Cal Flame LTR20091082 User's Manual
Contents
1. Listen for the sound of the gas igniting If the burner does not light on the first try repeat immediately If the burner does not light after three attempts turn the control knobs to the OFF position Wait five minutes until the gas clears before attempting to light it again Repeat the procedure or try the manual lighting procedure below Upon successful lighting repeat the process on the other burners you wish to light To shut off the burners rotate the knob and turn to OFF It is nor mal to hear a popping sound when the burners are turned off lt www calspas com a uang pis 3ulsn 5 Using Your Side Burner Manually Lighting the Side Burners WARNING Do not use standard matches or cigarette lighters to per form match lighting procedures Serious burns can occur and lighters can explode 1 Open the hood 2 If you have just attempted to light the burner allow five minutes for any accumulated gas to dissipate 3 Keep your face as far away from the burners as possible 4 Light and insert a long stem match holding it near the burner ports 5 Push in and turn the control knob just past the LIGHT position to HIGH 6 Listen for the sound of the gas igniting If the burner does not light after five seconds turn the control knobs to the OFF position Wait five minutes until the gas clears before attempting to light it again 7 If the burner does not light after several attempts see Trou2. Perform a leak test at least once a year whether the gas supply cyl inder has been disconnected or not In addition whenever the gas cylinder is connected to the side burner or whenever any part of the gas system is disconnected or replaced perform a leak test As a safety precaution remember to always leak test your side burner outdoors in a well ventilated area Never smoke or permit sources of ignition in the area while doing a leak test Do not use a flame such as a lighted match to test for leaks Use a solution of soapy water 1 6 Prepare a leak testing solution of soapy water by mixing in a spray bottle one part liquid soap to one part water Make sure all the control knobs are in the OFF position Turn on the gas Apply the leak testing solution by spraying it on joints of the gas delivery system Blowing bubbles in the soap solution indicates that a leak is present Stop a leak by tightening the loose joint or by replacing the faulty part with a replacement part recommended by the manu facturer Do not attempt to repair the cylinder valve if it is dam aged The cylinder must be replaced Turn all control knobs back to the full OFF position If you are unable to stop a leak 1 2 Turn all control knobs back to the full OFF position Shut off the gas supply to the side burner and release pressure in the hose and manifold by pushing in and turning any of the control valves one quarter turn counter clockw
3. burners You will not need all of the parts in the kit Before you begin make certain the LP gas source has been discon nected Replacing the side burner orifices 1 Remove the grate burner cap and burner diffuser from the side burner Using a 7mm wrench remove the orifice for the burner Apply a small amount of pipe compound to the orifice threads Screw in the orifice until it is finger tight Tighten the orifice with the 7mm wrench aan kW N If you have dual side burners repeat the previous steps for the second burner Cal Flame Side Burners LTR20091082 Rev A www calspas com xipueddy S Appendix 9 2009 WARRANTY LMS offers the following limited warrants against defects in material and workmanship on Cal Flame barbecue products and components One Year Warranty LMS warrants against deterioration and corrosion all parts equipment and construction for a period of one year Extent of Warranty This warranty is only valid on Cal Flame side burners delivered in the United States or Canada and extends through the selling dealer to the original purchaser at the original site of installation This warranty becomes valid at time of purchase and ends either by specified time frame listed above or upon owner transfer or relocation Manufacturer Warranty All Cal Flame models are manufactured with the highest quality ap pliances and are warranted to be free from defects in material and workman
