DURO-BEAM DIVING BOARD LA MESA/LOS ARCOS - Inter-Fab
Contents
1. 10 Los Arcos Exploded View amp Parts List 174 Paver Kit MOMO ex la aceia a cha nt Ax ERE S n URS ARAS S Te Article 5 Extracted from ANSI NSPI 5 2008 13 18 Pages for Notes an aia SANA ER 19 20 Inter Pab Warranty iss nu wid e aia ve c Ro e ed wit o DBLM LAIM Rev 12 09 BK DB INSTALL 4 INSTALLATION MANUAL LA MESA LOS ARCOS SAFETY FIRST This Inter Fab diving board and stand shall be installed only by a professional swimming pool contractor or with the direct supervision of a licensed professional engineer or architect Diving boards may be installed only on residential inground swimming pools properly designed for their use Diving boards that are improperly installed can be very dangerous to the user resulting in possible serious head and or spinal column injury including the paralysis or death of the user It is very important that this diving board and or stand be installed only on a pool that is built in strict accordance with the American National Standard for Residential Inground Swimming Pools ANSI NSPI 5 2008 and in strict accordance with the included INTER FAB RESIDENTIAL POOL SPECIFICATIONS TABLE 2 Under no circumstances can this diving board and or stand be installed on any above ground or on ground swimming pool In addition to the above standard and referenced table these ins2. MIN MAX HEIGHT IMPORTANT Los arcos NOMINAL rch hee TE DISTANCE FROM OVERHANG OF BOARD BOARD END OF BOARD PLUS OR ABOVE PART FORWARD JIG BOLT THESE DIMENSIONS LENGTH 5 FORWARD JIG BOLT MINUS 3 WATER ARE ACCURATE ONLY WA HOW FOR VERTICAL POOL WALLS TYPICALLY GUNITE CONSTRUC TION WITH LESS THAN A 3 RADIUS TO THE POOL FLOOR DUE TO THE VARYING SIZES OF OTHER POOLS TYPICALLY VINYL LINER CON STRUCTION PLEASE CONTACT CUSTOMER SERVICE FOR PROPER JIG PLACEMENT 1 800 737 5386 Cannot Put 8 diving board on a type pool S E E i DB LM LAIM Rev 12 09 BK DB INSTALL 7 INSTALLATION MANUAL LA MESA LOS ARCOS FIG C DURO BEAM JUMP BOARD n FULCRUM paene A M Pce DB6 70 25 17 85 12 00 4 00 30 00 19 32 DB8 94 00 17 25 12 00 4 00 40 00 19 32 117 50 17 25 12 00 52 00 19 32 NOTE 10 board not available for Los Arcos stand 10 board only applicable for the La Mesa stand in accordance with these installation instructions FIG D LA MESA LOS ARCOS JIG Yellow Jig Caps 2 Red Jig Cap 1 BOLT REBAR SIDE VIEW lt q B TABLE 6 JIG DIMENSIONS 6 La Mesa Los Arcos 14 00 1 2 X 6 Carriage 8 La Mesa Los Arcos 6 50 22 00 1 2 X 6 Carriage 10 La Mesa 6 50 29 50 1 2
3. IM Rev 12 09 BK DB INSTALL 11 INSTALLATION MANUAL LA MESA LOS ARCOS PAVER KIT INFO SELECTED DIVING PRODUCTS When installing an Inter Fab diving board and base set up using a paver kit you must ensure that all standard requirements for a diving board and base installation are met The diving board and base set up must be compatible with the type of pool on the intended installation and all ANSI NSPI 2003 requirements must be met Figure 1 illustrates the standard minimum concrete pad recommended for all Inter Fab diving board and base set ups which is 4 wide x 8 long x deep Figure 2 shows an example side view of a paver jig used in a paver installation Pavers can be a maximum of 3 thick Pavers must be mechanically attached to the concrete pad using a setting material such as mortar or thinset for example that is no thicker than 3 8 Hefer to Figure 3 to determine how much of the jig needs to be exposed above the final deck surface You will need to factor in the thickness of your paver 3 MAX and the thickness of your setting material 3 8 MAX for your individual installation Inter Fab Inc will not be responsible for damage to pavers caused by drilling or mechanically attaching to concrete pad Refer to paver manufacturer s specific installation instructions before beginning Recommended Minimum Example of a Paver Jig in Relationship to Concrete Pad Concrete Area for Diving Bases SIDE VIEW WI S
