Electrolux ER6633I User's Manual
Contents
1. Push the appliance into the housing until the stop strip A touches the kitchen unit If after having carried out the operation described in section 2 there is still some space left between the appliance and the kitchen unit fit the trimming provided together with the appliance on the stop strip A Open the door and push the appliance against the side of kitchen furniture opposite to that of appliance hinges Fasten the appliance with 4 screws provided in the kit included with the appliance Snap vent grille C and hinge cover D into position Door Reversal The appliance s door has been locked in position for transport by means of pins on both sides According to the door opening direction remove relevant pins at the top and at the bottom 50 min cm 200 Press in the joint covers between the appliance and the kitchen furniture Apply covers B on joint cover lugs and hinge holes Position the runners H at the top and bottom of the inside of the kitchen unit as shown in the figure and mark the position of the external holes After preparing the holes screw the runners to the kitchen unit door using 3 5x16 mm screws Open both the appliance door and that of the kitchen unit to approx 90 Place the little plates over the runners Hold the doors of the appliance and the unit together and mark the holes Remove the little plates and drill the holes 2 mm in diameter Replace the little plates ove2. and then pull it outward by pressing as shown in the figure Unscrew the bulb and replace it with a new 15 watt bulb available from your nearest Electrolux Service Centre Replace the light cover by sliding it into its original position and replacing the screw When the appliance is not in use When the appliance is not in use for long periods disconnect from the electricity supply empty all foods and clean the appliance leaving the door ajar to prevent unpleasant smells SOMETHING NOT WORKING Before contacting your local Service Force Centre check the following points No power to appliance Check there is power at the socket Check there is not a power cut by checking the household lights Check the fuse has not blown The light does not come on Ensure that the bulb is correctly fitted Replace the bulb if it has blown Check the door light switch is not jammed The temperature in the fridge is too high Check the ambient temperature is within the appliances operating limits of 10 C to 32 C Check the thermostat is turned to the correct setting relative to ambient conditions The compressor runs continuously Adjust the thermostat control knob to give correct temperature control See page 5 Check that the door is closed Large quantities of food have recently been placed in the cabinet and or door is frequently opened Check that air ventilation is not obstructed Excessive frost and ice
3. IN F O INSTRUCTION BOOKLET REFRIGERATOR ER 6633 2222747 46 CONTENTS Instructions for the User Important Safety Instructions Description of the Appliance Operation Before use Setting the temperature Fresh food refrigeration The door shelves oi oi oi o O1 A C Health and safety guidelines Defrosting Normal Operating Sounds Maintenance and Cleaning Internal cleaning Changing the light bulb When the appliance is not in use oe oo 0 00 ss N O Something not Working 9 Service and Spare Parts 10 Customer Care Department 10 Guarantee Conditions 11 Instructions for the Installer Technical Specifications 14 Installation 14 Positioning 14 Electrical Connection 15 Building in 16 Instructions for building in the appliance 16 Door Reversal 16 A IMPORTANT SAFETY INSTRUCTIONS These warnings are provided in the interests of your safety Ensure that you understand them all before installing or using this appliance Your safety is of paramount importance If you are unsure about any of the meanings of these warnings contact the Customer Care Departement Prior to Installation Check the appliance for transport damage Under no circumstance should a damaged appliance be installed In the event of damage please contact your retailer Installation This appliance is heavy Care should be taken when moving it It is dangerous to alter the specifications or attempt to modify this product in any way En