4. or incorrect and or prohibited applications as specified in the owner s manual Gas lines must be installed by a licensed plumber only or local gas com pany agent Incorrect electrical installation by unlicensed electricians service by non LMS authorized representatives acts of God and other cases beyond the control of LMS are not covered by this warranty Please refer to the owner s manual for examples of exclusions and common acts invalidating this warranty This limited warranty applies only to side burners used for personal family and outdoor household purposes This warranty does not apply to labor charges on side burn ers replacement parts and hardware This limitation is retroactive and applies to all side burners manufactured from 2000 and hereafter xipueddy 3 Legal Remedies This limited warranty gives you specific legal rights You may have other rights which may vary from state to state Customer Service For customer service contact the authorized selling dealer immedi ately If you need additional information or assistance please contact the LMS Customer Relations Department at 1462 E Ninth St Pomona CA 91766 or call 800 225 7727 See your Cal Flame barbecue dealer for a copy of the applicable war ranty details and any questions you may have regarding the warranty coverage on your barbecue Warranty Limitations The Limited Warranty is void if the side burner has been subject to negligence alterati
5. for cleaning and is dishwasher safe Use a solution equal parts detergent and hot water just as you would for any cooking equipment A stiff wire brush or steel wool may also be helpful in removing grime and food deposits Covering Your Side Burner When not in use and after cooling cover your side burner with our canvas cover See your local Cal Flame dealer for details The cover will help protect your side burner from detrimental effects of weather and environmental pollutants Never put a cover on a hot side burner Allow the side burner to cool before covering GF bane Cal Flame Side Burners www calspas com LTR20091082 Rev A Troubleshooting Problem Solution Problem Solution Problem Solution Problem Solution Smell of gas is present Check for loose connections in the gas line Perform a leak test following the procedure described in this man ual Burner does not ignite Check the position of the sparker tip It should be point ing forward towards the front of the burner e Make sure there is a blue spark at the electrode tip to the burner e Make sure the igniter wire is connected firmly to the valve ignition device and the electrode e Make sure the valve orifice is free of any debris dust or grease If there is no spark at all replace the electrode or igniter wire Note Turn off the gas at the source while troubleshoot ing Obstruction in the gas line Remove the fuel line
6. the gas supply closed and control knobs set to the off position check each position igniter individu ally for the presence of a spark at the electrode Push each knob in fully and rotate it about 1 4 turn to the left counter clockwise until you hear a loud click The trigger hitting the strike block should produce a blue spark at the electrode tip Return control knob to the off position before checking the next igniter CF Cal Flame Side Burners www calspas com LTR20091082 Rev A Converting Side Burner from LP to NG When converting an LP side burner that is connected to an LP grill you MUST convert both appliances It is dangerous to have an LP appliance and an NG appliance supplied by the same fuel WARNING You must have an authorized service technician perform this procedure If these instructions are not followed exactly a fire or explosion may result causing property dam age personal injury or loss of life Lloyd s Material Supply LMS will not be held responsible for an improperly converted gas side burner All Cal Heat side burners are manufactured to use standard liquid pro pane LP and can be converted to burn natural gas NG You will need one or two orifices depending on the size of the side burner contained in the conversion kit provided with the side burner The conversion kit contains orifices to convert five main burners two small rear infrared burners one large infrared burner and two side
7. 2009 OwWNER S MANUAL United States and Canada Cal Spas Home Resort 1 3025346 www calspas com Installation Assembly Cabinet Cut out Dimensions 4 Gas Requirements and Connection 5 Leak Testing Procedure 6 LP ba as 7 Natural Gas 9 Installing Side Burner with a Grill 10 Using Your Side Burner Lighting the Side Burner 00 cece eee eee 12 Basic Side Burner 14 Cleaning and Maintenance Stainless Steel Care and Cleaning 15 Covering Your Side Burner 18 Appendix Troubleshooting 19 Converting Side Burner from LP to NG 21 2009 Warranty s s l lisi 22 Save these instructionsi Copyright 2008 2009 LMS Tnc All rights re served Duplication vvithout vvritten consent is strictly prohibited Cal Flame is a registered trademark Due to continuous improvement programs all models operation and or specifications are subject to change without prior notice LTR20091082 Rev A 6 15 09 California Proposition 65 Warning Chemicals known to the State of California to cause cancer birth defects or other reproductive harm are found in and or creat ed by the combustion of natural gas propane butane a
