Lanier 6110 User's Manual
Contents
1. Information Ames test negative Acute skin irritation n a Acute oral toxicity Oral LDLO gt 5 0g kg Acute allergenic effects n a Special effects Carcinogenicity In 1996 the IARC reclassified Carbon Black as a Group 2B carcinogen possible human carcinogen This evaluation is given to carbon black for which there is inadequate human evidence but sufficient animal evidence The latter is based upon the development of lung tumors in rats receiving chronic inhalation exposures to free carbon black at levels that induce particle overload of the lung Studies performed in animal models other than rats have not demonstrated an association between carbon black and lung tumors Moreover 2 years cancer bioassay using a typical toner preparation containing carbon black did not demonstrate an association between toner exposure and tumor development in rats Section 12 Environmental Ecological Information Acute toxicity to fish N A Bioaccumulation Not known in bioaccumulation Persistence Degradability Not known Acute toxicity to daphnia Not available Algae inhibition test Not available Section 13 Disposal Consideration Used Toner should be disposed of under conditions that meet all federal state and local environmental regulations Disposal regulations vary from locality to locality therefore consult your local Lanier office or the EPA to determine the proper method for disposal Do not incinerate loose or spilled Toner Section 14 Tr2. Measures Spill leak Procedures If spilled sweep up using an approved toner vacuum with a 0 5 micron filter or smaller such as the Atrix AAA Toner Vacuum or 3M Toner Vacuum Use of a vacuum cleaner not rated for toner particles could result in a fire or personal injury Remove residue with soap and cold water Miscellaneous Keep product out of sewers and watercourses Personal protection Avoid inhalation of dust Section 7 Handling and Storage Special Handling Cleanse skin after contact before breaks or meals and end of workday Do not handle in areas where the wind blows Minimize the breathing of dust Special Storage Avoid direct sunlight Keep out of reach of children Store in a cool dry place Below 35C 95F Section 8 Exposure Control and Personal Protection Information Respiratory Protection none required under normal use Hand Protection none required under normal use Eye Protection none required under normal use Skin Protection none required under normal use Section 9 Physical and Chemical Properties CHARACTERISTICS Appearance Black Melting point N a Form Powder Vapor pressure N a Odor Odorless Vapor density N a Solubility in Water Insoluble Evaporation rate N a Specific Gravity 1 1 approx Boiling point N a Section 10 Stability and Reactivity Conditions to avoid none Materials to avoid none Stability Stable Hazardous decomposition products Will not occur Section 11 Toxicological
3. MATERIAL SAFETY DATA SHEET Emergency Telephone 800 526 4371 LANIER A RICOH COMPANY Lanier Worldwide Inc 2300 Parklake Drive NE Atlanta GA USA 30345 2979 Section 1 Chemical Product and Company Information Identity 6110 6112 Black Toner MSDS No CP 251 Product ID 117 0135 Issued 06 15 2004 Supersedes 12 26 2000 Synonyms Date 06 15 2004 amp Common Black Toner for Prepared by EH amp S Department 770 496 9500 Names Lanier 6110 6112 Approved by Larry Choskey Manager CEH amp S European Walter Fricke Manager Safety amp Uses Lanier 6110 6112 Copier Contact Environment Lanier Worldwide Inc Chemical Im Taubental D 41468 Neuss Formula Mixture Germany 49 2131 387 177 Section 2 Composition Information on Ingredients Component Percent CAS No Exposure Limits Source Styrene acrylate copolymer 93 27136 15 8 Not listed n a Carbon black 4 1333 86 4 3 5mg m OSHA PEL 3 5mg m ACGIH TWA Organic pigment 3 8005 02 5 Not listed N a PEL as the product 15mg m total dust 5mg m respirable dust TLV as the product 10mg m total dust 5mg m respirable dust Section 3 Hazards Identification HMIS Rating FLAMMABILITY 1 REACTIVITY 0 HEALTH 1 SPECIAL none Health Hazards Acute Chronic Immediate and Potential Minimum irritation to respiratory tract may occur as with exposure to any non toxic dust May cause gasping if inhaled Inhalation should be avoided May cause temporary eye di
