Homelite UT08520 Blower User Manual
Contents
1. H To reduce the risk of hearing loss associated with sound H Do not point the blower nozzle in the direction of people level s hearing protection is required or pets H To reduce the risk of injury associated with contacting H Never run the unit without the proper equipment attached rotating parts stop the engine before installing or Page 3 Always ensure the blower tubes are installed SYMBOLS Some of the following symbols may be used on this product Please study them and learn their meaning Proper interpretation of these symbols will allow you to operate the product better and safer SYMBOL NAME DESIGNATION EXPLANATION Safety Alert Precautions that involve your safety To reduce the risk of injury user must read and understand operator s manual before using this product oO Eye and Hearing Protection Wear eye and hearing protection when operating this equipment Read The Operator s Manual A ee Failure to keep long hair away from the air inlet could result in Long Hair a personal injury Blower Tubes Do not operate without tubes in place Loose Clothing Failure to keep loose clothing from being drawn into air intake could result in personal injury Use unleaded gasoline intended for motor vehicle use with an Gasoline and Lubricant octane rating of 87 R M 2 or higher This product is powered by a 2 cycle engine and requires pre mixing gasoline and 2 cycle lubricant Page 4 SYMBOLS The followi2. SOME STATES DO NOT ALLOW LIMITATIONS ON HOW LONG AN IMPLIED WARRANTY LASTS SO THE ABOVE LIMITATION MAY NOT APPLY TO YOU HOMELITE ASSUMES NO RESPONSIBILITY FOR INCIDENTAL CONSEQUENTIAL OR OTHER DAMAGES INCLUDING BUT NOT LIMITED TO EXPENSE OF RETURNING THE PRODUCT TO AN AUTHORIZED HOMELITE SERVICE CENTER AND EXPENSE OF DELIVERING IT BACK TO THE OWNER MECHANIC S TRAVEL TIME TELEPHONE OR TELEGRAM CHARGES RENTAL OF A LIKE PRODUCT DURING THE TIME WARRANTY SERVICE IS BEING PERFORMED TRAVEL LOSS OR DAMAGE TO PERSONAL PROPERTY LOSS OF REVENUE LOSS OF USE OF THE PRODUCT LOSS OF TIME OR INCONVENIENCE SOME STATES DO NOT ALLOW THE EXCLUSION OR LIMITATION OF INCIDENTAL OR CONSEQUENTIAL DAMAGES SO THE ABOVE LIMITATION OR EXCLUSION MAY NOT APPLY TO YOU This warranty gives you specific legal rights and you may also have other rights which vary from state to state This warranty applies to all HOMELITE brand products manufactured by or for Homelite and sold in the United States and Canada To locate your nearest Homelite authorized service center dial 1 800 242 4672 or log on to our website at www homelite com Page 15 WARRANTY THE FOLLOWING CALIFORNIA AIR RESOURCES BOARD CARB STATEMENT ONLY APPLIES TO MODEL NUMBERS REQUIRED TO MEET THE CARB REQUIREMENTS HOMELITE CONSUMER PRODUCTS INC LIMITED WARRANTY STATEMENT FOR FEDERAL AND CALIFORNIA EMISSION CONTROL SYSTEMS NON ROAD AND SMALL OFF ROAD ENGINES YOUR WARRANTY RIG
3. We recommend Wide Vision Safety Mask for use over eyeglasses or standard safety glasses with side shields Always use eye protection which is marked to comply with ANSI Z87 1 SAVE THESE INSTRUCTIONS Page 5 FEATURES PRODUCT SPECIFICATIONS 7 9 Ibs WIG ME kenna saat a a ela 26cc Engine displacement acer E R R E S Air Velocity 170 375 g Ll LUI l O o Q LUI pr o cc T BIN NAN me INA o PRIMER BULB Nean N STARTER GRIP CHOKE DIAL BLOWER TUBE Page 6 FEATURES KNOW YOUR BLOWER See Figure 1 The safe use of this product requires an understanding of the information on the tool and in this operator s manual as well as a knowledge of the project you are attempting Before use of this product familiarize yourself with all operating features and safety rules ROTOCHOKE ZIP START The rotochoke zip start allows for easier and quicker starting ASSEMBLY UNPACKING This product requires assembly Carefully remove the product and any accessories from the box Make sure that all items listed in the packing list are included Inspect the product carefully to make sure no breakage or damage occurred during shipping Do not discard the packing material until you have carefully inspected and satisfactorily operated the product If any parts are damaged or missing please call 1 800 242 4672 for assistance PACKING LIST Blowe
