Breville BTA820XL Toaster User Manual
Contents
1. 0 36 mm Spark plug gap 0 030 in 0 76 mm Valve clearance with valve springs installed and piston 1 4 in 6 mm past top dead center check when engine is cold See Repair Manual P N 272147 Intake 0 004 0 006 in 0 10 0 15 mm Exhaust 0 009 0 011 in 0 23 0 28 mm TUNE UP SPECIFICATIONS Models 200000 210000 Armature air gap 0 008 0 012 in 0 20 0 30 mm Spark plug gap 0 030 in 0 76 mm Valve clearance with valve springs installed and piston 1 4 in 6 mm past top dead center check when engine is cold See Repair Manual P N 272147 Intake 0 004 0 006 in 0 10 0 15 mm Exhaust 0 004 0 006 in 0 10 0 15 mm 275092 CAUTION This engine is shipped from Briggs amp Stratton without oil Check oil level before starting Note Synthetic oil meeting ILSAC GF 2 API certification mark and API service symbol shown at left with SJ CF ENERGY CON SERVING or higher is an acceptable oil at all temperatures Use of synthetic oil does not alter required oil change intervals engine If you start the engine without oil the engine will be damaged beyond repair and will not be covered under warranty Note If this engine is equipped with gear reduction gear SAE Viscosity Grades reduction case must be filled with oil prior to operating en gine See gear reduction oil filling instructions on page 12 Memm OIL CAPACITY a ba EA Model 110000 and 120000 series engines ho2. Operating amp Maintenance Instructions Model Series Covered in This Manual 110000 120000 200000 210000 Note General Model Series numbers noted above are inclusive of the specific model number found on your engine To get replacement parts or technical assistance in Month Day Year the future write your engine Model Type Code and date of purchase here TABLE OF CONTENTS Briggs amp Stratton does not approve or authorize the use of these engines on 3 wheel All Terrain Vehicles ATVs motor Engine Information bikes fun recreational go karts aircraft products or vehicles intended for use in competitive events Use of these engines in such applications could result in property damage serious injury including paralysis or even death Fuel and Starting Information Starting and Stopping Maintenance Need assistance Go to www briggsandstratton com Parts and Service amp Storage for detailed information regarding Briggs amp Stratton engines Warranty Information Or call 1 800 233 3723 U S A and Canada to hear a menu of pre recorded messages offering engine maintenance information PRINTED IN U S A Copyright 2005 by Briggs amp Stratton Corporation FORM NO 275092 8 05 BRIGGS amp STRATTON IMPORTANT ENGINE INFORMATION BRIGGS amp STRATTON CORPORATION FAMILY YBSXS 3192VA 274812 THIS ENGINE CONFORMS TO 2000 2001 CALIFORNI 275092 A CO BEFORE OPERATING ENGINE e Read
3. me de contr le des missions pour votre petit moteur tout terrain En Californie les petits moteurs tout terrain partir de l ann e 2006 doivent tre con us fabriqu s et quip s pour r pondre aux normes s v res antibrouillard de l tat Ailleurs aux Etats Unis les nouveaux moteurs tout terrain allumage command par bougie depuis l ann e 1997 doivent r pondre des normes semblables dict es par la U S EPA B amp S doit garantir le syst me de contr le des missions de votre moteur pendant les dur es indiqu es ci apr s en supposant que le petit moteur tout terrain ne soit pas mal utilis n glig ou que son entretien ne soit pas d fectueux Le syst me de contr le des missions comprend des pi ces comme le carburateur le filtre air le syst me d allumage la Durit de carburant le silencieux et le convertisseur catalytique Des connecteurs et d autres assemblages impliqu s dans les missions peuvent aussi en faire partie Si la condition de garantie est remplie Briggs amp Stratton r parera gratuitement votre moteur y compris le diagnostic les pi ces et la main d uvre Couverture de la garantie de d fectuosit du contr le des missions de Briggs amp Stratton Les petits moteurs tout terrain sont garantis en ce qui concerne les d fauts des pi ces du contr le d mission pendant une p riode de deux ans aux conditions nonc es plus loin Si une pi ce de votre moteur couverte par cette g
