Golden Technologies GB106 User's Manual
Contents
1. Use your thumbs to operate the control levers Use your left thumb to press lightly on the R reverse motion lever to move your scooter in reverse Increase the pressure applied by your thumb to increase your reverse speed To stop your scooter release all pressure on the lever The lever will automatically return to the center neutral position and your scooter will come to a gradual stop Buzzaround Lite Owner s Manual Models GB106 and GB106XR Updated 07 08 Page 14 OPERATION DC Battery Voltage Meter This meter shows the amount of voltage in your Buzzaround Lite batteries Green indicates a full battery charge Yellow indicates caution and approximately one half charge on the batteries Red indicates that the batteries have less than one half of a charge remaining See Care and Maintenance section for instruction concerning charging the batteries Note Your scooter will automatically turn itself off if the battery output falls to 18 VDC or lower Tiller Adjustment The tiller on your Buzzaround Lite scooter employs an adjustment knob to provide you with infinite tiller angle settings To set the tiller to your liking follow these directions Use one hand to grasp a handgrip Use your other hand to loosen the tiller adjustment knob Position the tiller to a comfortable driving position Tighten the tiller adjustment knob Tiller Adjustment Knob Buzzaround Lite2. Golden Technologies GB106 and GB106 XR Buzzaround Lite 401 Bridge Street Old Forge PA 18518 Tel 800 624 6374 Fax 570 451 7494 www goldentech com
3. Page 26 GENERAL CARE AND MAINTENANCE If the battery terminals become corroded Corrosion can cause a poor electrical connection and operational problems Clean corroded battery terminals with a stiff brush and a solution of baking soda and water CLEANING YOUR BUZZAROUND LITE Tires Clean the tires with ordinary kitchen type cleaners and a damp cloth Do not use solvents on tires Solvent can cause the tire material break to down or become too soft Body The body rear shroud deck shroud of your scooter is formed ABS plastic and is painted for style and durability Each Buzzaround Lite comes standard with three sets of quick snap color shrouds in Red Blue and Sahara Colors can be changed by gently snapping off the pieces Do not use a sharp object when removing shroud pieces Clean the body of your scooter with a damp cloth Do not hose down your scooter Dry with a clean soft cloth Use cool water mixed with a mild soap to remove dirt and oils Use a non abrasive car wax on the ABS body parts Buff by hand with a soft cloth Seat Vinyl Seat Clean with a mild soap or mild detergent and a damp cloth A vinyl cleaner may also be used Buzzaround Lite Owner s Manual Models GB106 and GB106XR Updated 07 08 Page 27 CARE AND MAINTENANCE OF YOUR BUZZAROUND LITE Charger and Batteries The Buzzaround Lite scooter comes equipped with a 24 Volt rechargeable battery pack FIR
4. Owner s Manual Models GB106 and GB106XR Updated 07 08 Page 15 OPERATION Armrest Width Adjustment To adjust the armrest width 1 Loosen the adjustment knobs at the rear of the seat 2 Slide the armrests in or out to the desired width 3 Tighten the adjustment knobs Max arm width 24 WARNING BE SURE ADJUSTMENT KNOBS ARE SECURELY TIGHTENED AGAINST THE INSERTED ARM REST TUBE DO NOT EXCEED MAXIMUM ARM WIDTH Seat Height Adjustment To adjust the seat height 1 Remove the seat by holding the Seat Rotation Lever up and lifting the seat straight up 2 Set the seat aside 3 Remove ball detent pin or the bolt nut and washers that hold the seat post in the seat pedestal 4 Position the seat post at the desired height while aligning the holes in the seat post and the seat pedestal 5 Reinstall the ball detent pin or nut bolt and washers and tighten securely Buzzaround Lite Owner s Manual Models GB106 and GB106XR Updated 07 08 Page 16 OPERATION cont WARNING THIS SCOOTER WILL TIP EASIER WHEN THE SEAT IS IN ITS HIGHEST POSITION Seat Rotation Lever The seat can be rotated through 360 and locked at any 45 position 1 Pull up on the Seat Rotation Lever and rotate the seat to the desired position 2 Release the handle to lock the seat at any 45 position WARNING DO NOT ATTEMPT TO DRIVE YOUR BUZZAROUND LITE IN ANY SEAT POSITION OTHER THAN FULLY FORWARD Flip Up Armrests Pull up on the end of
5. 1 Hold the seat on an angle so you can see the seat swivel post underneath 2 Place the seat swivel post into the seat post as shown below WARNING Pinch Point Keep hands and clothing clear of the seat swivel post and seat post Accident hazard due to non engaged seat Ensure that the seat is properly engaged after getting on by turning the seat slightly left and right Accident hazard due to incorrect seat position Always turn the seat to face forwards and engage it before driving If the seat is in any other position the possibility of tipping is increased Before turning the seat always ensure that the scooter is on an even and solid surface Seat Swivel Post Seat Post Buzzaround Lite Owner s Manual Models GB106 and GB106XR Updated 07 08 Page 35 Transporting Your GB 106 Buzzaround Lite Note Buzzaround Lite scooters can be equipped with docking devices for loading into onto a vehicle by means of mechanical lift or hoist Golden Technologies does not sell this lifting equipment however you may contact your local home health care dealer for more information To Transport your Buzzaround Lite You will want to consider the best way for transportation Do you own a van Do you own a SUV Do you own a compact car Depending on what type of vehicle you transport the Buzzaround Lite in you will want to plan where you will store your scooter while driving Disassemble or fold down the seat and tiller to eas
