Weber 120 Owner's Manual
Contents
1. e The Spider Insect Screen should also be checked for any obstructions See Annual Maintenance section These instructions will give you the minimum requirements for assembling your Weber gas barbecue Please read the instructions carefully before using your Weber gas barbecue Improper assembly can be dangerous Not for use by children This Weber gas barbecue is designed for use with butane propane gas only Do not use with natural gas The valve and regulator are for Butane propane gas only Do not use with charcoal fuel This Weber gas barbecue is not intended for commercial use The use of alcohol and or prescription or non prescription drugs may impair the consumer s ability to properly assemble or safely operate the appliance Operating A WARNING This barbecue should only be used outdoors in a well ventilated area Do not use in a garage shed hut or any other enclosed area A WARNING Your Weber gas barbecue must not be used under an unprotected combustible roof or overhang A WARNING Your Weber gas barbecue is not intended for installation in or on recreational vehicles and caravans and or boats A WARNING Do not use the barbecue where the top back or sides of the grill are within 60 cm 24 in of combustible materials This Weber gas barbecue is not intended for and should never be used as a heater Do not leave the Weber gas barbecue unattended Keep children and pets2. Contact the Customer Service Representative in your region using the contact information on our web site Log onto www weber com When leak checks are complete turn gas supply OFF at the source and rinse connections with water Connecting the Butane Propane Cylinder Use butane propane cylinders with a minimum capacity of 5 kg anda maximum capacity of 13 kg You will need butane propane cylinder a soap and water solution and a rag or brush to apply it The regulator illustrations shown in this manual may not be similar to the one you are using for your barbecue due to different country or regional regulations Some regulators push ON to connect and pull OFF to disconnect others have a nut with a left hand thread that connects to the cylinder valve Follow specific regulator connection instructions Position the regulator so that the vent hole faces downwards 1 Mix the soap and water 2 Turn on the cylinder valve 3 Check for leaks by wetting the fitting with the soap and water solution and watching for bubbles If bubbles form or if a bubble grows there is a leak Demark Sweden Norway Finland Iceland The Netherlands Hungary Czech Republic United Kingdom France Spain Portugal Belgium Ireland Greece Luxembourg Italy Switzerland Germany Austria Regulator Regulator vent hole COUNTRY GAS TYPE amp PRESSURE lL 30mbar 3B P I 28 30 37mbar L DOmbar 3B P
3. away from the Weber gas barbecue at all times Check that the area under the control panel and the bottom tray are free from debris that might obstruct the flow of combustion or ventilation air Change the flexible hose when national regulations stipulate this as a requirement Any parts sealed by the manufacturer must not be altered by the user Any modification of the appliance may be dangerous WARNING The entire cooking box gets hot when in use Do not leave unattended WARNING Keep any electrical power cable away from any heated surface WARNING Keep the cooking area clear of inflammable vapours and liquids such as petrol paraffin alcohol etc and other combustible materials WARNING Never store an extra spare butane propane cartridge cylinder under or near the Weber gas barbecue WARNING When cooking the appliance must be on a level stable surface in an area clear of combustible material GENERAL INSTRUCTIONS contiuen Cooking To light the grill Refer to the lighting instructions in this owners manual and printed on the fold out tables Q120 200 220 of your grill To preheat the grill Light the Weber gas grill according to the lighting instructions in this owners manual Close the lid Preheat the grill for 5 10 minutes depending on conditions such as air temperature and wind Cleaning A WARNING Turn your Weber gas barbecue OFF and wait for it to cool before cleaning For availa