4. can cause nausea fainting or death e Start and run engine outdoors e Do not start or run engine in enclosed area even if doors or windows are open Running engines produce heat Engine parts especially muffler become extremely hot Severe thermal burns can occur on contact Sn A Combustible debris such as leaves grass brush etc can catch fire e Allow muffler engine cylinder and fins to cool before touching e Remove accumulated combustibles from muffler area and cylinder area e Install and maintain in working order a spark arrester before using equipment on forest covered grass covered brush covered unimproved land The state of California requires this Section 4442 of the California Public Resources Code Other states may have similar laws Federal laws apply on federal land BRIGGS amp STRATTON ENGINE INFORMATION Spark plug Air cleaner Choke Carburetor Fuel shut off valve if equipped Rope handle Finger guard Stop switch OIL GARD light if equipped Fuel fill oN oO akhoND GENERAL INFORMATION ENGINE MODEL This is a single cylinder overhead valve OHV air cooled engine It is a low emissions engine In the state of California OHV Model Series 110000 and 120000 engines are certified by the California Air Re sources Board to meet emissions standards for 125 hours OHV Model Series 200000 210000 engines are ce
5. entire Operating amp Maintenance Instructions AND the instructions for the equipment this engine powers e Failure to follow instructions could result in serious injury or death THE OPERATING amp MAINTENANCE INSTRUCTIONS CONTAIN SAFETY INFORMATION TO e Make you aware of hazards associated with engines e Inform you of the risk of injury associated with those hazards and e Tell you how to avoid or reduce the risk of injury The safety alert symbol is used to identify safety HAZARD SYMBOLS AND MEANINGS information about hazards that can result in personal injury A signal word DANGER WARNING or CAUTION is We used with the alert symbol to indicate the likelihood and the potential severity of injury In addition a hazard symbol Explosion Moving Parts may be used to represent the type of hazard A DANGER indicates a hazard which if not ponm avoided will result in death or serious injury Toxic Fumes fat Surace Shock A WARNING indicates a hazard which if not Nc avoided could result in death or serious injury Kickback A CAUTION indicates a hazard which if not avoided might result in minor or moderate injury THE INTERNATIONAL SYMBOLS USED ON THE ENGINE OR CAUTION when used without the alert symbol IN THIS MANUAL INCLUDE indicates a situation that could result in damage to the engine The engine exhaust from this prod Safety Alert Read Owner s On Off Manual 0 N NR Oil Stop Fuel Shutoff Cho
6. tank EMPTY or with fuel shut off valve OFF WHEN STORING GASOLINE OR EQUIPMENT WITH FUEL IN TANK e Store away from furnaces stoves water heaters or other appliances that have pilot light or other ignition source because they can ignite gasoline vapors Starting engine creates sparking Sparking can ignite nearby flammable gases Explosion and fire could result e If there is natural or LP gas leakage in area do not start engine e Do not use pressurized starting fluids because vapors are flammable Rapid retraction of starter cord kickback will pull hand and arm toward engine faster than you can let go Broken bones fractures bruises or sprains could result e When starting engine pull cord slowly until resistance is felt then pull rapidly e Remove all external equipment engine loads before starting engine e Direct coupled equipment components such as but not limited to blades impellors pulleys sprockets etc must be securely attached Rotating parts can contact or entangle hands feet hair clothing or accessories Traumatic amputation or severe laceration can result e Operate equipment with guards in place e Keep hands and feet away from rotating parts e Tie up long hair and remove jewelry Do not wear loose fitting clothing dangling drawstrings or items that could become caught Engines give off carbon monoxide an odorless colorless poison gas Breathing carbon monoxide
7. 6 460 502 6 456 515 6 382 166 6 369 532 6 356 003 6 349 688 6 347 614 6 325 036 6 311 663 6 284 123 6 263 852 6 260 529 6 242 828 6 239 709 6 237 555 6 230 678 6 213 083 6 202 616 6 145 487 6 142 257 6 135 426 6 116 212 6 105 548 6 347 614 6 082 323 6 077 063 6 064 027 6 040 767 6 014 808 6 012 420 5 992 367 5 904 124 5 894 715 5 887 678 5 852 951 5 843 345 5 823 153 5 819 513 5 813 384 5 809 958 5 803 035 5 765 713 5 732 555 5 645 025 5 642 701 5 628352 5 619 845 5 606 948 5 606 851 5 605 130 5 497 679 5 548 955 5 546 901 5 445 014 5 503 125 5 501 203 5 497 679 5 320 795 5 301 643 5 271 363 5 269 713 5 265 700 5 243 878 5 235 943 5 234 038 5 228 487 5 197 426 5 197 425 5 197 422 5 191 864 5 188 069 5 186 142 5 150 674 5 138 996 5 086 890 5 070 829 5 058 544 5 040 644 5 009 208 4 996 956 4 977 879 4 977 877 4 971 219 4 895 119 4 875 448 4 819 593 4 720 638 4 719 682 4 633 556 4 630 498 4 522 080 4 520 288 4 512 499 4 453 507 4 430 984 D 476 629 D 457 891 D 368 187 D 375 963 D 309 457 D 372 871 D 361 771 D 356 951 D 309 457 D 308 872 D 308 871 18 Cette page ne s applique que pour le Canada et les Etats Unis D claration de garantie pour les d fauts de contr le d missions pour la Californie les tats Unis et le Canada Le California Air Resources Board CARB U S EPA et B amp S ont le plaisir de vous expliquer la garantie du syst