4. ON THE JUMP BOARD AT A TIME WITH A MAXIMUM WEIGHT OF 250 LBS DB LM LA M Rev 12 09 BK DB INSTALL 9 INSTALLATION MANUAL LA MESA LOS ARCOS FIG E LA MESA BASE EXPLODED VIEW 11 10 4 5 CD CT pt ta EI c 6 Ss 12 if 8 6 b m 7 0 m 4 TID 2 LAMB shown LAM8 LAM10 TABLE 8 PARTS LIST HARDWARE NOTE Use a small dab of BITS UTS anti seize lubricant included on all bolt threads COMPONENT DESCRIPTION DBEWW 6 Duro Beam White w White Top Tread amp Hdw Kit LAM6 6 La Mesa Fiberglass Diving Base HARDWARE LM J6 6 La Mesa Los Arcos Mounting Jig TIGHTENING H 1 2 BLK WASH 1 2 x 2 Black Rubber Washer SCHEDULE H 1 2 RED WASH 1 2 x 2 Red Rubber Washer E Secure Stand to Jig with 55 1 2 LOC WA 1 2 Lock Washer S S 55 1 2 NUT 1 2 13 Hex Finish Nut S S Anchor Hex Nuts at 40 45 FT LBS H SS 1 2 F WAS 1 2 USS Flat Washer S S H 1 1 2 WHT CAP 750 x 1 1 2 White UV Nut Cap H SS 5 C BOLT 1 2 13 x 5 Carriage Bolt S S Secure Board to Stand with H WHT WAS CAP LF White Washer Cap Mounting Hex Nuts at 20 25 LM FP La Mesa Los Arcos Rubber Fulcrum Pad FT LBS NOTES DB6WW diving board shown in exploded view for illustration purposes Must be purchased separately Other
5. Pools Each of these dimensions must be met or exceeded Installation of a diving board of any type on a pool that does not meet or exceed each of the minimum specifications as provided on page 5 including but not limited to the slope requirement is in direct violation of this manufacturer s instructions and the 2003 Standard and can result in serious injury or death Installation of this La Mesa Los Arcos Dive Stand and or Duro Beam Diving Board is limited to Hesidential Inground Pools only A 6 diving board can only be installed on a 6 dive stand an 8 diving board can only be installed on a 8 stand a 10 diving board can only be installed on a 10 stand Inter Fab Duro Beam Diving Boards are designed for use on fixed fulcrum dive stands Installation on any variable fulcrum dive stand is strictly prohibited Comply with local government regulations for Residential Inground Swimming Pools if they exceed the ANSI NSPI 5 2003 Standard for Residential Inground Swimming Pools When installing any Duro Beam Diving Board to any dive stand you must ensure the board is mounted with the correct distance from the board mounting bolt holes to the fulcrum See Table 5 Board Dimensions and Fulcrum Settings on page 8 Head carefully pages 13 18 of this installation manual which contain portions of the ANSI NSPI 5 2003 Standard for Residential Inground Swimming Pools ensure that you understand Figure 3 and Table 1 provided in the ANSI NSPI 5 200
6. WATER ENVELOPE ANSI NSPI 5 2003 MINIMUM DEPTHS MINIMUM WIDTHS MINIMUM LENGTHS AT POINT AT POINT BETWEEN POINTS o TYPE Als c o Alas clo was CD DE WE 0 DIVING EQUIPMENT PROHIBITED 6 0 7 8 VARIES 6 0 28 9 MAX 16 0 7 6 5 0 2 9 12 0 15 0 12 0 8 0 1 amp 7 0 7 6 vanes 6 0 28 9 M 6 10 8 0 5 0 2 9 19 07 15 0 19 0 8 0 2 0 7 6 9 0 vanes 6 0 31 3 7 8 8 6 5 0 2 9 15 0 18 0 15 0 9 0 2 6 8 0 10 6 VARIES 6 0 33 8 v 86 9 0 5 0 2 9 15 0 18 0 15 0 9 0 3 0 9 0 12 0 VARIES 6 0 36 9 en CROSS SECTION AT POINT D TABLE 2 INTER FAB RESIDENTIAL POOL MINIMUM SPECIFICATIONS MAX DIVING MAX HEIGHT CROSS SECTIONAL MIN HEAD ENG Argon a MENTA CROSS SECTIONAL DIMENSIONS AT POINT B ROOM m DIVING TYPE pgL HOW F G H J K L M N SURFACES 0 DIVING EQUIPMENT PROHIBITED 608 6 JB 20 eg 5 0 4 7 25 76 60 99 245 12 8DE EJB 20 eg 3 10 4 7 25 76 68 3 9 215 12 Il 10 DB 8 JB ce eg 14475 445 7 55 8 0 87 3 115 1 75 18 40 DE 8 JB 30 es 5 105 3 10 78 e8 8 3 5 7 27 13 v_ 12 DB 8 JB 40 eg 8 2 9 115 7 95 9 0 8 25 5 27 14 Min length between points CD may vary based upon water depth at
7. X Carriage NOTE 10 jig available for La Mesa stand only DB LM LAIM Rev 12 09 BK DB INSTALL 8 INSTALLATION MANUAL LA MESA LOS ARCOS La Mesa Los Arcos Stand and or Duro Beam Diving Board INSTALLATION INSTRUCTIONS Be sure the concrete deck surrounding the anchor jig complies with the minimum dimensions as shown in Figure A on page 6 for the La Mesa stand or Figure B on page 7 for the Los Arcos stand Read and understand the ANSI NSPI 5 2003 American National Standard for Residential Inground swimming Pools and Table 1 and Table 2 on page 5 before you install the La Mesa Los Arcos Stand and or Duro Beam Diving Board The La Mesa Los Arcos Stand three bolt jig should be set in accordance with Table 3 on page 6 La Mesa stand or Table 4 on page 7 Los Arcos stand with the RED capped bolt closest to the pool The diving board must be placed on the deep end of the pool on centerline The tip of the diving board must be positioned directly over Pt A as shown on the Figures 3 on page 5 and according to the ANSI NSPI 5 2003 Standard and Inter Fab s Residential Pool Minimum Specifications Make sure the jig anchor bolts project out of the concrete deck 1 1 2 with ample concrete depth below the jig in accordance with Figure A on pages 6 La Mesa stand or Figure B on page 7 Los Arcos stand Do not install the La Mesa Los Arcos Stand and or Duro Beam Diving Board if the deck does not meet the minimum require