4. for presenting your non road or small off road engine to an authorized service dealer as soon as a problem exists The warranty repairs should be completed in a reasonable amount of time not to exceed 30 days If you have any questions regarding your warranty rights and responsibilities you should contact a Homelite Consumer Products Inc Customer Representative at 1 800 242 4672 DEFECT WARRANTY COVERAGE REQUIREMENTS a The warranty period begins on the date the engine or equipment is delivered to an ultimate purchaser b General Emissions Warranty Coverage Homelite Consumer Products Inc war rants to the ultimate purchaser and each subsequent purchaser that your non road or small off road engine is designed built and equipped at the time of sale to conform with all applicable regulations adopted by the California Air Resources Board or the United States Environmental Protection Agency and that it is free from defects in materials and workmanship which cause the engine to fail to conform with applicable regulations for a period of two years from the date the non road or small off road engine is purchased by the initial purchaser c The warranty on emissions related parts will be interpreted as follows Any warranted part that is not scheduled for replacement as required in the Emissions Maintenance Schedule and Warranty Parts List set forth below is warranted for two years If any such part including any part that is scheduled
5. only for regular inspec tion fails during the period of warranty coverage it will be repaired or replaced at any HOMELITE Authorized Service Center at no charge Any such part repaired or replaced under warranty will be warranted for the remaining warranty period A statement to the effect of repair or replace as necessary would not reduce the period of warranty coverage Any warranted part that is scheduled for replacement as required maintenance in the Emissions Maintenance Schedule and Warranty Parts List is warranted for the period of time prior to the first scheduled replacement point for that part Any such part repaired or replaced under warranty is warranted for the remainder of the period prior to the first scheduled replacement point and will be repaired or replaced at any HOMELITE Authorized Service Center for no charge until that replacement point is reached Homelite Consumer Products Inc shall remedy warranty defects at any authorized HOMELITE Authorized Service Center including any distribution center that may be franchised to service the subject engines Any diagnostic work done at a HOMELITE Authorized Service Center shall be free of charge to the owner if such work determines that a warranted part is defective Any manufacturer approved or equivalent replace ment part may be used for any warranty maintenance or repairs on emission related parts and must be provided free of charge to the owner if the part is still
6. ERATION A WARNING Do not allow familiarity with product to make you careless Remember that a careless fraction of a second is sufficient to inflict serious injury A WARNING Always wear safety goggles or safety glasses with side shields when operating this tool Failure to do so could result in objects being thrown into your eyes resulting in possible serious injury APPLICATIONS You may use this product for the purposes listed below E Clearing leaves and other debris from your lawn E Keeping decks and driveways free from grass clippings leaves pine needles and other debris FUELING AND REFUELING FUEL MIXTURE This product is powered by a 2 cycle engine and requires pre mixing gasoline and 2 cycle lubricant Pre mix unleaded gasoline and 2 cycle engine lubricant in a clean 1 gallon container approved for gasoline Recommended fuel This engine is certified to operate on unleaded gasoline intended for automotive use Mix Homelite Premium Exact Mix lubricant with gasoline according to the instructions on the package If Premium Exact Mix lubricant is not available use a high quality synthetic 2 cycle engine lubricant mixed at 2 6 oz per gallon US Do not use automotive lubricant or 2 cycle outboard lubricant NOTE Premium Exact Mix fuel mix will stay fresh up to 30 days DO NOT mix quantities larger than usable in a 30 day period PREMIUM EXACT MIX 50 1 GASOLINE LUBRICANT 2 6 Oz 20cc 20 ml 1 gal