8. aminated or stale fuel Use clean fresh lead free gasoline and Briggs amp Stratton Fuel Stabilizer Part No 5041 4 Parts which are scored or broken because an engine was operated with insufficient or contaminated lubricating oil or an incorrect grade of lubricating oil check oil level daily or after every 8 hours of operation Refill when necessary and change at recommended intervals OIL GARD may not shut down running engine Engine damage may occur if oil level is not properly maintained Read Operating amp Maintenance Instructions 5 Repair or adjustment of associated parts or assemblies such as clutches transmissions remote controls etc which are not manufactured by Briggs amp Stratton 6 Damage or wear to parts caused by dirt which entered the engine because of improper air cleaner maintenance re assembly or use of a non original air cleaner element or cartridge At recommended 17 intervals clean and re oil the Oil Foam element or the foam pre cleaner and replace the cartridge Read Operating amp Maintenance Instructions 7 Parts damaged by over speeding or overheating caused by grass debris or dirt which plugs or clogs the cooling fins or flywheel area or damage caused by operatingthe engine in a confined area without sufficient ventilation Clean fins on the cylinder cylinder head and flywheel at recommended intervals Read Operating amp Maintenance Instructions 8 Engine or equipme
9. arantie est d fectueuse Briggs et Stratton la r parera ou la remplacera Responsabilit s du propri taire au titre de la garantie En tant que propri taire d un petit moteur non routier vous tes responsable de l entretien n ces saire indiqu dans les instructions de fonctionnement et d entretien Briggs amp Stratton recomman de de conserver toutes les factures de maintenance de votre moteur mais Briggs amp Stratton ne peut renier la garantie uniquement cause de l absence de factures BRIGGS amp STRATTON
10. area Oil Fill OIL LEVEL 1 Place engine level and Remove oil fill 3 Pour oil slowly Fill to 4 Replace and tighten clean around oil fill area cap or dipstick point of overflowing oil fill cap BRIGGS amp STRATTON OIL CHECKING AND ADDING OIL Low Oil Fill 11 with Dipstick TYPE OF FUEL TO USE e Use clean fresh regular unleaded gasoline with a minimum of 85 octane Fresh fuel prevents gum from forming in the fuel system or on essential carburetor parts Purchase fuel in quantity that can be used within 30 days e Do not use gasoline which contains Methanol e Do not mix oil with gasoline e For engine protection use Briggs amp Stratton Gasoline Additive available from your Authorized Briggs amp Stratton Dealer P N 5041 or single use pouch Remove dipstick and wipe with clean cloth ADDING FUEL EE e Turn engine OFF and let engine cool at least 2 minutes before removing gas cap e Fill fuel tank outdoors or in well ventilated area e Keep gasoline away from sparks open flames pilot lights heat and other ignition sources e f fuel spills wait until it evaporates before starting engine BRIGGS amp STRATTON STARTING STARTING AND OPERATING TIPS Store and fuel equipment in level position Use fresh fuel See Fuel Use correct type of oil for expected starting temperature See Oil Remove external equipment engine loads See 2 Inser
11. be fully reimbursed for those items that are defective To avoid misunderstanding which might occur between the customer and the Dealer listed below are some of the causes of engine failure that the warranty does not cover Normal wear Engines like all mechanical devices need periodic parts service and replacement to perform well Warranty will not cover repair when normal use has exhaustedthe life of a part or an engine Improper maintenance The life of an engine depends upon the conditions under which it operates and the care it receives Some applications such as tillers pumps and rotary mowers are very often used in dusty or dirty conditions which can cause what appears to be premature wear Such wear when caused by dirt dust spark plug cleaning grit or other abrasive material that has entered the engine because of improper maintenance is not covered by warranty This warranty covers engine related defective material and or workmanship only and not replacement or refund of the equipment to which the engine may be mounted a does the warranty extend to repairs required because of 1 PROBLEMS CAUSED BY PARTS THAT ARE NOT ORIGINAL BRIGGS amp STRATTON PARTS 2 Equipment controls or installations that prevent starting cause unsatisfactory engine performance or shorten engine life Contact equipment manufacturer 3 Leaking carburetors clogged fuel pipes sticking valves or other damage caused by using cont
