79 Series Service Equipment
Contents
1. Recovery valve core removal allows recovery unit to work at maximum efficiency speeding recovery process PART NUMBERS 7982921 095 0 5 11141 0 Core Remover 7982923 85 RD 5 11142 0P Core Remover R 12 VACUUM CHARGE VALVE 79R2925 15 RD 5 11125 0P Used as a vacuum monitoring valve 4 side port to attach electronic micron vacuum gauge for greater accuracy Core remover allows evacuation and charge through an unrestricted line for increased speed and higher vacuum Core replacement tool Recovery valve core removal allows recovery unit to work at maximum efficiency speeding recovery process LCD VACUUM GAUGE amp SENSOR 79R0190 Ls RD 5 11115 0P Drop Ship Only LCD Vacuum Gauge Vacuum gauge combines thermocoupler sensor technology with advanced IC electronics for precise readings and repeatability not found with thermistor sensors or analog meters G Precision circuitry to control sensor and then translate sensor input into micron readings Provides accurate readings on job after job from 1999 to 1 micron without calibration Large high contrast digital display for easy reading Female to female coupler to connect sensor into system Powered from one D cell battery Compact design with storage case for sensor cable and hose Rugged molded case protects electronic circuitry and sensor RD 5 11116 0P 79R0195 15 Drop Ship Only Thermocouple Sensor No adjust2. SERVICE EQUIPMENT MISCELLANEOUS ORIFICE TUBE REMOVER KIT 79R1660 Designed to remove all necessary parts of complete or damaged orifice tube RD 5 11135 0P 79R4006 79R0105 SCHRADER CORE TOOL 79R8945 RD 5 12674 0P High Flow Schrader Core Remover Installer Tool PART NUMBERS 79R0105 RD 5 11143 0P 7964006 RD 5 11148 0P 7984007 RD 5 11123 0P 79RA008 RD 5 11138 0P COMPRESSOR TOOL KIT A B C D E F G H J K L M N 7983000 ADAPTERS AND COUPLER Adapt female quick connect to male thread Knurled fittings for easy connection 79R4007 mme 79R4008 Adapter acme female hex to 13mm male R 134a low side R 12 to R 134a Coupler Converts Standard R 12 flare to R 134a 4 acme thread Adatpter R 12 female QD to 4 male flare Adapter R 134a 14 female QD to male ACME RD 5 5620 0P Deluxe Sanden Tool Kit For 50 508 and SD 510 COMPRESSORS Contains the following Seal Seat Remover 0 Ring Remover Clutch Holder Seal Remover Installer Seal Protector Clutch Face Installer Oil Dipstick Internal Snap Ring Plier External Snap Ring Plier Handle Puller Fingers Puller Pilot Puller Plate Assembly Bearing Remover Installer PAGE 580
3. Service Equipment SERVICE EQUIPMENT 79R0010 0 5 7105 0 88 79R0020 RD 5 7106 0M 10 per package WARNING CONTAINS R 12 A SUBSTANCE WHICH HARMS PUBLIC HEALTH AND ENVIRONMENT BY DESTROYING OZONE IN THE UPPER ATMOSPHERE TO REMOVE R 12 FROM THE A C SYSTEM USE SERVICE EQUIPMENT CERTIFIED TO MEET THE REQUIREMENTS OF S A E J2209 OR J1990 REFRIGERANT CAUTION LABELS PLEASE NOTE When servicing R 12 and R 134a systems the tools that come in contact with the refrigerant such as gauge sets charging equipment and recovery recycle equipment must be dedicated to one refrigerant or cross contamination may occur AIR CONDITIONER RED DOT CORP SEATTLE WA MODEL NO MAXIMUM OPERATING CHARGE Lb OF REFRIGERANT MAXIMUM OIL CHARGE OZ COMPLIES WITH SAE J639 REFRIGERANT UNDER HIGH PRESSURE SYSTEM TO BE SERVICED BY QUALIFIED PERSONNEL ONLY IMPROPER SERVICE METHOD MAY CAUSE INJURY CONSULT SHOP MANUAL FILL OUT AND ATTACH THIS LABEL TO VEHICLES REFRIGERANT RETROFIT LABELS 79R0030 10 per package RD 5 10908 0P NOTICE RETROFITTED to R 134 a Retrofit procedure performed to SAE Jii CAUTION System bo he serviced by qualified personnel Retrofit Date Name of company or individual performing retrofit Address City State Tel Lubricant Type Auxiliary Label Location PAGE 562 Zip R 134a Charge Lubricant Amount 10 per package CAUTION CONTAINS R 134a AVOID BREATHING A