6. GC322 323 325 Lifetime Limited Warranty For the life of the scooter from the date of purchase from an authorized Golden Technologies dealer in the event of defective materials or workmanship Golden Technologies will repair or replace at our option any of the following structural frame components found to be defective by an authorized Golden Technologies representative Steel Frame Frame Welds Tiller Frame Front Fork Seat Post Two Year Warranty For the period of two years from the date of purchase in the event of defective materials or workmanship Golden Technologies will repair or replace at our option with any new or reconditioned components any of the following drive train components found to be defective by an authorized Golden Technologies representative Transaxle Motor Brake Assembly electrical function only Note An increase in operating noise of the transaxle DOES NOT constitute a defect With normal wear and tear operating noise is expected to increase For the period of two years from the date of purchase in the event of defective materials or workmanship Golden Technologies will repair or replace at our option any of the following electronic assemblies found to be defective by an authorized Golden Technologies representative Electronic Controller Battery Charger Dash Assembly Potentiometer Assembly Wire Harness es Note While charging batteries it is normal for the battery charger to heat up Heat
7. INTRODUCTION Congratulations on the purchase of your new Golden Technologies Buzzaround Lite scooter The Buzzaround Lite combines cutting edge technology with attractive designs that are also highly functional in today s world We at Golden Technologies know that you have chosen a scooter that will give you years of dependable operation and will also enhance the quality of your life by providing you with the mobility to experience a more active daily lifestyle Please read understand and follow all of the instructions and suggestions in this manual before you operate your Buzzaround Lite for the first time The safe use of your new scooter is very important and starts with you Your new Buzzaround Lite is user friendly and designed for maximum maneuverability in even the tightest spaces If you feel uncomfortable with your new scooter or do not understand the instructions presented in this owner s manual or if for any reason you do not feel capable of performing the activities necessary to assemble disassemble operate or maintain your Buzzaround Lite please contact the home health care dealer you purchased this scooter from or contact Golden Technologies technical support services at 800 624 6374 Golden Technologies Inc cannot be held responsible for personal injury or property damage resulting from the unsafe or the improper use of any of our broad range of health and personal mobility products Please fill out and mail the enclosed
8. completely discharge the batteries before charging them Note If you are not going to use your Buzzaround Lite for an extended time fully charge the batteries before storing your scooter The batteries can be left unmaintained for up to 6 months if they are first fully charged and kept at room temperature approximately 72 F Note if you have not used your scooter for more then three days make certain that you charge the batteries on the night before you are going to use your scooter This will ensure that you start operating your scooter with a full charge on the batteries Note If you use your scooter during the day charge the batteries as soon as you are finished using it The charger is fully automatic Following this procedure will prepare you scooter for a full day s service each day Note If you use your scooter sparingly over the course of the day and have not reduced the charge on the batteries by any great amount it may not be necessary to charge the batteries every night Battery Maintenance Lead Acid Gel cell or AGM deep cycle batteries are used for operating your Buzzaround Lite These batteries are maintenance free There is no danger of spillage or leakage so these batteries are safe to transport on aircraft busses trains etc By following the procedures set out in this manual you can expect extended life from your batteries Buzzaround Lite Owner s Manual Models GB106 and GB106XR Updated 07 08
9. are filled with foam This means you will never have a flat tire even if you puncture the tire IF YOUR BUZZAROUND LITE DOES NOT OPERATE Make certain that the brake handle is set to the engaged forward position Check the main circuit breaker If necessary reset the circuit breaker Make certain that the speed adjustment dial is at the desired setting Be sure that the key is all the way in the key receptacle and the scooter is ON note the green LED light is illuminated WARNING ONLY START DRIVING IF EVERYTHING IS IN WORKING ORDER HAVE ANY AND ALL DEFECTS REPAIRED IMMEDIATELY IF NONE OF THE ABOVE PROCEDURES SOLVE THE PROBLEM CONTACT YOUR AUTHORIZED GOLDEN TECHNOLOGIES DEALER LUBRICATION All of the bearings on your Golden Technologies Buzzaround Lite are permanently lubricated and sealed No lubrication is required Buzzaround Lite Owner s Manual Models GB106 and GB106XR Updated 07 08 Page 25 GENERAL CARE AND MAINTENANCE WARNING THE BATTERIES USED ON YOUR SCOOTER HOLD A SUBSTANTIAL AMOUNT OF POWER SHORTING OF THE TERMINALS CAN RESULT IN BURNS OR OTHER INJURIES AND IN DAMAGE TO THE BATTERIES AND TO THE ELECTRONIC COMPONENTS OF YOUR BUZZAROUND LITE ALWAYS USE CARE AND CAUTION WHEN HANDLING THE BATTERIES Battery Charging Information Note Your scooter may be equipped with either GEL Lead Acid or AGM batteries These batteries do NOT have memory It is not necessary to
10. coming from the battery charger does not constitute a defect Buzzaround Lite Owner s Manual Models GB106 and GB106XR Updated 07 08 Page 38 One Year Limited Warranty For the period of one year from the date of purchase in the event of defective materials or workmanship Golden Technologies will repair or replace at our option any of the following parts found to be defective by an authorized Golden Technologies representative Bearings Bushings Seat Swivel Mechanism Rubber Components excludes tires Armrests Plastic Components excludes body Items not listed are covered at the discretion of Golden Technologies Any accessories standard or optional supplied by Golden Technologies are covered for a period of one year from the date of purchase with the particular unit Warranty Exclusions Golden Technologies does not provide warranty on any of the following items which may require replacement due to the normal wear and tear of day to day usage Tires and Tubes ABS Plastic Shrouds Armrest Pads Motor Brushes Bulbs Fuses Brake Pads Upholstery This warranty also excludes the following Batteries Please consult battery manufacturer for any implied warranty Loss or theft of components ie keys baskets etc Damage caused by Battery fluid spillage or leakage Abuse misuse accident or negligence Improper operation maintenance or storage Commercial use or use other than normal Repairs and or modificati
