Fisher-Price N0457 User's Manual
Contents
1. up hills or run into fixed objects which can cause the wheels to stop spinning while power is still being supplied to the motors If a thermal fuse continually trips contact your local Power Wheels authorized service center Check all wires and connectors Make sure the motor harness connector is plugged into the battery and that there are no loose wires around the motors If your battery is old or if you have not followed Battery Care instructions your battery may be dead If you are unsure whether or not the battery is dead you can have it tested at your local Power Wheels authorized service center The electrical switches can become corroded due to exposure to water or moisture or can jam due to loose dirt sand or gravel Contact your local Power Wheels authorized service center for diagnosis and repair Contact your local Power Wheels authorized service center for diagnosis and repair Check all wires and connectors Make sure the motor harness connector is plugged into the battery and that there are no loose wires around the motors The built in thermal fuse may trip and shut down operation of the vehicle if the vehicle is overloaded or the driving conditions too severe Once a fuse has tripped remove your foot from the pedal and wait approximately 25 seconds before operating the vehicle again To avoid repeated automatic shutdowns do not overload the vehicle by exceeding the 65 Ibs 29 5 kg maximum weigh2. 4 screw through the large opening in the Steering column cap and through the hole in the steering column Tighten the screw 8 M78 3pr 0920 DECORATION e Before applying the labels wipe the surface of the vehicle with a clean dry cloth to remove any dust or oils e Place the labels exactly as shown in the illustrations For best results avoid repositioning a label once it has been applied to the vehicle e After applying a label rub the label firmly with a clean dry cloth to make sure the label is adhered to your vehicle Start at the center of a label and smooth towards the outer edges to remove air bubbles TOP VIEW R s ki oe 7 p q La RIGHT SIDE VIEW LEFT SIDE VIEW M78 3pr 0920 SOUND BOX BATTERY INSTALLATION e Press the tab under the back edge of the seat and lift to remove the seat AA LR6 _ 4 eves O 7 ff m Battery Compartment Door am DASH VIEW e Locate the battery compartment near the dash e Loosen the screw in the battery compartment door Remove the battery compartment door e Insert three AA LR6 alkaline batteries Hint We recommend using alkaline batteries for longer battery life e Replace the battery compartment door and tighten the screw e Fit the tab at the front of the seat into the slot near the sound button Snap the tab at the back of the seat into the slot near the rear of the vehicle e f the toy begins to operate errati
3. authorized service center nearest you please visit us on line at www powerwheels com or call 1 800 348 0751 LIMITED WARRANTY Bumper to Bumper Limited Warranty One year limited warranty from the date of purchase on the Power Wheels vehicle Six month limited warranty on the 12 volt battery For the original purchaser this one year limited warranty covers the Power Wheels ride on vehicle purchased from Power Wheels against defects in materials and workmanship The six month limited warranty applies only to the 12 volt battery included by Power Wheels with the original purchase of the vehicle This warranty covers normal use and does not cover the Power Wheels vehicle or battery if damaged by unreasonable use neglect accident abuse misuse improper service or other causes not arising out of defects in materials or workmanship Evidence of any attempt at consumer repair will void this warranty THIS WARRANTY DOES NOT COVER AND IS INTENDED TO EXCLUDE ANY LIABILITY ON THE PART OF POWER WHEELS WHETHER UNDER THIS WARRANTY OR IMPLIED BY LAW FOR ANY INDIRECT OR CONSEQUENTIAL DAMAGES FOR BREACH OF WARRANTY SOME STATES DO NOT ALLOW THE EXCLUSION OR LIMITATION SO THIS LIMITATION MAY NOT APPLY TO YOU should you need service or assistance with your vehicle during the warranty period do not return the vehicle to the store Power Wheels has provided a nationwide network of authorized service centers If there is not an
4. normal driving conditions please contact your local Power Wheels Authorized Service Center For the location of the Authorized service Center nearest to you visit us on line at www powerwheels com or call 1 800 348 0751 Important Notes e Your new battery must be charged for at least 18 hours before you use it in your vehicle for the first time e We recommend that you start charging your battery before beginning assembly of your new vehicle e The battery must be upright while charging e The charger is not a toy e Do not short circuit the battery e You do not need to remove the battery from your vehicle to recharge it e Before charging the battery examine the battery case for cracks and other damage which may cause sulfuric acid electrolyte to leak during the charging process If damage is detected do not charge the battery or use it in your vehicle Battery acid is very corrosive and can cause severe damage to Surfaces it contacts e Do not charge the battery on a surface such as a kitchen counter top which could be damaged by the acid contained inside the battery Take precautions to protect the surface on which you charge your battery e Use only a Power Wheels 12 volt charger with 12 V connector input 120 VAC 60 Hz with an output of 12 VDC 1200 mA to charge your Power Wheels 12 volt battery Adults Note Regularly examine the charger for damage to the cord plug housing or other parts that may res