12. e limitation and exclusion may not apply to you This warranty gives you specific legal rights and you may also have other rights which vary from state to state and country to country OUR ENGINE Vanguard ELS Fource Classic Etek 1 C Intek Industrial Plus Kool Bore Intek Power Built OHV Sleeve Bore Quantum Quattro Q45 Sprint WARRANTY PERIOD Consumer Use 2 years 2 years 1 year 2 years 1 year Commercial Use 1 year 90 days 90 days Note the following special warranty periods 2 years for Classic engines in the European Union and Eastern European countries for all consumer products in the European Union and for emission control systems on engines certified by EPA and CARB 5 years for Consumer use 90 days for Commercial use of Touch N Mow starter on Quantum and Intek engines One year for Consumer use 90 days for Commercial use on engines certified to operate on Kerosene fuel Engines used on Home Standby Generator applications are warranted under Consumer use only This warranty does not apply to engines on equipment used for prime power in place of a utility Engines used in competitive racing or on commercial or rental tracks are not warrantied The warranty period begins on the date of purchase by the first retail consumer or commercial end user and continues for the period of time stated in the table above Consumer use means personal residential household use by a retail consumer Co
13. evel is not properly maintained and will void warranty coverage lf the engine will not start has stopped running and or a light flickers in the stop switch add oil see instructions WARNING k Y e Do not use pressurized starting fluids e Vapors are flammable REWIND MANUAL STARTER TO START ENGINE cHoke ae el 5 NAS POSITION Fuel shut off Choke 3 Move throttle if 2 Turn fuel shut off valve if equipped 1 4 turn equipped to FAST to OPEN A a Operate engine with 3 Push choke lever to CHOKE position throttle in FAST Let engine warm up If choke equipped Slowly adjust toward RUN position Wait until engine runs smoothly before each choke adjustment 5 Push rocker switch 6 if equipped to ON Grasp rope handle Pull slowly until resistance is felt then pull rapidly to start engine and avoid kickback TO STOP ENGINE CAUTION Do not stop D engine by moving choke D control to CHOKE Backfire fire or engine damage could occur 1 Move throttle if equipped 2 Push rocker switch to SLOW then to STOP if equipped to OFF Fuel shut off 3 Close fuel shut off valve if equipped BRIGGS amp STRATTON STARTING AND STOPPING ELECTRIC KEY STARTER if equipped TO START ENGINE u jrun CHOKE N OPEN J POSITION Fuel sh
14. ichment system e Carburetor and internal parts e Fuel Pump Fuel line fuel line fittings clamps b Air Induction System e Air cleaner e Intake manifold c Ignition System e Spark plug s e Magneto ignition system d Catalyst System e Catalytic converter e Exhaust manifold e Air injection system Pulse valve e Miscellaneous ltems e Vacuum temperature position time sensitive valves and switches e Connectors and assemblies 2 Length of Coverage B amp S warrants to the initial owner and each subsequent purchaser that the Warranted Parts shall be free from defects in materials and workmanship which caused the failure of the Warranted Parts for a period of two years from the date the engine is delivered to a retail purchaser 3 No Charge Repair or replacement of any Warranted Part will be performed at no charge to the owner including diagnostic labor which leads to the determination that a Warranted Part is defective if the diagnostic work is performed at an Authorized B amp S Service Dealer For emissions warranty service contact your nearest Authorized B amp S Ser vice Dealer as listed in the Yellow Pages under Engines Gasoline Gasoline En gines Lawn Mowers or similar category 4 Claims and Coverage Exclusions Warranty claims shall be filed in accordance with the provisions of the B amp S Engine War ranty Policy Warranty coverage shall be ex cluded for failures of Warranted Part