11. Buzzaround Lite Owner s Manual Models GB106 and GB106XR Updated 07 08 Page 1 GB 106 and GB 106XR Buzzaround Lite Y O U R L I F E I N M O T I O N 401 Bridge Street Old Forge PA 18518 Tel 800 624 6374 Fax 570 451 7494 www goldentech com Buzzaround Lite Owner s Manual Models GB106 and GB106XR Updated 07 08 Page 2 Note This owner s manual is for the Golden Technologies Buzzaround Lite model numbers GB 106 and GB 106XR All size specifications operating procedures assembly and disassembly instructions are the same for both models Better performance figures are achieved with the GB 106XR using extended range technology The use of the term Buzzaround Lite is to imply reference to both models unless otherwise noted Your GB 106 Buzzaround Lite package should include the following items If your package arrived without any of the following items please contact us right away 1 Owner s Manual 2 Battery Charger 3 Battery Pack 4 Seat w adjustable Arm Rests 5 Seat Post Hardware nut bolt pin and washers 6 2 Keys 7 Tiller Mounted Basket 8 Buzzaround Lite scooter DISCLAIMER Golden Technologies Inc is not and cannot be held responsible for any damage or injury incurred due to improper or unsafe use of the Golden Buzzaround Lite scooter Golden Technologies Inc specifically disclaims responsibility for any bodily injury or property damage that may occur during any use that d
12. C 12Ahx2 Standard 12 VDC 15Ahx2 Extended Range Turning Radius 31 ANSI RESNA 31 ANSI RESNA 3 Point Turn 39 39 90 Degree Corridor Turn 28 28 Weight Seat 15 x15 18 pounds 18 pounds Seat 16 x16 27 7 pounds 27 7 pounds Standard battery pack 21 pounds Extended range battery pack 25 pounds Front half 32 pounds 32 pounds Rear half 24 pounds 24 pounds Freewheel mode Yes Yes Maximum incline 6 degrees 7 5 degrees Electronic speed control Yes Yes Brakes Electro mechanical Electro mechanical Charger Off board Off board Rear wheel drive Sealed transaxle motor 24 VDC Sealed transaxle motor 24 VDC Controller 45 amp programmable 45 amp programmable Buzzaround Lite Owner s Manual Models GB106 and GB106XR Updated 07 08 Page 37 Consumer Limited Warranty Scooters Effective June 1 2008 The following warranty is granted only to the INITIAL Consumer who has purchased our product and commences on the Date of Purchase by the Consumer from an Authorized Golden Technologies Provider The Consumer must have a warranty registration card filed with Golden Technologies to receive service This warranty supersedes all previous warranties for all scooter models effective June 1 2008 The warranty covers the following scooter models Buzzaround GB106 106XR 106XP3 Liteway GL100 Companion GC422 Companion GC222 223 Avenger GA531 541 Companion
13. D OTHER SAFETY CONSIDERATIONS MEDICATION Always check with your physician to determine if any of the medications you are taking may affect your judgment and or your ability to operate your Buzzaround Lite Also check with your physician concerning your physical ability to operate a scooter WARNING DO NOT CONNECT OR ALLOW ANYONE EXCEPT AN AUTHORIZED GOLDEN TECHNOLOGIES REPRESENTATIVE TO CONNECT ANY ELECTRICAL OR MECHANICAL DEVICE TO YOUR BUZZAROUND LITE UNAUTHORIZED ACCESSORIES WILL VOID THE WARRANTY AND MAY CAUSE INJURY Note Please remember that while on your Buzzaround Lite you are a motorized pedestrian You must observe and obey all pedestrian rules and regulations for the locale in which you are riding Please use your Buzzaround Lite scooter often and allow it to expand the horizons of your daily life But as with all things especially motor operated vehicles observing a few rules and safety considerations will help ensure safe scooter operation So please follow the rules below Do not turn your scooter while on an incline or decline Always keep all your body parts within the confines of the scooter Do not hose down your scooter Always remain properly seated when operating your scooter Do not place your scooter in freewheel mode when on an incline or decline Never sit on your scooter when it is in freewheel mode Always reduce the speed of your scooter when making turns Do no
14. E HAZARD Do not cover the battery charger and ventilation slot while charging batteries Only use the battery charger in well ventilated areas To Charge the Battery Pack 1 Make certain your key is in the OFF position 2 Remove charger and AC cord from back of seat 3 Plug the charger into the charger port on the battery pack and into a working electrical outlet Note A red LED light should now illuminate showing the batteries are charging 4 When the charging cycle is complete a green LED light will illuminate indicating a complete charge 5 Unplug and stow the charger and cord into the AC cord pack Troubleshooting Tips If batteries fail to charge within 12 hours Check the battery connections It may be necessary to have the batteries load tested by your dealer It may be necessary to have the charger tested Note The battery pack can be charged while it is installed on the scooter or when it is detached from the scooter WARNING Do not leave the battery pack and charger plugged in for more than 12 hours Damage to the battery pack and a hazardous condition may result Buzzaround Lite Owner s Manual Models GB106 and GB106XR Updated 07 08 Page 28 DISASSEMBLING AND TRANSPORTING YOUR BUZZAROUND LITE Your Buzzaround Lite scooter is designed to be disassembled easily in order be transported When disassembling your scooter please be sure to follow these simple instructi
15. SCOOTER TO TIP AVOID THIS DANGER AT ALL TIMES BY STEERING A WIDE ARC AROUND CORNERS AND OBSTACLES ALSO TO AVOID THE RISK OF TIPPING REDUCE SPEED BEFORE NEGOTIATING ANY TURNS Steering in a tight spot If you must steer in a tight spot such as entering a doorway or when turning around 1 Bring your Buzzaround Lite to a full stop 2 Turn the speed control dial to the slowest setting Fully counter clockwise 3 Turn the tiller to the direction in which you wish to drive 4 Press gently on the appropriate thumb lever and slowly turn your Buzzaround Lite For more information on dealing with obstacles and tight spots see Control through tight spots on the next page Steering in Reverse Backing up your Buzzaround Lite requires attention to what you are doing 1 Use your left thumb to press against the drive control lever marked R 2 Turn the tiller to the left to drive in reverse to the left 3 Turn the tiller to the right to drive in reverse to the right Note Your Buzzaround Lite speed in reverse is fifty percent of the maximum speed set on the speed control dial Buzzaround Lite Owner s Manual Models GB106 and GB106XR Updated 07 08 Page 19 RIDING YOUR BUZZAROUND LITE cont Control through tight spots As you use your Buzzaround Lite to increase your mobility you will undoubtedly encounter some obstacles that will require practice to negotiate smoothly and safely Below are some common obstacles that you ma
