Avalon Stoves A10-1224 User's Manual
Contents
1. Mount Supports 2 INSTALLATION INSTR TIONS The Avalon can be used with On Board pre regulated low pressure 1 2 PSI LPG systems or with LPG disposable 1 Ib canisters DOT 39 NRC 228 286 Complete installation requires either Magma A10 1210 Quick Disconnect for On Board LPG Systems or Magma A10 1207 Quick Disconnect Canister Kit see below A10 1210 eS a Quick Disconnect for On Board LPG System Al10 225 Hose Kit A10 1207 Quick Disconnect for Disposable Canister ATTACHING QUICK DISCONNECT FITTING TO BBQ sii To connect retract sleeve of socket Fig 1 Retract Sleeve Fig 1 Fig 2 Insert gas inlet Fig 2 3 Reease Fig 3 Sleeve Release sleeve and push socket until sleeve snaps forward locking gas inlet in socket Fig 3 OPERATING PROCEDURES OPERATE ONLY ON LOW WHEN LID IS CLOSED ALWAYS OPERATE WITH SMOKER BOX IN PLACE ALWAYS OPERATE WITH GREASE TRAY amp GREASE DRIP BOX WITH FOIL LINER IN PLACE ALWAYS COVER FUEL INLET WITH DUST CAP TO PREVENT OBSTRUCTION FROM DEBRIS OR SPIDER WEBS WHEN NOT IN USE WARNING Do not overheat barbecue Stainless Steel loses anti corrosive charac teristics when subjected to extreme heat Stainless Steel parts were made to fit closely to reduce on board rattle extreme heat wi2. part will be repaired or replaced at Magma s option If you wish to obtain performance under this limited warranty you should contact Magma s Customer Service Department via telephone at 562 627 0500 or 800 86 MAGMA or via e mail at magmamail aol com or via U S Postal Service mail at Magma Products Inc attention Customer Service 3940 Pixie Ave Lakewood CA 90712 The defective part along with proof of purchase must be returned postage prepaid to Magma Products Inc We suggest that you keep your purchase receipt as we may require reasonable proof of purchase In the state of California only if refinishing or replacement of the product is not commercially practicable the retailer selling the product or Magma Products Inc will refund the purchase price paid for the product less the amount directly attributable to use by the original consumer prior to the discovery of the nonconformity In addition in the state of California only you may take the product to the retail establishment from which it was purchased or to any retail establishment selling this product in order to obtain performance under this warranty All implied warranties including the implied warranties of merchantability and fitness for a particular purpose are limited in duration to the express warranty periods specified herein for the parts described herein Some states do not allow limitations on how long an implied warranty lasts so the above limitation may not a
3. OWNER S MANUAL L oN by MAGMA Avalon Marine Propane Barbeque Grill Model A10 1224 For questions regarding performance assembly operation parts or returns contact the experts at MAGMA by calling TOLL FREE IN U S A AND Before returning this CANADA 1 800 86 MAGMA item to the 7 00 a m 5 00 p m Pacific Time Monday thru dealer s Friday or e mail us at magmamail aol com M MAGMA Read all instructions before operating Save manual for future reference IMPORTANT SAFETY WARNINGS READ ALL INSTRUCTIONS BEFORE OPERATING USE OUTDOORS ONLY DO NOT USE THIS APPLIANCE INSIDE THE BOAT OR ANY ENCLOSED SPACE BBO5 RADIATE HEAT CLEARANCE FROM COMBUSTIBLES 24 SIDES AND BACK NEVER USE UNDER AWNINGS PATIO COV ERS ETC USE PROPANE GAS ONLY FUEL STORAGE SHOULD BE IN COM PLIANCE WITH THE AMERICAN BOAT AND YACHT COUNCIL ABYC STANDARDS A 1 9 MARINE LIQUIFIED PETROLEUM GAS LPG SYSTEMS FOR NATURAL GAS APPLICATION CONTACT MAGMA ALWAYS LIGHT BBO WITH LID OPEN NEVER LEAVE HOT BARBECUE UNATTENDED USE HOT PAD WHEN HANDLING ALWAYS TURN BBO OFF AFTER USE FEATURES Warming Rack Smoker Box x under grate N Thermometer Grease Tray Lid Lock Grease Tray Grill Lifting Wire Latch Over smoker box Gas Inlet 3 Quick Plastic Disconnect Dust Cap efi Serial Number Grease Drip Box Grease Drip Box Receiver with lock
4. ll cause parts to expand and tighten in place If medium or high heat is required grill with lid open LIGHTING INSTRUCTIONS Open lid during lighting Push and turn knob slowly counter clockwise to high position If unit does not ignite return knob to off position and repeat a Visually confirm ignition Look through hole to ver ie ify flame see Illustration Flame Check Hole Turn knob to adjust flame both sides TO REDUCE FLARE UP Trim excess fats from meat Use non oil based marinades Reduce heat or use one burner only Use water spray directly on flare ups Cook only on low with lid on USE OF GREASE TRAY amp GREASE DRIP BOX ALWAYS LEAVE GREASE TRAY amp GREASE DRIP BOX WITH LINER IN PLACE WHEN OPERATING Grease drip box receiver Locking i clip e y 4 Grease 4 drip box Place in grease 7 drip box so liner Slide box into receiver under BBO is below top until secured by locking clip edge of box Fold lip down flat Lift up on ring to unlock grease tray Pull out to clean only after BBO is cold ADJUSTMENT OF SPARK CAUTION Spark can cause small shock Do not leave fingers on or near igniter wire while engaging sparker Bend electrode wire approximately 3 16 to 1 8 from large hole in burner CORRECT PLACEMENT OF GRILL GRATES Grill grate with grill lift ing wire at front right over the smoker box V Screw head will match