4. ON AYCLIFFE Unit 16 M45 SHEFFIELD M38 BIRKENHEAD M11 CARLISLE M10 ISLE OF MAN M64 LIVERPOOL M15 MANCHESTER M09 PRESTON M13 STOCKPORT M16 Gurney Way Aycliffe Industrial Estate Newton Aycliffe DL5 6UJ Pennine House Roman Ridge Ind Roman Ridge Road Sheffield S9 1GB NORTH WEST 1 Kelvin Park Dock Road Birkenhead L41 1LT Unit 7 James Street Workshops James Street Carlisle Cumbria CA25AH South Quay Ind Estate Douglas Isle of Man IM1 5AT Unit 1 Honeys Green Precinct Honeys Green Lane Liverpool L12 9JH Unit B Central Industrial Estate St Marks Street Bolton BL3 6NR Unit 250 Dawson Place Walton Summit Bamber Bridge Preston Lancashire PR58AL Unit 20 Haigh Park Haigh Avenue Stockport SK4 1QR ATA Electrolux Service Force BSERVICESFORCE 1 To contact your local Electrolux Service Centre telephone 08705 929 929 BIRMINGHAM M18 BOURNE M44 BRIDGNORTH M72 GLOUCESTER M23 HEREFORD M31 HIGHAM FERRERS M51 ILKESTON M43 LEICESTER M22 LINCOLN M40 NEWCASTLE UNDER LYME M12 REDDITCH M20 TAMWORTH M19 WORCESTER M73 MIDLANDS 66 Birch Road East Wyrley Road Ind Estate Witton Birmingham B6 6DB Manning Road Ind Estate Pinfold Road Bourne PE10 9HT 68 St Mary s Street Bridgnorth Shropshire WV16 4DR 101 Rycroft Street Gloucester GL1 4NB Unit 3 Bank Buil
5. ays switch off the appliance and disconnect from the electrical supply When unplugging always pull the plug from the mains socket do not pull on the cable Servicing This product should be serviced by an authorised engineer and only genuine spare parts should be used Under no circumstances should you attempt to repair the appliance yourself Repairs carried out by inexperienced persons may cause injury or serious malfunctioning Contact your local Service Force Centre At the end of the Appliance Life When disposing of your appliance use an authorised disposal site Remove the plug and ensure that any locks or catches are removed to prevent young children being trapped inside i DESCRIPTION OF THE APPLIANCE D Dairy compartment 2 Can storage shelf 3 Bottle storage shelf Salad bin 5 Glass shelf for storing fresh meat 6 Storage shelves Thermostat control i OPERATION Before use Remove all securing tapes Wash inside the appliance with lukewarm water and bicarbonate of soda b ml to 0 5 litre of water Do not use soap or detergent as the smell may linger Dry thoroughly Setting the temperature The temperature inside the refrigerator is regulated by a thermostat with 6 temperature positions and one OFF O position Position 1 2 minimum coldness Position 6 maximum coldness Turn the thermostat dial to the required position the intermediate position is usually t
6. cleaned and placed in the bottom salad drawer Butter amp cheese these should be placed in special airtight containers or wrapped in aluminium foil or polythene bags to exclude as much air as possible Milk bottles these should have a cap and should be stored in the bottle rack on the door The walls of the refrigerator are equipped with runners so that shelves can be positioned as desired The door shelves To permit storage of food packages of various sizes the central door shelf can be adjusted in height To do this proceed as figure For more thorough cleaning the top door shelf and the bottle shelf can be removed by pulling them in the directon of the arrows then refitting them in position i HEALTH AND SAFETY GUIDELINES Because of consumer demand preservatives have been removed from many pre prepared foods This together with the changes in shopping habits to a once a week shop mean that safe handling and storage of food is even more important than ever The following tips should help you to ensure that the food in your home is in as perfect condition as possible W Keep the time between buying chilled food and placing it in your fridge as short as possible Tests showed that the temperature of 1 litre of orange juice rose to 22 C in an hour between the supermarket and home It then took 11 hours to get down to 7 C in the refrigerator W Keep the refrigerator door closed as much a
