Premier Mounts PP-FCTA-QL
Contents
1. PP FCTA QL Cable Output Cable Input Release Pin 146 Braided Cable Release Pin Mounting Hole 146 Braided Cable Release Pin Mounting Hole Page 10 Visit the Premier Mounts website at http Avww mounts com Installation Instructions PP FCTA QL 24 1he Braided Cable Release Pin Mounting Hole he Braided Cable Release Pin Mounting Hole Installation Instructions Visit the Premier Mounts website at http Avww mounts com Page 11 gt 4 24 PP FCTA QL Ne To relieve tension on the s braided cable slide the release pin on the Quick Lock 1 Adjust the t46 braided cable tension and placement so that the cable forms a 15 angle away from the corner of the ceiling plate Ne Do not overtighten the cable tension 2 When adjusting the tension of the weight bearing side of the Quick Lock the 1 6 braided cable must be pulled through the Quick Lock until the desired tension is attained 3 Once attained pull the 1 6 braided cable through the other side of the Quick Lock 4 Once the tension has been adjusted be sure that there is a minimum of 6 of excess t s braided cable on the non weight bearing side of the Quick Lock 5 Use cable cutters to remove any remaining s braided cable optional Proceed to the Securing 1 72 NPT section 1h Braided Cable To Ceiling Attachment Excess 1e2. Page 14 Visit the Premier Mounts website at http www mounts com Installation Instructions PP FCTA QL 24 Warranty PREMIER MOUNTS LIMITED LIFETIME WARRANTY What and Who is Covered by this Limited Warranty and for How Long Premier Mounts warrants this product to be free from defects in material and workmanship for the lifetime of the original owner of this product The limited warranty is valid only for the original purchaser of the product What Premier Mounts Will Do At the sole option of Premier Mounts Premier Mounts will repair or replace any product or product part that is defective If Premier Mounts chooses to replace a defective product or part a replacement product or part will be shipped to you at no charge but you must pay any labor costs What is Not Covered Limitations PREMIER MOUNTS DISCLAIMS ANY LIABILITY FOR DAMAGE TO MOUNTS ADAPTERS DISPLAYS PROJECTORS OTHER PROPERTY OR PERSONAL INJURY RESULTING IN WHOLE OR IN PART FROM IMPROPER INSTALLATION MODIFICATION USE OR MISUSE OF ITS PRODUCTS PREMIER MOUNTS DISCLAIMS ALL OTHER WARRANTIES EXPRESS OR IMPLIED INCLUDING WARRANTIES OF MERCHANTABILITY AND FITNESS FOR A PARTICULAR PURPOSE PREMIER MOUNTS IS NOT RESPONSIBLE FOR INCIDENTAL OR CONSEQUENTIAL DAMAGES INCLUDING BUT NOT LIMITED TO INABILITY TO USE ITS PRODUCTS OR LABOR COSTS FOR REMOVING AND REPLACING DEFECTIVE PRODUCTS OR PARTS SOME STATES DO NOT ALLOW THE EXCLUSION OR LIMITATION OF INCIDENTAL OR CONSEQ
3. Braided Cable Quick Lock T Bar Frame Ceiling Tile Page 12 Visit the Premier Mounts website at http Avww mounts com Installation Instructions PP FCTA QL 24 Securing 1 1 2 NPT to the PP FCTA QL Secure the 1 72 NPT pipe to the ceiling plate and tighten by using one 1 M5 x 16mm combo head screw to the plate The M5 x 16mm combo head screw must be used to stabilize the 1 2 NPT pipe M5 x 16mm Screw 1 2 Pipe Ceiling Plate Assembly Tiles T Bar Frame Rails Camera Screw Installation optional A Make sure the camera supports one 1 1 4 20 screw 1 Determine which screw hole on the upper adapter plate you will use to attach the camera 2 Insert one 1 1 4 20 x 2 3 4 pan Phillips head screw commercially available through one 1 wing nut commercially available and the desired screw hole The screw should go through both the upper and lower adapter plates It will later be used to mount the camera A Do not overtighten the mounting screw 1 4 20 x 2 3 4 combo head screw commercially available pe Y lt _ Jam nut commercially available 1 4 20 camera screw holes ae Ko ot 1 4 20 threaded insert on e lt camera Installation Instructions Visit the Premier Mounts website at http www mounts com Page 13 gt 4 22 PP FCTA QL Technical Specifications All measurements are in inches