5. not charge the battery longer than 30 hours e Once the battery is charged disconnect the charger connector from the battery Unplug the charger from the wall outlet The battery is now ready to be installed in your vehicle Please see the Battery Installation section on page 11 for detailed instructions on installing your battery If your battery is already installed in your vehicle simply re connect the motor harness connector to the battery Steering Steering Linkage Column not turned e Fit the end of the steering column into the hole in the Steering linkage 7 M7873pr 0920 Push Handlebar Assembly 57 Steering Column Clip l e Push down on the handlebar assembly to snap it in place e Slide the steering column clip under the steering column as Shown and push to snap in place e Turn the vehicle upright Handle Pieces TNT Gy Steering Column Cap r 6e DASH VIEW g S BOTTOM VIEW e Fit BOTH handle pieces onto the handle base on the dash of the vehicle e Carefully turn the vehicle upside down Note The handle pieces are designed to fit one way If either e Again make sure the end of the steering column is through piece does not seem to fit on one side of the handle try the the hole in the steering linkage other side e Fit the steering column cap onto the end of the e Insert the 6 x 1 2 screw into the handle assembly and tighten Steering column e Insert the 8 x 3
6. remove an exhausted battery from the vehicle Battery leakage and corrosion can damage the vehicle e Do not store the battery on a surface such as a kitchen counter top which could be damaged by the acid contained inside the battery Take precautions to protect the surface on which you store the battery e Do not store the battery in temperatures above 75 F or below 10 F e Use only a Power Wheels 12 volt battery Remember to charge the new battery for at least 18 hours before first use e Prevent the battery from moving freely inside the battery compart ment Always use the battery retainer straps to secure the battery in the battery compartment e Examine the battery charger and their connectors for excessive wear or damage each time you charge the battery lf damage is detected do not use the charger or the battery until you have replaced the worn or damaged part Disposal X e Your Power Wheels battery is a non spillable sealed lead acid battery It must be recycled or disposed of in an environmentally sound manner e Do not dispose of a lead acid battery in a fire The battery may explode or leak e Do not dispose of a lead acid battery in your regular household trash The incineration landfilling or mixing of Sealed lead acid batteries with household trash is prohibited by law in most areas e Protect the environment by not disposing of this product with household waste 2002 96 EC Check your local author
7. the daytime or a well lit area 7 Restrict your child s driving to areas that are generally level with gentle inclines or slopes 8 Do not allow your child to drive down or across a steep slope The vehicle may gain unsafe speed even if the pedal is released to stop The vehicle may tilt and tip over The wheels could lose traction causing the vehicle to slip 9 Do not allow your child to drive up steep inclines The motor may Stop and the vehicle could roll backwards at an unsafe speed 10 Never put anything near any moving parts Rotating parts such as motors gear boxes and wheels can snag fingers hair etc causing serious injury Do not allow operation of the vehicle when it is on its side or in an upside down position Do not operate the vehicle near flammable vapors gasoline paint thinner acetone liquid wax etc The vehicle s electrical switches like most electrical switches emit an internal spark when first turned on or turned off The presence of flammable liquids or vapors could cause an explosion or a fire Keep all flammable products in tightly sealed containers and away from the vehicle 12 Do not allow a child to operate the vehicle without direct adult supervision To prevent unsupervised use of the vehicle disconnect the motor harness from the battery when the vehicle is not in use To disconnect the motor harness Press the rear tab on the seat and lift to remove Pull the motor harness co
