User`s Manual & Operating Instructions
Contents
1. Thermostat will shut off once reached desired room temperature is Do not feel heat or air flow reached Heater is operating correctly Heater does not heat area Heater is operating correctly in front of heater it will disperse heat throughout room to heat entire space 2013 Pinnacle Products International Inc 9 Garage Heater User s Manual REMINGTON LIMITED WARRANTY Pinnacle Products International Inc warrants this heater to the original retail purchaser only to be free from defects in material and workmanship for a period of one 1 year from the date of initial purchase This product must be properly installed maintained and operated in accordance with the instructions provided Pinnacle Products International Inc requires reasonable proof of your date of purchase from an authorized retailer or distributor Therefore you should keep your sales slip invoice or cancelled check from the original purchase This Limited Warranty shall be limited to the repair or replacement of parts which prove defective under normal use and service within the warranty period and which Pinnacle Products International Inc shall determine at its reasonable discretion This warranty does not apply to products purchased for rental use This Limited Warranty does not cover any failures or operating difficulties due to normal wear and tear accident abuse misuse alteration misapplication improper installation or imprope2. User s Manual amp Operating Instructions Model Numbers REM 03 240 GH REM 05 240 GH Intertek 4006316 CONSUMER READ AND SAVE THESE INSTRUCTIONS USE THIS HEATER ONLY AS DESCRIBED IN THIS MANUAL ANY OTHER USE WARNING NOT RECOMMENDED BY THE MANUFACTURER MAY CAUSE FIRE ELECTRIC SHOCK OR INJURY TO PERSONS 2013 Pinnacle Products International Inc 668 Stony Hill Road 302 Yardley PA 19067 USA Toll Free 800 641 6996 Fax 215 891 8461 Web www remingtonheater com Email info pinnacleint com aa YY PINNACLE INTERNATIONAL 821000210 13 NEVER LEAVE HEATER UNATTENDED WHILE REMINGTON CONNECTED TO A POWER SOURCE Table Of Contents Safety Iniormaton ir reu Leu Lnuunn 1 2 Maintenance 8 Specifications and Features ees 3 Troubleshooting Guide 9 SSD esse AO NA e mntsedesietaieenssts altes 10 leet Le a a a 7 8 Safety Information AWARNING FIRE OR EXPLOSION MAY OCCUR Heater has hot arching or sparking parts inside Do not use it in areas where gasoline paint or flammable liquids are used or stored RISK OF FIRE To prevent a possible fire Do not block intakes or exhaust in any AWARNING manner Do not use on soft surfaces like a bed where openings may become blocked Heater must be kept clear of all obstructions Maintain a 3 foot minimum clearance from front and 12 inches from sides and rear Heaters must be kept clean of lint dirt and debris see maintenance instructions Pa
3. MUST BE A MARNE ATTACHED TO A JOIST WITH A MINIMUM OF TWO 2 SCREWS IN OPPOSING HOLES A WARNING If you are attaching this heater to a ceiling surface other than a wood ceiling joist and drywall please use appropriate fasteners The screws included with your heater are not intended to be used for metal joists O 2013 Pinnacle Products International Inc 6 Garage Heater User s Manual NEVER LEAVE HEATER UNATTENDED WHILE REMINGTON CONNECTED TO A POWER SOURCE Operation Operation 1 Position the fan heater so that it stands Automatic Overheat Safety Control upright on a firm level surface and at a This heater is equipped with safety internal safe distance from wet environments and heat limiting thermostat and overheat flammable objects protection circuit When a potential overheat 2 Connect the fan heater to the proper electrical temperature is reached the system will power See Grounding instructions automatically shut the heater off Page 8 and Figure 2 Thermostat Instructions 3 Set the thermostat dial to the maximum At first set the thermostat to and let the temperature heater operate with full power input When 4 The fan heater will switch on when the the room temperature reaches the required function selector dial is set to one of the three value turn the thermostat to the left until it power settings switches off The thermostat will then switch on and off Unit is Off automati
4. panel board circuit breaker WARNING or fuse box and lock or tag the panel board door to prevent someone from turning on the power while you are working on the heater When using electrical appliances basic precautions should always be followed to reduce the risk of fire electric shock and injury to persons including the following AVVARNINGI Read all instructions before AWARNING RISK OF ELECTRIC SHOCK using this heater Extreme caution is necessary when any Avoid using an extension cord because the heater is used by or near children or invalids extension cord may overheat and cause a risk of fire Do not use outdoors ALWAYS use only the electrical power voltage and frequency specified on the model plate of the heater This heater is not intended for use in bathrooms laundry areas and similar indoor locations Never locate heater where it may fall into a bathtub or other water container ALWAYS use only three prong grounded Do not use heater in wet or moist locations outlet and extension cord Always locate heater on a stable and level RF DDIG Mic NGEN USE surface ALWAYS install the heater so that it is not directly exposed to water spray rain dripping Do not place the heater against paperboard or i P ga pap water or wind low density fiberboard surfaces CAUTION HOT WHILE AWARNING IN OPERATION DO NOT TOUCH KEEP CHILDREN ANIMALS CLOTHING A
