Premier LMVF, 37" - 63"
Contents
1. q a Small Straw Depth Plus 1 8 Allowance or Toothpick Visit the Premier Mounts website at http www premiermounts com Za Marking the 1 8 Allowance Marking the Depth Threaded Insert V Small Straw or Toothpick Small Straw Depth Plus 1 8 Allowance or Toothpick Mark Installation Instructions gt 4 LMVE 22 Installing the Mounting Brackets con d Attaching the Mounting Brackets to the Flat Panel This section presumes that you have read and understood thes Selecting the Proper Mounting Hardware section Place your flat panel screen side down on a soft flat surface Identify the number and location of the thread inserts on the back of your flat panel Aligning the holes on each mounting bracket with the thread inserts on the back of your flat panel Secure each mounting bracket to your flat panel by inserting a minimum of two 2 screws per bracket A Do not overtighten the mounting hardware Make sure the directional arrows on the mounting brackets are facing up Proceed to the Mounting the Flat Panel below Mounting the Flat Panel Attaching the Flat Panel to the Wall Plate A This section requires two people Do not release ae flat panel until you are certain that top and bottom hooks of both mounting brackets are securely seated on the upper and lower mounting rails of the wall panel Raise the flat panel past the top and bottom mounting rails on the w2. ATTACHMENTS OR MODIFICATIONS At least two qualified people should perform the assembly procedure Personal injury and or property damage can result from dropping or mishandling the flat panel If mounting to wall studs or ceiling studs make sure that the mounting screws are anchored into the center of the wall studs or ceiling studs Use of an edge to edge stud finder is recommended A It is recommended that a maximum of plaster board be used when mounting to wooden studs Be aware of the mounting environment If drilling and or cutting into the mounting surface always make sure that there are no electrical wires in wall Cutting or drilling into an electrical line may cause serious personal injury Make sure there are no water or natural gas lines inside the wall where the mount is to be located Cutting or drilling into a water or gas line may cause severe property damage or personal injury This product is intended for indoor use only Use of this product outdoors could lead to product failure and or serious personal injury Do not install near sources of high heat Do not install on a structure that is prone to vibration movement or chance of impact Contact Premier Mounts with any questions 800 368 9700 techsupport mounts com Page 2 Visit the Premier Mounts website at http www premiermounts com Installation Instructions Electronic Stud Finder Protective Eyewear 2 Drill Bit g gt a Socket Wrench 2 Socket P
3. 13 Ce LMVF TOP VIEW SIDE VIEW REAR VIEW FRONT VIEW Page 14 Visit the Premier Mounts website at http www premiermounts com Installation Instructions 7 G PREMIER MOUNTS LIMITED LIFETIME WARRANTY What and Who is Covered by this Limited Warranty and for How Long Premier Mounts warrants this product to be free from defects in material and workmanship for the lifetime of the original owner of this product The limited warranty is valid only for the original purchaser of the product What Premier Mounts Will Do At the sole option of Premier Mounts Premier Mounts will repair or replace any product or product part that is defective If Premier Mounts chooses to replace a defective product or part a replacement product or part will be shipped to you at no charge but you must pay any labor costs What is Not Covered Limitations PREMIER MOUNTS DISCLAIMS ANY LIABILITY FOR DAMAGE TO MOUNTS ADAPTERS DISPLAYS PROJECTORS OTHER PROPERTY OR PERSONAL INJURY RESULTING IN WHOLE OR IN PART FROM IMPROPER INSTALLATION MODIFICATION USE OR MISUSE OF ITS PRODUCTS PREMIER MOUNTS DISCLAIMS ALL OTHER WARRANTIES EXPRESS OR IMPLIED INCLUDING WARRANTIES OF MERCHANTABILITY AND FI
