Craftsman 40-Volt Owner's Manual
Contents
1. then seek immediate medical attention m Save these instructions Refer to them frequently m Donotcrush drop or damage battery pack Do and use them to instruct others who may use not use a battery pack or charger that has been this hedge trimmer If you loan someone this dropped or received a sharp blow A damaged hedge trimmer loan them these instructions battery is subject to explosion Properly dispose also of a dropped or damaged battery immediately m Donotdispose of batteries in a fire The cell mav explode Batteries should be recvcled Consult your local waste authority for information regarding available recvcling and or disposal options CALIFORNIA PROPOSITION 65 A WARNING This product and some dust created by power sanding sawing grinding drilling and other construction activities may contain chemicals including lead known to cause cancer birth defects or other reproductive harm Wash hands after handling Some examples of these chemicals are e lead from lead based paints e crystalline silica from bricks and cement and other masonry products and e arsenic and chromium from chemically treated lumber Your risk from these exposures varies depending on how often you do this type of work To reduce your exposure to these chemicals work in a well ventilated area and work with approved safety equipment such as those dust masks that are specially designed to filter out microscopic particles SAVE THESE INST2. pack Released electrolyte is corrosive and may cause damage to the eyes or skin It may be toxic if swallowed Batteries can explode in the presence of a source of ignition such as a pilot light To reduce the risk of serious personal injury never use any cordless product in the presence of open flame An exploded battery pack can propel debris and chemical If exposed flush with water immediately For use with Craftsman 40 V lithium ion battery packs 29111 2Ah and 29131 4Ah Refer to your battery owners manual for further information Do not charge unit in a damp or wet location Following this rule will reduce the risk of electric shock For best results your battery unit should be charged in a location where the temperature is more than 50 F 10 C but less than 100 F 38 C Do not store outside or in vehicles 4 English SPECIFIC SAFETV RULES m Under extreme usage or temperature conditions m When battery pack is not in use keep it away battery pack leakage may occur If liquid comes from other metal objects like paper clips coins in contact with your skin wash immediately with keys nails screws or other small metal objects soap and water then neutralize with lemon juice that can make a connection from one terminal or vinegar If liquid gets into your eyes flush to another Shorting the battery pack terminals them with clean water for at least 10 minutes together may cause sparks burns or a fire
3. the tool and in this operator s manual as well as a knowledge of the project you are attempting Before use of this product familiarize yourself with all operating features and safety rules ROTATING HANDLE GUARD The handle of your hedge trimmer rotates 90 degrees to The guard helps to deflect chips or other debris away the left or right for control and precision trimming from the operators hands ADJUSTABLE AUXILIARY HANDLE The adjustable auxiliary handle adjusts to 3 positions for better comfort and control ASSEMBLY UNPACKING 4 WARNING If anv parts are damaged or i i missing do not operate this product until the ds lalo parts are replaced Failure to heed this warning i could result in serious personal injury Carefully remove the product and any accessories i Jury from the box Make sure that all items listed in the WARNING Do not attempt to modify packing list are included this product or create accessories not recommended for use with this product Any m Inspect the product carefully to make sure no such alteration or modification is misuse and breakage or damage occurred during shipping could result in a hazardous condition leading to Do not discard the packing material until you have possible serious personal injury carefully inspected and satisfactorily operated the WARNING Do not connect to power product supply until assembly is complete Failure to m If any parts are damaged or missing please call comp
4. 5A 34101887 34981887 31103996 Batterv Pack 31101998 Batterv Charger See this section for all of the figures referenced in the operator s manual Consulte esta secci n para ver todas las figuras a las que se hace referencia en el manual del operador A Blades hojas B Scabbard funda C Guard protecci n D Adjustable auxiliary handle Mango auxiliar ajustable E Lock button for rotating handle Bot n de bloqueo para la manija giratoria F Lock out button bot n del seguro G Rear Handle with overmold mango trasero con sobremoldeado H Switch trigger gatillo Side lock button Bot n de bloqueo lateral Fig 2 _ Fig 3 A Battery pack paquete de baterias A Lock out button bot n del seguro B Battery port recept culo para bater as B Switch trigger gatillo del interruptor C Latches pestillos A Lock button for rotating handle Bot n de bloqueopara la manija giratoria A Side lock button Bot n de bloqueo lateral Fig 6 Fig 7 PROPER OPERATING POSITION or POSICI N CORRECTA PARA EL MANEJO DE LA HERRAMIENTA A Scabbard funda