4. grill or attempted use of natural gas in a butane propane gas A Your Weber gas grill should not be used by children unit is dangerous and will void your warranty Accessible parts of the grill may be very hot Keep A Adented or rusty gas supply cartridge cylinder may be young children away while it is in use hazardous and should be checked by your gas supplier A Exercise caution when using your Weber gas grill It Do not use a gas supply cartridge cylinder with a cE will be hot during cooking or cleaning and should never be left unattended or moved while in operation damaged valve GB INT ENGLISH 41009 02 15 06 WARNINGS continven A Even though your gas supply cartridge cylinder may appear to be empty it might still contain gas The cartridge cylinder should be transported and stored A accordingly A Under no circumstances should you attempt to disconnect the gas regulator or any gas fitting while your grill is in operation gt D Owner s Guide Use heat resistant oven gloves when operating grill Do not use this grill unless all parts are in place The unit must be properly assembled according to the instructions outlined in the Assembly Instruction section of the grill Do not use the Weber grill in the boot of any vehicle or inside an estate car people carrier minibus or caravan Use the regulator that is supplied with your Weber gas Warning Make sure you are outdoors and away fro
5. or entrecote 2 5 cm 1 in thick 4 o 10 minutes High 2 5 3 cm 1 to 1 1 2 in thick 4 to 16 minutes sear 10 minutes High Grill 4 to 6 minutes Low 2 5 3 cm 1 to 1 1 2 in cubes Beefburger or rissole 2 cm 3 4 in thick 2 2 5 cm 3 4 to 1 inch thick o 12 minutes Medium o 10 minutes Medium Chop rib loin or shoulder o 15 minutes sear 6 minutes High grill 4 to 8 minutes Low o 18 minutes sear 8 minutes High grill 6 to 10 minutes Low Loin boneless 2 2 5 cm 3 4 to 1 in thick O to 12 minutes sear 6 minutes High a 4 to 6 minutes Low Chicken breast boneless 175 g 6 oz 8 to 12 minutes Medium skinless 3 4cm 1 1 4 to 1 1 2 in thick Chicken half 550 675g 1 1 4 to 1 1 2 Ib 1 to 1 1 4 hours Low Chicken pieces bone in 30 to 40 minutes Low breast wing Chicken pieces bone in 40 to 50 minutes Low leg thigh GRILLING GUIDE contiuen Don t forget to regularly brush off your cooking grate and Fish fillet of slice clean out the drip pan under the grill The following cuts thicknesses weights and grilling times for food are meant to be guidelines rather than hard and fast rules Cooking times are affected by such factors as wind outside temperature and how well done the food should be cooked Grill for the time given on the chart or to the desired degree of doneness turning once halfway through the grilling time Cooking times for beef and lamb are for medium cooking ti
6. this Limited Warranty There are no other express warrants except as set forth herein and any applicable implied warranties of merchantability and fitness are limited in duration to the period of coverage of this express written Limited Warranty Some regions do not allow limitation on how long an implied warranty lasts so this limitation may not apply to you Weber is not liable for any special indirect or consequential damages Some regions do not allow the exclusion or limitation of incidental or consequential damages so this limitation or exclusion may not apply to you Weber does not authorise any person or company to assume for it any other obligation or liability in connection with the sale installation use removal return or replacement of its equipment and no such representations are binding on Weber This Warranty applies only to products sold at retail Printed in U S A
7. CONSUMPTION DATA KW Hs gm Hs GAS INSTRUCTIONS Q 200 220 continven If there is a leak turn off the gas and tighten the fitting Turn the gas back on and recheck with the soap and water solution If the leak does not stop contact the Customer Service Representative in your area using the contact information on our web site Log onto www weber com DO NOT USE THE BARBECUE 4 When leak checks are complete turn gas supply OFF at the source and rinse connections with water A DANGER Do not use an open flame to check for gas leaks Be sure there are no sparks or open flames in the area while you check for leaks Sparks or flames will result in a fire or explosion which can cause serious bodily injury or death as well as damage to property A DANGER Do not store a spare butane propane cylinder under or near this appliance A ATTENTION This product has been safety tested and is only certified for use in a specific country Refer to country designation located on outer carton These parts may be gas carrying or gas burning components Please contact Weber Stephen Products Co Customer Service Department for genuine Weber Stephen Products Co replacement part s information A WARNING Do not attempt to make any repair to gas carrying or gas burning components without contacting Weber Stephen Products Co Customer Service Department Your actions if you fail to follow this product Warning may cause a fire or an e