5. 6996 Model Serial Date of Purchase 2013 Pinnacle Products International Inc Serial Number Label 10 Garage Heater User s Manual E TEE eegen PINNACLE INTERNATIONAL 2013 Pinnacle Products International Inc 668 Stony Hill Road 302 Yardley PA 19067 USA Toll Free 800 641 6996 Fax 215 891 8461 Web www pinnacleint com Email info pinnacleint com
6. ND COMBUSTIBLES AWAY FROM HEATER Keep all combustible materials away from this heater Minimum Clearance From Combustibles __ REM 03 240 GH REM 05 240 GH 3 ft ER Look for this icon throughout the manual for helpful tips on how to assemble use and clean your Electric Fan Heater 2013 Pinnacle Products International Inc 2 Garage Heater User s Manual NEVER LEAVE HEATER UNATTENDED WHILE REMINGTON CONNECTED TO A POWER SOURCE Specifications Model REM 03 240 GH REM 05 240 GH 10 200 17 000 3 000 5 000 Heat Settings III 2 Specifications subject to change without notice Features REM 03 240 GH REM 05 240 GH Swivel Bracket Heater Coil Adjustment Knob Fan AAN CEE na A S Front Guard ZY Thermostat Knob Function Selector Power Light Caution Light Figure 1 2013 Pinnacle Products International Inc 3 Garage Heater User s Manual NEVER LEAVE HEATER UNATTENDED WHILE REMINGTON CONNECTED TO A POWER SOURCE Assembly Instructions What s In The Box OO 66 mm Screws 4 8 mm washers 2 Lock Washers 2 Swivel Bracket 2013 Pinnacle Products International Inc 4 Garage Heater User s Manual CONNECTED TO A POWER SOURCE T an a TT z TT lt Z D GC lt Tr I gt lt Tr D TT gt D z REMINGTON ions Instruct Assembl s gt La a Ei A
7. cally to control the room temperature Fan Runs No heating according to the preset value and keep the room temperature constant Fan Runs Half Power Heating When using the heater for the first time you may notice a slight emission of smoke This NOTE The fan will run continuously while the is guite normal and it stops after a short heater is operating time The heating element is made of steel and was coated with a layer of protective oil 5 Once the room reaches the desired during production The smoke is caused by temperature turn the thermostat dial back the leftover oil as it is heated until heating element turns off O 2013 Pinnacle Products International Inc T Garage Heater User s Manual NEVER LEAVE HEATER UNATTENDED WHILE REMINGTON CONNECTED TO A POWER SOURCE Operation Grounding Instructions REM 03 240 GH REM 05 240 GH This heater is for use on 240 or 208 volts Be sure that the electrical receptacle is of the The cord has a plug as shown in figure 2 configuration and capacity appropriate for the below No adapter is available for this blade heater configuration and none should be used The type outlet is a 240 or 208 volt grounding outlet When properly installed it provides a ground connection through the cord to the heater to protect the operator from electric shock Figure 2 Maintenance Cleaning and Maintenance The enclosure is easy to get dirty Wipe it often wit
8. ducts International Inc SHALL HAVE NO LIABILITY WHATSOEVER TO PURCHASER OR ANY THIRD PARTY FRO ANY SPECIAL INDIRECT PUNITIVE INCIDENTAL OR CONSEQUENTIAL DAMAGES Pinnacle Products International Inc assumes no responsibility for any defects caused by third parties This Limited Warranty gives the purchaser specific legal rights a purchaser may have other rights depending upon where he or she lives Some states do not allow the exclusion or limitation of special incidental or consequential damages or limitations on how long a warranty lasts so the above exclusion and limitations may not apply to you Pinnacle Products International Inc does not authorize any person or company to assume for it any other obligation or liability in connection with the sale installation use removal return or replacement of its equipment and no such representations are binding on Pinnacle Products International Inc Always be sure to specify the model number and serial number when making any claim with Pinnacle Products International Inc For your convenience use the space provided below to list this information Register Your Product Online at http www remingtonheater com Product_Registration php Locating Your Serial Number Your serial number can be found on the heater s rating label It will begin with the letters FH followed by 9 digits For Example FH120900170 Have your Serial Number ready before ne customer service at 800 641
