Teka DA-90 User's Manual
Contents
1. 120 mm reduction Support for tubecover Wall support Wall plugs 8 x 40 Long bolts 5 x 45 Wall plugs 6 x 30 Long bolts 04 x 30 26 4 x 018 washers 26 4 x O12 washers Screws 83 9 x 13 Screws M4 x 12 Clips POF FPO DD Installation Fig 1 Page 31 On installing the kitchen hood make sure that the Safety Instructions set out on page 10 are complied with To obtain optimum performance the external conduct must not be more than FOUR METRES long have no more than two 90 angles and its diameter must be at least 8120 1 Trace and drill the points for fitting the wall plugs onto the wall P 18 x 40 and J1 26 x 30 2 Centre the support H around the point marked J1 trace and drill the fixing point for the wall plug J2 06 x 30 3 Attach the Supports O to the wall using the long bolts Q 25 45 and the support with the long bolts I 04 x 30 as in figure 1 4 Hang the kitchen hood onto the mounted supports O Straighten the appliance by tightening the long bolts L M4 x 12 5 Trace the location of the wall plugs 08 x 40 through the inside of the kitchen hood 6 Take the kitchen hood off 7 Drill into the wall and fit the wall plugs R x 40 8 Hang the kitchen hood tighten the screws M M4 x 12 with the washers 06 4 x 212 and the long bolts S 5 x 45 with the washers T 06 4 x 18 9 Mount the tubecovers2. the fat dissolves and then rinsing them under the tap or using special anti grease products They can also be washed in a dishwasher In this case it is advisable to stack them vertically to avoid food residues to stick to them Cleaning in a dishwasher may damage the metallic surface blackening it although this will not affect its fat retention capacity Once clean leave them to dry off and then fit them onto the kitchen hood Changing light bulbs Proceed as follows e Unscrew the lamp cap trimming cover e Change the broken burnt out lamp Maximum lamp power is 20 W G 4 e Screw in the lamp cap trimming cover Problem solving Proceed with the following checks before calling the Technical Service Problem Possible cause n apis Mare cabins COO Ki Fia CODHe M 1790 Per Tegu a rb Spit d Prine Currie EI P Far denn Face aie nra ie eee oe ee Kel adn S IS nr miras Gh Pc id CP ae Pidal licere 34 chee cou rer bes 18 h aX gx conduet Page bie Ge Kon Iha larrqpos o rer gl uz ha arm Eire Tha lar pe are Charca da larga Hitman de lame Sizes and specifications See page 30 TEKA INDUSTRIAL S A reserves the right to make changes and corrections to its products as it deems necessary without altering their basic characteristics 12 Accesories supplied 150
3. 7 27 47 013430 15 96 Athens TEKA HELLAS A E 30 210 9760283 210 9712725 Hungary Budapest TEKA HUNGARY KFT 36 1 354 21 10 1 354 21 15 Indonesia Jakarta P T TEKA BUANA 62 21 39052 74 21 39052 79 Malaysia Kuala Lumpur TEKA K CHENTECHNIK MALAYSIA SDN BHD 60 3 762 01 600 3 762 01 626 Mexico Mexico D F TEKA MEXICANA S A DE C V 52 555 762 04 90 555 762 05 17 Poland Pruszk w TEKA POLSKA SP ZO O 48 22 738 32 80 22 738 32 89 Portugal Ilhavo TEKA PORTUGUESA LTDA 351 234 32 95 00 234 32 54 57 Russia Moscow TEKA RUS LLC 7 095 737 4689 095 737 4690 Singapore Singapore TEKA SINGAPORE PTE LTD 65 6 73 42415 6 73 46881 Thailand Bangkok TEKA THAILAND CO LTD 66 2 5164954 2 9021484 The Netherlands Zoetermeer TEKA B V 31 79 345 15 89 79 345 15 84 Turkey Istanbul TEKA TEKNIK MUTFAK A S 90 212 274 61 04 212 274 56 86 U K Abingdon TEKA PRODUCTS UK LTD 44 1235 86 19 16 1235 83 51 07 U S A Tampa TEKA USA INC 1 800 419 9344 813 228 8604 Venezuela Caracas TEKA ANDINA S A 58 212 291 28 21 212 291 28 25 Mod 0 000 Gr ficas Alhambra Teka Industrial S A Cajo 17 39011 Santander Spain Tel 34 942 35 50 50 Fax 34 942 34 76 94 http www teka net K CHENTECHNIK Teka K chentechnik GmbH Sechsheldener Str 122 35708 Haiger Germany Tel 49 2771 8141 0 Fax 49 2771 8141 10 http www teka net JKP 06 03