4. 206 to 0 to 827 kPa Bold high visibility dials have colored temperature scales for easy reading Flutterless technology and surge protection minimize needle pulsation Accuracy 3 2 3 percent Diameter 2 1 2 64 mm Connections 1 3 NPT PAGE 569 SERVICE EQUIPMENT TANKS amp HOSES REFRIGERANT RECOVERY TANKS R 134A TANKS Drop Ship Only Drop Ship Only FOR R 134A amp R 12 For R 134a refrigerant Refillable refrigerant tanks are D O T approved for safety Come with the valving necessary for recovery and recycling Distinctive blue exterior clearly identifies these tanks as R 134a equipment Used to store recovered refrigerants 79R1810 and 7981820 are equipped with 3 pin Brad Harrison connector Gray and yellow color coding Y valve allows liquid vapor collection Cylinders equipped with a protective collar and handle Float switch plug 2 4 Pressure rating 2400 kPa 350 PSI PART NUMBERS 7961810 85 RD 5 11120 0P Cylinder with Float 30 pound N 79R 1815 RD 5 11121 0P Cylinder with Y Valve no float 30 pound 7961820 9 RD 5 11122 0P Cylinder with Float 50 pound 7961825 89 RD 5 11083 0P Cylinder with Y Valve no float a 50 pound REFRIGERANT IDENTIFIER LLL NN 79R3591 LS TICS PEPE 30 Ib Tank with float switch 134a 7961912 LS RD 5 11563 0P d spectrometer detect aA a and held micro infrared spectrometer detector cont
5. 60 Hz 79R4030 Ls RD 5 11140 0P Vacuum Pump 220V 50 Hz Rated as free air displacement pump Large sight glass for easier monitoring electronic gauge then provides more precise Rugged metal construction with no plastic to Large oil drain valve for quicker draining readings crack or fall off Longer heat dissipation fins for a cooler running Gas ballast speeds evacuation and keeps oil Oil reservoir port has a wide mouth for easier unit cleaner neater filling doubles as an pump exhaust Low operating temperature improves efficiency Tethered caps stay with the unit and is threaded to attach garden type hose for and vacuum exhausting to remote location Low profile on off switch avoid breakage Drop Ship Only Large oil reservoir helps reduce operating Vacuum indicator gauge at pump intake temperature and dilute corrosive contaminants fitting shows evacuation progress ata glance Pump rating 1 5 cfm Field rating 15 microns Intake 1 4 flare and 2 ACME thread Motor 1 horsepower at 1725 rpm Internal capacitor thermal overload Temperature Rise 104 F 40 C Voltage single phase 115 Volt 60 Hz or 220 Volt 50 Hz Oil capacity 24 oz 0 7 liter Dimensions 101 2 x 5 x 91 4 26 67 x 12 95 x 23 37 cm 4 0 CFM VACUUM PUMPS 79R4040 Ls RD 5 11118 0P Vacuum Pump 115V 60 Hz 7984050 15 RD 5 11119 0P Vacuum Pump 230V 50 Hz Rated as free air displacement pump Large sight glass for easier monitoring electronic gauge
6. 79R4587 RD 5 13221 0P 8 oz Pag Oil Use with R 134a Sanden Compressors 150 viscosity 6 per case 79R4595 RD 5 8062 0P R 134a and R 12 12 oz Ester oil Use with CCI Compressors 12 per case Retro Fix Il MISCELLANEOUS DIAL THERMOMETER FIN COMB DYE 79R1150 RD 5 10209 0P 7981255 RD 5 11113 0P 7985025 RD 5 7956 0P 2 dial face with 0 to 220 F range Multi head tool straightens 8 9 10 12 14 and For Pag Oil 15 fins per inch Six per pack Works on radiator evaporator coils and 79R5030 y RD 5 8039 1M aluminum finned heat exchangers For Ester Qil Breaks down easily for tool box storage Six per package 4 EU e Compact 10 cm 4 length 7 79R5035 RD 5 13225 0P For Ester Oil INFRARED 5 Six per package THERMOMETER KD 7981153 5 RD 5 11525 0P 3 AIR CONDITIONING SERVICE MANUAL 79R5901 RD 5 11043 0P RedDOT L7 REFRIGERATION TAPE RN 7984400 RD 5 4058 360P 2 wide by tape P cn elect used in covering o VET exposed A C fittings 30 foot roll WIRE LOOM CONDUIT 7960125 RD 5 9569 96P 7980225 RD 5 7357 96P 0 250 inside diameter black wire loom conduit 0 250 inside diameter gray wire loom conduit 79R0138 RD 5 4762 96P 7980241 RD 5 5562 96P 0 375 inside diameter black wire loom conduit 0 413 inside diameter gray wire loom conduit 79R0150 RD 5 5905 96P 0 500