8. S Fax 1 909 629 3890 www calspas com LTR20091082 Rev A 6 15 09
9. a replacement hose contact your Cal Flame dealer e Ensure the area around the barbecue is clear of flammable sub stances such as gasoline yard debris wood etc Ensure there is no blockage of the airflow through the vent space located below the face of the unit e When using propane gas e Keep the special ventilation openings in the enclosure free and clear of debris CF lume F Cal Flame Side Burners www calspas com LTR20091082 Rev A e If connected to a propane cylinder carefully inspect the rubber hose attached to the regulator before each use e Ensure the propane cylinder regulator and rubber hose are installed in a location not subject to heating above 125 F 51 C Ensure the burner flames burn evenly along both sides of each burner with a steady flame mostly blue with yellow tipping If burner flames are not normal check the orifice and burner for insects or insect nests Ensure the in line gas valve or gas cylinder valve is always shut OFF when the side burner is not in use Do not operate the side burner with its cover closed or the back burner with its cover installed Electronically Lighting the Side Burners 1 2 3 Cal Flame Side Burners LTR20091082 Rev A Open the hood Keep your face as far away from the burners as possible Rapidly rotate the burner knob counter clockwise past the light position to HIGH You will hear a loud click as the electronic lighter produces a spark
10. ble shooting Guide in the back of this manual Basic Side Burner Operation Before lighting make sure all burner controls are off Do not attempt to light the burners if the smell of gas is present Check the connection with a soap and water solution after attaching the hose For LP units make sure there is gas in the tank and it is sitting upright For natural gas units make sure the shut off valve is on 1 Light the side burners using the instructions on the previous page Place pots on the side burners and cook to desired completion Adjust heat setting if necessary You may set the control knob to any position between HIGH and LOW Do not leave the side burner unattended while cooking Fumi Cal Flame Side Burners www calspas com LTR20091082 To ensure safe and proper maintenance we recommend you follow these directions carefully Clean the side burner regularly as determined by the amount of use and foods cooked In addition keep the area around your side burner clear and free from combustible materials gasoline and other flam mable vapors and liquids Do not obstruct the flow of combustion and ventilation air These instructions describe the best way to care for your stainless steel Although stainless steel will discolor and accumulate grime with regular use it can keep its original shine with periodic cleaning We strongly recommend using a surface protectant to prevent smudging and sur face
11. e for cleaning light soil on all stainless steel surfaces Do not use steel wool or wire brushes to scrub your side burner For light soil use a damp sponge or cloth For heavier stains use a Scotch Brite scrubber or similar product CF dame Cal Flame Side Burners www calspas com LTR20091082 Rev A 1 Clean Thoroughly clean stains food and grime using a sponge or damp cloth with warm water and a mild dish soap Use Fantastik or For mula 409 to remove heavier soil 2 Rinse Thoroughly rinse all surfaces and dry them completely with a clean towel Do not allow stainless steel to air dry 3 Polish We strongly recommend that you apply a surface protectant to all exposed stainless steel surfaces Spray a small amount of WD 40 or Sheila Shine on a piece of paper towel and rub with the grain over the surface of the appliance Using a clean terry cloth or paper towel polish the appliance by rubbing with the grain until excess liquid is removed and the surface shines It should not be oily to the touch however some residue is acceptable Some people have reported that using lemon oil products such as Old English furniture polish is effective for polishing stainless steel and pro tecting the surface N Do not use VVD 40 or Sheila Shine near food or on food preparation surfaces as it is a health hazard Caution A N NEVER spray WD 40 or Sheila Shine near an open flame These products are extremely flammable while in the