16. around Lite Owner s Manual Models GB106 and GB106XR Updated 07 08 Page 9 EMI RFI The rapid development of electronics especially in the area of communications has saturated our environment with electromagnetic radio waves that are emitted by television transmitters cellular phones citizen s band radios CBs amateur radios HAM radios wireless computers links microwave transmitters paging transmitters etc These electromagnetic EM waves are invisible and increase in strength the closer one gets to the source of transmission When these energy waves act upon electrical devices and cause them to malfunction or to function in an erratic or uncontrolled manner they are referred to as Electromagnetic Interference EMI or Radio Frequency Interference RFI EMI RFI AND YOUR BUZZAROUND LITE All electrically powered vehicles including scooters are susceptible to EMI RFI This interference could result in abnormal or unintended movement of your Golden Technologies Buzzaround Lite The FDA has determined that each make and model of scooter can resist EMI RFI to a certain level The higher the level of resistance the greater the degree of protection from EMI RFI measured in volts per meter V M The FDA has also determined that current technology is capable of providing 20 V M of resistance to EMI RFI which would provide useful protection against common sources of interference The resistance level of the Golden Te
17. batteries are not fully charged 3 Insert the key into the keyhole 4 Push the key all the way into the key receptacle to power the scooter 5 Place your hands on the handgrips If you wish to drive forward position your right thumb on the drive control lever marked F and push forward If you wish to drive in reverse position your left thumb on the drive control lever marked R and push forward 6 Press against the thumb lever to gently accelerate your Buzzaround Lite Buzzaround Lite Owner s Manual Models GB106 and GB106XR Updated 07 08 Page 18 RIDING YOUR BUZZAROUND LITE cont 7 Release the lever to allow your Buzzaround Lite to come gently to a full stop 8 Practice these two basic functions until you feel that you have control of your scooter EMERGENCY BRAKING LET GO OF THE DRIVE LEVER The drive lever automatically returns to the central position if you let go The scooter automatically brakes using the electric regenerative brake Steering Steering your Golden Technologies Buzzaround Lite is easy and logical 1 With both hands on the handgrips of the tiller turn the tiller to the right to travel to the right 2 With both hands on the handgrips of the tiller turn the tiller to the left to travel to the left 3 Make certain to maintain sufficient clearance when turning your scooter so that the rear wheels will clear any obstacle WARNING TURNING TOO SHARPLY AROUND A CORNER CAN CAUSE THE
18. chnologies Buzzaround Lite is unknown EMI RFI RECOMMENDATIONS Do not turn on or use hand held personal electronic communication devices such as cellular phones walkie talkies or CB radios while your scooter is turned on Be aware of any nearby transmitters radio television microwave etc on your intended route and avoid operation of your scooter close to any of those transmitters Remove the key if your Buzzaround Lite is going to be in a stationary position for any length of time Be aware that adding accessories or components or modifying your scooter may make it more susceptible to EMI RFI If unintended movement or brake release occurs turn your scooter off and remove the key as soon as it is safe to do so Report all incidents of unintended movement or brake failure to Golden Technologies WARNING TURN OFF YOUR SCOOTER AND REMOVE THE KEY AS SOON AS IT IS SAFE TO DO SO IF UNINTENDED OR UNCONTROLLABLE MOTION OCCURS OR IF UNINTENDED BRAKE RELEASE OCCURS Buzzaround Lite Owner s Manual Models GB106 and GB106XR Updated 07 08 Page 10 Scooter Information BUZZAROUND LITE Circuit Breaker Tiller Adjustment Knob Freewheel Brake Release Key Drive Control Lever Buzzaround Lite Owner s Manual Models GB106 and GB106XR Updated 07 08 Page 11 FOR YOUR RECORDS Please fill in your Buzzaround Lite information below This information will be useful in the event that
19. eed potentiometer problem LED Flashes 8 times pause 8 times pause Motor disconnected or faulty LED Flashes 9 times pause 9 times pause Controller fault WARNING DO NOT OPERATE THE SCOOTER IF THE BATTERY IS NEARLY DISCHARGED FAILURE TO COMPLY WITH THIS CONDITION MAY LEAVE THE USER STRANDED IN AN UNSAFE POSITION This is the LED light that will flash in the event of a problem Buzzaround Lite Owner s Manual Models GB106 and GB106XR Updated 07 08 Page 22 GENERAL CARE AND MAINTENANCE Main Circuit Breaker The 35 amp circuit breaker and exposed reset button are located on the front of the battery cover The button is visible through the battery cover If your Buzzaround Lite fails to operate your main circuit breaker may have tripped WARNING DO NOT ATTEMPT ELECTRICAL REPAIRS CONSULT GOLDEN TECHNOLOGIES OR YOUR AUTHORIZED GOLDEN TECHNOLOGIES DEALER WARNING NEVER SOAK YOUR SCOOTER IN ANY LIQUID THIS MAY CAUSE PERSONAL INJURY AND OR DAMAGE TO YOUR SCOOTER Circuit Breaker Buzzaround Lite Owner s Manual Models GB106 and GB106XR Updated 07 08 Page 23 Possible causes for the main circuit breaker to trip Run down batteries Over exerting the motor Possible solutions Recharge your batteries If the problem persists have an authorized Golden Technologies dealer load test the batteries to assure they are not damaged If the problem persists assure you
