S60 / S80 / V70 / V70 XC / XC70 / XC90 S60 / S80 / V70
Contents
1. compartment Steps 33 54 apply to the V70 e Remove the right side panel by first removing the cover and the screw in the front edge e Pull the top of the panel out until the clips release e Fold the panel inwards Lift the panel out 30776709 Page 15 of 22 Installation instructions accessories Remote start fuel driven heater Volvo Car Corporation G teborg Sweden M8504252 M8504269 ra M8503005 VolvoCar Corporation 2006 Printed in Sweden Steps 33 54 apply to the V70 e Remove the small insulation panel in front of the right hand lamp by pulling it forward at point A Steps 33 54 apply to the V70 e Remove the loudspeaker grille on the right hand D pillar panel First pry off the lower edge of the loudspeaker grille using a weatherstrip tool Pull the grille out slightly and then downwards until the hooks at the top edge release Steps 33 54 apply to the V70 e Carefully pry up the rear roof lighting using a weatherstrip tool e Unplug the connector from the roof lighting and move it aside Steps 33 54 apply to the V70 e Remove the rear headlining panel by first removing the screw in the space where the roof lighting is Pull off the front edge of the headlining to release the four clips Then pull off the rear edge until the remaining clips release 30776709 Page 16 of 22 Installation instructions accessories Remote start fuel driven heater Volvo Car Corporation G teborg S2. the marked surface on the rear end of the right hand vent Use isopropanol part no 1161721 and wipe dry Steps 33 54 apply to the V70 e Remove the protective backing tape from the other Velcro piece 30776709 Page 19 of 22 Installation instructions accessories Remote start fuel driven heater Volvo Car Corporation G teborg Sweden Steps 33 54 apply to the V70 e Press the receiver unit securely into place on the rear end of the right hand vent IMG 259227 Steps 33 54 apply to the V70 e Reinstall the panels mats and covers according to the previous steps but in reverse order Steps 33 54 apply to the V70 e Programme the software in accordance with the service information in VIDA e Test the function according to the accessory manual Steps 55 62 apply to XC90 e Remove the two centre floor hatches by lifting them slightly and then pulling them away from their mountings at the front edge If the rear centre floor hatch is equipped with grocery bag holder on the underside then the floor hatch is secured with a belt on each short side of the storage box These must be detached e Remove the storage box VolvoCar Corporation 2006 Printed in Sweden 30776709 Page 20 of 22 Installation instructions accessories Remote start fuel driven heater Volvo Car Corporation G teborg Sweden Steps 55 62 apply to XC90 Applies to cars with three rows of seats and integrated carrier bag holde
3. Installation instructions accessories Remote start fuel driven heater bo o Volvo Car Corporation G teborg Sweden Section Group Weight Kg Pounds Year Month S60 S80 V70 V70 XC XC70 XC90 Nene E IMG 258811 VolvoCar Corporation 2006 Printed in Sweden 30776709 Page 1 of 22 Installation instructions accessories Remote start fuel driven heater D 4 Volvo Car Corporation G teborg Sweden Required tools VolvoCar Corporation 2006 Printed in Sweden 30776709 Page 2 of 22 Installation instructions accessories Remote start fuel driven heater bo Volvo Car Corporation G teborg Sweden VolvoCar Corporation 2006 Printed in Sweden 30776709 Page 3 of 22 Installation instructions accessories Remote start fuel driven heater a Volvo Car Corporation G teborg Sweden l Any comments on this publication Please contact your nearest retailer Thank You se CATA ET ents euedinana snaieviscaiewnesunesnanknoainteonendncxukandesketomaeddsiantatuicntatartecerecastsvasbaasassasaesdveasasceis IMG 213320 VolvoCar Corporation 2006 Printed in Sweden 30776709 Page 4 of 22 Installation instructions accessories Remote start fuel driven heater Volvo Car Corporation G teborg Sweden INTRODUCTION e NOTE Read through the entire text before carrying out any work e The front page gives the date of this edition and the edition it replaces e The seco