12. from side burner Do not smoke or perform any maintenance in the vicinity of an open flame Open the gas valve for one second to blow out any debris Close off the gas valve and reconnect the fuel line securely Yellow Flame Once the entire burner is operating check the flame color to be sure that it is mostly blue Some yellow at the tips may be present due to impurities in the fuel If the flame is golden or yellow in color the reason could be oil film residue from boil over or other foreign mat ter on the burner Cal Flame Side Burners j LTR20091082 Rev A www calspas com xipueddy Appendix Problem Solution Problem Solution Plugged orifice Unplug the orifice as follows Remove burner rack and brass burner Using a 7mm socket or socket wrench remove the brass orifice Gently clear any obstruction with a fine wire Reinstall the orifice and replace the burner racks If an obstruction is suspected in the control valve con tact your local Cal Flame dealer for assistance Misalignment of Igniter on Burner Check for proper position of the electrode tip which is next to but does not touch the brass burner It should be pointing straight up and free of grease to allow proper sparking The ignition wire should be connected firmly to the valve ignition device and electrode Reattach it if it has become disconnected Replace the ignition wire if it is frayed or cracked With
13. ide Burner Read all instructions before you operate your side burner We recommend you wash your side burner with soap and water prior to lighting it for the first time Oils are used during the manufacturing process and some residual oil may still be on the stainless steel parts of your side burner Washing will reduce the possibility of discoloration We also recommend you keep your side burner covered when not in use This will minimize the amount of dust and dirt that accumulates on your side burner and extend the life of your side burner Remember to use your Cal Flame side burner safely by following these reminders It is dangerous to use side burners in any manner other than for what it is designed for e Do not use charcoal in a side burner Do not heat sealed containers such as cans or jars on side burners Explosion may result resulting in injury or death Any sealed con tainer such as a pressure cooker must have a properly operating pressure relieve valve to minimize explosion hazard e Never put combustible material such as paper cloth or flammable liquids on your side burner at any time Do not use the side burner to store flammable materials Lighting the Side Burner Each time you light the side burner check the following e Inspect the hose before using the side burner If there is excessive abrasion or wear or if the hose is cut it must be replaced prior to using the side burner If you need
14. ir Fire aerosol forms Hazard N Do not use a vvire brush or stainless steel on any part of your side burnerl Note Cal Flame Side Burners LTR20091082 Rev A ni www calspas com uvu ureki puc Suluc y Cleaning and Maintenance Rust Removal It is a common misconception that stainless steel does not rust It does not stain corrode or rust as easily as ordinary steel it stains less but it is not stain proof If not properly protected and maintained it can corrode pit and discolor Because salt will accelerate rust and corrosion side burner owners who live near the beach need to be dili A N gent in maintaining their stainless steel hardware You need to clean and polish your stainless steel frequently apply a protectant and ensure water does not collect and puddle Important Periodically clean exterior stainless steel surfaces with WD 40 or Sheila Shine and wipe down with a dry cloth or paper towel until surface is free of rust If there is significant rust or corrosion use a Scotch Brite scrubber Both of these products will act as a surface protectant and help resist smudges stains and rust Although nitric acid also called aqua fortis can be effec tive for rust removal it is a highly corrosive chemical Be cause of the potential for injury or damage to your stain Caution less steel we do not recommend using nitric acid Burner rack The burner rack can all be removed
15. ise On LP systems remove the cylinder from the side burner Call an authorized gas appliance service technician or an LP gas dealer Do not use the appliance until the leak is corrected Fumi Cal Flame Side Burners www calspas com LTR20091082 LP Gas Tank Requirements For plumbed in LP installation use a convertible regulator and set it for LP gas Maximum line pressure for plumbed in propane is 14 WC 3 5 kPa Minimum line pressure for propane is 11 WC The side burner unit must be used with the gas pressure regulator The regulator will control and maintain a uniform gas pressure in the mani fold The burner orifices have been sized for the gas pressure delivered by the regulator WARNING Attempting to operate the side burner unit without the gas regulator installed could cause an explosion and possible death Cylinder Specification Any LP gas supply cylinder used with this side burner must be e Constructed and marked in accordance with the Specifications for LP Gas Cylinders of the U S Department of Transportation or the National Standard of Canada CAN CSA B339 Cylin ders Spheres and Tubes for Transportation of Dangerous Goods and Commission as applicable e Approximately 12 inches in diameter and 18 inches high The maximum fuel capacity is 20 lbs of propane or 5 gallons Full cyl inder weight should be approximately 38 Ibs 43 7 Ibs nominal water capacity Never fill the c