8. the fasteners on the battery retainer to hold the battery in place e Fit the tab at the front of the seat into the slot near the sound button Q e Snap the tab at the back of the seat into the slot near the rear of the vehicle M78 3pr 0920 BATTERY CARE AND DISPOSAL Care lf a battery leak develops avoid contact with the leaking acid and place the damaged battery in a plastic bag See information below for proper disposal lf acid comes in contact with skin or eyes flush with cool water for at least 15 minutes and call a physician lf acid is internally ingested give water milk of magnesia or egg whites immediately Never give emetics or induce vomiting Call a physician e Charge a new battery for at least 18 hours before first use Never charge the battery longer than 30 hours Overcharging or undercharging the battery may shorten battery life and decrease vehicle running time e After the first charge recharge the battery for at least 14 hours after each use Never charge the battery longer than 30 hours Charge the battery after each use regardless of how long the vehicle was used e The battery must be upright while charging e Do not allow the battery to run down completely before charging e Charge the battery before storing the vehicle e Charge the battery at least once per month even if the vehicle has not been used e Leaving the battery in a discharged condition will ruin it e Always
9. 1 PROBLEM POSSIBLE CAUSE Vehicle does not run Undercharged battery Charger is not working Tripped thermal fuse Loose wire or loose connectors Dead battery Electrical switch damage Motor damage Vehicle was running but Loose wire or loose connectors suddenly stopped Tripped thermal fuse 16 SOLUTION Charge the battery A new battery should have been charged for at least 18 hours before using the vehicle for the first time After first time use recharge the battery for at least 14 hours after each use Never charge the battery longer than 30 hours Check all connectors Make sure the charger connector is plugged into the battery and that the charger is plugged into the wall Make sure power flow to the wall outlet is ON There is no sure way to tell if your charger is working unless you have a volt meter If you suspect there is a problem with your charger contact your local Power Wheels authorized service center They can test your charger for you The built in thermal fuse may trip and shut down operation of the vehicle if the vehicle is overloaded or the driving conditions too severe Once a fuse has tripped remove your foot from the pedal and wait approximately 25 seconds before operating the vehicle again To avoid repeated automatic shutdowns do not overload the vehicle by exceeding the 65 Ibs 29 5 kg maximum weight Capacity or by towing anything behind the vehicle Do not drive
10. WHEELS FisherPrice e Please read this manual and save it with your original sales receipt e Adult assembly is required e Requires three AA batteries not included for sounds and light box operation e Tool needed for assembly Phillips screwdriver not included e Use only with a Power Wheels 12 Volt Lead Acid Rechargeable Battery and a Power Wheels 12 Volt Charger with type 12V connector both included Owner s Manual aS with Assembly Instructions MULCH ROUGH TERRAIN For Models M7873 and N0457 gt PS eg a Ss gt i 2 bo w TABLE OF CONTENTS Important Information onen anaua anana Warnings and Cautions o aaua aaan Battery Charging cass aciaovt abh dnahvaield a RWnrasncw acasbk abroad teeta has ASSCMDW 22500465005 eras had AGE G Us ean aiden e DECORATION at ay ce bere nals oeetnw ete Pace sue gid ei sie nels sound Box Battery Installation 0 0 0 cee eee eee 12V Battery Installation 0 0 0 0 0 ee eee Battery Care and Disposal 20 0 cece eee Safe Driving Rules 0 0 0 ccc cee eee eee IMPORTANT INFORMATION e Your new vehicle requires adult assembly Please set aside at least 30 minutes for assembly e You must charge your battery for 18 30 hours before you use your vehicle for the first time We recommend that you start charging your battery before beginning assembly Please see Battery Charging beginning on page 6 for det
11. ailed instructions e Read this manual carefully for important safety information and operating instructions before using your vehicle Keep this manual for future reference as it contains important information e Avoid using this vehicle on inclined surfaces This vehicle is appropriate for use on generally level rough terrains including hard surfaces wet and dry grass ruts gravel mulch and mud and by children 3 years of age and older e This vehicle has been pre set so it will only operate in low speed See the instructions on page 14 for high speed lock out information e Use this vehicle ONLY outdoors Most interior flooring can be damaged by riding this vehicle indoors Fisher Price will not be responsible for damage to the floor if the vehicle is used indoors e To prevent damaging the motors and gears teach your child to stop the vehicle before switching direction Do not tow anything behind the vehicle or overload it Do not exceed the maximum weight capacity of 65 Ibs 29 5 kg e f you have any questions about your Power Wheels vehicle please call our toll free service lines at 1 800 348 0751 from 9 AM to 7 PM EST Monday through Friday and 11 AM to 5 PM EST Saturday Trained customer service representatives are available to take your call in English or French Habla Espanol Si usted tiene alguna pregunta necesita asistencia llame gratis 1 800 348 0755 para los Estados Unidos Tenemos representantes que hab
