Karcher K 2200 G User's Manual
Contents
1. Pump is sucking air Water inlet filter is clogged Check that hoses and fittings are air tight Turn off machine and purge pump by squeezing trigger gun until a steady flow of water emerges through the nozzle Remove filter and rinse out in warm water Discharge nozzle is obstructed Calcified gun hose or spray wand Blow out or remove debris with a fine needle Run distilled vinegar through detergent suction tube 1 800 537 4129 page 10 m a o Lor o Q oa N t N co Io o o e m a TROU B LESHOOTING continued Symptom No detergent Garden hose connection leaks Spray wand or Spray extension wand leaks Pump is noisy Water leaks from pump up to 10 drops per minute is permissible Oil Drip Detergent suction tube not properly connected to the machine Solution Check connection Detergent is too thick Dilute detergent for best results use Karcher detergent The filter is closed Open the filter by turning it to the desired detergent intake Filter on detergent suction tube is clogged Run warm water through filter to remove debris Damaged or clogged detergent suction tube Remove obstruction or replace detergent suction tube Spray wand is in high pressure position Turn spray wand tip to low pressure position Discharge nozzle is obstructed Loose fittings Blow out or remove debris2. and apply to surface at low pressure For best results clean one side of vehicle at a time and always apply detergent from bottom to top do not allow detergent to dry on surface If needed use special Wash Brush Attachment to remove stubborn dirt Rinse at high pressure in a sweeping motion keeping the spray nozzle approximately 6 8 inches from the cleaning surface distance should increase when rinsing pin striping or other sensitive surfaces Always clean from top to bottom and from left to right For best results wipe surface dry with a chamois or soft dry cloth Caution Do not use rotating nozzle spray wand on vehicles as it may cause damage o a iv Q e N T N o 2 o o r m a o o te o Q oa N ba T N o 1o i o m a CLEANING TIPS continued Barbecue Grills Outdoor Patio amp Lawn Furniture Power Equipment amp with or without detergent Gardening Tools Pre rinse furniture and surrounding area with fresh water If using Karcher All Purpose Cleaner place detergent suction tube directly into cleaning solution and apply to surface at low pressure Allow Karcher All Purpose Cleaner to remain on surface 1 3 minutes Do not allow detergent to dry on surface If needed use special Wash Brush Attachment to remove stubborn dirt Rinse at high pressure in a sweeping motion keeping the spray nozzle approximately 3 6 inches from the cleaning surf
3. between the FULL and ADD marks on the dipstick Be sure the machine is level when checking the oil level Refer to the engine s operating manual for seasonal grades REE y Step 3 Connect garden hose to unit s water inlet Step 4 Connect high pressure hose to high pressure outlet Step 5 Connect garden hose to the cold water source and turn water on completely Step 6 Trigger the gun to eliminate trapped air wait for a steady flow of water to emerge from the spray nozzle o a i Q o N T N o to o o r m fy OPERATING INSTRUCTIONS continued fi Tea ia 5 Step 7 Slide the throttle control to the fast position Step 8 Pull the starter Move the ckoke lever to the CHOKE position only if the handle If the engine fails to engine is cool After starting move the choke to RUN start after 3 pulls squeeze the trigger gun to release pressure and repeat step 8 USING THE ACCESSORIES The spray wand allows you to adjust the cleaning pressure To clean at maximum pressure the wand must be positioned to the high pressure setting To apply detergent the wand must be positioned to the low pressure setting For high pressure turn wand collar in the plus direction 1o o te o Q oa N q N or 1p So i m fy For low pressure turn wand c
4. 9 139 083 05 00 KARCHER Model K 2200 G Part No 1 133 115 0 High Pressure Washer Operator Manual OVETVIEW aa 2000 MAAN GG kl ka pod PER EEN 1 Precautions 00000 eee eee eee 1 2 Assembly Instructions 2 0000005 3 Operating Instructions 00 00 c eee 4 Using the Accessories 5 Working with Detergents aaa 6 Shut Down and Clean Up 200055 7 Taking a Break 2 eee 7 Winterizing and Long Term Storage 7 Cleaning Tips eee eee 8 9 Optional Cleaning Accessories 9 Troubleshooting a 10 11 Specifications Operating pressure 2200 PSI Water volume 2 0 GPM Engine 6 0 HP Briggs amp Stratton Quantum 800 537 4129 MODEL K 2200 G OVERVIEW Item Description 1 Water inlet 2 Detergent tray with screw 3 Knob Assembly two each Bolt Knob 4 Oil fill cap High pressure hose 6 Detergent suction tube with filter 7 Handle 8 Accessory rack 9 Trigger gun safety lock 10 Trigger gun 11 Pull start 12 Gas tank 13 Choke 14 Trotile 15 Wand with adjustable spray nozzle 16 High pressure outlet not pictured gr o Da o Qa e0 N T 7 N oe Q ce q NEVER point nozzle at people or animals drink alcohol or use drugs while operating this equipment spray electrical connections electrical outlets or fixt
