Century HES80 User's Manual
Contents
1. INSTALLER CONSUMER IT SAFETY INFORMATION i CENTURY PLEASE READ THIS MANUAL HEATING BEFORE INSTALLING AND m USING APPLIANCE BA N F F WARNING IF THE INFORMATION IN THIS MANUAL IS NOT FOLLOWED Freestand I ng EXACTLY AN ELECTRICAL SHOCK OR FIRE MAY RESULT CAUSING Electric StOVe PROPERTY DAMAGE PERSONAL INJURY OR LOSS OF LIFE Model H ES80 FOR YOUR SAFETY Service must be performed by a qual ified service agency DO NOT STORE OR USE GASOLINE OR OTHER FLAMMABLE VAPORS OR LIQUIDS IN THE VICINITY OF THIS OR ANY OTHER APPLIANCE SP C US Installation Instructions and Homeowners Manual CFM Home Products 2695 Meadowvale Blvd e Mississauga Ontario Canada L5N 8A3 800 668 5323 INSTALLER DO NOT DISCARD THIS MANUAL LEAVE FOR HOMEOWNER S190006 6 04 Rev 0 Table of Contents PLEASE READ THE INSTALLATION amp OPERATING INSTRUCTIONS BEFORE USING THIS APPLIANCE Thank you and congratulations on Vour purchase of a CFM Home Products stove IMPORTANT Read all instructions and warnings carefully before starting installation Failure to follow these instructions may result in a possible electric shock fire hazard and will void the warranty Installation Instructions General ELSE 3 Locating Your Stove 3 Stove DIMENSIONS aiam Ei ele nad Sede Redden de kac e ee ds 4 Clearance to Combustibles 5 Hearts saura name2. 610 mm hearth is not mandatory but is recommended for aesthetic purposes We recommend a noncombustible hearth which does not obstruct heater openings Electric Specifications Voltage siccus dues 120V AC 60Hz Total Amps 12 20 Amps Total Watts cae sisse mass em 1460 Watts Heater Ratings 1300 Watts Electrical Connection 15 Amp 120 Volt 60 Hz circuit with a properly grounded outlet is required Preferably the appliance will be on a dedicated circuit as other appliances on the same circuit may cause the circuit breaker to trip or the fuse to blow when the heater is in operation The unit comes standard with a 6 1 8m long three wire cord exiting from the rear of the stove Plan the installation to avoid the use of an extension cord If an extension cord must be used it must be a minimum 14AWG three wire with grounding type plug connector and rated not less than 1875 Watts The cord shall not be more than 20 6m in length WARNING Electrical outlet wiring must comply with local building codes and other applicable regulations to reduce the risk of fire electrical shock and injury to persons WARNING Do not use this stove if any part of it has been under water Immediately call a qualified service tech nician to inspect the stove and replace any part of the electrical system Pp S790006 Fan Kit Installation When installed the heater must be elec
3. a qualified service person Under no circumstances should this appliance be modified Parts having to be removed for servicing must be replaced prior to operating this stove again Do not use outdoors This heater is not intended for use in bathrooms laundry areas and similar indoor locations Never locate this appliance where it may fall into a bathtub or other water container 10 Do not run cord under carpeting Do not cover cord with throw rugs runners or the like Arrange cord away from traffic areas and where it will not be tripped over 11 To disconnect this appliance turn controls to the off position then remove plug from outlet 12 Connect to properly grounded outlets only 13 This appliance when installed must be electrically grounded in accordance with local codes with the current CSA C22 1 Canadian Electrical codes or for USA installations follow local codes and the National Electric Code ANSI NFPA No 70 S790006 14 Do not insert or allow foreign objects to enter any ventilation or exhaust opening as this may cause an electric shock fire or damage the appliance 15 To prevent possible fire do not block air intakes or exhaust in any manner Do not use on soft sur faces like a bed where openings may become blocked 16 This appliance has hot and arcing or sparking parts inside Do not use it in areas where gasoline paint or flammable liquids are used or stored This appli ance should not
4. be used as a drying rack for cloth ing nor should Christmas stockings or decorations be hung on or near it 17 Use this appliance only as described in this manual Any other use not recommended by the manufac turer may cause fire electric shock or injury to per sons 18 Avoid the use of an extension cord because the extension cord may overheat and cause a risk of fire However if you have to use an extension cord the cord shall be No 14 AWG minimum size and rated not less than 1875 Watts The extension cord must be a three wire cord with grounding type plug and cord connector The extension cord shall not be more than 20 feet 6m in length 19 SAVE THESE INSTRUCTIONS Locating Your Stove Your new freestanding electric stove may be installed virtually anywhere in your home However when choosing a location for your new stove ensure that the general instructions are followed Also for best effect install the stove away from direct sunlight Stove Dimensions LA 24 616 mm I 14 362 mm LLL L S 224 572 mm 13 343 mm S190006 Clearance to Combustibles Baok EE NR 2 51 mm SIDES sise cesi Pee Pacem a ee 6 153 mm gp en ins ni 0 0 mm OO 24