7. dings Cattle market Hareford HE4 9HX 30 High Street Higham Ferrers Northants NN10 8BB Unit 2 Furnace Road lkeston DE7 5EP Unit 7 Oaks Ind Estate Coventry Road Narborough Leicestershire LEO 5GF Unit 8 Stonefield Park Clifton Street Lincoln LN5 8AA 18 21 Croft Road Brampton Ind Estate Newcastle under Lyme Staffordshire ST5 OTW 13 Thornhill Road North Moons Moat Redditch Worcestershire B98 9ND Unit 3 Sterling Park Claymore Tamworth B77 5DO Units 1 amp 2 Northbrook Close Gregorys Mill Ind Estate Worcester WR3 8BP LONDON amp EAST ANGLIA BECKENHAM M79 CHELMSFORD M47 COLINDALE M53 ELTHAM M78 ENFIELD M49 GRAVESEND M57 HARPENDEN M46 LETCHWORTH M50 MAIDENHEAD M60 MOLESEY M61 NEWBURY M24 IPSWICH M48 NORWICH M52 11a Gardener Ind Estate Kent House Lane Beckenham Kent BR3 1QZ Hanbury Road Widford Ind Estate Chelmsford Essex CM12 3AE Unit 14 Capitol Park Capitol Way Colindale London NW9 0EQ 194 Court Road Mottingham Eltham London SE9 4EW 284 Alma Road Enfield London EN3 7BB Unit B4 Imperial Business Estate Gravesend Kent DA11 ODL Unit 4 Riverside Estate Coldharbour Lane Harpenden AL5 4UN 16 17 Woodside Ind Estate Works Road Letchworth Herts SG6 1LA 2 4 Royal Lane Yiewsley West Drayton Middlesex UB7 8DL Reform Road Maidenhead Berkshire SL6 8BY 10 Island Far
8. haped drip collector at the back of the refrigerator compartment behind the fruit and salad drawers Use the special cleaner provided which you will find already inserted into the discharge hole Normal operating sounds You may hear faint gurgling or bubbling sounds when the refrigerant is pumped through the coils or tubing at the rear and the cooling evaporator When the compressor is on the refrigerant is being pumped round and you will hear a whirring sound or pulsating noise from the compressor A thermostat controls the compressor and you will hear a faint click when the thermostat cuts in and out MAINTENANCE AND CLEANING Before any maintenance or cleaning work is carried out DISCONNECT the appliance from the ELECTRICITY supply Internal cleaning Clean the inside and accessories with warm water and bicarbonate of soda 5ml to 0 5 litre of water Rinse and dry thoroughly NEVER USE DETERGENTS ABRASIVE POWDERS HIGHLY PERFUMED CLEANING PRODUCTS OR WAX POLISHES TO CLEAN THE INTERIOR AS THESE WILL DAMAGE THE SURFACE AND LEAVE A STRONG SMELL Clean the drain hole of the water trough at regular intervals and make sure that the drain hole is never obstructed so that the defrost water may flow freely Changing the light bulb Should the interior light fail to work first switch off the appliance and disconnect from the electricity supply then replace the bulb as follows unscrew the light cover
9. has built up Ensure the door is not left open Check that nothing is preventing the door from closing Is the door gasket intact and clean Noise Refer to normal operating sounds Water under the salad bin Check the drain hole is not blocked see Maintenance and Cleaning If after the above checks there is still a fault call your local Service Force Centre In guarantee customers should ensure that the above checks have been made as the engineer will make a charge if the fault is not a mechanical or electrical breakdown Please note that proof of purchase is required for any in guarantee service calls SERVICE AND SPARE PARTS In the event of your appliance requiring service or if you wish to purchase spare parts please contact your local Electrolux Service Force Centre by telephoning 08705 929929 Your telephone call will be automatically routed to the Service Centre covering your post code area The addresses are listed on the following pages Before calling out an engineer please ensure you have read the details under the heading Something Not Working and have the model number and purchase date to hand Please note that it will be necessary to provide proof of purchase for any in guarantee service calls In guarantee customers should ensure that the checks under the heading Something Not Working have been made as the engineer will make a charge if the fault is not a mechanical or electrica
10. he most suitable 3 4 The thermostat setting can vary as the temperature inside the refrigeration compartment depends on the following factors room temperature how often the door is opened how much food is stored position of the appliance Important If the fridge is not defrosting correctly it is possible that because a very low temperature has been selected the motor is working continuously which prevents the defrost cycle from operating To ensure correct defrosting a lower number should be selected on the thermostat and you should notice that the motor cuts out from time to time which is correct If you wish to return to a lower temperature turn the thermostat to a higher number however you should turn the setting lower occasionally to allow automatic defrosting Fresh food refrigeration To obtain the best performance do not store warm food or evaporating liquids in the refrigerator do cover or wrap the food particularly if it has a strong flavour Do not cover the shelves with any protective material such as paper cardboard or plastic which may obstruct the air circulation through them To help you use your refrigerator correctly here are some more useful hints Raw meat beef pork lamb amp poultry wrap in polythene bags and place on top of the salad drawer Meat can only be stored safely in this way for one or two days at the most Fruit amp vegetables these should be thoroughly