8. Weber Q w 120 200 220 Gas Grill Owner s Guide Register your grill online at www weber com A WARNING Do not try to light the Weber gas barbecue without first reading the Lighting instructions in this manual YOU MUST READ THIS OWNER S GUIDE BEFORE OPERATING YOUR GAS GRILL A WARNING 1 Do not store spare liquid butane propane cartridge cylinder within 3m 10 feet of this appliance 2 Do not store or use petrol or other flammable liquids or vapours within 8m 25 feet of this appliance A DANGER If you smell gas 1 Shut off gas to the appliance 2 Extinguish any open flames 3 Open lid 4 If odour continues keep away from the appliance and immediately call your gas supplier or your fire service Leaking gas may cause a fire or explosion which can cause serious bodily injury or death or damage to property A WARNING Follow all leak check procedures carefully in this manual prior to barbecue operation Do this even if barbecue was dealer assembled ADANGER Failure to follow the Dangers Warnings and Cautions contained in this Owner s Manual may result in serious bodily injury or death or in a fire or an explosion causing damage to property INFORMATION FOR THE INSTALLER This manual must remain with the owner who should keep it for future use THIS GAS APPLIANCE IS DESIGNED FOR OUTDOOR USE ONLY AWARNINGS A Follow regulator connection instructions for your type 4 Ifthe burne
9. bility of replacement cooking grate contact the Customer Service Representative in your region using the contact information on our web site Log onto www weber com Outside surfaces Use a warm soapy water solution to clean then rinse with water A CAUTION Do not use oven cleaner abrasive cleaning products kitchen cleaning products cleaners that contain citrus products or abrasive cleaning pads on barbecue Disposable Drip Pan 2 or Stainless Steel Pan Head Phillips Screw 1 4 20 x 1 1 2 Screw 2 Catch Pan 1 Note Wind and weather may require adjustment of the burner control knob to obtain the correct cooking temperature If the burner goes out during cooking open the lid turn off the burner and wait five minutes before relighting Drippings and grease Excess drippings and grease will collect in the catch pan in the slide out bottom tray located on the underside of the grill Disposable Weber drip pans are available that fit the catch pan Slide out bottom tray Remove excess grease then wash with warm soapy water then rinse Cooking grate Clean with a suitable brass bristle brush Remove from grill and wash with warm soapy water then rinse with water as required Catch pan Disposable foil trays are available or you can line the catch pan with aluminum foil To clean the catch pan wash with warm soapy water then rinse Inside cooking box Brush any debris off burne
10. e printed instructions that accompany it when assembled and operated in accordance with the printed instructions accompanying it Weber may require reasonable proof of your date of purchase THEREFORE YOU SHOULD RETAIN YOUR SALES RECEIPT OR INVOICE This Limited Warranty shall be limited to the repair or replacement of parts that prove defective under normal use and service and which on examination shall indicate to Weber s satisfaction that they are defective Before returning any parts contact the Customer service representative in your region using the contact information sheet provided with your manual If Weber confirms the defect and approves the claim Weber will elect to replace such parts without charge If you are required to return defective parts transportation charges must be prepaid Weber will return parts to the purchaser freight or postage prepaid This Limited Warranty does not cover any failures or operating difficulties due to accident abuse misuse alteration misapplication vandalism improper installation or improper maintenance or service or failure to perform normal and routine maintenance including but not limited to damage caused by insects within the burner tubes as set out in this owner s manual Deterioration or damage due to severe weather conditions such as hail hurricanes earthquakes or tornadoes discolouration due to exposure to chemicals either directly or in the atmosphere is not covered by