16. items of interest to children in the side burner e Never allow children to sit or stand on any part of the side burner Cal Flame Side Burners ht Fane LTR20091082 Rev A www calspas com suon n sui C Installation Assembly CO Most cities and counties require permits for exterior construction and electrical circuits In addition some communities have codes requiring residential barriers such as fencing and or self closing gates on prop erty to prevent unsupervised access to the property by children under the age of five Your dealer can provide information on which permits may be required and how to obtain them prior to the delivery of your equipment We recommend the installation adjustment and service of your new side burner be performed by LMS qualified installers and service tech nicians to ensure proper operation and prevent accidents When planning your Cal Flame side burner location access to gas lines should be considered The location with the shortest gas line run is recommended When determining a suitable location consider factors such as expo sure to wind proximity to traffic paths and windows that open into the home Cabinet Cut out Dimensions Your Cal Flame side burner is de signed for easy installation into a non combustible enclosure The supporting deck or counter must be flat and level When determin ing the final location of your side burner adequate cross ventila tion
17. llation must conform to local codes or in the absence of local codes with either the National Fuel Gas Code ANSI 2223 1 NFPA54 Natural Gas and Propane Installation Code CSA B149 1 or Propane Storage and Handling Code B149 2 as applicable To prevent fire and smoke damage remove all packaging material before operating side burner Before you start cooking clean the entire side burner thoroughly with hot soapy water This is necessary to remove residual sol vents oil and grease used in the manufacturing process The grates should also be thoroughly cleaned in the same manner Cal Flame Side Burners LTR20091082 Rev A vivvvv calspas com A3 yes Safety Instructions 9 Operation Do not use side burner for other than intended use In the event that a burner goes out turn burner knobs to the full OFF position and let it air out Do not attempt to use the side burner until the gas has had time to dissipate Keep all electrical supply cords and the rotisserie motor cord away from the heated areas of the side burner Never use the side burner in windy conditions If used in a consis tently windy area a windbreak will be required Always adhere to the specified clearances listed in this manual Never line the side burner with aluminum foil When the unit is not in use be sure to turn off the gas at the source When handling LP gas line and connectors do not allow them to c
18. must be present to prevent gas from being trapped in the event of a leak The drawings below show the different types of cabinet cut out dimensions for side burners Model Description Width Depth Height BBQO8898P Deluxe Single Side Burner 12 1 8 21 34 7 Va BBQO8899P Deluxe Double Side Burner 12 3 87 2134 71914 08954 Deluxe Side by Side Burner 25 14 13 7 A A Cal Flame Side Burners www calspas com F LTR20091082 Rev A Gas Requirements and Connection Gas Requirements and Connection IMPORTANT The Cal Flame side burner is manufactured to operate on liquid propane LP However it can be converted to operate on natural gas NG by an authorized service technician Consult your Cal Flame dealer for information on converting your side burner Owners must not convert their side burners themselves At tempting to convert the side burner from LP to NG may re sult in serious injury and will void the warranty coverage Aiquiassy uopeyre sul C If you do not have an updated filler valve on your existing propane tank you will need to purchase one at your local hardware store Without it you will not be able to attach your tank to your Cal Flame side burner or refill the tank at your local propane refill station Cal Flame Side Burners LTR20091082 Rev A www calspas com Installation Assembly Leak Testing Procedure