11. l breakdown CUSTOMER CARE DEPARTMENT For general enquiries concerning your Electrolux appliance or for further information on Electrolux products please contact our Customer Care Department by letter or telephone as follows Customer Care Department Electrolux 55 77 High Street Slough Berkshire SL1 1DZ Tel 08705 950 950 calls to this number may be recorded for training purposes GUARANTEE CONDITIONS Standard guarantee conditions We Electrolux undertake that if within 12 months of the date of purchase this Electrolux appliance or any part thereof is proved to be defective by reason only of faulty workmanship or materials we will at our option repair or replace the same FREE OF CHARGE for labour materials or carriage on condition that m The appliance has been correctly installed and used only on the electricity supply stated on the rating plate m The appliance has been used for normal domestic purposes only and in accordance with the manufactuer s instructions m The appliance has not been serviced maintained repaired taken apart or tampered with by any person not authoried by us m All service work under this guarantee must be undertaken by an Electrolux Service Force Centre m Any appliance or defective part replaced shall become the Company s property m This guarantee is in addition to your statutory and other legal rights Home visits are made between 8 30am and 5 30pm Monday to Friday Visits ma
12. m Avenue West Molesey Surrey KT8 2UZ 9 Pipers Court Berkshire Drive Thatcham Berkshire RG19 4ER Unit 6C Elton Park Business Centre Hadleigh Road Ipswich IP2 ODD 2b Trafalgar Street Norwich NR1 3HN 13 SUNBURY Unit 1a M63 The Summit Hanworth Road Hanworth Ind Estate Sunbury on Thames LUV16 Li SOUTH EAST ASHFORD Unit 2 M58 Bridge Road Business Est Bridge Road Ashford Kent TN2 1BB FLEET Unit 1 M59 Redsfield Ind Estate Church Crookham Fleet Hampshire GU13 ORD HAYWARDS 21 25 Bridge Road HEATH Haywards Heath M55 Sussex RH16 1UA SOUTH WEST BARNSTAPLE Main Road M30 Fremington Barnstaple North Devon EX31 2NT BOURNEMOUTH 63 65 Curzon Road M26 Bournemouth Dorset BH1 4PW BRIDGEWATER M35 BRISTOL M25 EMSWORTH M33 ISLE OF WIGHT M34 NEWTON ABBOT M29 REDRUTH M36 6 Hamp Ind Estate Bridgewater Somerset TA6 3NT 11 Eldon Way Eldonwall Trading Bristo Avon BS43QQ 266 Main Road Southbourne Emsworth PO10 8JL Unit 8 Enterprise Court Ryde Business Park Ryde Isle of Wight PO33 1DB Unit 2 Zealley Ind Estate Kingsteignton Newton Abbot S Devon TQ12 3TD Unit 7D Pool Ind Estate Wilson Way Redruth Cornwall TR15 3QW G TECHNICAL SPECIFICATIONS POWER SUPPLY VOLTAGE AND FREQUENCY 220 240 V 50 Hz TOTAL POWER ABSORBED 110 W AVERAGE DAILY UNITS ELECTRICITY 0 62 kWh GROSS CAPACITY 158 NET CAPACITY 1541 This figure is based on
13. r new home They will then ensure that the local Service Organisation is aware of your move and able to look after you and your appliance France Senlis 33 0 44 62 22 22 Germany Nurenberg 49 0 911 323 2600 Italy Pordenone 39 0 1678 47053 Sweden Stockholm 46 0 20 78 77 50 UK Slough 44 0 1753 219898 11 Electrolux Service Force TRS To contact your local Electrolux Service Centre telephone 08705 929 929 CHANNEL ISLANDS GUERNSEY JERSEY Guernsey Electricity PO Box 4 Vale Guernsey Channel Islands Jersey Electricity Company PO Box 45 Queens Road St Helier Jersey Channel Islands JE4 8NY SCOTLAND ABERDEEN M05 AUCHTERMUCHY M03 BLANTYRE M07 DUMFRIES M01 DUNOON M67 GLASGOW M04 INVERNESS M06 ISLE OF ARRAN OWN SALES ISLE OF BARRA OWN SALES ISLES OF BUTE ISLE OF LEWIS KELSO M08 54 Claremont Street Aberdeen AB10 6RA 33a Burnside Auchtermuchy Fife KY147AJ Unit 5 Block 2 Auchenraith Ind Estate Rosendale Way Blantyre G72 0NJ 93 Irish Street Dumfries Scotland DG12PQ Brair Hill 7 Hill Street Dunoon Argyli PA23 7AL 20 Cunningham Road Clyde Estate Rutherglen Glasgow G73 1PP Unit 3B Smithton Ind Estate Smithton Inverness IV1 AJ Arran Domestics Unit 4 The Douglas Centre Brodick Isle of Arran KA27 8AJ J Zerfah 244 Bruernish Isle of Barra Western Islands HS9 5QY Walker Engineering Glenmhor Upper Serpen