12. any interference received including interference that may cause undesired operation NMB 003 Cet appareil num rique de la classe B est conforme a la norme NMB 003 du Canada utilisation de ce dispositif est autoris e seulement aux conditions suivantes 1 il ne doit pas produire de brouillage et 2 lutilisateur du dispositif doit tre pr t a accepter tout brouillage radio lectrique re u m me si ce brouillage est susceptible de compromettre le fonctionnement du dispositif M7873pr 0920 12V BATTERY INSTALLATION IMPORTANT Use only a Power Wheels 12 volt lead acid rechargeable battery Use of any other battery will damage your vehicle Make sure that you charge the battery for at least 18 hours using the enclosed Power Wheels 12 volt charger before Operating your vehicle for the first time Charge the battery for at least 14 hours after each use of the vehicle Never charge the battery longer than 30 hours Failure to follow these instructions may damage your battery and will void your warranty e Press the tab under the back edge of the seat and lift to remove the seat gt Power Wheels 12 Volt Battery Battery l Retainer Straps D L 2 gt e Unfasten the battery retainer straps to access the battery compartment e Place the battery upright in the battery compartment 11 e Plug the motor harness connector into the battery y rt P Battery 7 R a etainer Straps e Secure
13. authorized service center in your area please visit us on line at www powerwheels com or call Consumer Relations for information 1 800 348 0751 This warranty gives you specific legal rights and you may also have other rights which may vary from state to state PLEASE SAVE YOUR ORIGINAL SALES RECEIPT M78 3pr 0920 Before first time use you must charge the battery 18 hours Charge the battery immediately after each use Charge the battery once a month even if the vehicle is not used or stored Do not return your vehicle to the store We re a toll free phone call away and we can help If you are missing parts or need assistance please call 1 800 348 0751 9 AM 7 PM EST Monday through Friday and 11 AM 5 PM EST Saturday Or contact your local independently owned and operated Power Wheels Authorized Service Center For the location nearest you visit us on line at www powerwheels com Consumer inquiries should be directed to Fisher Price Inc Power Wheels 636 Girard Avenue East Aurora NY 14052 Fisher Price Inc a Subsidiary of Mattel Inc East Aurora New York 14052 U S A 2008 Mattel Inc All Rights Reserved and designate U S trademarks of Mattel Inc Fisher Price and Power Wheels are U S trademarks of Mattel Inc PRINTED IN MEXICO M7873pr 0920
14. cally you may need to reset the electronics Remove the batteries and replace them e When sounds or lights from this toy become faint or stop it s time for an adult to change the batteries Protect the environment by not disposing of this product X with household waste 2002 96 EC Check your local authority for recycling advice and facilities Europe only Battery Safety Information In exceptional circumstances batteries may leak fluids that can cause a chemical burn injury or ruin your product To avoid battery leakage e Do not mix old and new batteries or batteries of different types alkaline standard carbon zinc or rechargeable nickel cadmium e Insert batteries as indicated inside the battery compartment e Remove batteries during long periods of non use Always remove exhausted batteries from the product Dispose of batteries safely Do not dispose of product in a fire The batteries inside may explode or leak e Never short circuit the battery terminals e Use only batteries of the same or equivalent type as recommended e Do not charge non rechargeable batteries e Remove rechargeable batteries from the product before charging e f removeable rechargeable batteries are used they are only to be charged under adult supervision FCC Statement United States Only This equipment has been tested and found to comply with the limits for a Class B digital device pursuant to Part 15 of the FCC Rules These limits ar
15. e designed to provide reasonable protection against harmful interference in a residential installation This equipment generates uses and can radiate radio frequency energy and if not installed and used in accordance with the instructions may cause harmful interference to radio communications However there is no guarantee that interference will not occur in a particular installation If this equipment does cause harmful interference to radio or television reception which can be determined by turning the equipment off and on the user is encouraged to try to correct the interference by one or more of the following measures e Reorient or relocate the receiving antenna e Increase the separation between the equipment and receiver e Consult the dealer or an experienced radio TV technician for help Note Changes or modifications not expressly approved by the manufacturer responsible for compliance could void the user s authority to operate the equipment This device complies with Part 15 of the FCC Rules Operation is subject to the following two conditions 1 this device may not cause harmful interference and 2 this device must accept any interference received including interference that may cause undesired operation ICES 003 e This Class B digital apparatus complies with Canadian ICES 003 e Operation is subject to the following two conditions 1 this device may not cause harmful interference and 2 this device must accept