20. eep your Buzzaround Lite speed control dial set fully counterclockwise at the slowest speed setting If you must come to a stop release the thumb control lever slowly and smoothly Max incline GB106 6 Max incline GB106XR 7 5 Grass and Gravel Your Buzzaround Lite performs admirably on grass gravel and hills but you must follow the operational parameters presented in this manual Refer to the Safety section If you are unsure about any situation avoid it Common sense is your best protection Feel free to use your Buzzaround Lite on lawns or in park areas Avoid long or high grass which may wrap around your scooter s axles Buzzaround Lite Owner s Manual Models GB106 and GB106XR Updated 07 08 Page 21 DIAGNOSTICS SYSTEM Any fault condition on the controller or scooter will cause the Power on diagnostics LED to flash The LED light located on the faceplate of the scooter will tell you about the problem in how it flashes LED Flashes 1 time pause 1 time and pause Batteries are low scooter still operates LED Flashes 2 times pause 2 times pause Batteries are very low scooter will not drive LED Flashes 3 times pause 3 times pause Over voltage to controller LED Flashes 5 times pause 5 times pause Brake in freewheel or brake connection problem LED Flashes 6 times pause 6 times pause Paddle or speed potentiometer problem LED Flashes 7 times pause 7 times pause Paddle or sp
21. either armrest to flip it up for easy transfer on and off your scooter Seating The Golden Technologies Buzzaround Lite seat is available in black vinyl Buzzaround Lite Owner s Manual Models GB106 and GB106XR Updated 07 08 Page 17 RIDING YOUR BUZZAROUND LITE MOUNTING Note For you first driving sessions make certain that your Golden Technologies Buzzaround Lite starts out on a level surface and that you will continue driving on a level surface To Get On Your Buzzaround Lite WARNING BE SURE YOUR SEAT IS LOCKED IN THE FORWARD POSITION BEFORE OPERATING Make certain that the seat is positioned for safe and easy mounting Position yourself in the seat Use the seat rotate lever to position the seat in the fully forward direction Fasten your lap belt if so equipped BASIC DRIVING 1 Make certain that you are seated safely and properly on your Buzzaround Lite 2 Turn the speed control dial fully counterclockwise to its slowest setting RISK OF ACCIDENTS Never touch the freewheel brake release lever while driving Never switch the scooter to the freewheel mode when somebody is sitting on it For proper operation the freewheel brake release lever should always be securely engaged Do not disengage the motor when on an incline NOTE Reverse movement of the scooter may not occur when the speed control dial is set fully counterclockwise at its slowest setting especially when the
22. etal frames This can cause injury Look very carefully before assembling Buzzaround Lite Owner s Manual Models GB106 and GB106XR Updated 07 08 Page 32 ASSEMBLING YOUR GB 106 BUZZAROUND LITE WARNING INJURY HAZARD DUE TO IMPROPER ASSEMBLY Ensure that all components in the scooter have been correctly assembled After assembly check that all locking devices are holding correctly BE SURE YOU HAVE ALL THE IMPORTANT PARTS 1 Line up the front and rear components WARNING WATCH FINGER PLACEMENT BE CAREFUL NOT TO PINCH YOUR FINGERS 2 Connect the front and rear frame sections and connect the components WARNING WATCH YOUR FINGERS Notice how the front component connects to the rear component Buzzaround Lite Owner s Manual Models GB106 and GB106XR Updated 07 08 Page 33 ASSEMBLING YOUR BUZZAROUND LITE 1 Make certain both the front and rear frames are locked 2 Install battery pack 3 Install your seat 4 Position your tiller WARNING MAKE SURE YOU TIGHTEN YOUR TILLER TO BE SURE IT IS LOCKED 5 Unlock your front wheel lock knob WARNING IF YOU DON T UNLOCK YOUR TILLER LOCK KNOB YOUR TILLER WILL NOT TURN THIS COULD CAUSE INJURY Unlock front wheel lock knob Engage your brake Install your Seat Set your Tiller angle using the tiller lock knob Buzzaround Lite Owner s Manual Models GB106 and GB106XR Updated 07 08 Page 34 INSTALLING THE SEAT
23. ily load into your vehicle Do not lift your Buzzaround Lite by its plastic body parts These parts are not designed to be used as handles Also damage to these parts is NOT covered in any warranty Do not use tires or wheels to lift the rear carriage The carriage may rotate and cause injury or damage Use moving blankets or other forms of padding to protect your GB 106 Buzzaround Lite during transportation WARNING IF YOUR SCOOTER AND ITS COMPONENTS ARE NOT PROPERLY AND SECURELY STOWED THE SCOOTER OR COMPONENTS MAY SHIFT WHILE DRIVING CAUSING INJURY OR DAMAGE If the scooter is transported in the vehicle when fully assembled no one should sit on the scooter during loading no one should sit on the scooter during transport WARNING If you use an outside lift system be sure to secure your Buzzaround Lite as it could fall off the lift Also if any electronics are exposed to moisture they may fail Buzzaround Lite Owner s Manual Models GB106 and GB106XR Updated 07 08 Page 36 BUZZAROUND LITE SPECIFICATIONS Model GB106 GB106XR Length 36 5 36 5 Width 21 25 21 25 Tires Foam Filled NON PNUEMATIC Foam Filled NON PNUEMATIC Front 8 8 Rear 8 8 Weight Capacity 250 pounds 250 pounds Maximum Speed 4 mph 4 mph Ground Clearance 2 2 Operating Range standard pack 8 miles Operating Range extended range pack 10 miles Batteries 12 VD
24. lly before lifting WARNING BE CAREFULL NOT TO PINCH YOUR FINGER BETWEEN THE FRAMES THIS AREA IS A PINCH POINT AND REQUIRES YOUR FULL ATTENTION Step 7 Hold seat post with one hand and push the rear section apart as shown below to disconnect the front and rear frame sections Push the rear down to separate connections and front from rear Buzzaround Lite Owner s Manual Models GB106 and GB106XR Updated 07 08 Page 31 ASSEMBLY OF YOUR BUZZAROUND LITE WARNING DO NOT SIT ON OR OPERATE YOUR SCOOTER UNLESS BATTERY BOX IS IN PLACE AND THE LOCKING MECHANISM IS ENGAGED WARNING BE AWARE OF ANY POSSIBLE PINCH POINTS WHEN CONNECTING THE REAR FRAME TO THE FRONT FRAME PLEASE NOTE WARNING LABLES AT PINCH POINTS WHEN ASSEMBLING Pinching and crushing hazard Increased hazards due to pinching or crushing result due to the component weight such as batteries during preparation for transport and maintenance work Always carry out any work to be done with great care Always try to get help from a second person especially when stowing parts for transport Pinch Point A pinch point is an area where you MUST consider your fingers to be sure your fingers DO NOT become pinched between two metal areas The greatest chance of pinch points become possible during the assembly of the Buzzaround Lite scooter See photo below to become knowledgeable with this area WARNING Be sure not to position a finger between the m