7. HTS AND OBLIGATIONS The U S Environmental Protection Agency EPA the California Air Resources Board CARB and Homelite Consumer Products Inc are pleased to explain the Emissions Control System Warranty on your 2007 model year non road or small off road engine In California new equipment that uses small off road engines must be designed built and equipped to meet the state s stringent anti smog standards In other states new 2000 and later model year non road engines must be designed built and equipped at the time of sale to meet the U S EPA regulations for small non road engines The non road engine must be free from defects in materials and workmanship which cause it to fail to conform with U S EPA standards for the first two years of engine use from the date of sale to the ultimate purchaser Homelite Consumer Products Inc must warrant the emission control system on your non road or small off road engine for the period of time listed above provided there has been no abuse neglect or improper maintenance of your non road or small off road engine Your emission control system may include parts such as the carburetor or fuel injection system the ignition system catalytic converters fuel tanks valves filters clamps connectors and other associated components Also included may be hoses belts and connectors and other emission related assemblies Where a warrantable condition exists Homelite Consumer Products Inc will r
8. J6Y or equivalent spark plug with 025 in electrode gap Use an exact replacement and replace annually or more frequently if necessary A WARNING Be careful not to cross thread the spark plug Crossthreading will seriously damage the product CLEANING THE EXHAUST PORT AND MUFFLER Depending on the type of fuel used the type and amount of lubricant used and or your operating conditions the exhaust port and muffler may become blocked with carbon deposits If you notice a power loss with your gas powered tool you may need to remove these deposits to restore performance We highly recommended that only qualified service technicians perform this service SPARK ARRESTOR The spark arrestor must be cleaned or replaced every 25 hours or yearly to ensure proper performance of the product Spark arrestors may be in different locations depending on the model purchased Please contact the nearest service dealer for servicing your spark arrestor A WARNING Never run the blower without the spark arrestor in place Failure to do so could result in a fire that could cause serious personal injury FUEL CAP A WARNING A leaking fuel cap is a fire hazard and must be replaced immediately Failure to do so could result in a fire that could cause serious personal injury The fuel cap contains a non serviceable filter and a check valve Aclogged fuel filter will cause poor engine performance If performance improves when the f
9. NTENANCE SCHEDULE AND WARRANTED PARTS LIST Emissions Parts Inspect Before Clean Every Replace Clean Every Replace Every Each Use 5 Hours Every 25 Hours 25 Hours 50 Hours or Yearly or Yearly CATALYTIC MUFFLER ASSEMBLY AIR FILTER ASSY includes Filter SPARK SCREEN FUEL TANK ASSY includes Fuel Lines Fuel Cap IGNITION ASSY includes Spark Plug ALL EMISSIONS RELATED PARTS ARE WARRANTED FOR TWO YEARS OR FOR THE PERIOD OF TIME PRIOR TO THE PARTS FIRST SCHEDULED REPLACEMENT WHICHEVER COMES FIRST MAKE THE MOST OF YOUR PURCHASE Go to www homelite com and register your new tool on line Your product has been fully tested prior to shipment to ensure your complete satisfaction For any questions about operating or maintaining your product call the Homelite Help Line To register your Homelite product or set up your eBox account by regular mail please print the following infor mation on a 3 in x 5 in card or standard postcard your name mailing address phone numbers email address Homelite product s purchased with item number from package and serial number for each product Mail the card to Homelite Consumer Products Attn Homelite Registration 1428 Pearman Dairy Road Anderson SC 29625 To receive information on our company and products please include the following statement on your registration card Send me information on your products and company using the contact information am providing with this product registrat
10. OPERATOR S MANUAL 26cc MightyLite Blower UT08520 UT08921 ALL VERSIONS Your blower has been engineered and manufactured to Homelite s high standard for dependability ease of operation and operator safety When properly cared for it will give you years of rugged trouble free performance Thank you for buying a Homelite product SAVE THIS MANUAL FOR FUTURE REFERENCE TABLE OF CONTENTS Danie aiie i a i PEE T E E E E T ERTO T E tutes ces SR 2 General Safety Rules teach RR 3 Specific Safety RUS usando 3 Symbols Sai iaia alia i iii iii i FA 4 5 Features cenare 6 7 ASSEMDIY aurea iaia oi 7 8 Operallons agisci ii 9 11 Mantenance aiuole ale aiar 12 13 Troubleshootingi i i a rari ige nia ER A ei ici 14 Warraniy Gsssaza iii ina a ei iii il se ei ii ile 15 17 Parts Ordering Service calare Back Page INTRODUCTION This product has many features for making its use more pleasant and enjoyable Safety performance and dependability have been given top priority in the design of this product making it easy to maintain and operate Page 2 GENERAL SAFETY RULES H Never operate the unit without a spark arrestor screen this screen is located inside the muffler H Product users on United States Forest Service land and in some states must comply with fire prevention regulations This product is equipped with a spark A WARNING READ AND UNDERSTAND ALL INSTRUCTIONS Failure to follow all instructions listed
