Napoleon Fireplaces N415-0232 User's Manual
Contents
1. This appliance should be installed and serviced by a qualified installer to conform with local codes Installation practices vary from region to region and it is important to know the specifics that apply to your area for example in Massachusetts State e The appliance off valve must be a T handle gas cock e The flexible connector must not be longer than 36 inches The installation must conform with local codes or in the absence of local codes with the National Fuel Gas Code ANSI Z223 1 INFPA 54 in the United States or CSA B149 1 Natural and Propane Installation code in Canada The appliance and its individual shut off valve must be disconnected from the gas supply piping system during any pressure testing of the system at test pressures in excess of 1 2 psig 3 5kPa This appliance must be isolated from the gas supply piping system by closing its individual manual shut off valve during any pressure testing of the gas supply piping system at test pressures equal to or less than 1 2 psig 3 5kPa The following clearances to combustible materials must be maintained Sides all around 24 inches 610mm Top 72 inches 1 830m e Always keep the appliance area clear and free from combustible materials gasoline and other flammable vapours and liquids e Donotlocate appliance where it can get excessively NATIONAL on FIREPLACE Ve suggest that our gas INSTITUTE hearth products be installed NE and serviced by profes e Do2. approved for elevations from 0 to 4500 feet in Canada and the U S When installing this appliance at an elevation above 4500 feet in the U S it may be necessary to decrease the input rating by changing the existing burner orifice to a smaller size Input should be reduced four percent 496 for each 1 000 feet beyond the 4 500 feet above sea level unless the heating value of the gas has been reduced in which case this general rule will not apply To identify the proper orifice size check with the local gas utility When installing this unit at an elevation above 4 500 feet in Canada check with local authorities Consult your local gas utility for assistance in determining the proper orifice for your location CLEANING STAINLESS STEEL Stainless steel tends to oxidize or stain in the presence of chlorides and sulfides particularly in coastal areas and other harsh environments such as the warm highly humid atmosphere around pools and hot tubs These stains could be perceived as rust but can be easily removed or prevented To provide stain prevention and removal wash all stainless steel surfaces every 3 4 weeks or as often as required with fresh water and or stainless steel cleaner Cleaning The Stainless Steel Surface Do not use abrasive cleaners or steel wool on the stainless steel parts Doing so will scratch the finish Surfaces should be cleaned with warm soapy water while the metal is still warm to the touch To clean stainless s
3. cylinders shall be ventilated by openings at the level of the cylinder valve and at floor level The effectiveness of the opening s for purposes of ventilation shall be determined with the LP gas supply cylinder s in place This shall be accomplished by one of the following One side of the enclosure shall be completely open OR For an enclosure having four sides a top and bottom a At least two ventilation openings at cylinder valve level shall be provided in the side wall equally sized spaced at 180 degrees 3 14 rad and unobstructed Each opening shall have a total free area of not less than Y square inch per pound 3 2 sq cm kg of stored fuel capacity and not less than a total free area of 10 square inches 64 5 sq cm b Ventilation opening s shall be provided at floor level and shall have a total free area of not less than inch per pound 3 2 sq cm kg of stored fuel capacity and not less than a total free area of 10 square inches 64 5 sq cm If ventilation openings at floor level are in a side wall there shall be at least two openings The bottom of the openings shall be at floor level and the upper edge no more than 5 inches 127mm above the floor The openings shall be equally sized spaced at 180 degrees 3 14 rad and unobstructed c Every opening shall have minimum dimensions so as to permit the entrance of a 1 8 inch 3 2mm diameter rod e Cylinder valves shall be readily accessible for hand operation A door on