4. on 6 Ceiling Tile Hole Cutter Drill Mounting Hole Escutcheon Ring Escutcheon Ring Hand The escutcheon ring has been designed for use with 1 and 2 NPT Installation Instructions Visit the Premier Mounts website at http Avww mounts com Page 5 Pre set four 4 M5 x 16mm combo screws on the ceiling plate assembly two on each end of the plate Remove any of the 24 x 24 or 24 x 48 tiles that are surrounding the marked tile Measure 3 from the edge of the t bar frame to the inside of the tile do this for all four edges of the ceiling tile The mounting hole should be located in the center most location of the ceiling tile Once the mounting hole has been cut place the ceiling plate assembly on the t bar rails Proceed to Securing the Ceiling Plate section Page 6 1 4 20 camera screw holes PP FCTA QL M5 x 16mm Screws Ceiling Plate Assembly Upper Adapter Plate LA Mounting Hole N T Bar Frame Ceiling Tile Visit the Premier Mounts website at http www mounts com Installation Instructions PP FCTA QL Securing the Ceiling Plate Once the ceiling plate assembly is resting on the t bar frame rails use a screwdriver to tighten the four 4 M5 x 16mm combo screws Slide the upper plate assembly over the hole that was cut in the tile and center it over the hole Tighten all four 4 jam nuts A Do not overtighten the mounting screws Pro
5. TIMES DURING THE ASSEMBLY OF THIS PRODUCT USE STOP PROPER SAFETY EQUIPMENT AND TOOLS FOR THE ASSEMBLY PROCEDURE TO PREVENT PERSONAL INJURY PREMIER MOUNTS DOES NOT WARRANT AGAINST DAMAGE CAUSED BY THE USE OF ANY PREMIER MOUNTS PRODUCT FOR PURPOSES OTHER THAN THOSE FOR WHICH IT WAS DESIGNED OR DAMAGE CAUSED BY UNAUTHORIZED ATTACHMENTS OR MODIFICATIONS AND IS NOT RESPONSIBLE FOR ANY DAMAGES CLAIMS DEMANDS SUITS ACTIONS OR CAUSES OF ACTION OF WHATEVER KIND RESULTING FROM ARISING OUT OF OR IN ANY MANNER RELATING TO ANY SUCH USE ATTACHMENTS OR MODIFICATIONS At least two qualified people should perform the assembly procedure Personal injury and or property damage can result from dropping or mishandling the projector This product is intended for indoor use only Use of this product outdoors could lead to product failure and or serious personal injury Do not install near sources of high heat Do not install on a structure that is prone to vibration movement or chance of impact Contact Premier Mounts with any questions 800 368 9700 techsupport mounts com Page 2 Visit the Premier Mounts website at http Avww mounts com Installation Instructions gt a PP FCTA QL 24 Installation Tools The following tools may be required dependent upon your particular installation These tools are not provided by Premier Mounts but you can purchase them at your local hardware store Ladder ay Hand Held Drill Pencil Protective Eyewear Phil
6. 10 Concrete Ceiling Determine the mounting location Use a 4 concrete drill bit to pre drill the mounting holes Place the concrete anchor into the pre drilled hole and gently tap into place using a rubber mallet or hammer Run the open end of the ths braided cable through the hole in the eye anchor bolt Run the open end through the loop Pull the open end down until the braided cable tightens around the eye anchor bolt Repeat through for the remaining three mounting points Proceed to the Quick Lock Installation on page 10 Page 8 Visit the Premier Mounts website at http Awww mounts com Installation Instructions PP FCTA QL 24 Truss Ceiling Ceiling Truss Loop the braided cable around the truss Run the open end of the 14 braided cable through the hole in the loop Pull the open end down until the 146 braided cable tightens around the truss Repeat through for the remaining three mounting points Proceed to the Quick Lock Installation section on page 10 Installation Instructions Visit the Premier Mounts website at http www mounts com Page 9 gt 4 22 Quick Lock Installation Feed the 4 braided cable into the Quick Lock see directional input arrows To release the s braided cable slide the release pin to disengage Please follow the steps below in numerical order and to correctly install the Quick Lock Cable Kit