19. nd other fuels Always operate this unit as described in the owner s manual and in well ventilated areas WARNING Improper installation adjustment altera tion service or maintenance can cause injury or property damage Read the installation operating and maintenance instructions thoroughly before installing or servicing this equipment Placement and Location Cal Flame side burners are designed for outdoor use only Never locate this appliance in an enclosed room under a sealed overhead structure or in any type of enclosed area such as a ga rage shed or breezeway Keep clear of trees and shrubs Do not place a side burner under or near windows or vents that can be opened into your home Cal Flame side burners are not intended for installation in or on recreational vehicles or boats Maintain sufficient distance as to not overheat any overhead com bustible material such as a patio cover The area surrounding your new side burner should be kept clean and free from flammable liquids and other combustible materials such as mops rags or brooms as well as solvents cleaning fluids and gasoline Do not use the side burner or area surrounding the side burner as a storage area for flammable or plastic items Do not store the liquid propane LP cylinder in the vicinity of this or any other ap pliance when it is not being used Set Up We recommend that a licensed contractor install your Cal Flame side burner Insta
20. ome in contact with any metal surfaces of the cart or cabinet Do not drop LP connectors Do not use solid fuel such as charcoal briquettes Never leave the side burner unattended when in use When using pots and pans boil overs will cause smoking and greasy boil overs may ignite Always use the proper size pan Select utensils with flat bottoms large enough to cover the burner The use of under sized utensils exposes the sides of the utensils to direct contact with a portion of the flame This can scorch utensils and hamper cleanup Exces sive flames on large stainless steel pots can result in permanent discoloration For best results we recommend commercial quality aluminum pans and utensils Always position handles of utensils so they do not extend over ad jacent work areas or cooking areas This reduces the risk of burns ignition of flammable materials and spillage due to accidental con tact with the utensils Do not use water on grease fires Never pick up a flaming pan Turn the appliance off and smother the flaming pan with a tight fitting lid a cookie sheet or a flat tray For flaming grease outside of the pan smother it with baking soda or use a dry chemical or foam type fire extinguisher Never allow clothing pot holders or other flammable materials come in contact with or be close to any grate burner or hot sur face until it has fully cooled Never wear loose fitting or hanging Fumi Cal Flame Side Burners www cal
21. on misuse abuse repairs by non LMS authorized representatives incorrect electrical installation acts of God and any other cases beyond the control of LMS Examples of common acts in validating this warranty include but are not limited to e Scratches caused by normal use e Damage caused by extreme weather conditions hot cold etc e Damage caused by dirt sand and or water damage Cal Flame Side Burners LTR20091082 Rev A www calspas com Damage caused by continued operation of the barbecue with ei ther known or unknown problems Damage caused by direct sunlight Appendix 5 Damage caused as a result of failure to follow the operating in structions as defined in this owner s manual This Limited Warranty applies only to barbecues normally used for per sonal family or household purposes This Limited Warranty specifically excludes commercial side burners Warranty Exclusions LMS warrants the side burner from defects in material and workman ship for a period of one year from the original date of purchase CF une Cal Flame Side Burners www calspas com I LTR20091082 Rev A Cal Flame Side Burners LTR20091082 Rev A xipueddy 5 CONTACT INFORMATION For customer service please contact your authorized dealer immediately If you need additional information and or assistance please contact Customer Service Department 1462 East Ninth Street Pomona CA 91766 Toll Free 1 800 CAL SPA