16. icant to protect them during shipment Wipe all metal parts with a paper towel to remove any excess lubricant F i 1 Handlebar Handle 2 Pieces Vehicle with Seat Gi Steering Column Clip Ip Steering Column Cap 12 Volt Battery Charger lt 12 Volt Battery Part not shown Label Sheet Tynan SAG 6 x 1 2 Screw 1 8 x 3 4 Screw 1 Screws are shown actual size Note Tighten and loosen all screws with a Phillips screwdriver Do not over tighten the screws M7873pr 0920 Vehicle Handlebar Seat 12 Volt Battery PARTS PICTURE J 12 Volt Battery Charger m Steering Column Cap r steering Column Clip t Handle 2 Pieces Parts Not Shown Label Sheet 6 x 2 Screw 1 8 x 3 4 Screw 1 M78 3pr 0920 BATTERY CHARGING ELECTRICAL HAZARD A WARNING e Battery can fall out and injure a child if vehicle tips over Always use battery retainer straps e PREVENT FIRE Never modify the electrical system Alterations could cause a fire resulting in serious injury and could also ruin the electrical system Use of the wrong type battery or charger could cause a fire or explosion resulting in serious injury Use of Power Wheels components in products other than Power Wheels vehicles could cause overheating fire or explosion e The battery must be handled by adults only The battery is heavy and contains sulfuric acid electrolyte Droppi
17. ice center for diagnosis and repair No action required If your charger does not get warm during use it does not mean that it is not working properly No action required If your battery does not make noise or swell slightly during charging it does not mean that it is not accepting the charge M78 3pr 0920 VEHICLE CARE e Check all screws and their protective coverings regularly and tighten as required Check plastic parts on a regular basis for cracks or broken pieces e During snowy or rainy weather the vehicle should be stored inside or under a protective cover Remember to charge the battery at least once per month while your vehicle is not in regular use e An extremely dirty vehicle can be rinsed with a hose but avoid spraying directly into switches motors and battery compartment Water or moisture in the motors or electrical switches can cause them to corrode and could cause switch or motor failure e Avoid operating the vehicle on sand Sand in the motors or electrical switches can cause them to jam and could cause switch or motor failure e The vehicle can be wiped down with a soft dry cloth For a shiny finish you can wipe plastic parts with a non wax furniture polish applied to a soft cloth Do not use automotive wax e To ensure that your vehicle stays in good operating order we recommend that you periodically have your vehicle checked by a Power Wheels authorized service center For the location of the
18. icle it is important to remember that their judgment skills are still very immature Unsupervised driving by children can lead to serious injury Before children use this vehicle an adult should carefully evaluate the driving area as well as the children s skill level and ability to drive this vehicle safely Children are not always able to recognize or anticipate hazards even when they have been taught about them There is no acceptable substitute for direct adult supervision Teach appropriate safety rules to your child before allowing operation of this vehicle These rules should also be reviewed with neighborhood children or other playmates who want to drive this vehicle Riding Rules Make sure children know and follow these rules for safe driving 1 Always sit on the seat 2 Always wear shoes 3 Only 1 one rider at a time A child who is not sitting on the seat or who is standing on the vehicle could fall off cause a tip over or block the driver s view A child could be seriously injured 4 Do not allow any child to drive the vehicle in the street or near moving motorized vehicles 5 Do not allow any child to drive near bodies of water Such as pools or creeks obstructions such as furniture low tree limbs or play equipment or drop offs such as stairs or decks 6 Do not allow any child to drive the vehicle in the dark A child could encounter unexpected obstacles and have an accident Operate the vehicle only in