11. below may result in electric shock fire and or serious personal injury SAVE THESE INSTRUCTIONS Do not allow children or untrained individuals to use this unit Never start or run the engine inside a closed area breathing exhaust fumes can kill Wear eye protection which is marked to comply with ANSI Z87 1 as well as hearing protection when operating this arrestor however other user requirements may apply Check with the federal state or local authorities in your area Before storing allow the engine to cool Empty fuel tank and restrain the unit from moving before transporting in a vehicle To reduce the risk of fire and burn injury handle fuel with care It is highly flammable product H Do not smoke while handling fuel E Keep all bystanders children and pets at least 50 ft Mix and store fuel in a container approved for gasoline away H Mix fuel outdoors where there are no sparks or flames H Wear heavy long pants boots and gloves Do not wear H Select bare ground stop engine and allow to cool before loose fitting clothing short pants jewelry of any kind or refueling g9 baretoor H Loosen fuel cap slowly to release pressure and to keep To reduce the risk of injury associated with objects being drawn into rotating parts do not wear loose clothing scarves neck chains and the like fuel from escaping around the cap Tighten the fuel cap securely after refueling ene H Wipe spilled fuel from the u
12. ces on the date of the original retail purchase Any part of the this product manufactured or supplied by Homelite and found in the reasonable judgment of Homelite to be defective in material or workmanship will be repaired or replaced without charge for parts and labor by a Homelite authorized service center The product including any defective part must be returned to an authorized service dealer within the warranty period The expense of delivering the product to the dealer for warranty work and the expense of returning it back to the owner after repair or replacement will be paid by the owner Homelite s responsibility in respect to claims is limited to making the required repairs or replacements and no claim of breach of warranty shall be cause for cancellation or rescission of the contract of sale of any HOMELITE brand product Proof of purchase will be required by the dealer to substantiate any warranty claim All warranty work must be performed by a Homelite authorized service center This warranty is limited to ninety 90 days from the date of original retail purchase for any HOMELITE brand product that is used for rental or commercial purposes or any other income producing purpose This warranty does not cover any HOMELITE brand product that has been subject to misuse neglect negligence or accident or that has been operated in any way contrary to the operating instructions as specified in this operator s manual This
13. de shields during power tool operation or when blowing dust If operation is dusty also wear a dust mask GENERAL MAINTENANCE Avoid using solvents when cleaning plastic parts Most plastics are susceptible to damage from various types of commercial solvents and may be damaged by their use Use clean cloths to remove dirt dust lubricant grease etc A WARNING Do not at any time let brake fluids gasoline petroleum based products penetrating lubricants etc come in con tact with plastic parts Chemicals can damage weaken or destroy plastic which may result in serious personal injury Only the parts shown on the parts list are intended to be repaired or replaced by the customer All other parts should be replaced at an Authorized Service Center LUBRICATION All of the bearings in this tool are lubricated with a sufficient amount of high grade lubricant for the life of the unit under normal operating conditions Therefore no further lubrication is required CHOKE DIAL COVER WAVY WASHER FILTER ee SCREEN WASHER CLEANING THE AIR FILTER SCREEN See Figures 9 10 For proper performance and long life keep the air filter screen clean H Remove the hex nut wavy washer flat washer and choke dial cover E Brush the air filter screen lightly to clean H Reinstall the choke dial cover flat washer wavy washer and hex nut Page 12 MAINTENANCE SPARK PLUG This engine uses a Champion RC