5. pply to you Neither Magma dealers nor the retail establishment selling this product has any authority to make any warranties or to promise remedies in addition to or inconsistent with those stated above Magma s maximum liability shall not exceed the purchase price of the product paid by the original consumer Some states do not allow the exclusion or limitation of incidental or consequential damages so the above limitation or exclusions may not apply to you The warranty gives you specific legal rights and you may also have other rights which vary from state to state MAGMA and the Magma logo are registered trademarks of Magma Products Inc Avalon is a trademark of Magma Products Inc Patent pending CALIFORNIA PROPOSITION 65 WARNING The burning of gas cooking fuel generates some by products which are on the list of substances which are known by the State of California to cause cancer or reproductive harm California law requires businesses to warn customers of potential exposure to such substances To minimize exposure to these substances always operate this unit according to the use and care manual ensuring you provide good ventilation when cooking with gas GMA Magma Products Inc 3940 Pixie Avenue Lakewood CA 90712 USA Phone 562 627 0500 e mail magmamail aol com 5 2002 Website www magmaproducts com 60 1224
6. slot in the bottom rod of grill grate USING SMOKER BOX ALWAYS OPERATE WITH SMOKER BOX IN PLACE Wood chips must be soaked in water prior to use per wood chip manufacturer s instructions Lift far right grill grate by placing spatula blade under the grill lifting wire to expose the smoker box a Fill box with chips and replace grate Use the right burner on low temperature to smoke wood chips INTENANCE ALWAYS COVER FUEL INLET WITH DUST CAP TO PREVENT OBSTRUCTION FROM DEBRIS OR SPIDER WEBS WHEN NOT IN USE A WORD ABOUT STAINLESS STEEL Stainless steel exposed to high heat for prolonged periods will change in color and texture The radiant plates and other internal parts used to distribute heat evenly across the grill do so by deflecting high heat over a large surface area This pro longed exposure to high temperature will cause the plates to change color This bluing and later browning is normal and will not affect the product operation Exterior Stainless Steel Components We recommend that you clean grill after each use Use soapy water with a soft cloth or sponge Rinse with fresh water and dry We also recommend that you cover the grill between uses Optional covers are available from your retailer or directly from Magma Interior Stainless Steel Components We recommend cleaning after each use Oven Grill Cleaner is recommended to remove burnt on residue Igniter Electrode The igniter electrode located j
7. t even with match No gas flow Obstructed gas flow debris or spider webs in burner tube Check fuel level refill cylinder or replace canister Clean valve orifice and burner check all lines see page 6 Flare up Excessive cooking temperature Grease and or residue build up Excessive fat in meats Excessive oils in marinades Operate only on low when lid is closed Reduce flame level Leave lid open Turn off one burner Use water spray to cool Clean components Trim fat from cuts of meat before grilling Use non oil based marinades Yellow sooty flame Obstructed gas flow debris or spider webs in burner tube Check and clean valve orifice and burner Check gas supply lines see page 6 LIMITED WARR TY Magma Products Inc guarantees the Avalon gas grill to be free from defects in materials or workmanship to the original consumer This guarantee is for the periods herein specified when used under normal and reasonable conditions one I year from the date of original purchase This warranty does not include the cost of property damage or any inconvenience due to the failure of the product Nor does it cover damage due to misuse abuse accident or damage resulting from transportation of the product Nor does it include damage resulting from the commercial use of this product If the product fails to operate due to a defect in materials or workmanship during the warranty period the defective
8. ust beside the burner should be kept clean of all grease and debris Wipe it clean with a soft cloth Care should be taken not to damage the ceramic insulation spark electrode or bend the electrode wire during this process Grill Grates We recommend that you clean the grill grates with a brass wire brush while the grill is warm They can then be washed by hand as required Oven Grill Cleaner is recommended to remove burnt on residue Control Valves The valves were adjusted set and tested at the factory You should not attempt to adjust the valves Call MAGMA if you suspect that your valve is not properly adjust ed Removal and Cleaning the Burner Tubes 1 Lift burner out 2 Rotate burner 3 Lift and pull 4 Remove of bracket Inspect burners remove debris or spider webs Inspect valve oriface while burner is removed clean if needed To re install reverse the removal procedure above be sure brass orifice is centered in burner tube 6 TROUBLE SHOOTING GUIDE Problem Burner will not light with igniter Possible Cause Igniter electrode covered with grease or residue Igniter electrode too far from burner Igniter electrode wire loose or disconnected Wire is shorted causing spark from wire before electrode No spark being generated Possible Solution Clean igniter electrode Adjust electrode until proper spark appears see page 5 Call Magma Call Magma Call Magma Burner will not ligh
Download Pdf Manuals
Related Search