White Outdoor 144-994-190 User's Manual
Contents
1. Model Nos 144 994 190 144 995 190 NNT OUTDOOR PRODUCTS PARTS CATALOG AND INSTRUCTION MANUAL Yard Boss GT 1655 Yard Boss GT 1855 Thank you for purchasing an American built product PRINTED IN U S A FORM NO 770 3581 INDEX Safe Operation Practices 3 Off Season Storage ASSEMDBIV site casts AA EA tan AANA 5 Electrical Diagram COS eaa E aea axexwale oeud as 8 Illustrated Parts for Tractor Operation PREE EE I O a s a O E OA 11 Illustrated Parts for Transaxle ii AdjS iMn S aene ra annaa 12 Illustrated Parts for Hydrostatic Pump LUDPI CATION anessa rea 2 aena a AA 17 Illustrated Parts for Three Point Hitch Maintenance 0 0 cc cee ee eee 18 Trouble Shooting Charts SOOSCOCOOOOOOOOCCS e LIMITED WARRANTY For one year from the date of original retail purchase WHITE OUTDOOR PRODUCTS will either repair or replace at its option free of charge F O B factory or authorized service firm any part or parts found to be defective in material or workmanship Transportation charges for the movement of any power equipment unit or attachment are the responsibil ity of the purchaser Transportation charges for any parts submitted for replacement under this warranty must be paid by the purchaser unless such return is requested by WHITE OUTDOOR PRODUCTS This warranty will not apply to any part2. in jury 16 17 18 19 20 21 22 23 24 25 26 Disengage power to attachment s and stop engine before making any repairs or ad justments Disconnect the spark plug wire and keep the wire away from the plug to pre vent accidental starting Before attempting to unclog the mower or discharge chute stop the engine The mower blade s may continue to rotate for a few seconds after the engine is shut off Therefore be sure the blade s have stopped completely Disconnect the spark plug wire and keep the wire away from the plug to pre vent accidental starting Disengage power to attachment s when transporting or not in use Take all possible precautions when leaving vehicle unattended such as disengaging power take off lowering attachments shift ing into neutral setting parking brake stop ping engine and removing key Do not stop or start suddenly when going uphill or downhill Mow up and down face of steep slopes never across the face Use ex treme caution if it is necessary to drive the tractor up an incline or back the tractor down an incline because the front of the tractor could lift and rapidly flip over backward which could cause serious injury Reduce speed on slopes and in sharp turns to prevent tipping or loss of control Always keep the tractor in gear when going down steep hills to take advantage of engine brak ing action Stay alert for holes in terrain and other hidden
3. stopped and inspected for damage after strik ing a foreign object The damage should be repaired before restarting and operating the equipment Do not change the engine governor settings or overspeed the engine When using the vehicle with mower proceed as follows 1 Mow only in daylight or in good artificial light ransaxle nee Dipsti k haat Seat Rear Axle p Hi w Range Undercarriage 34 35 36 KNOW YOUR TRACTOR Steering Wheel Control 2 Never make a cutting height adjustment while engine is running if operator must dismount to do so 3 Shut the engine off and wait until the blade comes to a complete stop before removing the grass catcher 4 Check blade mounting bolts for proper tightness at frequent intervals Check grass catcher bags frequently for wear or deterioration For safety protection replace only with new bag meeting original equipment specifications Look behind to make sure the area is clear before placing the transmission in reverse and continue looking behind while backing up Disengage blades before shifting into reverse and backing up This unit should not be driven up a ramp onto a trailer or truck under power because the unit could tip over causing serious personal injury The unit must be pushed manually to load properly Lever Front P T O 16 x 6 50 Tires 18 x 6 50 Tires
4. which has become inoperative due to misuse ex cessive use accident neglect improper maintenance alterations or unless the unit has been operated and maintained in accordance with the instructions furnished This war ranty does not apply to the engine motor battery battery charger or component parts thereof Please refer to the applicable manufacturer s warranty on these items This warranty will not apply where the unit has been used commercially Warranty service is available through your local authorized service dealer or distributor If you do not know the dealer or distributor in your area please write to the Customer Service Department of WHITE OUTDOOR PRODUCTS The return of a complete unit will not be accepted by the factory unless prior written per mission has been extended by WHITE OUTDOOR PRODUCTS This warranty gives you specific legal rights You may also have other rights which vary from state to state q PSOCCCCCCS t WARNING a a OT TTR 4 ee St a a a a This unit is equipped with an internal combustion engine and should not be used on or near any unim proved forest covered brush covered or grass covered land unless the engine s exhaust system is equipped with a spark arrester meeting applicable local or state laws if any If a spark arrester is used it should be maintained in effective working order by the operator In the State of Califo