5. A trically connected and grounded in accor dance with local codes or in th absence of local codes with ANSI NFPA No 70 NOTE 110 120 electric power is required to operate blower fan Be sure to leave sufficient excess wire in case minor adjustments are required Any electrical re wiring of this fan must be done by a qualified electrician Turn off all power before installation CAUTION Be careful not to touch or bend the flame generator 1 Remove panel from back of pedestal 2 Install the fan through the opening at the back of the pedestal Place fan assembly as far forward as possible inserting long flange through slot in front panel Fig 1 Fig 1 Insert flange through slot in front panel 3 Use two screws provided to secure fan assembly to base of pedestal Fig 2 4 From front of unit attach brass handle to front of fan assembly flange Fig 3 5 Plug in grounded service cord to a convenient wall receptacle 6 Replace rear panel in pedestal Fan Assembly Fig 2 Secure fan assembly to base of pedestal Fig 3 Attach brass handle to front of unit Service Instructions 1WARNING Disconnect power before attempting any maintenance or cleaning to reduce the risk of fire electrical shock or personal injury Maintenance of Motors The motors used on the fan and the flame generator assembly are prelubricated for extended bearing life and require no further lubrication Howe
6. ACK WIRE 3 BLACK WIRE 8 WHITE RED WIRE BLACK WIRE If repairing or replacing any electrical component or wiring the original wire routing color coding and securing locations must be followed MOTOR FLAME GENERATOR WHITE WIRE REMOTE RECEIVER e WIRE 11 RED WIRE 10 WHITE WIRE 6 BLACK BLACK WIRE d MGE HEATER WIRE 9 WHITE ul GREEN WIRE Operating Instructions Main On Off Switch The On Off switch supplies power to all of the func tions of the stove It is located at the top rear of the unit WARNING During any service of this appliance the power to the unit must be turned off It is not acceptable to use the On Off switch to meet this requirement On Off Switch Heater Control Flame Control Fig 4 HES80 controls S790006 Heater Control The heater control acts to turn the heater on and off as well as setting the comfort level in the room Turning the knob clockwise from the off position will place the heater into operation The further the knob is rotated clockwise the higher the set point temperature turning the knob counterclockwise will lower the set point tem perature Turning it all the way counterclockwise will turn the heater function off 1 YEAR WARRANTY For Century Heating Electric Stove BASIC WARRANTY CFM Home Products hereinafter referred to collectively as the Company warrants that you
7. a ou pr vu par la loi 7 Toutes autres garanties exprim es ou sous entendues en ce qui a trait au produit ses composants et accessiores OU toutes obligations responsabilit s de la part de la Soci t sont aux pr sentes expressment excluses 8 La Soci t n assume et n autorise personne assumer en son nom toutes responsabilit s en ce qui a trait la vente de ce produit Majestic Fireplaces 9 Les garanties telles que d crites dans ce document ne s appliquent accessoires non CFM Home Products utilis s conjointement pour l installation de ce produit Cette garantie est nulle si a Le po le a t utilis dans une atmosph re contamin e par du chlore du fluor ou tous autres produits chim iques b Le po le est assujetti de longues p riodes d humidit ou de condensation c Toute alt ration abus volontaire accident ou mauvais usage du produit annulera cette garantie SI UN SERVICE SOUS GARANTIE EST REQUIS 1 Communiquez avec votre d taillant Assurez vous que vous avez votre garantie votre re u de caisse ainsi que le num ro de mod le s rie de votre produit CFM Home Products 2 NE TENTEZ PAS D EFFECTUER DES REPARATIONS VOUS MEME S190006
8. as provided by law 7 All other warranties expressed or implied with respect to the product its components and accessories or any obliga tions liabilities on the part of the Company are hereby expressly excluded 8 The Company neither assumes nor authorizes any third party to assume on its behalf any other liabilities with respect to the sale of this Norther Flame product 9 The warranties as outlined within this document do not apply to non CFM Home Products accessories used in con junction with the installation of this product This warranty is void if a The stove has been operated in atmospheres contami nated by chlorine fluorine or other damaging chemicals b The stove is subjected to prolonged periods of damp ness or condensation c Any alteration willful abuse accident or misuse of the product IF WARRANTY SERVICE IS NEEDED 1 Contact your supplier Make sure you have your warranty your sales receipt and the model serial number of your CFM Home Products product 2 DO NOT ATTEMPT TO DO ANY SERVICE WORK YOUR SELF GARANTIE DE BASE CFM Home Products aux pr sentes nommee la Soci t garantit votre nouveau po le lectrique Northern Flame contre tous d fauts de fabrication et de mati res premi res pour une p riode d un an a compter de la date d installa tion sujet aux conditions et limitations suivantes 1 Le po le electrique doit tre install par un entrepreneur de service autor