5. ace For best results clean from top to bottom and from left to right Caution Do not use rotating nozzle spray wand on patio or lawn furniture as it may cause damage with or without detergent Pre rinse cleaning surface with fresh water If using Karcher All Purpose Cleaner or Degreaser place detergent suction tube directly into cleaning solution and apply detergent at low pressure Allow Karcher detergent to remain on surface 1 3 minutes Do not allow detergent to dry on surface Rinse at high pressure keeping the spray nozzle approximately 3 6 inches from the cleaning surface For removing extremely stubborn dirt it may be necessary to move the spray nozzle even closer to the surface for greater dirt cutting action To remove caked on mud from garbage cans lawn mower blades wheel barrels or other non sensitive metal surfaces you may Recommendations want to use the Karcher Rotating Nozzle Before cleaning any surface an Spray Wand inconspicuous area should be cleaned Caution Do not use rotating nozzle spray to test spray pattern and distance for wand on cloth plastic or other sensitive maximum cleaning results surfaces as it may cause damage e If painted surfaces are pealing or chipping use extreme caution as pressure washer may remove the loose paint from the surface OPTIONAL CLEANING ACCESSORIES Optional cleaning accessories are available to further enhance your cleaning capabilities See accessories order f
6. ained in the pump temperatures The machine should not be exits Turn off immediately placed near an open flame i e furnace 3 Drain the gas and oil from the engine hot water heater etc 4 Do not allow high pressure hose to Caution Failure to follow the above become kinked directions will result in damage to the pump assembly and accessories CLEANING TIPS Deck Cleaning with or without detergent Pre rinse deck and surrounding area with fresh water If using Karcher Deck Wash place detergent suction tube directly into cleaning solution and apply to surface at low pressure For best results limit your work area to smaller sections of approximately 25 square feet Allow Karcher Deck Wash to remain on surface 1 3 minutes Do not allow detergent to dry on surface Rinse at high pressure in a long sweeping motion keeping the spray nozzle approximately 3 6 inches from the cleaning surface Always clean from top to bottom and from left to right When moving on to a new section of the cleaning surface be sure to overlap the previous section to eliminate stop marks and ensure a more even cleaning result Caution Do not use rotating nozzle spray wand on wood surface as it may cause damage House Siding with or without detergent Pre rinse cleaning surface with fresh water If using Karcher House Wash place detergent suction tube directly into cleaning solution and apply to surface at low pressure for best results limit yo
7. esetting This ensures that the pump does not become damaged AN Caution e Follow the maintenance instructions specified in the manual e This machine has been designed for use with cleaning detergent supplied or recommended by the manufacturer The use of other cleaning detergents may affect the operation of the machine and void the warranty N o Lor o Q oa N oa t NG co pi d i i q m a ASSEMBLY INSTRUCTIONS Step 1 Slide the handle through the accessory rack o 0 te o a for N N B Step 2 Align the holes of the accessory Step 3 Insert the handle into the frame e rack to the handle and fasten the four Align holes insert bolt and tighten with screws knob m fy Step 4 Insert the spray wand into the gun Push in and turn clockwise to lock spray wand in place Turn the wand collar clockwise onto the spray wand threads until tight Step 5 Attach high pressure hose to trigger gun OPERATING INSTRUCTIONS I Step 1 Fill gas tank with unleaded gasoline Do not use leaded gasoline Important Do not run the engine with a high or low oil level as this can cause engine damage If you have further questions regarding the engine please refer to the engine s operating manual included with the unit Step 2 Check oil level Oil level should always be
