Lifetime Products Stepper Machine 101301 User's Manual
Contents
1. Do not tighten completely until after step 5 Two Adults Required for Y A Assembly y e Remove Nylock Nut HA and Washer HE from the bottom two Blue Tubes B Place a new Blue Tube B at the bottom of the red pentagon assembly Secure the Blue Tube B and Red Tubes A to the existing joints by replacing the Washer HE and the Nylock Nut HC Tighten joint a joint b and joint c completely Two Adults Required for Assembly Joint b Joint a Make sure all the bolts on the bottom go in the direction shown outside in to prevent injury C6 Add one of the assemblies completed in step 2 to the assembly completed in step 5 Two Adults Required for Use the instructions from steps 3 4 and 5 to attach the Assembly assemblies Continue adding the assemblies from step 2 to complete the circle Remove the Standard Nut HD and Washers HE at joint d and add a Large Blue Tube B 1 Replace the Washer and Nut however do not completely tighten joint d repeat the same process for joint e Remove the Standard Nut HD and Washer HE at joint f Place the added Large Blue Tubes B 1 over the bolt in the order shown Add a Large Red Tube A 1 on the top of joint f replace the Washer HE and Standard Nut HD Tighten joint completely Complete around the circle Connect five Large Red Tubes A 1 at the top by sliding a 1 3 4 Bolt HA through a Washer HE and thr2. ground Safety Copies of these reports can be obtained by sending a postcard to the Office of Public Affairs U S Consumer Product Safety Commission Washington D C 20207 or call the toll free hotline 1 800 638 2772 This data is from tests conducted by independent testing laboratories on a 6 inch depth of uncompressed shredded tire samples produced by four manufacturers It is recommended that persons seeking to install shredded tires as a protective surface request test data from the supplier showing the critical height of the material when it was tested in accordance with ASTM F1292 The maximum fall height for this product is 5 feet We recom mend using 6 of Double Shredded Bark Mulch 8002153 1 1 8 x 33 875 Red Tubing 8002151 1 1 8 x 38 128 Blue Tubing 8002886 1 1 4 x 33 875 Red Tubing 8002890 1 1 4 x 38 128 Blue Tubing 8002067 Handhold OOOOO Dome Climber Hardware 8002389 8002102 5 16 x 1 3 4 Bolt 8000162 5 16 x 3 4 Bolt 8000209 5 16 Nylock Nut 8001390 5 16 Standard Nut 8002027 1 4 Thin Washer 8000355 3 16 Allen Wrench There may be extra hardware OOOOOO A 1 and B 1 can be identified by the sticker placed around the tube and must be placed in the locations shown in the instructions Do not remove the stickers until after step 8 Complete the joint shown five times Slide a Washer HE over a 1 3 4 Bolt HA then
3. equipment ustomer Service 1 800 225 3865 Monday Friday 7 a m to 5 p m MST Call or visit our Web site at www lifetime com for Saturday hours Lifetime Products Inc P O Box 160010 Clearfield UT 84016 This product is intended for use by children ages 3 to 12 and is for residential use only IMPORTANT SAFETY INFORMATION PLEASE READ BEFORE BEGINNING ASSEMBLY Installation and Ground Preparation Instructions e Place the equipment on level well drained ground not less than 6 ft 1 8 m from any structure or obstruction such as a fence garage house overhanging branches laundry lines or electrical wires e Do not install home playground equipment over concrete asphalt packed earth or any other hard surface A fall onto a hard surface can result in serious injury to the equipment user see page 4 To prevent serious injury warn children that they must not use the equipment until properly in stalled Operating Instructions Observing the following instructions and warnings reduces the likelihood of serious or fatal injury e The maximum number of occupants that may safely use the entire playset is 6 with a maximum weight of 600 pounds e On site adult supervision should be provided for children of all ages e Instruct children not to use the equipment in a manner other than intended To prevent entanglement and strangulation dress children appropriately using well fitting shoes and avoiding ponchos sc
4. la cual est dise ado e Para prevenir enredos y estrangu laci n vista a los ni os correctamente con calzado adecuado y evite el uso de ponchos bufandas chaquetas con cordeles para el cuello cascos con correas y otro tipo de ropa holgada que sea potencialmente peligrosa durante el uso del equipo e No se suba al equipo cuando ste mojado e No fije al equipo de patio de juegos elementos que no est n espec fica mente dise ados para ello como por ejemplo cuerdas para saltar tendederos para ropa correas de mascotas cables y Cadenas etc pues revisten un peligro de estrangulaci n Ce produit est concu pour un usage par des enfants g s de 3 12 ans Ne pas installer sur du b ton de l asphalte de la terre compact e ou toute autre surface dure Une chute sur une surface dure peut entrainer des blessures graves L observation des d clarations et des avertissements suivants r duit les risques de blessures graves ou fatales e Le nombre maximal d occupants pouvant utiliser cet quipement en toute s curit est de 6 avec un poids maximal de 600 Ib 272 kg e La pr sence d un adulte surveillant les enfants de tous ges doit tre assur e e Ne pas utiliser l quipement a d autres fins que pour l usage pr vu e Pour viter l emm lement des cordes et des cha nes et ainsi viter tout risque d tranglement veillez habiller les en fants correctement Chaussez des souliers bien adapt s Ne me