7. RD 5 11226 0P 79R9516 RD 5 8895 0P 79R1525 RD 5 7732 0P Hydraulic Hand Pump and 6 Hose with HYDRAULIC CYLINDER Male Quick Disconnect Retro Fit Hydraulic Cylinder for 79R1510 Bubble Crimp Kit with Female Quick Disconnect PAGE 564 SERVICE EQUIPMENT RECOVERY RECYCLING AND RECHARGING SYSTEMS R 134A 7960120 LS RD 5 11580 0P Drop Ship Only Air Conditioning Recovery Recycling Unit R 134a 110V 60 Hz Simplest easiest to use air conditioning service One touch air purge eliminates non units on the market today helps technicians condensables in system meet today s tough service standards One touch oil drain after every service tells Operation is quick and efficient lowers air how much oil is needed to keep compressor conditioning service costs fully lubricated Easy to operate just connect quick connect Automatic tank full and high pressure shut offs couplings to vehicle and push Recovery Recycle Shock resistant scales for accurate charging switch unit completes recovery and recycle Single pass filtering system process Built in manifold gauge set Built with quality components such as 1 2 Moisture indicator hp oil less compressor new advanced shock Tank refill adapter E scale dual protected solenoids and Modular design for easy repair Large pneumatic tires Premium hoses approved to SAE2197 standard Fully factory tested Built in accessory and t
8. SIZE SHOWN ACTUAL SIZE RD 5 4693 0M Connector Housing 5 Contact Male Spade Switch Body SHOWN 6076 OF ACTUAL SIZE RD 5 8591 0M Housing Connector 3 Contact Male Weatherpak Shroud SHOWN 6076 OF ACTUAL SIZE RD 5 5661 0M Housing Connector Contact Female Weatherpak Tower SHOWN 60 OF ACTUAL SIZE RD 5 3975 0M Terminal Female 56 Series Spade Receptacle 14 gauge SHOWN ACTUAL SIZE RD 5 5078 0M RD 5 5992 0M RD 5 6317 0M RD 5 9017 0M Terminal Female Terminal Female Terminal Female Terminal Female Weatherpak with Barrel End 280 Series with Square End Micro Pack 100 Metripak 280 with Square Tang 14 gauge 14 gauge contact 14 gauge SHOWN ACTUAL SIZE SHOWN ACTUAL SIZE SHOWN ACTUAL SIZE SHOWN ACTUAL SIZE cS Ep yY tL din CONNECTORS RECEPTACLES TERMINALS SEALS LOCKS HOUSINGS Use the RD numbers to order replacement parts Login to www rdac com with your password For additional Electrical Connector Assembly Kits order RD 5 11966 0P ELECTRICAL CONNECTOR ASSEMBLY TOOL KIT The perfect companion to Red Dot s Connector Assembly Kit these are the only tools you ll need to assemble all of the connectors shown above 79R3535 RD 5 12140 0P CC RD 5 12137 0P RD 5 12135 0P RD 5 12139 0P RD 5 12138 0P RD 5 12136 0P RD 5 12134 0P 579
9. inside diameter black wire loom conduit 0 500 inside diameter gray wire loom conduit 7980250 RD 5 7171 96P fi 79R0258 RD 5 55908 96P 0 625 inside diameter gray wire loom conduit K Limited to stock on hand PAGE 577 SERVICE EQUIPMENT MISCELLANEOUS R 134A RETRO KITS R 12 SERVICE abaran CCI Tecumseh Retro kit Applications 79R4004 Ls RD 5 11124 0P Allis Chalmers Autocar Brockway Caterpillar Chevy RE TR OFIT K IT Air Conditioning Adapter GMC Deutz Allis Diamond Rio Fiat Allis Ford FS 6 gm Sa amma Y Used to service air conditioning systems on Nippondenso 6E171 use 4379 RD599830 retro fit kit E Loans Ford Sperry Ford Tractor Fox River Freightliner Hesston peo mt SEA Ka 1991 and later GM vehicles HFI International Harvester IH Navistar J l Case John Deere Long Kenworth Mack Marmon Massey Ferguson New Holland New Idea Avco Oliver Peterbilt Steiger Versatile Volvo White GM Western Star White Farm All with compressor model Climate Control York AMT 2 Tecumseh eo 79R4605 POE Sanden Seltec Zexel Retro kit Applications AMENS Caterpillar Chevy GMC Deutz Allis Euclid Fiat Allis eto SEALANT Allis Chalmers Ford FS 6 Nippondenso 6E171 use Ar Conditioning Syst OR 79R6700 RD 5 7242 0P RD 5 9983 0P retro fit kit Ford Sperry Ford Tractor BRL OZ 954 MU 4 Freightliner Hesston HFI Hino International Harvester 3 Adhesive