8. diving board options available DB LM LA IM Rev 12 09 BK DB INSTALL 10 INSTALLATION MANUAL LA MESA LOS ARCOS FIG F LOS ARCOS BASE EXPLODED VIEW 11 La 1 eo m LON 00 DRAWING REPRESENTS THE FOLLOWING PART NUMBERS LOS6 shown LOS8 TABLE 8 PARTS LIST NOTE se a small dab of KITS QTY COUNTS anti seize lubricant included on all bolt threads COMPONENT DESCRIPTION LOS6 6 Los Arcos Fiberglass Diving Base DBEWW 6 Duro Beam White w White Top Tread amp Kit HARDWARE LM J6 6 La Mesa Los Arcos Mounting Jig TIGHTENING H 1 2 BLK WASH 1 8 x 2 Black Rubber Washer SCHEDULE H 1 2 RED WASH 1 8 x 2 Red Rubber Washer Secure Stand to Jig with H SS 1 2 LOC WA 1 2 Lock Washer S S H SS 1 2 H NUT 4 2 13 Hex Finish Nut S S Anchor Hex Nuts at 40 45 FT LBS H SS 1 2 F WASH 1 2 USS Flat Washer 5 5 H 1 1 2 WHT CAP 750 x 1 1 2 White UV Nut Cap H SS 5 C BOLT 1 2 13 x 5 Carriage Bolt S S Secure Board to Stand with H WHT WAS CAP LF White Washer Cap Mounting Hex Nuts at 20 25 LM FP La Mesa Los Arcos Rubber Fulcrum Pad FT LBS mo m NOTES DB6WW diving board shown in exploded view for illustration purposes Must be purchased separately Other diving board options available DB LM LA
9. 09 BK DB INSTALL foot in 7 feet 30 cm 213 cm to the point of the first slope change as shown in figure 5 5 6 2 Changes in slope between shallow and deep areas shall be at a minimum water depth of 2 feet 9 inches 83 8 cm and be at least six feet 182 9 cm from the shallow end except as specified in 6 3 5 6 3 The slope of the floor from the point of the first slope change toward the deep end shall not exceed 1 foot in 3 feet 30 cm 91 cm SHALLOW END WATERLINE E STEEPEST ALLOWABLE MAX SLOPE SLOPE ZR a 11 MAX MORTO SCALE AM TYPE PLUMB a 6 0 MIN Figure 5 Shallow end depths INSTALLATION MANUAL LA MESA LOS ARCOS SUPPORT INFORMATION ARTICLE 5 POOL DIMENSIONS AND TOLERANCES Extracted from ANSI NSPI 2003 American National Standard for Residential Inground Swimming Pools 5 7 Shallow end water depths Water depth in the shallow area shall be a minimum of 2 feet 9 inches 83 8 cm except for those locations specified in 6 3 Shallow End Detail for Beach and Sloping Entries The water depth at the shallowest point shall not exceed four feet 121 9 cm as shown in figure 5 5 8 Manufactured diving equipment for in ground swimming pools diving board stand com bination or manufactured platform NOTE For consumer safety information warnings and education programs See appendices D E and F 5 8 1 When manufactured diving equipment is installed it shall conform t
10. 3 Standard NOTE The installation of this La Mesa Los Arcos Dive Stand and or Duro Beam Diving Board is not complete until you the installer have measured the pool as well as the diving board s height above water and the fulcrum distance to ensure they meet the Inter Fab s Residential Pool Minimum Specifications and the ANSI NSPI 5 2003 Standard for Residential Inground Swimming Pools In addition the installation of this diving board is not complete until you the installer have delivered to your customer and reviewed with your customer the Owners Manual as well as the Plan Your Dive Steer Up brochure THE DURO BEAM BOARD amp LA MESA LOS ARCOS STAND ARE A DIVING BOARD ONLY ONE PERSON AT A TIME ON THE DIVING BOARD WITH A MAXIMUM WEIGHT LIMIT OF 250 LBS DB LM LAIM Rev 12 09 BK DB INSTALL 4 INSTALLATION MANUAL LA MESA LOS ARCOS MINIMUM DIVING WATER ENVELOPE NOTE DRAWINGS ARE NOT TO SCALE Tc hella F SECTION G CROSS SECTION POINT A C 2 0 WATERLINE DIVING EQUIPMENT REFERENCE DIAGRAM NOT TO SCALE MINIMUM WATER SURFACE SHAPE TIP OF BOARD ABOVE POINT A MINIMUM WIDTH LENGTH AND DEPTH DIMENSIONS FOR WATER ENVELOPE START FROM POINT A DIVING EQUIPMENT D E WATERLINE CROSS SECTION AT POINT B ALLOWA _ SLOPE M GALLO END WALL WA RE 88 BC Pu 2 3 R MAX CROSS SECTION AT POINT C TABLE 1 MINIMUM