4. LMVF Video Wall Flat Panel Framing System INSTALLATION INSTRUCTIONS cD PREMIER Cag MOUNTS CREATING POSITIVE CUSTOMER EXPERIENCES 9589 000 001 00 Weight Limiteen er tere cece enter on eer era errren rarer cere r rr E E rrr rep E 2 WalMInG StAlSMOMtS ea AN S peau sebeptaeazece tenes 2 metalation Too b cesesssceeteensvedeseciscascteenyescncuaenvandadsecdscasdadtayyaceieneevicaniageyseashigen sqaseanenveaseiaeevSenoiadeeteneeuneneved cadteevasanddcens 3 PANS ISU sastcneta vanced duapadectactp suas es vauinct ta tauieacec tana dees audaws ete esainesehe tpn ceediaslnnetenceacutnceettga nah tad uu ceeagtaameetee acl nates aatene 3 FAUNO Soari n T la updos vaughn Corduedndee ax T advtbede Naaaeects dadueteadeniaes 5 Installing the Wall Plate Srne aan ies ietaaedcs baceaves waite E S sacle aauavediandiae 6 OGUORI O O S 6 Installing the Mounting Brackets eieroneen o nnn EAA 8 Selecting the Mounting Hardware ossoa ra r edits ada avuaniy yamine Rivers 8 Attaching the Mounting Brackets to the Flat Panel 0 cccceeteeeeeeeeeneee eee eenneeeeeeenieeeeseeiaeeeeeeeneeeeeeeeaas 9 Mounting the Flat iP ame secs cusisceistinbsseasssntattedeseieddyedstaclagel a iuadieai eas dnidiened alates end nantes 9 Attaching the Flat Panel to the Wall Plate cccececcceeceseeccceeeeeeeceeeenenseeeeensnseeeeeenaneeeeeensaaseeeeeseaaaeeteneaaes 9 Locking Safety screw stallati cs rn sete cou iets be en aud O 10 Post Installation AdjuStMe nt eonn
5. TNESS FORA PARTICULAR PURPOSE PREMIER MOUNTS IS NOT RESPONSIBLE FOR INCIDENTAL OR CONSEQUENTIAL DAMAGES INCLUDING BUT NOT LIMITED TO INABILITY TO USE ITS PRODUCTS OR LABOR COSTS FOR REMOVING AND REPLACING DEFECTIVE PRODUCTS OR PARTS SOME STATES DO NOT ALLOW THE EXCLUSION OR LIMITATION OF INCIDENTAL OR CONSEQUENTIAL DAMAGES SO THE ABOVE LIMITATION OR EXCLUSION MAY NOT APPLY TO YOU What Customers Must Do for Limited Warranty Service If you discover a problem that you think may be covered by the warranty you MUST REPORT it in writing to the address below within thirty 30 days Proof of purchase an original sales receipt from the original consumer purchaser must accompany all warranty claims Warranty claims must also include a description of the problem the purchaser s name address and telephone number General inquiries can be addressed to Premier Mounts Customer Service at 1 800 368 9700 Warranty claims will not be accepted over the phone or by fax Premier Mounts Attn Warranty Claim 3130 East Miraloma Ave Anaheim CA 92806 How State Law Applies THIS WARRANTY GIVES YOU SPECIFIC LEGAL RIGHTS AND YOU MAY ALSO HAVE OTHER RIGHTS WHICH VARY FROM STATE TO STATE Premier Mounts intends to make this manual accurate and complete However Premier Mounts makes no claim that the information contained herein covers all details conditions or variations nor does it provide for every possible contingency in connection with the installation
6. a a ccceteeadcnd E A a 10 Maintenance and SeVGi ocssssiniak annaa aA R O O 13 Technical Specifications wevscccesacevses seacans scasceanacnsasagaasasaawncasecedacadharses EE aE aA E 14 Wan anty aseainena a e a ae aa base aA e dawns a aa E ANE 15 Weight Limit THE WALL STRUCTURE MUST BE CAPABLE OF SUPPORTING AT LEAST FIVE TIMES THE WEIGHT OF Drap FIA PAREI Weight 22 5 bs THE FLAT PANEL IF NOT THE WALL STRUCTURE MUST BE REINFORCED Warning Statements PRIOR TO THE INSTALLATION OF THIS PRODUCT THE INSTALLATION INSTRUCTIONS MUST BE READ AND COMPLETELY UNDERSTOOD KEEP THESE INSTALLATION INSTRUCTIONS IN AN EASILY ACCESSIBLE LOCATION FOR FUTURE REFERENCE PROPER INSTALLATION PROCEDURE BY A QUALIFIED SERVICE TECHNICIAN MUST BE FOLLOWED AS OUTLINED STOP IN THESE INSTALLATION INSTRUCTIONS FAILURE TO DO SO COULD RESULT IN PROPERTY DAMAGE SERIOUS PERSONAL INJURY OR EVEN DEATH SAFETY MEASURES MUST BE PRACTICED AT ALL TIMES DURING THE ASSEMBLY OF THIS PRODUCT USE STOP PROPER SAFETY EQUIPMENT AND TOOLS FOR THE ASSEMBLY PROCEDURE TO PREVENT PERSONAL INJURY PREMIER MOUNTS DOES NOT WARRANT AGAINST DAMAGE CAUSED BY THE USE OF ANY PREMIER MOUNTS PRODUCT FOR PURPOSES OTHER THAN THOSE FOR WHICH IT WAS DESIGNED OR DAMAGE CAUSED BY UNAUTHORIZED ATTACHMENTS OR MODIFICATIONS AND IS NOT RESPONSIBLE FOR ANY DAMAGES CLAIMS DEMANDS SUITS ACTIONS OR CAUSES OF ACTION OF WHATEVER KIND RESULTING FROM ARISING OUT OF OR INANY MANNER RELATING TO ANY SUCH USE