10. then provides more precise Rugged metal construction with no plastic to Large oil drain valve for quicker draining readings crack or fall off Longer heat dissipation fins for a cooler running Gas ballast speeds evacuation and keeps oil Oil reservoir port has a wide mouth for easier unit cleaner neater filling doubles as an pump exhaust Low operating temperature improves efficiency Tethered caps stay with the unit and is threaded to attach garden type hose for and vacuum exhausting to remote location Low profile on off switch to avoid breakage Drop Ship Only Large oil reservoir helps reduce operating Vacuum indicator gauge at pump intake temperature and dilute corrosive contaminants fitting shows evacuation progress at a glance Pump rating 4 cfm Field rating 15 microns Intake 1 4 and 2 ACME thread TN 0 Motor 1 3 horsepower at 1725 rpm CR Internal capacitor thermal overload Temperature rise 104 F 40 C Voltage single phase 115 Volt 60 Hz or 230 Volt 50 Hz Oil capacity 0 7 liter 24 oz Overall dimensions 15 1 4 x 63 2 x 12 38 7 x 17 1 x 30 5 cm Weight 29 5 Ibs 13 4 kg K Limited to stock on hand PAGE 572 79R4060 Vacuum Pump 115V 60 Hz Rated as free air displacement pump Rugged metal construction with no plastic to crack or fall off 011 reservoir port has a wide mouth for easier neater filling doubles as an pump exhaust and is threaded to attach garden type hose for exhausting to remote l
11. 107 09 RD 5 11145 0P Blue Flex Hose 4 7980109 595 RD 5 11146 0P Red Flex Hose 4 K Limited to stock on hand PAGE 578 MISCELLANEOUS ELECTRICAL CONNECTOR ASSEMBLY KIT Plugs for Compressor Clutches Blower Motors Switches Relays Heater A C Units Acutators and more gt suu ccc 7983532 0 5 11966 0 26 Finally kit to fit that hard to find plug assembly RedDot can with the right housing terminal seal and lock Electrical Connector acm that looks and fits like the sealed OE connector Assembly Kl J Here s what you get 0 0 ERE RD 5 3992 0M RD 5 10424 0M 0 5 3977 0 RD 5 5077 0M RD 5 6061 0M RD 5 5073 0M RD 5 5933 0M RD 5 8634 0M Connector Male Bullet Connector Male Bullet Receptacle Spade Seal Blue Lock Housing Connector Housing Connector Housing Connector Sealed 1 contact Sealed 1 contact Sealed 1 contact Weatherpak Metripak Metripak TPA 2 Contact Male 3 Contact Female 1 Contact Female 14 16 Gauge 12 gauge 14 16 gauge 12 gauge Blue Weatherpak Shroud Weatherpak Tower Metripak with Square End SHOWN 60 OF ACTUAL SIZE SHOWN 6076 OF ACTUAL SIZE E ug RD 5 8778 0M SHOWN ACTUAL SIZE SHOWN ACTUAL SIZE SHOWN 60 OF ACTUAL SIZE eil SHOWN ACTUAL SIZE RD 5 4438 0M RD 5 5746 0M RD 5 3979 0M RD 5 5988 0M RD 5 8635 0M SHOWN ACTUAL SIZE Hg SHOWN ACTUA
12. 2 8 oz IH Navistar Isuzu Iveco J l Case John Deere Kenworth Mack Marmon Mercedes New Holland Nissan U D HD Tek Farm Oliver Peterbilt Steiger Versatile Volvo White GM c ZEE Western Star White Farm All with compressor model Sanden Zexel Diesel Kiki 79R4615 RD 5 8961 0P GM A6 R4 DA6 Retro kit Applications Caterillar Deutz Allis Fiat Allis Allis Chalmers Chevy GMC J l Case John Deere Long Massey Ferguson Navistar New Idea Avco Mack Terex All with compressor model GM A6 Frigidaire 79R4625 RD 5 9983 0P Nippondenso Retro kit Applications 1980 to current Ford cars pickups and vans All with compressor models FS6 HR980 FX15 FS10 Frigidaire A6 Nippondenso 6E 6P 10P 10PA Sanden 505 507 FOR CONVERTING R12 A C SYSTEMS TO ENVIRONMENTALLY SAFE HFC 134A Kits include the minumum components necessary to convert from an R12 system to R134a system Kit includes 0 rings and gaskets retro charging adapters R12 charging port eliminator cap retrofitted identification label and 802 of Retro A C Ester Oil NOTE RETRO KITS ARE NOT ENDORSED BY THE COMPRESSOR MANUFACTURERS FLEX HOSES 79R0107 used on low pressure side of R 12 air conditioning recovery systems 79R0109 used on high pressure side Easy retrofit of existing hoses to provide ball valve capability Flexible hose between valve and fitting makes hook up in tight areas much easier PART NUMBERS 7980
13. 5 ft 7983172 095 RD 5 11099 0P R 134a Charging Hose Red 457 cm 15 ft K Limited to stock on hand PAGE 566 SERVICE EQUIPMENT SERVICE EQUIPMENT RECHARGE OIL PUMP SEALANT FILTER RD 5 11117 0P 79RO115 RD 5 14063 0P 7981730 Ls 2u Trap Sealant Filter System Used to replace oil in air conditioning system or compressors after oil This rugged filter cartridge connects in line has been removed between a vehicle and any service equipment Easily works with system pressures up to 2070 kPa 300 PSI to protect refrigerant supply recovery system and Includes bottle with calibration marks hose and low oil separators side R 134a coupler