4. V70 e Remove the connector 1 from the accessory electronic module AEM e Connect the corresponding connector 2 to the T cable for the thick cable harness for the accessory electronic module AEM e Connect the remaining connector 3 on the T cable to the connector that was disconnected from the accessory electronic module AEM e Reinstall the accessory electronic module AEM in its bracket Steps 33 54 apply to the V70 e Clean the marked surface on the inside of the rear side window below the panel edge using isopropanol part no 1161721 and wipe dry Steps 33 54 apply to the V70 e Press the antenna onto the inside of the window as close to the panel edge as possible e Clamp the cable at the existing cable harness IMG 259206 VolvoCar Corporation 2006 Printed in Sweden 30776709 Page 18 of 22 Installation instructions accessories Remote start fuel driven heater Volvo Car Corporation G teborg Sweden M8703709 M8703710 IMG 222287 VolvoCar Corporation 2006 Printed in Sweden Steps 33 54 apply to the V70 e Take the relay and the large clip from the kit e Press the relay into the relay holder e Press the clip into the relay holder Steps 33 54 apply to the V70 e Press the clip with the relay holder and relay inside the panel edge in front of the right hand rear lamp Steps 33 54 apply to the V70 e Carry out steps 21 27 Steps 33 54 apply to the V70 e Clean
5. driven heater Volvo Car Corporation G teborg Sweden Steps 1 32 apply to the S60 S80 e Turn the handle 1 on the right hand side through 90 e Fold the side panel inwards and lift it out M8503479 Steps 1 32 apply to the S60 S80 a Applies to the S60 Remove the weatherstrip by the C pillar panel at the rear edge of the rear door opening 4 Remove cover and screw from the top of the panel e Pull the top edge of the C pillar panel inwards into the car 1 Fold the panel forwards 2 and lift it out IMG 258823 Steps 1 32 apply to the S60 S80 Applies to the S80 e Remove the weatherstrip by the C pillar panel at the rear edge of the rear door opening e Remove the two steel clips at the front edge upper edge of the panel e Pull the top edge of the C pillar panel inwards into the car Fold the panel forwards and lift it out IMG 258824 Note When removing the C pillar panel do not grip it with your hand or with a tool in the area around the IC hatch 1 as the joint function in the hatch would then become deformed and it cannot be reset VolvoCar Corporation 2006 Printed in Sweden 30776709 Page 8 of 22 Installation instructions accessories Remote start fuel driven heater Volvo Car Corporation G teborg Sweden Steps 1 32 apply to the S60 S80 Applies to the S80 e Unthread the belt from the belt guide e Insert a hand down the side of the lower section of the side cu
6. en 30776709 Page 11 of 22 Installation instructions accessories Remote start fuel driven heater Volvo Car Corporation G teborg Sweden e Press the clip with the relay holder and relay onto the panel edge at the rear edge of the wheel arch e Remove the Velcro from the kit and cut it in the centre IMG 222282 e Press the Velcro pieces together IMG 222283 e Wash the plane surface of the receiver unit using isopropanol P N 1161721 and wipe dry IMG 222284 VolvoCar Corporation 2006 Printed in Sweden 30776709 Page 12 of 22 Installation instructions accessories Remote start fuel driven heater Volvo Car Corporation G teborg Sweden e Remove the backing from one side of the Velcro strips and press them onto the receiver unit IMG 222286 e Carefully loosen the secondary catch of the black six pin connector from the kit using a small screwdriver IMG 225262 e Connect the green GN cable from the kit to terminal 3 and the black BK cable to terminal 6 in the six pin connector e Press the secondary catch into place on the black six pin connector IMG 258843 Synchronizing the Transmitter Receiver e 1 Connect the negative battery cable in the car e 2 Put batteries in the transmitter battery compartment e 3 Connect the connector and antenna cable to the receiver unit e 4 Within 5 seconds press the OFF button on the transmitter until the LED goes IMG 258663 out Synchronizati
7. en work is completed the ignition key must be turned to position Il before reconnecting the battery negative lead Remote start fuel driven heater Note This accessory requires software unique to the car 30776709 Page 6 of 22 Installation instructions accessories Remote start fuel driven heater Volvo Car Corporation G teborg Sweden Steps 1 32 apply to the S60 S80 Applies to the S60 e Remove the cargo compartment carpet at the rear edge First turn the two handles 1 90 M8503480 Steps 1 32 apply to the S60 S80 Applies to the S60 e Pull up the front of the cargo compartment carpet Fold the front half back over the rear half of the cargo compartment carpet Steps 1 32 apply to the S60 S80 Applies to the S60 e Slide the entire cargo compartment carpet forward slightly Twist slightly to remove the carpet through the tailgate opening Applies to the S80 e Fold the cargo compartment carpet together Twist the cargo compartment carpet slightly so that it can be removed from the cargo compartment Applies to S60 S80 e Remove the carpet from the luggage compartment Steps 1 32 apply to the S60 S80 e Press the center of the clip into the lower edge of the folding side panel on the right hand left hand side until a click is heard e Remove the clips M8503478 VolvoCar Corporation 2006 Printed in Sweden 30776709 Page 7 of 22 Installation instructions accessories Remote start fuel