5. AND PREPARATION FOR RECYCLING 4 WARNING Upon removal cover the batterv pack s terminals with heavv dutv adhesive tape Do not attempt to destrov or disassemble batterv pack or remove anv of its components Batteries must be recvcled or disposed of properly Also never touch both terminals with metal objects and or body parts as short circuit may result Keep away from children Failure to comply with these warnings could result in fire and or serious injury TRANSPORTING AND STORING m Always place the scabbard on the blade before storing or transporting the hedge trimmer Use caution to avoid the sharp teeth of the blade m Clean the hedge trimmer thoroughly before storing Store th hedge trimmer indoors in a dry lace that is inaccessible to children Keep away rom corrosive agents such as garden chemicals and de icing salts LUBRICATING THE BLADE See Figure 7 page ii WARNING Always allow the blades of the hedge trimmer to come to a stop and remove the battery pack before lubricating Failure to do so could result in accidental starting causing possible serious personal injury For easier operation and longer blade life lubricate the hedge trimmer blade before and after each use m Remove the battery pack from the hedge trimmer m Lay the hedge trimmer on a flat surface Apply light weight machine oil along the edge of the top blade NOTE If you will be using the hedge trimmer for an extended time it i
6. OPERATOR S MANUAL MANUEL DEL OPERADOR CRAFTSMAN 40V LITHIUM ION CORDLESS HEDGE TRIMMER CORTASETOS INALAMBRICO LITIO ION 40V Model No 138 99017 Numero de modelo 138 99017 A WARNING To reduce the risk of injury the user must read and understand the operator s manual before using this product AX ADVERTENCIA Para reducir el riesgo de lesiones el usuario debe leer y comprender el manual del operador antes de usar este producto Customer Help Line 1 888 266 7096 Tel fono de atenci n al consumidor 1 888 266 7096 Sears Brands Management Corporation Hoffman Estates IL 60179 USA Visit the Craftsman web page www craftsman com Visite el sitio web de Craftsman www craftsman com e Save this manual for future reference KB Guarde este manual para futuras consulta 218549 TABLE OF CONTENTS INDICE DE CONTENIDO ENGLISH ESPANOL n Warranty asia ima ira lassi 2 Garantia Inlges seccion 2 w Introduction ie ie nai 2 m Introducci n Inlges seccion 2 m General Safety Rules m Reglas de seguridad generales m Specific Safety Rules m Reglas de seguridad espec ficas m Symbols mi SIMDOIOS sistir aaea daai fu fada m Features m Caracter sticas Assembly m Armado Operation m Funcionamiento Maintenan e ss i ina e aa 11 n Mantenimiento s piau Illustrated parts list Figura numeras ilustracion
7. RUCTIONS 5 English The following signal words and meanings are intended to explain the levels of risk associated with this product SVMBOL SIGNAL MEANING f Indicates an imminentiv hazardous situation which if not avoided will result in death DANGER or serious injury n Indicates a potentially hazardous situation which if not avoided could result in death A WARNING or serious injury A Indicates a potentially hazardous situation which if not avoided may result in minor or A CAUTION moderate injury CAUTION Without Safety Alert Symbol Indicates a situation that may result in property damage Some of the following symbols may be used on this product Please study them and learn their meaning Proper interpretation of these symbols will allow you to operate the product better and safer SYMBOL NAME EXPLANATION A Safety Alert Symbol Indicates a potential personal injury hazard To reduce the risk of injury user must read and understand Read Operator s Manual y operator s manual before using this product Always wear eye protection with side shields marked to comply with ANSI Z87 1 ca Wet Conditions Alert Do not expose to rain or use in damp locations Eye Protection Failure to keep your hands away from the blade will result in serious personal injury Keep Bystanders Away Keep all bystanders at least 50 ft away Wear non slip heavy duty protective gloves when handling Gloves the blades Operate