25. mpletely open 5 When the door is completely open stop your scooter 6 Drive through the doorway while keeping your hand on the door to prevent it from hitting or blocking your scooter 7 If it is a self closing door it will close behind you 8 If it is not a self closing door pull it closed behind you Ramps Because of the American Disabilities Act ADA many buildings are fitted with ramps that provide access for scooters and for other mobility vehicles Buzzaround Lite Owner s Manual Models GB106 and GB106XR Updated 07 08 Page 20 RIDING YOUR BUZZAROUND LITE cont When proceeding up any ramp curb or incline Lean forward in your seat to move your center of gravity forward for maximum stability and safety RISK OF ACCIDENTS Negotiating curbs requires practice Please observe the maximum obstacle heights of 2 inches Please start practicing curb climbing with small curbs If the ramp has a switchback good cornering ability is required Maneuver your scooter so that the front wheels take wide swings around the corners of the ramp Doing this will allow your scooter s back wheels to follow a wide arc around the corner staying clear of obstacles If you must stop your scooter while driving up a ramp Starting up again simply requires that you apply gentle and steady forward power pressure to the right hand thumb lever Accelerate gently after stopping on any incline Driving down a ramp K
26. nd inclines straight on Be aware of and careful near mechanical pinch points for example when mating the rear carriage to the front frame especially when assembling and disassembling your scooter See Assembly Disassembly section Never sit on your Buzzaround Lite when it is being transported Do not operate your vehicle if it is not functioning properly Use caution when driving on soft or uneven surfaces such as grass and gravel Also use caution on decks where there is no railing Never drive on the roadway except when you must cross the street Never back up or down a step or curb Never operate your Buzzaround Lite while you are under the influence of alcohol WARNING TURNING TOO SHARPLY AROUND A CORNER CAN CAUSE THE SCOOTER TO TIP AVOID THIS DANGER AT ALL TIMES BY STEERING A WIDE ARC AROUND CORNERS AND OBSTACLES ALSO TO AVOID THE RISK OF TIPPING REDUCE SPEED BEFORE NEGOTIATING ANY TURNS FOR EMERGENCY STOPPING REMOVE SCOOTER KEY SCOOTER WILL STOP NEVER OPERATE SCOOTER ON SNOW OR ICE NEVER TRANSFER ONTO OR OFF OF THIS SCOOTER USING THE SEAT BACKREST FOR SUPPORT DURING TRANSFER THE SEAT BACK MAY FOLD DOWN AND MAY CAUSE YOU TO LOSE YOUR BALANCE AND COULD RESULT IN PERSONAL INJURY MAKE SURE THE SEAT SWIVEL IS LOCKED DO NOT LEAN ON TILLER FOR SUPPORT DURING TRANSFERS THE TILLER MIGHT UNINTENTIONALLY MOVE AND CAUSE YOU TO LOSE YOUR BALANCE WHICH COULD RESULT IN PERSONAL INJURY Buzz
27. ndle is in the engaged position See the disassembly section in this manual Flip up the armrests WARNING WHEN GETTING ON OR OFF YOUR BUZZAROUND LITE DO NOT PUT MOST OR ALL OF YOUR WEIGHT ON THE EDGE OF THE DECK DOING SO MAY CAUSE THE SCOOTER TO TIP GETTING ON YOUR BUZZAROUND LITE Make certain that the key is removed Position the seat for safe and easy mounting See Operation section Carefully place one foot on the approximate center of the deck and seat yourself comfortably and securely on the seat Fasten the lap belt if your scooter is so equipped Flip down the armrests GETTING OFF YOUR BUZZAROUND LITE Make certain that the power is turned off and key is removed Flip up the armrest Unfasten the lap belt if your scooter is so equipped Carefully place one foot on the ground transfer your weight to that leg and slowly come to a standing position Step away from the scooter MAXIMUM WEIGHT Your Buzzaround Lite has been rated to a maximum payload includes operator and any other carry on baggage of 250 pounds Exceeding the maximum weight rating will void the warranty WARNING EXCEEDING THE MAXIMUM WEIGHT RATING MAY ALSO RESULT IN INJURY TO YOU AND TO OTHERS Buzzaround Lite Owner s Manual Models GB106 and GB106XR Updated 07 08 Page 6 SAFETY DRIVING YOUR BUZZAROUND LITE ON AN INCLINE For maximum stability lean forward on your seat while
28. oes not comply with applicable federal state or local laws or ordinances Buzzaround Lite Owner s Manual Models GB106 and GB106XR Updated 07 08 Page 3 CONTENTS ________________________________________ Introduction 4 5 Safety 6 8 EMI RFI 9 Your Golden Technologies Buzzaround Lite 10 11 Operation 12 16 Riding Your Buzzaround Lite 17 20 Diagnostics 21 General Care and Maintenance 22 26 Care and Maintenance of your Buzzaround Lite 27 Disassembly of your Buzzaround Lite 28 30 Assembly of your Buzzaround Lite 31 34 Transporting your Buzzaround Lite 35 Buzzaround Lite Specifications 36 Warranty 37 Warranty Card 39 Buzzaround Lite Owner s Manual Models GB106 and GB106XR Updated 07 08 Page 4
29. ons Step 1 Place your scooter on a level surface WARNING BE SURE YOUR KEY IS OUT OF THE KEYHOLE BEFORE YOU BEGIN DISASSEMBLING YOUR BUZZAROUND LITE Step 2 Optional Remove the arms from the seat This will reduce the weight of the seat making it easier to lift Step 3 While holding the seat rotation lever up grip the seat and remove from the scooter Your seat will pull out of the post Grip the seat on opposite sides and with a firm grip pull the seat straight up towards you to remove Pop the seat Buzzaround Lite Owner s Manual Models GB106 and GB106XR Updated 07 08 Page 29 DISASSEMBLY OF YOUR BUZZAROUND LITE cont Step 4 Lift the battery box from the scooter This will unlock the frame latch automatically Pull the battery box Step 5 Loosen tiller adjustment knob and fold the tiller down flat Then tighten the adjustment knob to secure the tiller in its new position Once the tiller is flat you may use it as a handle for easy transportation Loosen this knob to lay tiller flat Turn this knob to lock the front wheel Step 6 Lock tiller lock This knob is found just above the front wheel Push in and turn clockwise 90 degrees You should lock the front wheel to keep it from turning side to side to help control while carrying Buzzaround Lite Owner s Manual Models GB106 and GB106XR Updated 07 08 Page 30 DISASSEMBLY OF YOUR BUZZAROUND LITE Cont Tighten the knob fu
