American Standard 3636.STTS User's Manual
Contents
1. American Standard Style That Works Better Installation Instructions TOWN SQUARE ACRYLIC SHOWER BASE MODELS 3636 STTS 3838 NEOTS 4834 STTS Certified to comply with ANSI 2124 2 1987 Observe local plumbing and building codes Thank you for selecting American Standard the benchmark of fine quality for over 100 years To ensure this product is installed properly please read these instructions carefully before you begin Certain installations may require professional help Also be sure your installation conforms to local codes For alcove STTS models installation only The opening dimensions should be 1 8 larger than dimensions shown 752769 100 Rev C NOTE Read instructions completely before proceeding with installation 3838 NEOTS 3636 STTS a 484mm 19 1 16 4834 STTS 870mm 34 1 4 iem L 8 7 16 610mm 24 679mm 26 3 4 215mm 8 7 16 Y t y 484mm 215mm 19 1 16 8 7 16 E e 1219mm 48 215mm 48 8 7 16 I lt 972mm 38 1 4 DRAIN 3838 NEOTS ASSEMBLY 5 A ae Straine Before installing drain into a the shower base remove strainer see Fig C This will be installed after Insure the floor and stud walls Rubber are square and plumb Provide a 5 x 5 127mm x 127mm opening in the floor for the drain see Figs A amp B The drain plug accommodate2. Ecatepec 55540 Edo Mexico Toll Free 01 800 839 1200 www americanstandard com mx 752769 100 Rev C
3. is warranty does not cover any labor or other costs of removal or installation nor shall American Standard be responsible for any other incidental or consequential damages attributable to a product defect or to the repair or exchange of a defective product all of which are expressly excluded from this warranty Some states or provinces do not allow the exclusion or limitation of implied warranties so this exclusion may not apply to you This warranty gives you specific legal rights You may have other statutory rights that vary from state to state or from province to province in which case this warranty does not affect such statutory rights For service under this warranty it is suggested that a claim be made through the contractor or dealer from or through whom the product was purchased or that a service request including a description of the product model and of the defect be sent to the following address In the United States American Standard Brands P O Box 6820 Piscataway New Jersey 08855 Attention Director of Consumer Affairs For residents of the United States warranty information may also be obtained by calling the following toll free number 800 442 1902 www americanstandard com In Canada AS Canada ULC 5900 Avebury Rd Mississauga Ontario Canada L5R 3M3 Toll Free 800 387 0369 www americanstandard ca In Mexico American Standard B amp K Mexico S de R L de C Via Morelos 330 Col Santa Clara
4. ng detergents formulated for use on tile or porcelain enamel surfaces should be avoided Caution Do not allow liquid detergent containers to remain on base surfaces for more than a few moments Do not use Lestoil Windex Mr Clean Dow Disinfectant spray or concentrate or Lysol Basin Tub and Tile Cleaner Do not allow nail polish remover dry cleaning fluid acetone paint remover or other solvents to contact acrylic surface AS AMERICA INC AMERICAN STANDARD ONE YEAR LIMITED WARRANTY If inspection of this AS America Inc American Standard plumbing product within one year after its initial purchase confirms that it is defective in materials or workmanship American Standard will repair or at its option exchange the product for a similar model This warranty does not apply to local building code compliance Since local building codes vary considerably the purchaser of this product should check with a local building or plumbing contractor to insure local code compliance before installation This warranty shall be void if the product has been moved from its initial place of installation if it has been subjected to faulty maintenance abuse misuse accident or other damage if it was not installed in accordance with American Standard s instructions or if it has been modified in a manner inconsistent with the product as shipped by American Standard American Standard s option to repair or exchange the product under th
5. s a 2 51mm PVC waste pipe The waste pipe should extend above the surface of the sub floor 3 8 1 16 51 mm 2 PVC Waste Pipe 127mm x 127mm 5 x 5 Opening A See Product Chart for Drain Location shower base is in its final position Install the drain to the shower base as shown in Fig D Use silicone sealant between drain body and shower base Silicone Sealant Rubber Gasket ra Base Fiber Co Sy Gasket C Locking SSS Waterproof Drywall 13mm 1 2 minimum Note Variations in levelness of subfloor may require adjustment of waste pipe height See product drawings on this page for the specified drain locations 3636 STTS 4834 STTS 3 mm 1 8 No Bedding Under e Bedding Material Area 90 51 mm 2 C L 127mm x 127mm PVC Waste Pipe 5 x 5 Opening B See Product Chart for Drain Location 51 mm 2 PVC Pipe Bedding Material 51 x 102 mm 2 x 4 Stud Wall After leveling base on subfloor use base and mark studs This will be the installed height of shower base Mix the low shrink bedding material grout mortar plaster etc Concrete is not recommended Apply enough bedding material to support the entire bottom of the shower base The bedding material must not be used under the apron front edge 1 Lift and lower base over center E of drain pipe and set in
6. to place After the bedding material has been poured and before it sets lower the shower base into position with the drain assembly sliding over the waste pipe as shown in Fig E It will be necessary to rock the shower base until the top of the tile flange aligns with the lines drawn in Step 3 on the stud walls Make certain the apron is contacting the rough floor along the entire length of the shower base Insure that the base is level in two directions see Fig F Snap strainer back into place and check for proper drainage Level base in two directions F Note Allow the bedding material to completely harden before applying weight to the bottom of the shower base Tape over the strainer to protect the finish and prevent construction debris from entering the drain Finish installation as shown in Figure H Tile Waterproof Drywall Tile m T Adhesive FOR AFTER SALES SERVICE CALL 1 800 442 1902 WEEKDAYS AS America Inc 2010 CLEANING AND MAINTENANCE Your American Standard shower base is designed to last indefinitely with reasonable care and maintenance The high gloss acrylic surface is resistant to impact and retains its luster with proper care and maintenance An integral slip resistant surface is incorporated for user safety General Cleaning Do not use abrasive cleaners a mixture of warm water and a mild liquid detergent is adequate for most cleaning Stro
Download Pdf Manuals
Related Search