8. With Two Hands Hold and operate the hedge trimmer properly with both hands Moving Parts Keep hands away from moving parts No Hands Symbol 6 English Some of the following symbols may be used on this product Please study them and learn their meaning Proper interpretation of these symbols will allow you to operate the product better and safer SYMBOL NAME EXPLANATION Failure to use in dry conditions and to observe safe practices Electric Shock can result in electric shock This product uses nickel cadmium Ni Cd and lithium ion Li ion batteries Local state or federal laws may prohibit disposal of batteries in ordinary trash Consult your local waste authority for information regarding available recycling and or disposal options Revolutions strokes surface speed orbits etc per minute 7 English FEATURES PRODUCT SPECIFICATIONS Motor iaia iaia Cutting SPEEd inn 1600 cuts min Blade Length Weight without battery pack 5 5 Ibs 2 5 Kg Cutting Capacity KNOW YOUR HEDGE TRIMMER TRIGGER SWITCH AND LOCK OFF BUTTON See Figure 1 page i The trigger switch located beneath the rear handle and the lock off button located behind the front handle must be depressed simultaneousiv to allow blade rotation Lock off switch may be released once hedge trimmer is running The safe use of this product requires an understanding of the information on
9. ade other conductive parts of the hedge trimmer or live electric cords or lines will result in death by electrocution or serious injury WARNING Clear the area to be cut before each use Remove all objects such as cords lights wire or loose string which can become entangled in the cutting blade and create a risk of serious personal injury Before starting the hedge trimmer hold the unit with both hands with the cutting blades directed away from you Always use the hedge trimmer properly Do not force the hedge trimmer through heavy shrubbery This can cause the blades to bind and slow down If the blades slow down reduce the pace Do not try to cut stems or twigs that are larger than 2 3 in thick or those obviously too large to feed into the cutting blade Use a non powered hand saw or pruning saw to trim large stems If blades do become jammed stop the motor allow the blades to stop and remove the battery pack before attempting to remove the obstruction If desired you can use a string to help cut your hedge level Decide how high you want the hedge Then stretch a piece of string along the hedge at this height Trim the hedge just above this guide line of string Trim the side of a hedge so that it will be slightly narrower at the top More of the hedge will be exposed when shaped this way and it will be more uniform Always hold hedge trimmer with both hands when operating Use a firm grip on the handles T
10. arked to comply with ANSI Z87 1 Protect your lungs Wear a face or dust mask if the operation is dusty Following this rule will reduce the risk of serious personal injury Dress Properly Do not wear loose clothing or jewelry Contain long hair Loose clothes jewelry or long hair can get caught in moving parts Wear heavy long pants long sleeves boots and gloves Do not wear loose fitting clothing short pants sandals or jewelry of any kind Do not go barefoot Secure long hair so it is above shoulder level to PA prevent entanglement in any moving parts Keep Children Away keep all bystanders children and pets at least 50 feet away Use Right Appliance do not use appliance for any job except that for which it is intended Don t Force Hedge Trimmer It will do the job better and less with likelihood of risk of injury at the rate for which it was designed Disconnect Hedge Trimmer remove battery from hedge trimmer when not in use before servicing when changing accessories such as blade and the like Do Not Overreach Keep proper footing and balance at all times Proper footing and balance enables better control of the hedge trimmer in unexpected situations Do not use on a ladder or unstable support Do not operate in poor lighting Keep hands face and feet at a safe distance from moving parts Do not touch or try to stop the cutting blades when they are moving Do not use hedge trimmer
11. cutting blades or cutting edges when picking up or holding the unit Blades coast after unit is turned off Always stop the motor when cutting is delayed or when walking from one cutting location to another Keep unit clean of grass clippings and other materials They may become lodged in the cutting blades Store Idle Hedge Trimmer Indoors When not in use product should be stored indoors in a dry locked up place out of the reach of n children Replace scabbard cover when unit is not in use LI Never douse or squirt the unit with water or anv other liquid Keep handles dry clean and free from debris Clean after each use see storage n instructions Secure the unit while transporting BATTERY SAFETY Battery operated units do not have to be plugged into an electrical outlet therefore they are always in operating condition Be aware of possible hazards even when unit is not operating Remove the battery pack before making any adjustments cleaning storing or removing material from the unit or when not in use A battery pack must be recharged only with the specified charger for the battery pack A charger that may be suitable for one type of battery pack may create a risk of fire when used with another battery pack Use battery pack only with charger listed To reduce the risk of explosion and possible injury DO NOT place battery units or their batteries near fire or heat Do not mutilate the battery
