PCC1287GB - DUPLEX ISSUE 5_040811
Contents
1. IMPORTANT e After installation the appliance must be tested for soundness e The gas supply input pressure to which this appliance is connected MUST not rise or fall by more than 2 5mbar butane propane from nominal when ALL appliances connected to the same supply are operated simultaneously SERVICING ALL SERVICING MUST BE CARRIED OUT BY AN APPROVED COMPETENT PERSON BEFORE ANY SERVICE WORK IS STARTED THE APPLIANCE SHOULD HAVE BEEN LEFT TO COOL AND BE DISCONNECTED AT THE MAINS SOCKET AFTER EACH SERVICE THE APPLIANCE MUST BE CHECKED FOR GAS SOUNDNESS 1 Remove appliance from housing Disconnect from gas supply 1 Open the oven door and remove the 2 screws from each side trim Carefully slide the appliance out one third and check for any possible snagging of wires or pipes If OK lift appliance out onto a suitable surface 2 Control replacement Disconnect from gas supply 1 Remove appliance from housing 2 Open the oven door and unscrew the 2 screws holding the thermostat probe in position and push the probe back out through the hole in the rear of oven Remove the retaining screws from on top and underneath the control Disconnect the inlet pipe and two burner supply pipes Remove the fittings off the old control and fit on the replacement 3 Remove the grill burner Disconnect from gas supply 1 Remove appliance from housing 2 Open the oven door Remove the three flue retaining screws two beneath the fascia panel on2. found just above the burner on the rear wall Unscrew the locknut and pull out the thermocouple from the rear of the appliance 8 Removing Drop Down Oven Door Open the door and engage catch to hook on each hinge Lift the door and pull out of front trim
3. PCC 1287 Issue 5 GB THETFORD BUILD IN APPLIANCES FOR USE WITH LIQUIFIED PETROLEUM GAS MODELS S 0G70000 Duplex Oven amp Grill S OV70000 Mk3 Oven Only USER AND INSTALLATION INSTRUCTIONS FOR USE IN GB IE FR NL BE LU ES IT NO DE DK SE WARNING e _ Only use this appliance in a well ventilated area Read the instructions before use e This appliance must be installed in accordance with the regulations in force THETFORD LIMITED UNIT 19 Oakham Drive Parkwood Industrial Estate Rutland Road Sheffield S3 9QY ENGLAND TEL 44 0 1142738157 FAX 44 0 114 275 3094 DUPLEX amp Mk3 OVEN ONLY Ly sequi oe LED INVAOYA equ LED 3NVdOMd 1equi oe 0 5 ANV LNG sequi 0 8z 0 5 ANV LNG 0 d 8 yo 4 0 82 y uoa ses SAY19 SA 19 H G M H ja en CIN B TH ea xaqana 00007AO S 0000 AO S 0000 50 S 000090 s INTRODUCTION GB This appliance is designed for cooking foods any other use is incorrect and dangerous Failure to install the appliance correctly or improper use will invalidate any warranty or liability claims This appliance must be installed in accordance with the local national and European regulations in force Particular attention shall be given to the requirements regarding ventilation Read the instructions before installing or using the appliance The appliance MUST be installed by an approved competent person Provision Of Ventil
4. ation The use of a gas cooking appliance results in the production of heat and moisture in the room in which it is installed Ensure that the kitchen is well ventilated keep natural ventilation holes open or install a mechanical ventilation device mechanical extractor hood Prolonged intensive use of the appliance may call for additional ventilation for example opening a window or more effective ventilation for example increasing the level of mechanical ventilation where present The room containing the appliance should have an air supply in accordance with local national and European standards Position This appliance must be positioned free from draughts which may affect the combustion and in a manner that will prevent the accumulation of unburnt gas When in use ensure that air vents are not inadvertently blocked or shut off IMPORTANT e Appliance should only be used with Liquified Petroleum Gas LPG Use only the Gas Pressures specified e This appliance MUST be earthed OPERATION The burners on this appliance have fixed aeration and no adjustment is required Depending on the gas being used the burners should flame as follows Propane The flames should burn quietly with a blue green colour with no sign of yellow tips Butane Normally on initial lighting a small amount of yellow tipping will occur and then slightly increases as the burner heats up IMPORTANT Before using the appliance for the first time remo