5. slide the Bolt through four Blue Tubes B and two Red large Tubes A 1 in the order indicated by the numbers Slide another Washer HE over the Bolt and secure with a Standard Nut HD Hold the Nut with a wrench while tightening the Bolt Tighten completely to prevent movement Repeat this step five times making five joints Attach a Blue Tube B to tubes 1 and 2 at the bottom of each assembly completed in the previous step joint a Slide a 3 4 Bolt HB through a Thin Washer HE and the two Blue Tubes B Place a Washer HE over the 3 4 Bolt HB and Finger tighten Nylock Nut HC for removal later Follow the same assembly for joint b and repeat this step on all five assemblies joint a the top joint as shown below by placing a 1 3 4 Bolt HA through Washer HE then through the Blue Tubes B and Red Tube A Place a Washer HE over the 1 3 4 Bolt HA and Finger tighten Standard Nut HD for removal later Two Adults Required for Assembly Bring two of the assembles completed in steps 1 and 2 together as shown in the image below Place a Red Tube A over the Blue Tubes B and secure the Red and Blue Tubes together at The Geo Dome should be stood upright to complete this step and the rest of the assembly Add two additional Red Tubes A in the order indicated Place the 1 3 4 Bolt HA through the Washer HE then through the five Red Tubes A Secure with Washer HE and Standard Nut HD
6. Owner s a bad A embly Instructions 5 Do limber wit Model 101301 102300 CALL OUR CUSTOMER SERVICE DEPARTMENT at 1 800 225 3865 HOURS 7 00 a m to 5 00 p m Monday through Friday Mountain Standard Time Call or visit our Web site at www lifetime com for Saturday hours For customers outside the U S or Canada please contact the store for assistance Lifetime Products Inc L F E T j M E PO Box 160010 e Freeport Center Bldg D 11 i Clearfield Utah 84016 0010 This product is intended for use by children ages 3 to 12 and is for residential use only 4 25 2011 Instruction 1050346 B som Before Beginning Assembly som Only adults should set up the play equipment Do not allow children in the setup area until assembly is complete Tools Required for Assembly Ratchet with 1 2 Socket deep socket my be needed 2x 3 16 Allen Wrench included Indicates the num people required to c assembly step Two Adults Require Save this owner s man the event that the man FAILURE TO FOLLOW THESE WAR com RESULT IN SERIOUS INJURY OR PS OPER AMAGE Al VILL VOID THE WARRANTY To ensure safety t attempt to a ble thi y equipment without carefully following the instructions E e beginning asse he instructions Proper and complete assembly orientati ynd supervision are essential to reduce the risk of accident or injury Most injuries are caused b Besancior nal wing instructions Use caution when using this play
7. arves jackets with neck drawstrings helmets with straps and other loose fitting clothing that is potentially hazardous while using equipment e Instruct children not to climb when the equipment is wet e Instruct children not to attach items to the playground equipment that are not specifically designed for use with the equipment such as but not limited to jump ropes clothesline pet leashes cables and chain as they may cause a strangulation hazard Maintenance Instructions e Check surfacing material and replenish as necessary to maintain proper depth see page 4 e Check all nuts and bolts twice monthly during the usage season for tightness and tighten as re quired It is particularly important that this procedure be followed at the beginning of each season e Replace broken handholds immediately do not allow children to play on damaged equipment e Remove any tripping hazards such as exposed concrete footings tree stumps or rocks e Check all coverings for bolts and sharp edges twice monthly during usage season to be certain they are in place Replace when necessary It is especially important to do this at the beginning of each new season e Sand rusted areas on tubular members and repaint using a nonlead based paint e Ifthe warning sticker is illegible destroyed or removed contact Customer Service for a replacement Disposal Instructions Disassemble and dispose of the playground equipment in such a way that no u
8. e maximum number of oc cupants that may safely use the equipment is 6 with a maximum weight of 600 pounds e On site adult supervision should be provided for children of all ages e Do not use the equipment in a man ner other than intended e To prevent entanglement and strangulation use well fitting shoes and avoid ponchos scarves jack ets with neck drawstrings helmets with straps and other loose fitting clothing that is potentially hazardous while using equipment e Do not climb when the equipment is wet e Do not attach items to the playground equipment that are not specifically designed for use with the equipment such as but not lim ited to jump ropes clothesline pet leashes cables and chain as they may cause a strangulation hazard Lifetime Products Inc PO Box 160010 Freeport Center B Este producto es para ni os de 3 a 12 a os de edad No lo instale sobre concreto asfalto tierra empaqueta da o cualquier otra superficie dura La caida sobre una superficie dura podr a ocasionar serias lesiones Si se presta atenci n a los siguientes enunciados y avisos de advertencia se reduce la probabilidad de pro ducirse lesiones serias o mortales e El n mero m ximo de ocupantes que pueden usar de forma segura el equipo es 6 con un peso m ximo de 600 Ib 272 kg e Los ni os de todas las edades deben estar bajo la supervisi n de un adulto en el lugar e No use el equipo de una forma distinta para