12. degrees to either side until it clicks into place and the button pops out To turn the handle back to center press the lock button again turn the handle slightly release the lock button and continue turning the handle until it locks into place USING THE ADJUSTABLE AUXILIARY HANDLE See Figure 5 page i Place the hedge trimmer on a flat and even surface and disconnect from the power supply Make sure that you released the triggers Press the side lock button on the handle and begin moving forward or backwards Release the lock button and continue moving the handle until it locks into place HOLDING THE HEDGE TRIMMER See Figures 6 pages ii The unit has both a front adjustable auxiliary handle and a rotating rear handle With the blade directed away from you hold the unit by both handles WARNING Always keep both hands on the hedge trimmer handles Never hold shrubs with one hand and operate hedge trimmer with the other Failure to heed this warning can result in serious injury CUTTING TIPS A DANGER Never cut near electric cords or lines If blade jams on any electrical cord or line DO NOT TOUCH THE BLADE IT CAN BECOME ELECTRICALLY LIVE AND VERY DANGEROUS Continue to hold the hedge trimmer by the insulated rear handle or lay it down and away from you in a safe manner Disconnect the electrical service to the damaged line or cord before attempting to free the blade from the line or cord Contact with the bl
13. e designed with features that protect the lithium ion cells and maximize batterv life Under some operating conditions these built in features mav cause the batterv and the tool it is powering to act differentiv from nickel cadmium batter ies During some applications the batterv electronics may signal the battery to shut down and cause the tool to stop running To reset the batterv and tool place the power switch in the OFF position then start the unit and resume nor mal operation If placing the power switch in the OFF position does not reset the batterv and tool the batterv pack is depleted If depleted the battery pack will begin charging when placed on the lithium ion charger STARTING AND STOPPING THE HEDGE TRIMMER See Figure 3 page i To start Remove the scabbard Press and hold the lock out button Depress the switch trigger Release the lock out button Continue to depress the switch trigger for extended operation 9 English OPERATION To stop Release the switch trigger to stop the hedge trimmer Upon release of the switch trigger the locked out button will automaticallv reset to the locked out position USING THE ROTATING REAR HANDLE See Figure 4 page i Place the hedge trimmer on a flat and even surface and disconnect from the power supply Make sure that vou released the triggers Press the lock button and begin turning the rear handle Release the lock button and turn the handle 90
14. ed products or anv strong solvents to clean vour hedge trimmer Following this rule will reduce the risk of loss of control and deterioration of the enclosure plastic To avoid the risk of electric shock do not operate unit in damp or wet locations Use only accessories that are recommended by the manufacturer for your model Accessories that may be suitable for one hedge trimmer may create a risk of injury when used on another hedge trimmer Hedge trimmer service must be performed only by qualified repair personnel Service or maintenance performed by unqualified personnel may result in a risk of injury When servicing a hedge trimmer use only identical replacement parts Follow instructions in the Maintenance section of this manual Use of unauthorized parts or failure to follow Maintenance instructions may create a risk of shock or injury SPECIFIC SAFETY RULES Before starting the hedge trimmer make sure the blade is not in contact with any object i Stop the unit remove the battery and make sure the blade has stopped before setting the unit down Never cut any material with a diameter larger n than 2 3 in DANGER Risk of cut Keep hands away from blades Do not attempt to remove cut material n or hold material to be cut when blades are moving Keep both hands on handles when power is on Make sure battery is removed and the trigger is released when clearing jammed material from blades Do not grasp the exposed
