Marvel Industries 6OSWCE User's Manual
Contents
1. Since bottles are not stacked on top of each other you can easily view and access your inventory without disturbing other bottles see Figure 5 6OSWCE WINE CELLAR FEATURES Front Bottles Necks Facing Rear Rear Bottles Necks Facing Front Figure 4 wm IL a Aor F i J L en W Figure 5 CARE AND CLEANING OF YOUR OUTDOOR WINE CELLAR Condenser The condenser tubing inside the cabinet does not require frequent cleaning however satisfactory cooling depends on adequate ventilation over the coils Be sure that noth ing obstructs the required air flow openings in front of the cabinet At least once or twice a year brush or vacuum lint and dirt from the condenser for efficient performance by unscrewing the grille on the bottom front of the cabinet Cabinet The stainless steel cabinet can be washed with either a stainless steel cleaner or a mild soap and water and thoroughly rinsed with clear water NEVER use abrasive scouring cleaners Interior Wash interior compartment with mild soap and water Do NOT use an abrasive cleaner solvent polish cleaner or undiluted detergent Roll out Racks Tha racks may be cleaned with mild soap and water and2. a soft cloth Do NOT use any abrasive cleaners Door Gasket The vinyl gasket may be cleaned with mild soap and water a baking soda solution or a mild scouring powder Light Bulb Replacement WARNING DISCONNECT THE POWER CORD BEFORE ATTEMPTING LIGHT BULB REPLACEMENT Failure to do so may result in an electrical shock that could severely injure you This product uses two 6 watt light tubes to illuminate the interior of the wine cellar The light tube is a very reliable electrical component but should it not function properly please call the dealer you purchased your wine cellar from for a replacement light tube Use only an original equip ment light tube from your dealer or Marvel Industries Do NOT under any circumstance use a light tube that exceeds 10 watts To replace a light tube use a hex head driver remove the two hex head screws that hold a cover plate over the back section of the light tube Set the screws and cover plate aside for reassembly later Using a small flat blade screwdriver gently lever the front section of the light tube down to allow it to be pulled clear of the light housing Disconnect the two insulated electrical connectors from the cabinet s electrical cable and discard the old light tube Reconnect the electrical connector of the new light tube to the cabinet s electrical cable connectors Make sure it is secure and fully installed Carefully realign the light tube s electrical terminal ba
3. ELLAR If You Do Need Service If you do need service contact your dealer or Marvel Indus tries In any correspondence refer to the model number and serial number of your unit which is located on the upper left hand side of the wall liner Retain your proof of purchase You may want to record these numbers in the space below For Your Records Date of Purchase Dealer s Name Dealer s Address Dealer s City Dealer s State Dealer s Zip Appliance Serial Number Model Number Date Warranty Card Sent Must be within 10 Days of Purchase How to Obtain Service Your outdoor wine cellar requires little service because the best and most up to date materials equipment and qual ity methods are employed throughout the manufacturing process If trouble occurs during normal operation first check the troubleshooting chart on the previous page to see if any of these simple steps may correct the problem If service becomes necessary 1 Ifthe product is within the first year warranty period please call Marvel Customer Service at 800 428 6644 for directions on how to obtain warranty coverage in your area 2 Ifthe product is outside of the first year warranty period Marvel Customer Service can provide recom mendations of service centers in your area A listing of authorized service centers is also available at www lifeluxurymarvel com under the service and support section 3 In all correspondence regarding service be sur