14. r the runners and screw in the screws provided 3 5x16 mm For the alignement of the kitchen unit door if necessary use the clearance size of the slotted holes At the end of the procedure check that the doors of the appliance and the kitchen unit open properly Electrolux Household Appliances Limited 2000
15. red green and yellow Connect the blue neutral wire to the terminal in the plug which is marked with the letter N or coloured black Connect the brown live wire to the terminal in the plug which is marked with the letter L or colured red The plug moulded onto the lead incorporates a fuse For replacement use a 13amp BS1362 fuse Only ASTA or BSI approved fuses should be used The plug must not be used if the fuse cover carrier is lost The cover carrier is indicated by the coloured insert at the base of the plug A replacement cover carrier must be obtained from your local Electrolux Service Force Centre This appliance complies with the E E C Directive No 87 308 of 2 6 87 relative to radio interference suppression C This appliance complies with the following E E C Directive 73 23 EEC of 19 2 73 Low Voltage Directive and subsequent amendments 89 336 EEC of 3 5 89 Electromagnetic Compatibility Directive and subsequent amend ments Please ensure that when the appliance is installed it is easily accessible for the engineer in the event of breakdown GREEN amp YELLOW 9 o O 13 AMP FUSE 13 AMP BROWN BLUE Penn CORD CLAMP G BUILDING IN Instructions for building in the appliance Dimensions of the recess Height of housing 880 mm Depth of housing 550 mm Width of housing 560 mm For appropriate venting follow indications in the figure
16. s possible W Do not push food together too much try to allow air to circulate around each item W Cool cooked food as quickly as possible but do NOT place in the refrigerator until cool Leave food in a cool place in order that it can then be placed in the refrigerator as soon as possible W Do NOT mix raw and cooked meat they must be in separate containers Take care not to let the meat juices drip onto other food If the meat does drip remove everything and clean thoroughly W Do not store food uncovered m Remove suspect food from your refrigerator and clean the interior see Maintenance and Cleaning Never allow spillages to dry and harden Store eggs in the egg rack provided in the refrigerator door Discard any broken or chipped eggs Regularly check the refrigerator door seal to ensure that it is clean and free from debris Always wash your hands with soapy water and dry them with a clean towel before handling food Keep work surfaces clean and avoid cross contamination by not using the same work surface or knife without washing them thoroughly in between DEFROSTING The refrigerator automatically defrosts every time the compressor stops The water is discharged via the pipe into a tray located at the back of the appliance above the compressor where it evaporates Important A avoid defrost water overflowing into the fridge periodically clean the water discharge hole in the centre of the V s
17. standard test results in accordance with European Standard EN153 Actual consumption will depend on how the appliance is used and where it is located INSTALLATION Positioning The appliance should be installed well away from sources of heat such as radiators boilers direct sunlight etc best performance is obtained with ambient temperature between 10 C and 32 C For building in and reversing the door if necessary refer to the relevant instructions in the following pages ELECTRICAL CONNECTION WARNING THIS APPLIANCE MUST BE EARTHED The manufacturer declines any liability should this safety measure not be observed If the plug that is fitted to your appliance is not suitable for your socket outlet it must be cut off and the appropriate plug fitted Remove the fuse from the cut off plug The cut off plug should then be disposed of to prevent the hazard of shocks in case it should be plugged into a 13amp socket in another part of your home Important The wires in the mains lead are coloured in accordance with the following code Green and Yellow Earth Blue Neutral Brown Live If you fit your own plug the colours of the wires in the mains lead of your appliance may not correspond with the markings identifying the terminals in your plug proceed as follows Connect the Green and the Yellow earth wire to the terminal in the plug which is marked with the letter E or the earth symbol or colo