5. con toasting Trivet in low position Grilling Chops Trivet removed Slow Grilling The pan supplied with the appliance is multi functional for use either whilst grilling or when using the oven The pan handle can be removed or inserted whilst pan is in use Always remove the handle when the pan is in use The control tap on this appliance operates both the Grill and Oven burners To ensure safe operation it is not possible to operate both burners at the same time Using the Oven 1 Ensure gas supply is connected and turned on 2 Open door push in the control knob and turn anticlockwise to gas mark 9 3 Light burner with match keeping the control knob held in for 10 15 seconds for models with spark ignition the procedure is similar except burner ignited be depressing the ignition button 4 Release knob and turn to required heat setting 5 If burner has not lit within 15 seconds release knob and wait at least 1 minute before repeating operations 2 to 4 6 Place the oven shelf in the required position and close the door 7 To turn off rotate the control knob until the line on the knob is aligned with the dot on the control panel Before first time use heat the oven at gas mark 5 for 30 minutes to eliminate any residual factory lubricants open windows to assist in removal of any unpleasant smells or smoke Although the oven does heat up quickly it is recommended that a 10 minutes preheat be allowed The oven shoul
6. d reach full temperature in 15 20mins The shelf has a raised bar to prevent dishes making contact with the back of the oven and to allow good circulation at the rear of the oven To remove a shelf pull forward until it stops raise at front and remove OPERATION GB Oven Temperature Control The oven temperature is controlled by a thermostatic gas tap and is variable over the range 130 C to 240 C The temperature settings on t he control knob refer to the centre of the oven and at any particular setting the oven will be hotter at the top and cooler towards the base The variation between top and centre and centre to bottom is approximately equivalent to one gas mark Care should be taken not to overload the oven ensure adequate spacing when cooking more than one item to allow free circulation of heat WARNING Never cover slots or holes in the oven or cover a shelf with materials such as aluminium foil Doing so restricts airflow and may cause carbon monoxide poisoning Do s And Don ts DO read the user instructions carefully before using the appliance for the first time DO allow the oven to heat before using for the first time in order to expel any smells before the introduction of food DO clean the appliance regularly DO remove spills as soon as they occur DO always use oven gloves when removing food shelves and trays from the oven DO check that controls are in the off position when finished DO NOT allow children nea
7. e located on top rear of flue cover Lift off the flue cover Lever off starlock washers retaining the grill burner 4 Spark Ignition where fitted Disconnect from gas supply 1 Remove appliance from housing 2 Grill burner Remove the screw from the bracket and spark ignition probe in the top of the burner Trace the electrode wire back to the generator and pull off the connector Oven burner Trace the electrode wire up the back of the cooker to the generator and pull off the connector Unscrew the fixing screw on the spark electrode inside the oven cavity then carefully pull the electrode from inside the oven and remove Piezo Electric Generator Remove all electrode wires Remove the lock nut and carefully remove from panel SERVICING GB 5 Grill burner injector No62 Disconnect from gas supply 1 Remove appliance from housing 2 Release injector holder from bracket disengage the grill pipe from the control and remove the injector 6 Oven burner injector No59 Open the oven door and unscrew the burner retaining screw slide the burner to the left and lift out The injector is exposed to the right hand side of the cut out Unscrew the injector 7 Thermocouple replacement Disconnect from gas supply 1 Remove appliance from housing 2 Grill burner Unscrew the thermocouple from the control Unscrew the nut at the burner Oven burner Unscrew the thermocouple from the control Inside the oven cavity the thermocouple is
8. erviced by an approved competent person in accordance with the local and National European standards in force Failure to install the appliance correctly could invalidate any warranty or liability claims and lead to prosecution Particular attention shall be given to the requirements regarding ventilation Read the instructions before installing or using this appliance Ventilation This appliance is suitable for installation into Holiday Homes Touring Caravans and Boats In all cases the national standards with regard to ventilation for the particular vehicle into which the appliance is to be installed must be adhered to The European Standard EN1949 Specification for the installation of LPG systems in leisure and other road vehicles specifies appliances be installed in accordance with the manufacturer s instructions including the adequate provision to avoid the accumulation of un burnt gases We recommend a floor vent venting to the outside with minimum size 130mm maximum 2000mm which should be baffled to prevent direct draughts to the appliance Location of Appliance This appliance maybe installed in a kitchen kitchen diner but NOT in a room containing a bath or a shower LP gas appliances must not be fitted below ground level e g ina basement Position The performance of this appliance meets the requirements of the European Standard for Domestic Cooking Appliances EN30 which specifies a maximum allowable temperature ri