19. ity for recycling advice and facilities Europe only e Return an exhausted battery to a federal or state approved lead acid battery recycler such as a Power Wheels authorized service center or a local seller of automotive batteries For the authorized service center location nearest to you please visit us on line at www powerwheels com or call 1 800 348 0751 Contact your local waste management officials for other information regarding the environmentally sound collection recycling and disposal of lead acid batteries If you live in the State of Florida or the State of Minnesota it is prohibited by law for anyone to throw away lead acid batteries in the municipal waste stream 12 M7873pr 0920 SAFE DRIVING RULES RIDING HAZARD A WARNING e Prevent Injuries and Deaths e Direct Adult Supervision Required e Never Ride at Night e Keep Children Within Safe Riding Areas These areas must be away from swimming pools and other bodies of water to prevent drownings generally level to prevent tipovers away from steps steep inclines cars roads and alleys Riding Rules Make sure children know and follow these rules for safe driving and riding Always sit on the seat Always wear shoes Only 1 one rider at a time Restrict your child s driving to areas that are generally level 13 ok aS Teach Safety Rules to Children While children can quickly develop the skill necessary to drive this veh
20. lan espanol para atender su llamada For your convenience Power Wheels maintains an independently owned and operated Authorized Service Center Network with more than 300 authorized service centers nationwide Our authorized service centers will repair or replace parts under warranty at no extra charge and can perform non warranty repairs for a minimal charge To find the authorized service center nearest you please visit us online at www powerwheels com or call 1 800 348 0751 e To register your vehicle please visit us on line at www powerwheels com M78 3pr 0920 ELECTRICAL HAZARD AN WARNING e Battery can fall out and injure a child if vehicle tips over Always use battery retainer straps e PREVENT FIRE Never modify the electrical system Alterations could cause a fire resulting in serious injury and could also ruin the electrical system Use of the wrong type battery or charger could cause a fire or explosion resulting in serious injury Use of Power Wheels components in products other than Power Wheels vehicles could cause overheating fire or explosion e The battery must be handled by adults only The battery is heavy and contains sulfuric acid electrolyte Dropping the battery could result in serious injury e Never allow children to charge the battery Battery charging must be done by adults only A child could be injured by the electricity involved in charging the battery e Read the safety instructions on the ba
21. ng the battery could result in serious injury e Never allow children to charge the battery Battery charging must be done by adults only A child could be injured by the elec tricity involved in charging the battery e Read the safety instructions on the battery e Examine the battery charger and their connectors for excessive wear or damage each time you charge the battery If damage or excessive wear is detected do not use the charger or the battery until you have replaced the worn or damaged part N CAUTION Use the charger in dry locations only About Thermal Fuses Your Power Wheels 12 volt battery is equipped with a built in thermal fuse The thermal fuse is a self resetting safety device which automatically trips and shuts down operation of the vehicle if the vehicle is overloaded or the driving conditions too severe Once a fuse has tripped remove your foot from the pedal and wait approximately 25 seconds before operating the vehicle again To avoid repeated automatic shut downs do not overload the vehicle by exceeding the 65 Ib 29 5 kg maximum weight capacity or by towing anything behind the vehicle Avoid severe driving conditions such as driving up slopes or running into fixed objects which can cause the wheels to stop spinning while power is still being supplied to the motors and make sure your child stops the vehicle before switching direction lf a thermal fuse in a battery continually trips under
22. nnector from the battery Replace the seat on the vehicle M78 3pr 0920 VEHICLE OPERATION As assembled your vehicle is ready to roll in low speed 21 2 mph maximum After your child has mastered the basic skills of driving and understands the rules for safe driving it s time to remove the high speed lock out screw to operate in high speed See the instructions in this section to remove the lock out screw and operate the vehicle at high speed Beginner Use Low Speed Drive Shifter e Make sure the shifter is in low speed position E e Press the foot pedal The vehicle goes forward at a maximum of 21 2 mph e Help your child practice steering to learn how far and how quickly to turn the handlebar when driving forward in low speed To Back Up IMPORTANT To prevent damaging the motors and gears teach your child to stop the vehicle before switching direction e Make sure the shifter is in reverse position Li e Press the foot pedal The vehicle backs up at a maximum of 21 2 mph e Help your child practice steering to learn how far and how quickly to turn the handlebar when driving in reverse STOP gt gt e Your vehicle has a patented electronic braking system that automatically stops the vehicle when your child s foot lifts from the pedal e Make sure your child is comfortable with steering the vehicle and automatically knows how to stop Advanced Use High Speed Drive e Remove the high s