4. not use this appliance if any part has been under water Immediately call a qualified service stonalssvhoarecartitigd n technician to inspect the unit and to replace any part of the control system and any gas control the U S by the National which has been underwater Fireplace Institute NFI as CERTIFIED NFI Gas Specialists www nficertified org www napoleonfireplaces com SPECIFICATIONS DIMENSIONS g Bumer Assembly Burner Assembly Outer Base A 508 mm 2 Pa _ Natural Mor Gas Hose not supplied AT Hbase INPUT MODEL FUEL MAX INPUT Btu Hr GPFN Natural Gas 60 000 GAS INLET PRESSURES CENTRE OF MINIMUM CLEARANCE TO COMBUSTIBLES PATIOFLAME Top of unit to ceiling um u 24 MAX OVERHANG j n3 P BM fet mor Ux Gum HR ur UB UT EP UN NP s s s s s www napoleonfireplaces com INSTALLATION WARNING when the appliance is being used with the optional tripod it must not be situated on a combustible surface nor can it be located below a combustible overhang The glass embers and the burner assembly are shipped together e Remove the glass embers and burner assembly and check for damage DO NOT install damaged components The glass embers may have sharp edges wear safety glasses and gloves when handling e Place the appliance on a level secure surface in desired location This location must be adjacent to the gas supply line or cylinder NOTE Minimu
5. was made through an authorized NAPOLEON dealer your heater is subject to the following conditions and limitations This limited warranty applies only while the unit remains at the site of original installation and only if the unit is installed in Canada or the United States This factory warranty is non transferable and may not be extended whatsoever by any of our representatives Installation must be done in accordance with the installation instructions included with the product and all local and national building and fire codes This limited warranty does not cover damages caused by misuse lack of maintenance accident alterations abuse or neglect and parts installed from other manufacturers will nullify this warranty This limited warranty further does not cover any scratches dents corrosion or discoloring caused by excessive heat abrasive and chemical cleaners mechanical breakage of logs and embers In the first year only this warranty extends to the repair or replacement of warranted parts which are defective in material or workmanship provided that the product has been operated in accordance with the operation instructions and under normal conditions After the first year with respect to the President s Limited Lifetime Warranty NAPOLEON may at its discretion fully discharge all obligations with respect to this warranty by refunding to the original warranted purchaser the wholesale price of any warranted but defective parts A
6. ATOR NG UNITS ONLY ACCESSORIES 10 i 2 Eu EN 6 LAE 2 c REF Ho haa haul mE LN www napoleonfireplaces com 12 TOS yet SEM Pee aa wee wu ZZ T YY Str t N Qh q k FAS SENE Ara lt 2 E n gt Me CR U IVa FIT El Y UN l e m www napoleonfireplaces com gt im O ud E I Q gt Q N Q S 2 a lt q o O G o0 c le O E Lo Lem Q O gt i Lem cC 19 Lo Q 9 YN 2 0 lt a lt H 13 SERVICE HISTORY Service Performed Special Concerns Service Technician www napoleonfireplaces com Dealer Name 14 Notes www napoleonfireplaces com
7. INSTALLER LEAVE THIS MANUAL WITH THE APPLIANCE CONSUMER RETAIN THIS MANUAL FOR FUTURE REFERENCE INSTALLATION AND QUALITY FIREPLACES OPERATING INSTRUCTIONS Award Winning Products Q Ye e NAPOLEON CERTIFIED UNDER CANADIAN AND AMERICAN NATIONAL STANDARDS CR97 003 CAN1 2 21 M85 IAS U S 4 96 PATIOFLAME OUTDOOR GAS FIREPLACE GPFGN NATURAL GAS GPFGP PROPANE CERTIFIED FOR CANADA AND UNITED STATES USING ANSI CSA METHODS SAFETY INFORMATION WARNING If the information in these instructions are not followed exactly a fire or explosion may result causing property damage personal injury or loss of life Do not store or use gasoline or other flammable vapors and liquids in the vicinity of this or any other appliance WHAT TO DO IF YOU SMELL GAS Do not try to light any appliance Do not touch any electrical switch do not use any phone in your building Immediately call your gas supplier from a neighbour s phone Follow the gas supplier s instructions If you cannot reach your gas supplier call the fire department Installation and service must be performed by a qualified installer service agency or II III the supplier XXXXXX000000 MODEL NO APPLY SERIAL NUMBER LABEL FROM CARTON Serial No Wolf Steel Ltd 24 Napoleon Rd Barrie ON L4M 4Y8 Canada 103 Miller Drive Crittenden Kentucky USA 41030 Phone 705 721 1212 e Fax 705 722 6031 e www napoleonfireplaces com e a