11. 6 0 7 6 5 0 2 9 112 0 15 0 12 0 8 0 1 6 7 0 e Varies 6 0 28 9 6 10 8 0 5 0 2 9 12 0 115 0 12 0 8 0 2 0 7 6 9 0 Varies 6 0 31 3 IV 7 8 187 6 5 0 2 9 115 0 118 0 15 0 9 0 pe 8 0 10 6 Varies 16 0 133 9 V 8 6 9 0 5 0 2 9 15 0 118 0 115 0 9 0 3 0 9 0 I2 O Varies 6 0 36 9 Minimum lengths between points CD DE WE Minimum length between points CD may vary based upon water depth at point D and the slope between points C amp D Figure 3 drawings are not to scale For pool types see Glossary 5 5 Offset ledges 5 6 1 The slope of the floor from the shallow end wall towards the deep area shall not exceed 1 5 5 1 Offset ledges shall be a maximum of 8 inches 20 3 cm wide 5 5 1 1 Offset ledges located less than 42 inches 1067 mm below waterline shall be pro portionately less than 8 inches 20 3 cm wide and fall within 11 from plumb measured from the top of the waterline See figure 4 5 6 Floor slopes Floor slopes shall be reasonably uniform and comply with 5 6 1 through 5 6 3 TOP OF WALL WATERLINE TYPICAL PLUMB 42 A WALL SECTION 8 MAX OFFSET 1f MAX 1 5 SLOPE WALL ee VARIABLE es Qu SLOPE n a 8 LEDGE AT 42 X TO FLOOR BELOW WATER LEVEL REFERENCE DIAGRAM NOT TO SCALE Figure 4 Offset ledges DB LM LAIM Rev 12
12. DURO BEAM DIVING BOARD LA MESA LOS ARCOS STAND Assembly amp Installation Instructions e TUCSON A 386 FAX 520 DB LM LAIM Rev 12 09 BK DB INSTALL For Technical Support or Assistance Contact Customer Service at INTER FAB INC 3050 S ALVERNON WAY TUCSON AZ 85713 800 737 5386 or visit www inter fab com To obtain complete copies of the ANSI NSPI 5 2003 otandard for Residential Inground Pools or to obtain copies of the Plan Your Dive Steer Up or The sensible Way to Enjoy Your Inground Swimming Pool contact The Association of Pool amp Spa Professionals APSP 2111 Eisenhower Ave Alexandria VA 22314 703 838 0083 or visit www theapsp org DB LM LAIM Rev 12 09 BK DB INSTALL INSTALLATION MANUAL LA MESA LOS ARCOS TABLE OF CONTENTS wi alo cae datare s nea at a d ut mata a il a ata e intended Use INSIPUCTIONS 3 Important Notices to the Installer mata a omenie ci iei densa mata ee 4 Minimum Diving Water Envelope Information La Mesa Base 6 Los Arcos Base Placement sima as mina FAVRE ad ska S oram a taia i Duro Beam Board Dimensions amp Fulcrum Settings 8 La Mesa Los Arcos Jig Information cese a Installation INSCPUCTIONS g La Mesa Exploded View amp Parts 5
13. OL FLOOR 9 5 45 5 40 Cannot Put 8 diving board on a type pool 41 25 59 29 i 20 39 29 DUE TO THE VARYING SIZES OTHER POOLS TYPICALLY VINYL LINER CON STRUCTION PLEASE CONTACT CUSTOMER Cannot Put 10 diving board a type pool SERVICE FOR PROPER j Cannot Put 10 diving board on a type Il pool JIG PLACEMENT 51 5 75 5 1 800 737 5386 45 5 39 5 09 00 09 00 OQ GI G2 G2 DB LM LAIM Rev 12 09 BK DB INSTALL 6 INSTALLATION MANUAL LA MESA LOS ARCOS NOTE READ THESE INSTRUCTIONS IN THEIR ENTIRETY BEFORE ATTEMPTING THE INSTALLATION FIG B LOS ARCOS PLACEMENT SPECIFICATIONS 1 1 2 BOLT HEIGHT ABOVE DECK DECK END WATER END 1 oS u DIVING BOARD 7 5 1 d HOW i ae Imm WATER J ELA WA DECK LENGTH 8 MIN DECK THICKNESS 6 MIN JIG BOLT PATTERN DECK WIDTH 4 MIN CH 08 6 50 SS BOARD LENGTH A A e 14 m g prp A ne TOWARD POOL INTER FAB CANNOT GUARANTEE CUSTOMER S CONCRETE OR THICKNESS NOTE WHEN COPING IS USED DO NOT SET FRONT JIG BOLTS CLOSER THAN 3 FROM THE BACK EDGE OF THE COPING TABLE 4 PLACEMENT CHART ADDITIONALLY REFER TO ANSI NSPI 5 2003 American National Standard for Residential Inground Swimming Pools and to page 5 for Inter Fab Residential Inground Pool Minimum Specifications
14. a lt _ See Figure 3 Below The minimum i concrete depth shall be 6 for the diving base i concrete pad Layer of setting material to secure i CONCRETE pavers to i concrete Minimum jig depth is either CONCRETE 3 5 or 4 5 See Figure LA MESA BASE LOS ARCOS BASE LM J6 PAVER 1 2 X 8 Carriage SS WITH 8 JIG LM J8 PAVER 1 2 X 8 Carriage SS WITH 10 JIG o LM J10 PAVER 1 2 X 8 Carriage SS DURO SPRING BASE o DS J PAVER 5 8 X 10 Hex Head SS TECHNI SPRING STEEL BASE o TS J PAVER 1 2 X 10 Hex Head SS j TSF J PAVER 1 2 X 12 Hex Head SS BA J6 PAVER 1 2 X 10 Hex Head 55 WITH 8 JIG o BA J8 PAVER 1 2 X 10 Hex Head 55 CITY BASE o CITY J6 PAVER 1 2 X 8 Carriage SS Fig 3 e eS eS eS Oy Oy Cy Cy Cy Cy DB LM LAIM Rev 12 09 BK DB INSTALL 12 INSTALLATION MANUAL LA MESA LOS ARCOS SUPPORT INFORMATION ARTICLE 5 POOL DIMENSIONS AND TOLERANCES Extracted from ANSI NSPI 2003 American National Standard for Residential Inground Swimming Pools 5 Pool dimensions and tolerances 5 1 General requirements Design dimensions shall comply with specifications in this standard The pool shall be constructed to these design dimensions within the tolerances listed in 5 1 1 5 1 1 Construction tolerances There shall be construction tolerances allowed on dimensional de signs The overall length width and de