8. nd page shows the tools needed for the installation and the contents of the installation kit e The illustrations display the procedure in order of operation The order of operation is repeated in the text section e Cut out the text page in order to follow the illustrations and text at the same time VolvoCar Corporation 2006 Printed in Sweden Cars equipped with SRS SIPS Airbag Warning Extra care must be taken when working on cars equipped with SRS SIPS air bags This is important to prevent 1 Personal injury 2 Damage to or malfunction of the SRS SIPS system Work on the SRS SIPS systems or related components must always be carried out by an authorised Volvo workshop Is the car equipped with SRS supplemental restraint system Cars equipped with a driver s airbag have the letters SRS imprinted on the centre panel of the steering wheel Cars equipped with driver s and passenger airbags are marked with SRS on both the steering wheel centre panel and also on the dashboard close to the airbag If the car is equipped with SIPS side impact protection system a SIPS decal is marked on both the front seats Cars equipped with inflatable curtains have the marking SRS on one of the panels along the posts on the inside of the car Cars equipped with SRS supplemental restraint system also have a SRS decal on the front windscreen Do not damage the SRS wiring Do not trap fray pierce or damage the SRS wi
9. on complete e Press the receiver unit onto the Velcro on the body plate if it has loosened Note VolvoCar Corporation 2006 Printed in Sweden 30776709 Page 13 of 22 Installation instructions accessories Remote start fuel driven heater Volvo Car Corporation G teborg Sweden Tape up any cable excess from the timer relay and place next to the control module under the insulation e Clean the marked surface on the inside of the smooth panel surface using isopropanol part no 1161721 and wipe dry e Remove the protective backing tape from the other Velcro piece IMG 222287 e Press the receiver unit securely into place on the smooth surface IMG 258864 e Reinstall the panels mats weatherstrips and seats according to the previous steps but in reverse order VolvoCar Corporation 2006 Printed in Sweden 30776709 Page 14 of 22 Installation instructions accessories Remote start fuel driven heater Volvo Car Corporation G teborg Sweden M8503008 VolvoCar Corporation 2006 Printed in Sweden e Programme the software in accordance with the service information in VIDA e Testthe function according to the accessory manual Steps 33 54 apply to the V70 e Remove both the floor hatches Lift the rear edges of the floor hatches slightly Then pull the hatches backwards from their mountings Steps 33 54 apply to the V70 e Remove the right hand folding panel in the cargo
10. r on the underside of the centre floor hatch e Fold up the centre rear floor hatch 1 e Detach the two straps on the underlying panel Lift up the rear edge of the panel fold the floor hatch back and lift out the floor hatch with the panel Applies to cars with three rows of seats without an integrated carrier bag holder e Lift up the centre rear floor hatch at the rear edge and lift it out Applies to all models e Remove the right hand side floor hatch 2 Steps 55 62 apply to XC90 Applies to cars with two rows of seats e Remove the front storage box Steps 55 62 apply to XC90 e Remove the folding side panel from the right hand side of the cargo compartment R8504159 Steps 55 62 apply to XC90 e Carefully pull off the top edge of the right hand D pillar panel Continue down until the three clips have released e Remove the panel by pulling it straight up and unhook it from the side panel If applicable disconnect the connector for the D pillar loudspeaker R8504086 VolvoCar Corporation 2006 Printed in Sweden 30776709 Page 21 of 22 Installation instructions accessories Remote start fuel driven heater bo o Volvo Car Corporation G teborg Sweden Steps 55 62 apply to XC90 Steps 55 62 apply to XC90 R3702909 Steps 55 62 apply to XC90 e Carry out steps 42 54 VolvoCar Corporation 2006 Printed in Sweden 30776709 Page 22 of 22
11. ring SRS wiring has orange casing and or is plaited Steering and front suspension The contact reel in the SRS system can easily be damaged when working on the steering wheel steering shaft or steering gear Refer to the SRS supplemental restraint system Service Manual or service instructions in VIDA for information on carrying out such work This is to prevent damage SRS warning lamp If the SRS warning lamp lights after repairs have been carried out take the car to an authorised Volvo workshop SRS collision sensor control module S60 V70 00 S80 XC90 The collision sensor control module is located on the transmission tunnel 30776709 Page 5 of 22 Installation instructions accessories Remote start fuel driven heater Volvo Car Corporation G teborg Sweden VolvoCar Corporation 2006 Printed in Sweden in the centre console in front of the parking brake WARNING The air bag inflation areas must not be obstructed Never place any objects such as upholstery or accessories within these areas The panels must be able to deploy in the correct manner at the right time otherwise there is a risk of personal injury in the event of a collision WARNING The ignition must be in position 0 and the key removed from the ignition if any connector in the SRS system is to be disassembled Then wait at least one minute Then disconnect the battery negative lead before disassembling any of the connectors Wh