7. UENTIAL DAMAGES SO THE ABOVE LIMITATION OR EXCLUSION MAY NOT APPLY TO YOU What Customers Must Do for Limited Warranty Service If you discover a problem that you think may be covered by the warranty you MUST REPORT it in writing to the address below within thirty 30 days Proof of purchase an original sales receipt from the original consumer purchaser must accompany all warranty claims Warranty claims must also include a description of the problem the purchaser s name address and telephone number General inquiries can be addressed to Premier Mounts Customer Service at 1 800 368 9700 Warranty claims will not be accepted over the phone or by fax Premier Mounts Attn Warranty Claim 3130 East Miraloma Ave Anaheim CA 92806 How State Law Applies THIS WARRANTY GIVES YOU SPECIFIC LEGAL RIGHTS AND YOU MAY ALSO HAVE OTHER RIGHTS WHICH VARY FROM STATE TO STATE Disclaimer Premier Mounts intends to make this manual accurate and complete However Premier Mounts makes no claim that the information contained herein covers all details conditions or variations nor does it provide for every possible contingency in connection with the installation or use of this product The information contained in this document is subject to change without notice or obligation of any kind Premier Mounts makes no representation of warranty expressed or implied regarding the information contained herein Premier Mounts assumes no responsibility for accura
8. ceed to the Electrical Box Cut out Removal section below Electrical installation should be done in accordance to local codes and regulations Cut the tile where the electrical box is going to be secured Using commercially available hardware depending on electrical installation environment install the electrical box and secure it to the ceiling plate assembly Make all electrical connections at this time Proceed to the Ceiling Attachment section Installation Instructions Electrical Box Cut out Visit the Premier Mounts website at http www mounts com Upper Plate Assembly Upper Plate Assembly T Bar Frame Rails Tiles Commercially Available Page 7 b a 24 PP FCTA QL Ceiling Attachment Wood Stud ii The PP FCTA QL must be secured using the Quick W Locks and ie braided cables supplied Anchoring eye bolts are commercially available Ne Wood Stud Ceiling Determine the mounting location Eye Lag Bolt Use a 1 8 drill bit to pre drill the mounting holes Secure the four 4 74 eye lag screws to the wood stud in the ceiling Run the open end of the t46 braided cable through the hole in the eye lag screw Run the open end through the loop Pull the open end down until the 14 braided cable tightens around the eye lag screw Repeat through for the remaining three mounting points Proceed to the Quick Lock Installation on page
9. cy completeness or sufficiency of the information contained in this document Disclaimer NORTH AMERICA EUROPE 3130 East Miraloma Avenue Unit 3 The Moorings Business Park a BA USA Channel Way Longford and Canada USA and Canada Coventry CV6 6RH UK Phone 1200 3003700 Phone 44 0 24 7664 4105 Fax 1 800 832 4888 Other Locations Fax 44 0 24 7664 4165 Phone 001 714 632 7100 Fax 001 714 632 1044 Premier Mounts 2011 Installation Instructions Visit the Premier Mounts website at http www mounts com Page 15
10. ea aeaa a ehai Taai aiaa 7 Electrical Box Cut out Rem val asinn aaa TAN E a TAR 7 Ceiling Attachment serinin na a aai dk aaa aeaa a NA aaa aad aaa ari aaa Sa aaea aiaeei 8 Quick Lock InStallatiOn osne E E E R E E N i 10 Securing 1 12 NPT to the PP FCTA QL cccceccceeeee eeneee eee te cents eee eeneeeeeeeeceeeeeeeseneeeeeeeseeeeeeeeseeeeeeeesenaaeeeseeeaeeeeseenaaees 13 Securing the Camera Optlomal isscesscnsieeciiG nn aaraa a A NA ETE N aaaes ae AEEA 13 Technical Specifications escrir rodiedin oan aaia aniria aaraa iaaea iaaa aa aare aa ea a aai a A E aae EE EE EErEE 14 War ANY sacicee ceca cvadiessdeesawbed aus a anar e a a a aa aae iee iaa aa aaa saaa ia randia 15 DISGCIANMMEN sesend a a a a ae rea Eana aa a Ea AAEE Aaaa a aa aa AA Aaa EE EAA aa 15 Weight Limit THE CEILING STRUCTURE MUST BE CAPABLE OF SUPPORTING AT LEAST FIVE TIMES THE WEIGHT OF Manimuni Projector Weight 5O bs i THE PROJECTOR IF NOT THE CEILING STRUCTURE MUST BE REINFORCED Warning Statements PRIOR TO THE INSTALLATION OF THIS PRODUCT THE INSTALLATION INSTRUCTIONS MUST BE READ AND COMPLETELY UNDERSTOOD KEEP THESE INSTALLATION INSTRUCTIONS IN AN EASILY ACCESSIBLE LOCATION FOR FUTURE REFERENCE PROPER INSTALLATION PROCEDURE BY A QUALIFIED SERVICE TECHNICIAN MUST BE FOLLOWED AS OUTLINED STOP IN THESE INSTALLATION INSTRUCTIONS FAILURE TO DO SO COULD RESULT IN PROPERTY DAMAGE SERIOUS PERSONAL INJURY OR EVEN DEATH SAFETY MEASURES MUST BE PRACTICED AT ALL