9. nreasonable hazards will exist at the time the equipment is discarded Follow all local disposal requirements Playset dimensions 10 diameter Recommended play area 22 diameter CONSUMER INFORMATION SHEET FOR PLAYGROUND SURFACING MATERIALS The U S Consumer Product Safety Commis sion CPSC estimates that about 100 000 playground equipment related injuries resulting from falls to the ground surface are treated annually in U S hospital emergency rooms Injuries involving this hazard pattern tend to be among the most serious of all playground injuries and have the potential to be fatal particularly when the injury is to the head The surface under and around playground equipment can be a major factor in determining the injury causing potential of a fall It is self evident that a fall onto a shock absorbing surface is less likely to cause a serious injury than a fall onto a hard surface Playground equipment should never be placed on hard surfaces such as concrete or asphalt and while grass may appear to be acceptable it may quickly turn to hard packed earth in areas of high traf fic Shredded bark mulch wood chips fine sand or fine gravel are considered to be acceptable shock absorbing surfaces when installed and maintained at a sufficient depth under and around playground equipment Table 1 lists the maximum height from which a child would not be expected to sustain a life threaten ing head injury in a fall o
10. nto different loose fill surfac ing materials if they are installed and maintained at depths of 6 9 and 12 inches However it should be recognized that all injuries due to falls cannot be pre vented no matter what surfacing material is used It is recommended that a shock absorbing material should extend a minimum of 6 ft in all direc tions from the perimeter of stationary equipment such as climbers and slides However because children may deliberately jump from a moving swing the shock ab sorbing material should extend in the front and rear of a swing a minimum distance of 2 times the height of the pivot point measured from a point directly beneath the pivot on the supporting structure This information is intended to assist in comparing the relative shock absorbing properties of various materials No particular material is recom mended over another However each material is only effective when properly maintained Materials should be checked periodically and replenished to maintain correct depth as determined necessary for your equip ment The choice of a material depends on the type and height of the playground equipment the availability of the material in your area and its cost TABLE 1 FALL HEIGHT IN FEET FROM WHICH A LIFE THREATENING HEAD INJURY WOULD NOT BE EXPECTED This information has been extracted from the CPSC publications Playground Surfacing Technical Information Guide and Handbook for Public Play
11. ough the five Large Red Tubes A 1 in the order shown Secure with a Washer HE and Standard Nut HD Tighten completely Check and tighten all bolts before allowing children to play Do not allow Children to play on the Dome Climber before the handholds are in place Attach Handholds C to each of the joints not touching the ground Attach the handholds by sliding a Washer HE over the 1 3 4 Bolt HA and placing the Handhold C over the 1 3 4 Bolt HA Line up the notch on the bottom of the handhold with the tube on the top of the joint Secure each Handhold with a Washer HE and Nylock Nut HC Tighten completely STOP It is critical that this washer is added Make sure the notch in the handhold is securely in place over the tube as shown Before allowing children play ensure handholds are in place and secure Replace broken handholds immediately do not allow children to play on damaged equipment When moving the Dome Climber do not slide the Dome or tip it on its side This may cause the Dome to lose its shape Instead use several people to lift the Dome and move it to the new location This product is intended for use by children ages 3 to 12 Do not install over concrete asphalt packed earth or any other hard surface A fall onto a hard sur face can result in serious injury Observing the following statements and warnings reduces the likelihood of serious or fatal injury e Th
12. ttez pas de ponchos de foulards charpes ou de blousons avec des cordons pr s du cou ni de casques avec des sangles et tout autre v tement ample pouvant potentiellement s av rer dangereux lors de l utilisation de l quipement e Ne pas monter sur l quipement lorsque celui ci est mouill e Ne pas attacher d objets sur l quipement de jeu non sp cifiquement con us pour celui ci tels que mais sans s y limiter des cordes sauter des cordes linge des laisses d animaux des c bles et des cha nes Ceux ci posent un risque d tranglement 1073434 dg D 11 Clearfield UT 84016 e USA e 1 800 225 3865
Download Pdf Manuals
Related Search