15. ke Fuel uct contains chemicals known to the State of California to cause cancer birth defects or other reproductive harm Briggs amp Stratton does not necessarily know what equipment this engine will power For that reason you should carefully read and understand the operating instructions for the equipment on which your engine is placed Gasoline and its vapors are extremely flammable and explosive Fire or explosion can cause severe burns or death WHEN ADDING FUEL e Turn engine OFF and let engine cool at least 2 minutes before removing gas cap e Fill fuel tank outdoors or in well ventilated area e Do not overfill fuel tank Fill tank to approximately 1 1 2 inches below top of neck to allow for fuel expansion e Keep gasoline away from sparks open flames pilot lights heat and other ignition sources e Check fuel lines tank cap and fittings frequently for cracks or leaks Replace if necessary WHEN STARTING ENGINE e Make sure spark plug muffler fuel cap and air cleaner are in place e Do not crank engine with spark plug removed e If fuel spills wait until it evaporates before starting engine e If engine floods set choke to OPEN RUN position place throttle in FAST and crank until engine starts WHEN OPERATING EQUIPMENT e Do not tip engine or equipment at angle which causes gasoline to spill e Do not choke carburetor to stop engine WHEN TRANSPORTING EQUIPMENT e Transport with fuel
16. ld approxi mete 5W 30 10W 30 mately 5 8 quart 20 ounces 0 6 liter es PE EA AE EL Or 20 20 32 40 c 30 0 10 20 30 40 Model series 200000 and 210000 engines hold approxi STARTING TEMPERATURE RANGE ANTICIPATED BEFORE NEXT OIL CHANGE mately 7 8 quart 28 ounces 0 8 liter CAUTION Air cooled engines run hotter than automotive TYPE OF OIL TO USE engines The use of non synthetic multi viscosity oils Er 5W 30 10W 30 etc in temperatures above 40 F 4 e Use a high quality detergent oil classified For Service will result in higher than normal oil consumption When using SF SG SH SJ or higher such as Briggs amp Stratton a multi viscosity oil check oil level more frequently SAE 30 Part Number 100005 20 oz or 100028 48 oz CAUTION SAE 30 oil if used below 40 F 4 C will result e Do not use special additives in hard starting and possible engine bore damage due to inadequate lubrication e Choose a viscosity according to the table opposite CHECKING AND ADDING OIL e Check oil level before starting the engine e Check level daily or after every eight 8 hours e Keep oil level at FULL e Do not overfill if equipped Remove dipstick and wipe with clean 3 Pour oil slowly Fill to FULL line on cloth Replace and tighten dipstick dipstick recheck Ll Place engine level and Remove and check oil level 4 Replace and tighten dipstick clean around oil fill
17. lely for the lack of re ceipts or for your failure to ensure the perfor mance of all scheduled maintenance As the small off road engine owner you should Owner s Warranty Responsibilities however be aware that B amp S may deny you war ranty coverage if your small off road engine or a part has failed due to abuse neglect improper maintenance or unapproved modifications You are responsible for presenting your small off road engine to an Authorized B amp S Service Dealer as soon as a problem exists The undisputed warranty repairs should be completed in a reasonable amount of time not to exceed 30 days If you have any questions regarding your war ranty rights and responsibilities you should con tact a B amp S Service Representative at 1 414 259 5262 The emissions warranty is a defects warranty Defects are judged on normal engine perfor mance The warranty is not related to an in use emissions test Briggs amp Stratton Emissions Control Defects Warranty Provisions The following are specific provisions relative to your emissions Control Defects Warranty Coverage It is in addition to the B amp S engine warranty for non regulated engines found in the Operating and Maintenance Instructions Warranted Parts Coverage under this warranty extends only to the parts listed below the emissions con trol systems parts to the extent these parts were present on the engine purchased a Fuel Metering System e Cold start enr
18. mmercial use means all other uses including use for commercial income producing or rental purposes Once an engine has experienced commercial use it shall thereafter be considered as a commercial use engine for purposes of this warranty NO WARRANTY REGISTRATION IS NECESSARY TO OBTAIN WARRANTY ON BRIGGS amp STRATTON PRODUCTS SAVE YOUR PROOF OF PURCHASE RECEIPT IF YOU DO NOT PROVIDE PROOF OF THE INITIAL PURCHASE DATE AT THE TIME WARRANTY SERVICE IS REQUESTED THE MANUFACTURING DATE OF THE PRODUCT WILL BE USED TO DETERMINE THE WARRANTY PERIOD ABOUT YOUR ENGINE WARRANTY Briggs amp Stratton welcomes warranty repair and apologizes to you for being inconvenienced Any Authorized Service Dealer may perform warranty repairs Most warranty repairs are handled routinely but sometimes requests for warranty service may not be appropriate For example warranty would not apply if engine damage occurred because of misuse lack of routine maintenance shipping handling warehousing or improper installation Similarly warranty is void if the serial number of the engine has been removed or the engine has been altered or modified Ifa customer differs with the decision of the Service Dealer an investigation will be made to determine whether the warranty applies Ask the Service Dealer to submit all supporting facts to his Distributor or the Factory for review If the Distributor or the Factory decides that the claim is justified the customer will
