Baumatic CAN52.2ME cooker hood
Contents
1. Instruction manual User Manual for your Baumatic CAN52 2ME Canopy cooker hood ae Baumatic You will be mine NOTE This User Instruction Manual contains important information including safety amp installation points which will enable you to get the most out of your appliance Please keep it in a safe place so that it is easily available for future reference for you or any person not familiar with the operation of the appliance DD 24 09 07 Contents Contents Environmental note Alternative Methods Of Extraction Installation Ducted Out Installation Recirculating Operating Your Extractor Care amp Cleaning Electrical Connections Not Working Properly 10 Contact details CHOIAAMRWNeE This appliance complies with all relevant legal safety requirements Inappropriate use can however lead to personal injury and damage to property To avoid the risk of accidents and damage to the appliance please read these instructions carefully before using it for the first time They contain important information on the safety installation use and maintenance of the appliance Keep these operating instructions in a safe place and ensure that all users are familiar with the contents Pass them on to any future owner of the appliance Environmental note This appliance is marked according to the European directive 2002 96 EC on Waste electrical and Electronic Equipment WEEE2. Once the above has been completed the extractor should be introduced into the aperture ensuring the two flexible clips support the canopy on either side When the extractor is in position it is important to secure the extractor to the canopy by the use of four screws not provided through the four pre drilled holes in the extractor flange two front and two rear 2 The Re circulation Mode fig 2 When there is no easy access to an outside wall the extractor can easily be adapted to clean air polluted by cooking smells by the use of a charcoal filter This can be purchased from the Baumatic Spares Department under reference CFM1 Remember that the appliance cannot be used in re circulation mode without the use of a charcoal filter The Charcoal Filter Filters do have a limited life We advise you to change them when there is a noticeable drop in performance The intervals between changing the filters will depend entirely upon the amount of cooking you do but on average they will last about 6 months To fit the new filter remove the fascia grill by pressing down the two clips towards the face of the grill it will disengage Then simply locate the charcoal filter on the two lugs on the motor and turn in an clockwise direction To remove the charcoal filter repeat the process but in an anti clockwise direction The Grease Filter The grease filter is made of a metallic material and can be cleaned in hot soapy water It is important
3. prevent the oil from catching fire and never leave the hob unattended General Cleaning Always switch off the electricity supply prior to cleaning Wipe the external surfaces of the extractor regularly using warm water and mild detergent Never use abrasives or wire wool since these will damage the appliance Changing The Light Bulb Always switch off the electricity supply prior to changing the bulb To replace a bulb simply remove the fascia grille unscrew the bulb and replace with one of an identical wattage Replace the facia grille Electrical Connections IMPORTANT ENSURE THAT THE ELECTRICITY SUPPLY IS SWITCHED OFF BEFORE CONNECTING Your appliance must be connected to fixed wiring via the use of a double pole switched fused spur outlet with at least 3mm contact separation and preferably with a pilot lamp The fuse must have a 3 amp fuse rating We strongly recommend the appliance is connected by a qualified electrician who is a member of the N I C E LC or CORGI This will ensure that the I E E wiring regulations and any local regulations are complied with NOTE The terminology DOUBLE POLE means that both the live and neutral supplies are switched and disconnected at the same time The terminations labelled SUPPLY are for the connection for the internal house wiring and the terminations labelled LOAD are for the connection of the appliance Important The wires in the mains lead are coloured in accordance with the fol
4. to clean the grease filter on a regular basis To remove the filter mat simply remove the facia grille and then unclip the two wire retainers which hold the filter mat in place Clean the filter and then replace securing with wire retainers IMPORTANT You should never attempt to use the extractor without the grease filter since a grease build up could prevent the motor working properly and create a fire hazard If the filter is not cleaned regularly the risk of fire will be increased Always switch off the electricity supply before cleaning or changing the filters Operating Your Extractor The light can be switched on or off regardless of fan motor operation to illuminate the cooking area The extractor fan has three speed settings for light medium or heavy extraction of cooking vapours The different levels of extraction are numbered I II amp II and can also be recognised by the changes in noise level of the extractor fan when operating For Your Safety In order to protect your appliance and minimise the risk of fire don t barbecue food directly under the extractor Similarly do not prepare flamb dishes immediately under the extractor If you use a gas hob don t remove pots without first turning off the flame Your extractor is designed to draw gases up and away from your hob This means that exposed flames may behave unpredictably in the vicinity of the appliance whilst it is switched on When frying take particular care to
5. By ensuring this product is disposed of correctly you will help prevent potential negative consequences for the environment and human health which could otherwise be caused by inappropriate waste handling of this product bow J The symbol aia on the product or on the documents accompanying the product indicates that this appliance may not be treated as household waste Instead it shall be handed over to the applicable collection point for the recycling of electrical and electronic equipment Disposal must be carried out in accordance with local environmental regulations for waste disposal For more detailed information about treatment recovery and recycling of this product please contact your local city office your household waste disposal service or the shop where you purchased the product O The packaging materials that Baumatic uses are environmentally friendly and can be recycled o Please discard all packaging material with due regard for the environment Alternative Methods Of Extraction THESE INSTRUCTIONS MUST BE STRICTLY ADHERED TO FAILURE TO COMPLY COULD RESULT IN OVERHEATING AND SERIOUS DAMAGE TO YOUR APPLIANCE 1 Extraction Via Ducting The very best method of cleaning the kitchen of unwanted odours is by connecting the appliance to an exhaust duct that vents to the outside atmosphere via an exterior wall Suitable 125 mm diameter ducting kits may be purchased from the Baumatic Spares Department Ducting your