8. NG PRODUCT IMPROVEMENTS NAPOLEON IS A REGISTERED TRADEMARK OF WOLF STEEL LTD PATENTS U S 5 303 693 801 CAN 2 073 411 2 082 915 WOLF STEEL LTD www napoleonfireplaces com WARNING For Outdoor Use Only WARNING Improper installation adjustment alteration service or maintenance can cause injury or property damage Read the installation operating and maintenance instructions thoroughly before installing or servicing this gas patio flame SAFE OPERATING PRACTICES THIS APPLIANCE IS HOT WHEN OPERATED AND CAN CAUSE SEVERE BURNS IF CONTACTED e Installation and repair should be done by a qualified service person The appliance should be inspected before use and at least annually by a qualified service person More frequent cleaning may be required as necessary It is imperative the control compartment burners and circulating air passageways of the appliance be kept clean e Do not operate appliance before reading and understanding operating instructions Failure to operate appliance according to operating instructions could cause fire or injury e Risk of burns The appliance should be turned off and cooled before servicing e Do not install damaged incomplete or substitute components e Young children should be carefully supervised when they are in the vicinity of the appliance Toddlers young children and others may be susceptible to accidental contact burns A physical barrier is recommended if there are at risk individuals
9. ON WARNING If you do not follow these instructions exactly a fire or explosion may result causing property damage personal injury or loss of life Upon completing the gas line connection a small amount of air will be in the lines When first lighting the burner it will take a few seconds for the lines to purge themselves of this air Once the purging is complete the burner will light and operate as indicated in the instruction manual Subsequent lighting of the appliance will not require such pruging unless the gas supply has been disconnected FOR YOUR SAFETY READ BEFORE LIGHTING A This appliance must be lit by hand while following these instructions exactly B Before operating smell all around the appliance area for gas and next to the floor because some gas is heavier than air and will settle on the floor C Use only your hand to turn the manual gas control valve Never use tools If the valve will not turn by hand do not try to repair it Call a qualified service technician Force or attempted repair may result in a fire or explosion D Do not use this appliance if any part has been under water Immediately call a qualified service technician to inspect the appliance and replace any part of the control system and any gas control which has been underwater WHAT TO DO IF YOU SMELL GAS e Donottry to light any appliance e Do not touch any electric switch Do not use any phone in your building e Immediately call your
10. fter the first year NAPOLEON will not be responsible for installation labour or any other costs or expenses related to the reinstallation of a warranted part and such expenses are not covered by this warranty Notwithstanding any provisions contained in the President s Limited Lifetime Warranty napoleon s responsibility under this warranty is defined as above and it shall not in any event extend to any incidental consequential or indirect damages This warranty defines the obligations and liability of NAPOLEON with respect to the NAPOLEON gas appliance and any other warranties expressed or implied with respect to this product its components or accessories are excluded This limited warranty does not cover damages resulting from the use of components not supplied with the appliance or the use of fuel other than those specified Any damages to appliance due to weather long periods of dampness condensation damaging chemicals or cleaners will not be the responsibility of NAPOLEON The bill of sale or copy will be required together with a serial number and a model number when making any warranty claims from your authorized dealer The warranty registration card must be returned within fourteen days to register the warranty NAPOLEON reserves the right to have its representative inspect any product or part thereof prior to honouring any warranty claim ALL SPECIFICATIONS AND DESIGNS ARE SUBJECT TO CHANGE WITHOUT PRIOR NOTICE DUE TO ON GOI