19. model year 2006 and later must be designed built and equipped to meet the State s stringent anti smog standards Elsewhere in the United States new non road spark ignition engines certified for model year 1997 and later must meet similar standards set forth by the U S EPA B amp S must warrant the emis sions control system on your engine for the peri ods of time listed below provided there has been no abuse neglect or improper maintenance of your small off road engine Your emissions control system includes parts such as the carburetor air cleaner ignition sys tem fuel line muffler and catalytic converter Also included may be connectors and other emissions related assemblies Where a warrantable condition exists B amp S will repair your small off road engine at no cost to you including diagnosis parts and labor Briggs amp Stratton Emissions Control Defects Warranty Coverage Small off road engines are warranted relative to emissions control parts defects for a period of two years subject to provisions set forth below If any covered part on your engine is defective the part will be repaired or replaced by B amp S As the small off road engine owner you are re sponsible for the performance of the required maintenance listed in your Operating and Main tenance Instructions B amp S recommends that you retain all your receipts covering mainte nance on your small off road engine but B amp S cannot deny warranty so
20. n if damaged or plugged SPARK PLUG Use only Briggs amp Stratton Spark Tester part number 19368 to check for spark Note In some areas local law requires using resistor spark plug to suppress ignition signals If this engine was originally equipped with resistor spark plug use same type for replacement 030 0 76 mm WIRE GAGE 7 RESISTOR P N 491055 13 If you perform any maintenance on the engine first disconnect the spark plug wire from the spark plug and disconnect the battery at the negative terminal electric starter engines only to prevent unintentional sparking Unintentional sparking can result in fire or electric shock Unintentional start up can result in entanglement traumatic amputation or laceration Use only correct tools e Do not strike the flywheel with a hammer or hard object because the flywheel may later shatter during operation e Do not tamper with governor spring links or other parts to increase engine speed FUEL SYSTEM Replacement parts for fuel system cap hoses tanks filters etc must be the same as original parts otherwise fire can occur A REPLACE FUEL FILTER if equipped Drain fuel tank or close fuel shut off valve before replacing fuel filter Otherwise fuel can leak out creating a fire explosion hazard FUEL FILTER P N 499638 FUEL HOSE CLAMPS MAINTENANCE CLEANING DEBRIS CAUTION Do not use water to clean engine parts Wa
21. nt parts broken by excessive vibration caused by a loose engine mounting loose cutter blades unbalanced blades or loose or unbalanced impellers improper attachment of equipment to engine crankshaft over speeding or other abuse in operation 9 A bent or broken crankshaft caused by striking a solid object with the cutter blade of a rotary lawn mower or excessive v belt tightness 10 Routine tune up or adjustment of the engine 11 Engine or engine component failure i e combustion chamber valves valve seats valve guides or burned starter motor windings caused by the use of alternate fuels such as liquified petroleum natural gas altered gasolines etc Warranty service is available only through service dealers which have been authorized by Briggs amp Stratton Corporation Your nearest Authorized Service Dealer is listed in the Yellow Pages of your telephone directory under Engines Gasoline or Gasoline Engines Lawn Mowers or similar category Briggs amp Stratton Corporation B amp S the California Air Resources Board CARB and the United States Environmental Protection Agency U S EPA Emissions Control System Warranty Statement Owner s Defect Warranty Rights and Obligations The California Air Resources Board CARB U S EPA and B amp S are pleased to explain the Emis sions Control System Warranty on your small off road engine SORE In California new small off road engines