30. ons made to any part without the specific consent of Golden Technologies Exceeding the specified weight capacity of the unit Accessories other than those supplied or approved by Golden Technologies Failure to adhere to the product instructions Acts of Nature such as lightning strikes earthquakes etc Circumstances beyond the control of Golden Technologies ANY PARTS ALTERED OR REPAIRED BY UNAUTHORIZED PERSON Warranty Service Warranty Service must be performed by an authorized Golden Technologies representative Golden Technologies reserves the right to replace warranted part s with refurbished or new part s at our discretion All labor charges service calls transportation costs or any other charge s associated with the installation of any warranted part s are the responsibility of the consumer Warranty is for the replacement of the parts only and does not include freight for the replacement parts Consumers are not to return any item s to Golden Technologies without prior written authorization Any damages incurred while warranted part s are in transport are the sole responsibility of the consumer There is no other express warranty Implied warranties including those of merchantability and fitness for a particular purpose are excluded Liabilities for consequential damages are excluded This warranty gives you specific rights and you may also have other rights which may vary from state to state Buzzaround Lite Owner
31. proceeding up ramps slopes curbs or any low rise Drive with caution when attempting to negotiate any incline even handicap access ramps Always climb or descend a gradient by driving straight up or straight down the face of the slope Do not traverse or drive across the face of a gradient Do not attempt to negotiate an incline that is covered with snow ice cut or wet grass leaves or any other potentially hazardous material Do not back down an incline Try to keep your Buzzaround Lite moving when climbing an incline If you do come to a stop restart and accelerate slowly and carefully Do not try to descend or climb a slope whose gradient is greater than recommended See Specifications section WARNING IF WHILE YOU ARE DRIVING DOWN A SLOPE YOUR SCOOTER STARTS TO MOVE FASTER THAN YOU FEEL IS SAFE RELEASE THE THUMB LEVER AND ALLOW YOUR BUZZAROUND LITE TO COME TO A STOP WHEN YOU FEEL THAT YOU AGAIN HAVE CONTROL OF YOUR SCOOTER PUSH THE THUMB LEVER FORWARD AND CONTINUE SAFELY DOWN THE REMAINDER OF THE SLOPE DRIVING DOWN AN INCLINE Always drive forward down any ramp low rise or incline Never drive your scooter in reverse down any incline ramp curb or low rise Backing down any slope may create a very hazardous situation Max incline GB106 6 Max incline GB106XR 7 5 Buzzaround Lite Owner s Manual Models GB106 and GB106XR Updated 07 08 Page 7 SAFETY RULES FOR USE AN
32. r battery charger is operating properly Resetting the Main Circuit Breaker If the main circuit breaker trips as a result of run down batteries or because of a temporary overload reset the circuit breaker using the following directions 1 Wait 5 minutes to allow the motor and electronics board to cool or return to normal operating temperature 2 Press in on the main circuit breaker reset button WARNING BE SURE YOU REMOVE THE KEY FROM THE KEY RECEPTACLE BEFORE RESETTING YOUR SCOOTER NOTE If the main circuit breaker continues to trip there is an underlying electrical fault that needs professional attention Please contact your local Golden Technologies Dealer NOTE Do not reset your main circuit breaker repeatedly You must correct the underlying problem Failure to correct the problem could cause injury or damage and will void the warranty Buzzaround Lite Owner s Manual Models GB106 and GB106XR Updated 07 08 Page 24 GENERAL CARE AND MAINTENANCE Wheels and Tires Your Buzzaround Lite scooter is equipped with split rim wheels and foam filled tires Front Tire Rear Tire Solid Foam filled Solid Foam filled How to change a tire assembly 1 Remove the center nut 2 Remove the tire assembly from the scooter 3 Install a new tire assembly onto the axle 4 Install and tighten the center nut NOTE All tires on your Buzzaround Lite are foam filled This means that there is NO air in any tire The tires
33. s Manual Models GB106 and GB106XR Updated 07 08 Page 39 Scooter Warranty Card Please mail this document to Golden Technologies Inc Warranty Registration Office 401 Bridge Street Old Forge PA 18518 Please fill in your Buzzaround Lite information below This information will be useful in the event that you ever need to contact Golden Technologies concerning your scooter Model __________ Serial Number _____________________ Date of Purchase _________________ Body Color _____________ Options______________________________________________________ Your Golden Technologies representative or dealer Name________________________________________________________ Company _____________________________________________________ Address ______________________________________________________ _____________________________________________________________ I have read and fully understand ____ My Golden Technologies Buzzaround Lite owner s manual including the sections on operating instructions safety guidelines maintenance and battery instructions ____ Golden Technologies Buzzaround Lite Warranty ____ My Golden Technologies Buzzaround Lite dealer has instructed me on how to operate my scooter Signature____________________________________ Telephone _____ ________ __________________ Buzzaround Lite Owner s Manual Models GB106 and GB106XR Updated 07 08 Page 40 Y O U R L I F E I N M O T I O N BuzzLite GB106 GB106XR OWN 0708