14. epair your non road or small off road engine at no cost to you including diagnosis parts and labor performed at an authorized service center for HOMELITE brand outdoor products MANUFACTURER S WARRANTY COVERAGE This product s emissions control system is warranted for two years If any emission related part on your engine is defective the part will be repaired or replaced by Homelite Consumer Products Inc free of charge OWNER S WARRANTY RESPONSIBILITIES a As the non road or small off road engine owner you are responsible for the perfor mance of the required maintenance listed in your operator s manual Homelite Consumer Products Inc recommends that you retain all receipts covering maintenance on your non road or small off road engine but Homelite Consumer Products Inc cannot deny warranty solely for the lack of receipts or for your failure to ensure the performance of all scheduled maintenance Any replacement part or service that is equivalent in performance and durability may be used in non warranty maintenance or repairs and shall not reduce the warranty obligations of Homelite Consumer Products Inc b As the non road or small off road engine owner you should be aware however that Homelite Consumer Products Inc may deny you warranty coverage if your non road or small off road engine or a part has failed due to abuse neglect improper maintenance or unapproved modifications c You are responsible
15. er of a pile E Operate power equipment at reasonable hours only not early in the morning or late at night when people might be disturbed Comply with the times listed in local ordinances H To reduce sound levels limit the number of pieces of equipment used at any one time H Operate blower at the lowest possible throttle speed to do the job H Check your equipment before operation especially the muffler air intakes and air filters E Use rakes and brooms to loosen debris before blowing E In dusty conditions slightly dampen surfaces when water is available H Conserve water by using power blowers instead of hoses for many lawn and garden applications including areas such as gutters screens patios grills porches and gardens H Watch out for children pets open windows or freshly washed cars and blow debris safely away E Use the full blower nozzle extension so the air stream can work close to the ground E After using blowers or other equipment CLEAN UP Dispose of debris in trash receptacles CAUTION Do not place blower on top of or near loose debris Debris may be sucked into blower intake vent resulting in possible damage to the unit INTAKE VENT Page 11 MAINTENANCE A WARNING When servicing use only identical Homelite replacement parts Use of any other parts may create a hazard or cause product damage A WARNING Always wear safety goggles or safety glasses with si
16. gine may be flooded proceed to next item Remove spark plug turn blower so spark plug hole is aimed at the ground Rotate the choke dial to RUN position and pull starter cord 10 to 15 times This will clear excess fuel from engine Clean and reinstall spark plug Pull starter three times with choke dial at RUN If engine does not start rotate choke dial to FULL CHOKE position and repeat normal starting procedure If engine still fails to start repeat procedure with a new spark plug Contact a servicing dealer Allow engine to completely warm up If engine does not accelerate after three minutes contact a servicing dealer Contact a servicing dealer Use fresh fuel and the correct 2 cycle lubricant mix Clean air filter Refer to Cleaning the Air Filter Screen earlier in this manual Contact a servicing dealer WARRANTY LIMITED WARRANTY STATEMENT Homelite Consumer Products Inc Homelite warrants to the original retail purchaser that this HOMELITE brand outdoor product is free from defect in material and workmanship and agrees to repair or replace at Homelite s discretion any defective product free of charge within these time periods from the date of purchase H Two years for all models if used for personal family or household use H 90 days for any unit used for other purposes such as rental or commercial This warranty extends to the original retail purchaser only and commen