9. r the cooker when in use Turn pan handles away from the front so that they cannot be caught accidentally DO NOT allow fats or oils to build up in the oven trays or base DO NOT use abrasive cleaners or powders that will scratch the surfaces of the appliance DO NOT under any circumstances use the oven as a space heater DO NOT put heavy objects onto open grill and oven doors Leaks If a smell of gas becomes apparent the supply should be turned off at the cylinder IMMEDIATELY Extinguish naked lights including cigarettes and pipes Do not operate electrical switches Open all doors and windows to disperse any gas escape Butane Propane gas is heavier than air any escaping gas will collect at a low level The strong unpleasant smell of gas will enable the general area of the leak to be detected Check that the gas is not escaping from an unlighted appliance Never check for leaks with a naked flame leak investigation should be carried out using a leak detector spray MAINTENANCE This appliance needs little maintenance other than cleaning All parts should be cleaned using warm soapy water Do not use abrasive cleaners steel wool or cleansing powders When cleaning the burner ring it is essential to ensure that the holes do not become blocked The control knobs are a push fit and can be removed for cleaning INSTALLATION GB Regulations and Standards In your own interest of safety it is law that all gas appliances are installed and s
10. se of the furniture into which the appliance is installed of 65 C above the ambient temperature To ensure compliance with the standard it is important the installation follows the dimensions as shown in this manual ALL combustible materials such as curtains and shelves must be kept well clear of the appliance and their installation should meet all relevant local and national European standards in force Fixing The appliance can be front or side fixed holes are provided for either installation method Fixing screw positions are located in the side trims and accessed by opening the oven door IMPORTANT e If it is not possible to install the appliance as per our recommendations refer to Spinflo by Thetford for guidance Construction materials all cooking appliances become hot during use It is important the installer verifies the furniture construction material is suitable for the application i e Plastic materials used in the construction may have a softening point lower than the maximum allowable temperature rise specified in the European Standard EN30 INSTALLATION GB Gas Connection The 8mm gas inlet is located to the rear of the appliance Prior to connection remove the plastic protection plug from the fitting The appliance MUST be connected using metal pipe manufactured from either copper seam welded steel seamless steel or stainless steel which complies to the requirements of EN1949 rubber tubing MUST NOT be used
11. ve all accessories and packing in the grill and oven including any surface protection film ie plastic coating Clean all interior surfaces with hot soapy water to remove any residual protective covering of oil and rinse carefully OPERATION GB WARNING The grill MUST only be used with the grill door open The heat deflector below the fascia should be pulled out prior to lighting the grill Never adjust the heat deflector position without using hand protection ie oven gloves When cooking always ensure young children are kept away Using the Grill 1 Ensure gas supply is connected and turned on 2 Open door push in the control knob and turn clockwise to full rate large flame 5 3 Light burner with match keeping the control knob held in for 10 15 seconds models with Spark Ignition the procedure is similar except burner ignited by depressing the ignition button 4 Release knob and turn to required heat setting 5 If burner has not lit within 15 seconds release knob and wait at least 1 minute before repeating operations 2 to 4 6 To turn off rotate the control knob until the line on the knob is aligned with dot on the control panel Before first time use heat the grill for 20 minutes to eliminate residual factory lubricants open windows to assist in removal of any unpleasant smells or smoke Recommended positions for the reversible grill pan trivet Trivet in high position Grilling Sausages Steak Ba
Download Pdf Manuals
Related Search