11. gas supplier from a neighbour s phone Follow the gas supplier s instructions e fyou cannot reach your gas supplier call the fire department LIGHTING INSTRUCTIONS 1 Locate the manual gas control valve 2 Place the firestarter near the burner ports on top of the burner Light the firestarter For a Natural Gas unit turn on the ON OFF valve slowly at the unit For a LP unit turn the valve in the LP tank counter clockwise all the way and then turn on the ON OFF valve slowly at the unit 3 If the burner does not light before the fire starter goes out immediately turn the gas off 4 Wait at least five 5 minutes to clear out any gas Then smell for gas including near the base of the unit If you smell gas STOP Refer to the safety information in the owner s manual If you don t smell gas repeat step 2 TO TURN OFF GAS Turn the ON OFF valve to the off position at the unit for Natural Gas unit For LP unit turn the ON Off valve to the off postion at the unit and then turn the valve on the LP tank to the OFF position clockwise Note The propane regulator in this appliance is equipped with a low flow protection device Unless the propane cylinder valve is opened before the appliance valve the gas flow will be reduced resulting in a very small flame To reset this device shut off the appliance valve then the propane cylinder valve Next diconnect the regulator adaptor from the tank and then reconnect Follow the lighting proced
12. in the house To restrict access to an appliance or stove install an adjustable safety gate to keep toddlers young children and other at risk individuals out of the vicinity and away from hot surfaces e Ensure you have incorporated adequate safety measure to protect infants toddlers from touching hot surfaces e Under no circumstances should this appliance be modified e Keep the packaging material out of reach of children and dispose of the material in a safe manner As with all plastic bags these are not toys and should be kept away from children and infants e Do not leave appliance unattended when in use e For Outdoor use only e This appliance must not be used for cooking e This unit is not for use with solid fuel e Improper installation adjustment alteration service or maintenance can cause injury or property damage Read the installation operating and maintenance instructions thoroughly before installing or servicing this equipment e This appliance shall be used ONLY outdoors in a well ventilated space and shall NOT be used inside a building garage or any other enclosed area e Cylinders must be stored outdoors in a well ventilated area out of reach of children Disconnected cylinders must have threaded valve plugs tightly installed and must not be stored in a building garage or any other enclosed area e Storage of this appliance indoors is permissible only if it has been disconnected from its fuel supply natural gas
13. line or LP gas cylinder e fitis evident there is excessive abrasion or wear or the hose is cut it must be replaced prior to the appliance being put into operation e Clothing or other flammable materials should not be hung from the appliance or placed on or near the appliance e Any guard or other protective device removed for servicing the appliance must be replaced prior to operating the appliance e Inspect the fuel supply connection for signs of leakage including the hose for LP models before each use of the appliance e The pressure regulator and hose assembly supplied with LP models must be used Replacement pressure regulators and hose assemblies must be those specified in this manual e The LP gas supply cylinder used with LP models must be constructed and marked in accordance with the specifications for LP gas cylinders as required by the U S Department of Transportation DOT or the Canadian Transport Commission CTC e The LP gas cylinder supply system must be arranged for vapour withdrawal e TheLP gas cylinder used must include a collar to protect the cylinder valve e When an LP model is not in use the LP gas must be turned off at the supply cylinder e To extend the life of your appliance protect and cover it from the elements when not in use e This product must be installed by a licensed plumber or gas fitter when installed within the commonwealth of Massachusetts www napoleonfireplaces com GENERAL INFORMATION