15. al pool types are shown in figure 3 and table 1 5 9 1 Location of point A Point A shall be defined as a point located on the minimum water en velopes 5 9 1 1 Point A Point A is a construc tion location nearest the deep end wall where the minimum water depth is satisfied 5 9 1 2 Point A as shown in figure 3 and table shall be the reference point of origin for all dimensions defining the minimum water envelope 5 9 2 Type 0 pool where diving is prohibited shall not be limited in width length or water depth except as specifically provided for in this standard 5 9 3 Location of equipment and pool fea tures in the minimum water envelope If the pool is designed for use with diving equipment steps pool stairs ladders underwater benches special features and other accessory items shall be located outside the minimum water envelope See figure 6 5 9 4 Typical pool design configurations Vinyl liner shotcrete fiberglass and concrete con structions shall conform to but are not limited to the typical pool configurations shown in figure 2 5 10 Stationary diving platform s and diving rock s Stationary diving platform s and diving rock s built on site shall be allowed to be flush with the wall and located in the diving area of the pool Point A shall be in front of the wall at the platform or diving rock centerline NOTE For consumer safety information warning and education programs See appendices D E a
16. he safest place to swim and a diving board installed in compliance with manufacturers instructions and the ANSI NSPI 5 2003 Standard for In ground Residential Pools is the safest place to dive from To ensure that you and your family and guests are able to safely enjoy your div ing board for many years it is critical that you follow the following instructions DO 4 10 11 18 13 14 Know the shape and depth of the pool before you dive Make sure that all family members and guests are familiar with these instructions before they use your pool and diving board Make sure that the diving board has been installed in compliance with the Assembly and Installation Instructions and with the ANSI NSPFS 2003 Standard for In ground Residential Pools This includes the shape and depth of the pool as well as the height of the diving board Enter feet first the first time Plan your path to be sure you avoid any other swimmers or objects in or under the water such as floats tires toys etc Keep your head up arms up and fully extended and steer up with your hands Practice carefully before you dive headfirst Become familiar with the diving board and its spring before diving headfirst Dive straight ahead not to the side of the board or pool Dive from the diving board only Make sure that children and non swimmers are supervised at all times Always remember that when you dive you must steer up Inspect y
17. il purchase Volleyball Volleyball Net Basketball Basketball Net and pumps are warranted for ninety 80 days from date of retail purchase The Board Fall Board Fall L LED and Board Fall fiber optic water features used for the Jump amp Splash T7 and aquaBoard products have a warranty period of one 1 year from the date of retail purchase Zoomerang slide products warranty period is one 1 year from the date of retail purchase Build Your Own Slide BYOS and Build Your Own Slide 2 BYOS 2 warranty periods are one 1 year from the date of retail purchase City 2 Slide and City Base products warranty period are one 1 year from the date of retail purchase Unless expressly stated otherwise all products manufactured by Inter Fab are for residential installation single family residence inground pool use only Inter Fab Inc expressly disclaims any and all warranties and liability arising from the installation or use of its residential products for any non residential use such as semi public public or commercial applications Products expressly manufactured for commercial installation and use will be subject to this limited warranty This limited warranty is in lieu of all other warranties whether express or implied Inter Fab Inc disclaims any warranty of merchantability or fitness for a particular use and noninfringement in relation to any of its products and Inter Fab Inc is not liable for co