7. all panel Slide the flat panel down slowly keeping it close to the wall Engage the top and bottom mounting brackets to the rails of the wall plate Installation Instructions Visit the Premier Mounts website at http www premiermounts com Page 9 The locking safety screws keep the flat panel from being accidently dislodged from the LMVF Locate the pre installed M6 x 30mm locking safety screw at the bottom of one of the mounting brackets Use a Phillips head screwdriver to tighten the locking safety screw Repeat steps 1 and 2 for the other locking safety screw A Do not overtighten the locking safety screws Proceed to the Post Installation Adjustments below Post Installation Adjustments The LMVF has a set of post installation adjustments on each mounting bracket Figure 1 Use your fingers to adjust the fine tune controls independently Below are some examples Make sure the the locking safety screws are loosened before making adjustments Figure 1 Page 10 Visit the Premier Mounts website at http www premiermounts com LMVF Pre installed M6 x 30mm Locking Safety Screw 1 per Bracket Installation Instructions Post Installation Adjustments cont d Tilt Left 0 Left Control Right Control Tilt Right 4 2 Left Control Right Control Tilt Up Na AN TILT Left Control Right Cont
8. at http www premiermounts com Installation Instructions LMVF 22 Features The LMVF Video Wall Flat Panel Framing System is a customizable video wall mounting system featuring multi monitor stacking open design and custom spacers Once the first frame is level all other frames integrate and instantly level to each other for faster installation Spacers are custom designed for specific flat panels Post Installation Adjustments Patent pending leveling tilt and in out adjustment knobs make it easier than ever to flush and level the flat panels for a seamless video wall Cable Electrical Cut Out Allows for easy cable access and power distribution installations Fits Most Flat Panels The mount is designed to fit most flat panels sized 40 and up Locking Safety Screws Prevent the flat panel from being removed or dislodged from the wall plate Use an optional Lock It security barrel for added protection Kickstand Prop up the flat panel with the kickstand for easy maintenance Installation Instructions Visit the Premier Mounts website at http www premiermounts com Page 5 b a Ca LMVF Installing the Wall Plate You must secure the wall plate to two 2 wall studs with six 6 lag bolts 3 lag bolts for each stud found Use a stud finder to determine the exact center of wall studs in the vicinity of the wall plate Use a pencil to mark the exact center of each of the wall studs Two people are reco
9. her into each pilot hole 2 Tighten all lag bolts using a socket wrench and 7 socket Do not overtighten the lag bolts when attaching the mount to the wall Improper installation may result in personal injury or property damage Proceed to the Installing the Mounting Bracket on page 8 Installation Instructions Visit the Premier Mounts website at http www premiermounts com Page 7 Page 8 b a ee LMVF Installing the Mounting Brackets Selecting the Mounting Hardware Insert a small straw or toothpick into the threaded inserts found on the back of the flat panel Use a pencil to mark the depth of the threaded insert on the small straw or toothpick Mark the straw or toothpick 1 8 above the depth of the threaded insert as shown in Figure 1 Insert the small straw or toothpick into the remaining threaded inserts to compare and verify their depth using the straw or toothpick s 1 8 allowance mark Locate the correct diameter screw for the threaded insert If the screw you selected is longer than the 1 8 allowance mark on the small straw or toothpick as shown in Figure 2 and Figure 3 do not use this screw The screw length must not bypass the mark 6 Test each size of the screws provided The correct screws should thread easily into the mounting point and not pull out when tension is applied Go to Griplate Washer Installation on page 9 Figure 2 E Screw 4 X