8. nment and your pressure washer Special formula won t clog the suction tube filter and will protect the internal parts of the pressure washer for a longer life For Karcher Detergents check your retailer or call 1 800 537 4129 The following Karcher detergents are available e Vehicle Wash e Degreaser e All Purpose Cleaner e House Wash Deck Wash Ce o Da i Q e0 N T N o pn o o r m a NG o Da o Qa for N 7 N oO ID o o am fy SHUTTING DOWN amp CLEAN UP a HALAGA A a Step 1 Remove Step 2 Step 3 Step 4 detergent suction tube Turn off the engine Turn off the water Press trigger to from container and source release water insert into one gallon of pressure fresh water Siphon water at low pressure for one minute re a P Step 5 Disconnect the Step 6 Disconnect the high pressure hose from the garden hose from the high pressure outlet and engage the gun safety lock water inlet on the unit TAKING A BREAK five minutes or more Step1 Turn off the Step 2 Press trigger to Step 3 Engage gun engine release water pressure safety lock WINTERIZING AND LONG TERM STORAGE 1 Disconnect all water connections 5 Store the machine and accessories in 2 Start the machine for a few seconds until a room which does not reach freezing the water which had rem
9. ollar in the minus direction WARNING TO AVOID SERIOUS INJURY NEVER POINT SPRAY NOZZLE AT YOURSELF OTHER PERSONS OR ANIMALS WORKING WITH DETERGENT Detergents can only be applied in the low setting Step 1 Slide the detergent tray into one of the slots of your choice Secure the tray to the frame by fastening the screw HIN Step 2 The wand must be set in the low pressure position to apply detergents Step 3 Fill a container with Karcher detergent Place the filter end of detergent suction tube into the container Be sure to adjust the filter by turning it to the desired detergent intake For best results see Cleaning Tips on pages 8 amp 9 for specific information on how to clean different surfaces Caution Never use e Bleach Chlorine products and other corrosive chemicals e Liquids containing solvents i e paint thinners gasoline oils Tri sodium phosphate products Ammonia products Acid based products These chemicals will harm the unit and will damage the surface being cleaned Step 4 With the engine running pull trigger to operate unit Liquid detergent is drawn into the unit and mixed with water Apply detergent to work area Do not allow detergent to dry on surface Always Use Karcher Detergents for Best Results Karcher biodegradable detergents are specially formulated to protect the enviro
10. orm for product descriptions and ordering instructions e Rotating Wash Brush e Pipe Drain Cleaner e Wash Brush e Floor Washing Tool e House Washing Wand e Sandblasting Attachment e Extension Wand Detergent Foamer Attachment e Rotating Spray Wand e Water Pumping Kit e Flexible Spray Wand e Water Suction Hose e Underbody Spray Wand e Extension Hose 25 e Telescopic Spray Wand TROUBLESHOOTING Symptom Engine will not start For additional engine problems refer to the engine owners manual Unit does not reach high pressure Output pressure varies high and low No gasoline Low oil level Solution Fill gas tank Add oil Choke is not in correct position Slide choke lever to CHOKE position Engine throttle is not in correct position Position the throttle to FAST Pressure built up in the high pressure washer Diameter of garden hose is too small Squeeze the trigger to release the pressure Replace with a 3 4 inch garden hose Water supply is restricted Check garden hose for kinks leaks and blockage Not enough inlet water supply Open water source full force Water inlet filter is clogged Spray wand is in low pressure position Not enough inlet water sup ply Remove filter and rinse out in warm water Turn spray wand tip to high pressure position Turn water on full force Check garden hose for kinks leaks or blockage
11. to come into contact with the muffler guard e Do not leave the machine running unattended Learn how to stop the machine and release pressure quickly Be thoroughly familiar with the controls e Stay alert watch what you are doing Do not operate the product when fatigued or under the influence of alcohol or drugs e Do not stand on unstable surfaces Stand with both feet balanced at all times e The Gun Safety Lock PREVENTS the trigger from accidentally being engaged This safety feature DOES NOT lock trigger in the on position Water Supply Cold Water Only Water hose must be at least 3 4 inch in diameter Flow rate of water supply must not fall below 2 5 GPM gallons per minute e Flow rate can be determined by running the water for one minute into an empty 5 gallon container The water supply temperature must not exceed 104 F 40 C Never use the pressure washer to draw in water contaminated with solvents e g paint thinners gasoline oil etc e Always prevent debris from being drawn into the unit by using a clean water source We strongly recommend that this high pressure washer not be left running for periods of 5 minutes or longer without the trigger gun being engaged This Karcher high pressure washer is equipped with thermal protection to extend the life of your pressure washer The thermal protector will automatically activate ata predetermined temperature ejecting hot water before r