23. ome batteries to make noise and swell slightly while charging and is not reason for concern 18 SOLUTION The vehicle was pre set to run only in low speed To allow the vehicle to run in low and high speed you must remove the high speed lock out screw from shifter Follow the instructions on page 14 It is possible that only one rear wheel may spin when both rear wheels are raised off the ground and the vehicle is in low speed This does not necessarily indicate a problem Check for proper operation of the drive system by raising the rear wheels off the ground and pressing the foot pedal If only one rear wheel spins carefully press your hand on the spinning wheel to slow it down The other rear wheel should begin to spin If the other rear wheel does not begin to spin there may be a problem with the vehicle Contact your local Power Wheels authorized service center for diagnosis and repair Check all wires around the motors and all connectors to make sure they are tight Contact your local Power Wheels authorized service center for diagnosis and repair Check all wires around the motors and all connectors to make sure they are tight Contact your local Power Wheels authorized service center for diagnosis and repair Contact your local Power Wheels authorized service center for diagnosis and repair Teach your child to stop the vehicle before switching direction Contact your local Power Wheels authorized serv
24. peed lock out screw from the shifter e Remove the seat on the vehicle Store the high speed lock out screw e Make sure the shifter is in high speed position FA e Press the foot pedal The vehicle moves forward at a maxiumum speed of 5 mph e Help your child practice steering to learn how far and how quickly to turn the handlebar when driving forward in high speed IMPORTANT Use the vehicle ONLY outdoors Most interior flooring can be damaged by riding the vehicle indoors Fisher Price will not be responsible for damage to floors if vehicle is used indoors M78 3pr 0920 COOL ATV TO AWESOME A T REX y e Press the sound button to hear A T Rex growl and roar e Pull the handle down to transform the ATV into an A T Rex Listen as the A T Rex growls and roars and watch his eyes light up Hint Pull the handle all the way down to keep the vehicle in A T Rex mode e Push the handle forward to transform back to an ATV 15 M78 3pr 0920 PROBLEMS AND SOLUTIONS IMPORTANT If you experience a problem with your vehicle first check the Problems and Solutions Guide below If you still experience a problem please contact Power Wheels Consumer Relations toll free at 1 800 348 0751 between 9 AM 7 PM EST Monday through Friday and 11 AM 5 PM EST Saturday Or contact your local Power Wheels authorized service center For the location nearest you please visit us on line at www powerwheels com or call 1 800 348 075
25. t capacity or by towing anything behind the vehicle Do not drive up hills or run into fixed objects which can cause the wheels to stop spinning while power is still being supplied to the motors If a thermal fuse continually trips contact your local Power Wheels authorized service center M78 3pr 0920 PROBLEM POSSIBLE CAUSE Short run time Less than 1 3 hours per charge Undercharged battery Overcharged battery Battery is old and will not accept full charge Tripped thermal fuse Vehicle runs sluggishly Undercharged battery Battery needs charging Battery is old and will not accept full charge Vehicle is overloaded Driving conditions are too stressful 17 SOLUTION Charge the battery A new battery should have been charged for at least 18 hours before using the vehicle for the first time After first time use recharge the battery for at least 14 hours after each use Never charge the battery longer than 30 hours Check all wires and connectors Make sure the charger connector is plugged into the battery and that the charger is plugged into the wall Make sure power flow to the wall outlet is ON Do not charge the battery longer than 30 hours If you suspect that your battery is damaged as a result of overcharging contact your local Power Wheels authorized service center They can test your battery for you Even with proper care a rechargeable battery does not last forever Average ba