4. MARVEL OUTDOOR REFRIGERATED WINE CELLAR Installation Operation and Maintenance Instructions Outdoor Refrigerated Wine Cellar 6OSWCE life luxury marvel An AGA Company UNPACKING YOUR OUTDOOR WINE CELLAR Remove Packaging Your outdoor wine cellar has been packed for shipment with all parts that could be damaged by movement securely fas tened Before using be sure all packing materials and tape have been removed Important Keep your carton packaging until your wine cabinet has been thoroughly inspected and found to be in good condition If there is damage the packaging will be needed as proof of damage in transit Note to Customer This merchandise was carefully packed and thoroughly inspected before leaving our plant Responsibility for its safe delivery was assumed by the retailer upon acceptance of the shipment Claims for loss or damage sustained in transit must be made on the retailer as follows e Exterior and Concealed Damage Any damage must be reported immediately to your retailer DO NOT RETURN DAMAGED MERCHANDISE TO THE MANUFACTURER FILE THE CLAIM WITH THE RETAILER REMINDER IT IS IMPORTANT THAT YOU SEND IN YOUR WARRANTY RECORD CARD IMMEDIATELY AFTER TAKING DELIVERY OF YOUR REFRIGERATED DRAWERS Outdoor 60SWCE Wine Cellar Specifications 170 bs 54 Wine Bote 40 65 F Dimensions HxWxD in 34 x 23 7 8 x 24 1 4 Power Supply 115V supplied with a 15 amp plug Select Location The prope
5. This will reset all audible and display alarms Sabbath Mode Your wine cellar is equipped with a Sabbath Mode feature By activating this mode you will be disabling all displays audible alarms and lights To activate the Sabbath Mode press and hold the SET button while pressing the F C button four 4 times within seven 7 seconds To deactivate Sabbath Mode repeat the process Sabbath Mode will automatically deactivate after 72 hours Insert Wine Bottles The six 6 roll out shelves each hold eight 8 bottles See Figure 3 for typical wine bottle spacing Tall bottles should not be loaded on the bottom rack because they may pre vent the door from closing Loading Tips and Suggestions Position white wines on the middle or lower racks and red wines on the upper racks see Figure 4 Keep wines that you plan to use for everyday drinking and entertaining on the front half of the racks where labels are completely visible Place wines for aging or longer term storing in the rear Roll out Racks The six 6 roll out wine racks may be pulled out ap proximately 14 inches to facilitate adding or removing bottles Do NOT lean on or press down heavily on the wine shelves Doing so may damage the shelves and the wine bottles stored on them Pull the wine racks out gently and carefully to minimize unsettling your wine collection AVOID pulling out more than one rack at any time to maintain stability Single Bottle Racks
6. ance will start upon initial plug in The LED will flash amber upon initial plug in due to your unit being powered on at the factory to verify performance and then powered off The Sentry System refrigeration monitor senses a power outage has occurred and relays this infor mation to you when you initially power up your appliance This is normal and pressing the ON OFF button will reset this alarm function If your appliance s control has been shut off i e unit plugged in interior lights operate display blank unit must be turned on To turn on your appliance push and hold for five 5 seconds the ON OFF button located on the display panel see Figure 2 Once loaded with wine bottles allow at least 48 hours for the unit to stabilize before making any adjustments to the initial setting Set Your Temperature Mode This product can display either Fahrenheit or Celsius To do so press the F C button on the display panel Set the Controls The available temperature range of the unit is from 40 to 65 degrees F The temperature set point is initially set in the factory at 55 degrees F The temperature set point can be lowered or raised by first pushing the SET button on the display pad A SET icon will be displayed Pushing either the WARMER or COLDER buttons located on the display pad will raise or lower the set temperature by one 1 degree F or C depending on your setting As with any r
7. anty or assume any other obligation for Marvel Industries These warranties apply only to products used in any of the fifty states of the United States and the District of Columbia To obtain performance of this warranty report any defects to Marvel Industries PO Box 997 Richmond Indiana 47375 0997 Phone 800 428 6644 Marvel Industries PO Box 997 Richmond IN 47375 0997 800 428 6644 An AGA Company 41010819 Rev B 03 03 08 www lifeluxurymarvel com All specifications and product designs subject to change without notice Such revisions do not entitle the buyer to corresponding changes improvements additions replacements or compensation for previously purchased products