14. m clearances to combustible construction must be maintained see SPECIFICATIONS section WARNING vou must have clear and easy access to the on off valve AFTER the appliance is installed and connected to the gas supply in order to safely turn off the burner THE ON OFF GAS VALVE IS USED TO TURN THE BURNER ON AND OFF NATURAL GAS Connect the incoming gas supply line to the on off gas valve of the appliance Make certain ALL gas connections are tight turn the on off valve at the unit slowly to the on position and use soapy water to test for leaks as indicated in the diagrams DO NOT USE AN OPEN FLAME Burner Assembly A Manual Gas Valve on off LP PROPANE GAS Attach cylinder retaining bracket supplied to the base of the cylinder Then secure to the surface to which it sits Cylinder should be on a level surface This appliance has been designed for use with a 20lb 9 1kg or a 30lb 13 6kg size propane cylinder only not supplied e Make sure cylinder valve is in its full off position Turn clockwise to stop e Check cylinder valve features to ensure it has proper external mating threads Cylinder Valve Marked USE WITH TYPE 1 e Inspect hose shipped with the unit for damage Never attempt to use damaged or plugged equipment See your local LP Gas Dealer for repai
15. rs e After inspecting the LP hose shipped with the unit connect the end with the female fitting on the hose to the male fitting on the on off gas valve at the end of the flex tube Tighten fittings using 2 wrenches e When connecting regulator assembly to the cylinder valve hand tighten black QCC1 nut clockwise to a positive stop DO NOT use a wrench to tighten Use of a wrench may damage the quick closing coupling nut and result in a hazardous condition e Locate the hose out of pathways where people may trip over it or in areas where the hose may be subject to accidental damage e Open cylinder valve fully counter clockwise Turn the on off valve at the unit slowly to the on position and use a soapy water solution to check all connections for leaks as indicated in the diagrams before attempting to light the appliance If a leak is found turn tank valve off and do not use the appliance until repairs can be made DO NOT USE AN OPEN FLAME K ye m Manual Gas Valve on off Oylinder Retaining Bracket www napoleonfireplaces com ENCLOSURES FOR LP GAS SUPPLY SYSTEMS WARNING During the initial purging and subsequent lightings NEVER allow gas valve to remain in the Open position without first placing and igniting the firestarter If you build an enclosure for an LP gas cylinder follow these recommended specifications You must also follow local codes e Enclosures for LP gas supply
16. sk napoleonproducts com Na415 0232 AUG 18 10 NAPOLEON products are designed with superior components and materials and are assembled by trained craftsmen who take great pride in their work Every component has been thoroughly inspected by a qualified technician before packaging and shipping to ensure that you the customer receive the quality product you expect from NAPOLEON NAPOLEON GAS APPLIANCE 5 YEAR LIMITED WARRANTY All stainless steel components of your new NAPOLEON gas appliance are warranted against defects for five years All parts such as gas valves logs glass embers gasketing are covered and NAPOLEON will provide replacement parts free of charge during the first year of limited warranty Labour related to warranty repair is covered free of charge during the first year Repair work however requires the prior approval of an authorized company official Labour costs to the account of NAPOLEON are based on a predetermined rate schedule and any repair work must be done through an authorized NAPOLEON dealer CONDITIONS AND LIMITATIONS NAPOLEON warrants its products against manufacturing defects to the original purchaser only Registering your warranty is not necessary Simply provide your proof of purchase along with the model and serial number to make a warranty claim NAPOLEON reserves the right to have its representative inspect any product or part thereof prior to honouring any warranty claim Provided that the purchase
17. the enclosure to gain access to the cylinder valve is acceptable provided it is QCC1 non locking and can be opened without the E CU mP use of tools nMi e There shall be a minimum clearance of 2 inches 50 8mm between the lower surface of the X floor of the LP gas supply cylinder enclosure Propane Regulator L ss and the ground Hose Manual Gas L U valve on off e The design of the enclosure shall be such T SL Natural Gas ylinder Retaining Supply Line that 1 the LP gas supply cylinder s can be Bracket not supplied connected disconnected and the connections inspected and tested outside the cylinder enclosure and 2 those connections which could be disturbed when installing the cylinder s in the enclosure can be leak tested inside the enclosure e Be certain to mount or set the LP gas cylinder on a flat surface and restrain it to prevent it from tipping e Purge the gas supply line of any trapped air prior to the first firing of the unit CYLINDER RETAINING BRACKET 1 Fasten the bracket to the bottom of the propane bottle using bolt J and nut supplied f A 2 Tighten the lag screw into the mounting surface leaving approximately of thread above the surface SEE THRy 3 Slide propane bottle into position so that the bracket slides under the head of the lag screw 4 Tighten