26. the vehicle use and use conditions Replace the battery with a new Power Wheels 12 volt rechargable battery Do not substitute parts Make sure you do not overload the vehicle by allowing more than one rider at one time by exceeding the 65 Ibs 29 5 kg maximum weight capacity or by towing objects behind the vehicle Restrict your child s driving to areas that are generally level with gentle inclines or slopes M78 3pr 0920 PROBLEM Vehicle runs in low speed but does not run in high speed Please note The vehicle is designed to operate in low speed only in reverse When the foot pedal is pressed one rear wheel spins Sometimes the vehicle doesn t run but other times it does When the foot pedal is pressed the vehicle won t run without a push Battery s thermal fuse constantly trips but the vehicle is not overloaded nor the driving conditions too severe Loud clacking or grinding noise from a motor gearbox Charger gets warm during use Battery makes a sizzling or gurgling noise when charging POSSIBLE CAUSE High speed lock out screw not removed Operation of vehicle in low speed Loose wire or connector Motor or electrical switch damage Loose wire or connector Dead Spot on motor Damaged battery Child is switching between FORWARD and REVERSE without stopping Broken gears It is normal for some chargers to get warm during use and is not reason for concern It is normal for s
27. ttery e Examine the battery charger and their connectors for excessive wear or damage each time you Charge the battery If damage or excessive wear is detected do not use the charger or the battery until you have replaced the worn or damaged part e HOT motors Handle carefully RIDING HAZARD A WARNING e Prevent Injuries and Deaths e Direct Adult Supervision Required e Never Ride at Night e Keep Children Within Safe Riding Areas These areas must be away from swimming pools and other bodies of water to prevent drownings generally level to prevent tipovers away from steps steep inclines cars roads and alleys e Riding Rules Make sure children know and follow these rules for safe driving and riding Always sit on the seat Always wear shoes Only 1 one rider at a time A CAUTION e In the unassembled state this package contains small parts Adult assembly is required e Use the charger in dry locations only 3 M787 3pr 0920 PARTS e f you experience a problem with this product or are missing a part please call us at 1 800 348 0751 rather than return this product to the store e Please identify all parts before assembly and save all packaging material until assembly is complete to ensure that no parts are discarded e Some parts were placed under the seat for shipment Press the tab under the back of the seat and lift to access the battery compartment e Metal parts have been coated with a lubr
28. ttery life is 1 to 3 years depending on vehicle use and use conditions Replace the battery with a new Power Wheels 12 volt rechargeable battery Do not substitute parts The built in thermal fuse may trip and shut down operation of the vehicle if the vehicle is overloaded or the driving conditions too severe Once a fuse has tripped remove your foot from the pedal and wait approximately 25 seconds before operating the vehicle again To avoid repeated automatic shutdowns do not overload the vehicle by exceeding the 65 Ibs 29 5 kg maximum weight capacity or by towing anything behind the vehicle Do not drive up hills or run into fixed objects which can cause the wheels to stop spinning while power is still being supplied to the motors If a thermal fuse continually trips contact your local Power Wheels authorized service center Charge the battery A new battery should have been charged for at least 18 hours before using the vehicle for the first time After first time use recharge the battery for at least 14 hours after each use Never charge the battery longer than 30 hours Check all connectors Make sure the charger connector is plugged into the battery and that the charger is plugged into the wall Make sure power flow to the wall outlet is ON Be sure to charge the battery after each use Even with proper care a rechargeable battery does not last forever Average battery life is 1 to 3 years depending on
29. ult in the risk of fire electric shock or injury In the event of any damage do not use the charger until the damage has been properly repaired Please call 1 800 348 0751 e f your battery is old and will not accept a charge do not leave it in the vehicle Always remove a dead battery from the vehicle M78 3pr 0920 ASSEMBLY A WARNING Power Indicator Children can be harmed by small parts sharp edges and sharp points in the vehicle s unassembled state or by electrical items Care should be taken in unpacking and assembly of the vehicle Children should not handle parts including the battery or help in assembly of the vehicle i Battery Charger Connector e Plug the charger connector into the battery e Plug the charger into a standard wall outlet Notes Use the charger only in a wall outlet Do not plug the charger into a ceiling outlet If power flow to the wall outlet is controlled by a switch make sure the switch is ON The power indicator on the charger does not indicate the charge status of your battery The power indicator allows you to see that there is power from the wall outlet a e Before first time use charge the battery for at least 18 hours e Fit the handlebar steering column down through the large Never charge the battery longer than 30 hours opening in the front end of the vehicle e Recharge the battery for at least 14 hours after each use of your vehicle Do
Download Pdf Manuals
Related Search