BENDIX TCH-010-005 User's Manual
Contents
1. Technical Bulletin Bulletin No PRO 10 05 Effective Date 1 1 89 Cancels N A Page 1 of 2 Subject Soeedometer Interface Module REFER TO REVERSE SIDE FOR SCHEMATICS lt has been determined that for current installations of a Bendix cruise control system on vehicles utilizing an electronic soeedometer the interface module is no longer required Kit 209898 which contained the interface module has been obsoleted and replaced by kit 209890 lf a vehicle that is utilizing an interface module develops a problem with the speed signal vehicle functions in stationary throttle mode but will not set in cruise mode and it has been determined the problem is not the speed sender or the stop light circuit and wiring continuity has been verified The following steps are recommended 1 Remove the interface module from the system 2 Cut off the two pin molded connector from the inhibit soeed wire harness Attach eyelet tyoe connector to the end of the green and gray wires 3 Connect the gray wire to a speed input terminal on the soeedometer head Connect the green wire to a good ground Note If after this procedure has been followed and it is determined that there is inadequate speed signal for both the speedometer and cruise control to function properly install a dual output sender such as Wabash 60 0131 into the transmission and run separate circuits to each unit WITH INTERFACE MODULE INSTALLED BACKSIDE OF SPEEDOMETER HEAD C2. A 1 CONTROL MODULE W SOLENOID INTERFACE ASSY _ MODULE ALTERNATE WIRING METHOD 3 PIN RING TERMINAL MOLDED CONNECTOR 2 PIN MOLDED CONNECTOR INHIBIT SPEEO WIRE HARNESS TO CLUTCH SWITCH FOR REMOVE EYELETS AND SPLICE MANUAL TRANSMISSION BLUE AND VIOLET WIRES WATERPROOF SPLICE FOR AUTOMATIC TRANSMISSION WITH INTERFACE MODULE REMOVED BACKSIDE OF SPEEDOMETER HEAD CONNECT GRAY WIRE TO SPEED INPUT TERMINAL MOLDED 3 PIN RING TERMINAL GREEN WIRE CONNECTOR L 2 INHIBIT SPEED 2 PIN MOLDED WIRE HARNESS CONNECTOR REMOVED TO CLUTCH SWITCH REMOVE EYELETS AND SPLICE MANUAL TRANSMISSION BLUE AND VIOLET WIRES WATERPROOF SPLICE FOR AUTOMATIC TRANSMISSION
Download Pdf Manuals
Related Search