22. rea of not less than one square inch per pound 7 1 cm2 kg of stored fuel capacity and not less than a total free area of 10 square inches 64 5cm2 If ventilation openings at floor level are in a sidewall there shall be at least two openings The bottom of the openings shall be at floor level and the upper edge no more than 5 inches 127 mm above the floor The openings shall be equally sized spaced at 180 3 14 rad and unobstructed c Every opening shall have minimum dimensions so as to permit the entrance of a 1 8 inch 3 2 mm diameter rod Transporting and Storing LP Gas Transport only one cylinder at a time Ensure the cylinder is secured in an upright position with the control valve turned off and the dust cap in place Store cylinders outdoors and out of reach of children Do not store cylinders in a building garage or any other enclosed area Fumi Cal Flame Side Burners www calspas com LTR20091082 A Natural Gas Requirements The installation of this appliance must conform with local codes or in the absence of local codes to the national fuel gas code ANSI Z223 1a 1998 Installation in Canada must be in accordance with the standard CAN CGA B149 2 Propane Installation Code A licensed contractor or local gas company representative must per form all natural gas connections Ensure that the service supplying the side burner is fitted with a shut off valve conveniently positioned near the side burner and gi
23. rust from accumulating The easiest way to clean the side burner is immediately after cooking is completed Doing so will extend the life of your side burner prevent grease fires and present a pleasant appearance while you cook Stainless Steel Care and Cleaning All exposed stainless steel surfaces require special attention if you want to keep them looking clean and bright Following these simple instruc tions will help avoid scratching or damaging the finish and keep your stainless steel attractive Cal Flame Side Burners LTR20091082 Rev A vyvvv calspas com pue 2 Cleaning and Maintenance Cleaning Products and Materials Avoid using these common cleaning products and materials they will damage the surface of your stainless steel e CLR Lime Avvay e Oven cleaner e Cleansers such as Ajax or Comet e Ammonia e Bleach e Chlorine e Steel wool pads e Wire brushes e Scrapers e Pumice We recommend these products for cleaning your stainless steel e Mild dish detergent such as Dawn e Formula 409 e Fantastik e Sheila Shine exterior ONLY WD 40 exterior ONLY We have had best success with Sheila Shine but WD 40 works very well too Sheila Shine is available in some hardware stores WD 40 is widely available Some people have reported that using baking soda lemon oil olive oil vinegar or club soda can be effectiv
24. sealant that is approved for use on LP gas 2 Install the pipe tee assembly to the grill intake pipe Tighten as sembly and align the branch opening of the tee with the hole of the cabinet Connect the flexible hose male end to the pipe tee 4 Install and secure the side burner into the island by simply setting it in place 5 Connect the female end of the flexible hose to the side burner intake pipe 6 Connect gas supply to the grill 7 Check for gas leaks using soap water solution CF lame Cal Flame Side Burners www calspas com LTR20091082 Rev A T Adapter 3 8 Threaded To grill located underneath and To side burner located behind grill underneath behind burner urner From Grill From Side B 3 8 Fittings 141 To Propane Tank NOTE You will need to use a gas rated sealer on gas connectors that are not flared Open barbecue door Install hose with regulator on propane tank Then connect the other end to T adapter Make sure to use gas rated tape seal when installing adapter to insure proper seal B Then take other end of T adapter vvith hose attached and connect to end of male located underneath and at the back of the grill Use gas rated tape seal on all connections Connect the last open line to the side burner Use gas rated tape seal on all connections Cal Flame Side Burners 57777 7 LTR20091082 Rev A www calspas com Aiquiassy uopeyre sul Using Your S
25. ship at time of delivery The appliance warranty is extended through the manufacturer of the product Warranty Performance In the event of a malfunction or defect covered under the terms of this warranty a factory authorized service agent of LMS will perform the necessary repairs To obtain service contact the selling dealer In the event the consumer is unable to obtain satisfactory customer service from the selling dealer or service agent written notification must be given to the LMS Customer Relations Department within 30 days of the reported failure There will be no charge for parts or labor on a covered item However the service agent may assess a reason able travel or mileage charge per service call If LMS determines that repair of a covered item is not feasible L M S reserves the right to replace the defective merchandise with merchandise equal in value to the original purchase price Warranty repair and or replacement is the sole discretion of LMS and this warranty does not cover costs therein including but not limited to freight removal re installation etc This warrant is non transferable and may not be extended beyond the above mentioned time frames under any circumstances by any of LMS s representatives GF lame Cal Flame Side Burners www calspas com LTR20091082 Rev A Warranty Limitations This warranty is void if the side burner has been subject to negligence alteration misuse repairs dings dents scratches