Can be used for R 12 systems use a regular charging hose with 74 inch flare fittings Volume per stroke 1 5 ounces System pressures up to 2070 kPa 300 PSI Holds 16 ounces REFRIGERANT FILTER amp PREFILTER SERVICE PARTS FOR 7980120 85 RD 5 11087 0P Air Conditioning Recovery Recycling Unit R 134a 110V 7960130 85 RD 5 11089 0P Air Conditioning Recovery Recyding Unit R 134a 220V n li V TEM 7960101 Ls RD 5 11081 0P Refrigerant Filter Capacity 41 cubic inches Color GRAY Dimensions 3 89mm diameter by 9 241cm overall length Features Hi tech design captures large volumes of sealant oil sludge and other contaminants while still filtering effectively without plugging Maintenance is fast and simple with a clean out d
14. C REFRIGERANT AND LUBRICANT VAPOR OR MIST EXPOSURE MAY IRRITATE EYES NOSE AND THROAT TO REMOVE R 134a FROM A C SYSTEM USE SERVICE EQUIPMENT CERTIFIED TO MEET THE REQUIREMENTS OF S A E J2210 IF ACCIDENTAL SYSTEM DISCHARGE OCCURS VENTILATE WORK AREA BEFORE RESUMING SERVICE ADDITIONAL HEALTH AND SAFETY INFORMATION MAY BE OBTAINED FROM REFRIGERANT AIR CONDITIONER RED DOT CORP SEATTLE WA MODEL NO MAXIMUM OPERATING CHARGE Lb OF REFRIGERANT 2 MAXIMUM OIL CHARGE 02 COMPLIES WITH SAE J639 CAUTION REFRIGERANT UNDER HIGH PRESSURE SYSTEM TO BE SERVICED BY QUALIFIED PERSONNEL ONLY IMPROPER SERVICE METHOD MAY CAUSE INJURY CONSULT SHOP MANUAL FILL OUT AND ATTACH THIS LABEL TO VEHICLES SERVICE EQUIPMENT E Z CLIP FITTINGS amp TOOLS 79R8920 RD 5 10717 0P im 7988930 RD 5 10739 0P 6 12 Connecting Tool Hose Cutter amp Blade maximum hose 0 D 2 79R8926 79R8931 TEZDZTT 16 Connecting Tool Replacement Blade for 7988930 above TOOL KIT STEEL FIELDCASE RD 5 10718 0P 79R8916 RD 5 11372 0P Includes 100 each Clips 6 8 10 12 50 each Cages 6 8 10 12 50 each O Rings 6 8 10 12 100 each O Ring Nipple 6 8 10 12 Connecting Tool 79R8920 Hose Cutter 79R8930 2 Replacement blades for Hose Cutter 79R8915 Includes 20 each Clips 6 8 10 12 10 each Cages 6 8 10 12 Connecting Tool 79R8920 Hose Cutter 79R8930 Replacement blade for Hose Cut
15. L SIZE RD 5 5076 0M RD 5 5989 0M Receptacle Bullet Receptacle Bullet Connector Male Spade Seal Gray Lock Housing Connector Housing Connector Housing Connector Sealed 1 Contact Sealed 1 contact Sealed 1 contact Weatherpak Metripak Metripak TPA 2 Contact Female 2 Contact Male Contact Male 14 16 Gauge 0 156 dia 12 Gauge 0 180 dia 14 16 gauge 14 18 gauge Volvo Paccar Case OEM Weatherpak Tower Metripak 280 Metripak 280 HD SHOWN ACTUAL SIZE SHOWN ACTUAL SIZE SHOWN ACTUAL SIZE SHOWN ACTUAL SIZE Black SHOWN 60 OF ACTUAL SIZE SHOWN 60 OF ACTUAL SIZE SHOWN 60 OF ACTUAL SIZE SHOWN ACTUAL SIZE i RD 5 5074 0M RD 5 5990 0M RD 5 6191 0M RD 5 8231 0M RD 5 9081 0M RD 5 5660 0M RD 5 6318 0M RD 5 9080 0M Terminal Male Terminal Male Terminal Male with Pin End Terminal Male Lock Push in Housing Connector Housing Connector Connector Housing Weatherpak 280 Metripak 280 with Blade End 14 16 gauge Metripak 280 with Flat Pin End HD Caterpillar OEM Male Weatherpak Female Flat MicroPack 100 2 Contact Female I pin with Blade End 14 gauge SHOWN ACTUAL SIZE 14 gauge Green HD Shroud IHC 6 conductor HD Caterpillar OE SHOWN 60 OF ACTUAL SIZE SHOWN ACTUAL SIZE SHOWN 6076 OF ACTUAL SIZE SHOWN ACTUAL SIZE 14 gauge SHOWN ACTUAL SIZE SHOWN ACTUAL
16. TIBLE WITH R12 34a amp RIZ Pun CARAT az ment Combines proven technology with user friendly features Santoprene holster provides protection and a comfortable grip Gooseneck probe is 16 long wraps onto the back for storage sensing tip fits into the recessed slot Other features include audible and visual leak indicators volume control and sensitivity selection for most refrigerants including R 134a new blends and substitutes DROPSHIP ONLY PAGE 575 SERVICE EQUIPMENT MISCELLANEOUS REFRIGERANT OIL 79R4550 RD 5 5916 0P 79R4563 RD 5 9635 0P ONLY 128 oz Ester Oil Plastic Bottle 100 viscosity MINERAL OIL 1 quart 4 per case Quality wax free compressor oil for air conditioning systems Printed calibrations to facilitate measured pouring Viscosity 500 S S U 100 F 6 per case AA RedDOT p rx 4 106 79R4580 RD 5 7103 0P 79R4561 MEAE 8 0z SP15 Pag Oil Use with R 134a Sanden 12 oz Ester Oil Plastic Bottle 100 viscosity Compressors 221 viscosity 6 per case 6 per case SANT dDOT ur SP 15 PREMIUM STMTHETE uy HF s 100 aree eren Saas 79R4585 RD 5 7166 0P 32 oz Pag Oil Use with R 134a Zexel Seltec 7984562 WAAR Diese Kiki Compressors 46 viscosity 32 oz Ester Oil Plastic Bottle 100 viscosity 6 per case 6 per case o cni na m a x intret PAGE 576