11. e an open flame to check for gas leaks Be Hose Reg Spain Denmark Portugal sure there are no sparks or open flames in the area while you check for leaks Sparks or flames will result in a fire or explosion which can cause serious bodily Hose Reg Switzerland injury or death as well as damage to property Hose Reg Ireland Hose Reg Sweden A DANGER Hose Reg UK Do not store a spare butane propane cartridge under Hose Reg Australia or near this appliance FP Hose Reg Norway Finland COUNTRY GAS TYPE amp PRESSURE Demark Sweden Norway Finland The Netherlands United Kingdom France Spain Portugal I ge 7 2ombars Belgium Ireland Greece Luxembourg Italy Germany Austria lap Jombars CONSUMPTION DATA Main Burner g Hs Max 202 GAS INSTRUCTIONS Q 100 120 continven Check for gas leaks 1 Regulator to butane propane cartridge connection A WARNING If there is a leak at connection 1 remove butane propane cartridge Do not operate grill Use a different butane propane cartridge and recheck for leaks with soap and water solution If a leak persists after retightening the butane propane cartridge turn OFF the gas DO NOT OPERATE THE GRILL Contact the Customer Service Representative in your area using the contact information on our web site Log onto www weber com Check 2 Valve to regulator connections A WARNING If there is a leak at connection 2 turn OFF the gas DO NOT OPERATE THE GRILL
12. hen lighting the barbecue Push burner control knob in and turn to START HI Check that the burner is lit by looking down through the cooking grate You should see a flame A Caution do not fold in tables until grill is cold Q120 200 220 O gt gt Push the red ignition button several times so that it clicks each time Check that the burner is lit by looking down through the cooking grate You should see a flame WARNING If the burner does not light turn the burner control knob to OFF and wait 5 minutes to let the gas clear before you try again or before you try to light with a match Q LOW d m i m MED Hi START sane HIGH OFF O OFF To Extinguish Push in and turn burner control knob clockwise to the OFF position MAINTENANCE Replacing Burner Tube 1 Your Weber Gas Grill must be OFF and cool 2 Unscrew and remove butane propane cartridge cylinder from the valve regulator assembly Open the lid Remove cooking grate Unscrew and remove the 1 4 x 20 inch stainless steel hex nut and stainless steel washer that holds the burner tube inside the cook box a 6 Carefully slide the burner tube out from the cook box A Caution the burner openings 1 must be positioned properly over the valve orifices 2 DEY 7 To reinstall the burner reverse steps 5 to 7 Weber Spider Insect screens Your Weber gas barbecue as well as any
13. k for leaks Sparks or flames will result in a fire or explosion which can cause serious bodily injury or death and damage to property Q200 220 TROUBLESHOOTING Burner burns with a yellow or orange flame in conjunction with the smell of gas Burner does not light or flame is low in HIGH position Experiencing flare ups A CAUTION Do not line the bottom tray with aluminum foil Burner flame pattern is erratic Flame is low when burner is on HIGH Flames do not run the whole length of the burner tube Inside of lid appears to be peeling Resembles paint peeling Burner does not light when igniter button is pushed Burner flame does not ignite completely around the burner tube Clean Weber Insect Spider screen See Annual Maintenance section Inspect Weber Insect Spider screen for possible obstructions Blockage of holes Is butane propane cartridge cylinder fuel low or empty Replace butane propane cartridge cylinder Does the burner light with a match If you can light the burner with a match then check the ignition system Are you preheating barbecue in the prescribed manner Clean thoroughly See Cleaning section Is the cooking grate heavily coated with burned on grease Clean bottom tray Are burners clean Clean burner See Annual Maintenance section The lid is cast aluminum not paint It cannot peel What you are seeing is baked on g