15. es iii Figure numbers illustrations CRAFTSMAN FOUR YEAR FULL WARRANTY FOR FOUR YEARS from the date of purchase this product is warranted against any defects in material or workmanship FOR TWO YEARS from the purchase date a supplied battery pack or charger is warranted against material or workmanship defects With proof of purchase a defective product will be replaced free of charge For warranty coverage details to obtain free replacement visit the web site www craftsman com This warranty is void if this product is ever used while providing commercial services or if rented to another person This warranty gives you specific legal rights and you may also have other rights which vary from state to state Sears Brands Management Corporation Hoffman Estates IL 60179 kk GARANTIA COMPLETA DE CUATRO ANOS CRAFTSMAN Esta soplador tiene garantia por cualquier defecto en material o mano de obra DURANTE CUATRO ANOS desde la fecha de compra Las baterias v el cargador tienen garantia por cualquier defecto durante dos afio desde la fecha de compra Los productos defectuosos se remplazar n sin cargo Para conocer los detalles sobre la cobertura de la garantia para obtener un remplazo gratuito visite el sitio web www craftsman com La garantia pierde validez si este producto se utiliza mientras se prestan servicios comerciales o si se alquila a otra persona Esta garantia le otorga derechos legales es
16. he unit is used for cutting in either direction in a slow sweeping action from side to side Wear gloves when trimming thorny or prickly growth When trimming new growth use a wide sweeping action so that the stems are fed directly into the cutting blade Older growth will have thicker stems and will be trimmed easiest by using a sawing movement 10 English MAINTENANCE 4 WARNING When servicing use only identical replacement parts Use of anv other parts mav create a hazard or cause product damage 4 WARNING Alwavs wear eve protection with side shields marked to complv with ANSI 287 1 Failure to do so could result in objects being thrown into vour eves resulting in possible serious injurv 4 WARNING To avoid serious personal injury always remove the battery pack from the product before inspecting cleaning or performing any maintenance GENERAL MAINTENANCE Avoid using solvents when cleaning plastic parts Most plastics are susceptible to damage from various types of commercial solvents and may be damaged by their use Use clean cloths to remove dirt dust oil grease etc 4 WARNING Do not at anv time let brake fluids gasoline petroleum based products penetrating oils etc come in contact with plastic parts Chemicals can damage weaken or destrov plastic which mav result in serious personal injurv Replacement parts should only be installed by quali fied repair personnel BATTERY PACK REMOVAL
17. if switch does not turn it on or off A hedge trimmer that cannot be controlled with the switch is dangerous and must be repaired Avoid Accidental Starting Be sure switch is in the locked or off position before plugging into power cord Carrying hedge trimmers with your finger on the switch or plugging the power cord into a hedge trimmer with the switch on invites accidents Avoid Dangerous Environments Do not use the hedge trimmer in damp or wet locations Do not operate the hedge trimmer in rain Maintain Hedge Trimmer with Care Follow instructions for lubrication and changing accessories keep handles dry clean and free from oil and grease Keep cutting blades sharp and clean Properly maintained hedge trimmers with sharp cutting edges are less likely to bind and are easier to control and reduce risk of injury Check for misalignment or binding of moving parts breakage of parts and any other condition that may affect the hedge trimmer s operation If damaged have the hedge trimmer serviced before using A guard or any other part that is damaged should be carefully checked to determine that it will operate properly and perform its intended function Many accidents are caused by poorly maintained hedge trimmers 3 English GENERAL SAFETV RULES Keep the hedge trimmer and its handle drv clean and free from oil and grease Alwavs use a clean cloth when cleaning Never use brake fluids gasoline petroleum bas
18. ly could result in accidental starting and 1 888 266 7096 for assistance possible serious personal injury PACKING LIST Hedge Trimmer Scabbard Operator s Manual 40v Battery 40v Charger 8 English OPERATION A WARNING Do not allow familiaritv with this product to make vou careless Remember that a careless fraction of a second is sufficient to inflict serious injurv MA WARNING Alwavs wear safetv goggles or safetv glasses with side shields that complv with ANSI Z87 1 when operating power tools Failure to do so could result in objects being thrown into vour eves resulting in possible serious injurv 4 WARNING Do not use anv attachments or accessories not recommended by the manufacturer of this product The use of attachments or accessories not recommended can result in serious personal injury Before each use inspect the entire product for dam aged missing or loose parts such as screws nuts bolts caps etc Tighten securely all fasteners and caps and do not operate this product until all missing or damaged parts are replaced by qualified repair personnel Call 1 888 266 7096 to obtain replace ment parts Part installation should only be performed by qualified repair personnel APPLICATIONS You may use this product for the purpose listed below m Trimming and shaping hedges and shrubbery IMPORTANT For complete charging instructions refer to the Operator s Manuals for the Craftsman 40 volt battery