17. aminated refrigerants and digitally displays the 73 _ that can readily identify and measure the percentage of air and alerts you with audible and 7961914 15 RD 5 11561 0P percentage of purity of R 134a R 22 and R 12 visual alarms for flammable hydrocarbons 30 Ib Tank only 134a with 98 accuracy It can also detect blends and Operates on 12 volt DC Includes analyzer hose WRAP AROUNDHEATER 79R1800 15 RD 5 11114 0P Wrap Around Heater 115V Used to heat 30 50 and 125 pound refrigerant cylinders Maintains an even temperature for constant positive pressure that speeds transfer of LI E refrigerant for a complete charge every time 5 5 Expandable wraps around 30 50 and 125 pound refrigerant tanks Thermostat controlled K Limited to stock on hand PAGE 570 79R3178 Ls Coupler chrome with blue anodized body low side to 14 mm Couplers interface with R 134a service ports Quick easy connect disconnect SERVICE EQUIPMENT SERVICE COUPLERS RD 5 11102 0P 7 a Control valve allows access to system even at working pressures Integral safety sleeve holds coupler securely to service port High flow characteristics R 12 AIR CONDITIONING CHARGING HOSES Proven performance Double barrier protection for R 12 and R 134a Nylon permeation barrier meets U L requirements for R 12 R 134a R 22 and R 503 refrigera
18. l capabilities for automated economical charging Charging module hooks to scale with coiled cord Simple 3 button operation Use with all refrigerants Hold resume mode for switching supply tanks in mid charge Automatic hold if refrigerant flow stops Extends solenoid life Schrader valve prevents backflow through solenoid Power pack eliminates battery draw during charging Refrigerant tank not included eq 0 to stock on hand MANIFOLD GAUGES MANIFOLD GAUGES 7983120 LS RD 5 11104 0P Manifold Assembly R 134a 79R3140 15 RD 5 11085 0P Manifold Assembly R 12 N Used to check pressure in R 134a and R 12 cooling Sliding double O ring pistons with non rotating design systems reduces wear and extends N Bold easy to read gauges large bold numbers and service life colored scales are easy to read Fast acting valve only 1 2 turns for full flow Removable Lexan crystals resist breakage SERVICE PARTS Gauge cases are color coded red and blue 79R3135 RD 5 11136 0P Piston Pressure tested for reliability Forged brass body with metal valve handles for durability Surge protector and silicone dampened movement helps minimize needle pulsation for easier more accurate readings 79R3137 RD 5 11137 0P Handle Group 79R3125 Ls RD 5 11105 0P Manifold Gauge Red R 134a 0 to 500 PSI 0 to 3447 kPa 7983127 S s Manifold Gauge Blue R 134a 30 to 0 to 120 PSI
19. let filter to protect from dirty air conditioning systems Easy use two hose setup and on the fly auto purge Recovery capabilities Vapor and Liquid applications Compressor Oil Filled Hermetic Dimensions w x xh 14 7 x12 x 15 x 36cm x 32cm x 38cm Refrigerants R 12 and R 134a Voltage 115V 60 Hz single phase Recovery rate Liquid 4 lbs 2 kg per minute maximum Vapor 1 Ibs 0 5 kg per minute maximum Weight 25 105 11 kg PART NUMBERS 7963165 85 RD 5 11091 0P Yellow R 12 Charging Hose 7961810 85 RD 5 11120 0P Refrigerant Cylinder 30 Ib 7960160089 RD 5 11101 0P R 134a Recovery 79R3175 9 RD 5 11094 0P Yellow R 134a Charging Hose ADDITIONAL PARTS FOR 79R0165 7961820 85 RD 5 11122 0P Refrigerant Cylinder 50 Ib 7983162 095 RD 5 11086 0P R 12 Charging Hose Red 457 cm 15 ft 7983164 05 RD 5 11088 0P R 12 Charging Hose Blue 457 cm 15 ft 7983166 85 RD 5 11090 0P R 12 Charging Hose Yellow 457 cm 15 ft 7983161 85 RD 5 11093 0P R 12 Charging Hose Blue 244 cm 8 ft 7983163 85 RD 5 11092 0P R 12 Charging Hose Red 244 cm 8 ft ADDITIONAL PARTS FOR 79R0160 7961820 85 RD 5 11122 0P Refrigerant Cylinder 79R3173 E RD 5 11095 0P R 134a Charging Hose Blue 244 cm 8 ft 7983171 05 RD 5 11096 0P R 134a Charging Hose Red 244 cm 8 ft 7983176 05 RD 5 11097 0P R 134a Charging Hose Yellow 457 cm 15 ft 7983174 05 RD 5 11098 0P R 134a Charging Hose Blue 457 cm 1