14. ked for gas leaks The burners web site Log onto www weber com have been flame tested As a safety precaution Check however you should re check all fittings for leaks 2 Valve to regulator connections before using your Weber gas barbecue Shipping A WARNING If there is a leak at connection and handling may have loosened or damaged a 2 turn OFF the gas DO NOT OPERATE gas fitting THE GRILL Contact the Customer Service A WARNING Perform these leak checks Representative in your area using the even if your barbecue has been assembled contact information on our web site Log by a dealer or at the shop where you on to www weber com gas fitting bought it When leak checks are complete turn gas supply You will need a soap and water solution and a OFF at the source and rinse connections with rag or brush to apply it water To perform leak checks make sure the Burner is in the OFF position Turn on gas supply A WARNING Do not ignite burner while checking for leaks Check for leaks by wetting the connections with the soap and water solution and watching for bubbles If bubbles form or if a bubble grows there is a leak Note Since some leak test solutions including soap and water may be slightly corrosive all connections should be rinsed with water after checking for leaks A DANGER Do not use an open flame to check for gas leaks Be sure there are no sparks or open flames in the area while you chec
15. key Joe Genesis China Kettle Silhouette Denmark Kettle Silhouette Smokey Joe Weber Finland Smokey Joe France Kettle Silhouette Smokey Joe Weber One Touch Germany Smokey Joe Weber One Touch Greece Smokey Joe Ireland Kettle Silhouette Smokey Joe Italy Smokey Joe Weber Japan Smokey Joe Weber Korea Smokey Joe Weber New Zealand Weber Smokey Joe Nigeria Weber Norway Smokey Joe Weber Portugal Weber South Africa Smokey Joe Weber Kettle Configuration Spain Smokey Joe Weber Sweden Kettle Silhouette Smokey Joe Switzerland Kettle Silhouette Smokey Joe Weber United Kingdom Smokey Joe Weber Weber One Touch U S A Kettle Configuration Kettle Silhouette Smokey Joe Weber One Touch Firespice Go Anywhere Kettle Configuration Kettle Silhouette Genesis Flavorizer Crossover Flamgo Performer Rapidfire Tuck N Carry Jumbo Joe Bar B Kettle Master Touch Spirit Grill Out Summit Platinum 1 800 Grill Out Ranch Matchless Flame Zimbabwe Weber Kettle Configuration Kettle Silhouette GAS INSTRUCTIONS Q 100 Connecting the Butane Propane Cartridge Use butane propane disposable cartridges with a minimum capacity of 430g and a maximum capacity of 460g The cartridge must have an EN417 valve as illustrated One type of cartridge that can be used is a Weber Baby Q Performer gas cartridge Another type of cartridge is a Primus model 2202 A CAUTION Only use cy
16. linders that are marked Propane fuel or Butane Propane mix Push LP disposable cartridge into regulator and turn clockwise until tight A WARNING Hand tighten only Using excessive force could damage the regulator coupling and cartridge valve This could cause a leak or prevent gas flow A The disposable cartridge must fit within the support basket You will need butane propane cartridge a soap and water solution and a rag or brush to apply it 1 Mix the soap and water 2 Turn the gas control to ON by turning anti clockwise 3 Check for leaks by wetting the fitting with the soap and water solution and watching for bubbles If bubbles form or if a bubble grows there is a leak If there is a leak turn OFF the gas and tighten the cartridge Turn the gas back ON and re check with the soap and water solution Damaged If the leak does not stop remove the cartridge Try a second cartridge if the leak persists remove cartridge Contact the Customer Service Representative in your area using the contact information on our web site Log on to www weber com DO NOT USE THE REPLACEMENT HOSE AND REGULATOR BARBECUE 4 When leak checks are complete turn gas supply OFF at the source and Country rinse connections with water Hose Belgium Hose Reg Holland Hose Reg Greece Italy Regulator Gas control valve close clockwise until tight A DANGER Hose Reg Germany Austria Do not us