9. ee cidre dant ee ex nds 5 Electrical Specifications 5 Electrical Connections 4 2444 esa ede em a mana eed eR e dee das 5 Fan Kit Installation sus canes ah seat dee ed dks A ee dea 5 Service Instructions Replacing Light Bulbs 6 Maintenance of Motors 6 Electrical Wiring Diagram 7 Operating Instructions ONOR GWC eoira ne en ue ee intention 7 Heater Control n T Warranty xod ene die ane d date tune date ee whee bed ha EA 8 2 S190006 Installation Instructions D w A O1 o N oO Read all instructions before using this appliance This appliance is hot when in use To avoid burns do not let bare skin touch hot surfaces If provided use handles when moving this appliance Keep combustible materials such as furniture pillows bedding papers clothes and curtains at least 3 feet 914mm from the front of this appliance CAUTION Extreme caution is necessary when any heater is used by or near children or invalids and whenever the heater is left operat ing unattended If possible always unplug this appliance when not in use Do not operate any heater with a damaged cord or plug or after the appliance malfunctions has been dropped or damaged in any manner Any repairs to this appliance should be carried out by
10. is et comp tent Il doit tre install et utilis en tout temps selon les instructions d installation et de fonc tionnement fournies avec le produit Toute alt ration abus volontaire accident ou mauvais usage du produit annulera cette garantie 2 Cette garantie n est pas transf rable et est offerte l a cheteur au d tail d origine condition que l achat soit effec tu par l entremise d un d taillant autoris de la Soci t 3 Cette garantie est limit e la r paration ou au remplace ment de des pi ce s trouv e s d fectueuse s en mati res premi res ou main d oeuvre condition que les dites pi ces aient t sujettes aux conditions normales d usage et de service apr s que ledit d faut a t confirm par une inspection par la Soci t 4 Cette Garantie ne couvre pas les ampoules inclus dans le po le lectrique 5 La Soci t peut sa discr tion se d charger enti rement de toutes obligations se rapportant cette garantie en rem boursant le prix de gros de la des pi ce s d fectueuse s 6 Tous les frais d penses d installation de main d oeuvre de construction de transport ou autres caus s par une des pi ce s d fectueuse s une r paration un remplacement ou autre ne seront pas couverts sous cette garantie et la Soci t n assume aucune responsabilit pour ceux ci De plus la Soci t ne pourra tre tenue responsable pour tous dommages fortuits ou indirects sauf l
11. r new Century Heating stove is free from manufacturing and material defects for a period of one year from date of installation subject to the following conditions and limitations 1 This electric stove must be installed and operated at all times in accordance with the Installation and Operating instructions furnished with the product Any alteration willful abuse accident or misuse of the product shall nullify this warranty 2 This warranty is non transferrable and is made to the origi nal owner provided that the purchase was made through an authorized supplier of the Company 3 This warranty is limited to the repair or replacement of part s found to be defective in material or workmanship provided that such part s have been subjected to normal conditions of use and service after said defect is confirmed by the Company s inspection 4 This warranty does not cover the lightbulb s included with the stove 5 The Company may at its discretion fully discharge all obli gations with respect to this warranty by refunding the wholesale price of the defective part s 6 Any installation labour construction transportation or other related costs expenses arising from defective part s repair replacement or otherwise of same will not be cov ered by this warranty nor shall the Company assume responsibility for same Further the Company will not be responsible for any incidental indirect or consequential damages except
12. ver periodic cleaning vacuuming of the fan heater unit is recom mended WARNING Make sure the power is turned off before proceeding Replacing Light Bulbs This stove uses two clear 120 Volt 60 Watt E 12 socket base light bulbs small base chandelier candle type The 60 Watt bulbs are located under the log set ember bed For convenience if one of the bulbs burns out it may be a good idea to replace both of the light bulbs 1 Turn off power to the unit by unplugging the power cord Let stove cool if it has been operating Remove rear access panel from back of pedestal to expose light bulbs CO N o CAUTION Be careful not to touch or bend the flame generator 4 Examine the bulbs to determine which bulb needs to be replaced 5 Unscrew defective bulb s Install new 60 Watt light bulb s Replace rear access panel Plug power cord into wall outlet WARNING Do not exceed 60 watts per bulb Use of higher rated bulbs may result in a fire causing property damage or per sonal injury N O S190006 7 Electrical Wiring Diagram Any electrical repairs or rewiring of this unit should be carried out by a licensed electrician in accordance with national and local codes A WIRE 2 BLACK WIRE 1 BLACK SPEED CONTROL SWITCH THERMOSTAT D m SWITCH OFF ON LP WIRE 5 BLACK ORANGE WIRE WIRE 7 WHITE RED LINE OUTPUT RED LINE INPUT SPEED CONTROL J D WIRE 4BL
Download Pdf Manuals
Related Search