20. ments or warmup Stays calibrated after on off switching and long evacuations J Automatic ambient temperature compensation Automatic battery compensation Replaceable thermocouple sensor with inch flare no calibration required Comes with 182 cm 6 ft long sensor cable K Limited to stock on hand PAGE 574 HEAVY DUTY RETROFIT ADAPTER KIT 79R8940 RD 5 9986 0P SERVICE EQUIPMENT MISCELLANEOUS A C FLUSH VACUUM PUMP OIL COMPRESSOR OIL 79R4650 RD 5 10206 0P RD 5 11327 0P INJECTOR 128 ounce 1 gallon Use with 79R4010 79R1710 RD 5 8291 0P P percas Promotes internal R134a sealing for good Adding oil to air vacuum and absorbs conditioning compressors i D sarei bm process The refrigerant Qoo Regular oil changes charge is wasted and some ae promote longer disassembly is required vacuum pump life 79R1700 and 79R1710 is used in conjunction with a e gauge manifold assembly pi Solvent Based It utilizes the pressure o differential from the high to the low side of the pe E system to inject 2 oz of oil meas OUI into the unit dd udin 79RAG55 LEAK DETECTOR OIL DIPSTICK 7963576 15 RD 5 11365 0P RD 5 11568 0P ounce 1 quar 4 per case i Heated accuprobe electronic leak Sanden Oil Dipstick ES detector rednor E A PEHE Pics Efi i SOC ANI PREMIUM Solvent Based Solution COMPA
21. nts Moisture barrier provides improved resistance to moisture contaminates expensive refrigerant SealRight fittings immediately trap refrigerant in hose when disconnected 45 end allows easier connection in tight areas Gaskets resist deterioration from R 12 and R 134a refrigerants and oils PART NUMBERS 7983162 85 RD 5 11086 0P 7983164 85 RD 5 11088 0P 7983166 5 X RD 5 11090 0P 7983165 85 5 11091 0 7983161 85 5 11093 0 7983163 85 RD 5 11092 0P K Limited to stock on hand Red 457 cm 15 ft Blue 457cm 15ft Yellow 457 cm 15 ft Yellow 244 cm 8 ft Red high 244 cm 8 ft Blue low 244 cm 8 ft TANKS amp HOSES Retrofit R 12 Vacuum Pump to R 134a R 134A AIR CONDITIONING CHARGING HOSES 4 hoses for R 134a refrigerant Acme fitting meets SAE requirements Double barrier protection Threads 1 2 Acme female 14 mm Acme male PART NUMBERS 7983175 85 RD 5 11094 0P 7983173 85 5 11095 0 7983171185 5 11096 0 7983176 85 RD 5 11097 0P 7983174185 5 11098 0 7983172 85 5 11099 0 7963180 RD 5 14064 0P 79R3182 RD 5 14065 0P Yellow 244 cm 8 ft Blue 244 cm 8 ft Red 244 cm 8 ft Yellow 457 cm 15 ft Blue 457 cm 15 ft Red 457 cm 15 ft Blue 914 cm 30 ft Red 914 cm 30 ft PAGE 571 VACUUM PUMPS amp ACCESSORIES 1 5 CFM VACUUM PUMPS 7984020 Ls RD 5 11139 0P Vacuum Pump 115V
22. ocation Large oil reservoir helps reduce operating temperature and dilute corrosive contaminants Pump rating 7 cfm Field rating 25 microns Intake 14 flare and 7 ACME thread Motor 7 horsepower at 1725 rpm Internal capacitor thermal overload Temperature Rise 104 F 40 C Voltage single phase 115 Volt 60 Hz or 220 Volt 50 Hz Oil capacity 28 oz 0 8 liter Dimensions 16 14 x6 x 11 12 41 28 x 15 24 x 23 5 cm SERVICE EQUIPMENT VACUUM PUMPS amp ACCESSORIES 7 CFM VACUUM PUMPS RD 5 14061 0P Large sight glass for easier monitoring Large oil drain valve for quicker draining readings Longer heat dissipation fins for a cooler running Gas ballast speeds evacuation and keeps oil unit cleaner Low operating temperature improves efficiency Tethered caps stay with the unit and vacuum Low profile on off switch to avoid breakage Vacuum indicator gauge at pump intake fitting shows evacuation progress at a glance electronic gauge then provides more precise Drop Ship Only K Limited to stock on hand PAGE 573 SERVICE EQUIPMENT VACUUM PUMPS amp ACCESSORIES R134a 3 IN 1 VALVE FOR VACUUM CHARGE RECOVERY CORE TOOL Used as a vacuum monitoring valve 4 side port to attach electronic micron vacuum gauge for greater accuracy Core remover allows evacuation and charge through an unrestricted line for increased speed and higher vacuum Core replacement tool