12. shion Release the catches while lifting the side cushion Steps 1 32 apply to the S60 S80 Applies to the S80 e First lift the bottom edge of the short end of the cushion and then the front edge and pull it off Note The cushion may be securely attached IMG 258826 e Lift out the cushion e Check that all the clips are intact If not they must be replaced Applies to S60 S80 e Lift the accessory electronic module AEM out of the bracket e Disconnect the large connector from the accessory electronic module AEM by pressing in the catch A and pulling the black handle B in the direction of the arrows until a click is heard e Disconnect the connector from the accessory electronic module AEM VolvoCar Corporation 2006 Printed in Sweden 30776709 Page 9 of 22 Installation instructions accessories Remote start fuel driven heater Volvo Car Corporation G teborg Sweden Remove e the black catch 1 holding the black switch in place in the connector by pulling in the direction of the arrow e the black switch 2 by inserting a pointed object in the hole in the other end Press out M3702530 e Connect the yellow cable from the control module to terminal 3 in the accessory electronic module AEM connector Note The numerical markings on the top and bottom of the black terminal pin are extremely small so be careful when installing the cable Reinstall M3702955 e the black swi
13. tch in the connector Lock it into place using the catch e the connector into the accessory electronic module AEM Secure using the black locking handle e Remove the connector 1 from the accessory electronic module AEM e Connect the corresponding connector 2 to the T cable for the thick cable harness for the accessory electronic module AEM e Connect the remaining connector 3 on the T cable to the connector that was disconnected from the accessory electronic module AEM e Reinstall the accessory electronic module AEM in its bracket e Clean the marked surface on the inside of the rear window below the panel edge using isopropanol part no 1161721 and wipe dry IMG 258827 VolvoCar Corporation 2006 Printed in Sweden 30776709 Page 10 of 22 Installation instructions accessories Remote start fuel driven heater Volvo Car Corporation G teborg Sweden e Press the antenna onto the inside of the window as close to the panel edge as possible e Tape the cable securely in place IMG 258828 e Pull the antenna cable through the hole for the panel s guide e Tape the cable harness at the panel to protect it against wear from the panel s guide e Secure the antenna cable 1 as illustrated IMG 258831 e Take the relay and the large clip from the kit e Press the relay into the relay holder e Press the clip into the relay holder M8703702 VolvoCar Corporation 2006 Printed in Swed
14. weden M8503010 M3702530 M3702955 VolvoCar Corporation 2006 Printed in Sweden Steps 33 54 apply to the V70 Caution Remove the panel in the following order otherwise the panel may become damaged e 1 Grip the edge and pull inward so that the clips release e 2 Detach the upper edge at the window so that the panel can pass the gas strut e 3 Pull inward to make the clips in the opening release e 4 Lift the panel upwards Steps 33 54 apply to the V70 e Lift the accessory electronic module AEM out of the bracket Steps 33 54 apply to the V70 Remove e the black catch 1 holding the black switch in place in the connector by pulling in the direction of the arrow e the black switch 2 by inserting a pointed object in the hole in the other end Press out Steps 33 54 apply to the V70 e Connect the yellow cable from the control module to terminal 3 in the accessory electronic module AEM connector Note The numerical markings on the top and bottom of the black terminal pin are extremely small so be careful when installing the cable Reinstall 30776709 Page 17 of 22 Installation instructions accessories Remote start fuel driven heater Volvo Car Corporation G teborg Sweden e the black switch in the connector Lock it into place using the catch e the connector into the accessory electronic module AEM Secure using the black locking handle Steps 33 54 apply to the
Download Pdf Manuals
Related Search