17. m any source of ignition when changing or connecting the butane propane cartridge cylinder Q100 120 Use butane propane disposable cartridges with a minimum capacity of 430g and a maximum capacity of 460g The cartridge must have an EN417 valve as illustrated One type of cartridge that can be used is a Weber Baby Q Performer gas cartridge Another type of cartridge is a Primus model 2202 GENERAL INSTRUCTIONS If you have questions or need advice regarding your grill or its safe operation please log onto www weber com Your Weber gas barbecue is a portable outdoor cooking appliance With the Weber gas barbecue you can grill barbecue roast and bake with results that are difficult to duplicate with indoor kitchen appliances The closed lid produces that outdoor flavour in the food The Weber gas barbecue is portable so you can easily change its location in your garden or on your patio Portability means you can take your Weber gas barbecue with you if you move Butane propane gas supply is easy to use and gives you more cooking control than charcoal fuel Storage and or Non use 6 When the Weber gas barbecue is not in use the gas cartridge cylinder must be DISCONNECTED and stored outdoors in a well ventilated place The Weber gas barbecue should be checked for gas leaks and any obstructions in the burner tubes before using See Sections General Maintenance and Annual Maintenance
18. me unless otherwise noted Let thick chops and steaks rest for 5 to 10 minutes before carving The internal temperature of the meat will rise by 5 to 10 degrees during this time Fish amp Seafood For more grilling tips and recipes visit www weber com Vegetables Mushroom shiitake or button es 8 to 10 minutes Mushroom chestnut cups 2 to 15 minutes Medium or flats Onion 1 27cm 1 2 in slice SY 8 to 12 minutes 3 4cm 1 4 to 1 2 in thick 1 2 5 cm 1 2 to 1 in thick 2 5 3cm 1 to 1 1 4 in thick 3 to 5 minutes High 5 to 10 minutes High 10 to 12 minutes High a mae id Fish whole 450g 1 Ib 15 to 20 minutes Medium 1 kg 2 to 2 1 2 Ib 20 to 30 minutes Medium Corn on the cob husked Po O to 12 minutes Medium Corn on the cob in husk Po 25 to 30 minutes Medium Garlic whole Po 45 to 60 minutes Low edium edium Potato 1 27cm 1 2 in slices Po 4 to 16 minutes Medium Aubergine 1 27cm 1 2 in 8 to 10 minutes Medium slices WARRANTY In order to validate your warranty please register your grill online at www weber com Weber Stephen Products Co Weber hereby warrants to the ORIGINAL PURCHASER of this Weber gas grill that it will be free of defects in material and workmanship from the date of purchase as follows Aluminum Castings Thermoplastic Thermoset Parts 5 years 5 years excluding fading All Remaining Parts 2 years when assembled and operated in accordance with th
19. n the fold out WARNING Do not lean over the open 5 work surface Q120 200 220 barbecue Keep your face and body at least 30 cm 12 in away from the matchlight 6 1 Open the lid hole when lighting the barbecue 2 Unfold the work surfaces Q120 200 220 Turn the cylinder on by turning the cylinder valve A 3 Make sure the control knob is turned OFF Push control knob in and turn clockwise to ensure that it is in the OFF position anticlockwise Q200 220 4 Push burner control knob in and turn to START HI a j A Caution do not fold in tables until grill is cold Q120 200 220 A DANGER Failure to open the lid while igniting the barbecue s burner or not waiting 5 minutes to allow the gas to clear if the barbecue does not light may result in an explosive flare up which can cause serious bodily injury or even death A WARNING If the burner does not light turn the burner control knob to OFF and wait 5 minutes to let the gas clear before you try again or before you try to light with a match Manual Lighting Open the lid Unfold the work surfaces Q120 200 220 Make sure the burner control knob is turned OFF Turn the cylinder on by turning the cylinder valve anticlockwise 0200 220 Strike a match and put the flame into the matchlight hole under the igniter A WARNING Do not lean over open barbecue Keep your face and body at least 30 cm 12 inches away from the matchlight hole w
20. ons If the ignition system fails to ignite the burner light the burner with a match If the burner lights with a match then check the ignition system e Check that both the white 1 and black 2 ignition wires are attached properly A DANGER Failure to correct symptoms may result in a fire which can cause serious bodily injury or death and cause damage to property 2 Barbecue does not reach temperature 3 Barbecue heats unevenly 4 One or more of the burners do not ignite A CAUTION Do not clean the Spider Insect screen with hard or sharp tools Do not dislodge the Spider Insect screen or enlarge the screen openings Lightly tap the burner to get debris and dirt out of the burner tube Once the Spider Insect screen and burner is clean replace the burner If the Spider Insect screen becomes damaged or cannot be cleaned contact the Customer Service Representative in your area using the contact information on our web site Log onto www weber com Main Burner Flame Pattern The Weber gas barbecue burner has been factory set for the correct air and gas mixture The correct flame pattern is shown 1 2 3 4 Burner tube Tips occasionally flicker yellow Light blue Dark blue MAINTENANCE ccontinuen will work Check and clean the air shutter opening at the ends of the burner Check and clean the valve orifice at the base of the valve Use a Steel bristle brush to clean the outside of