22. rized Briggs Stratton are required to meet Briggs amp Stratton standards When you purchase equipment powered by a Briggs amp Stratton engine you are assured of KG highly skilled reliable service at more than NZ 30 000 Authorized Service Dealers worldwide including more than 6 000 Master Service Technicians Look for these signs CR P E BRIGGS amp STRATTON wherever Briggs amp Stratton service is offered gt BRIGGS amp STRATTON 15 SERVICE 8 STORAGE SERVICE amp STORAGE STORAGE Engines stored over 30 days need special attention 2 While engine is still warm change oil 1 To prevent gum from forming in fuel system or on 3 Remove spark plug and pour about 1 oz 30 ml of essential carburetor parts engine oil into cylinder Replace spark plug and crank a if fuel tank contains oxygenated or reformulated slowly to distribute oil gasoline gasoline blended with an alcohol or an ether run engine until it stops from lack of fuel or b if 4 Clean engine of surface debris chaff or grass fuel tank contains gasoline either run engine until it stops from lack of fuel or add a gasoline additive to the 5 Store in a clean dry area Do gas in the tank See parts list Single use pouches of WARNING not store in same area as a gas additive are available from your service dealer If stove furnace water heater you use a gas additive run the engine for several A We or other appliance
23. rtified by the California Air Resources Board to meet emissions standards for 250 hours Such certification does not grant the purchaser owner or operator of this engine any additional warranties with respect to the performance or operational life of this engine This engine is warranted solely according to the product and emissions warranties stated elsewhere in this manual Note For practical operation horsepower loading should not exceed 85 of rated horsepower Engine power will de crease 3 1 2 for each 1 000 feet 300 meters above sea level and 1 for each 10 F 5 6 C above 77 F 25 C Engine will operate satisfactorily at an angle up to 15 MODEL SERIES 110000 2 11 16 in 68 mm REMISE MNT der 2 3 64 in 52 mm 11 58 cu in 190 cc Displacement MODEL SERIES 120000 2 11 16 in 68 mm 2 13 64 in 56 mm 12 48 cu in 206 cc BRIGGS amp STRATTON Fuel tank Oil fill Dipstick Blower housing Oil drain plug Oil fill cap Engine ZN if equipped 97 Model XXXXX Code Type XXXX XX XXXXXXXX Muffler Muffler guard if equipped Spark arrester if equipped MODEL SERIES 200000 3 120 in 79 23 mm 2 438 in 61 67 mm 18 64 cu in 305 cc Displacement MODEL SERIES 210000 3 300 in 83 81 mm 2 438 in 61 67 mm 20 85 cu in 342 cc TUNE UP SPECIFICATIONS Models 110000 120000 Armature air gap 0 010 0 014 in 0 25
24. s which are not original B amp S parts or because of abuse neglect or improper maintenance as set forth in the B amp S Engine Warranty Policy Briggs amp Stratton Engines Are Made Under One Or More Of The Following Patents Design D 247 177 Other Patents Pending B amp S is not liable to cover failures of War ranted Parts caused by the use of add on non original or modified parts 5 Maintenance Any Warranted Part which is not scheduled for replacement as required maintenance or which is scheduled only for regular inspec tion to the effect of repair or replace as nec essary shall be warranted as to defects for the warranty period Any Warranted Part which is scheduled for replacement as re quired maintenance shall be warranted as to defects only for the period of time up to the first scheduled replacement for that part Any replacement part that is equivalent in perfor mance and durability may be used in the per formance of any maintenance or repairs The owner is responsible for the perfor mance of all required maintenance as de fined in the B amp S Operating and Maintenance Instructions 6 Consequential Coverage Coverage hereunder shall extend to the fail ure of any engine components caused by the failure of any Warranted Part still under warranty 6 691 683 6 647 942 6 622 683 6 615 787 6 617 725 6 603 227 6 595 897 6 595 176 6 584 964 6 557 833 6 542 074 6 520 141 6 495 267 6 494 175 6 472 790
25. t dipstick 3 Pour oil slowly but DO NOT Fill to FULL TIGHTEN mark on dip Remove and stick Replace and tighten dip stick e This engine is certified to operate on gasoline Exhaust Emission Control System EM Engine Modifications CAUTION Some fuels called oxygenated or reformu lated gasoline are gasoline blended with alcohols or ethers Excessive amounts of these blends can damage the fuel system or cause performance problems If any undesirable operating symptoms occur use gasoline with a lower percentage of alcohol or ether 1 Remove cap Fill tank to approximately 1 1 2 inches below top of neck to allow for fuel expansion Be careful not to overfill Briggs amp Stratton Smart fill fuel can fills to the correct level and automatically shuts off reduc ing spills and emissions 2 Replace cap before starting Periodically remove any debris buildup from the machine See Maintenance After engine has started let it warm up several seconds to several minutes depending on outside temperature For maximum performance and life operate engine equipment operating instructions with choke in RUN and throttle in FAST STARTING AND STOPPING BRIGGS amp STRATTON CAUTION Some engines may be equipped with OIL GARD The OIL GARD is intended to warn the operator that the engine is low on oil Always check oil level before starting Engine damage may occur if the oil l