9. ge 8 RISK OF FIRE DO NOT use heater with extension cord Plug the heater directly AWARNING into a 208 240VAC receptacle AWARNING OVERHEATING OR FIRE MAY OCCUR Do not place heater behind doors AWARNING RISK OF ELECTRIC SHOCK OR INJURY Do not run cord under carpeting Do not cover cord with throw rugs runners or similar coverings Do not route cord under furniture or appliances Arrange cord away form the traffic area where it will not cause a tripping hazard Do not operate any heater with a damaged cord or plug or after heater malfunctions or has been dropped or damaged in any manner Discard heater or return to authorized service facility for examination and or repair RISK OF ELECTRICAL SHOCK Connect to properly grounded outlets only Do AWARNING h T not insert or allow foreign objects to enter any ventilation or exhaust opening as this may cause an electric shock or fire or damage the heater Unplug heater before performing any maintenance or when not in use To disconnect heater turn control to low then remove plug from outlet WARNING NEVER SUSPEND ANY OBJECTS FROM MOUNTED HEATER CAUTION RISK OF ELECTRIC SHOCK DO NOT OPEN HEATER SHELL NO USER SERVICEABLE PARTS INSIDE 2013 Pinnacle Products International Inc 1 Garage Heater User s Manual NEVER LEAVE HEATER UNATTENDED WHILE REMINGTON CONNECTED TO A POWER SOURCE Safety Information Turn the electrical power off at the electrical
10. h a soft sponge For very dirty parts wipe with a sponge dipped in lt 122 F water Before cleaning the appliance disconnect it from the outlet and let it cool down In order to protect the enclosure don t and mild detergent then dry the heater splash water onto the heater and never enclosure with a clean cloth Be careful not to use a solvent like gasoline isoamyl acetate let the water enter the inside of the appliance toluene etc to clean the heater 2013 Pinnacle Products International Inc 8 Garage Heater User s Manual NEVER LEAVE HEATER UNATTENDED WHILE REMINGTON CONNECTED TO A POWER SOURCE Troubleshooting Locating Your Serial Number Your serial number can be found on the heater s rating label It will begin with the letters FH followed by 9 digits For Example FH120900170 Have your Serial Number ready before calling customer service at 800 641 6996 Fan stays on when heat shuts 1 Fan runs continuously while 1 Heater is operating correctly off the heater is operating 1 Fan speed stays constant 1 Heater is operating correctly Setting changes amount of heat output only Fan speed stays the same when changing settings Heating element is made of 1 Heater is operating correctly stainless steel and will not glow red to produce heat Heating element does not glow red No power to heater Check power connections connect heater to power supply Desired room temperature
11. r maintenance and service by you or any third part Failure to perform normal and routine maintenance on the heater shipping damage damage related to insects birds or animals of any kind and damage due to weather conditions are also not covered In addition the Limited Warranty does not cover damage to the finish such as scratches dents discoloration rust or other weather damage after purchase All transportation costs for the return of damaged product or parts will be the responsibility of the purchaser Upon receipt of damaged item Pinnacle Products International Inc will examine the item and determine if defective Pinnacle Products International Inc will repair or replace and return the item freight pre paid NEVER LEAVE HEATER UNATTENDED WHILE CONNECTED TO A POWER SOURCE lf Pinnacle Products International Inc finds the item to be in normal operating condition or not defective the item will be returned freight collect This Limited Warranty is in lieu of all other express warranties Pinnacle Products International Inc disclaims al warranties for products that are purchased from sellers other than authorized dealers or distributors AFTER THE PERIOD OF THE ONE 1 YEAR EXPRESS WARRANTY EXPIRES Pinnacle Products International Inc DISCLAIMS ANY AND ALL IMPLIED WARRANTIES INCLUDING WITHOUT LIMITATION THE IMPLIED WARRANTIES OF MERCHANTABILITY AND FITNESS FOR A PARTICULAR APPLICATION FURTHER Pinnacle Pro
12. wal Du ii A SA Garage Heater User s Manual 2013 Pinnacle Products International Inc NEVER LEAVE HEATER UNATTENDED WHILE REMINGTON CONNECTED TO A POWER SOURCE Assembly Instructions Tools Needed Remove heater and all packaging materials Power Drill from the shipping carton 4 mm or 5 32 in drill bit Phillips head screwdriver Stud finder wy Tip Be sure to remove the hardware J Tip Seek assistance when installing package from the Styrofoam packaging heater Ceiling Mounting Attaching Heater to Swivel Bracket 1 Locate wood stud in ceiling where heater will 1 Line up holes on swivel bracket with the be mounted holes on the heater shell 2 Use swivel bracket to mark 4 holes for 2 Attach heater to swivel bracket with drilling Be sure a minimum of 2 holes across adjustment knobs larger 8 mm washers and swivel bracket from each other will be drilled locking washers Page 5 into wood stud in ceiling 3 Pre drill 4 holes for screws AWARNING Be certain adjustment knobs 4 Attach swivel bracket to ceiling using 4 are tightened firmly to secure washers and screws attach 2 screws to heater to swivel bracket stud then turn 90 degrees to attach 2 final screws Two 2 screws must be attached to a wood ceiling joist min 1 5 If 2 remaining screws cannot be attached to a wood ceiling joist then moly toggle bolts should be used for remaining holes HEATER
Download Pdf Manuals
Related Search