21. outdoor gas appliance is a target for spiders and other insects They can nest in the venturi section 1 of the burner tube This blocks the normal gas flow and can cause the gas to flow back out of the air shutter This could result in a fire in and around the air shutter causing serious damage to your barbecue The burner tube air shutter is fitted with a stainless steel screen 1 to prevent spiders and other insects from accessing the burner tubes through the air shutter openings We recommend that you inspect the Spider Insect screen at least once a year See Annual Maintenance section Also inspect and clean the the Spider Insect screen if any of the following symptoms should ever occur 1 The smell of gas in conjunction with the burner flames appearing yellow and lazy Annual Maintenance Inspection and cleaning of the Spider Insect screen If there is dust or dirt on the Spider Insect screen remove the burner for cleaning the screen Brush the Spider Inspect screen lightly with a soft bristle brush i e an old toothbrush Make sure the igniter port hole A lines up with the arrow tab B on the igniter box Check that the ignition button pushes the igniter button down and returns to the up position If the ignition system still fails to light contact the Customer Service Representative in your area using the contact information on our web site Log onto www weber com Ignition System Operati
22. r tubes DO NOT ENLARGE BURNER PORTS OPENINGS Wash the inside of cooking box with warm soapy water and rinse with water PARTS LIST Cooking Grate 1 SAD Cotter Pin 2 a A WARNING Check the catch pan and the bottom of the grill for grease build up before each use Remove excess grease to avoid a fire in the bottom of the grill A WARNING Do not move the Weber gas grill when operating or while the grill is hot Inside lid While lid is warm wipe inside with paper towel to prevent grease build up Flaking built up grease resembles paint flakes Swing up work tables 0120 200 220 Wash with a soft cloth and a soap and water solution Do not use cleaners that contain acid mineral spirits or xylene Rinse well after cleaning Swing up work tables 0120 200 220 are not to be used as cutting boards q Control Knob 1 Handle Spacer 2 Handle 1 d20 Hinge Pin 2 Thermometer 1 Wing Nut 1 ASSEMBLY VENET 2 WEBER STEPHEN PRODUCTS CO www weber com 2006 The following trademarks are registered in the name of Weber Stephen Products Co an Illinois corporation located at 200 East Daniels Road Palatine Illinois 60067 U S A Australia Smokey Joe Weber Kettle Silhouette amp Genesis Austria Kettle Silhouette Smokey Joe Weber Benelux Kettle Silhouette Smokey Joe Weber Compact Grill Configuration Botswana Weber Canada Smo
23. rease that has turned to carbon and is flaking off THIS IS NOT A DEFECT Clean thoroughly See Cleaning section Is burner tube positioned too far away from the igniter Check that the burner tube is positioned correctly over box the ignition box See Maintenance Replacing the Burner Tube Clean burner See Annual Maintenance section Use a small paper clip to unclog any dirty ports Are the burner ports clean and fully open If problems cannot be corrected using these methods please contact the Customer Service Representative in your area using the contact information on our web site Log onto www weber com You must preheat the grill before you cook on it First open the lid and follow lighting instructions Close the lid and let the grill heat for about 10 minutes Then you will be ready to grill A light coating of oil will help brown your food evenly and keep it from sticking to the cooking grate Always brush or spray oil onto your food not directly onto the cooking grate We suggest that you grill with the lid down Why Because it reduces the chance of flare ups and cooks your food faster and more evenly When using a marinade sauce or glaze with a high sugar content or other ingredients that burn easily only brush it onto the food during the last 10 to 15 minutes of grilling GRILLING GUIDE tt ines andor Weight aoro oriin Steak fillet rump 2 cm 3 4 in thick o 8 minutes High