10. hillips Head Screwdriver Parts List Your Premier Mounts product is shipped with all proper installation hardware and components If there are parts missing and or damaged please stop the installation and contact Premier Mounts at 800 368 9700 LMV Video Wall Mount Assembly Components Wall Plate A Mounting Bracket Qty 1 i Qty 2 he x 3 Lag Bolt 546 Flat Washer Wooden Studs Only Qty 6 Qty 6 Thread Depth Indicator Supplied Installation Instructions Visit the Premier Mounts website at http www premiermounts com Page 3 b a A LMVF Parts List con d Mounting Hardware M4 x 16mm Screw Qty 6 M6 x 30mm Screw Qty 6 M4 x 25mm Screw Qty 6 M6 x 45mm Screw Qty 6 M4 x 30mm Screw Qty 6 M8 x 16mm Screw Qty 6 M5 x 16mm Screw Qty 6 com ca u 0 a comme M8 x 25mm Screw Qty 6 w CE C M5 x 25mm Screw Qty 6 M8 x 30mm Screw Qty 6 e Ca M5 x 30mm Screw Qty 6 a M8 x 45mm Screw M6 x 16mm Screw Qty 6 Qty 6 M6 x 25mm Screw M8 x 70mm Screw Qty 6 Qty 4 Page 4 Visit the Premier Mounts website
11. mmended for this step one person to level the wall plate and another person to mark the wall stud location Place the wall plate against the wall in the desired viewing location Adjust the wall plate to align the mount slots in the wall plate with the center of the wall studs Level the wall plate Use a pencil to mark the upper right mounting location along the center of the wall stud Drill a pilot hole in the center of the upper right mark using a 4 drill bit and power drill A Only use a 7 drill bit when drilling pilot holes Page 6 Visit the Premier Mounts website at http www premiermounts com Installation Instructions gt 4 LMVF D2 Installing the Wall Plate contd Place the wall plate against the wall and align it with the pilot hole Insert one 1 5 4 x 3 lag bolt and one 1 6 washer into the upper right pilot hole Use a socket wrench and a 2 socket to tighten the lag bolt A Do not overtighten the lag bolt 1 Level the wall plate 2 Use a pencil to mark the remaining five 5 mounting locations along the center of each wall stud Two people are recommended for this step one person to level the wall plate and another person to drill the pilot holes Drill a pilot hole in the center of each of the marks with a power drill and a drill bit A Only use 74 drill bit when drilling the pilot holes 1 Insert one 1 4 x 3 lag bolt and one 1 6 was
12. or use of this product The information contained in this document is subject to change without notice or obligation of any kind Premier Mounts makes no representation of warranty expressed or implied regarding the information contained herein Premier Mounts assumes no responsibility for accuracy completeness or sufficiency of the information contained in this document Contact Us NORTH AMERICA EUROPE 3130 East Miraloma Avenue Unit 3 The Moorings Business Park aa iat USA Channel Way Longford and Canada USA and Canada Coventry CV6 6RH UK Enone 1 PO ee Phone 44 0 24 7664 4105 Fax 1 800 832 4888 Other Locations Phone 001 714 632 7100 Fax 001 714 632 1044 Fax 44 0 24 7664 4165 Premier Mounts 2011 Patalafon Instructions Visit the Premier Mounts website at http www premiermounts com Installation InsfPacteonsS
13. rol Tilt Down from tilted up position fo fo TILT TILT Left Control Right Control Installation Instructions Visit the Premier Mounts website at http www premiermounts com Page 11 A LMVF Post Installation Adjustments cont d Level Up RO R Left Control Right Control monne eo Doe Level Down from leveled up position ls la Left Control Right Control moe Se SS Seo Rotate Left SAS Left Control Right Control E SA moe Se Ss Se Seco Rotate Right P Left Control Right Control Creed monne eo Dome Page 12 Visit the Premier Mounts website at http www premiermounts com Installation Instructions d LMVF Ca Maintenance and Servicing Loosen the locking safety screws on the mounting brackets Lift and tilt up the bottom of the mounting brackets then set their kickstands against the bottom tubing of the mount Figures 1 amp 2 You can now reach behind the flat panel for maintenance and servicing lt n Figure 1 Figure 2 Installation Instructions Visit the Premier Mounts website at http www premiermounts com Page
Download Pdf Manuals
Related Search