18. sure that the appliance does not stand on the electrical supply cable Any electrical work required to install this appliance should be carried out by a qualified electrician or competent person Parts which heat up should not be exposed Whenever possible the back of the appliance should be close to a wall but leaving the required distance for ventilation as stated in the installation instructions The appliance should be left for 2 hours after installation before it is turned on in order to allow the refrigerant to settle Refrigerant During transportation and installation of the appliance be certain that none of the components of the refrigerant circuit become damaged If the refrigerant circuit should become damaged avoid open flames and sources of ignition thoroughly ventilate the room in which the appliance is situated Child Safety Do not allow children to tamper with the controls or play with the product There is a risk of suffocation Keep packaging material away from children During Use This appliance is designed for domestic use only specifically for the storage of edible foodstuffs It is not intended for commercial or industrial use Containers with flammable gases or liquids can leak at low temperatures Do not store any containers with flammable materials such as spray cans fire extinguisher refill cartridges etc in the refrigerator Maintenance and Cleaning Before cleaning alw
19. tine Road Rothesay Isle of Bute PA20 9EH ND Macleod 16 James Street Stornoway Isle of Lewis PA87 2QW 2 8 Wood Market Kelso Borders TD57AX ORKNEY Corsie Domestics M65 7 King Street Kirkwall Orkney KW15 Hydro Electrical Inveralmond House Ruthervenfield Road Perth PH13AQ PERTH Graham Begg Unit 4 Airport Ind Estate OWN SALES Wick KW1 4QS SHETLAND Tait Electronic Systems Ltd Holmsgarth Road Lerwick OWN SALES Shetland ZE10PW SHETLAND Bolts Shetland Ltd 26 North Road Lerwick OWN SALES Shetland ZE10PE WHALSAY Leask Electrical Harisdale Symbister Whalsay OWN SALES Shetland ZE2 9AA NORTHERN IRELAND BELFAST Owenmore House M27 Kilwee Business Park Upper Dunmury Lane Belfast BT17 0HD WALES CARDIFF Guardian Industrial Estate M28 Clydesmuir Road Tremorfa Cardiff CF2 2QS Unit 6 7 Coed Parc Abergele Road Rhuddlan Clwyd Wales LL18 5UG Maes Y Coed High Mead Llanybydder Carmarthenshire SA40 9UL HAVERFORDWEST Cromlech Lodge M75 Ambleston Haverfordwest Pembrokeshire SA62 5DS OSWESTRY Plas Ffynnon M17 Warehouse Middleton Road Oswestry SY11 2PP 12 GATESHEAD M39 GRIMSBY M42 HULL M41 LEEDS M37 NORTH EAST Unit 356a Dukesway Court Dukesway Team Valley Gateshead NE11 0BH 15 Hainton Avenue Grimsby South Humberside DN32 9AS Unit 1 Boulevard Industrial Estate Hull HU3 4AY 64 66 Cross Gates Road Leeds LS15 7NN NEWT
20. y be available outside these hours in which case a premium will be charged Exclusions This guarantee does not cover m Damage or calls resulting from transportation improper use or neglect the replacement of any light bulbs or removable parts of glass or plastic m Costs incurred for calls to put right an appliance which is improperly installed or calls to appliances outside the United Kingdom m Appliances found to be in use within a commercial environment plus those which are subject to rental agreements m Products of Electrolux manufacture which are not marketed by Electrolux European Guarantee If you should move to another country within Europe then your guarantee moves with you to your new home subject to the following qualifications m The guarantee starts from the date you first purchased your product m The guarantee is for the same period and to the same extent for labour and parts as exists in the new country of use for this brand or range of products m This guarantee relates to you and cannot be transferred to another user m Your new home is within European Community EC or European Free Trade Area m The product is installed and used in accordance with our instructions and is only used domestically i e a normal household m The product is installed taking into account regulations in your new country Before you move please contact your nearest Customer Care centre listed below to give them details of you
Download Pdf Manuals
Related Search