19. pack and charger TO INSTALL REMOVE BATTERY PACK See Figure 2 page i WARNING Alwavs remove battery pack from the product when you are assembling parts making adjustments cleaning or when not in use Removing battery pack will prevent accidental starting that could cause serious personal injury To install m Place the power switch in the OFF position m Place the battery pack in the hedge trimmer Align raised rib on battery pack with groove in the hedge trimmer s battery port m Make sure the latch on the battery pack snaps in place and that the battery pack is secured in the hedge trimmer before beginning operation CAUTION when placing battery pack in the tool be sure raised rib on battery pack aligns with the bottom of the tool and latches into place properly Improper installation of the battery pack can cause damage to internal components To remove m Placethe power switch in the OFF position Locate the latch on the front of the battery pack and depress to release the battery pack from the hedge trimmer Remove battery pack from the hedge trimmer A WARNING Batterv tools are alwavs in operating condition Therefore switch should alwavs be locked with hands free of the lock out button when not in use Remove batterv pack when transporting or carrving hedge trimmer to avoid accidental starting which mav result in serious injurv BATTERV PROTECTION FEATURES Craftsman 40 V lithium ion batteries ar
20. pecificos y es posible que tambi n tenga derechos que varian segun el estado Sears Brands Management Corporation Hoffman Estates IL 60179 2 English INTRODUCTION INTRODUCCION This tool has many features for making its use more pleasant and enjoyable Safety performance and dependability have been given top priority in the design of this product making it easy to maintain and operate kkk Esta herramienta ofrece numerosas caracter sticas para hacer m s agradable y placentero su uso En el dise o de este producto se ha conferido prioridad a la seguridad el desempe o y la fiabilidad por lo cual se facilita su manejo y mantenimiento GENERAL SAFETY RULES A WARNING Read and understand all n instructions Failure to follow all instructions listed below may result in electric shock fire and or serious personal injury READ ALL INSTRUCTIONS Know your hedge trimmer Read and understand the operators manual and observe the warnings and instruction labels affixed to the hedge trimmer Stav alert watch what vou are doing and use common sense when operating a power hedge trimmer Do not use hedge trimmer while tired or under the influence of drugs alcohol n or medication Amoment of inattention while operating power hedge trimmers may result in serious personal injury Do not allow children or untrained individuals to n use this unit Use Safety Glasses always wear eye protection with side shields m
21. s advisable to oil the blade periodically Stop the hedge trimmer Remove the battery pack Lubricate the hedge trimmer as described above Reinstall the battery pack and resume use CLEANING THE HEDGE TRIMMER m Remove the battery pack m Slide the scabbard over the blade m Clean dirt and debris from the body of the hedge trimmer using a damp cloth with a mild detergent NOTE Do not use any strong detergents on the plastic housing or the handle They can be damaged by certain aromatic oils such as pine and lemon and by solvents such as kerosene m Moisture can cause a shock hazard Wipe off any moisture with a soft dry cloth m Use a small brush or the air discharge of a small vacuum cleaner brush to clear dust or debris from the air vents on the motor housing STORING THE HEDGE TRIMMER See Figure 8 page ii m Clean the hedge trimmer thoroughly before storing Store the hedge trimmer in a dry well ventilated place that is inaccessible to children Keep away from corrosive agents such as garden chemicals and de icing salts m Always place the scabbard on the cutting blades before storing 11 English CRAFTSMAN 40 V HEDGE TRIMER MODEL NUMBER 138 99017 The model number will be found on a label attached to the motor housing Alwavs mention the model number when calling to order replacement parts To order parts call 1 888 266 7096 PARTS LIST Kev Part No Number Description 34991887 322167
Download Pdf Manuals
Related Search