26. spas com LTR20091082 A garments while using your side burner Fabric may ignite and result in personal injury e Only use dry pot holders and do not use a towel or other bulky cloth in place of pot holders Moist or damp pot holders used on hot surfaces can cause burns e Do not heat any unopened glass or metal container of food on the side burner Pressure may build up and cause the container to burst possibly resulting in serious personal injury or damage to the side burner Do not reach over your side burner when hot or in use Maintenance and Repair e Spiders and other insects can nest in the burners of the side burner and block the gas and airflow to the burner ports This creates a dangerous condition that can result in a fire behind the valve pan el Inspect and clean the burners periodically and follow the guide lines in the Cleaning and Maintenance section of this manual e Unless specifically recommended in this manual do not repair or replace any part of the side burner A qualified technician should perform all service Any repairs made by a non L M S approved dealer technician will void your warranty Storage e When your side burner is not in use turn off the gas at the supply cylinder Precautions Regarding Children e Never leave children unattended in the area where the side burner is being used Close supervision of children is necessary when any appliance is use near children e Do not store
27. ving ease of access The side burner must be isolated from the gas supply piping system by closing its individual manual shutoff valve during any pressure testing of the gas supply piping system at test pressures equal to or less than 0 5 psi 3 5 kPa The side burner and its individual shutoff valve must be disconnected from the gas supply piping system during any pressure testing of that system at test pressure in excess of 0 5 psi 3 5 kPa Connection 1 Slide the side burner forward to gain access to the gas connection point in the rear 2 Connect a suitable flex connector to the gas connection point 3 Check the side burner controls to ensure all control valves are in the full OFF position 4 Turn on the main gas supply and check all connections for leaks using soapy water as described in the leak testing procedure sec tion Warning If you see bubbles in the soapy solution at any of the connec tions turn off the gas supply and tighten the connection If tightening the connection does not seal the leak it may be necessary to replace the flex hose Cal Flame Side Burners ht Fane LTR20091082 Rev A www calspas com Aiquiassy uopeyre sul Installation Assembly Installing Side Burner with a Grill If you are installing a side burner in conjunction with a gas grill install it in the following manner 1 Assemble a 3 8 pipe nipple to the 3 8 pipe tee using Teflon tape or pipe sealant Use only
28. ylinder beyond 80 full QCC 1 Cylinder Valve 5 2D Pressure Relief Valve Black Coupling Nut Turn clockwise to connect Bleed off Valve Turn clockwise to close Cal Flame Side Burners lt Fane LTR20091082 Rev A www calspas com Aiquiassy uopeyre sul Installation Assembly Place the dust cap on the cylinder valve outlet whenever the cylinder is not in use Only install the type of dust cap on the cylinder valve outlet that is provided with the cylinder valve Other types of caps or plugs may result in leakage of propane LP Gas Hook Up An enclosure for an LP gas cylinder shall be vented by openings at the level of the cylinder valve and at floor level The effectiveness of the openings for purposes of ventilation shall be determined with the LP gas supply cylinder in place This shall be accomplished in one of the following manners 1 One side of the enclosure shall be completely open 2 Enclosures that have four sides complete with a top and bottom a At least two ventilation openings at cylinder valve level shall be provided in the sidewall equally sized spaced at 180 3 14 rad and unobstructed Each opening shall have a total free area of not less than one square inch per pound 7 1 cm2 kg of stored fuel capacity and not less than a total free area of 10 square inches 64 5 cm b Ventilation openings shall be provided at floor level and shall have a total free a
Download Pdf Manuals
Related Search