17. ion Page 17 OPERATOR S MANUAL 26cc MightyLite Blower UT08520 UT08921 ALL VERSIONS warnine The engine exhaust from this product contains chemicals known to the State of California to cause cancer birth defects or other reproductive harm CALIFORNIA PROPOSITION 65 e PARTS AND SERVICE Prior to requesting service or purchasing replacement parts please obtain your model and serial number from the product data plate e MODEL NUMBER UT08520 UT08921 e SERIAL NUMBER e HOW TO OBTAIN REPLACEMENT PARTS Replacement parts can be purchased online at www homelite com or by calling 1 800 242 4672 Replacement parts can also be obtained at one of our Authorized Service Centers e HOW TO LOCATE AN AUTHORIZED SERVICE CENTER Authorized Service Centers can be located online at www homelite com or by calling 1 800 242 4672 e HOW TO OBTAIN CUSTOMER OR TECHNICAL SUPPORT To obtain Customer or Technical Support please contact us at 1 800 242 4672 HOMELITE CONSUMER PRODUCTS INC 1428 Pearman Dairy Road Anderson SC 29625 Phone 1 800 242 4672 www homelite com 987000 046 3 25 08 REV 06
18. ir filter Ignition System i Spark Plugs ii Magneto or electronic ignition system iii Spark advance retard system Exhaust Gas Recirculation EGR System il EGR valve body and carburetor spacer if applicable ii EGR rate feedback and control system 5 Air Injection System i Air pump or pulse valve ii Valves affecting distribution of flow ili Distribution manifold Catalyst or Thermal Reactor System i Catalytic converter ii Thermal reactor iii Exhaust manifold Particulate Controls i Traps filters precipitators and any other device used to capture particulate emissions Miscellaneous Items Used in Above Systems i Electronic controls ii Vacuum temperature and time sensitive valves and switches iii Hoses belts connectors and assemblies Homelite Consumer Products Inc will furnish with each new engine written instruc tions for its maintenance and use by the owner The Emissions Compliance Period referred to on the Emissions Compliance label indicates the number of operating hours for which the engine has been shown to meet Federal emission requirements Category C 50 hours B 125 hours and A 300 hours Page 16 WARRANTY THIS PRODUCT WAS MANUFACTURED WITH A CATALYST MUFFLER Congratulations You have made an investment toward protecting the environment In order to maintain this product s original emission level please refer to the maintenance schedule below EMISSIONS MAI
19. lon US 1 liter FILLING TANK H Position the product on its side with the fuel cap pointing upward Clean surface around fuel cap to prevent contamination Loosen fuel cap slowly Rest the cap on a clean surface Carefully pour fuel into the tank Avoid spillage Immediately replace fuel cap and hand tighten Wipe up any fuel spillage NOTE It is normal for smoke to be emitted from a new engine after first use A WARNING Always shut off engine before fueling Never add fuel to a machine with a running or hot engine Move at least 30 ft from refueling site before starting engine Do not smoke Page 9 OPERATION STARTING AND STOPPING See Figures 4 6 Starting the product differs depending on whether the engine is cold or warm Blower should be on a flat bare surface for starting TO START A COLD ENGINE H Place the throttle stop lever in the high speed position H Slowly press the primer bulb seven 7 times H Rotate the choke dial clockwise to the FULL CHOKE position H Pull the starter grip sharply until engine attempts to run no more than 4 pulls H Rotate the choke dial to the counterclockwise HALF CHOKE position H Pull the starter grip sharply until the engine runs H Allow the engine to run for 10 seconds H Rotate the choke dial counterclockwise to the RUN position RUN H Turn throttle stop lever to desired speed NOTE Move the throttle stop lever to the Ce position S IDR to run
20. ng signal words and meanings are intended to explain the levels of risk associated with this product SYMBOL SIGNAL MEANING DANGER Indicates an imminently hazardous situation which if not avoided will result in death or serious injury i WARNING Indicates a potentially hazardous situation which if not avoided could result in death or serious injury CAUTION Indicates a potentially hazardous situation which if not avoided may result in minor or moderate injury CAUTION Without Safety Alert Symbol Indicates a situation that may result in property damage SERVICE Servicing requires extreme care and knowledge and should A WARNING be performed only by a qualified service technician For service we suggest you return the product to your nearest AUTHORIZED SERVICE CENTER for repair When servicing use only identical replacement parts To avoid serious personal injury do not attempt to use this product until you read thoroughly and understand completely the operator s manual If you do not understand the warnings and instructions in the operator s manual do not use this product Call Homelite customer service for assistance A WARNING The operation of any power tool can result in foreign objects being thrown into your eyes which can result in severe eye damage Before beginning power tool operation always wear safety goggles or En safety glasses with side shields and when needed a full face shield
