may not be able to remove the white color imparted to the water NOTE As supplied or diluted product material foam included when splashed on automobiles or other personal property is difficult to remove if allowed to dry SECTION XIV TRANSPORTATION
12. sh Point closed cup gt 171 F ASTM D93 209 deg boiling point Flammable Limits Lower Explosive Limit LEL None Upper Explosive Limit UEL None Extinguishing Media Liquid product does not burn The product will only burn after the water it contains is driven off For cured product use carbon dioxide foam dry chemical or water fog to extinguish fire Aqueous solution is not flammable Special Fire Fighting Procedures and Precautions None Unusual Fire and Explosion Hazards None SECTION VI ACCIDENTAL RELEASE MEASURES Small Spill Take up with an absorbent material and dispose of at any landfill Large Spill Containment Technique Stop spilled material from being released into the environment Vacuum material up or dry then pick up remaining plastic Wet area and clean up before prod uct dries Ventilate the space involved Wash area well Clean up Procedures Wear suitable protectiv quipment Transfer to containers by suction preparatory for later dispos al Place in suitable containers for recovery or dis 30f7 posal Flush area with water spray Wash contaminated property before the product cures See Section 13 for disposal assistance Wash area well Special Instructions for accidental release Spilled product is very slippery Use care to avoid falls A film will form on drying Remove saturated clothing and wash contacted skin area with soap and water Allow spill to dry
13. the best of our knowledge using raw material listings and supplier provided information 1 800 650 0553 Email trisealusa gmail com Proud Members ASTM USGBC ABF and many others Copyright Trademark PPend 1995 2014 TriSealUSA L L C All Rights Reserved 100f7
14. tn Mike Berry PASS IT ON PRODUCT 1600 Stethem Ferry LIABILITY LAW REQUIRES IT Johns Creek Ga 30022 1 800 650 0553 Tricopolymer General Product Information Product Information provided remains property of TriSealUSA and may be distributed under written permission of same Manufac turer s findings and tests made cover a span between 1995 to June 2014 Check for warranty information updates Some product variations are designed in the final recipe according to desired outcome Test Ratio Full Strength Saturation Rate applied 100 1 3 mil thickness avg Best application method Commercial power sprayer Dries Clear Do not dilute Spray according to Label Directions Tintable May be added to water based paints Do not apply to driveways or walking surfaces Application Rate Varies as to product average is 400 1600 sq ft per gallon using low pressure moderate volume med Tip Apply until surface is wet keep moving until finished if possible EPA Registered Company 90313 GA 001 HS TARRIF 3209 Meets EPA exemption FIFRA regulations DOT Regulations Class 60 Exceeds ASTM C 1071 Requirements for coatings Meets or exceeds ASTM standards C1071 coating D3359 08 C 1520 02 E2418 06 inspection E1903 97 2002 revision D3273 D5590 and many others according to product recipe type Toxic rating 0 Non Toxic Methods tested rat rabbit rainbow trout daphnid flathead min now saltwater fish bees Humans No Leaching ASTM
Download Pdf Manuals
Related Search