11. lips Tip Screwdriver 1 8 Drill Bit 1 4 Concrete Drill Bit Parts List Your Premier Mounts product is shipped with all proper installation hardware and components Make sure that none of these parts are missing and or damaged before beginning the installation If there are parts missing and or damaged please stop the installation and contact Premier Mounts at 800 368 9700 PP FCTA QL Mount Hardware Main Ceiling Plate Ya x 3 Eye Lag Screws M6 x 2 4 Eye Lag Anchors Qty 4 Qty 4 Qty 1 Quick Lock Cable Kit Escutcheon Ring Quick Locks The x 25 Braided Cable Qty 1 Qty 4 Qty 4 Strands Installation Instructions Visit the Premier Mounts website at http Avww mounts com Page 3 gt 4 24 PP FCTA QL Features Adjustability Up to 9 of lateral shift Variety Fits all 1 NPT pipe Camera Screw Hole Use a 1 4 20 screw to mount a camera alongside the projector Electrical Access Knockouts for electrical or signal Includes the Quick Lock Cable Kit junction boxes l Escutcheon Ring with integrated hole saw Introduction Please read these installation instructions once thoroughly before attempting to install your Premier Mounts product Please take a minute to familiarize yourself with the contents of the package and make sure you have all the parts and tools you need to safely complete the installation In addition some steps of this installation
12. may require two people to prevent personal injury and or damage to your projector Please observe all warnings in the following installation procedure and utilize proper safety equipment at all times Page 4 Visit the Premier Mounts website at http www mounts com Installation Instructions 4 PP FCTA QL 24 Cutting the Access Hole Observe the room and the ceiling find the most diy appropriate location for the projector placement and lightly mark the bottom of the tile Separate the escutcheon ring and the hole saw Attach the hole saw to a hand held drill If no drill is available you may turn by hand Determine where the hole will be and mark this location with a pencil A Place the hole saw over the spot where the mark was made B Carefully depress the trigger on the hand held drill and begin to drill the hole being careful not to damage the ceiling tile B Once complete place the drill off to the side and pick Hole Saw Escutcheon Ring up the escutcheon ring Line the escutcheon ring up with the drilled hole in the ceiling tile C Insert the escutcheon ring into the hole and gently push it into place D You may need to pinch the escutcheon ring into place This can be done by taking your index finger and placing it up into the mounting hole and pressing down from the top Your thumb will press up from the bottom effectively pinching the escutcheon ring into place Proceed to the Mounting the PP FCTA QL
13. wD PREMIER Cag MOUNTS CREATING POSITIVE CUSTOMER EXPERIENCES INSTALLATION INSTRUCTIONS PP FCTA QL Suspended Ceiling Adapter NORTH AMERICA EUROPE w aaioin GA ene Gk Unit 3 The Moorings Business Park USA and Canada Channel Way Longford 7 Conventry CV6 6RH Phone 800 368 9700 Fax 800 832 4888 Phone 44 0 2476 644105 Other Locations Fax 44 0 2476 644165 Phone 001 714 632 7100 Fax 001 714 632 1044 9533 030 001 08 gt 4 E PP FCTA QL Weight MTA cia eaen tag savraaten cia pacer hs auate Yoo setarcnwe di sea vain ad ease tec sa SA War aaeuaceck paatcantengaaaua E sayowetunt pasuconase gan aue Uatagqunwteappenauteaens 2 Warning Statements ss2esiasi05 visceaccasidehanc dias caazacydanvaeraiisee siecayazsaties OAA AA NTE a Aaea INE aden 2 Installation TOMS ja g ca tee ccy essetun tna weer ataaie dis eae a a eas shay duds tan tye an baea a aa a vagy deayaaaeads abhded disease de 3 PANS Listessa a e a e aiaa ideae Adana a en a siete ndeduadesavenseiiasdveceneduayeedvaaitees 3 ET UAE EE TE EN EA sites E ET NAET E E EATA EE 4 PP FCTA QL Installations nsien reana a wn ea va eae eee dda vv vag A a awe aa wea deed va edie edd caves 5 Cutting the Access Hole c cc cccccceceeeeeeeeeeeeeaeeaeneeceee eee aiani aaia anaa a a daa aaa iaaa iaaa daaa dia 5 Mounting the PP FCTA Q rcii E E O A NEEE TEE EE E O t 6 Securing the Ceiling Plate sicer ipararanas ia aaa aaa aaa a A aa aA aa aaa aaan aa aa
Download Pdf Manuals
Related Search