21. nit Move 30 ft away from H Secure long hair so it is above shoulder level to prevent refueling site before starting engine entanglement in any rotating parts na E Never attempt to burn off spilled fuel under any H Do not operate this unit when you are tired ill or under circumstances the influence of alcohol drugs or medication i D t tei lighti H Use only identical manufacturer s replacement parts and oa iene ny POS An accessories Use of any other parts may create a hazard E Keep all parts of your body away from any moving parts or cause product damage and all hot surfaces of the unit H Maintain the unit per maintenance instructions in this E Wear a face filter mask in dusty conditions to reduce the Operator s Manual risk of injury associated with the inhalation of dust E Inspect the unit before each use for loose fasteners fuel Check the work area before each use Remove all objects such as rocks broken glass nails wire or string which can be thrown or become entangled in the machine Keep firm footing and balance Do not overreach Overreaching can result in loss of balance or exposure to hot surfaces leaks etc Replace damaged parts SPECIFIC SAFETY RULES Always hold the control handle in your right hand refer to the Operation section later in this manual for additional instructions removing attachments Always disconnect the spark plug before performing maintenance or accessing any movable parts
22. r Blower Tube Handle and Screw 2 Cycle Engine Lubricant Operator s Manual WARNING If any parts are damaged or missing do not operate this product until the parts are replaced Failure to heed this warning could result in possible serious personal injury A WARNING Do not attempt to modify this product or create accessories not recommended for use with this tool Any such alteration or modification is misuse and could result in a hazardous condition leading to possible serious personal injury NOTE Read and remove all hang tags and store with the Operator s Manual Page 7 ASSEMBLY A WARNING Stop the engine and disconnect the spark plug wire before installing parts making adjustments cleaning or when not in use Failure to do so could result in possible serious personal injury ASSEMBLING THE BLOWER TUBE See Figure 2 E Align the flat side of the blower tube with the flat side of the blower NOTE Homelite logo will be face up E Push blower tube into blower housing until the tube latch snaps into place H Toremove the tube lift the tube latch with a screwdriver and remove tube from the blower housing outlet ATTACHING THE HANDLE See Figure 3 E Position handle so that the screw hole is facing outward SCREW HOLE E Insert handle into blower handle compartment until the handle snaps into place H Secure handle in place with the provided screw HANDLE Page 8 OP
23. the blower at high speed Move the throttle stop lever to the lt gt position to run the blower at low speed HALF Blower speed decreases as the switch is moved closer CHOKE to the low speed position and increases when the switch is moved closer to the high speed position TO START A WARM ENGINE H Rotate the choke dial counterclockwise to the RUN position H Place the throttle stop lever in the high speed Ce position H Slowly press the primer bulb seven 7 times H Pull the starter grip sharply until the engine runs TO STOP THE ENGINE See Figure 6 Place the throttle stop lever in the STOP OFF position IF ASSISTANCE IS REQUIRED STARTING THIS PRODUCT Do not return this product to the retail store where it was purchased Please call our Customer Service Department for any issues you may have For Help Call 1 800 242 4672 A WARNING STOP OFF POSITION Keep away from all hot surfaces of the blower Failure to do so could result in possible serious personal injury Page 10 OPERATION OPERATING THE BLOWER See Figures 7 8 PROPER OPERATING POSITION A WARNING Always hold the blower away from your body with the handle in your right hand keeping clearance between your body and the product Any contact with the housing can result in burns and or other serious personal injury H To keep from scattering debris blow around the outer edges of a debris pile Never blow directly into the cent