8. ck into the rear of the light enclosure channel making sure not to crimp them Gently insert the light tube along the length of the light enclosure channel Press the light tube gently into the light enclosure channel Only a small part of the light tube should project below the ceiling of the wine cel lar DO NOT USE A HAMMER TO FIT THE LIGHT TUBE Place the light tube terminal cover plate back in the original position on the light enclosure s flange Reuse the original two screws to secure it in place Plug the wine cellar into the electrical socket Check to see if the light tube operates properly Your light tube s replacement is complete The light tubes are not covered by your warranty Replace ment tubes can be obtained from your dealer or from Marvel Industries In the Event of a Power Failure If a power failure occurs try to correct it as soon as pos sible Minimize the number of door openings while the power is off so as not to adversely affect the unit s tem perature Before Calling for Service TROUBLESHOOTING YOUR OUTDOOR WINE CELLAR Before calling for service check the troubleshooting table on this page This table lists possible problems unnecessary service call PROBLEM Cabinet light not working Appliance will not run Appliance runs too long Moisture collects inside Moisture collects on out side surface Interior too hot too cold Sentry System refrigeration monitor activated
9. e to give the model number serial number and proof of purchase 4 Try to have information or description of the nature of the problem how long the unit has been running the room temperature and any additional information that may be helpful in quickly solving the problem HOUSEHOLD PRODUCT WARRANTY Entire Product Limited One Year Parts and Labor Warranty Marvel warrants that it will supply all necessary parts and labor to repair or replace in the end user s home or office any component which proves to be defective in material or workmanship subject to the condition and exclusions stated below for a period of one year from the date of purchase by the end user Additional Second Through Fifth Year Limited Parts Only Warrranty During the four years following expiration of the one year limited warranty Marvel will supply replacement parts for the hermetically sealed refrigeration system which consists of the compressor condenser drier accumulator bypass valve connecting tubing and the evaporator that are proven to be defective due to workmanship or materials subject to the conditions and exclusions below The above warranties do not cover e Shipping costs of replacement parts or returned defec tive parts e Customer education or instructions on how to use the appliance e Any content loss due to product failure e Removal or installation Nor do the above warranties cover failure of this product or its compon
10. efrigeration product there is a slight temperature variance at different locations within the cabinet Adjustable Temperature Control The temperature control is fully adjustable from the low forties to the mid sixties The range allows flexibility of temperature preferences Sentry System O Power Failure Flashing Amber High Low Temp Red Figure 2 Reset OFF F Steady Amber Interior Light and Switch The interior light makes it easy to view your wine labels and enhances the display of your collection The light will always come on when the door is opened Warning Alarms Your wine cellar has been fitted with a Sentry System refrigeration monitor This monitor will let you know if your cellar is not functioning properly for optimum wine storage Door Ajar Alarm If the door has been left open for over five 5 minutes the alarm will sound and the LED will flash green This will stop as soon as the door is closed High and Low Temperature If your unit reaches temperatures outside normal operating temperatures for your set point for more than one 1 hour an alarm will sound and the LED will flash red This will warn you that your wines have seen temperatures that may not be conducive for long term storage Power Failure If your unit experiences a power failure the LED will flash amber until the alarm is reset Reset Alarms Press the ON OFF button for approximately one 1 sec ond
11. ents due to e Transportation or subsequent damages e Commercial use or use other than normal household or small office e Improper installation misuse abuse accident or alteration use on wiring not conforming to electrical codes low or high voltages failure to provide neces sary maintenance or other unreasonable use Parts or Service Not Supplied or Designated by Marvel The above warranties also do not apply if e The original bill of sale deliver date or serial number cannot be verified e Defective parts are not returned for inspection if so requested by Marvel e The refrigeration equipment is not in the possession of the original end use purchaser The warranties set forth herein are the only warranties extended by Marvel Industries Any implied warranties in cluding the implied warranty of merchantability are limited to the duration of these express warranties In no event shall Marvel Industries be liable for any consequential or incidental damages or expenses resulting from breach of these or any other warranties whether express or implied Some states do not allow the exclusion or limitation of con sequential damages or a limitation on how long an implied warranty lasts so the above exclusion or limitation may not apply to you This warranty gives you specific legal rights and you may have other rights that may vary from state to state No person firm or corporation is authorized to make any other warr