18. the lag screw onto the bracket 5 For fastening to a concrete surface a concrete anchor will be required Not supplied www napoleonfireplaces com FINISHING GLASS MEDIA INSTALLATION WARNING Glass embers may have sharp edges wear safety glasses and gloves when handling Do not change or substitute the glass ember material provided with this fireplace If replacing use only replacement glass embers available from your local authorized dealer distributor WARNING Glass embers may have a fine oil residue that needs to be cleaned prior to installation Clean the glass with mild dish soap drain rinse thoroughly and dry before installing 1 Carefully pour the appliance glass media onto the appliance log support as shown 2 Spread the glass evenly over the pan burner The distribution of clear glass over the burner pan will influence flame height OPTIONAL MKR ROCK INSTALLATION WARNING Real rocks must not be used in this appliance Heat will cause them to explode 1 Remove the glass media from your appliance 2 Place the 4 notched rocks and 2 clusters on the edge of the burner pan as shown making sure not to cover any ports 3 Place the remaining refractory rocks on and around the burner as desired There are not set locations 4 Spread the lava rock removed in Step 1 and evenly distribute it around the rocks www napoleonfireplaces com OPERATI
19. ure ensuring the propane cylinder valve is opened before the unit is www napoleonfireplaces com 10 MAINTENANCE The appliance should be inspected before initial use and inspected and cleaned at least annually by a qualified field service person e Tampering is DANGEROUS and voids all warranties Any component that is found to be faulty must be replaced with an approved component e To obtain proper operation it is imperative that the burner flame characteristics are steady not lifting or floating Check the burner flame patterns with the image e Periodically remove the glass embers and examine the burner If dirty clean with a soft brush Also examine the area around the burner air shutter Any dirt or foreign material such as spider webs or nests in this area should be removed This will ensure long life and trouble free operation When the appliance is put back in service check the burner flame patterns with the image Reinstall the glass embers as shown in the glass media installation e Periodically check the hose connecting the LP gas cylinder to ensure it is not damaged in any way During the winter months in cold weather climates it is recommended to disconnect the Patioflame and store it in a cool dry place Do not store the propane tank inside For the remainder of the year protect and cover your Patioflame from rain freezing rain and snow HIGH ELEVATION INSTALLATION This listed gas appliance is tested and
20. urfaces use a stainless steel or non abrasive cleaner Always wipe in the direction of the grain Over time stainless steel parts discolour when heated usually to a golden or brown hue This discolouration is normal and does not affect the performance of the appliance www napoleonfireplaces com 11 REPLACEMENTS Contact your dealer or the factory for questions concerning prices and policies on replacement parts Normally all parts can be ordered through your Authorized dealer distributor FOR WARRANTY REPLACEMENT PARTS A PHOTOCOPY OF THE ORIGINAL INVOICE WILL BE REQUIRED TO HONOUR THE CLAIM When ordering replacement parts always give the following information e Model amp Serial Number of appliance e Installation date of appliance e Part number e Description of part e Finish IDENTIFIES ITEMS WHICH ARE NOT ILLUSTRATED FOR FURTHER INFORMATION CONTACT YOUR AUTHORIZED DEALER WARNING Failure to position the parts in accordance with this manual or failure to use only parts specifically approved with this appliance may result in property damage or personal injury COMPONENTS REF PART NO DESCRIPTION OOOO LOG SUPPORT BURNER ASSEMBLY ORIFICE BRACKET PROPANE ORIFICE 43 NATURAL GAS ORIFICE 25 60 ORIFICE blank NG 460 ORIFICE blank LP GLASS EMBERS BRONZE 7 W175 0210 FLEX c w SHUT OFF STAINLESS STEEL W530 0023 PROPANE REGULATOR HOSE ASSEMBLY LP UNITS ONLY NG REGUL
Download Pdf Manuals
Related Search