24. uel cap is loosened the check valve may be faulty or filter clogged Replace the fuel cap if required STORING THE PRODUCT H Clean all foreign material from the product Store it in a well ventilated place that is inaccessible to children Keep away from corrosive agents such as garden chemicals and de icing salts E Abide by all Federal and local regulations for the safe storage and handling of gasoline WHEN STORING 1 MONTH OR LONGER MB Drain all fuel from tank into a container approved for gasoline Run engine until it stops Page 13 TROUBLESHOOTING C From Posi Gase Soon Engine will not start Engine starts but will not accelerate Engine starts but will only run at high speed at half choke Engine does not reach full speed and emits excessive smoke No spark No fuel Engine is flooded Starter rope pulls harder now than when new Engine requires approximately three minutes to warm up Carburetor requires adjustment Check lubricant fuel mixture Air filter is dirty Spark arrestor screen is dirty Page 14 Check spark Remove spark plug Reattach the spark plug cap and lay spark plug on metal cylinder Pull the starter rope and watch for spark at spark plug tip If there is no spark repeat test with a new spark plug Push primer bulb until bulb is full of fuel If bulb does not fill primary fuel delivery system is blocked Contact a servicing dealer If primer bulb fills en
25. under warranty Homelite Consumer Products Inc is liable for damages to other engine components caused by the failure of a warranted part still under warranty Add on or modified parts that are not exempted by the California Air Resource Board may not be used The use of any non exempted add on or modified parts will be grounds for disallowing a warranty claim Homelite Consumer Products Inc will not be liable to warrant failures of warranted parts caused by the use of anon exempted add on or modified part The California Air Resources Board s Emission Warranty Parts List specifically defines the emission related warranted parts EPA s regulations do not include a parts list but the EPA considers emission related warranted parts to include all the parts listed below Homelite Consumer Products Inc will provide any documents that describe its warranty procedures or policies within five days upon request by the California Air Resources Board EMISSIONS PARTS LIST Emissions parts vary from product to product Your emissions control system warranty applies to any of the following components that may be included on your product 1 Fuel Metering System i Carburetor and internal parts and or pressure regulator or fuel injection system ii Air fuel ratio feedback and control system iii Cold start enrichment system iv Fuel Tank 2 Air Induction System i Controlled hot air intake system ii Intake manifold iii A
26. warranty does not apply to any damage to the product that is the result of improper maintenance or to any product that has been altered or modified The warranty does not extend to repairs made necessary by normal wear or by the use of parts or accessories which are either incompatible with the HOMELITE brand product or adversely affect its operation performance or durability In addition this warranty does not cover A Tune ups Spark Plugs Carburetor Carburetor Adjustments Ignition Filters B Wear items Bump Knobs Outer Spools Cutting Lines Inner Reels Starter Pulleys Starter Ropes Drive Belts Tines Felt Washers Hitch Pins Mulching Blades Blower Fans Blower and Vacuum Tubes Vacuum Bags and Straps Guide Bars Saw Chains Homelite reserves the right to change or improve the design of any HOMELITE brand product without assuming any obligation to modify any product previously manufactured ALL IMPLIED WARRANTIES ARE LIMITED IN DURATION TO THE STATED WARRANTY PERIOD ACCORDINGLY ANY SUCH IMPLIED WARRANTIES INCLUDING MERCHANTABILITY FITNESS FOR A PARTICULAR PURPOSE OR OTHERWISE ARE DISCLAIMED IN THEIR ENTIRETY AFTER THE EXPIRATION OF THE APPROPRIATE TWO YEAR ONE YEAR OR NINETY DAY WARRANTY PERIOD HOMELITE S OBLIGATION UNDER THIS WARRANTY IS STRICTLY AND EXCLUSIVELY LIMITED TO THE REPAIR OR REPLACEMENT OF DEFECTIVE PARTS AND HOMELITE DOES NOT ASSUME OR AUTHORIZE ANYONE TO ASSUME FOR THEM ANY OTHER OBLIGATION
Download Pdf Manuals
Related Search