18. ls 5 3 3 The walls of Type I pool when defining the 5 4 Maximum allowable wall slope minimum diving water envelope shall be plumb or outside of Type 1 water geometry See figure 3 ta 5 4 1 Maximum allowable wall slope shall not ble 1 slope greater than 11 from plumb SECTION ae ee et SYMMETRY B 20 REFERENCE DIAGRAM NOT TO SCALE MINIMUM WATER SURFACE SHAPE LR MINIMUM WIDTH LENGTH AND DEPTH DIMENSIONS FOR WATER ENVELOPE START FROM POINT A D E WATERLINE TM gr SEE FIGURE 3 FOR 29 q 2 9 SHALLOW END DETAIL ALLOWABLE W DEEP END WALL BC E SHALLOW END WALL WA PR WATERLINE WATERLINE i i 1 SYM 1 1 i i CROSS SECTION AT POINT A CROSS SECTION AT POINT B WATERLINE WATERLINE SYM i 6 R 2 3 R MAX SYM CROSS SECTION AT POINT C CROSS SECTION AT POINT D REFERENCE DIAGRAM NOT TO SCALE Figure 3 Minimum water envelope DB LM LAIM Rev 12 09 BK DB INSTALL 14 INSTALLATION MANUAL LA MESA LOS ARCOS SUPPORT INFORMATION ARTICLE 5 POOL DIMENSIONS AND TOLERANCES Extracted from ANSI NSPI 2003 American National Standard for Residential Inground Swimming Pools Table 1 Minimum water envelope Minimum depths Pool at point Minimum widths at point type A B jC D A B C D WA AB BC O Manufactured diving equipment is prohibited I 6 0 7 6 5 0 12 9 10 0 12 0 0 0 18 0 1 6 7 O 7 6 Varies 60 28 9 II
19. ments When finishing the deck surface maintain a level deck where the jig bolts project out so the dive stand makes uniform contact with the deck surface Allow the cement to fully cure before bolting the dive stand to the jig bolts Before bolting the dive stand to the jig bolts chisel away any excess concrete that may have built up around the jig bolts then remove the protective red and yellow rubber bolt caps Place the stand over the three jig bolts and secure according to the Hardware Instructions on pages 10 11 Tighten the Stand Anchor Hex Nuts to 40 45 FT LBS Do not over tighten Once the La Mesa Los Arcos Stand is properly secured to the three jig bolts then secure the Diving Board to the Dive Stand according to the Hardware Instructions on page 10 11 Tighten the Board Mounting Hex Nuts to 20 25 FT LBS Do not over tighten The Diving Board must be installed according the below board leveling instructions LEVEL The top surface of the diving board from the deck end to m ET the tip end shall be level or have an upward slope of 5 8 PTR R MOX PER FODT per foot maximum Elevation difference shall not exceed 3 3 4 6 Board or 5 8 Board or 6 1 4 10 Board from the deck end to the tip of the board There shall be DECK END NC WATER END no downward slope towards the water The slope shall be AAR measured using a level as shown in the graphic to the left ONLY ONE PERSON
20. mp Spa Professionals APSP 2111 Eisenhower Ave Alexandria VA 22314 703 838 0083 or visit www theapsp org DB LM LAIM Rev 12 09 BK DB INSTALL 18 INSTALLATION MANUAL LA MESA LOS ARCOS NOTES DB LM LAIM Rev 12 09 BK DB INSTALL 19 INSTALLATION MANUAL LA MESA LOS ARCOS NOTES DB LM LAIM Rev 12 09 BK DB INSTALL 20 INSTALLATION MANUAL LA MESA LOS ARCOS LIMITED WARRANTY Inter Fab Inc will repair or replace at its option any product manufactured by Inter Fab Inc that fails during the applicable warranty period because of a manufacturing or material defect provided that the defect is not the result of improper installation improper use or care negligence alterations or modifications to the product or natural accidents acts of God The applicable warranty period for products manufactured by Inter Fab Inc is three 3 years from the date of retail purchase except as specified below Echoes of Nature products are individually handcrafted and painted by skilled artisans and as a result dimensional differences and color variations are normal and are not a basis for warranty coverage The warranty period for pumps sold with the Echoes of Nature products is three 3 years from the date of retail purchase Water Sports sports equipment warranty periods are as follows Volleyball Poles Basketball Poles Basketball Rim and Basketball Backboard are one 1 year from date of reta