26. ter could contaminate fuel system Use a brush or dry cloth Daily or before every use clean accumulated debris from engine Keep linkage spring and controls clean Keep area around and behind muffler free of any combustible debris Engine parts should be kept clean to WARNING reduce the risk of overheating and ignition of accumulated debris A Finger Guard Linkage Springs Controls Muffler and Spark Arrester 14 PARTIAL LIST OF GENUINE BRIGGS amp STRATTON PARTS BRIGGS amp STRATTON PART PART NUMBER Flat air cleaner cartridge 491588 or 5043 Flat air cleaner pre cleaner 493537 OR 5064 Model Series 110000 120000 Oval air cleaner cartridge 690610 or 5059 Oval pre cleaner 273356 OR 5059 Model Series 200000 210000 Oval air cleaner cartridge 695302 Oval pre cleaner 695303 Oil foam air cleaner pre cleaner 273332 Oil 100005 or 100028 Fuel filter 694485 Gas additive 5041 Resistor spark plug 491055 Long life platinum spark plug 5066 used on most OHV engines Spark plug wrench 89838 or 5023 Spark tester 19368 Oil pump kit 5056 uses standard electric drill to remove oil from engine quickly SERVICE See an Authorized Briggs 8 Stratton Service Dealer Each one carries a stock of Genuine Briggs 8 Stratton Parts and is equipped with special service tools Trained mechanics assure expert repair service on all Briggs amp Stratton engines Only dealers advertising as Autho
27. that uses a minutes to circulate the additive through the carburetor y pilot light or has a device that Then engine and fuel can be stored up to 24 months can create a spark 16 BRIGGS amp STRATTON ENGINE OWNER WARRANTY POLICY Effective July 1 2004 replaces all undated Warranties and all Warranties dated before July 1 2004 LIMITED WARRANTY Briggs amp Stratton Corporation will repair or replace free of charge any part s of the engine that is defective in material or workmanship or both Transportation charges on parts submitted for repair or replacement under this warranty must be borne by purchaser This warranty is effective for the time periods and subject to the conditions stated below For warranty service find the nearest Authorized Service Dealer in our dealer locator map at www briggsandstratton com or by calling 1 800 233 3723 or as listed in the Yellow Pages THERE IS NO OTHER EXPRESS WARRANTY IMPLIED WARRANTIES INCLUDING THOSE OF MERCHANTABILITY AND FITNESS FOR A PARTICULAR PURPOSE ARE LIMITED TO ONE YEAR FROM PURCHASE OR TO THE EXTENT PERMITTED BY LAW ANY AND ALL IMPLIED WARRANTIES ARE EXCLUDED LIABILITY FOR INCIDENTAL OR CONSEQUENTIAL DAMAGES ARE EXCLUDED TO THE EXTENT EXCLUSION IS PERMITTED BY LAW Some states or countries do not allow limitations on how long an implied warranty lasts and some states or countries do not allow the exclusion or limitation of incidental or consequential damages so the abov
28. ut off Choke 2 Turn fuel shut off valve if equipped 1 4 turn to OPEN 3 Push choke lever to CHOKE position 4 7 Let engine warm up If choke equipped Slowly adjust toward RUN position Wait until engine runs smoothly before each choke adjustment ar l ey Move throttle if equipped to FAST Operate engine with throttle in FAST CAUTION To prolong starter life use short starting cycles 5 seconds maximum then wait one minute 5 Push rocker switch if 6 Insert key and Follow equipment manufacturers recommendations equipped to ON turn to START for charging battery TO STOP ENGINE QA ej LA 1 Move throttle if equipped to SLOW Turn key to OFF Remove key and store out of reach of children 3 Push rocker switch if equipped to OFF 10 4 y Fuel shut off Close fuel shut off valve if equipped ENGINE AND ENGINE PARTS BRIGGS amp STRATTON MAINTENANCE We recommend that you see an authorized Briggs amp Stratton Service Dealer for all maintenance and service of the engine and engine parts Use only genuine Briggs amp Stratton parts MUFFLER Replacement parts for the muffler WARNING must be the same and installed in the A7 same position as the original parts otherwise fire can occur If muffler is equipped with spark arrester screen remove screen for inspection Replace scree
Download Pdf Manuals
Related Search