5. hazards Use care when pulling loads or using heavy equipment A Use only approved drawbar hitch points B Limit loads to those you can safely control C Do not turn sharply Use care when back ing D uss counterweight s or wheel weights when suggested in owner s manual Watch out for traffic when crossing or near roadways When using any attachments never direct dis charge of material toward bystanders nor allow anyone near vehicle while in operation Handle gasoline with care It is highly flam mable A Use approved gasoline container B Never remove cap or add gasoline to a run ning or hot engine or fill fuel tank indoors Wipe up spilled gasoline C Open doors if engine is run in garage Ex haust fumes are dangerous Do not run engine indoors 27 28 29 30 31 32 33 Power Take Off Lever P T O 23 x 9 50 Tires 27 x 9 50 Tires Keep the vehicle and attachments in good operating condition and keep safety devices in place Use guards as instructed in operator s manual Keep all nuts bolts and screws tight to be sure the equipment is in safe working condi tion Never store the equipment with gasoline in the tank inside a building where fumes may reach an open flame or spark Allow engine to cool before storing in any enclosure To reduce fire hazard keep engine free of grass leaves or excessive grease The vehicle and attachments should be
6. rnia the above is required by law Section 4442 of the California Public Resourc Code Other states may have similar laws Federal laws apply on federal lands A spark arrester muffler is available at your nearest engine authorized service center 2 with the instructions may result in personal injury ORE To reduce the potential for any injury comply with the following safety instructions Failure to comply SAFE OPERATION PRACTICES FOR RIDING VEHICLES 1 10 11 13 14 15 Read this owner s manual carefully in its en tirety before attempting to assemble or operate this unit Keep this manual in a safe place for future and regular reference and for ordering replacement parts This unit is a precision piece of power equip ment not a plaything Therefore exercise ex treme caution at all times Know the controls and how to stop quickly READ THIS OWNER S MANUAL Do not allow children to operate vehicle Do not allow adults to operate it without proper instruction Only persons well acquainted with these rules of safe operation should be allowed to use your mower No one should operate this unit while intox icated or while taking medication that impairs the senses or reactions Wear sturdy rough soled work shoes and close fitting slacks and shirts to avoid en tanglement in the moving parts Never operate a unit in bare feet sandals or sneakers To prevent injury do not car
7. ry passengers or give rides Keep children pets and by standers out of the area while mowing Only the operator should ride on the unit and only ride in the seat Check overhead clearance carefully before driving under power lines guy wires bridges or low hanging tree branches before entering or leaving buildings or in any other situation where the operator may be struck or pulled from the unit which could result in serious in jury To maintain control of the unit and reduce the possibility of upset or collision operate the tractor smoothly Avoid erratic operation and excessive speed Keep the area of operation clear of all per sons particularly small children and pets Stop engine when they are in the vicinity of your mower Although the area of operation should be completely cleared of foreign ob jects a small object may have been over looked and could be accidently thrown by the mower in any direction and cause injury Clear work area of objects which might be picked up and thrown by the mower in any direction and cause injury Stop the blade s when crossing gravel drives walks or roads Disengage all attachment clutches and shift into neutral before attempting to start engine Disengage power to attachment s and stop engine before leaving operating position Do not put hands or feet near or under rotating parts Keep clear of the discharge opening at all times as the rotating blade s can cause
Download Pdf Manuals
Related Search