21. nd F INSTALLATION MANUAL LA MESA LOS ARCOS SUPPORT INFORMATION ARTICLE 5 POOL DIMENSIONS AND TOLERANCES Extracted from ANSI NSPI 2003 American National Standard for Residential Inground Swimming Pools Figure Top view examples of accessory equipment and parul features prohibited in the water envelope DB LM LAIM Rev 12 09 BK DB INSTALL 17 INSTALLATION MANUAL LA MESA LOS ARCOS SUPPORT INFORMATION ARTICLE 5 POOL DIMENSIONS AND TOLERANCES Extracted from ANSI NSPI 2003 American National Standard for Residential Inground Swimming Pools 5 10 1 The maximum height of the stationary diving platform or diving rock above the waterline shall be as follows Pool Type I 42 inches 106 7 cm Pool Type II 42 inches 106 7 cm Pool Type III 50 inches 127 0 cm Pool Type IV 60 inches 152 4 cm or Pool Type V 69 inches 175 3 cm 5 10 2 Stationary diving platform s and div ing rock s shall not be permitted on Pool Type O 5 10 3 The diving equipment manufacturer shall specify minimum headroom above water 5 11 Swimming pool slides 5 11 1 Slides where installed shall be in stalled in accordance with manufacturer s specifica tions NOTE For consumer safety information warn ings and education programs see appendices D E and F To obtain complete copies of the ANSI NSPI 5 2003 Standard for Residential Inground Pools contact The Association of Pool a
22. nsequential incidental or specific damages This warranty is limited to the repair or replacement of the manufacturing or material defect or refund of the original purchase price whichever is less at the sole option of Inter Fab Inc and expressly does not cover any labor or reinstallation expenses related to the replacement of any and all Inter Fab products This limited warranty shall be the sole and exclusive remedy of irrespective of whether the claims are made in contract tort warranty law equity or by statue This warranty is to the original purchaser of the product only Inter Fab s limited warranty is neither transferable nor portable from consumer to consumer The effective coverage date begins at the date of retail purchase Product owner or representative must notify Inter Fab Inc or its wholesale agent in writing giving a full description of the nature of the product defect or failure along with proof of purchase serial number s of the product and photos within thirty 3O days of the expiration of the applicable warranty period Inter Fab Inc reserves the right to physically inspect damaged or defective products or components to determine the cause of the damage or defect prior to authorizing repair or replacement of its products 3050 5 Alvernon Way Tucson AZ 85713 520 790 7040 800 737 5386 Fax 520 790 7127 inter fab com DB LM LAIM Rev 12 09 BK DB INSTALL 21
23. o the specifications set forth in 5 8 through 5 9 and shall be located in the deep area of the pool so as to provide the minimum dimensions as shown in 5 9 5 8 1 1 Manufactured diving equipment shall not be installed on Type 0 pools 5 8 2 Diving equipment Diving equipment shall be designed for swimming pool use and shall be installed in accordance with the manufacturer s speci fications 5 8 2 1 Diving equipment installation and use instructions shall be provided by the diving equipment manufacturer and shall specify the mini mum water dimensions required for each diving board and diving stand combination They may refer to the water envelopes type of their choice by dimen sionally relating their products to Point A on the wa ter envelopes as shown in figure 3 and table 1 5 9 1 through 5 9 3 5 8 2 2 Diving equipment shall be per manently labeled and affixed to the diving equipment or jump boards and shall include but not be limited to manufacturer s name and address date of manufacture minimum water envelope required for each diving board and diving stand combination and maximum weight limitations of the user as specified by the board manu facturer DB LM LAIM Rev 12 09 BK DB INSTALL 16 5 8 2 3 Diving equipment shall have slip resisting tread surfaces 5 9 Figure 3 contains suggested drawings and dia grams for minimum water envelope for swimming pools designated type I V Individu
24. our diving board base and stand on a regular basis at least twice a year and keep them in proper repair Contact your dealer installer or Inter Fab 800 737 5386 with any questions or concerns about the safe use of your diving board DON T lls 2 10 Vs 12 13 Don t drink and dive Dont install this or any diving board on an above ground pool or dive into an above ground pool from any surface Never install any Inter Fab diving board on a variable fulcrum dive stand Dont dive into a pool from anyplace not specif ically designated for diving Never dive into the shallow portion of any pool Dont dive across the width of the pool or to the sides of the pool Don t Run and dive Dont engage in horseplay in or around the diving board or pool Dont use your diving board as a trampoline Dont do a back dive Backyard pools are not built for that type of activity Dont try fancy dives Keep the dives simple Dont dive into or through objects or toys such as inner tubes Don t swim or dive alone Dont use a diving board or stand or base that is rusted or worn out or in poor repair DB LM LAIM Rev 12 09 BK DB INSTALL INSTALLATION MANUAL LA MESA LOS ARCOS IMPORTANT NOTICES TO THE INSTALLER The specifications found on page 5 of this manual represent the minimum water envelope required by Inter fab and by the ANSI NSPI 5 2003 Standard for residential Inground Swimming
