Rust-Oleum Automotive 263377 Use and Care Manual
Contents
1. 0061 www rustoleum com An RPM Company2. 514 TECHNICAL DATA GD ROLL BAR amp CHASSIS PAINT PHYSICAL PROPERTIES ROLL BAR amp CHASSIS PAINT Resin Type Epoxy Ester Modified Alkyd Pigment Type Carbon Black Solvents Acetone Butyl acetate Xylene MIR 1 40 Max Fill Weight 11 ounces Recommended Dry Film 2 0 mils Thickness DFT Per Coat 50u Practical Coverage at Recommended DFT 10 15 sq ft can 0 90 1 40 m can Touch 2 4 hours Dry Times at 70 80 F 21 27 C and 50 Handle 5 9 hours Relative Humidity Recoat Within 1 2 hour or after 1 week Fully Dry 24 hours Dry Heat Resistance 250 F 121 C Shelf Life 5 years Flash Point 156 F 104 C Safety Information For additional information see MSDS The technical data and suggestions for use contained herein are correct to the best of our knowledge and offered in good faith The statements of this literature do not constitute a warranty express or implied as to the performance of these products As conditions and use of our materials are beyond our control we can guarantee these products only to conform to our standards of quality and our liability if any will be limited to replacement of defective materials All technical information is subject to change without notice ma RUSTOLEUM BRANDS Rust Oleum Corporation Form GDH 409 11 Hawthorn Parkway Phone 877 385 8155 Rev 080514 Vernon Hills Illinois 6
3. AN CAUSE SERIOUS ILLNESS SUCH AS BRAIN DAMAGE ESPECIALLY IN CHILDREN PREGNANT WOMEN SHOULD ALSO AVOID EXPOSURE Wear a NIOSH approved respirator to control lead exposure Clean up carefully with a HEPA vacuum and a wet mop Before you start find out how to protect yourself and your family by contacting the National Lead Information Hotline at 1 800 424 LEAD or log on to www eps gov lead APPLICATION Shake can vigorously for one minute after the mixing ball begins to rattle If mixing ball fails to rattle DO NOT STRIKE CAN Contact Rust Oleum Shake often during use Hold can 10 14 from surface and spray in a steady back and forth motion slightly overlapping each stroke Keep the can the same distance from the surface and in motion while spraying Apply 2 or more light coats a few minutes apart Do not use near open flame DRY amp RECOAT Dry and recoat times are based on 70 F 21 C and 50 relative humidity Allow more time at cooler temperatures Dries to the touch in 2 4 hours to handle in 5 9 hours and is fully dry in 24 hours May recoat within 1 2 hour or after 1 week CLEAN UP Wipe off tip when finished Clean up wet paint with xylene or mineral spirits Properly discard empty container Do not burn or place in home trash compactor CLOGGING If the valve clogs twist and pull off spray tip and rinse ina solvent such as mineral spirits Do not insert any object into can valve opening Form GDH 409 Rev 080
4. po TECHNICAL DATA AT O 92 ROLL BAR amp CHASSIS PAINT DESCRIPTION AND USES PRODUCT APPLICATION cont Rust Oleum Roll Bar amp Chassis Paint is a one step epoxy coating that does not require a primer It gives the appearance of a tough baked on porcelain like finish that provides excellent corrosion resistance It is suitable for use on roll bars grill guards frames suspension trailers and equipment Rust Oleum Roll bar amp Chassis Paint features an advanced spray system that allows you to spray at any angle even upside down for those hard to reach areas A comfort spray tip with wider finger pad reduces fatigue caused by continuous spraying PRODUCTS SKU 11 ounce spray Description 263377 Gloss Black 275231 Satin Black PRODUCT APPLICATION PAINTING CONDITIONS Use outdoors or in a well ventilated area such as an open garage Use when temperature is between 50 90 F 10 32 C and humidity is below 65 to ensure proper drying Do not use on galvanized metal Avoid spraying in very windy and dusty conditions Cover surrounding area to protect from spray mist SURFACE PREPARATION Wash the surface with a commercial detergent or other suitable cleaning method Rinse with fresh water and let dry Remove loose paint and rust with a wire brush or sandpaper Lightly sand glossy surfaces WARNING If you scrape sand or remove old paint you may release lead dust LEAD IS TOXIC EXPOSURE TO LEAD DUST C
Download Pdf Manuals
Related Search