4. Rev 0705 Manual de Instrucciones Campanas Extractoras DA 90 Vr 01 Bedienungsanleitung Dunstabzugshauben DA 90 Vr 01 Instructions Manual Kitchen Hoods DA 90 Vr O1 Manuel d instructions Hottes aspirantes DA 90 Vr 01 Manual de Instru es Exaustores DA 90 Vr 01 OAHTIEX APHZELIZ KAMINS AAA TOIXOY DA 90 Vr 01 Kullanim Kilavuzu Davlumlaz DA 90 Vr 01 K CHENTECHNIK ENG Dear client Congratulations on your choice We are sure that this modern functional and practical appliance made with top quality materials will fully satisfy your needs Please read every section of this INSTRUCTIONS MANUAL before using your kitchen hood for the first time to ensure maximum performance from the appliance and to avoid breakdowns which may be caused by incorrect use as well as to allow any minor problems to be solved Store this manual as it will provide useful information about your kitchen hood at all times and will also help other people to use it Safety Instructions Please be aware of current local regulations with reference to domestic electrical fittings and gas eduction Verify that the tension and frequency of the network match those indicated on the label located inside the kitchen hood e The appliance must be connected to the network using a break switch with a universal cut off and minimum contact separation of 3 mm THE NET CABLE MUST NOT BE SUBTITUTED e Once the kitchen hood has bee
5. attaching the lower one to the support H as per the detail in figure 1 Lift the upper tubecover up to the desired height and mark its shape on the wall Remove the tubecovers 10 Fit the clips F to the support C 11 Centre the support C around the shape marked trace and drill the fixing points for the wall plugs E 26 x 30 Attach the support C with the long bolts D 04 x 30 12 Fit the part B if the inner tube not supplied is 2120 13 Attach the inner tube with a clamp not supplied to B or on to the motor s air outlet vent as the case may be 14 Once the inner tube is fitted fit the lower tubecover around the extractor fan outlet and attach the upper tubecover with the screws G 3 9 x 13 Active charcoal filters Optional When exterior gas extraction is not possible then the kitchen hood may be set to purify the air by recycling it through active charcoal filters The active charcoal filters have an active life of between three to six months depending on the individual conditions of use These filters cannot be washed nor regenerated They must be replaced once their useful life comes to an end Fig 2 Page 31 1 Fit the nut supports F onto the body of the kitchen hood 2 Attach the supports B with the screws E M4 x 12 onto the nuts F 3 Mount the carbon filters A introducing the anchorages into the grooves of the supports B 4 Fit the metal filters 5 Remove th
6. e tubecovers H supports G to the diffuser C 6 Fit the diffuser C into the inside of the lower tubecover H with the screws D M4 x 12 Mount the tubecovers H Fit the nut 13 ENG 30 Eaim trjv Tato Termin XapaxTgnetikny iope Teknlk 220 230 50 Yi afl 23x Hat Frekans Hz Dam Ed SAT AAC ure HET A A da Pr E A SAEI m sd moz cu Een n n PTS A XL pg IH n Fateacia V1 io bot 2 x 20 250 m a Caudal de aspiraci n MLN TL LAMPES MOTOR Lights Motor Pawer W Moor Valumo 2x20 250 B50 ms h thi Esczur ik 850 m h Pesbncia WI Tas Luges Motor 2 x 207 250 850 mh Caudal De Aspira o Ink Colici Tekh Cebrli 2 x AU 250 ASO h iban Uzenndeki teknik zellikler etiketini kontrol ediniz 31 TEKA GROUP COUNTRY CITY COMPANY CC PHONE FAX Austria Wien KUPPERSBUSCH GES M B H 43 1 86680 0 1 86680 72 Belgium Zellik B V B A K PPERSBUSCH S P R L 32 2466 8740 2466 7687 Chile santiago de Chile TEKA CHILE S A 56 2 273 19 45 2 273 10 88 China Shanghai TEKA CHINA LTD 86 21 6236 2375 21 6236 2379 Czech Republic Brno TEKA CZ S R O 42 05 4921 0478 05 4921 0479 France Saint Ouen Aum ne TEKA FRANCE SAS 33 0820 0