34. t operate or store your scooter where it will be exposed to rain snow mist and below freezing temperatures Do not operate your scooter on slippery icy or salted surfaces Never charge a frozen battery Do not modify your scooter in any way that is not authorized by Golden Technologies Buzzaround Lite Owner s Manual Models GB106 and GB106XR Updated 07 08 Page 8 SAFETY RULES FOR USE AND OTHER SAFETY CONSIDERATIONS FOR YOUR BUZZAROUND LITE Read completely and understand this owner s manual before assembling operating transporting or disassembling your scooter Always operate your Golden Technologies Buzzaround Lite with thought care and safety Do not attempt to use your scooter on an escalator Always use an elevator Do not carry passengers under any circumstances Do not mount or dismount your scooter unless the brake is engaged Make certain that the key is removed before mounting or dismounting your scooter Do not back your scooter down an incline or across an uneven surface Make certain that the seat is locked in the forward position before operating your scooter Always come to a full stop before changing direction from forward to reverse or from reverse to forward Do not operate your scooter where you could not safely or legally walk Do not climb ramps or curbs that exceed your scooter s capacity Always approach curbs a
35. uminate Once illuminated your scooter is powered Note Always make certain that the key is removed from the key switch before getting on or off your scooter Buzzaround Lite Owner s Manual Models GB106 and GB106XR Updated 07 08 Page 13 OPERATION When the power to your Buzzaround Lite is turned on an LED Light Emitting Diode will illuminate This LED is used in diagnosing operational problems that may arise See Diagnostics section on page 21 Horn Button Press this button to sound the horn Drive Control LEver This self centering drive control lever system controls your Buzzaround Lite speed up to the maximum speed set by the speed adjustment dial as well as the forward and reverse direction This control system is also called the Wig wag To drive forward Place your hands on the handgrips Use your thumbs to operate the drive control lever User your right thumb to press lightly on the F forward motion lever to move your scooter forward Increase the pressure applied by your thumb to increase your forward speed To stop your Buzzaround Lite release all pressure on the lever The lever will automatically return to the center neutral position and your scooter will come to a gradual stop Note Always bring your Buzzaround Lite to a full stop before changing direction from forward to reverse or from reverse to forward To drive in reverse Place your hands on the handgrips
36. warranty registration card We at Golden Technologies Inc would appreciate hearing about your experience with your new Buzzaround Lite scooter Please mail your warranty card to Golden Technologies Inc Warranty Registration Office 401 Bridge Street Old Forge PA 18518 Phone 570 451 7477 Fax 570 451 7494 Stop by our website 24 hours a day www goldentech com Buzzaround Lite Owner s Manual Models GB106 and GB106XR Updated 07 08 Page 5 INTRODUCTION Your Golden Technologies Buzzaround Lite is a battery operated personal mobility vehicle Please exercise caution and consideration when you are operating it Driving your Buzzaround Lite carefully and thoughtfully will help ensure your personal safety and the safety of other people Note Before learning to operate your Buzzaround Lite have your Golden Technologies Inc representative determine if it is advisable for you to practice getting on and off your Buzzaround Lite and operating it in the presence of an attendant BEFORE GETTING ON YOUR BUZZAROUND LITE READ COMPLETELY AND UNDERSTAND THIS OWNER S MANUAL BEFORE ASSEMBLING OPERATING TRANSPORTING OR DISASSEMBLING YOUR GOLDEN TECHNOLOGIES BUZZAROUND LITE Check to be certain that the key is removed See operation section in this manual This will eliminate the possibility of accidentally activating the thumb lever controls and causing injury to you or to others Check to be certain that your scooter brake ha
37. y meet during the daily use of your scooter Listed with those obstacles are some driving tips that should help you conquer those obstacles Learn and follow those tips and with surprising ease you will soon be in control of your scooter as you maneuver it through doors up and down ramps up and over curbs through grass and gravel and up and down inclines Doors Approach any unfamiliar door slowly Notice if the door has a knob or a push bar Determine if the door opens towards you or away from you Do not try to use your own strength to open the door Learn to use the power of your scooter to do the majority of the work for you If the door opens away from you 1 Use one hand to turn the doorknob or to operate the push bar 2 Use your other hand to steer the scooter and to gently press on the thumb lever that will move your scooter slowly forward 3 Use your arm to push the door gently open 4 Drive through the doorway 5 If it is a self closing door it will close behind you 6 If it is not a self closing door stop your scooter when it is clear of the door and use your hand to push the door closed If the door opens towards you 1 Use one hand to turn the doorknob or to pull the handle 2 Keep your grip on the knob or on the handle 3 Use your other hand to steer your scooter and to gently press the thumb lever that will move your scooter slowly in reverse 4 Allow the power of your Buzzaround Lite to pull the door co
38. you ever need to contact Golden Technologies concerning your scooter Model ________ Serial Number _____________________ Date of Purchase _________________ Body Color _____________ Options______________________________________________________ Your Golden Technologies representative or dealer Name________________________________________________________ Company _____________________________________________________ Address ______________________________________________________ _____________________________________________________________ Please remember to fill in and return your Warranty registration card Buzzaround Lite Owner s Manual Models GB106 and GB106XR Updated 07 08 Page 12 GB 106 Buzzaround Lite Operation DC Battery Voltage Meter Key On position Horn Button Speed Adjustment Knob Reverse Drive Control Lever Forward Hand Controls Speed Adjustment Dial The speed adjustment dial allows you to pre select the maximum top speed of your Golden Technologies Buzzaround Lite Turn the dial completely counterclockwise to operate your scooter at the lowest speed Turn the dial clockwise to operate your scooter at top speed We recommend that you select a speed setting at which you feel comfortable safe and in control of your scooter Key Switch This switch turns the power of your Buzzaround Lite on and off Insert the key into the keyhole and push until fully inserted Notice a green LED light ill
Download Pdf Manuals
Related Search