6. extractor means that your appliance does not require a charcoal filter Fig 1 DUCTING MODE NO CHARCOAL FILTER REQUIRED REMEMBER Before drilling or chiselling the wall check for pipes and power cables 1 Ensure the ducting hose is kept as short as possible and with the minimum number of bends to permit the smoothest airflow The maximum length is 3 metres with one 90 degree bend each additional 90 degree bend means that the maximum length will reduce by 1 metre 2 The ducting hose must not be bent more than 90 degrees 3 Ducted air must not be discharged into a flue which is used for exhausting fumes from appliances supplied with energy other than electricity 4 Ensure the requirements of the local authorities are adhered to concerning the discharge of exhaust air 5 Ensure adequate room ventilation is provided when the extractor is used in the same room as appliances supplied with energy other than electricity 6 Never duct into a hot air flow such as a central heating duct 7 We strongly advise that all exterior outlets be fitted with a valve or louvred slatting 1 Extraction Via Ducting cont Before you think about fixing it s as well to give careful consideration to the power connection It is vital that the supply cable should be well shielded from your grill hob or oven If it isn t heat from any one of these sources may damage the cable insulation and give rise to a fire risk Unde
7. ings 6 Bennet Road Reading Berkshire RG2 0QX United Kingdom Sales Telephone 0118 933 6900 Sales Fax 0118 931 0035 Service Telephone 0118 933 6911 Service Fax 0118 986 9124 Spares Telephone 01235 437244 Technical Advice Telephone 0118 933 6933 E mail sales baumatic co uk technical baumatic co uk Website www baumatic co uk Republic of Ireland 01 6266 798 Holland Baumatic Benelux B V Grindzuigerstraat 22 1333 MS ALMERE The Netherlands 3136 549 1555 www baumatic nl Czech Republic Baumatic CR spol s r o Amperova 495 46215 Librec Czech Republic 420 800 185 263 www baumatic cz Slovak Republic Baumatic Slovakia s r o Skultetyho 1 831 04 Bratislava 3 Slovakia 421 255 640 618 Germany Baumatic Gmbh J anderstrasse 9 Mannheim 68199 Germany 4962 112 9190 www baumatic de Italy Baumatic Italia S R L Via Caltana 129 Campodarsego Padova 35011 Italy 3904 9920 2297 www baumatic it 11 Baumatic www baumatic com
8. lowing code BLUE NEUTRAL BROWN LIVE As the colours of the wires in the mains lead of this appliance may correspond with the colours markings identifying the terminals in your spur box proceed as follow The wire which is coloured blue must be connected to the terminal which is marked with the letter N or coloured black The wire which is coloured brown must be connected to the terminal which is marked with the letter L or coloured red WARNING This appliance has such technical particulars that it belongs to Class II insulation and therefore neither wire should be connected to the terminal marked with the letter E or by the earth symbol Not Working Properly Before you assume the worst check this simple fault finding guide to get to the root of the problem Light bulb doesn t come on A replacement is probably necessary but check first that the bulb is firmly screwed in to its holder If the filament is broken remember that the light bulbs are not covered by our guarantee Remember to disconnect the power supply to the appliance before removing the bulb Motor is on but fan doesn t seem to be as efficient as usual Check the grease filter mat If it hasn t been cleaned recently it might be clogged with grease If the filter mat is relatively clean check the charcoal filter if the appliance is set for recirculation mode If this hasn t been replaced for more than six months remove and insert a new one As time goes by accumula
9. r no circumstances should the exposed power supply cable come within 70cm of a direct source of heat Ideally it should be channelled into the wall well out of harm s way The extractor is designed to fit into a canopy When installing your extractor above a heat source i e any electrical or gas hob grill cooker etc the fixing height must THAN 70 cm between the hob highest point of the hob top including the burners and the bottom of the extractor The first step is to cut an aperture centrally in the base of the canopy The dimensions of the cutout are illustrated on the next page You should now decide which method of extraction you wish to incorporate i e via an external wall or by using the re circulating method with the use of a charcoal filter see page 7 Ensure prior provisions have been made for the electrical connections see pages 9 10 Before fitting the extractor into the canopy the two support clips one either side should be set to accommodate the thickness of the mounting surface This is achieved by adjusting the clip via the screw to the dimension of the mounting surface as shown above If you have decided to extract via an external wall a ducting kit should be fitted to the extractor prior to installation into the canopy Before assembling the extractor however it may be easier to remove the fascia grill This is achieved by sliding the two clips towards the rear of the appliance and the grill will disengage
10. ted grease will stop the charcoal filter from operating correctly This will reduce the efficiency of both the fan and the filter itself Works normally but cooking smells linger If you re using the unit in re circulation mode change the charcoal filter It is obviously past its prime Controls fail to switch motor on Check the plug socket and fuses If these are in order and fault persists it could be that an accumulation of grease has impaired the efficiency of the switch mechanism Try rapidly moving switch on and off several times in succession to clear grease deposit If the fault continues call the Baumatic Service Department Appliance does not work at all Check your extractor is switched on at the mains Next check for an unexpected power cut by switching on adjacent lights etc Still not working Call the service agent If having consulted the above diagnostic chart you are still unable to remedy the situation please call the Baumatic Service Department IMPORTANT If your appliance appears not to be operating correctly then you should disconnect it from your mains supply and then contact the Baumatic Technical Department on telephone number 0118 933 6933 DO NOT ATTEMPT TO REPAIR THE APPLIANCE YOURSELF Please refer to the conditions of guarantee that appear on the warranty card that you receive with the appliance 10 lt Jx aumatic You will be mine United Kingdom Baumatic Ltd Baumatic Build
Download Pdf Manuals
Related Search