7. e you start to cook in order to ensure that a steady air flow has been established before fumes appear Allow the extractor fan to run for several minutes after you have finished cooking between 3 to 5 minutes in order to expel all the grease from the outlet duct This prevents the return of grease smoke and smells Programming timer Proceed as follows 1 Choose the required speed 2 Press timer The light will begin to flash 3 Select the intake time by pressing the corresponding button see figure 4 Once the required time has been selected press timer again to memorise the program During the programmed time you can change fan speed except to suction intensive The intensive speed can only be selected manually and will change to speed 2 after approximately 10 minutes 11 ENG Cleaning and maintenance During cleaning and maintenance work make sure the safety instructions set out on page 10 are complied with Cleaning the hood body If your kitchen hood is made from stainless steel use proprietary cleaners mentioned in the product instructions Never use metallic scourers nor abrasive or corrosive products Dry the kitchen hood using a cloth that does not produce fibres Cleaning the metal filters To remove the filters from their fittings press lightly on the locks and then pull them off The metal filters can be cleaned by soaking them in hot water with neutral detergent until ENG
8. es produced during food preparation It will be your responsibility if it is used for other purposes which may be dangerous The manufacturer cannot accept responsibility for damage caused by improper use of the appliance For repairs please contact the nearest TEKA Technical Assistance Service and always use genuine spare parts Repairs or modifications carried out by unqualified personnel can cause malfunctions or may damage the appliance putting your safety in danger This appliance is marked according to the European directive 2002 96 EC on Waste Electrical and Electronic Equipment WEEE This guideline is the frame of a European wide validity of return and recycling on Waste Electrical and Electronic Equipment Index Page Description of the appliance 11 Instructions for use 11 Cleaning and maintenance 12 Problem solving 12 Sizes and specifications 12 Accessories supplied 13 Installation 13 Active charcoal filters 13 Description of the appliance A Electronic programmer control box with buttons to control speed light and power in use indicators B Metal filters C Lamps 20 W G 4 D E Vertically adjustable tubecovers Instructions for use You may control the kitchen hood by operating the controls as shown in the diagram O O O 30min 20min 10min OOOO X Light Minimum speed Medium speed Maximum speed Extra fan Timer owitch on the extractor fan a few minutes befor
9. n installed ensure that the mains cable to the network is not in contact with any live metal edges Avoid connecting the appliance to conductors used as exits for fumes produced by a non electric energy source e g boilers chimneys etc f the extractor fan is going to be used simultaneously with equipment powered by a non electric energy source e g gas cookers then the room must have sufficient ventilation Excessive fat accumulation in the kitchen hood and metal filters is a fire risk and may 10 also cause dripping therefore the inside of the kitchen hood and the metal filters must be cleaned at least once a month The lower part of the kitchen hood must be fitted at least 50 cm over electric hobs and 65 cm over gas or mixed hobs FOLLOW THE HOBS MANUFACTURER S MINIMUM RECOMMENDATIONS Never leave gas hobs lit if not covered by a container The fat accumulated in the filters may drip or catch fire when the temperature increases Avoid cooking under the kitchen hood if the metal filters are not fitted e g while they are being cleaned in the dishwasher You must not produce flames under the kitchen hood Disconnect the appliance before any interior manipulation e g during cleaning or maintenance We recommend the use of gloves and to be extremely careful when cleaning the kitchen hood s interior Your kitchen hood is designed for domestic use and only for extraction and purification of fum
Download Pdf Manuals
Related Search