25. point D and the slope between points C amp D ABBREVIATIONS DBL Diving Board Length DB Diving Board JB Jump Board HOW Height Over Water DB LM LAIM Rev 12 09 BK DB INSTALL 5 INSTALLATION MANUAL LA MESA LOS ARCOS NOTE READ THESE INSTRUCTIONS IN THEIR ENTIRETY BEFORE ATTEMPTING THE INSTALLATION FIG A LA MESA PLACEMENT SPECIFICATIONS 1 1 2 BOLT HEIGHT ABOVE DECK DECK END WATER END i DIVING BOARD 7 HOW i CONCRETE b SLAB WATER p S WA DECK LENGTH 8 MIN JIG BOLT PATTERN DECK THICKNESS 6 MIN 6 50 DECK WIDTH 4 MIN BOARD LENGTH A B 14 8 22 10 29 5 TOWARD POOL INTER FAB CANNOT GUARANTEE CUSTOMER S CONCRETE OR THICKNESS NOTE WHEN COPING IS USED DO NOT SET FRONT JIG BOLTS CLOSER THAN 3 FROM THE BACK EDGE OF THE COPING TABLE 3 PLACEMENT CHART ADDITIONALLY REFER TO ANSI NSPI 5 2003 American National Standard for Residential Inground Swimming Pools and to page 5 for Inter Fab Residential Inground Pool Minimum Specifications DISTANCE FROM MIN MAX HEIGHT IMPORTANT ts miae gu PART FORWARD JIG BOLT THESE DIMENSIONS LENGTH FORWARD JIG BOLT MINUS 3 WATER 0 WA HOW ARE ACCURATE ONLY FOR VERTICAL POOL 45 5 50 BUNTE GONSTHDE 45 5 eo TION WITH LESS E zo THAN A 3 BADIUS TO 2 ER THE PO
26. pth shall be limited to a tolerance of plus or minus 3 inches 7 6 cm All other dimensions shall be limited to a toler ance of plus or minus 2 inches 5 1 cm unless otherwise specified 5 2 Perimeter shape No limits are specified for shape of pools except that consideration shall be given to shape from the standpoint of circulation of the swimming pool water and safety to the user 5 3 Walls requirements 5 3 1 Walls in the shallow area and deep area of the pool shall not slope greater than 11 1 5 slope e POINT B WATER LEVEL TYPICAL MINIMUM CROSS SECTION ratio to a transition point The transition point shall not be less than 2 feet and 9 inches 83 8 cm below the waterline See figure 1 5 3 2 As shown in figure 2 at the depths of a and b the walls are permitted to join the floor TOP OF WALL WATER LINE PLUMB WALL SECTION 2 9 Minimum 41 MAX REFERENCE DIAGRAM NOT TO SCALE Figure 1 Maximum allowable wall slope TYPICAL GUNITE CONCRETE CONSTRUCTION POOLS WITH 11 WALLS eceesceseee TYPICAL VINYL LINER POOL CONSTRUCTION REFERENCE DIAGRAM NOT TO SCALE Figure 2 Typical pool design configurations DB LM LAIM Rev 12 09 BK DB INSTALL INSTALLATION MANUAL LA MESA LOS ARCOS SUPPORT INFORMATION ARTICLE 5 POOL DIMENSIONS AND TOLERANCES Extracted from ANSI NSPI 2003 American National Standard for Residential Inground Swimming Poo
27. tallation instructions provided by Inter Fab Inc must be diligently followed It is also important that any and all warnings provided with the diving board be strictly adhered to and posted in a conspicuous location If not provided or they are misplaced please purchase warning signs from your pool contractor or professional pool supply store and post them in a location that the users of the diving board can clearly see FOR RESIDENTIAL INGROUND SWIMMING POOL USE ONLY NO COMMERCIAL PUBLIC OR SEMI PUBLIC USE IS ALLOWED ONLY ONE PERSON ON THE DIVING BOARD AT ONE TIME MAXIMUM WEIGHT 250 LBS Plan Your Dive PLAN YOUR DIVE STEER UP Back Arched Arms Extended Head and Hands Up a DIVING TIPS Even the safest equipment must be used properly Inter Fab promotes safe diving by offering these tips on the proper use of your diving board always dive into water that meets depth requirements with arms extended be aware of the bottom and the walls of the pool avoid collisions with pool toys and floats and instruct your pool users to always steer up When you begin your dive you must get ready to steer up As you enter the water your arms must be extended over your head hands flat aiming up Hold your head and arch your back Hold Diving Form Steer up for a safe dive DB LM LAIM Rev 12 09 BK DB INSTALL 2 INSTALLATION MANUAL LA MESA LOS ARCOS INTENDED USE INSTRUCTIONS A pool is t
Download Pdf Manuals
Related Search