12. ur work area to sections of approximately 6 feet and always apply detergent from bottom to top Allow Karcher House Wash to remain on surface 1 3 minutes Do not allow detergent to dry on surface if surface appears to be drying simply wet down surface with fresh water If needed use special Wash Brush Attachment to remove stubborn dirt Rinse at high pressure from top to bottom in an even sweeping motion keeping the spray nozzle approximately 6 inches from the cleaning surface Caution Do not use rotating nozzle spray wand on siding as it may cause damage Cement Patios Brick and Stone with or without detergent Pre rinse cleaning surface with fresh water If using Karcher All Purpose Cleaner place detergent suction tube directly into cleaning solution and apply to surface at low pressure For best results limit your work area to smaller sections of approximately 25 square feet Allow Karcher All Purpose Cleaner to remain on surface 1 3 minutes Do not allow detergent to dry on surface Rinse at high pressure in a sweeping motion keeping the spray nozzle approximately 3 6 inches from the cleaning surface Always clean from top to bottom and from left to right For removing extremely stubborn stains use Karcher Rotating Nozzle Spray Wand Cars Boats amp Motorcycles with or without detergent Pre rinse vehicle with fresh water If using Karcher Vehicle Wash place detergent suction tube directly into cleaning solution
13. ures add fuel with the engine running or operate where fuel has been spilled touch hot surfaces or allow accessories to contact hot surfaces operate in an enclosed space exhaust fumes are dangerous operate near utilities with open flames operate without the water turned on and never use hot water IMPORTANT PRECAUTIONS Read First Safety Warnings When using this product basic precautions should always be followed e Read all the instructions before using the product e FIRE HAZARD Do not add fuel with the engine running Do not operate if fuel has been spilled Instead move the machine to a different location and avoid creating sparks Operate and fuel machine in a well venti lated area free of devices featuring an open pilot or flame such as boilers water heaters etc e High pressure jets can be dangerous if subject to misuse The jet must not be directed at persons animals electrical devices or the machine itself e Wear safety goggles Do not use acids solvents or any other flammable material in this product These products can cause physical injuries to the operator and irreversible damage to the machine If you have further questions regarding the use of recommended cleaning detergent please call Karcher customer service at 800 537 4129 e The machine has hot surfaces which can cause burns Operate the unit in a safe environment and away from children Do not allow the high pressure hose
14. with a fine needle Missing worn rubber washer Spray wand not properly attached Tighten fittings Insert new washer Insert the spray wand into the spray wand extension Carefully press in against the spring tension and twist into the locked position Spray wand extension not properly attached Broken o ring or plastic insert Pump is sucking air Loose fittings Slide the spray wand extension into the gun Turn the wand collar clock wise onto the gun threads until tight Call Karcher customer service hotline and order repair kit part no 2 883 111 0 Check that hoses and fittings are air tight Turn off machine and purge pump by squeezing trigger gun until a steady flow of water emerges through the nozzle Check that all fittings are tight Thermal protection device has been activated Thermal protection device will automatically reset Water seals are damaged or worn Oil seals are damaged or worn Call service center Call service center If you encounter any additional difficulties not listed please call our service center for help
Download Pdf Manuals
Related Search