12. r location will ensure peak performance of your appliance Choose a location where the unit will be out of direct sunlight and away from heat sources Best perfor mance will be maintained when installed within the follow ing parameters Unit should be operated in a properly ventilated area with ambient temperatures above 40 degrees and below 100 degrees Fahrenheit Cabinet Clearance Ventilation is required from the bottom front section of the unit Keep this area open and clear of any obstructions Adjacent cabinets and countertop can be installed on top back and sides of the unit as long as the grille and door access remain unobstructed An opening of 24 inches is required between cabinets and a depth of 24 inches Leveling Legs Adjustable legs at the front corners of the unit should be set so the unit is firmly positioned on the floor and the front is raised just enough so that the door closes easily when opened about halfway Turn leveling legs clockwise to raise unit counterclockwise to lower it Door Hinge Reversing You can change the door swing from right to left hand very easily Simply unscrew the top and bottom hinge pin lift the door off the bottom hinge and switch the hinges to the other side Screw the hinge pin back in what is now the bottom hinge unscrew the hinge pin in what is now the top hinge replace door and screw the pin back in the top hinge INSTALLING YOUR OUTDOOR WINE CELLAR a WARNING e Do no
13. t splash or spray water from a hose on the re frigerator Doing so may cause an electrical shock which may result in severe injury or death e This unit should not under any circumstances be ungrounded Grounding Method This product is factory equipped with a power supply cord that has a three pronged grounded plug It must be plugged into a mating grounding type receptacle in ac cordance with the National Electrical Code and applicable local codes and ordinances see Figure 1 If the circuit does not have a grounding type receptacle it is the re sponsibility and obligation of the customer to exchange the existing receptacle in accordance with the National Electri cal Code and applicable local codes and ordinances The third ground prong should not under any circumstances be cut or removed All U L listed refrigerated products are equipped with this type of plug A ground fault circuit interrupter electrical receptacle is to be used to supply electrical power to the refrigerator for outdoor applications Contact an electrician if you need to install one to supply electrical power to your outdoor refrigerator Electrical Connection Check the serial nameplate for the correct power supply Use only the electrical power supply specified on the serial nameplate DO NOT USE AN EXTENSION CORD Figure 1 SENTRY SYSTEM REFRIGERATION MONITOR ON OFF 55 Set Press and Hold Start Your Appliance Your appli
14. that you can remedy without difficulty to avoid an POSSIBLE CAUSES SOLUTIONS 1 Interior needs cleaning 1 Cabinet not level 2 Weak floor 1 Cabinet not level 2 Weak floor 1 Tube burned out 2 No power at outlet 1 ON OFF button pressed Help Prevent Tragedies 2 Power cord not plugged in Each year children die because they climb inside a discarded refrigera t electrical outlet z Boo a tion product get trapped inside and 4 House fuse blown suffocate Take precautions to prevent 1 Prolonged door openings such tragedies by removing the door 3 Controlsertoocold or by taping or chaining it shut before discarding 3 Condenser needs cleaning 1 Too many door openings 2 Prolonged door openings 3 Hot humid weather increases condensation 4 Control improperly set 1 Hot humid weather increases condensation as humidity decreases moisture will disappear 2 Control improperly set 1 Control improperly set 1 See Warning Alarms on page 3 2 See Sentry System Control Quick Reference 3 Temperature alarm may occur after user selected temperature set point changes in excess of 10 degrees F or during heavy usage conditions This is normal and not a fault of the appliance The Sentry System is monitoring the duration of large swings in temperature to protect your contents and may alert you to this event See Reset Alarms on page 4 OBTAINING SERVICE FOR YOUR OUTDOOR WINE C
Download Pdf Manuals
Related Search