4. ansportation Information International regulations RID ADR Not applicable ICAO TI ATA DGR Not applicable DOT 49 CFR Not applicable UN Classification Number Not applicable ADNR Not applicable IMDG Code Not applicable Specific precautionary transport measures Avoid direct sunlight Do not keep over 35 C 95 F Specific material to avoid None in normal use Information on this data sheet represents our current data and best opinion as to the proper use in handling of this product under normal conditions On the basis of the data available to us this product is not a dangerous substance One should however observe the usual precautionary measures for dealing with chemicals MATERIAL SAFETY DATA SHEET Page 2 of CP 251 Section 15 Regulatory Information Regulation US Canada Information OSHA Hazard Communication Standard 29CFR 1910 1200 Not regulated Toxic Substance Control Act TSCA All chemical substances in this product comply with all applicable rules or orders under TSCA RCRA 40 CFR 261 Product or components not listed CERCLA SARA Information Not regulated NTP Annual Report on Carcinogens Not listed as an NTP carcinogen IARC See section 11 California Proposition 65 Neither toner or any of the components are listed as chemicals known to the State of California to cause cancer or reproductive system effects Controlled Products Regulations Canada This product has been classified in accordance with t
5. he hazard criteria of the CPR Other State Regulations Carbon black is listed in the New Jersey Right to Know List Pennsylvania Hazardous Substance List and Massachusetts Substance List U S Canada Label Statements LOW HAZARD FOR RECOMMENDED HANDLING Minimize dust generation and accumulation Use with adequate ventilation EU Information Label Information According to Directives 67 548 EEC amp 88 379 EEC Symbol amp Indication Not required Risk Phrase Not required Safety Advise Phrase Not required EEC Directive 76 548 EEC 79 831 EEC 92 32 EEC All chemical substances in this product comply with all applicable rules or order under EEC Directive The Subject of Specific Provisions in Relation to Protection of Man or the Environment Directive 76 769 EEC Not required National requirement No specific regulations or restrictions Section 16 Miscellaneous Information Judgment as to the suitability of information contained herein for user s purposes is the responsibility of the purchaser Therefore although reasonable care has been taken in the preparation of this information Lanier Worldwide Inc extends no warranties makes no representations and assumes no responsibility as to the accuracy or suitability of such information for application to user s intended purposes or for consequences of its use All materials may present unknown hazards and should be used with caution Although certain hazards are described herei
6. n we do not guarantee that these are the only hazards that exist Information on this data sheet represents our current data and best opinion as to the proper use in handling of this product under normal conditions On the basis of the data available to us this product is not a dangerous substance One should however observe the usual precautionary measures for dealing with chemicals
7. scomfort Health Hazards of Long Term exposure Chronic Prolonged inhalation of excessive dust may cause lung damage It is attributed to lung overloading a generic response to excessive amounts of any dust retained in the lungs for a prolonged interval Use of this product as intended does not result in inhalation of excessive dust Carcinogenicity Carbon Black was reclassified as a Group 2B by the IARC in 1996 based upon the result of only the inhalation study in rats However there was not observed the incidence of tumors on the test results on dermal or oral studies Also 2 years inhalation study using a typical toner containing carbon black showed no association between toner exposure and animal tumors Section 4 First Aid Measures Gargle with water Remove to fresh air if effects In case of contact immediately flush eyes occur Get medical attention if needed with water for 15 minutes Get medical attention if needed Skin Contact Wash with soap and water Ingestion Dilute stomach contents with several glasses of water Get medical attention Section 5 Fire Fighting Measures Suitable extinguishing media COs dry chemical foam or water Extinguishing media which may not be used for safety reasons none Inhalation Eye Contact Special protective equipment for fire fighters none UEL n a EL n a your document management partner MATERIAL SAFETY DATA SHEET Page 2 of CP 251 Section 6 Accidental Release
Download Pdf Manuals
Related Search