24. rs should go out during cooking turn off all of gas grill gas valves Open the lid and wait five minutes before A Do not store a spare or disconnected gas supply attempting to re light the gas flame while observing the cartridge cylinder under or near this grill Lighting instructions A Do not put a grill cover or anything flammable on or in A Do not use charcoal briquettes or lava rock in your the storage area under the grill Weber gas grill A Improper assembly may be dangerous Please carefully A While cooking never lean over the open grill or place follow the assembly instructions in this manual hands or fingers on the front edge of the cooking box A After a period of storage and or non use the Weber A Should an uncontrolled flare up occur move food away gas grill should be checked for gas leaks and burner from the flames until flaring subsides obstructions before use See instructions in this manual A Should a grease fire occur turn off all burners and leave for correct procedures lid closed until fire is out A Do not use a flame to check for gas leaks A The Weber gas grill should be cleaned thoroughly at A Do not operate your Weber gas grill if there are any regular intervals leaking gas connections A When cleaning valves or burners do not enlarge orifices Flammable materials should not be present within or ports approximately 60 cm of the top bottom back or sides of A Butane propane gas is not natural gas The conversion the
25. the burner This is to make sure all the burner ports are fully open A CAUTION Do not enlarge the burner ports when cleaning If the flames do not appear to be uniform throughout the burner tube follow the burner cleaning procedures Main Burner Cleaning Procedure Turn off the gas supply Remove the burner See Replacing Burner Tube Look inside the burner with a torch Clean the inside of the burner with a wire a straightened out coat hanger Check for gas leaks After a period of non use we recommend that you perform the following maintenance procedures for your safety A Inspect the burner for correct flame pattern Clean if necessary following the procedures outlined in the Annual Maintenance section of this manual Check all gas fittings for leaks WARNING You should check for gas leaks every time you disconnect and reconnect a 1 Check 1 Regulator to butane propane cartridge cylinder connection A WARNING If there is a leak at connection 1 remove butane propane cartridge cylinder Do not operate grill Use a different butane propane cartridge cylinder and re check for leaks with a soap and water solution If a leak persists after re tightening the butane propane cartridge cylinder turn OFF the gas DO NOT OPERATE THE GRILL Contact the Customer Service Representative in your Note All factory made connections have been area using the contact information on our thoroughly chec
26. xplosion resulting in serious personal injury or death and damage to property Regulator to butane propane cylinder connection 1 Regulator to butane propane cylinder connection A WARNING If there is a leak at connection 1 remove butane propane cylinder Do not operate grill Use a different butane propane cylinder and recheck for leaks with soap and water solution If a leak persists after retightening the butane propane cylinder turn OFF the gas DO NOT OPERATE THE GRILL Contact the Customer Service Representative in your area using the contact information on our web site Log onto www weber com Check 2 Valve to regulator connections A WARNING If there is a leak at connection 2 turn OFF the gas DO NOT OPERATE THE GRILL Contact the Customer Service Representative in your area using the contact information on our web site Log onto www weber com When leak checks are complete turn gas supply OFF at the source and rinse connections with water Regulator Regulator vent hole REPLACEMENT HOSE AND REGULATOR Hose France Hose Belgium Hose Reg The Netherlands Hose Reg Greece Italy Hose Reg Germany Austria Hose Reg Spain Denmark Portugal Hose Reg Sweden Hose Reg Switzerland Hose Reg Ireland Hose Reg United Kingdom Hose Reg Australia Hose Reg Norway Finland LIGHTING INSTRUCTIONS Lighting Summary lighting instructions are o
Download Pdf Manuals
Related Search