23. ool storage box Vacuum timer allows technician to set time and two stage vacuum pump automatically pulls a deep vacuum Easy to set LCD display simply scroll to correct charge and push charge switch system quickly receives refrigerant Large 75 mm 3 5 in gauges allows technician to easily monitor air conditioning system SPECIFICATIONS Recovery tank One 50 pound Dimensions h x w x d 53 x 22 x27 63 x 68 x 134 cm Weight 120 Ibs 54 kg Vacuum Pump Two stage 6 cfm Hose length 15 ft 4 5 m ACME female x 13 mm male adapter SERVICE PARTS T 1 79R0107 79R0101 79R4006 79R0109 796010119 RD 5 11081 0P Refrigerant Filter 7984006 FJ RD 5 11148 0P 74 Female x 7 Male Acme Refill Adapter R 134a 79R0107 19 RD 5 11145 0P Blue Flex Hose 7 7980109 RD 5 11146 0P Red Flex Hose 4 K Limited to stock on hand PAGE 565 SERVICE EQUIPMENT SERVICE EQUIPMENT PORTABLE RECOVERY SYSTEM 79RO160 R 134a LS Drop Ship Only pes RD 5 11101 0P p Quickly recover contaminated known or unknown refrigerants including mixtures and blends Perfect for scavenger work or to protect recover recycle equipment and valuable refrigerant supply Pump straight liquid refrigerant at up to 4 Ibs minute vapor at 1 Ib minute Very durable oil less compressor direct drive and permanently lubricated cylinder walls Reliable and lightweight Built in 200 mesh in
24. rain and when necessary easy filter replacement K Limited to stock on hand PAGE 567 SERVICE EQUIPMENT CHARGING SCALES DIGITAL ELECTRONIC CHARGING SCALE 7980170 LS Drop Ship Only Manual Refrigerant Charging Scale Battery Powered Large heavy duty platform and oversized strain gauge bridge for accuracy and repeatability High quality load cell for improved accuracy Retractable 5 coiled cord for easier storage Water amp environment resistance with sealed LCD display and membrane keypad with tactile metal domes Overload Protection 1 2 bold dark numbers for easy reading outdoors Low battery indicator icon on LCD Optional AC power pack Measure imperial or metric units RD 5 11154 0P Meets UL and CE requirements Refrigerant tank Compatible with all refrigerants not included Specifications Capacity 110 Ibs 50kg Resolution 0 1 Ounce 0 01 Pound 0 01kg Accuracy 0 5 oz 0 03 Ib 0 015 kg Total Unit Weight 9 Ibs 4 1 kg Case Size LxWxH 15 2 x 12 W x3 A 394mm x 311mm x 83mm Platform Size 9 X 9 228mm X 228mm Battery 25 hours continuous use approximate Battery 9y Operating Temperature 32 F to 122 F 0 C to 50 C PROGRAMMABLE ELECTRONIC CHARGING SCALE WITH CHARGING MODULE 7980180 15 RD 5 11153 0P Drop Ship Only Automatic Refrigerant Charging Scale 110v 50 hz Same features as the 79R0170 above with additiona
25. ter EZ CLIP NIPPLE O RINGS 70R8836 70R8838 70R8831 70R8832 70R8840 RD 5 11461 0M 0 5 11462 0 RD 5 11463 0M 0 5 11464 0 0 5 13242 0 6 8 10 12 16 O Rings ship 25 per package e O CAGES amp CLIPS CAPS Packages of 10 Threaded protective caps Packages of 20 m Factory No Description Size Factory No Factory No 75R5555 RD 5 11325 0M E Z Clip Low Side Cap 6 7068806 RD 5 10709 0M 70808826 RD 5 10713 0M 75R5556 RD 5 11223 0M E Z Clip High Side Cap 8 70R8808 RD 5 10710 0M 70R8828 5 10714 0 10 70R8801 5 10711 0 70R8821 5 10715 0 12 70R8802 RD 5 10712 0M 70R8822 5 10716 0 16 79R8920 5 13543 0 563 SERVICE EQUIPMENT SERVICE EQUIPMENT CRIMP TOOLS 79R1560 RD 5 11225 0P 79R1565 RD 5 11232 0P Bubble Crimp Kit Bubble Crimp Kit with for use with Hydraulic Hand Pump and 6 Hose Air Impact Wrench Drop Ship Only CRIMP TOOL REPLACEMENT PARTS Description 79R1560 amp 79R1565 79R1510 amp 79R1515 Actuator Screw 79R1502 RD 5 7788 0P Strain Rod Set 2 79R1503 RD 5 7787 0P Latch Plate 79R1504 RD 5 7786 0P Actuator Bar 79R1505 RD 5 8481 0P Standard Crimp Die 6 79R1516 RD 5 7789 0P Standard Crimp Die 12 7981532 RD 5 11231 0P 79R1522 RD 5 7792 0P Standard Crimp Die 6 Reduced Bead Crimp Die 8 7981536 RD 5 11227 0P 79R9518 RD 5 8896 0P Reduced Bead Crimp Die 10 79R1541 RD 5 11229 0P 79R9521 RD 5 8897 0P Reduced Bead Crimp Die 6 7981546
Download Pdf Manuals
Related Search